Beruflich Dokumente
Kultur Dokumente
August 1989
Features Applications
Y Wide supply voltage range 3V to 15V Y Analog signal switching/multiplexing
Y Wide range of digital and analog switching g 7.5 VPEAK # Signal gating
Y ‘‘ON’’ resistance for 15V operation 400X (typ.) # Squelch control
Y Matched ‘‘ON’’ resistance over 15V # Chopper
signal input DRON e 10X (typ.) # Modulator/Demodulator
Y High degree of linearity 0.4% distortion (typ.) # Commutating switch
@ f
Y Digital signal switching/multiplexing
IS e 1 kHz, VIS e 5 Vp-p,
Y CMOS logic implementation
VDDbVSS e 10V, RL e 10 kX
Y Analog-to-digital/digital-to-analog conversion
Y Extremely low ‘‘OFF’’ switch leakage 0.1 nA (typ.)
Y Digital control of frequency, impedance, phase, and an-
@ V
DD b VSS e 10V alog-signal gain
TA e 25§ C
Dual-In-Line Package
TL/F/5661 – 1
Order Number CD4016B
2
DC Electrical Characteristics CD4016BC (Note 2) (Continued)
b 40§ C 25§ C 85§ C
Symbol Parameter Conditions Units
Min Max Min Typ Max Min Max
IDD Quiescent Device Current VDD e 5V, VIN e VDD or VSS 1.0 0.01 1.0 7.5 mA
VDD e 10V, VIN e VDD or VSS 2.0 0.01 2.0 15 mA
VDD e 15V, VIN e VDD or VSS 4.0 0.01 4.0 30 mA
Signal Inputs and Outputs
VDDbVSS
RON ‘‘ON’’ Resistance RL e 10 kX to
2
VC e VDD, VIS e VSS or VDD
VDD e 10V 610 275 660 840 X
VDD e 15V 370 200 400 520 X
VDDbVSS
RL e 10 kX to
2
VC e VDD
VDD 10V, VIS 4.75 to 5.25V
e e 1900 850 2000 2380 X
VDD e 15V, VIS e 7.25 to 7.75V 790 400 850 1080 X
VDDbVSS
DRON D‘‘ON’’ Resistance RL e 10 kX to
2
Between any 2 of VC e VDD, VIS e VSS to VDD
4 Switches VDD e 10V 15 X
(In Same Package) VDD e 15V 10 X
IIS Input or Output Leakage VC e 0, VDD e 15V g 50 g 0.1 g 50 g 200 nA
Switch ‘‘OFF’’ VIS e 0V or 15V,
VOS e 15V or 0V
Control Inputs
VILC Low Level Input Voltage VIS e VSS and VDD
VOS e VDD and VSS
IIS e g 10 mA
VDD e 5V 0.9 0.7 0.4 V
VDD e 10V 0.9 0.7 0.4 V
VDD e 15V 0.9 0.7 0.4 V
VIHC High Level Input Voltage VDD e 5V 3.5 3.5 3.5 V
VDD e 10V (see Note 6 and 7.0 7.0 7.0 V
VDD e 15V Figure 8 ) 11.0 11.0 11.0 V
IIN Input Current VCCbVSS e 15V g 0.3 g 10 b 5 g 0.3 g 1.0 mA
VDDtVIStVSS
VDDtVCtVSS
3
AC Electrical Characteristics* (Continued)
TA e 25§ C, tr e tf e 20 ns and VSS e 0V unless otherwise specified
Figure 1. tPLH, tPLH Propagation Delay Time Signal Input to Signal Output
TL/F/5661 – 2
FIGURE 2. tPZH, tPHZ Propagation Delay Time Control to Signal Output
4
AC Test Circuits and Switching Time Waveforms (Continued)
TL/F/5661 – 3
FIGURE 6. Crosstalk Ð Control to Input Signal Output
5
AC Test Circuits and Switching Time Waveforms (Continued)
TL/F/5661 – 4
FIGURE 7. Maximum Control Input Frequency
TL/F/5661 – 5
6
Typical Applications
4 Input Multiplexer
Sample/Hold Amplifier
TL/F/5661 – 6
Special Considerations
The CD4016B is composed of 4, two-transistor analog supply voltages, s5V, the CD4016B’s on resistance be-
switches. These switches do not have any linearization or comes non-linear. It is recommended that at 5V, voltages
compensation circuitry for ‘‘RON’’ as do the CD4066B’s. Be- on the in/out pins be maintained within about 1V of either
cause of this, the special operating considerations for VDD or VSS; and that at 3V the voltages on the in/out pins
the CD4066B do not apply to the CD4016B, but at low should be at VDD or VSS for reliable operation.
7
CD4016BM/CD4016BC Quad Bilateral Switch
Physical Dimensions inches (millimeters)
Dual-In-Line Package
Order Number CD4016CJ or CD4016MJ
NS Package J14A
Dual-In-Line Package
Order Number CD4016CN
LIFE SUPPORT POLICY
NS Package N14A
NATIONAL’S PRODUCTS ARE NOT AUTHORIZED FOR USE AS CRITICAL COMPONENTS IN LIFE SUPPORT
DEVICES OR SYSTEMS WITHOUT THE EXPRESS WRITTEN APPROVAL OF THE PRESIDENT OF NATIONAL
SEMICONDUCTOR CORPORATION. As used herein:
1. Life support devices or systems are devices or 2. A critical component is any component of a life
systems which, (a) are intended for surgical implant support device or system whose failure to perform can
into the body, or (b) support or sustain life, and whose be reasonably expected to cause the failure of the life
failure to perform, when properly used in accordance support device or system, or to affect its safety or
with instructions for use provided in the labeling, can effectiveness.
be reasonably expected to result in a significant injury
to the user.
National does not assume any responsibility for use of any circuitry described, no circuit patent licenses are implied and National reserves the right at any time without notice to change said circuitry and specifications.