Beruflich Dokumente
Kultur Dokumente
Principal Characteristics
Product Information at 25 C
Binder Volume Solids Density Typical Thickness Theoretical coverage
12 - 8 m/ lit 8.7- 5.7m/ lit This gure makes no allowance for surface prole, uneven application or losses in containers and equipment. Film thickness will vary depending on actual use and specication. Red Brown Semi at 25C 35 C 45 minutes 20minutes 10-12 hours 7-8hours Drying times are dependent on applied lm thickness; all data in this catalogue are reported at recommended D.F.T. These gures are given as a guide only. Factors such as air movement and humidity must also be considered. Store indoors, above+5C and max. +30C and 0-85% relative humidity 12 months when unopened containers and stored correctly 20 kg 10C
Storage conditions
Surface Preparation
All surfaces should be clean and dry. Clean surfaces thoroughly to remove all dirt, grease oil, and any other foreign matter by using a stiff brush and /or clean rags wet with mineral spirits. All areas by resulting, blistering, etc.should be cleaned by appropriate methods and spot primed. If the surface shows more than 25% failure or poor adhesion, all old coatings should be removed and a full prime system applied.
Application condition
In condition of high relative humidity i.e. 80-85% good ventilation conditions are essential. Substrate temperature should be at least 3 C above dew point. At application temperatures below 10C drying times will be signicantly extended and spraying characteristics may be impaired. Application at temperature below 5C is not recommended.
Page 1 of 2
26
Air Spray:
Brush: Roller:
Issued:23Aug 2009
QC-FO-11-02
NOTICE: The best of our knowledge the technical data contained herein is true and accurate on the data of publication and is subject to change without prior notice. User must contact ParsShamin company to verify correctness before specifying or ordering. No guarantee of accuracy is given or implied. We guarantee our products to conform to ParsShamin quality control.
27
Page 2 of 2