Beruflich Dokumente
Kultur Dokumente
the routers in the network are operating with dynamic routing protocols.
the routers in the network are operating with compatible versions of ios.
the routers in the network are operating with the same routing tables.
*** the routers in the network are operating with consistent routing knowledge. *
6 describe the switching function that occurs in a router.
source ip address
source mac address
*** destination ip address *
destination mac address
11
the routers shown in the graphic receive routing updates every 30 seconds by
default. select the commands that were configured on router2 to achieve this
update interval. (choose two.)
rip
igrp
bgp
ospf
*** eigrp *
13
assuming that the network shown in the graphic is converged and dynamic routing is
enabled, which of the following conditions will cause a modification to the
orlando routing table? (choose two.)
*** the device connecting the s0 interface of the tampa router to the serial link
loses power. *
*** a network administrator shuts down the orlando router e0 interface. *
a dchp server connected to the tampa e1 network loses power.
the ip address of a workstation on the orlando e0 network is reassigned.
a host on the orlando e1 network transmits data to a server on the tampa e1
network.
a telnet connection to the orlando router fails.
14 select the statements that describe link-state routing processes? (choose
three.)
*** each router develops its own map of the entire network. *
*** routers send triggered updates when changes in the network occur. *
*** link-state routing protocols place a higher load on router resources during
the routing protocol initialization. *
link-state protocols are more prone to routing loops than distance vector routing
protocols.
networks using link-state routing protocols are slower to reach convergence after
changes have occurred
than those using distance vector protocols.
15 which protocol provides enough information in its addressing scheme to allow a
packet to be forwarded from one host to another? (choose two.)
*** ip *
igrp
eigrp
*** ipx *
ospf
rip
static
bellman-ford
exterior gateway
internetwork packet exchange
distance vector
*** link-state *
17 which are the primary functions used by a router when forwarding data?(choose
two.)
data encryption
error notification
*** packet switching *
address identification
*** path determination *
packet validation
18 which protocol can be used to route traffic between two isps?
rip
*** bgp *
igrp
ospf
eigrp
19 why is it necessary to specify a list of networks when configuring an interior
routing protocol?
routers will not allow packets to be forwarded until the network has converged.
hosts are unable to access their gateway until the network has converged.
*** routers may make incorrect forwarding decisions until the network has
converged. *
routers will not allow configuration changes to be made until the network has
converged.
25
which of the following are valid static ip routes? (choose three.)