Beruflich Dokumente
Kultur Dokumente
Time:
Please answer in this paper and as clear as possible. Do not forget the UNITS!
Enjoy it! Behzad
Name:
B P G G B P G G Qv 1a 2 LRC 7 2 FB 1b 2 LC 8 2 vV 1c 2
, 2 2
IF 3 2
, 4 2
, 5a 2
, 5 2
AC 6a 2
AC 6b 2
AC 6c 2 Grade
Sum 22
Ch 20-21 Total 26
Teachers Comments
Students Comments
1/6
1.
Electrons are accelerated and shot into a region of homogeneous magnetic field, as illustrated in the figure below. The path of the electron beam in the region may be described by a quarter of a circle of radius 2.50 cm . The magnitude of the homogeneous magnetic field inside the region is 4.00 mT . Outside the square region the magnetic field is zero. a. b. c. What is the direction of the magnetic field inside the square region? Why? Explain. [2/0] Calculate the magnitude of the velocity of the electrons in the magnetic field. [2/0] Calculate the electric potential difference that has accelerated electrons to the velocity calculated above. [1/0]
2/6
2.
The magnetic flux through a solenoid containing 600 turns changes according to the accompanying figure. Calculate the emf induced in the coil at t = 0.30 s . [2/0]
3.
The two wires of a 10.0 m long appliance cord are 5.0 mm apart and carry a current of 2.0 A dc. Calculate the magnitude and direction of the force between the wires. [2/0]
3/6
4.
The magnetic flux through a coil of wire containing ten loops change from 25 Wb to 75 Wb in 0.25 s . What is the emf induced in the coil? [2/0]
5.
In the figure to the right the rod moves at a speed of 2.0 m / s to the right. It is 15.0 cm long, and has a resistance 1.4 . The uniform magnetic field is 825 mT and is into to the page of the paper and away from the reader of these words. The resistance of the Ushaped conductor is 60.0 at a given instant. a. Calculate the emf induced in the rod. [2/0] b. Draw the figure in your test sheet and Indicate clearly the direction of the induced current in the rod. Explain the reason behind your choice. [2/0]
4/6
6.
An average of 500 .0 kW of electric power is sent to a town from a power plant 25.0 km away. The transition lines is made of a bulky copper wire of total resistance 1.20 . a) Calculate the power loss if the power is transmitted at 220 .0 V [2/0] b) Calculate the power loss if the power is transmitted at 220.0 kV [2/0] c) Explain based on your calculations above why the electric transmission lines use high voltage Alternating Current. [2/0]
7.
In a series LRC circuit, the inductance is 50.0 mH , the capacitance is 25.0 F and the resistance is 35.0 k . The AC power supply provides 210 V at 50 Hz . Calculate the impedance of the circuit. [2/0]
5/6
8.
Electrical Oscillations: An LC-circuit is an electrical analogue of a harmonic oscillator 1 . A 50.00 F capacitor is first charged to 0.25 mC and of frequency: f = 2 LC then is connected to a 40.00 mH inductor. Calculate the frequency of the oscillations that results. [2/0]
6/6