Beruflich Dokumente
Kultur Dokumente
Case Knife
Fine-point Tweezers
Plastic Tweezers
Small Screwdriver
Case Wrench
Polishing Cloth
STEP
SNAP BACK
If the watch looks similar to this, follow the step-by-step instructions contained in the RED section labeled SNAP BACK.
If the watch looks similar to this, follow the step-by-step instructions contained in the BLUE section labeled HATCH BACK.
If the watch looks similar to this, follow the step-by-step instructions contained in the GREEN section labeled SCREW BACK.
1
STEP
SNAP BACK
Most case backs are snapped on and can be removed by inserting a blade into the appropriate notch of the case or case back and twisting the handle of the tool to pop off the back.
STEP IMPORTANT: Before removing battery(s), be sure to note which side is up. You will have to put the new Energizer battery in exactly the same way. In some watches, the battery is held in by small metal clips. If so, carefully follow the directions to the right for removing the various types of clips. Use plastic tweezers to remove battery(s).
When no groove is provided, be sure a sharp knife is inserted into the narrow slot between the back and the case. Once the knife is firnly in the groove, a slight twist of the knife handle will pop off the back.
SPRING CLIP: Lift up one end of the metal clip with the fine-point tweezers. It will come out. Then remove the battery.
STEP
SCREW-ON CLIP: Remove the screws with the small screwdriver. BE CAREFUL NOT TO LOSE THEM! CAUTION: CLIP MAY SPRING OUT. MAINTAIN PRESSURE OR SCREW MAY BE EJECTED.
PERMANENT CLIP: Lift the outside edge of the battery out of its compartment with the small screwdriver.
STEP
3 4
10 9 8 7
11
HATCH BACK
SNAP BACK
SPRING CLIP: Place one end of spring clip in place and firmly push the other end into its slot. Make sure spring clip is in the slot to avoid bent spring clips.
SCREW-ON CLIP: Place the clip over the new Energizer battery. Hold the screw with the fine point tweezers to start it in the hole. Tighten the screw.
STEP
STEP
HATCH BACK
STEP
STEP
STEP
STEP
3 4
10 9 8 7
11
H AT C H B A C K
SCREW BACK
STEP
STEP
STEP
Place the Case Wrench metal tips in the watch back notches.
STEP IMPORTANT: Before removing battery(s), be sure to note which side is up. You will have to put the new Energizer battery in exactly the same way. In some watches, the battery is held in by small metal clips. If so, carefully follow the directions to the right for removing the various types of clips. Use plastic tweezers to remove battery(s).
SCREW BACK
SPRING CLIP: Lift up one end of the metal clip with the fine-point tweezers. It will come out. Then remove the battery.
STEP
SCREW-ON CLIP: Remove the screws with the small screwdriver. BE CAREFUL NOT TO LOSE THEM! CAUTION: CLIP MAY SPRING OUT. MAINTAIN PRESSURE OR SCREW MAY BE EJECTED.
PERMANENT CLIP: Lift the outside edge of the battery out of its compartment with the small screwdriver.
STEP
3 4
10 9 8 7
11
SCREW BACK
SPRING CLIP: Place one end of spring clip in place and firmly push the other end into its slot. Make sure spring clip is in the slot to avoid bent spring clips.
SCREW-ON CLIP: Place the clip over the new Energizer battery. Hold the screw with the fine point tweezers to start it in the hole. Tighten the screw.
STEP
CROSS REFERENCE
STEP
STEP
WAT C H B AT T E R Y C R O S S R E F E R E N C E C H A R T
Energizer Battery No.*
301 303 309 311 314 315 317 319 321 329 333 335 337 339 341 344 346 350 357 361 362 364 365 366 370 371 373 376 377 379
Replacement Number
SR43SW SR44SW SR754SW SR910SW SR716W SR716SW SR516SW SR527SW SR616SW SR731SW SR610SW SR512SW SR416SW SR614SW SR1136SW SR712SW SR44W SR721W SR721SW SR621SW SR1116W SR1116SW SR920W SR920SW SR916SW SR626W SR626W SR521SW
CROSS REFERENCE
WAT C H B AT T E R Y C R O S S R E F E R E N C E C H A R T
Energizer Battery No.*
381 384 386 387S 389 390 391 392 393 394 395 396 397 399 ECR1025 ECR1216 ECR1220 ECR1225 ECR1616 ECR1620 ECR1632 ECR2012 ECR2016 ECR2025 ECR2032 ECR2320 ECR2430 ECR2450 EPX76
Replacement Number
SR1120SW SR41SW SR43W SR1130W SR1130SW SR1120W SR41W SR754W SR936SW SR927SW SR726W SR726SW SR927SW CR1025 CR1216 CR1220 CR1225 CR1616 CR1620 CR1632 CR2012 CR2016 CR2025 CR2032 CR2320 CR2430 CR2450 SR44
*For additional numbers, refer to the Energizer Wath Battery Replacement Guide or Energizer Battery Size Checker
W/BR/13503C
2002 ENERGIZER