Beruflich Dokumente
Kultur Dokumente
A student is often faced with the task of evaluating one of the six common trigonometric functions for some common multiple of pi, , , , , or . A student who has completed precalculus with trigonometry should be able to 6 4 3 2 produce an exact evaluation of the trigonometric function for these angles without resorting to the use of a calculator. This document provides a simple methodology for producing such evaluations. usually integer multiples of
The table on the next page represents our goal the student should be able to readily reconstruct this somewhat intimidating table. A blank table is provided on the following page so the student has a template for practice. The remainder of this document walks the student through the elementary steps that allow him to reconstruct the values of the six trigonometric for the common angle values of the first four quadrants.
TrigTable
2005 September 26
0
sin cos tan cot sec csc
2 3
3 4
5 6
0 1
7 6
5 4
4 3
3 2
5 3
7 4
11 6
1 2
2 2 2 2
3 2
1 2 3
3 2
1 2
2 2 2 2
1 2
1 2
2 2 2 2
3 2
1 2 3
3 2
1 2
2 2 2 2
1 2
3 2 3 3
3
3 2 3 3
3
3 2 3 3
3
3 2 3 3
3
Udf
1 1
2
Udf
1 1
Udf
3 3
3 3
Udf
1
2 2
3 3
3 3
Udf
2 3 3
Udf
2 3 3
2 3 3
Udf
2 3 3
Udf
2 3 3
2 3 3
Udf
2 3 3
2 3 3
Udf
TrigTable
2005 September 26
sin
cos
tan
cot
sec
csc
Use copies of this page to practice learning the values of the trigonometric functions.
TrigTable
2005 September 26
We first notice that the tangent, cotangent, secant, and cosecant functions are derived from the sine and cosine functions. Therefore, if we learn the first two table rows, we will be able to reconstruct the remaining four rows. We have cut our work by nearly 1/3! (I use the word nearly because there is some arithmetic involved in calculating the remaining values.) We next notice that the cosine function takes the same values as the sine function, but the values are shifted with respect to the angle . If we learn that pattern, it suffices to learn just the first row of the table. Next, we observe that the sine function repeats its values from quadrant to quadrant, with the occasional change of sign. Since all four quadrants are represented, it suffices to remember the values of the sine function for only the first quadrant. Therefore, if we can remember the sine function for 5 values of along with some rules for populating the remainder of the table, we have all 144 table values! There is one more bit of work I neglected to mention it is necessary to remember the common values of the angle parameter . However, patterns once again come to our rescue; it is necessary to learn only approximately 10 different numbers.
. That is, 0 +
and
. What about
TrigTable
2005 September 26
0
sin sin
1 2
2 2 2 2
3 2 3 2
0 2
1 2
4 2
Note that the values in the second row for the sine function have the same value as the corresponding value in the first row. Therefore, if one can begin at 0 and count whole numbers to the value 4, one has everything required to reproduce values of the sine function for the common first quadrant angle values.
TrigTable
2005 September 26
Values of the Cosine for the Common Angles in the First Quadrant
We may use the identity cos = sin and the symmetry of the first quadrant common angles about to develop the table to 2 4 include values of the cosine function for the first quadrant common angles. Using the symmetry of the first quadrant common angles about
, we see that the cosine values repeat the sine values, but in decreasing order.
0
sin cos
6 1 2
2 2 2 2
3 2
1 2
3 2
TrigTable
2005 September 26
Values of the Tangent for the Common Angles in the First Quadrant
The tangent function is defined as the ratio of the sine and cosine functions. This makes extending the table to include the values for the tangent function in the first quadrant relatively simple:
0
sin cos tan
1 2
2 2 2 2
3 2
1 2 3
3 2 3 3
Udf
It may be instructive to review the arithmetic required for rationalization of the denominator. The arithmetic for tan
1 1 2 1 1 3 3 tan = 2 = = = = 6 3 3 3 3 3 2 3 2
is developed:
tan
= 3 tan
and tan
= 3 tan
, and
TrigTable
2005 September 26
2 3
3 4
5 6
7 6
5 4
4 3
3 2
5 3
7 4
11 6
Quadrant Boundaries
3 , and 2 . Note that the sequence of denominators, 6, 4, and 3, repeats within each 2 2 quadrant, but the pattern reverses descending to ascending to descending - at each quadrant boundary. Thus, the student should be able to partially reconstruct the first line of the table as follows: The quadrant boundaries appear at 0, , ,
3 4 6 6 4 3
3 2
2 3 4 6
Second Quadrant
We previously noted the coefficient of pi in the numerator was 1 for the first quadrant common angles. There are similar patterns for each of the three remaining quadrants. The coefficient of pi in the numerator of the second quadrant common angles is always one less than the value of the denominator. 3 2 we have 2 = 3 1. For we have 3 = 4 1, etc. It is a simple matter to complete the second quadrant common That is, for 3 4 angle values.
2 3
3 4
5 6
6 4 3
3 2
2 3 4 6
TrigTable
2005 September 26
Third Quadrant
The coefficient of pi in the third quadrant is always one more than the value of the denominator. That is, for is a simple matter to complete the third quadrant common angle values. 7 we have 7 = 6 + 1. It 6
2 3
3 4
5 6
7 6
5 4
4 3
3 2
2 3 4 6
Fourth Quadrant
Finally, the coefficient of pi in the fourth quadrant is one less than twice the value of the denominator. That is, for
7 = 2 4 1 . This allows us to easily complete the sequence of common angle values.
7 we have 4 7 4 11 6
2 3
3 4
5 6
7 6
5 4
4 3
3 2
5 3
TrigTable
2005 September 26
Values of the Sine, Cosine, and Tangent Functions for All Four Quadrants
The values of the sine, cosine and tangent functions are readily extended to the remaining three quadrants by keeping track of the sign of each function in the respective quadrants. There is a simple mnemonic device for remembering which of the three functions is positive in each of the four quadrants: ASTC (or All Students Take Calculus). Each of the four letters represents one quadrant, A for I, S for II, T for III, and C for IV. The A mean All all three functions are positive in the first quadrant. S represents the sine function only the sine function is positive in Quadrant II. T represents the tangent function only the tangent function is positive in Quadrant III. Finally, C represents the cosine function only the cosine function is positive in Quadrant IV.
0
sin cos tan
2 3
3 4
5 6
0 1
7 6
5 4
4 3
3 2
5 3
7 4
11 6
1 2
2 2 2 2
3 2
1 2 3
3 2
1 2
2 2
2 2
1 2
1 2
2 2 2 2
3 2
1 2 3
3 2
1 2 3
2 2
1 2
3 2 3 3
3 2 3 3
3 2
2 2
3 2
3 3
Udf
3 3
Udf
What happens if one should not remember a value of one of these functions for a common angle value beyond the first quadrant? We may use practice of determination of sign (ASTC) and reference angle to mentally calculate sine, cosine and tangent values for quadrants II, III, and IV as the following examples illustrate. Example 1: Calculate sin
7 7 3 7 . Since < < , we know that lies in the third quadrant. Using the ASTC mnemonic, we know 6 6 6 2 7 7 sin < 0 . The reference angle for is - the first quadrant common angle with the same denominator. Therefore, 6 6 6 sin 7 1 = sin = . 6 6 2
TrigTable
10
2005 September 26
5 5 5 . First, verify that lies in the fourth quadrant. Therefore, tan < 0 . The reference angle is , so 3 3 3 3 tan 5 = tan = 3 . 3 3
7 7 7 2 7 = cos = . Verify that lies in Quadrant IV so that cos > 0 . Therefore, cos . 4 4 4 4 2 4
2 2 . Note that lies in the second quadrant and that the secant function is the reciprocal of the cosine 3 3 function. Therefore, the secant function and the cosine function have the same sign in Quadrant II. By ASTC, the cosine function is 2 2 negative in the second quadrant. Therefore, sec < 0 . Since is the reference angle, we have sec = sec = 2 . If the 3 3 3 3
1 cos
1 = 2. 1 2
TrigTable
11
2005 September 26