Beruflich Dokumente
Kultur Dokumente
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 60
Subaru 1600 1982-1983
FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Subaru 1600 1982-1983
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
NOTES: ** See Note #204 - Adding Actutor Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 60
Subaru 1800 1982-1983
FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2:
gnition #3:
Accessory:
Brake Light: GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Subaru 1800 1982-1983
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARN. OR DOME LGHT
NOTES: ** See Note #204 - Adding Actutor Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 60
Make: Model: Year:
Subaru 1800 Turbo 1983-1984
FUNCTON COLOR LOCATON
Start: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #1: BLACK GNTON SWTCH HARNESS
gnition #2: BLUE GNTON SWTCH HARNESS
gnition #3:
Accessory:
Brake Light: GREEN (-) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: YELLOW AT COL OR AT DASH TACHOMETER
Parking Lights: RED (+) AT LGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Subaru 1800 Turbo 1983-1984
FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
OEM Horn:
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release:
Alarm nput Wire: BLACK/RED (-) NSTR. PANEL HARNESS OR DOME LGHT
NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 60
B9 TRIBECA 2006
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
SUBARU'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS and
EXTRA GNTON KEY
FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+)
@ GNTON SWTCH
HARNESS
STARTER WHTE/BLACK (+)
@ GNTON SWTCH
HARNESS
STARTER 2 N/A
GNTON 1 GREEN (+)
@ GNTON SWTCH
HARNESS
GNTON 2 BLUE (+)
@ GNTON SWTCH
HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+)
@ GNTON SWTCH
HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLACK/WHTE (-)
@ COMBNATON LGHT
SWTCH
PARKNG LGHTS ( + )
WHTE/GREEN (+) or ORANGE
(+)
@ PARKNG LGHT SWTCH
POWER LOCK BROWN/WHTE (TYPE B)
N DRVERS KCK PANEL or
BU, 35-Pin Plug, Pin 15, See
NOTE *1
POWER UNLOCK BROWN/BLACK (TYPE B)
N DRVERS KCK PANEL or
BU, 35-Pin Plug, Pin 29, See
NOTE *1
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 60
EXTRA NFORMATON
NOTE *1 this vehicle uses a CENTRAL DOOR LOCKNG SYSTEM, when connecting a KEYLESS
ENTRY, you will need to add a Door Lock Actuator part #742 in the Drivers Door Only!!, some units
will also require (2) extra relays, part #775, to complete the installation, to connect, NOTE *2 the
ECM (Electronic Control Module) is located BEHND the PASSENGER Side of the DASH, the tach
wire is RED at PN 64.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 60
SVX 1992
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT Connect to BATTERY
STARTER BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK or WHTE (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/BLUE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED/WHTE (+) or RED (+)
@ STEERNG COLUMN
HARNESS
POWER LOCK
BLUE/BROWN or ORANGE
(TYPE B)
N DRVERS KCK PANEL
POWER UNLOCK
ORANGE or BLUE/ORANGE
(TYPE B)
N DRVERS KCK PANEL
DOOR TRGGER
WHTE/RED (+) or BLACK/RED
(-)
@ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 60
HORN N/A
TACH YELLOW or YELLOW/WHTE @ GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/RED (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 60
SVX 1993
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT BLACK/YELLOW (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
RED/YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) RED (+) @ HEADLGHT SWTCH
POWER LOCK ORANGE (TYPE B) BEHND GLOVEBOX
POWER UNLOCK BLUE/ORANGE (TYPE B) BEHND GLOVEBOX
DOOR TRGGER GREEN/BLACK (-) @ UNDERDASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN N/A
TACH YELLOW/WHTE @ GNTON COL
WAT TO START LGHT N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Subaru - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 60