Beruflich Dokumente
Kultur Dokumente
FOG LIGHTS
156
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 2 of 7
The vehicle has two additional fog lamps for use in poor visibility conditions.
The rear foglamps are activated by a button on the central console between the seats. A special symbol is lit up when
the side lights are on.
The circuit for the fog lights is protected by a special fuse and operated by a special relay, on the right hand side,
under the dashboard.
A warning light in the panel (rev counter module) signals that the lamps have been switched on.
In addition, if the side lights are switched off, the fog lights are also switched off even if the button is pressed. When
the side lights are turned on again, the fog lamps come back on.
If the ignition key is switched OFF and then turned back to the ON position, the operating button must be pressed once
again in order to turn the fog lights back on.
This control logic is managed by the integrated services control unit, also on the right hand side, under the dashboard.
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 3 of 7
The two front fog lights F15 (left) and F16 (right) are supplied through the fog lights relay J40 by the direct line from
the battery - maxifuse J/B2 of B5 ) up to 2/99 or of B99 from 2/99. - and through the front fog light fuse B13 up to
2/99 or F1 of the additional fuse box B98A from 2/99.
The signal which energizes the coil for the relay J40 arrives from the integrated services control unit M40 (pin 11 of
connector C) according to the enablement logic described.
The control unit receives the signal that the side lights are on from the switch for the steering column switch unit H5
(pin 8 of connector C) and the supply is controlled by the ignition (INT) from the line for fuse F1 of the junction unit B1
(pin 7 of connector B).
When the engagement signal also arrives from the button H35 (pin 1 of connector B), the control unit M40 sends the
command to the front fog lights relay J40 .
The supply line for the two fog lights also sends a signal to the rev counter module E15 (pin 14 of connector B) to light
up the "front fog lights on" warning light.
The switch H35 is lit up when the side lights are switched on by means of the line coming from the switch for the
steering column switch unit H5 .
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 4 of 7
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 5 of 7
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 6 of 7
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007
eLearn - Packet print Page 7 of 7
file://C:\Apps\eLearn\Web\tempschprint.html 18/01/2007