Beruflich Dokumente
Kultur Dokumente
MIL-STD-12D
29 May 1981
SUPERSEDING lfIL-sTD-12c
15 June 1968
~lLITARY STAWDARD ABBREVIATIONS USE ON DRAWIN6S, FOR AND IN SPECIFICATIONS, STANDARDS AND TECHNICAL OCUMENTS D
ORPR
Abbreviations for use on Drawings, and in Specifications, Standards and Technical Documents. MIL-STD-12D 1. This Military Standard is approved for use by all Departments and Agencies of the Department of Defense. Beneficial comments (recommendations, additions, deletions) and any pertinent 2. data which may be of use in Inproving this document should be addressed to: Commander, US Amy Armament Research and Development Coumand, ATTN: DRDAR-TST-S, Dover, New Jersey 07801, by using the self-addressed Standardization Ikcument Improvement Proposal (DD Form 1426),appearlng at the end of this document or by letter.
ii
Paragraph 1 1.1 1.2 1.2.1 1.2.2 1.2.3 2 2.1 2.2 2.3 3 3.1 4 4.1 4.2 4.3 4.4 4.5 4.6 4.7 4.8 5 5.1 5.2 SCOPE ------------------------ ----Scope ----------------.---.0-.--Appl 1catlon ------------------0-Short words -000----------------Field of use 0---.0-.0----------Combining form -.0-.0-0---------REFERENCED DOCUMENTS -------------General 9-----------------------Standards -----0-0--------------Other publications -------------DEFINITIONS ---------------- ------Abbreviations ------------------GENERAL REQUIREMENTS -------------Clarity ------------------------Word combinations -------------- Syntax --.-.0----0------------- -Capitalization ---0------------ .Punctuation --------.00---------Revised abbreviations ----------symbols ---------------- -------- Abbreviations used in existing technical documents ----------DETAIL REQUIREMENTS --------------List of terns and their abbreviations .00------------list of Cross reference abbreviations
Page 1 1 1 1 1 1 1 1 1 2 2 2 2 2 2 2 2 2 2 3 3 3 5 81
$ii
)
-
MIL-STD-12D 29 my 1981
MXLITARY STANDARD. ABBREVIATIONS FOR USE ON DRAWINGS, AND IN SPECIFICATIONS, STANDARDS AND TECHNICAL DOCUMENTS
1.
SCOPE
1.1 Scope. The terms and abbreviations in this standard are limited to those commonly used on drawings~ and in specifications standards? and technical documents. 1.2 Application. This standard provides a list of abbreviations authorized for use on drawings, and in specifications, standards, and other technical documents. 1.2.1 Short words. Abbreviations of words having five or fewer letters are not included except those established by longstanding practice. 1.2.2 Field of use. Where an abbreviation is intended primarily for a particular field of application, that field is indicated In parentheses following the term, eg, fast operate (relay). 1.2.3 Combininq form. Where No abbreviations are listed for the same word, the first applies to the word used alone, while the one designated (comb form) is to be used only in combination with abbreviations of other words to form an abbreviation for a word combination.
w
- 2.
REFERENCED DOCUMENTS
2.1 General. The issue of the following documents in effect on the date of invitation for bids form a part of this standard to the extent specified herein. 2.2 Standards ANSI Y1O.3-1968 ~YIO.5-1968 Quantities Used in Mechanics of Solids, Letter Symbols for Quantltles Used in Electrical Science and Electrical Engineering, Letter Symbols for Mathematical Signs and Symbols for use in Phys2cal Sciences and Technology Letter Symbols for S1 Units, and Certain Other Units of Measurem-t
ANSI Y1O.2O-L975
includlng ANSI YIO.20a 197S
: .
MIL-S7fl29 by 1#$!/
2.3
Copies of listed Industry Association Standards are available to Military activities through the DOD Single Stock Point, US Naval Supply Depot (NSD 103), 5801 Tabor Avenue, Philadelphia, PA 19120. Nonmilitary activities may obtain copies from: (ANSI) (ASTM) American National Standards Institute 1430 Broadway, New York, NY 10018 American Society for Testing and Materials 1916 Race Street, Philadelphia, PA 19103 The Institute of Electrical and Electronics Engineers, Inc. 345 E. 47th Street, New York, NY 10017
(IEEE)
3.
DEFINITIONS
3.1 Abbreviations. An abbreviation is a shortened form or abridgment of a word, expression or phase used to conserve space and time. 4. GENERAL REQUIREMENTS
4.1 Clarity. Abbreviations shall be used only when their meanings are unquestionably clear to the intended reader. WHEN IN DOUBT, SPELL IT OUT. Abbreviations that are not in comnon use and are to be used frequently in a document or where thewis doubt that the reader will understand their meanings, should be clarified when first used: by spelling out the word or complete phrase, followed by the abbreviation in parentheses. 4.2 Word combinations. Portions of an abbreviation for a word combination shall not be separated for use singly. Single abbreviations may be combined when necessary if there is no abbreviation listed for the combination. 4.3 Syntax. Unless othewise indicated herein, the same abbreviation shall be used for all tenses, the possessive case, participle endings, the singular or plural, and the noun and modifying forms of a term. 4.4 Capitalization. Abbreviations included in the left-hand column provide the form for use on drawings and documents produced in uppercase characters. The abbreviations in the right-hand column provide the form required for documents produced in lower-case characters; however, these abbreviations may be capitalized when required for emphasis. Abbreviations that are capitalized in the right-hand column are a continuation of prior usage and in general are abbreviations for major systems or are recognized as having significant application when used in text. Abbreviations are not listed in the right-hand column for many short words. If space limitations make it necessary to abbreviate such terms, the abbreviation which appears In the left-hand column shall be used except for the sllbstitutionof lower-case letters.
4.5 Punctuation.
4.5.1 Punctuation marks which do not appear in this standard shall not be used with the abbreviation of a techn~cal term; however, an abbreviation spelling a whole word should include a period if the abbreviation is not obvious to its intended reader. An exception is made for abbreviations used in computer applications wherein a hyphen (-) may be substituted for a blank space which appears in an abbreviation, eg. seqchk in lieu of seq chk.
with
adjectival forms
of abbreviations and
4.6 Revised abbreviations. Abbreviations in this standard reflect recent changes in the state-of-the-art. 4.7 Symbols. The distinction between abbreviations and symbols is tricky, because it depends upon context, rather than form. For example, the current is 5 amps and the pressure is 3 psi are allowable uses of abbreviations, whereas writing I = 5 amp and P = 3 psi are incorrect. Whenever a mathematical operation or sign is involved, such as the equality sign (=) or the division sign (/)~ abbreviations cannot be used= Mathematical operations re performed only upon symbols; for example, !l Symbols that appear in the following docuI =5Aandp=31bf/in. ments are preferred (for example, the current is 5 A) in lieu of abbreviations that appear in this standard and shall be used in lieu of abbreviations for terms that do not appear herein: Chemical Symbols: Websters Unabridged Dictionary (International Tabl~& of Chemical Elements) b. c. d. e. Mathematical Symbols: Quantity Symbols: Unit Symbols: Metric Practices:
4.8 Abbreviati~ns used in existinq technical documents: Unless,o~he~ise specified, any changes or revis~ons to an existing drawing, speclflcatlon, standard, or technical document prepared under a previous edition of this standard, may use the latest abbreviations, although the superseded abbreviations may appear elsewhere in the documnt. 5. DETAILED REQuIRmE~Ts
--4
TER,M
action ticm qct lvato a qcttvattoflnalysis qctivator qctlv8 counterwmsurfks 81ement group qctlvo actfvo Integral defense repaatersatell~te qctfvqctfvtty qctual qctual ground zero qctual time over target
APL abm@W qbx 1 qbbe qbn 1 qb t abv qb 1 qg1 alas 1 qs 1 SW abrsv AORSV RES qbrsv res qbs ME
AcTvm
~r 8*
MC
AID
ARS AC? AffL AGZ ATOT ACtE ACT G &CT R ADAPT AOPTR a% AFCS ADD ADDu AOOL ADOT 4DRS Am ADH AOd ACA nod AOd W ADMG ADSORB AOV ACCP AEO AAN ACN ANR AAFSS AERES A8AR ACR ADCS
a td ~tt
q tmt U* q =W 8CW q dafa t
actuate
actuating qctuator q daptation Sdaptmr q lapt*r booster Adaptiv@ flight system ~
ASS CLG AEE AesoRa ASSTR ACAO ACCEL ACLtR ACCLRM A-T AQL AQT ML Aa ACPTR
4CS Ao
Clg
adptr
S& APa
qbsorption
qbstract acadea i c accelerate qccelemtur accelerometer qccep t q cceptotsle q cceptable qcceptable rx~tmc*
absorb abs tr qcati qcce 1 qcl tr qcc 1m acp t Am ARL ACE ecptr 8CS qo m 8CS t qcc-ss qcdt
Control
adder qmltien
qtiittonal q-i tfv. address q-r. a49tes i v. qdjacent adjscent
Cttactcout
~fpmmt
q cceptor
qccess qccess opentng qccess panel qccess ttm qccessory
channel speed
qttmwatfm
adjust
q djustable q -ttttng
ausorbant q* anw
advam
engineering
change
propesa I advanm enginwring ordar advance alt8ratton notice notice qdvanco change qdvance materfal request q ~f-lal ffre qdvanced qdvanwd bslltstic reentry Sys tam advanced battery q cqtsition radar qdvanced capabillttes radar advati *fens@ c~fcations satellite radar qdvanced -sign qrray advanced firtng systems interceptor qdvanoed Ranned qdvamed manned penetrator qdvanced manned stratagtc q t reraf t solar qdvanced orbtttng obsewatory qdvanced tacticaI ball fsttc mtssl Ie q -mtage q dvertisement qdv i se qdv 1wry aerial deltvmy system . erodynamic q q erodyrtamtc center serodynamtc heattng q erologlcal 8WWnmJtfc mater~a qcrofmutlcal Specification
~rt
system
abar
AOAR
AFS AMI AMA AOSO ATEM ADVG m AOVS AOVSY AOS AEROOYN AC A6ROHEAT AEROL AERO Am
q ctc@rwf sci*roof
amnsup
qtc qpc q cq q cq AAC w qcr
--
q crylic
amrmdyn
SC qoroowa qerd qero t
TERM
aeronautical national taper ptpe threads aerenauttcal rec~nded practices amonautlcal standards group qerospace aerospace ground equloment aerospace veh~cle equipment qf ter qfter cooler qft-r engfne room after p*aic qfter perpendicular after torpedo room afterburner qfternoon Ipost mridieml qgen t qggrega te
AWIREVIATION
ANPT 4RP ASG AERUSP AGE AVE AFT AFTCLR AER AP AP AtRM All PM AGT AGGR &G AIL AP A8 As ABCB AOT A@ SW ACE ACI RC AIRCLNR AIR COND AOC AOM AOA AO AC AN ANA ANPT arp ASG aerosp AGE avE qft qftclr qer qp qp qtrm qb Pm qg t qggr ag q ~l qp AB qb qbcb qb t qb sw qcb qc t rc qirclnr qir Cond qdc qdm AOA qd
TER,M
qtr to ground mfsslle q fr to ground to afr qir to surface missile q lr to underwater mtsstle q ir trafffc control q fr transport radto q tr transportable sonar q lr turbine drive q tr turbtne motor q tr turbine starter q t rborne q trbome eerly uarnlng airborne early uarnlng q trcraft q trborne qarly uarntng ana control qirborne fixed qrray radar qirborne gunlaytng alrbome interceptor q trborne long range radar tnput q trborne radar qnd dopp~er q trborne ris@ar approach q irborne surveillance radar q trbome very low frequency q trboene vtbration monitor qtrcooled qircraft q trcraft approach I*ght q trcrart control and survei 1 lance aircraft control qnd warn!ng atrcraft mtss~le project power q lrcrs?t nuclear (propulsion) q irfr~ qtrfrasm-mounted qccessory
AFH3REVIATION
AGM
qgm
AGA
ASM AUM ATC ATR ATS ATD ATM ATS ABN AEU AEUA AEW6C AFAR AGL Al ALRI ARAO ARA ASR AVLF AVM ACLO ACF? AAL ACS ACV AMP
aga a sm
aum ATC atr qts atd qtm qts abn AEU qewa AEWC qf qr agl a{ qlrf qrad qra qsr qvlf qvm qctd qcFt qa J qcs qcu qfw 8afr qmad q?ft ap 1 apr t asdr apsr qs qs ql qt qim qcv apm q le qlg qc t
q gitstc
q t1eron qtmtng point q lr base q ir blast q tr blast ctrcuft breaker q ~r biast transformer a{r break switch air Clrcuft breaker air circulating q ir c188ner q lr condftton q ~r data co~ting q tr decoy missile q rtillery q ir defense q ir *t q tr qscape Navy Alr Fore@ Atr force Navy AeronautlcaI Navy OeSign Air force Air force! Navy Cfvfl Air Force techntcal order air headee q tr hetght survetllanee
AFR ANAO 4LFT APL APRT ASDR APSR AS AS AI AT ALU ACV APM ALC ALG ACT ALGO ALGOL ALOD ALIGN ALK ALKY AAC AU ANC ALLC)C AC [ ALLOW AEL hP L At. Y
dr 1ve
qtrllft airplane qirport atrport radar afrport a f rscoop q1rspeed
AFTO AHOR AHSR AHP AINOTN AI AI AIM ALBM A18 I ALV AL AMU AMUN AO A/ki AP API AR ARTCC ASR Asl?
surface survef
radar q fr homepover
q tr inductfon atr installations q ir intercept q ir Intercept missile q ir launc~d ballistic misstle launched boost intercept q ir air launched vehtcle q ir lock q lr movement data q ir mn~tions q ir over q tr over hydraulic q tr passage q ~r poslt~on indicator q ir refueling air route trafffc control cm ter q ir sea rescue a~r search raaar q ir shutoff q lr shut tev q {r Specfficatton q ir starttng q tr to q tr q tr to qlr tdentiffcat{on q tr to q ir missile q lr to ground
qlgo
ALGOL q ldd
qltgn
qlk alky aac qu anc allot AC X
ASNOF
AIRSHTR AS ASTRG A-A AAI AAM A-G
q now ae 1 qp 1 aly
A13RREVIATION
steel steel protective platlng alphabetical qlphwumerlc qlphanumeric output q lt~rat ion q I tared q l ternate qlternating current alternating current eonttnuous wave alternating current synchronous qlt8rnattng cuwent t8st volts qlternating current volts qlternating current working Vol ts qlternation q l tornat~ve q lternator q ltimeter q ltitude q ltitude direction tndicator q ltttude reservation qltttude transmitting q-t preen t q ltttude vertical veloctty indicator q luminum lum$~ conductor stae? reinforced q lumtnum-clad qma 1gam qmattir televtsfon. qmatol qmer qmer Ilght q~tent ad3u 1qnte qmendment Amer t can American Gage Oesign Standard Ame~tcan Natton+l Standard Code for Information Interchange Amertcan Standard American Steel Wire Gage American War Standard JWmrtcan Wtre Gage Amartcan, ttrittsh, Canadtan Amerfcan. Oritish, Australian Canadtan, q-t er qrewater suftch qmen i a qmumium nitrate qmunition qnmunttion hoist q-nition hotst arfve qwmunttien fdent~fication Cocto qamunltlon rack qmoun t ~erage 8Vre mm (cform) -v-a @effmd neter aaw9re turn
TERM
q ~re-hour
qfqmr=-hour ~hfbtous qamhlbious amtwr truck
AIUIREVIATION
AMP HR AMPM AMPki TRK ANPLDN AMPLC3 AMPLM3 AALC AMPL AI ANPTO AM ASK ANt.G AURT ALD A/Cl AOC A?UGS ANAL ARP ANALY AHR A8 AN LT AOR AUNOLS ANCF I L NPSH .-. ANCH ANER ACG ACG ANG AME AA I ANLOR Asv ATOT A?4LR AWiYo A?a-4Yo AML ANCG ANLR Al) A ANOZ ANW AMS AN ANT SCAN ATU A AAO AAW AA AAA AAC AAFC AASD ABM A8MEWS A8NN AF a
qlloy qlloy
qly
qspp
stl
q1pha 883 qno ql trn q i trd q ltn qc 8CCW qcs vact V8C v qcu q lt ql tnv q l tntr q ltm q lt qd ~ qltrv qlte qvv 1 ql qcsr qlcd q mlg ATV Rm amb ql q* qm qmend Amer AGDS ASCII
q I+wyna
control
q wvtd
qm ask q nlg qdrt
VAC7 VAC VACW AL7 ALTNV ALTNtU ALTM ALT AOI ALTRV ALTE AVVI AL AC$R ALCO ANLG A?V AN ANO Atg AMEJ AN8 AMENO AMER AOOS ASCII
Amer Std ASUG AW$ AUG A8C A8CA 8qs qrena qm nit 8qmohs t qmohs tdr qic aemork qmt qup a qu qt
program qn8 1yze qnctver qnchor bolt qnchor Itght qnchor ordw qnchor wtndlass qnchored filament qnd nipples and so furth (see qt cetera qnechotc qneroid q ngiocard{ogram wtgtocardtograph q ngle q ngle measurfng ecpipment q ngle of q pprosch indicator q ngle order q nglw stop valve q ngle tr8ck en target q ngu 1ar anhydr i de q nhydrous annea 1 qnnounc f ng qnnular anmmctator qnode qode (electron device) qod f ze qnodfze iattn qbbr) Smwr qntmarldtem (before noon) sntenna antenna scan qntenna tunfng unit antt (~ ?orm) qttatr output qnttafr warfare qntiaircraft q rt{llery qnttatrcraft q ntiaircraft comnon qntlatrcraft fire control qntiaircraft self destroying qntlballisttc mtsslle q ntiball istic missile early warntng system q ntiball istic fntssile misstle qttfrtction bearing
q nalog Ifne driver q nalog to digital q nalog to dtgltal q nalogous q nalysts q nalytical rework
qld
qla qdc qnl gs 8na ) qrp ana 1y qhr qb an It qor awnd 1s ancf i 1 npsh --qnch qner acg acg q ngle Am qa t anlor qsv qtot qnlr q nhyd q nhyd qn 1 ancg qnlr ann qd A qndz ---qns qm qnt scan qtu a qao AAw aa aaa aac aafc qasd abm ABMWS qbtlwl qfb
. .
ABBREVIATION
AfM Ma AN Al Ad Ad/Al ANTILOG AMSAN qfm qh 81 qj qj/al
TERM
qrtt-ttc Untt ~t qrmament qnd q lectronics change qmamnt matortal qmature qmature {altn qbbrl 8~ture accelerator qmture shunt smtng Amalng qnd Fus1ng System smtng wtre rmo~ grattng qrmor plwclng qrmor pterctng capped armnr piercing capped ball tsttc capped qrmor piercfng capped tncendlary armor pferclng capped tncandtary with tr8eer vlth qrsur ptercfng capped tracer qrmor pf8rctng tncendtary smr pterctng Incendiary with trac*r qrmor plerctng with tracer qrmor plate qrmored qmnored cable qrmored Infantry venlc)e 8mored personnel carrier qrmored utillty vehtcle Army-Navy Army-Navy @rittsh Amy-Navy Ctvtl Cmsnercial Army-Navy Arwy-Nwy mSt~ A?Wy-Navy-Alr Force qromattc q rrange q ~angement q rray processing tnstructton set qrr*s tar q rrest!ng (gear or hook) qrri va 1 qrs!ne qrticl* qettculated qrttftclal 8rtlf$cfal qarth s8tel?lte neutron qrtlftclal qrttftc!al transmiss q rttllery qs drawn qs ~tqs soon 8s possible qsbestos qsbestos (insul} qsbestus cement qsbestos cement boar~ cuvered metal qsaestos qsbestes mf 11 board
AB8REVIATION
ARI TMJ ARMT A&t qrt t~ qrm q8.
ant tgas
qnt lhunt q ntftetng qnti ja-lng
-t
ARM
8ntfjamfngi8mtfq : flterfwnc*
AA
ARMSt4T
antilogarithm
qntfatssilw surface to qir
q nttlog 8mam
qmtb qm qpers qrm qrr
qrm qa q -ht :; qu qg qp ape q pcbc qpc i qpc t t 8PC t qp t spit qp t qrm pl am qrm ca a$v qpc quv AN AM
mtsstlo
qttmtsstl~ mfsstlo qntimtor torpedo boat qntlmotorboat q nttparsonne 1 qntiradiat$on mtssfle q ntfrepeat relay q ntlsepttc qntfsuomartne ANT8 APERS ARM ARR ANTSPT 4s ASROC AsTO@ Asw AT ATAR ATM ATM &70RP ANTox ATRC ATR AT RT Auw APT APCRT APTC APOttt APPAR APRNT APP APPX AWL AS APLO APLQ APPT &PR APRCH APPCON ACR APPN APPVL APPV APVO APPO APPROX Am AQ Am ARCW APW ARCH ARCH ARNC AQ AMTI AWAR MAT
sntspt 8s
qsroc qster Asu qt star 8 tm qtnm 8 t orp qntox qtrc atr qtrt AUW qp t qper t ap te Spoth appar aprnt qpp qppx q 1 p9 qb afsld aptq qpp t qpr q prch qppcon acr qppn qppv 1 qppv q pvd ---qpprex qq qrb arcu qpu arch arch qrng ~ qmt f qwa r qwa t qp qri th q lu
antisubmarine
rock-t
qntfsubmartne torpedo qnttsubmarlno v8rfar8 q i tank pt qntttantc q trcraft rocket qntltam missile nonmetallic qntitank q ntftorpedo qntftoxtn sntltraciclng control qnt~transm{t r~coive sntftransmit receive tube qntfundarwater warfare apartment aperture q ~rture card q pothecary q pparatus
q pparen t q ppearance
block
ANC AND ANAF AROM ARR ARR APIS ARSR ARG ARR ARS ART ARTCLD ARTF AES ART RON ARTY AO AR ASAP AS8 A AC AC8 ACM me ARS ASPH ASWPF ASPHRS AT B ATF ASPRTR ALZ ASSEM
q rg
qrsr
:;1 tH
ALU
Iandtng
qrr qrs qrt srtcld qrtf ses art ron qtl Srty q d qr asap qsb q qc qcts am qm qrs q sph q sphpf asphrs a tb qtf q sprtr 812 assm
a
,
XIL-STD-12D
TERM
(auto manufacturing) 8mssstlly q ss-ly q d repair Sss-ly jfg qssign qssignment qsst Stal=e qssistant Ass~sted Takeoff System 8ssoci8t8 association qssort qstablo qstable Blockfng oscillator qstern q~tlgmatism qstragal qstronautical qstronom~c q stronom~cal time switch qstronomical unit qstrophysi cs q sy-tr~c q sywptote qsynchronous q synchronous data wlttplexer synchronizer qt q later date athusrtship qtmosphere qtmosp~rtc sound focusfng gain qtomic (cc* form) qtomic demolition mnitfon qtomfc e=plosion qtomfc hydrogen weld qtomtc striko recording system atomic weight qtomizing q ttach qttachsutnt attack attendant att8nt*on qttenuate qttenuated total reflectance qttitude qttorney qudible qud i o qudio @ecade oscillator sudto Frequency qudto playback unit qudio visuaaudl tor q lqrlent August authority to proceed authorize authorized data list autodyne detecttmn qnd ranging qutomatic qutomatic antijam circuit qutofnatic attack warning Sys tam automatic back bias qutomattc bandwidth control automtfc bass comensatfon qutomatic btas ccmpensatten
SsBrnlo
TERJhI
aut-tfc automatic system autrntle brightness control carri8r landing Celestlal AUC Ams Zs qcn
Mvtgatton
automatic check Valva Oheckout mfpment 8utrntic qut-tic clrcuft q nalyzer qxchange automatic Ctrcuit automatic Cluttw q laminator qutomatic cluttw mapping qutomatic data qccumulator qnd transfer q ccp~sition automatic data q xchange automatic data qutomatic data link automattc data processing automatfc data translator qutomatic d(gltal data q cqisttlon qnd recording automatic dtgital network qutomatic d$gital r-cordfng qnd control qutomatic dfgftal wat-r Sui tctl qutomatte direction finder qutosutlc door seal autatic electronic swltctttng center qutomatic ftne tuning automatic flight control ccptpment Automatic Flight Control systqutrntic f~ncy control automettc oatn control autmtfc gatn stabllizat!on automatic gimbaled antenna vectortng ~lpmrnt automatfc ground controlled q pwactl qutomatic ground controlled landtng automatic ground to q ir c~ications system Automattc Instrument Landing Approach System Automatic Instrument Landing System automattc lean qutomatic lev81 control qutomatic Iocon automatfc tow data rate
AuTo Cv
ACE ACA ACK7X ACL.E ACM ADAT ADA ADX AOL ADP AOT AOi)AR AUTOO IN AORAC
Asst
a70s &ssoc ASSN ASRT ASTII A80 ASTN ASTIG A ASNAU? ASTRO A7$ Au ASTROPHYS ASYkt ASYMP
quto Acz qca qcktx qcle qcm qcta t qds qdx adl AOP qdt qddar
cv
q strophys
AUTOOI N qdrac qdus qdf qds qesc qft AFCE AFCS qfc qgc q gs q gav* AGCA AGCL AGACS AILAS AILS lean
AOUS
ADF ADS AESC AFT AfCt!? AFCS AFC AGC
ASVN ADNS
ALD ATH ATM ASFG AT ADN AT XPL AT/V ASTREC Ar UT ATNG ATCH ATCH ATCK ATT ATTN ATTEN ATR AT7D ATTY AUO ADO AF APU av AUOTR AGNT AUG ATP AUTH AOL AUOAR AIJTO AAdAC AAUS A8B AWC ABSC ABC?
AILAS
AILS
qtty
qud qud qdo 8+ qpu qv qudtr q gmt Aug q tp quth ad 1 qudar
AUTO LEAN auto ALC *1C qlo ALO aldri ALDR I AMA Amos ANA AMOS
q utomatic
Irq?ut
message 8CCOUnting meteorological station mixture contrul mwlng target
automatic
auto qajac
AAws qbb qbut
abse q bcp
observing autatic aut-tic indicator autoaatic noise limiter autattc numor identification automatic outwt control q utomatic overload automat~c overload circuit autrntlc phaso control AUtOmStfC phaSe IOCR qutomatic picture transmissim q utomstlc pflot
qoc AUTO OVLD quto qovc AOVC APC 8pc q 1 p APL q pt APT
AOC
Ovid
PILOT
ABBREVIATION
AUTOP APM ARONE
TERM
qvlatlon q iectron Cs qviatfon fuel qviation gas turb ne qvfation gasoline qviation oil avoirdupois q waiting overhaul q vntng qxial flow qxial pitch qxial pressure q ngle qzinuth qziwth qnd elevation qzirmth qnd range qzimth change pulse aziwuth elevation qziwth only qztnuth ~antized gated video
ABBREVIATION
AV1ONICS AV?UEL AGT AVGAS AV02L AVDP AOH AWN AK FL AXP APA AZ AZEL AZRNG ACP AZEL AZON AQGV BAB SC BE 6F UFO BFL 6G eofs BP SPC 6T08 BTDL qvionfcs qvfuel q gt q vgas qvof 1 qvdp aoh qwn
autntfc pistol Wtomat t c programing qnd record f ng radar clttance s automattc measuring euufpment qutomatic reclosing qutomattc rich automatic send receive automatic sensitivity con t 1-01 sutomatlc sprtnkler qutomatic sprinkler riser qutomettc stabiltzatfon q ~ipment automatic starter qutomatic start~ng qutomatic stiffening qutomatic stop qnd check valv~ qutomatic terrain qvoidance qutomattc terratn folloutng automatic terrain fol!wtng radar qutomatic terrain reeognttion and navigation qutomatic test ancl checkout equipment qutomatic test equipment qutomat$c threshold var~ation qutomatic track whi Ie scan automatic tracking control qUtOm8tfC tracking untt qutomatic transformer automatic video no~se lcvellng autoaratfc,votce network wtomatfc volume control qutomatic volume expanslun qutomatfc zero set qutomatfcaf Iy programed too 1 automation qutomobile autonmtlve qutotransformer auxl liary q uxltiary detonating fuze q uxiltary drum q uxtllary nxmory q uxtltary power supply q uxil~ary power unit q uxiltary register auxtltary switch (breaker] sux~liary switch normally ciosed auxiliary switch (breakerl normaily open q vailability qvailable avemue average q verage da$ly traff{c q verage dlamter q verage qfficiency fndex q verage outgoing quality average outgoing ~ality Iimtt average ptcture level q vwrage sa~le nutier q verage total ~nspection qviatton
q utop spar
qrdme reel rtch
ax fl a xp
qpa az qzel q zrng aep qze 1 qzon aqgv
ASE
AUTOS?RT AUTOSTRTG AUTOSTIF AUTO S&CV ATA
ME
sutostrt sutostrtg sutostif quto sbcv sta qtf
ATF
AtFR AtRAN ATCE
atfr
ATRAN ATU
ATE
qtv
babbitt back connected back end back feee back focal distance back focal length
back back gear of board back pressure back pressure
bab bc be
bf
bfd bf 1 bg bofb bp bpc
AtE
AtV A7WS A7C ATU AXFMd AVNL AUTOVON AVC AVE Azs APT AUTOMN
control
atws atc a tu
axfmr qvn I AUTOVON qvc qve qzs Sp t automn quto autom quto xfmr aux qdf
back
to back
-ck transient diode logfc back view valve back water backface background back 1qsh backlash qllouance backshel f backup interceptor control backward uave magnetron backward wave osc~llator
Bv Bwv %F BKGO BL 6A
BKSLF BUIC BUM Eiwo tiWPA 8ACT BAF SAG 00 OAK ML BALUN BLU BAL V BAL CL 6ALRHE0 8ALS 88RG BLST 8AL
EM
bk ~
bl ba bkslf buic
AUTO
AUTOM AUTO XFNR AW
%3 bac t
AXO AM
APS APU AUXR ASU Asc ASO AVLBL AVA1 L AWE AVG AOT AVG OIA AEI AOQ AWL AWL ASN ATI AVN
axd am
qps qpu quxr qsw qsc aso qvlbi q va I 1 qve avg
network
baf bag bo bak ba ? ba ?un bld ttal v bal c1 ba 1rheo bals bbrg
blst ba 1 bm bamb t BMEWS b bsp bnd bnd dtS bd elim
bal Istop
band
AOQ
10
AI?I?REVIA?YON
w OUR OARS UC 9K UT Sc
SARO SKS 04
TER,NI
be8con
beacon qntenna cqulpment beacon ranging pulse beam beam formtng electrode beam of light transistor beqnd stringers bawnsteering
ABBREVJATION
BCN 8AE BRP BM OfE BOLT 66s 6MSTRG mm em 001 eot+r 8PS 8RI 8F BFO BO ECKT 8 DNG Bomi eR BFR BASIC ba8 brp bm
barrel
barrels barrels barrier barrier barrier barrier Barrier Barrier barrier barrtng
ttle
per per
roof
day hour
coat grease proof moisture vapor proof Ready Liqht SYs-fem Up Inciic~tor System waterproof
ERRD 9eL i311L ROLL BTR BPO BPH BARR Ec 8GP 8MVP BRLS -
w bur bsrb Bc bk bt DC baro bks bj brrd bb I bbl roll btr bpd bph Barr DC bgp bmvp SRLS
bf q bolt
DAs bms t rg brg bd {
WIS
BWP BRRG SLF 8 8 88: ee Bo BOF 80s0 BOIA Be
BUIS lx+
brrg
blf b a b& i bb bd bdf bdsd bdia De bf bha bi bl w ~ bsmt hsc oas bc 1
Daryta
base base base base
Itght fling
device)
[electron
base detonating fuze base detonating self destroying base dfameter qject~on base base $uze q ngle base hei{x base ignttion base line bmse percussion base pitch base plate basmnt basic basic air speed basic contour line basic i~ulse insulation 1 qve I basfc network basic oxygen furnace basic processing unit basket batch mfxcr bathythermograph battalion batten batter bat tery battery [electrical) battery charger battery echelon operating control battle battle dress~ng 08bayonet bayonet candelabra double bayonet candelabra contact bayonet candelabra stngle contact bayonet skirted
Bf 9HA S1 BL 6P
8P BP OsNT USC 8AS BCL BIL 8AS NET BOF BPu 8SKT 8MXR 61 W OATT BAT BTRY 6AT BAT CHG aEoc BAT 80 BE BAY BAYC SEE BELOW
bearing distance indicator bearfng procurement specification bearing range indicator best fr~ency beat fr~ency oscillator beat uscil?atur Decicet bedd f ng Van bedroom before qn-purpose beginners sy-olic instruction code (eowputers} beige bell alarm switch bell and bell bell and flangt bell qnd spigot bell cord bell crank bsll end belltng bel Imth
indicator heading
bdh f
bps br i bf bfo bo bck t bdng bdpn br bf r 8ASIC
BG
8A W
88B B~ f ahs ec SEL CRK @E @LNG 8LMTM BLWS 8LW BW BWL ONCH BME 8M aNcHBo BON BL 8R SUP 8NG M BT BTH BERTH BESS 8ETW EC 8P 8EV 8WS BvGE 6 I CONO Bcvx OCL B/E 8/L 8/M 8/s OL 8L STL E$MTLC 81N
bnch
bm
bnchbd
bdn bl
br
Dup bng
m bt bth
berth Eless
betw
8C bp bev *S bvge b t CO* bcv x bc 1
biCyCle
bill of exchange bfll of lading bfl? of material bill of sale billet billet steel bimetallic bfnary
b/e
bl 1 b/m b/s bl bl stl bmt ~C
baysk
bln
B/lYCAIIDSC
11
bay canalsc
TERM
8tnery keytng
ABBREVIATION
y Shtft
8crsK BCD DC! X0 OCR? BC BDC 80 bcfsk bed eel bco
TERM
blip fraam ratio bltp scan ratio block blocktng blocking oscillator b~ou torch bloudoun blower
ABBREVIATION
8fR Osn BLtC SLKC 80 0LW7 SLMDN 8L0 w BLWT aoc
ecu
btnery
btnery btnary tstrury Btnsry bfnary btnary btnary
coded \nformatton Cm OCtal range ttme coded counter decimal counter decoder dlgtt btnary cttvide qlectroma~ttc btnary stgnal stgnature btnary Mer binary subtract btnary to decimal btmr etndtng bindtng head btnnacle btnocular Elnomfnal cwpms$on btoastronautic orbiting Spaes statton btochemica) oxygen demand blologfca) biological defense biological e)ectronlcs btolog~cal warfare t)tology biology 4cform) biparttng doors b{~st Qtrmtngham Wire Gage
bcrt
be bdc w blt bess en
Blt Bov
t)ESS BN as 8/D Bon em em 8NCL SNCLR SINOMEXP eoss 800 BIOL Blootf BIONICS au OIOL 010
bs
b/d
Blueprtnt board board foot fw=asu=) boatswain bobbtn body bared bolts body centered cubic
body centered tetragonal ~e:n botlwr botler boiler botler botler
8s78 e
rate tnch second BCR 8P I 8PS DITUN BLK OK mu n-u DES 81 SOFS W as Wc EKD OLKN BLKNG Bo
bits per efts per et tumtnous black (altn qbbr) black black qnd white black qnd white prints e18ck qnamel slate t Pon black black ott finish slate bleck g~r
blol efoQef biontcs w b{ot bto btpd bpt BWG bs tb b b8r bpf bps bttum blk ---MM b-w 08s BI bofs *
c~ass$s
feed fcowpound feed pww feed-water tank
botler
horsepowr house
(type)
bolt
bolt ctrcle
bolted bonnet
bolted
--
on base
8L tlIL 8S1 LT 07s 8P m FOM BOSN SOB me Bcc K-r 80C BLR m 8F~ BFP BFU BNP WI BOPRESS EWR 6*R BP 800 8P BF BOLS 8LT Bc fiLT 67 ao/Bs 8P 06
bfp bfw bh
bopress bowr b@cr m ~ bf bets Dlt bo Dlt bt ~~~s * be bbl blu bnf bs btf btd
ca~rlc
bs bvc
bkd blkn blkng bo
60U aL BLU
SNF Bs BTF BTD BM80R ltOMO s 6?6 BTO 00MST SND a BOC 80s (tC SS awz 9NOG BNLS 8NT eR Sc BFO
m
m8ti
-r
b 8?4S bto bores b bdc
-e~t th
dte
powder
bsmi BL bl SLK Blk b!kt BLKT bikg BLKG OLKGO blkgd SLSTG PWO blstg BL bl OLDR bldr beacon plug tracer system 8AOS 8UP 8LbT et-o BAES
am Bow BSNITN
pVd
~ =tng -trig ~tght bonchd ~ (tnsul) bonded double b~ double bonded stng}e bonded single bonderfze bonding
q pproach
load load
qnd qnd
boneless
bonrut book rack bookca8e
bla~
b!bt
bltti
bltnder
b)d
bookfom
drawtng
.-
ruL-sTD-12D 29 my 1981
TERM
bedclot boost roctmt
boostw booster engina cutoff bootstrap bor8scope borestght borocaresistor crown borosfltcato light borr~ both faces both sides both ways bottle bottm bottoa chord bottom dead center bottom face bottom layer bottom lead laft bottom lead right bottom plane bottomt rig boulevard boundary boundary layer contro)
ABBREVIATION
BKLT SST m Bstn BECO STS7 8s BRSIT BCR Itsc 8LT or 8s mu BTL BOT BC BDC DF 9L 8711 BTLR UP SOT* ULVD BOY SLC BBYCY 80 LT BDVG 800 SW LT OPLA BWSTRN 8XF DXDT BRC BRKt URO B ERO BW SK BMt!P 8RKaD BR
BRS 00s
TERM
breech ~nlsm brick bridge brfdge ~toff br \ dgehead
ABBREVIATION
BN mRK BRDG Bctl 8mFQ BRT SET . llRIL OH 8* 8R S70 SWG BTU 8RCH Sc ecx BRZ act t4RN OR 86 s OAHG 8AR 8NG BR Om+ t3U8MEM OKT 8UCK eFR BA B/m 8R BEF BFG BLDG BL BL7ZN BITE au OHO ON BOZR 8ULL BB BPRF acnG 8B BOL BUSS b brctg
bco brghd
brt brt brt 1 Oh ahn
tlsrdWSS m4uber
Stawdard Standard Wtre Gawt
Brttfsh Woach
theraal unit
broadcast broadcast tmterference tronz* breoa closet brown brwn (altn abbr) Ufre Gage Broun qnd Sharp q t=mft -Chtbrowtf~
botmg
blvd bdy blc bbycy bd It bdvg w It bpla wstm b%f bndt ! brace brk t
(gun ) bretming
~$ng brush
qutrntlc machtna
rffle gun
ion
ltght
bow dtvtng bow door ltght bow p}sne bowstrtng box fin boxcar detector brace bracket bra i e braid (insul ) bra i dad qrmor OraJded wire brake brake horsep~r q ffective brake man pressure brakeband brmm brsss dlvlder strtp Brass braze braz i qr brazing breach f ng qnd bread wrapping
brd b bu -
brkM
br
W%
brz braz brzg brhg bwasa b brk
mechfne
S-all r9
BRZ BRAZ SRZG BRHG SW 6 SM s 8RK BBM Bd BKDN 9KDN010 ev 8RKR BE BRKG %OA BON BPQ SRTH SRTMR BA BL
brush holder ~le memory bucket buckram buffer bu~fm a4pltfter Wffw -ttlplexer buffer regtstee follower buffered emttter bu$flng build~q butlatng ltns butlt-ffl butlt-fn test equtpment bulk [substrate) (electron -$C8J bulkhead bull nose bu 1 I*zer bul I@ttn board bulletln builotproof bunching bunchi~ block bundle buoy -Ssenger W40y Underuatsound signal
brh bkt
bfr ba b/m br bef bfg bldg bl blttn bite BU
bM
bn bdzr bull bb bprf bc~ m Ml bmss buss b bynt bu brlp bnr bnsh brnshr brstr brst str
UJss :YNT
au SRLP 8NR 8RNG itmtt 8RNSHR @RsTR BRST STR BSLR BT @TR BTR 6U esHG BUSH 9CT BPD
buoyancy buoyant
-au burlap bufmr burnfng burntstl bumtsher burs ter burstfng strength bus sc18ctor bus tte bus transfer bush transfer
breadth Or bemn Of ship Weak break before make break jaw breakdown break~ dtode voltage breakdown
breaker
breaker end break 1ng breakoff qltltude Oroakoff he{ght breakpu!so generator breathe
bslr bt
btr btr bu bshg ----
w98ther
breathing apparatus
ba
bl
bet
br-h
loadtng
-.
13
TERW
bustness busfness tnuut
output rerun but-live butane butcher butt ltne butterfly buttock line but tan button h~ad buttweld buzzer dtmenstons) by (betveen bypass ngin cab OVQF q Czbln cabinet cabl* cabl* duct cab18 fuzlng !flrtngl cable reed cable television cable termination equ~pment cabIing diagram cadmium plate cage calculate calculated qtrspeed cal fber cal {brate speed calibrated air length Calibrated focal calibrated magn{ftcation calibration cal tper call box station calorie cam box cam casa cam chair cam follower cam roller cam timing contact ca~r ca~ra camera control un~t camouflage cam cam Cha!r ca~ctce t camshaf t can cance 1 cancelled Pransmlssion candelabra candelabra prefoeused candelabra screv candle candlepower cantster canop ~ cantf lever canvas vlre rope canvas coverefl
TER34
capacitor capacitor Capacitor capacity caplllary Captllary d{ode start start gate
qnd
Ai3RREV14TION
CDG CAPST
run
Cdg
Btor b!
butn btcr
b? btfl el btn btnhd btwld buz :yp coo cab cab ca cd Cf
capacttor-d{ode
tube
logfc
qnd
bulb
Cb \rd eatv c te cad cd p) Cg talc Cas ca 1 ca 1 cas Cf 1 cm ca 1 clpr Cbs ca ? Cbx c-s cc
cmf 1r cmrlr Ctc cam camr Ccu camof Cp cc Cn@k t
memory
tape of gravity
CALC CAS CAL CAL CAS CF L CM CAL CLP@ Ce s CAL Cs x CMCS cc CNFLR CMRLR CTc
cm
caps t CAPST5R capst8r CDL CDL CAP cap CPLRY Cplry CPLRY T8B cplry t6b CAP cap CPPD cppd CPsN cpsn Cps I CPSL Cbd C80 cbn CBN cf r CFR e-s CMOS Cs Cs cbn tet CBN TET crbnt CRBNT CARB carb cat CAT carb CARB cd CD cpm CPM cram CRAM CD ROR cd rdr Ctt CTT car CAR Ccg CCG c1 CL cpn t r CPNTR CARP carp crg CRG carr CARR cur CARR CUR carr ce f CEF Cf CF Cfs CFS cin CIN COOAN CODAN COR Cs c/N c/w CRYG CRTOG CTN CRTG CAO Csc CAS Cs c?+ CPT CSG CASS Cos c c1 C2CND BOX clP Cs Cs CSTL CsTG CAS CAS W~ CAT CTLST CAT C8 CAT Cor Cs c/n c/w cryg crtog ctn crtg cad Csc cas Cs C?l Cp t CS9 cass eos c Ct
CAMR
Ccu
CAMOF CP cc CMPKT CNSHFT CM CANC CANTRAN CANO cPREF CAND SCR
co CP CST R
cartrtdge
cartr~dge qctivated cartrtdge stora~e cascade case case harden casmnt projected casing cassette cassette-operated +o~) cast (ccast Iron CaSt lrOn conduft cast iron pipe cast steel cast stone castellate devtce case
cmshf t
cn cane
transom
system
box
hendrall
cap Serw capab 1w capacitance capacitance capacitor cap scr Cpb 1 cap c cap cd
casting
castto castle nuf catalog catalyst catapult catch B*S n category
(co*
form)
capacitordtode
. .
MIL-STD-12D
29 my TERM cathode
C8tcathode (a form) folectron devfcw) follwwr follou8r mtxar ray dtrectlon finder
1981
ABBREV1ATION
CATH c K CE CFM CR CRDF Cfto CRT cath c K Cf Cfln er
TERhl
C8remtc glazed structural facf~ unfts cuamlc glazed structural unit base Ceramic glazed units q lement ceramic metal ceramic tfl* ceramic til~ base coraa{c tfle floor ceramic to amtal (seal) certify cesspool chafn Chain grat8 nge cha 11 q Ctla-r qbbr) ch~r (altn chamfer change qbbr) Chafyw (aItn change notic8 change order chsnge ovar change point change ~st changeable type plate Style ctmnne 1 channel entry channel shifter chapter chsracter character register characterist tc charge charge coupled device charger Cnass 1s check Cbft check coil check te~late checX valve c~er checkout qnd automatic checkout nmnitorlng chemicai chemical biological uunltions chemtcal biological radiological (warfare) chem{cal defense chemical Inlllfng chemtcal warfare chemically pure of drawers chest Ctl #W cntffoniur chiffonier locker chiffonier mirror chi 1 led ch~lled drinking water chilled drinking water r. turn chflled water chloracetophenone chloracetophenone Solutlon chloroptcrin chloropicrin stannic chloride choke Chokm Coil
ABBREVIATION
CGSFU CGSU6 CQJ CERMH CT Cm CTF CERPWT CERT Cgs f u
cathode
c8th0d. cathode catm
Crdf
cro cr t catlhd Ctwalk clkj clkg
CAlufo
CTWALK CLKU CLKG
cAfJt CAV
CLG CAVU CEL K :EM *-----CB CF CEM NORT CPL CPC CTR co CTRF CrM Cfs CL CLA CLB CVK CM Cn CF CG CPi.R CP CP Cs CT CTOC CNTBRO CTRG CGS CMPS CP C7L CCD CFC CLU co CPE CPU CTE cw CAMA CTC
---Cb
Cf
cm
mort
Cpl
Cpc ctr cd ctrf Cfln Cfs c1 Cla clb Cvk cm cb Cf Cg cplr w Cp Cs et Ctoc cntbrd ctrg Cgs Cws m Ct I Ccd Cfc C)u eo cpe Cpu cte Ctu CAMA CTC cntfg~ Cf cer
Cert w Ch E Cg CG Cha 1 C?+AL Cmr CHM8R ---CHAM8 Chain CHAM Chng -.-en CN eo co Chgov CHGov CP w er CR Ct-ps CT-PS CHAN ehan CHAN ENT than ent SEE BELOW SEE BELOW cnAP chap CHAR char chr CHR Chrs t CHRST Chg ccd CCD chgr CHGR Chas CHAS cm chkb mfKB
Ctlc
CKT Cv CM(R co CAM CHEM CEM C8R CMLDEF CN Cw CP cow CH c?+ CH LKR CH MIR CHLD COW CDWR CHU Cti CNS 12 ck t Cv chk r co cam them Cbm C8R cmldef cm Cw w cdur Ctl Cll Ctl Ikr ch mir chid call cdur Chu cn Cns ps nc Ch Chc
WFGL Cf
CER
I
Ic
ckak~hkt;
~L.srD-12D 29 WY 1981
.
TERM
ABBREVIATION
I ..
TERM
9mr8r=q8rmce qrray qsri rig Iwat Igvfs 1t~tor c1I tp cl I c11Ock puls= control c Iock pulsSd c Iockw I so c 10s0 c 1Ose Coupld c 10~0 packsupport c 1~s to shoulder c 10s. IOS- type control c1
ABB=VIATION cLnfJ
CLT CLV CLN CL CP CPC Cu CL cc CP Cs CT s CTCCC CIS XTV CLE CL CLAC CLO CL cc CLOS CLTffi CLOY cLST8B Cl eta Clrg Clt Clv cln Cltp Clk w Cw c! cc w Cts c tccc Cts Cctv clcl C18C Clo c1 cc Clus Clthg Cldy Clstbb Cl cltr Cg Clamtt Cltrm Clsc eoam crs c6h ch ctd clmt etg coax Cobcrm Cobb Cbshp Ckpt cin Cage coo t CPACS cCsp
-t
CRM Cn NOLY SEC BELOU CR VAN a4Rm cRPL CR-R CRNNTC CINE CA CIR CCT CKT C9 CKT 8KR CCA cut CL CD QCTF CI CN Cm OP CP CPs CRT CSNT cm Cr moty SEE DEW cf= van
Ctrcutt
Ctmult circuit Ctf-attt Cimutt Ctrcutt Clrcult Circuit circuit Ciuuit Ctl=cult etrcul t ctrcult ctrcult tapm
b~9S~k*~
Crp ~ crruntr ernmtc Clne 0s ctr Ott Ckt Cb ckt -r CG8 Ckt cl cd Cktf cl cm Ckt OP w Cps crt csmt
c~r~it
contact
Iose-tn support c1 Iosed cfrcult televtsfon c1 Iosed end c 1 ;1 Iosed I-P b pproach contro Iosed loop q , Ioset : Iostng coil : Iostng : 1osum . lothi~ . . 1Oudy . . luster bob . bomunft : luster : Iuteh . lutter . gate t Iutter ilutter lockai*E ~tng targat tndicator -P c:Iutt-r cma 1qsce cmad ng c~ame qnd hat hooks cmat cmat hook {:Oated metal f%ated Coatlq Coaxlat Chrcobmlt
Cnu
CL CLTR CG CL~I CLTRM CLSC CCIAN CRS Cllw (24 C70 Cm T cm COAX COBCRM COBS Casw CKPT cIf4 CAGC COBI CP Acs Come CSP coo COEF CP CORCN cofML COFF @ae bu u ~AR COL1OAR ~~ COHO ~SK q .***
ctrcuit efrcular
circular circular ci~18r cifCU18r etrcular Ctrcular ctmulate ut~iati~ ci ~
untt
Csu
CIRC CEA CEP CNIL CP CP CPE CRCLT CUP CRCNF Cn CVL CLP CLP INSUL CLP S= CLPR CLAR CL CLASS CLS CP CP CLN CFT CG LKR co FCQ CLR CAT CA cGSF(J CGSU8 CIL CLWG Cwc c * . ..**
Csu
Clrc cea eep cmi 1 w w Crclt crcmf co Cv 1 Clp clp tnsul CIp scr clpr ciar c1 class Cls Cp =P cln Cf t cg Ikr co
qrror qverage error probability Wtl pitch polarization probable er~r watw Pum
=r=nce
Ctttzens -Ctvtl Clm Claap tnsulatim clq scrw cl-r clartftcatiom c1 qss cJasslficaticlasslfy C18W pla-
cobblw
cobbler sCoctcpt t cods tdentificatfon nun@er ~ q utomattc gain centrol Cbtphase q ntlclutter cod.d pulse System ~ decoder coder s~ential pulse Codtng Cwffictent coefficient of perfomme c~rc t on COf?ee m{ll COff erdam c~tzant cohWmt array radar coher$nt light detect!on qnd rafwtq ~rent master oscillator cohermt amwusry filter coher$nt oscillator cohe~ent phase shift ~eYiW CO1l f$ntsh W*-** q ****
otl ta* cleant~ gear locker Cl@-t Clea=t flush Wfth f~n~shed floor c 1qar cltor ~r turtmlonce q perture clear clear giaz~ structural factng un{ts clear glaza structural unit base clear tndtcatt~ ltght clear wtr~ glass clear write condition clear; reset
..**Q ihiorne t--d
q
fco
clr Cat
Cor f
Ceg coar CO1 tdar cCmf Coho cpsk ef --
Ca
Cgsrd Cgsub Cfl Clwg c o
q
I
*
q
leather
CR
TAN L~R
~r tan lthr
16
A1311REIIATION
Cofl Cotn cold cold cold cold sketch
TER!ki
common-contr~l q rrangement conmuntcatlon comuntcatton terminator c~ntcatton ~dentlflcatton Conms.wilcatlons cowmunicatfons cowswnlcattons navtgatfon swttchtng
ARIHZEVIATION
CCSA cow COLT CNI CAD C&o CAN Cesa Cofms colt CNx cad ebd can c&t cape Comcln
d{~le
brino W*
cold drawn
drawn copper drawn steel ffnished steel cold finished I qg cola cold punched polled cold rolled st*el cold cold side cold water COI Iaboration co) )apse col Iar COI Iectlng CO1 lectfve Col lector collector (electron collector rtng collimator coIlofe cologartthm co 1or cwlor code column c-a t Information c-at c-at ready c~at vchlclc c~lnatiom Coablne Celned -ined dlstrlbut{on
Cs co C8PMP CD CDC Cos Cr CFS COLG CP CR CRS CSD .CM CULLAS COLPS CLR CLTG CLTV COLL c device CLRG COLIM COLL COLOG CLR cc CDL CBT CIC center CR Cv COU8 CM80 CM8D frame COF
COHWNniCat\OnS c~nicattons
conblning C-St~b!e
co-stton c-stor Colmand and service module eomtand Comwwnd control number cqJtsltion Comwand data q
CoMa
COM8L COMB ctUtSTR Csn CCN CDA CDR COT CM CP CPO CORAL COMO WC UNT
Cormnand destruct receiver e-and destruct transmitter command mowle Cwwlmnd pulse Cof!slland pulse output conmand radio ?Ink eomaand weapon carrier co-n t
conmercta I co~rctal projected ufndow cemrclal quaiity Standard Conwn?rctal coawnercial translator consntss~on Co!mtt cmmedl ty coaanon cmmnen ldiagraml cowsnon base common battery common bus!ness-oriented 1 qnguage Collwlofi col lector consnon control untt dtgltizer qnt tter mode reject ton steel lprojectlle)
qnd tele!mtry CAT CAPE qutomat!c processing equipment COMCM conwamtcatiws countermeasures qnd dec8ptton comamlcations electronics CE CEM coasfunications q lectronics Sleteorologicat COMINT Intelligence c~nicatfons COWAN comunfcations jamlng camunlcat~ons moon =Iay CMR CONWED cowswntcstlons need c~lcations network COW4ET COMSAT comuntcattons satell?te c~fcat{qns satelltte CSR relay Cs E Coasmmtcations support clement COMPOOL conwunicattons tag Pool communications zone CUZI indicator c~ity qntenna televtsfon CATV cOamUnity qutomatic exchange CAX o$ffce Cuo cowwunity dial CERFS c~ntty educational radio fixed service Cr)wm comutator CE cofmsJtator end COMP eoap8n 1on cmpany ::MPTR comparator C8 c~arator buffer CMPR conysare c? c-are (for referenci~) COMPT coqsrtment CSA c~artment qnd qccess CMPs Comsss . CPS CMPSG coapass co~nsattng CCSL conqatible current-stnk~ng
CE CEM comlnt Comj qm co-*ed comne t COMSAT Csf cse Cowpoe 1 Coz t ca tv C8X Cdo CERFS cm ce Cco coq3tr Cb cqr Cf cow t csa CUQS Cp% -Sg CCSL cssb
CCML
CPW CO
Ssngle Stdeband
qvalanche diode compensating c~sa tor c-i Icr c~tl-r ass~ler complement c~lementary metal-ox(do semiconductor c~lementary semiconductor controlled mrcttf~er cowmtemmtary transistor logic Cwl-ntary unijunct{on transistor conp18t8 c~lcte round c~loto round chart c~l-te w{th
comen
. cad Colrpsg Cofp COHQ
COMP
COMPASS CMPLM C$Kls CSCR CT L cum COMPL CR CRC c/w
conQ8ss
Cmlln
CMOS
CSCR CTL
CUJT
Cowp 1 er Crc c/w
17
ABBREVIATION
CXD Cs ck d -t Cb
TERM
condensate condensation trail condensw condition Ccmdftlon (altn qbbr) conditioned reflex Imachtne conditioned r~sponse q nalog (machine) con@et conducted emiss~on conducted susceptfbfiity Commctivity conductor co-tor (altn qbbr) co=tor (COform) co~tor head con@Jl t cone point ccnfor (compare) (for refermctng) conference conf~denttal confi~rst ton conft~ration ttem confine Cotlfltct conformance
ABBREVIATION CNos
CONTRAIL CONO COf4UTN COND COW L EX coRA Cnds contra f
co~orwnt component
c~onent component cqnent
Cond
CBA
ccc CID CID m
c~a
ccc Ciu etd no
cond tn
---conf 1qx Cora cndc t ce Cs Cndc t Cndc t ---c Ctl Cnd Cp Cf conf conf
Comnent
C?JOCT CE Cs
CNOCT CNDCT CONO c 04 CP CF CONF CmF CoNfIG CI cow CF L CONF CFS CFSN CONGR CONL COF CONSCAN CSORO CONd coWfRoo Cow CONN DXAG
cqad %%s
CPRS CONPA CACB CPRSN CPRSR ~NPR Cpross cprs co@pa cacb cprsn cprsr ---C* c~ander
Str
q ir
circu$t
Corlf g i
c1 eon f Cf 1 conf Cfs cfsn congr
CIMPAPQER
C:P
ctpCtt
potnt
contuse
confusion Congruent con I ca 1 conical fin contcal scan conical scan on receive conjunction connectfnq rod connect ton cwtnectton dtagram co~tor conning tower consecutive of consist
tnput
comptr cayit carp ~tr cad cad f Cado CAD cats caso Cdu cod i t Ci c- Opc CnQscty CA t CAN CMAC CAT n C1lq)tg Cncv Cnc 1 Cone cm trc ---Cf con Cone 1 Cone Ccb ccc cc f w csb cncr Cdm
con I Cof
conscan Csoro conj Connrod Corm
only
test
support
~OW! d$sg
cenn contwr consec c/o es 1 cons i m cns 1d Ccp crisp cons t ecop Ccg cm Cct cue 1 Cr AR Cls coa w csd constr cmstr Cdc Cj con spec censu I t cent c1 cma
CONN
CONTWR CONSEC Clo CSL CONSIM CNSLD CCP CNSP CONST CCOP CCG
~tpmmnt c~ter data word dtrect to telegraph Comuter ~ter indicator ~t~r ope~at~ electronic display Ce~ter process control ~t~r security Conq3utee-aided Instruct Ion c~ter-aided manufacture ~ter-automated measurement qnd control CORCXJt@r12Sd qxtal t~raphy tomography conputer~zed
Cx
COED CPC CMPSCTY CA1 CAM CAMAC CAT cl CMPTG CNcv CWL CONC CNCTRC CONC Cr %=1 CONC Cca ccc CCF CP CS8 CNCR CON
CCM
ccl CDEL cF AR CLS Co& CP CSD CO?iSTR CONSTR Coc CJ CON SPEC CONSULT CONT CL cm CMC
==lWtfv cmsv@ concea Ied concentrate concentric concentric Ia)tn qbbr) concept forwlatlon
concession conclusion concrete concrete block ooncrete cetltng concrete floor concrete pterc~ng Concr-te splash Concurrent
block
CNVM
Cmvm
18
ABBREVIATION
(%VI CNTOR COR Cos CNTO CNTNR CONTAM COST CONT CQNT NP cPAM CTW CDTY CONT CDNTD cow cm cow C8 Ccs CCNO COGS CR Cw CWAR CWFM CwI CUIF CONW Cv CtR CONTR CCN CORL
TERM
control shift registgr control stlctc ste=rtng contro 1 $Wf ten con tro 1 trmsmitter whewl steertng control con t ro I word controllable pttch propeller controllable radar tzrget slaulator controlled bllp scan control~ed carrier modulation controlled current f=edback transformer controlled rectlfler controller controls Sdisplays convection convector convenl*nce convention conventtona ? convergence conversion conv=rt converter convertible Convwx
ABBREVIATION
csr Css Cs Cx Cus cent CONT MO CPCH PROP cpch CRTS crts CSR
cpd
cntor eor Cos cntd cn t nr contain Cost cent cent hp cpam ctam Cdty cent contd cent cc?ik eont CD Ccs cCOGS cr Cu cuar cwfm owl Cv+(f con tw Cv etr con t r ccn Cdr 1 ce i CFAC con t ro eentr cfbt CF AE CFE CFP Ctrs contr~b cent ctrl eonta COnt Ckt ccr cdx Clj Cp Csw Cpt CROM Cr cr
contact or, rurm { ng contact or. starttng conta~ned containw contaminated contaminated 0~~ sett~in9 taw contmts Continental horsepower continental polar qlr mass continental trepical q tr ln*s s contfnous duty cent tnue con t I nued cont~nuad ~altn qbbr) cont~nuity check continuous continuous bl~ continuous cu-rcial Sorv 1C* continuous current monitoring d~v!ce Continuous OrbitaI Guidance system rod continuous
Contimous conti*OUs raaar wave wave ac~tsitlon
Css Cs Cx Cws
ud oroD
C8S CCM
CCFT CR CONT C$o WNVN CONVR CNvc cow CVNTL CONVG CVRSN CONV cow CONV Cvx CNVR CLRM COOL CLO CLR CLG Cf COORD msAL UTC COP cm
cm
ccm
Ccf t Cr con t c6d convn convr cnvc conv cvnt 1 convg cvrsn conv Conv conv Cvx cnvr Clrm coo 1 cld clr Clg Cf coorct cosa I UTC cop cna Cuo cop pl cof)d csmf th cd Cdut ccd cm Cs CS8 ese CT L Ck ek b ckbd Ck f c~r cor bd Ccu eorp corr crctd . cm corre cotar cedar corad eors I
conwyor
cool room coolant cooled cooler Cooltng cooltng fan coordinate
continuous wave frequewy modulated cantlnuous wave illuminator continuous wave # intermediate frequency contt-ous w~ndow conttnuousiy vartable contour Cent rac t contract change notice data requira-ts contract lfst contract qnd ftem contract furnis-d q trcraft equ f preen t contract~ng officer contractor contractor furnish and tnstal I
coordinated
CE I cFnE
CONTRO COfUTR CFbI CFAE cfE CFP CTRS Ct)NTR I B ~N7 CTRL CO?JT k CONT CKT CCR Cox CLd CP Csw cPT CROM CR
shtpboard qllowance ltst Coordfnsted untversal =PP=r qlloy copper nickel copp=r oxide copper plate c~rwd aoppersmlth cord Cordue I t
time
Cutl
COP PL COPO csMrm4 CD COW Cco CM CNo Cs CSD CSE CT L CK CKB CKBO CKF COR cgR %0
cont~actor q frcraft
contractor equipment contractor
fl~rnts~~
equlpnwmt furn~shed
proper contrast
ty
furmfs-
contribution control (ccmqutersl control control qssemly control cl~cuit cuntrol contactor control difformtial trmsfnfttar contro I jo{nt cent ro 1 pefnt power switch control control power transformer memory con t ro 1 reaa-on!y cent ro 1 rel ay control room
corner
corner bead coronary-care carporatton Correct untt
Ccu
CQRP CORR CRCTD CM CORRE COTAR COOAR cQRAO CORAL
corrected cowecttvt
correlate corrulattracking correlattun n81yZi~ correlation correlation
matntanatie orientation and ranging disp~ay qnd recording radar radfo link
CR
19
KIL-STD-12D 29 hy 1981
TERIM
Correspond Corros 1on corrosion resistant corrosfon resistant steel Corrostvo Corruga t q Corrugated fiberboard corrugated metal PIPO corrugated Wlra glass cosecant cosine. cost plus fixed fee cost plus Incenttve qnd fretgtlt cost . tnsuranco cotangent cottsr cotter pln cotton cotton !tnsul)
AB13REV1AT[ON
CURRES CRSN CRE Cms CRsv CORR CORR FBO :rG Csc Cos cPfF CPl cIf COT COT COT COT c COT WCS CT cT/M cT/s CMTR Ccm CENC CEMF c1 CRM Cv COAL C90RE CUOREO Ccu Ct)hILL CDRI LLO CF CFLG COIN CM Cnao corres crsn ere cros crsv Corr aorr fbd Cwg Csc Cos crw (ss c+{crftlcal crltfcal crftfcal
TERM
spacm )
A13JlREVlATJON CR er
CRP CRIT cm Crp Crlt
crlt!cal
Cpf t Cpt
Ctf cot cot cot cot c cot web et et/m et/s cntr CCN
COttOn Webbing
cCemf Ct
cm w Cba I chore cboreu Ccu cdrfll cdrlllo Cf Cflg coin m Cwo Cw
cwntemea
sures
countermeasures qnd qtlon horni ng eountermeasur=s. cwnterpot se counterpunch countcrsha ft countwsi nk countorsim other stcountersunk Countersunk hesd count~tght count y -1coupled -~-Ifng coursa deviation ~ndfeator cars-s Cevw
Cpsa
Cpunch ctshf t csk csko ctsk eskh
critfcal critical cross qrm cross brsctng cross connection cross country cross cwuple cress re+erence cross sect ton crossbar crossbar tandem Crossf f re crossha~r crosshead cross t ng crossover crosspoint crosstalk crow+ 00 t crown Cruising crushed stone cryogen 1c cryoto anc~llary untt cryptoanalys ts cryptography cryptography crystal crystal controlled oscillator crystal driver crystal oscillator crystal mcttfler crystsl unlto pfezoelectrlc crystal ?Ine -lC cubic centlmoter Cubic foot (feet) CUbtC foot (feet) per nt~te foot (f-t) oer second cubic CUbtC Inch -
CF:
CRITF CPM cPt XARM XBRA XCO* XCY cc XREF XSECT XDAR XBT CFR Xt4AIR CXSHO XING CRSVR XP7 XTALK CRFT CRN CRUIS CRSHO STN CRYOG CAU CRYPTA CTGH CRYPTO X7AL Cco CD XTLO CR w
edr Cf f
Crltf Cpt xarm xbra Xconn Xcy cc xref Xsect xbar xb t cfr Xha I r crshd Xfng crsvr Xp t xtalk crf t crown Cruts
crsM
cryog cau crypts Ctgh crypto
stn
xtal Cco
cd Xtlo Cr Cu crys t Cu cc Cu ft cfm Cfs cu fn cum cum cu Yd cub Cu]v cum
CRYST Cu
cc CU FT CFM
cimfc
met8r
CFS
CU IN CUM g: am CULV CE7 CUP CR8S0 CUR C8MU COB co CDR CLR CNOAC CML CM CR Cs IGEN CT CURT CRV
Ctwt
Cty Cpl -Id eplr Cplg cd f c Cov covers cow 1 Crdl crn CI crank erkc cp$n Cshaf t Crk Shv Cpt Ctg Cr
WL
CPLD CPLR
CPLG COI c
Cov COVERS ~WL CROL r CRK CRKC
coversed
sine
Cwllng cradle crano crane load crank Cf-*nkcas@ Crmkpifl cramshaft Cramsheave crash positton crating
tndicator
cubic m~lllmeter cubfc yard Cubicls culvert ~lative qlapsed ttme CuIulat{ve cupboard curbs t de current CUr~t b$t monitor Unft d8t8 btt current =P-t denstty current dtrectionsl relay current l~mitlng resistor current -de dtgltal to q nalog conve~ter current nsxte Iog)c current mode %ultchtng current relay current sertes current source current transfwmer
C8 t
crbsd cur
Cdb
cd cdr
Clr cmdac
cm
Cms
cr Cs t gen Ct cur t crv
c-t
Curtatn Cumm
20
TERM
cuwo drawing
ABHRESIATION
CRV
TERM
data tw-mlnal WIpment qquipment data transm~tt~ng Of btrth dstc of request date da ted ciatum daughterboard day day letter
AllRREVIATION
WG
Crv
dug
Csffi
cu~H CUST CUST CSR CLTH CUTS CTLRY co Cov co Cov C7R CTG CYN CY c ---Cs RDX CYCLO CYL CYLL CYL CYL CART CYLS @m Dc DmPu OPG 9P DK DP DART OAP D8UT OATACOM DCZB
customer signature
cut length cut stone cut 1qry
raqufred
cutoff cutoff Valve cutout cutout valve cutter cutting cyanide cycle cycle (CO* form) cycle per second (see para 4.7 - Hertz) cycle shift
cyclonite cyclotron cylinder cyllnder cylindrical aamage
damag8
Cshg tush Cust Cust Csr clth Cu ts ctlry co Cov co Cov Ctr Ctg cyn Cy c ---Cs rdx eye ! o Cy I Cyll Cy I cyl cart Cyls ~ -r %9 Ok * dart dap abut da t c= ectb
dt8
axe
aoo
dor dtd
da t
dtrbd @y dl . dl a~o Uvpp i el dl dr ara dro dr i dr t ertr tit deartg
aft
daylight
daylight opening daylfght view plan positton indicator dead light dead load dead reckon{ng q nalyzer dead reckoning dead reckoning cqutpment dead reckoning indtcator dead reckon~ng tracer dead reckontng tra~ner deadweight deaeratlng tleaerattng feed tank dea 1qr unft decade counting ctecaoe scaler Ueca?eoman ia Oecsnntng scuttle decarburtzatlon decay ttm decelerate Oecenber decibel decimal decimal count~ng un{t declnal to analog decision c ek deck drain valve deck edge deck edge ltght deck house deck pterclng deck surface light declutch decode decoder decompression decontamination decrease
lock
cylindrical cylindrical
cartrtdge surface
control danper dmrq i ng dawpproof~ng dark , dash pot Irelay) q nalysis recording tape d:ta data qutomation propr11 ttme data Base update data co$$wmnicat{ons data conwunicat~ons tnput buffer control untt data ler data control receiver data conversion data ttem aescrfptfon translator data ltne
Ku
aec da
decn dk ddv me de tt Ok hse * ds It dclu dcd ctcdr
OACON DCR
010
OLT (IL OLA DL S OLS OLTM > OMX OP OPM OPU DQM QUO DRT ORCOG ORDCN 0R6A OSR OS&R OSE OSblM Osc
dl t
dl
dla 0]s dls
dl Us
dl
dmgt doe a
OPM
decrement dedefwkm
deep deep dram deep scattering layer deep space instrwmentatton facllfty deep tank deep underwater measurtng aev f ce defective defense defense acqulsltfon radar
OA OECN OK DOV DKE OE LT OK HSE OP OS LT DCLU Ocf) DCOR OECOMPN OECONTN DECR OECRT DED o Do DSL OSIF OT DUNC OEF DIEF OAR 9FQEL OIA DEFT OTR IIEF OFL OEFL OF
decowg?n decontn
ctecr decrt detl d dd ds 1
OSIF dt
aunt
def def
dar dfdel d{a d8f t dtr
deferred dellvery
deficiency deffnlte deflnlte deftnftion deflating in tfme ttme qllowance
relay
Osu
010
oaf Iect
defletlon plate
dto
def df f *# 1 @
21
MIL-srD-12D 29 My 1981
TERM
Iector defogging de$ ros t
ABBREVIATION
DfTR OF DFR WR DG$FR DEGUSG DCMPS OCMPTR OGS IIGR 9EG DHMY OYHR 01 my m OL OAGC OAVC DRO1 OELE DEL OLVV ON DLX D?4GZ DUTZR df tr df
TER.M
design marg~n qvaluation design speclftcat{on designated ground zero
ABFIREVIATIC)N
OME OSPEC OGZ DES DES OWL FT&TW DPFT OPTW SPFT SPTW OE$TN OASTARD d%~ec dgz des des dul fthtw dpf
-f
defrost ing
degas tfiar degsuss \ ng degsusslng comass degausslng comuter degaussing system degreaso ~ree dehumld~fy dehydrator detcing delay delsy drtver delay Itne delayed qutomat!c ga{n cent ro I d81ayed qutomatic volume control delayed range on target
designation
dt?stgnator designed water line desk , eonbinatton flat-top qnd typewriter pedestal desk . double flat-top pedestal desk , double
typwrtter
desk, single pedestal flat-top desk . single pedestal typewriter destlnmtion destroyer antisubmarine transportable qrray
dlvy
dn dlx dnqz dmtzr ei dm * etr dmnrlzr demob -f *I dmstn dnt rd den
OEST OESTR FIR DRO DESTR OSUPHTR OTCH DET OP I OROP OROTO DREC DET DBB OBB OTT DETN OET OETN on F OET OVL OEV OEV HGT OHP OEV LG DEV WD OEV
OEV OEVN
des t destr
fir
dro des tr dSUphtr dtch de t epi drdp drdto Urec det -b att
detn det detn
DI DM
DP OTR DMNRLZR OENDB OENOO 00 F OML ONSTN ONTRO DEN ;;NS ONTL OAMLG OSCAPRS OEPT OEP OEP OEP INST OEPR OP DC DOI DKPG o OERIV 00M DER ORK OSLTR OESCR OESCP DP
dens+ ty
dental
df dens cintl darnlg dscaprs dep t dep dep tnst dept * dc dd 1 dkpg d der fv der drtc dsl tr descr
des cp * dam dsntz dsntz dscc dsgn den dl 1
dA f de t dv 1 ----V
hgt
developed
Indfcator
modulation
description descriptive
development deviate deviation devtatlon equal lzer devlatton indicator dev t Ce device uneer test dew point deuatertng diagnostic gona 1 dfq d { agram disgramanat ic dfal tlluminatton indicating dfal
dut @
deutrg
oLILw4
OLINOG OLOCK DP OIAL PHTH OIA oEic
pattern
matrix
descriptor attribute desensitize desensitlz]ng destccant design deY\gn bandwidth aest~ change nottce load ~+gn Ilmit
6AM
dlindg d Iock *
Qiai dta *C Phtn
OSGN
OBW 004 DLL
OP OMO
DPH DIAPH
*
@h d i qph
MIL-STD-12D 29 hy 1981
TERM
diaphragm gland dt azoprf nt Dick. ffX dfo lock CJ1O temlate dielectric dlmsel dl-s~l belt drive d~esml direct dt.s-l q Iectrtc dtmsel engine dl@S8] engine direct drfve dlosol engine reekJction dr i vd~esei mechanical d18Sel oil dtesel v-belt drive diothmolamiw diftw-nce dlf?*rmCa channel difference in depth of modulation dtfterential differential amplif~er diffarenttal bearing indicatur dlff-reritial generator differential phase shift keying differential pressure differential thermal q nalysis differential thermocouple vel tmeter differential time relay diffraction diffusi~ digit digitat d~gital biock ANO-OR gate digital cons?unications digital conversion receiver dtgltal counting unit digital data dig~tal data converter dfg{tal data ltnk dtgital data proc=ss~n9 equ t men t dfgltai data receiver dig~tai data termtnal ~ipment dtgftal O?fferenttal q nalyzer digital distributing unit d~gital encoder digits? microcircuit digttal mltibeam st8erf~ dfffereme digital phase
ABBREVIATION
Oao
TERM
Oigtttzmr
ABBREVIATION
DGTZR OIHY DIL OIL OIM OMR ONG 010 DCG ORTL 0s DTL O1OPT OIPX DIPLXR OPST)( DIR DACT DAS DIR CONN DCTL dgtzr dfhy df) dfl dim -r Ctng dlo dcg ORTL ds OTL dtopt dtpx dfplxr dpstk dir dact das d~r corm OCTL dc dcr vdc t Vdc Vacu 000 ddr 010 dle
OPR
m mx m
OIEL
OSL 0s0 00 OE
dglci dpr of dlx dt dtel ds I dd de deng ded der M do dvbd dea dlft dchan
dihydr.te df lute
dtluttorl dimension dtmer d~ntng dtoda dtode eap8cftor diode mfcrouave diode resistor Iogtc diode suttch dtode transistor dtoptmr dlplox
DED OER m 00 Ovao OEA oIFf DCW$N 00?4 OIfF DIFA 08 I OG OPSK OP t2TA OTVM DIFF TR OIFFR OIFFUS DGT OGTL OBAO
Iog\c
dlff d!fa -i
dfrect q cting direct acting steam d!rect connect direct coupled transistor fogtc current dir~t restorer d~rect current
OIGICDN OCR
Ocu 00 Ooc 00L 00PE DOR 00TE 00A ODU
DC OCR vDCT test vults direct current Voc voltS direct ~rrent working volts VOCU current direct 000 dtrect distance dialing 00R drive dtrect OID direct inward Utallng OLC direct ltft control OMA memory qccess dtrect OINA a~llffcation noise di~t 000 outward dialing dtrect DROS readout satelllte dtrect ORET reentry te~==trY dtrect 0VS7 view storage tube dfrect OVL voice l~ne direct DIR d~r8Ct~On OF direction finder DIR di~tfOnal DIR COUP directional coupler DIR FLT directional ft~ter DG dt~8Ct!Onal gyro ORCTY directly OIR d!rector QRCTY directory iJS8L disable OISASSM dlsaSs-le OISASSY dtsasse-ly OM dfscard message
dtr
dfr COUp
de 1% OIWS nPD ORR ORRL OTU OTV 017s OIA OAC Oac OTVC OVN 012A Ooc dtms drr drr 1 dtu dtv di ts ala dac dbc dtvc dvm dda
digttal
dtgital
digttal
dtsconnectlng discontinue
dtscrete four{er dfscr~mlnatton discriminator dismngaglng
di81t rlnslng
dev~ce
transform radar
dsp 1n disc ds
dd dsCOnt DFT dr dscrm dsenga dshr du dg
converter
digital
to btnary converter
digital transm~sston and Wcrtflcation converter digttal volt~ter q nalog dtgttally directed digitally d!rected control
unit system
Osu
dos
23
.
ABBREVIATION
DISM dfsm
TERM
double qnode zene? diode double based sol~d propellant double biased (relay) double bottom double bratd (tr?sul) double break doublo channel *lex double contact double cotton [insul) double cotton doubl~ s{lk ( fnsul ) dWb]W COttOO Sf~le Silk [tnsul) XIe cotton varntsh (tnsul) double diamond double ena~l (tnsul) double end double extra strong doubls face doubt. feeder doubIe fre~ency Shtft keying double glass (fnsu]) double groove [Insul) double dwble groove p*tticoat finsull
ABBREVIATION
DAZO 08SP DB Dlt DB 00 DCD DC Dc DCDS Dcs DCV 00 DE DE XX STR OBLF OF OF SK 00 OG OGOP OHo ONW OLD DP SOP OPOC OPC w twec DPf)T
OPOT Sw
dazd
DISP 015P
OZSP
OSPNSG DISPL DSPL DhC D(kat DAS 0s7 DsPt OISPN of DISLVO 00 DIST ONE
display
Utsplay
Utspl*y
~fsplay
atSpass I
dfsposftlon @s*tpatlon factor * Sso 1Ved ~lssolved oxygen ~1 stance distance measurlna -.. eaulmment 81 stant Utstant early warning dfstfll dtsttl)ate C!!stilled water dtsttngulstl distortion Ulstortton eliminating voltage regulator dt stress distribute Ckt=tr!bUted emission ~tron a~!t~ier cttstrlbution Utstrtbutfon q~ltfier d~strtbution box distribution panel distributor dtstrtct dt ther
VIST DCU
OSTL OSTLT Dw DISTING 01 STN OEVR DTRS DISTR DEMA OISTR DAMP 08 OPNL OISTR 01S7 OTER 00 OVR
d-
alter
do dv r div
* dpbc dpdt
dpdt dpfc dpst dpst SW
OIV OIV
OTPB Dzv OCKG DOC OAC ONA 0(3 OLY 0s DWL OR OCL DST Osw DPLR 007 mpLoc 00RAN DDVAP 08L o
o
div d tpb
div dnu dck g doe dac dna dg Ctty dofn ds dul dr eel es t dsw *lr ddt dop 1oc *ran dovap -1 d d
OPFC DPST OPST Sw OP Sw OPL OPO OPR OSCT DSE 0s DSV 0ss8 OSPM or OULW 0WLF60 Ow D8LR or OVTL owl, UN DNDFT 0s O(3Z OFT 0s O?TG
Sw
code
ally
donmstic domestic service domfnent wavelength door *or closer door stop door suttch ~ler doppl-r data translator ~ler phase lock +ler rmge snd navigation doppler velocity and posftion ~le double (con@ form) double ffnsul) -b)e qcetate (insul) q cting -le q cting door ale q cttng steam ~le
draft
dovtnspou t
dl dbl act
dad
dozen
draft draft stop draft~ng
dastm
es df tg
24
MIL-STD-12D 29 h@y1981
TER.M
dmftlng machine drattlng request Uruftlng mom mmual draf tsman dra f n dra~n (electron device] dra{n tfle @ram draw out drawbar horsepower dra-ar pull drawer draw t ng drawing change notice drawing change request drawtng list erawing practice drawn drwtger dressed f Iutier) dP.SSed qnd matched dresser dr8ssing drift drt~t angle drtll drill jig artll plate drill rod drinkfng fountain dr i pproof drtpproet and rat proof dripproof open drlpproof protected dr~~raof semt-enclosed drippreof totally qnclosed drfptank drive ertve end Urtve fit drtve unit drfver drone fatrcraft) drop forge drsp hamr die drop manhole drOp wtre drop wood sid{ng drum read driver drum storage unit drum ttmtng pulse drum write driver dry battery
ABBREVIATION
Omxlt OR
TER,M
*1 Icate dist and mlsture -St ttgflt ~tch door duty duty cycle dwelllng
ABBREVIATION
OUP
DUM
DFTSMN OR o DT OR 00 DBI+P OBP DWR OWG OCN OCR DL ORPR , OWN DRGR ORS DbM ORSR DRSG OFT DA DR Obl DP OR OF OP
UJMR
DT 00 OY DTY CY. UWEL DYN OYB DCFEM Dol. OYNMT OYN OYNMT OYNN EA EF EL Ew EWR ELS Esv E ED AS8 EC: EGO ECH ER Es ECON ECON ECL EC EO
dt Ud
duty dty Cy
dynamic
dynamtc brak{ng crossed field dynamic q lectron multtpllcat~on dynamic octal lead dynaml te dynamo dynmmmeter dynamotor each each face qach layer each way q arly warning radar earth IandJfy system qarth Satellttm vehicle east q qsbestos eccentric eccentric orbit geophysical observatory echelon echo rang~ng echo soundtngeconomt ze econom t zer eddy current loss edge connector edge distance q dge of cutter edge thickness x% ~ca t i on educational television educator *C tor qffect qffective qffective diameter of objecttvo qffective focal length qffective horsepower qffoctlve radiated power airspeed eff=tfve t~e efficiency effluent ejactlon qjectton seat tlnm elapsed time code generator tifm indicator elapsed elasttc qlastic limit elasticity elbow electrlc q lectric dyna~ter q lectric horsepower q lectrlc motor driven q lectrfc panel q lectric power qnd distrfbutten power distribution I q leCtF~C
dwe 1 dyn
dyb dc fqm do 1 dynmt dyn dynmt dynm ea
dwg
dcn dcr
dl
ef el qw ewr
ELS esv c eb qsb EGO ecfl er es econ econ ec 1 U qel WC et ed educ etv educ educ ef t qf f edo ef 1 ehp erp etas qf f ef 1 qjn ejn st qjctr et ETCG eti qlas el elas elb elec edynm t qhp w W6d -d
OPRP
OPO OPP OPS
OPT
ORTA OR
EOC ET
EDGW EO EDUC ETV EOUC Ewc EFT EFF Eoo EFL EHP ERP ETAS EFF EFL EdN EdN ST EdCTR ET ETCG ET I ELAS EL ELAS ELB ELEC
OE OF ORU ORVR Q OF
Q
dt dhd dmh dw dws drd
dry bulb dry chemical dry pipe valve drydock dry fng
dua I dua 1 du81 dLfa 1 dua 1 diversity inline purpose comparator package
speed dr{ve
ttres tone mlttfrequency type blac& f{nish slate uaf ter waf ter door
*al Wet
dull **
*-1
DW Ows DRO Osu (ITP Quo OP D8 OCMEM OPV 00 DYG Dc?c DIP OP 0s0 DT DTMF OCTP D8FS DW Owo Ow OMPG ox OPLXR
dsu dtp
dwd * db dchem av dd
qjector qlapsed
EDYNMT
EHP EMO EP EP&D EPD
ABBREVIATION
EPS EPU EWC ELEC ELCTC ELCTC8R ELCTRG EDM EDT EMT ER TEMP ESPEC ET ETSQ ELV EP eps ewc elec elctc q lctcbr elctrg qdt emt er telW3 qspec et etsq elv ep
TERM
q lectronic control q Iectrontc counter counterfmasures electronic countermeasures q lectronic cwntemeasures env f reman t qlectrenlc countermeasures program qlectronic data gathering w i pment q lectrentc Uata processing q lectronic data processing ~lpnumt electronic differential analyzer electronic dtgttal analyzer qlectronic dtgltal tracking qnd ranging electron~c funds transfer qlectronic glide S10f3e electronic intelligence electronic interface qlectronic ja-lng .Iectronic mtssile q c~ls!tton q loctrontc order of battle electronic pos!tion Indfcator electronic private branch q xchange electronic reconnaissance electronic securfty qlectronic salective switching unit electronic sky screen ~tpment electronic standard electnmic switching electronic Swftching system electronic voltmeter q lectronic voltohfmnwter electronic warfare electronically alterable read-only nmmory @$ectron!cally steerable qrray radar e]ectrentcally steerable phased qrray radar electron~cs electroplate electropneumatlc electrostatic clectrostattc focustng q Iectrostattc storage tube electrostatic transistorized voltmeter electrostat~c units el~t elementary elafmnts of Oata slevate elevatlon elevator alfg{ble q l fmtnate qlltptlcal qlliptical head qlongate qlongation embedded wfrlng board e-ss efwrgency
q
ABBREVIATION
ELECTC ECCN ECM ECW ECMP EDGE EDP EDPE EOFA EOA EDITAR EFT EGS ELINT El Ed EMA Eo% EP1 EP8X ER ELSEC ESSU ELSSE EslD Es ESS EVM EVOM EW EAROM ESAR ESPAR ELEX EPL ELPNEU ES ESF EST ETVM ESu ELEM ELEM EOD ELEV EL ELEV EOP
@l@ctc
ECU ECU ECME ECMP
edfa qda qdl tar EFT egs elfnt qt ej ems apt EPBX er es) ec es su
esg
eolm qcg
ecg
ecdc SEE 9ELOW ELC7D EEQ EEG EED EGD ELHYO EL ELFC ELPC ELCTLT ELCTLT EM EMC EMINT EMI EMP E14Q EMR EMS EFW EWASER SEE BELOW elctd eeg q eg eect qd q ) hyd ql
qlectromncepha Iograph
q lectroexploslve
q lectroluminescent electroluminescent ferroelectric cell qlectroluminescent tve photoconduet el~trolyte qlectrolytic q)=tromagnet ~c electromagnetic ~attt3i1tty fntelltgence e?-romagnetle Interference electromagnetic electroma~et Ic pu I se quiet electromagnet~c electromagnet \c radiatton surveillance s!ectromagnetic uni ts qlectromagnetic e?ectromagnetlc wave awl by Stimulated emlssfon of -dtatfon q lectromechanl cal *lectromotiv@ force q lectron q lectron (n)-type s-iconductor materfal q lectron beam paramtrtc 8npllfler qlectron bombardment Induced conduct~vfty electron Coupled oscillator q lectmm paramagnsttc resonance q lectron sptn resonance q lectron stream potenttal electronic qlectmntc qutomatfc qxchange &/-t~niC CheCkOUt
elfc
qlPC
e}ctlt. q lctlt em emc emtnt emi
emfems
waser
q l=h emf elctrn n ebpa
ELMCH EMF ELCTRN N E8PA EBIC Eco EPR ESR ESP ELEK EN( ECO
q
esu
qlem q !em qod el*v el qlev elfg q l~m qlp elph qlng e 1ong
ebtc eco
epr
ELIG
ELIM ELP ELPH ELNG ELONG cue EMB EMER ..**
q
esr
esp elek eax eco **== o****
emer .*
*****
clccc:ochemiscry
ELECTROCHEM
electrochem
26
MIL-STS)-12D
.
TERM
Coolant System C-rgency coordinator -rgency decelerating mrgency (ralay) identification mrgency ltght power emergency power package qmrgency mrgency power supply power wft emergency room emergency snip service ewnwgency unsatisfactory emergency report emtssion emlttcr emttter ielectron device} qmitter coupled Iogtc emitter follower emttter-coupleci currant-steered logtc enpennage installation eq3 I qcenwmt qnd test enp 1oyee ewulator emlsion enable q ns1 ens-l I \nsul I enamel bended double cotton sflk finsul) ens-l bonded single cotton (insull enamel bonded stng)e silk (Insult enamel dwble cotton ( insul qnamel double cotton varnish I insul ) enamel double paper bonded (tnsull enamel double silk finsul) ena~l double silk varnish ( tnsul ) =namel slnale cotton ~ Insul qnaml sin~le cotton varnism { insul I bunded enamel single paper (tnsul) enamel single silk flnsul) enamel Single silk varnish ( insul ) encapsulate encased enciphered facsimtle conswnlcat tons enclose enclosure encode encodar qnd cell switch qnd half end ttem end of address end of line block end of message qd of message sequence qnd of part qnd of tape
ABBREVIATION
Ecs Ec EQE
CIO EPWR CT Ecs
TERM
and of tape pulse qnd of transmtsston (coqnaters) qd to end tangent screw endless qnde tone
ABBREVIATION
EOT PULSE EOT ETOE ETS ESTN ENRGZ ENGY EVSO ENGA ENGA ENG ED ENTC EO EOR
EPO ENG RM
ec
q td
qot eot
pulse
It
epvr
-P enps epu CR ESS eur
q msn emtr E ECL qf ECCSL
energ 1ze
qnergy qnergy vartant sementia detect ton engags engagfng engine engine drtve engine negative torque cent ro 1 engtno 011 engine order engine peopeI1er order engine room mgtne v-belt eng 1neer e~ineer furnish qnd {nstall engineering q ngtneerlng change notice q mgtneerfng change order engineering change proposal engineering change request qngtneerlng change request/ quthortzatlon data depository q ngtneer~ng enginewing department sketch ffeld change q nginwring Installation q ngineering engfneertng memof=anam engineering notice order q ngineering practice engtneerlng release notice qtneering release record engtneertng engineering sketch support aetlvlty q nglneertng work. order eng!neer+ng Engl Ish q ngrave en I qrge rged en I q enltsted men enter entrance ewmeratlon env~ I ope envalope drawing environment qnvtronmntal epltaxlal mesa epttaxlal planar e-a \ qbbr) eqUa! {altn ecual sectfon aqua ! t zer equally ecpally spaced equally spaced [altn abbrl SquatIon q ~llfbrfum q qufp qnd {nstall q cpfpage category numer q ~tpment ~l~nt and spare parts condttlon analysfs qfpment
EPP EMPS EPU & EUR EMSN EMTR E CCL ~F ECCSL 6MP
80 z eng m engv
engr efbf engrg een eco ecp ecr ecra add ad Sk efc et em en eo * ern q rr 8Sk ESA ewo Eng qngrv enlg enlgd qm qntr entr qnum env ed qnv { r env 1r em w eql --Qqs eq I eq I eql sp ---8q equtl e$ i ecn q -t 86 sp eca ..
E16T
EMPL EMU EMUL ENt3L CNAM E EBDC EBOS EBC
Et4GV ENGR EF&I ENGRG ECN ECt? ECP ECR ECRA EOD ED SK EFC El EM EN EO EP ERN ERR ESK ESA EWO ENG ENGRV ENi.G ENLGO EM ENTR ENTR ENUM ENV ED ENVIR ENVIR EM EP EQ1. EO Es EQL EQL EOL SP EQ SP EO EQUIL E&I
ebds ebc
ebs edc edcv
EBS
) EDC EDCV EBDP EDS EDSV ) Ec ECV EOP Es Esv ENCAP ENCSD CIFAX ENCL E=!. ENCO ENCOR Ec Sw EHF EI EoA EDL8 EOM EDMS EOP EOT
qs q sv
encap
encsd c~fax
qnc I qnc 1
ence
qop 80 t
ECN EoPT
E6SP ECA
ABHREVIAT103J
Ec
TERM
expanded direct
distance alalfng expanded mtal qxpanded posttlon tndleator q xpamled radar service q xpsndad swaep generator q xpanslon expansion joint q pproach clearance qxPected q xpedl te expendabi 1 fty. recoverabt I \ ty, reparabil ity cost expendable qxpendt ture qxpense qxper I men t qxperimental expe~lmental order experimental testing (atrcraft) explanation exp I ode qxplosion exploston proof qxplosive actuated lfght 8%p10Slve filter explosfve d ordnance disposal explosive exponent exponentla 1 q xposed exposure qxpress expulston qxtended range ball tstic misstle qxtended range doppler
ARFIREViATION
Ewo CM EPI ERS ESG EXP EXP JT EAC EXPEO ERRC
moo
EIC I@U!v EAS EDR EFL EFC ENSI ENT ESR -. ESHP EPROM eas ERCG ERECT ERCR ERR ERRC Ecc ED EDAC EOOF ESCL ESC Esc ESP C$?4TL ESTB tsT ECO ETA ETD E7R ETC ETCH Eo EVAC EVAC EVAL EVLTN EVAP EVAP EVRLK EXAM EX Exc EXC EXC EXCSV Excn EXC EXCTR EXCL EXCL EXEC EXEC EXER EXl+ EGT EPR
qe q lc
q qutv
qas qdr qf 1 q fc
em
apt
q rs q*g qxp exp qac
jt
ens I
qn t q sr
exped
q rre
eshp eprtxn
q rs
qrcg
q rect q rer
err errc Ecc ad edac eddt esc 1 esc 8SC qsp esnt 1 estb q st qcd
EXPEN EXPND ExP txP EXP EXPO x EXPL EXPLD EXPLM EP XPL ELF XPLD EOO EXPNT
EXPNT
w Xp 1 elf xpld
qod
eta q td
q tr etc etch eo qvac evac qval qv I tn ev qp evap svrlk q xam ex exe q xc care excsv exch exc exctr 8XC I exc 1 exec exec exer q Xh egt epr q xhv exh exst egv EBcnIc
EXP EXPSR EXP ExP ERBM EXTRADOP EXTND EXT 6X7 EXT EPT EXT EXT EX EC WIRE EF XHVY EHV XLW8 XSTR EVA EXTG EXTR XWAVE EXT14 EHW ELW EP EUV EHF ELF EX70 EXTR EXTRN ETDT ETT EGRO
mcept
excessive exctla~ q xei tat ion exci ter exclude exclustv8 execute executive exercfse q xhaus t q xhaust gas te~erature exhaust pressure ratio mhaust vent @xhtb(t extsttng exft guide vane
extractor
q xtraordinary
q xtreme
wave
EXHV EXt4
EXST CGV EBCDIC code
expanded bfnary-coded
etmal
~nterchange
extreme high water extreme low water extreme pressure extreme u!travtolet q xtrmmely htgh frequency q xtremely low frequency q xtrude qbbr) extrude (altn extruston qnd drtl! extmston trim tewplate qxtruslon trtm template qy8 ward qyo lens
ex t ept qx t qx t qx qc wire ef Xhvy qhv Xlwa Xstr qv a qxtg qxtr xuave q xtm ehw q lw qp euv ehf elf extol ---q xtrn etdt ett
EL
egrd ql
28
MIL-STD-12D 29 -y 1981
TER ,M
9yooot eyep48ce fatmtcate fnc8 centered cubfc tacc or field of drawtng face to face width face faceplate faclltty factng facslmtle factor factory factual co~iler fad-d prier to intercept failure faflure factor fa~luret rate fafrfng fafrlead fairwater planes false alarm rate familiar fan In fan marker fan out far sise qutomatic ga~n control fast qutomattc snuttle fast transfer fast Fourier transform fast operate {relay) fast release (relay) fast ttme constant fastener fathom faul t favorable fealor
AIIFIREVIATION
EYLT EYPC f aa eylt eypc f ab fcc f/e ftof fw fp facfl f Cg fax f ac fcty fact fpi flr ff fr fatr fld fwpln f qr f am fni ffu f no fs f qgc fast FFT fo fr f tc fstnr fm flt f qv felr fsbt f tr fee fed fII FIIG FIIN FS F S?4 FSCIL FSC FSCM fd fdw fwp fak fml fp fpot f br
TERM
fermle contact fiber f f berboard fiberboard corrugated doubie wal fiberboard
AFIBREVJATION
?ER CON F8R
FBaBo
FBDC FDWL F%DS FBRS FLD FAC % FOI FOE FET FESE FFL fFO FFI FFEC FI FM FP FR FS FSMUO FSM FSR FSE FSbI FWK F FIG F!L FCT FG FC FF FLR FIL FILL FIL FILH FLMPRS F LMSD FLTR FL FS FA FLOG FLF F LH FLL FLR FLU
Fcc
f/D FTOf fw FP FACIL FCG FAX F AC FCTY F ACT FPI fLR FF FR FAIR FLD FWPt.N FAR F AH FNI FM FNO FS F AGC FAST FFT ro FR FTC FSTNR FM fLT FAV FELR FS8L FTR FEB FED FIX FIIG FIIN FS FSN FSCIL FSC FSCM Fo FDU FWP FDBK FML FP FPOT FBR Fs FOR FELR F EM FFL FPT FS FTHRO FC
fse fSw fw f
ftg ffl fct fg
fc
ff flr fll fill ffl fi!h f 1nqws f lmsd fltr f!
feasible
feather February Federa I Federal Federal Gutde F@deral
Item Item
ldentfffcat~on !dentlf~cation
Identlffcation Item Nu*er Federal Speclfleation stock Nu*er Federal Federal supply Catalog
fs fa
fldo
Identtflcation List Fed.raI Supply Class Federal supply Code for Manufacturers feed feed water feed water Purim f~ack Peemack wltiple loop feedback post ttve f wack potentiometer f eedbacic resistance f ~aek stabilized feeder
flf
flh fll f)r flu fln fn f dr fgd f gP f nSh
----
FIN
FN FOR FGD FGR FNSH
FIN fAO Ffs
fs f dr
felr fem ffl fpt fs f thrd fc
feeler female
female femala f~le female ferrtto flared pip8 thread
no
f qo fls fnsh fs
spec
soldered
thread corm
f2s
f
fa81
FAOL
29
KIL-STD-12D
29 *Y 1981
TERM
firs ftro fir.
q larm box qnd bil~ qnd flushlng
ABBREI:IATION
FAUX F&% f&F FC FC FCR FCS FOC f t)c FDR FEXT FF fH FHC FHR FHY FLORA FM FPL FRES F RM FS Fw FSCK FIR fP fPRF FEI FS FFP F A8 FAR FACI IRED fSTG FIFO FY FPPR FSSN FTO FTG FXO FA7R FXP FTR FXTR FLGSTF FLGSTN FLM FLM RES FIM S10 FLMPRF FLMTT FLM8 FLG FD FLPR FLRO FTF FTFGS FLRG fL/W FL FLHLS FNN FLT FL FB FFILH f 8DX
TERM
flat flat flat flat flat flat flat flat flat head (altn abbr) nose (projectile) OVDI pattern point tllm roof trlfn tewplate washer work
ABBREVIATION
FH FN FO
F/P
---fn fo f /#a fp ftr ftt flu fluk f fln f bm flex f tm flex flt FCRLS fliden f dr
fab
f~f fc fc f cr FCS f 8C f de f dr fext ff
fh
clay flro control fire centro? radar Fire Control System ftre department connection fire direct!on center ffre door qxtinguisher fire fight!ng fire fire hose hose cabinet f~re hose rack fire hydrant ftra ftre Iocatlon raear main fire plug f!re res~stant fire fire room fire station wall ftre f trebrlck f i red fireplace fireproof error Incttcator ftrtng firing set f$xed price firm q {d box first first alarm register q rt)cle configuration first
fire
armor
FP FTR FTT F LW f LWK F F LN F BM fLEX FTM FLEX FLT FCRLS FLIOEN FDR F LDK FOAL FLT PLN FLSP FLTL F FF fFC FFL FLT fLTG FLOCOM FMS FIS FL F LONG FLDT FL FD FL FLG FLOT FL FLL FLRT FLSW FL FDfL FCPL FLKO F LUOR FPI FLR? fL FA8UN FMT F(JVM FT FLTP Fv f LMT FL fLTD f LIJSOC FLUSOCH F LUT
fhc . fW f hy t lora fm fpl f res t rm fs fw f eck f!r fp fprf fei fs ffp f ab far FACI 1red lstg flFO fy fppr fssn f td f tg
impection
ftrst reduction first stage f{rst-~n-f~rst-out fiscal year f Ishpaker f~ssion ftttcd fitting fixed fixed auto transformer fixed point transom ftxed f t xture flagstaff flagstone flame flare resistant flame retardant flameproof flamet{ght flamab]e f 1qnge flange focal distance f 1 qpper f Iared flared tube f~tt!ng tube fitting gasket flared seal flaring flash welding f lashing flashless flashless nonhygrescopic flashllgt?t flat flat bar fiat ffllister head flat head
flatten fleet b811fsttc missile flexlble flexiblm theatre misslIe f 1 qxure fllght Flight Contro? Ready Light system flfght data qntry fllgnt Oata recorder fltght deck qnd fllgnt clirector q ltftude Ind$cator flight plan flight space fllghtline fljnt flip fIoP fltp flop covlementary flip flop latah float flaat!ng flomttng cowwu4ator floatlq machine shoP flaatlng-pofnt Instruction set flood (vent) ftaodtng
fldc
fuat flt p)n flsp fltl f ff ffc ffl flt fltg f 1Ocom f nls
fts
fl f 1dng fldt fl fe fl flg flot fl fll flrt flsw fl fdfl fdpl flkd f Iuor fpl
f xd
fatr f Xp ftr fxtr flgstf flgstn flm flm res flm rtd f l~rf fimtt flm flg fd flpr f?rd ftf ftfgs flrg fllw fl flhls f nh flt fl fb ff{lh flh
f)ry
fl f qm fmt fovh ft fltp fv f Ilnt fl fltd f I Usoc f lusoch flut
flush valve flushmount flute lead fluted fluted socket fluted socket head
f Iutter
fU+
30
MIL-STD-12D 29 ?lay1981
TERM
flux )ogtc element array flwx valve flYtng spot dtgitizer ?Iywo!ght flywheel fO~ liqu~d focal focal length f Ocus and focus projection
ABBREV1ATION
FLEA Fv F so FLYWT fLYUHL FOLQ Foc FL FOC FPS FCSG FOFM FOSGEN FGY FLOG FFAR FO FOL FLUP FF FDSVC FT FPM FPS FSU FT LB FPS ---FTG FL EG FOUO FYIG F FF FA FD fD8 FOA FSA FP FCST Fso FCSLE FGN FS FMAN FS FGD FST FORG FK FKU FB7 FECP FORM FML FRMR FORM FORTRAN FTN fwo FAR F AC FET FER FLIR FP flea fv f sd flyvt flywhl folq f Oc fl f Oc f ps fcsg fofm f osgen f gy flag
TERM
forward propagation tropospheric scatter
forward propogatlon ionospheric scatter found foundation foundry four conductor four dimensional four pole four pole douole throw Swt tctl throw four pole single
AB~REVIATION
FPT$ FP[S FO F ON FORY 4/c 40 4P 4PDT SW 4PST SW fpts fpis fd f dn f dry 4/c 4d 4p 4pdt 4pst
scanning
focusing fog foam fog ot 1 smoke f Oggy generator
SW Sw
Swt ten
four pole switch four way tour wtre four-stage fourth stage foyer 4P SU 4uay 4W 4STG 4STG TOY FRAC FDG FHP FRAG FR FSW FRUU FRAUO FAT FA FCB F RHGT FMS Foe FREEED FRZ FRZR fP FRT FS FR FY FREQ F FATOL FAS7AR FAI FBOE FREQ CHG FREQ CONV Fo FOR FD FOOL FOM F08LR FREQ INO FIC FREQM FMCti F?4R FMR FW FM FMFB FMFM 4p SW 4way 4W 4stg 4stg f Oy frac f dg f hP f rag fr f Sw frwk fraud fat fa fcb frhgt fms fob f reebd f rz f rzr fp frt fs r? fy f req f
rocket
ffar fo
fol
f I+@
ff fdsvc +t
fpm f ps
per mtnute (feet) per second board measure pound force pound second (system]
footcandle (see para 4.7 cande 1a ) foottng footla-ert example for for official use only for your information and ~ i dance
fbm ft lb FPS ---f tg fl eg f Ouo fyig f ff fa fd fdb foa fba fp fcst fsd fcsle f gn fs frnan fs f gd
word
blower forced oil and air and aft fore fore peak forecast forecast support date forecastle foreign fore~gn serv~ce foreman foresight f Orged forged ste=l forgtng fOrk forked form block tewlate q ngineering chanoe formal propos a f formatlotl Formel l!nsul) former formla fo~la translation forttficatien forward fo~ard acquis!t{on radar forward q tr controller ballast tank forward forward engine room forward Iooktng infrared foruard perpendicular
fraudulent free alr tewerature aperture free Brass free cutting free height free machining steel free on, board freeboard f rmeze freezer freezing potnt fretght frefght supply Ivesse)) frenctt fry f recpmncy f~enoy Ica form) qnd ttme d~vislon freWefICy Itnk q ngle scanning, frequency qnd ranging tracking
fatdl
fastar fat f boe
Intensity
emission
freq ci-ig
freq fd c Onv
fst
f org fk fkd fbt f ecp f Orm fin? frmr f Orm FORTRAN f tn f wd
f dr
fa
nd
interference
far
f ac fbt f er fl!r fp
fm*m
frequency
31
ARIIREVIATiON
FM(W F*M FM ?07 FPt, FSR fs f SK FST rscx FSP fmop fapm flm fot tpl f sr fs f Sk fst fscl f ps ftl ft f td fat fw fwdct fup frtct fhp f rng fg fr fr bel
TERM
full Sfzw full voltage full WOV8 full wave rectlffer qwcres full-load fully qutoaattc c-fler transistor fully heat treated fume tight function functional confl~ration audi t functional conf~~ration Identtficatton q lectronic block functional functional schematic functional test functional test requirement fundamental fungus preof funnel furlong f umace f urn ~sh furniture fuse fUSO block fuse box fuse current rating
ABBREVIATSON
FS fv fw FUR FM FACT FHT FT fCTN FCA FC1 FE8 FS FT FTR FUND FP FUNL FUR FUR
FLJRN
?s
On phase
fv fw
f w
~ltlplex Gf opttlmJwl
fla
FACT fht ft fctn f ea FCI feb fs ft ftr fund fp funl f Ur
feqcncy phase lock fr~y scan radar fr-~mcv shift frw~mcy shift kwying frwquency shift transm~ssion freqwncy slmc8 Characteristic t~mce f~ncy standard primary frwency t)me ?ndtcator frsqency tracker fre~ency translation dlstortien frwsh q tr \nlet fresh water fresh water drain collecting tank fresh water pIJwq3 frfctton fFtCttOn horsepower frtnge frog f rem from below f rent front connected qnd front front focal length of board front front o? dash front upset jaw front vertex back focal distance front view frozen s?orage q tr rat~o fuel fuel qnd defuellng fuel contents gauge fuel fndicator reading fuel tnjection Itne fuel injection puq fuel line fuel Otl fwl oil punq fuel 0$) tank fuel oil transfer fuel service nozzle fuel tank fuel transfer puwp fuel tng fueling at sea fulcrum full dog point full duplex full duplex teletype fUll field full Frewency range rocordlng full hard full Indicator movement (as used in ANSI Y14.5) fulf tndicator readtng full load full load fra~ tfme operational capability full full scale
FTI FT
FTD FAX Fw FWOCT rwP FRICT FHP FRffi FG FR fR EEL FR fc fRTN FFL FOB FD FUU FVO rv FZSTO F/A PTIO F60F FCG FIR
fur
f urn furn fu fb f Uex f cr fuhlr f vr fuslg ---fs fsbl
fuse holaer
fuse voltage rating fuselage fuselage (altn abbrl fuselage statfon fusfble fusible cutout fus$on po~nt future f uze gage gage cOd@ nu-er gain control drfver gain t{me control ga 1 Iery gal?oy ga 11 ons gallons per hour gallons per mtnute gallons per second galvanic galvanize galvanized tron galvan~zed steel galvar?lzcd steel wire rope galvsnnealed gslvsnometer GaSc!ntlilatton System gang punch data gap filler filler {nput gap gap f{llar outPut gap filler radar g8rage gaebage garbage tn. garbage out
fr
fc
fzsto
f/a ratio fsdf f Cg fir fil fip fln fo
FIL
FIP FLN Fo FOP foT FOT F SN FTK f 1P ftffi F AS FUL FOP FOX FDTT FF FFRR Ftl FIM FIR FLLD FLFT
fop
fot
fot
f sn f tk f tp flng fas ful fdp f dx fdtt ff ffrr fh f lm ftr
flld
FURN FU Fa FU8X FCR FUWR FVR FUSLG FUS FS FSBL FSBL CUT FNPT Ful FZ GA GCN GCD G7C GALL GALY GAL GPH GPM GPS GALV GALV GALVI GALVS GSUR GALVNO GALVNM GSS ::0 GF X GFO GfR CAR G8G GIGO GARBO GMLOG GTR GA GE GF
fsbl cut tnpt fut fz ga gcn gcd gte gall galy ga 1 gph gpm gps galv galv galvi galvs gswr ga 1vnd galvw GSS w gfd gf t gfo
gfr
gar *9 gigo garbcl gm!dg gtr ;: gf gnp
garboard
garntsh moldlng garter gas q~llf~catlon gas qjection gas +\lled gas nonoe~sistent
flft
?Oc Fsc
fOc fSc
...
32
AI?BREVIAT!ON
GOPR GP G7R8 GTC GASIU GM Gox GSK7 GAS GENG Gco GECC GPF GT G GAI GTO GTV GOCR GABO GR GRK GRsx GRc GRG GRSHFT GENL GAT GEN CONT GN GOR GPER GP GPA GPATE GIRLS gopr
TERM
glide slope gllde slope recetver gl ld8r globe stop valve globe Valvm glossary gloup?ug g?ycertne glyptal cloth (tnsul -Id governing government goverfwsent furnished qircraft ewt~nt gwernment furnished ~i~nt gover~t fumtshed qipment list gove rfwent furnished material governmnt furnished parts govmr~nt furnlstwd property government furnished qnd servtces property government loaned equipment govermnent owned qquipment government test laboratory Government-Industry Data Exchange Progr8m govarnor grzb rod grade ~r8de abf?tty grade Itne gmdlent gra-atton grafn gram
q
ABBREVIATION
as GSR 3L Z Gsv GLV GLOSS GLPG GLVCN G GLD GOVG GOVT
GFAE GFE
w gtrb
gtc gmwy 9 S:t gas 9-Y gecc gp$
gtoss
gtpg g 1yen :ld govg 90V t GFAE
GF E
gt
G ga f gto gt~ gocr gabd gr gri( grbx grc grg grshf t gen 1 ga t gen cent ~r WER 9P gpa gpa te GIRLS
GFEL GFM
GFEL GFM GFP GFP GFPas GLE WE gt 1 GIDEP gov gr gr gr ab gl grad grdtn gr 9 gran gran grb gf f gnl td
grmn f te
grmodtze granolfthlc base grw!ottthic finish floor granulated graph isomorphism tester graph 1c qfnweter gr8phtc graphtc demand metwr graphic kilovolt a~eraf meter graphtc var-ter graphite grater grst i ng grave 1 gf-mfel-surface build-up grav t ty gray gray (altn abiw) gray tron greas~ grease nozzle grease trap groatmst csnsmn dlvfsor green green (altn abbr} grwn indicating law green Itght GFWnvich qpparent tlms Greenufch clvtl ttme Greenu{ch hour angle
GEt4 GEN
gen g+ld geol geemag *QP ~t ry Gsfl gr gmbl :1 9 glb grp gtz gfu gsfu gsub 9SU gut gutb glm :
field
geomagnettsm
dilution
~*~
of
GFLD GEOL GEOMAG GOOF GM GUTRY GSIL GR GM8L G GL G GLB GRP GLZ GFU GSFU GSU8 GSU GUT GUT8 GLUE GA G?
GROTN GR G GRAN GRAN Gf?e GF f GNLTD GIT GRPH GA GO GVA GRVA GPH GRTR GRTG GVL GSBR G GRA GY GI GRS mz GT GCO GRN G GIL GL GA1 GCT GHA
prectston
g--trtc
gecwnetry German silver germanium rectifisr gt~a? girder glass glass (insult glass block plasttc glass reinforced 91 qze glazed facing un{t g?azed structural facing unl ts glazsd structural untt base glazsd structural units glazed wall tile glazed uall tile base glazed wallboard q ngle gl!de patn gllcfe
roof
gsbr
$=* ---gi grs
gnoz
gt gcd
grn ---gil g! GAT GCT WA
TERM *tded
~lded ~tded mlsslle ~fded mtssile countermeasures gu~ded mtsslle launcher gutded space vehicle *fllottne gun earrlage ~n Iaylng gun -ta! ~n ~tor carriage qtming pofnt gun stght -gusset gutter gyamas t um gypsum gypsum plaster cetling gypsum-plaster wall
q ircraft q ircraft
ARRREVIATION
GAM
GAR GM
mtsslle rocket
gam
gar
L
gull
gsv
GML GSV GLTN GCRG cl. GMET GSAP Gus UJT GYM GYP GPC GPW GSB Gun GCMPS GYRO HLBRO HA HB l/2oP Hox l/2H l/2Ro NT RK Mu NW HLFM NT HARP HMR Ho HNtl CONT HF 8 HNo GEN HL W4DRL NW US7 FWWWL HD8K NC NH M HOCP HOL FKILG HR HATRAC Fu$osr HOSHK HGR Ho no !+0 CR Ho U~N HPC) HAPOAR HTM RUN tthG HAO Hvuf
gl
gltn sgust
gsap
gu:
grower greov t ng gross gross ton gross vehicle weight weight gross ground ground control center ground control landing ground controlled approach ground controlled interception ground controlled radar ground data equipment ground detector take off and ground effect
gypsum sheathing
9YPSUallbOard gyrocompass gyroscope ha 1herd half adder half breadth half dog point half dupiex half hard half round half track half wavm half uord ha 1f man ha 1f tone qnt{-rsdar Halpern hawsaer hand (con@ form) hand control hand form block hand generator hand lantern hand ra{l hand reset hand uhe-1 ha~ook
handcrank tt8fWho Id
board
is
gsb
Wws
gyro hlt)rd ha hb
l/2dp
landing ground ecwlpment fai!uro ground glass ground law ground mapping radar ground operation equ{pment
ground operational support system ground pos!tlon tnd$cator ground protective (relay) ground speed q ngle ground speed drift ground support equtpment ground to air ground to air data itnk ground to q ir to grwnd ground to alr transmitter to a?r transmitter gruund recefve~ ground to ground ground transmit ground zero 9round-fauIt Interrupter grounded (Outletl group list grwp qssembly parts group reeetltion frequency diffused grovn grown junction guarantee guaranteed mlniwm value guard guard rail gu i dance gu{dance qnd control guidance and navigation ~idance control guftte ~~de light *tded
point
GP GS
GSDA GSE G-A GAOL GAG GAT GATR G-G
hdx l/2h l/2rd htrk flu hw hIfm ht Harp hmr hd hnd cent hfb hnd gen hl lmdr ] hnd rst hndul hc hh hh hdcp hd I hdlg hr hatrac trees t hdshk flgr hng hd hd hci cr ha drn hpd hapdar h tm hdn hbg
handho 1e handicap
handle
GT
GZ GF I G GP GAPL GRF GO Gd WAR GMV GD GOR GONC G4 C GAN GC GOE GLT GOE
~r gdnc
96C gun gc
glt
hand 1 t ng handllng room handover transfer and accept change rmcetver handset handsRake ~co??puters) hanger hang t ng harbor defense hard hard chromium hard drawn hard potnt defense hard point denmnstrat?on qrray r-alar hard tube fmdulator harden qnd grind harden qnd dispersed hardened hardened voice channel
hild
hvch
ABBREVIATION
Wc HA M W3 HCI HCP Hoov HDWC How hve hdns ha tns hs Ilc f hcp MOV
TERM
na~l slngls Cellophane (fn%Ul) *avy enamel singlm cotton {tnsul) qname! singla cotton heavy varntsh ( lnsul ) heavy enaml single glass ( Insul ) heovy ena~l sing). papar bonded (tnsull qnamel single silk heavy f insul ) heavy enamel stngle silk varnfsh ( Insul ) fuel heavy end qvlatton heavy mach~ne gun heavy thermoplastic I insul) heel breaster heel line heel sanding heel to heel height hetght by w~dth by length height ffnder radar height ffnding height of burst height overlap coverage hetght range hetght range finder indicator height range height telllng surveillance helical hel~cal co~ression q xtensfon helfcal helicopter heltpotentlometer q ng)e heltx helper hermetically sealed container hsrmetlcally sealed Zener dtode herringbone he t-rodyne hexachlorethane hexagon huxagonal close packed hexagonal head hexagonal socket hexagonal socket head highqccuracy htgh q ltltude high low opening h{gh q ltitude platform q ltttude htgh relay potnt q ltftude high q ?tltude sound i ng high projectile htgh very htgh qd frequency dlrtit~m ftndtng high capacity (projectile) htgh carbon high carbon steel h~gh carbon steel heat treated q lectronic htgh density packag t ng hfgh energy fuel htgh qxplestve qxp)osive antta~rera?t high xploS\v@ antftank high q
AJIBREVIATION
HEX
heavy
Iterwless
harcness qssurance maintenance hardness hardness surveillance hardness-critical {tern hardness-crfttca! prucess hardover hardware
)mr=duare
cloth
t4EC
HECV HEG HEOP HE S HESV HEAF HMG HT HLBR ML MLSO H70H HGT Hxwxt. HFR ?+TF Hoe Hoc HR HRF HR I HTS HLCL HLCPs HLEXT HLCPTR HPOT HLXA HLP HSC HSZD I+GEN HE T HC HEX HCP HEX i+D HEX StJC HEX SOC14 H HIAC HA HALO HAP HARP HASP HVOF hecv hag hebp has hesv hea f hmg ht
dtstort!on leather
haversine hazard beacon hazardous head form) head fcom head qe cover head diameter head ulnd headed header head i ng headless headl }ntng headquarters h*9*>e t service #tEAF qwergency
heat
hdwc hdud hmnc Ho hd FiARN barn HARN l.THR barn h H m ml ha v HAV H9CN hbcn HAZ tlaz HO hd h H h6c H&C HO hd
w
lthr
tanks
heat
heat
qctuated
clevfce
heat heat heat heat heated heater heattng heattng caBinet heavfer than afrheavy heavy f tnsul ) heavy atrcraft fuel heavy barrel (rifle heavy duty heavy enamel ( tnsul qnamel bonded heavy cotton f insul } heavy enamel bond-d f fnsul ) Sflk heavy enamel bonded cotton (insul} heavy enamel bonded sflk Iinsul) qnanwl double heavy f~nsu)l qnamel double heavy varntsh ( insul t heavy enamel dOUble bunded I Insul! double heavy enamel ( ~nsul ) qnamel double heavy varnish I lnsul )
) }
doub
1e
i4D HOR HOG HOLS HLNG HO HOST HEST HT HAD HE NT RES HTSHLD HTSK H? tR HTO HTR HTG HC HTA WY H IIAF Im Ho w HEBDC HESOS HE8C HEBS HEDC HEDCV HE90P HEDS HEDSV
W hd hdr hdg halls hlng hq hds t best ht had he ht res htshld htsk ht tr htd
htr htg hc hta hvy h ha f hb hd he he13@c hebds hebc hebs hedc
ht%
hlcl hlcps hlext hlcptr *O t hlxa hlp hsc hszd hgbn het hc hex hcp hex hd hex see hex soch h hiac ha halo HAP harp hasp hvcff
hc he hc s hcsht hdep he f he
heaa heat
.-
35
ABBREVIATION
HEAP
UEDS HE I het hett heap
TERhi
highltne ht~ass filter highway hl~ j~W hinge hinge ltne hinge pfllar hfnged plotting board hinged seat hogshead hoist hold off generator hot aaown holder holding cetl holding holding ftxture hole (p)type semiconductor material hol low hollow metal hollow metal door and frame hollow tile home on jarmning homing homfng beacon homtng c~arator unit homfng on oftset beacon hone-ffn~sh mono-i ttn~c floor honeycont3 honorary hook rail hookup -r horizan horizon (altn abbr) horfzon scanner horizon sensor horizontal horizontal (cform) horizontal center lfne horizontal data Drecessina horizontal dfsplky tndica~or horlztmtal fqiJlsi9 horizontal i~ulse reisct{on horizontal location of center of gravity horizontal polarization horizontal reactfon horizontal refcrernce line hor120ntal shear horizontal situation indicator horizontal tabulation horizontal volute spring suspens~on horn fiber switch horn gap horsepower horsepower hOur hose blb hoso clam hose connector hose jacket (insul I hose rack hose thread hospt tal
ABBREVIATION
tfL HPFL
h] rpf
discwdf~
WY
w
hfgh qxplos{v8 ~nc=ndiary htgh qxplos)ve Incmdiary WI th tracer qxplos~ve plastic high htgh exp)ostve ramjet h+gh qxp\OSlvO rOCkOt assisted spott$ng h!gh qxplosive high cxplostve ulth tracer h~gh fidelity hign frequency high frequency current high fre~ency direction f I rider htgh frequency osclllator htgf! frequency transceiver hfgh grade plow steel h{gh humidity t-act high high intensity high level transistor logic high level transistor transistor log~c high pass high point high potential h~gh potent~al test high power aequlsitlon radar high power qwllf{er high pressure htgh pressure steam high pressure test high priority high random access high resolution infrared high resolution tracker h$gh speed radar high speed bombtng high speed data h{gh speed memory high speed paper tape reader high speed printer high speed reader high speed ste81 h)gh temperature high tensile high tensile cast iron high tensile steel high tensile strength high tension high velocity q ircraft high v-locity rocket high velocity armor piercing htgn veloclty target practice hfgh voltage hfgh voltage direct current high voltage power supply htgh vultage regulator htgh water line htgh-a)tltude terrafn contwr data sensor high-level language (co~uters I ?vfgh-nofs e-ifmmmity logic high-threshold Ioglc highest poss!ble frequency
Sabot
ktEIT
HEP HERd HERA MES HET
her j hers hes het hi fl hf hf our hf df hfo hfx he#~ hl~ hint hltl hlttl
HI FI kiF
UFCUR HFDF UFO HF X HOPS HI WM tfIMP HINT HI.TL 14LT7L HP HPT HIPOT t41PUTT HIPAR WA HP
km
J+L HPLR HPB Hs *O HST HOGEN HLON HLDR FILDG Hc t4F P Hot. * HNOF HT Hod HOM HO HCU HOE IIFMF HNYCN8 HON HR IUCP HPR HRZN HORIZ HSC Hs HOR!Z H HCL HOP HOI HZMP HIR HCG. HP HZRN HRL Hs HS I NT HVSS HNFER HGSW HP HP HR H6 NC NC(JNN W HR HSTH HOSP HBPMP H GALV HLG HP
hj hl
hplr tls hs t hogen hlCln hldr hldg ho hf P hol hm
hmaf
ht hoj hb hcu hob hfmf hnycnb hon hr hkp hpr hrzn ---hsc hs hor i z h z hdi hz~ htr hcg + hzrn hr 1 hs hs i ht hvss hnfbr hgsw m hp hr hb he hconn hj hr hsth hosp h galv hlg hp
HPT HIPRI NIRAC HRIR HR7 HS HS13R Hso HSM HSPTR HSP HSR tlss mu HTNSL HTC I
HTs HTs
zt hlpet hipott h i par hpa w hps hpt h~prt hi rac hrtr hr t hs hsbr hsd hsm hsptr hsp hsr hss htm htns 1 htci hts hts
ht w
Mr NV
WAR
HVAP HVTP HV HVDC HVPS HVR HUL F4ATCDS HLL I+dIL HTL HPF
HNIL llTL
hp f
36
ABBREVIATION
hot Iu!Bt IWt hot hot hot hot
TERM
Ident ffcatton fO* swftchf~ f dent fication
frtend or circuit light nu-r of posltlen Unft
AR8REV1AT10N
IFFS ID l.T ID No 1P Iu IDFO IOFR IPI !OENT lffs td lt td no tp tu tdfo tdfr ipf f dent tdl i gn t gntr IG tgn illum \?lus lPS tstar i/f i vd f mag tmt t tt qs t mrs t-
fwl led
rolled rolled tlrl water water ptckled ste91
qm
HR Otl
m.Po
HRs
NT w HWC HSD NW +fR HSE HSHLD HSG HVRNG mu NW
MO Ccs at NNTG riYa
circulat~ng
hybrid comuwter llnk q nalog qnd hybrid digital pulsm tlm nybrtct electromagnetic wave hybr~d microelectronic dev 1ce hydrant hydrated hydraulic hydraulic (ALTN A8BR) hydr*ullc clean hydraulic cycling unit hydre form d~e hydrocyantc acid hydroelectric hydrogen-ion concentration hydrometer ttydrophune hydrostat~c hyperbola hyperbolic constant hyperbolic cusecant C=%ifIe hyperbolic hyperboItc COta~gent hyperbolic secant hyperbolic sine hyperbolic tangent hyperf ino structure hyperbolic clean hypersonic research vUhiCl@ hyporsontc test vehiCle qrmor pfcrcing hypervelocity hypervelocity armor piercing discarding sabot hypervolocity target pract i c8 hypervelocity target practtce discarding sabot hypotenuse hypothetical ice cream Ice cuber tdeal Ioupass filter tdentical tdenttftcatton fdentlf?cat on and traceabt 1 ty Ident!ftcat on beacon identtfteat on friend or foe
ldent flcation tdentiflcatlon identtflcation identified foe identified frfend)y tdentff{ed prior to intercept Identify Idler ignftton ignttor tgnitor [electron device) Ignt tron illuminate illustrate parts breakdown illustrated image storage translation qnd reproduction Image to frame ratio Image velocity detector imaginary imftation !~dlate tmnedfate qccess storage imsnerslon I ~act qvalanche transtt inpact ttme i-act potnt 1~ance t -or l~oI Ier t~r+ect
IOL IGN
IGNTR 16 IGN ILLUM ILLUS IPe ISTAR I/F I VO
IMAG
IMIT IMMCO I AS IMRS 1MP !MPATT
1P 1MPD
lMPR IMPLR IMPF IMPRL I GMT IMPL IMPS IMPRG IMPRSN lFISBR IM1 IMP PS IMPROV
tspertal
HYDM HYPH HYORST HYPERB CSCH CSCH Cosn COTM SECH SIWI TANH HFS Hoc HRV H TV HVAP HVAPOS HVtP HVTP43S HYP tlYPOTH 1CRM l~tnge=nt tmplement f ~ose t ~Fegna t e i~resston i~roved high speed b-ing radar tnproved manned interceptor t~roved pIow steel tnprovement i~ulse impulse conductor tnpulse modulation in accordance wtth q ffect in ground ~n lieu of tn the place c{ted (for referencing ) tn the same place {for re+erenc!ng ) tnactivxte tna~ate t nboard incandescent incendiary tncendtavy boinch tnch per second
IMPLS IC IM IAW
IGE I LO LOC CIT 1810 INACTV INAO IN80 I NCANO I Km 10 IN I Ps IN L9 INCOT !NCIN INCLN ;iCLS
IC8R ILPFL
I DENT I DH4T :&T XBCN IFF
1ncnd fb tn tp%
in lb tncdt inctn ~ncln il incls
TER.M
tnfltght Inseetton tnformatton
ABBREVIATION
IFI INFO IR IRC
ISAP [AI
tft
tnfo Ir t rc f sap fat Ir I racqr t rah
tnformatlon retrieval
tnformat~on retrteval center {nformatlon sort qnd predict tnformatlonal qcqu~sttlon qnd !nterpretatton tnfrared tnfrared acquisition radar q lternate head tn+rared Infrared counter countermeasures tnfrared cwntermeasures infrared information and q nalysts infrared maser infrared measurement tnfrared mtss distance qpproximator Infrared monochromatic radiatton tnfrared phys~cal umasurewxmt tnfrared rance and detect~on tar~et seeker tnfrared tnfraped tracker ingot tnhibtt t~tbtt halt fltp-flop tntttal qpp~arance tnlttal fnltia) spproach fix inttt.al bofling potnt fn{ttal bowtJ release ttne tmttlal condlttons Intttal Opef-attng (operattonat) Capsbillty lnltfal potnt fnttfal spares support Ilst lnttlal velocity initiation tnftiatlon area dlscrtminator inject tnjectlon tnlet qnd outlet Inlet tnlet and outlet head tnlot gu{de vane Inlet manhole f nner lnnw bzck end l-r bottom tnner front end Inner keel inner mark*f= inopwatlve fnorganfc tnput q ss-l-r \nput data t~ut output tnput translator tfpt-output buffer q lement {nput-output tnput-output register fn~try inscription trisect scre8n tnsectfcide tnseparabie tnsert
IR
IRACOR lRAH I RCCM I RCM lRIA IRASER I RM 1RMA IRMRA IRPM IRRAO IRTS lRt 1Gt 1NW IHFF INIT
trmra
t rpm I rrad t rts lrt Igt t nhb thff In{t la
Iaf tbp
tndet {dx
11 lnd t qs iat I* t hptl Imn tmep 1tas 1nd tnd lp
tnd fd
~ndtr iw ~drty f ndv i ndoc td Ind L LC LCR Ind reg tnd t nd 1-s Idctr ! Syrl fnd? ts Ind fnrt tnrtflr inrtg tom Inrtl 1dsm lg t gs Iau fnstar t nf rn i nt Ifl lft-dfl
IA IAF IBP 2BRL xc IOc 1P ISSL Iv INIT IAD INd 2Nd INL 160 180H IGV INN INR Iet 18 IFE IK In INOP INORG INP IOA 1/0
lMXLTR I/OB
tndtrectly
Indfvtduslly Indoctrinate t~ draft in~ctance inductance fcm form) t~ctance capacitance
imctance reststanee capacitance
fmctance
regulator
tmctance
t~tfon l-ctlon
taetor inductosyn
self
conuass
industrial l~strtal swvice tmstry tnert Inert ftller gas fnert tnert Operational
tn8rtlal
IND
INRT INRTFLR INRTG 20M INRTL I DSM IG IGS INU ~NS7AR 1NFRN I NF lFL IfL-Oft
mtssfle
tfe \k ~m tnop Inorg tnp ida !/0 Inxltr t/00 [/08 !/or Inq
~nsc fs Ictcd t nsep I nsr
lattng
--
MIL-STD-12D 29 -y 1981
TERM
fnsert fns-rt ehsractor scrw tttread
ABBREVI,4TION
1?4S CHAR INST IPO
INS
TERM
integrated integrated tntegratti integrated cfrcutt data processing #njectlon logic tation fnstrumen
ABI3REVIATION
IC I DP IIL
tnsert~on phase delay tnsla fnslde diamtar tnstde frosted inst~ layer insi~ mold Ifne tnsfde of fwtal tnside radius fnside trim template Insignia tnsoluble
~nspect
10
IF IL I ML
inspection tnspectton and repair 8s necessary inspection check ftxture tnspectton check t-late tnstal 1 installation qnd checkout tnstallat{on qnd maintenance tnstal!atlon Instal ler instantaneous instantaneous qutomat~c gatn control qutomatic instantaneous volume control instantaneous frequency correlation instantaneous overload instantaneous relay fnst!tute tnstmct fnstructton instruction book instruction card instruction folder Instruction leaflet instruction plate fnstfwction pulse instruction tag Instrument instrument faltn abbr) instrwnt flight rules landing qpproacfi instrument Instrument Landing Approach system Instrument Landing System Instrument mteorologicat Condttton tnstnment panel Instrumentation instrumentation pover supply instrumentation telev!s~on ~nsufficient fnsulat8 fnsulated gate fteld effect transistor Insulating core trimsfor-r insu!attng transformer tnsutation \nsulat\on resistance specff {cation Insulation insulation test specification ~nsulstor i nsuro {ntake fntogral fntegrate
Ins char !nst t pd t ns id If fl tm? i/m tr ftt i Sgn t nso 1 { nsp t nsp $ran tcf ict tnst) tnstl i 6C i Urn Instlr inst i qgc i qvc ifc fol
lnst
IC
IDP IIL ~lr XLS 1padae
IIR
ILS IPADAt
radar
~ntegrated logfsttc support lntegr8ted passfvo-action qnd acquisition *tectton ~ipment integrated tfme qnd qbsolute error fntelltgence tntell$gence radar reporting tntensity Intenstve-care untt fntercept tntercept potnt interceptor lafrcraft) interceptor missile interceptor m$ssile radar tnterrogatton missile interceptor tacttcal interchangeability and substitution interchangeable lnte~hangesble soltd and screen panels interchanger Interchamel master pulse fnterchmnel ttme dtsplae-nt error intercowmunf cattng intercomuni cation (short 1ntsrcoamu ntcation form) tntercwmunlcatlon drum lnterc~nlcation System dtgital tnterconnecttng
17AE
t ta* intel t rr i ntmn Icu i ntcp tp f im ~mtr i tm tbs tntchg Ip Intchgr t1 tda tntercom. tntereom tcm ic drum I Cs f dac i ntcon Icbm lnclr
intcyl
INTEL
IRR INTEN ICU INTCP 1P F IM IMIE
ITM
16s INTCHG
INSt
I AGC I AVC IFC 101 INST RLY INST INStR INSTR 1S IC IF IL 1P 1P rl INSTR INSY IFR
ILA
1P
INTCHGR
ICMP
ITOE
rly
ILAS I LS I MC INSTPN
Inst Instr fnstr ib tc if tl fp if) it instr ---IFR I?a 1LAS ILS 9* fnstpn Instm t ps t ntv t nsuf f nsu I lGFET ict it fnsul ir i spec i ts t nsu 1 t ns intk i nt I nteg
INTERCOM INTERCOM I CM IC DRUM 1Cs I DAC I NTCON I CI!iM INCLR INTCYL INTFC I CD INTRF lFRU INTERGOVT ! NT xc IRATE INTR Ic XC & FCO INTLK 1 I NTMD t Df 10s IF IFA IFS IFT IRMR8M
q na)og convertor
INSTM
IPS I NW I NSUF I NSUL [GFET I Ct IT INSUL IR XSPEC fls INSUL INS INTK I NT
interconnect fon ~nteroonttnental bail istic missf Ie InterCooler tnte~yltnder tnterface Interface control draw!ng Interference lnteeference rejection unit tntergovernmenta 1 ~nterlm Intertm change qrea tntertm remote termfnal WIpment tntertor tnterior cowawnfcation qnd interior cowmwnication ftre control distribution tnterlock qrmor interlocked metallic (lnsul) intermediate tntermecftate dtstrtbut~ng f rams Intermadlate drum storage intermediate frequency Gntemdiate frequency q mlifier tntenmdiate freque~y StrfP
fnterwmdtatfrequency
tntfc t cd intrf tfru tntergovt tnt tc IRATE tntr ic iC 6 fed intlk i tntmd tdf 1ds tf \fa ffs
tft I rmrbm
transformer intermediate
ballistic
medtum range
misstle
INTEG
mL-sTD-12D 29 -y 1981
TERM
fntwmediatu lntermedlat8 lntwmedlate mts*fl* ~dulattm POUW wl~ffur
ABBR.EIIATION
In IH
TER,M t nverse
inverse inverse tnverse inverse tnverse fnvcrsc inv-rse
tnv8rse i nvort i mm-ter
ABBRE$IATION
INVS
ARCCSC
tm
fln t pa
xPA
1P I RBN
Ip
frbm t ts Iv tntmt tcss tdty im tfntl tc ice tnt con i Cv
ITS
xv
qnd
INTMT c~rctal
lntermodulat!on d~stsrtton 4nterrm 1 Iflt@rnal Castton q ngtne tnternal c~stton intomal eonnectton lntemal correction voltage tnternal diameter Intamal pipe thread $nterna) translator tnternattona 1 International Annealed Copper StandarU Intemat~onal Critical Tables tmternational direct distance dtaltng International Pipe Standard
Ic ICE
INT CON 1Cv 10 IP7 17
INTL I AC!i
ICT 1000
IPS I ST
SI
$x iom t ntphtr
i ntph I Cs i pbm intrpl intpo tp $ntpr intrplry ilas intrg t? irt it intrpt i ncr tcu int tpm i ps intsct tntshp intstg Intvl tntvim Ipdp intrc t intro i nvar 1ftvn is
Ion
INTPWTR INTPH
tnvestfgation invitation for bid tnvolute i ruard ton ctta-r f Onosphere tron (cform) iPOn body bronze mounted iron core reactor iron pfpe iron ptpe size iron pipe thread ironing board irregular island isolate field effect isolsted gate transistor isolatlon fsolation ward tsolatur tsometr~c isoscoles i Ssue identlftcation item recAJct\on studies ttlnerary j qck Jack screv jacket Jacket water jaming jansntng radar coverage tndicator Ja-tng to slgna!
ARCCOS ARCCOT ARCSEC ARCS2N ARCTAN lTL ITR INVT INV INWS IFO IWLT I Nuo xc 10NO I 18BM I CR 2P
IPS
i nvs Srccsc qrccos q rccot arcsec qrcs f n qrctan ftl I tr i nvt 1nv t nv8s ifb tnvlt tnud ic i Ono 1 ibbm i cr
ip t ps
IPT IB IRREG 1s ISOL IGFET ISLN ISLN MO ISLR I SO 1S0S 1ss I PO 11 IRS ITIN dK dKSCR dKT W dAMG JRC I Js dc dAN dAP dATO dP dTSN dT do UOG UN d JPFT dPt4T JT dAN UANAF JTB $JC dQP ds NPSM d U&? dNL Jut
ipt
tb irreg is isol
IGFET isln Isln wd islr f so i Sos tss \ pd t! i rs itln jk jkscr jkt jw j amg jrei
issue item
prtorfty
designator
Cs
IPBM
INTRPL INTPO 1P INTPR INTRPLRY I LAS
INTRG
IR IRT IT lNTRPT lNCR
closet
interrupted continuous usve ICU tnt8rrupter [relay] IW . Interruptions per minute IPM interruptions per second IPS tntersect 2NTSCT intershtp lNTSHP trite-stage INTSTG interval INTVL Intervalometer INTVLM tntervals of pulsations of 1PUP dtmlntsn~ng purled fntrtcate INTRC Intrinsic [1) type I semiconductor matertal fntroductton INTRO tnvarlant INVAR Inventory lNVN lnw8ntory schedule Is
jet qssisted takeoff Jet propelled Jettison jig t~lata job order joggle jotn joiner joiner p! laster fume ttght jotner ptlaster nontight
E Jan j qp JATO
JP
jtsn jt jo jog jn jpft J pnt jt UAN dANAF j tta jc JOP js npsm J j;:
joint doint
~utnt Jotnt jotnt joint joint joints Joist joists
journal duly
Amry-Navy
Army-Navy-Air Force bar comound operating procedures support
qnd
planks
W 1
40
ABBREVIATION
LOP LT LTRN LNYD LPG LGE UUWET LE LSM1 LSI LT LAOAR LSNG L!FO LLCSW LATL LA7 LTC LANH L61 LC LCE Lcc LELU LEU LES LET LFS LM LOC LSS LIJT LV LCHR LS L SM LE L AU LC L7 L AV twF LYR LYT LA LCM LC L LT LOR LORSP LO LE LER LIO LKG LOFF LC L CM LMC L S8 LVCD LTMR Lv LVS L LAE L BK
jfvjct
jb
w ET an j :nd Jnd ;Ust
data
processing
trmslatlon
ldp lt
ltm 1nyd lpg lge 1wvnet le LSH1 u: lt 1qdar 1Shg LIFO 1ch I Csu latl lat
junction box junct$on ffeld q ffect tram Jstor Juntor just not noticeable dfffwmc. just notleeabla dtffemmce
justification q sphalted, fwnmetal~~c jute qrmor (Insull kalamein kalamein door kalamein door qnd frame koenes cmment plaster keenos cement plaster cotling keeping kerosene key ~ntelligenee posftlon key locker key pulsing keyboard keyboard send qnd r@Cefv_ keypuncn keysea t koyway kick plate k{ck plate qnd drip ktckoff (relay) kfckpipe kiln dried kilowolta$?pere hour k~lovoltaqJere hOUr meter ktlovolta~ere meter k~louatt hour meter kinescope kinettc energy klystron awlifler klyst~On oscillator klystron power suPPIY wmdulato~ kne8 brace knife b!ade knife edge knife Sultch knock devn knockout knot hnur 1 Korosesl &e i Iq laboratory labyrinth labyrinth pack 1qc~r 1qalder ladder rung I qggs ng
Iamvnmte ~ qb ] aCk 18qYho I der Imdfng
1any8rd
lapptng 1qrge lsrge qrtificial neuron netvort( large qnd large scale hybrid ~ntegr8t\on large scale integration large tug laser detection and ranging lash~ng Iast-tn-first-out latch latch checktng swttch lat.ral latltud8 lattice 1qunch nd iwact I qunch q 1aunch complex 1qunch -lex qqUtpm@ftt 1qunch control center 1qunctl qnable Ioglc unit 1qunch enabllng unit 1qunch wscape system 1aunch qscape tower unch facil~ty simulator 1q unch mount Iq 1aunch operations center unch status 1q wmarizef= unch umbtlfcal 1q tower unch vehicie 1q uncher 1q launcher site launcher status wltiplexer launching e+tpment 1sundry chute laundry laundry tray lavatory lawn faucet yer 1q yout 1q ngle load q lead coatad metal lead cover=d lead sheath (tnsul) lead time ?aader leadership 18ad{ng Ieadtng edge q dge radtus 18adlng ;eadless tnvcrted device ge 1qak q Iaakof f lewnlng curve IQast comon wwlttple l@aSt material condition least significant bit 19ast voltage coincidence detector laather 1qwe 1qaves left loft arfthmet{c element left bank
dR
JUST UJ
KAL KALD KOF KCP KCPC KPG KRSN KIP KL KPLS KYBO KSR KP KSt KW KPL KP60 KO KP KD KVAH KVAMN KVAM KUHN KI?fE KE KLA KLO KPSM KO KNBL KNE D KN SW KO KO UN KNRL
kal kald kdf k Cp kcpc tcpg k PSn ktp kl k~ls k ybd ksr kp kst kuy kp I kp6d ko kp kd kvah kvahm kvam kwhm ktne Me kla klo kpsfn
It 1anh
181 lC 1ce LCC ?elu Ieu 18s let 1+s )Sl 1Oc 1Ss lut Iv 1chr 1s ) sm le 1au Ic It 1qv If 1yr lyt
kb knbl kned
kn sw kd ko kn knrl kral Ibl 1qb lbyr lby~k 1qq 1qd
la
1cm lC ;t 1dr 1drsp
KRAL
LSL LAB LBYR L8YRPK LAQ LAO t.R LAG LAM LMPBLK LPHLDR LOG LOG (3R LOSS LSW LT LLTT LD W LANG
ld
le 1qr lid lkg IOff lC
Icm
lm 1Sb 1vcd
Imdtng
gear
Lmdtng
Observer Signal System Iandtng Stgnal wand light Iandline teletype 1qndnark I wtguage
1thr
Iv 1Vs 1 188 lbk
41
MIL-STD-L2D 29 ?kY1981
TERM loft cfrcular polarization ABBREVIATION
LCP Ltf Ltl OR LtfS Ln LR1 LS LG LDP Lc LCRV LOL LOA LG/D LNG LN80 LNO LNSP LTR LS )Cp Ih lh dr lhs lm Irl IS Ig lbp lC ?Crv 10T 1oa
TERiM
l~ghtproof louver Itghtproof shade Ifghtproof vent lfghtwight concrete ltghtwfght tnsu18tlng concrete Itgfum vttaa 1 fmr 1 InStone
ABBREVIATION
LPL LPS LPV LWC LWIC LGWVTE LIM LS LIM LIM SW LTD LC lpl
loft hDnd
loft hand drtve left hmd side Iaft mla left rtght Indtcator Iwt side length length between ~~-t-lsrs length Of ChO~ length of curve 18ngth of ,lead (actual) I@ngth overall lengthto-dtameter ratto Iengthentng lmns boarcl lens nmdulated oset?lator lens speed letter !ett@r box letter of \ntent letter press }ettmring 18vall lovo? detector level discriminator levelometer 1qver Ieutsite Ilalson [aircraft) 1 tberty I t brary library issue document 1 t tense llfo float llf~ jacket preseever l{f8
1ps
1pv luc Iufc Ignmvt@ lfm 1s Ilm limsu 1td lC Ittits 1ob LSA lmtr )mtg 1 1assm 1 qrp
Igld )ng
LINOIS LOB
LSA
1lmo
1nsp ltr
LI
LTRPRS LTR LVL LDET LDISCR LEVMETR LVR L L LBRT LERY LID LIC LF !-d LPRSV@ LCS LB LSVG LUO LFT LE LT LAS LAO I L LASER
LMTR LMTG L LASSM LARP LB LC LO LDA LDC LE13 Lf LMU LOB LOP LOS LPM LPTR LRA LTU LTM LIN LIN LOc LOT LET LIC LP LTeo LVOT LIFMOP LNG LK LKGE LINOL LB LF LNTL LIQ LIQ FL LQGLS LZN LOX LPG LR LRE LCD LO?4ETR LOR L
lb
lC Id 1da 1dc 1ea ?f )IIU 1ob lop 10s lom lptr 1ra 1tu 1tm Ttn Iln Idc Idt let LIC lp 1tbo lvdt l(fmop I ng Ik lk~ linol lb lf lntl ltq !Iq fl Iqgls Iln 1ox I pg Ir 1I-e Lco
Swttch ltgnt activated l(ght **rera#t b~nary \nformatton Ilnk Ilght awq21if~catlon by sttaulated emtsston of radiation Ilght case ltght detection and rzmgfng l~~t distrfbutton box light emfttlng diode l(ght gun Tight gun a~lffter ?fght gun pulse generator light lock lt@t switch tank Itght Ifgnt trap Ilght-activated controlled Semiconductor
rectffier
Ifght-intens!ty detectar IIght-optic microscope lightening l~ghten!ng hole llghter than afr lfghtlng lfghtn$ng qrrester LTID LOM LTG LTGH LTA L7G LA ltid 1Om 1 tg ?tgh lta Itg la
42
MIL-sTIk12D
29 &y
TERIM of drawings llst of qffectiv8 pages list of material llst of speclficattons Ifst of specifications and standards Iisttng time limit lithograph Ilthographtc Iftter Ittter hook Itve load 1 Izard 1oad load adjuster memory load buffer load carrter toad center load circuft efficiency load classlftcation nu-er load c~cnsated dlde transistor logtc load compensating [relay) load factor (tabular) load tndlcat~ng relay load ltmittng reststor load Itst load ratio load ratio control load res~stor (relay) load shlftlng reststor load tap changing load update subset load uater ltne I oader Ioadfng lobe on recetve only local qcquisftton radar local qpparent time local 1~1 automatic message accounting local battery local C!vtl tim ngle 100al hour q local mean time local operating procedure 10C81 oscillator local osci I?ator frequency Iocal stdereal time ?ocal standard tinm? local zone time localfzer locate locate (altn qtmr) locate drum address Iocatlon lock on lock pillar lock up lock washer locked Iocked Clased tn device locked locked open locked oscillator quadrature grid looked rotor )OCked-rOtOr q~eres 1ooker locking list ARFIREVIATION
Lo LOEP LM Ls LSST LTL LITHO LITNG LIT w LL Id
1981
TERIM
locknut pipe thread Iockscrew locksmith lockwire locomotive locus of radius locust loft line lofted Iine logartthm logarft~ (natural) log8rlthmic impllfier logarithmic fast time constant logle logic drtver logtc theory logic unit logically passive self-dual logtsttc Ioglsttc Cmwun icatlon logttudinal posit~on of cmter of flotatlon 1ong long (altn qbtm) long baseline radar Jong endurance patrolling t Orpedo long lead time long leaf yellow pine long part nunber long path tnfrared long persistence long playing long pulse continual wave long range long range qctive detection long range data long range earth current conmuntcat ions tong range ~nterceptor long range navigation long range radar long range radar input long side low taper long wheelbase t ongeron longitude longitudinal qxpansion joint Ionaltudinal Iofiitudinal position o~ center of buoyancy longitudinal position of center of gravity Iengttudinal tirm constant looking lookout loop controi (relay) loop error signal loop feedback s~gnal loop gain loop input svgnal 1ooper loss of signal lot fraction reltab{llty definition lot tolerance percent eefecttve loudness level
ABFJREV1ATION
NPSL LKSCR LSMITH LKWR LOCO L/R LCT Lt. LL LOG LN LOAMP LOGFTC LGC LD LT LU LPSD LOG LOGCOM LCF L LG LOBAR LEPT LLT LLYP LPN LOPAIR 1P LP LPCW LR LORAO LRO LOREC LRI LORAN LRR LR : LSD LTPR LWE LONGN LONG LONG LEd LC8 LCG LTC LKG LKT LPC LES NPSL lkscr lsmith 1kwr 1Oco I/r let 11 11 1Og In loanQ Iogftc 1gc Id It Iu Ipsd 1Og 1ogcom Icf 1 . ..1obar Iept Ilt Ilyp 1pn lopair lp lp I pew lr 1orad 1rd lorec lri I oran 1rr lri 1Sd 1 tpr 1* 1Ongn 1Ong 1ong lej I Cb 1 C9
1oep
In Is Isst
ltl
11 tho litho lft lh . 11 Iiz Id la lbm lC lC ?ce 1cn LCUTL lC If lfrly 11 T-es 11 lr If-c lr 1sr 1tc 1us lU1 1dr
1dg Ioro
ICI I qr Iapt LAHA lb LCT 1ha LMT 1Op 10 Iof lsdt 1st LZT 1Oc let .-.. t da lctn 10 lplr Ikup lk wash lkd !kd C
1tc
lkg lkt 1pc I qs Ifs Ig Iis I pr 10s LFRO LTPO 11 1s I Vr
LFS LG Lls
LPR LOS LFRO LTPO LL :~R
!id
lkd O 1Oqg Ikrot 1ra Ikr lkg lknt
?Ocknut
Ioudspeakor 1ouver
43
KIL-STD-12D 29 ?h)f981 1
TER31
IOwOW opening louuwed door
AIIFIREVIATION
TERM
lumn per watt Iufsfrlous lunar qnd interplanetary vehlcla lunar 8xcursion frmdule lunar orbit rendezvous lunette Mach wer msc!l i m machine gun machine operation machine rifle macntne scmu machine steel macnlned surface machi nary mochinfst IasgBz 1ne magazine floodtng qnd sprfnkl~ng magnaflux magnestum- thorium magna t magne* i c magnet+c q irborne detection m8gnetfc amlifier msgnettc armature magnetic cor8 magnstlc core memory magnetic dtrectiton indtcator magnetic drum dfgltal dff?erenttal analyzer magnetic drum receiving ~i~nt detector magnetic frequency
ADIIREV1ATION
L Pw LUM LIV L EM LOU L(JN Wacn MACH MG m MR MSCR MST MASU MCHRY MCHST MAG MF&S M MAG- THOR MAG MAG MAO MAGAMP MG MC MCM MO I MADOIOA MAORE MFO w MICR MMS MAGNOD Moc MP1 MS MT MIH MTR MTTE MTMS MTU MVP MVS Wo MGTMTR MMf M/S MAGN Ma S MGF MAGTD MAH MB Mcki MT w MOS M8T Me MB1 MCT I pw lum ltv LEM 1or 1un Mach math w mr mscr mst masu mchry -hs t mag mfhs m mag- thor mag mag MAO magafm @W mcm
~.
LVO LVO
1Vo 1vd
1 1oac 1qs LAB LABS 1qed 1qrf 18s0 Ic lcolnt 1or ldri Idb l-id Ie lf lofar tfe Ifo If 11 LLL llltv 1Onl lp \p 1Opar lpo )p 1pox
1Sp ?sb ISd
accuracy
qlloy steel qltitude bo~ing altitude tmmblng system slt!tude drogue delfvery qltltude rad~r fuztng q ltitude searcn option carbon Coo?ar?t data rate data rate tnput drag energy tOn datcctor qxplosive f raquency frequency qcquisition and rangfng correction )W frequency frequency oscl 1 Iator lW low fntensity 10U 1qV* ) Iou I-cl logic low Itght level television IOU order memory 80U ~ss paint ITOW ~ q c~isitton vac$ar toM pwler output Iou pressurw Iou ~sura oxygen 10U speed speed buffer 10U 10U speed data Tou steam rou tq*ratur* low tenston lw torque scanning low velocfty 10U vhf transmitter recetver low voltage low voltage drop Iou voltage protection ?OU voltage release lw voltage release effect ?OU ~ter ltne Tou-?Wency outer marker Iw-pouer vor Tw-pouered fan maricer re-res=lut~on Infrared m+ oamter 1-r lower -se lowr cwntrol l~mlt louer deck touu sideband I Owest lowest effective power Twest maxtmum range lwost UsablFrecnJencY tw8st usable htgfi fre&ency lwpass filte~ lox cl=sn Iubrlcant lubFtcat* Iubrtcattng oil Iubrlcattng oil pu~ rmrlcatton order rwr
LOAC LAS LAB LA6S LAOO LARF LASO LC LCOLNT LDR LDR I LD8 LEID LE LP LO:AR LFC LFO
LI
LL LLL LLLTV LOM. LP LP LOPAR LPO LP LPOX LSP Lsa LSD LSTM LTEMP LT LTQ LVS LVTR LV LVO LVP LVRLSE LVRE LWL LFOM LPVOR LPFM LRIRR LWR LC LCL LOU LSB LUST LEP LMR LUF LUHF LPFL LC LU8T LU8 LUBQ LOP LO LBR
Rdi
maddlda mad~e mf d mtl mler ms ma-d moc ~i ms mt mth mtr mtte Istms mtu Wp s mhd mgtmtr nswf m/s magn Wbs mgf magtd man m -h mt m -S tit m *t Ut
Istln 1 t8!lq3 lt 1 tq lVS lvtr IV 1vd I Vp lvrlse Ivre lWI lfom 1pvor Ipfm lrirr ) wr Ic LCL Idk I 86 lust 1ep 1mr Iuf luhf Ipfl lC ) Ubt lub Iubo 1Op LO 1br
44
MIL-STD-12D 29 My 1981
u ma{n coo 1ant m8fn distrfbuttng framb main drum nginw cutoff ma~n q main feed ma~n landing gear mainframe - malntentincw maintenance qnd repair maintenance and supply maintenance engineering analysis record meintenanco ground +tpment maintenance of close contact maintenance of true bearing maintenance parts ktt maintenance parts list maintenance reqired not deve 1oped matntenanee requirement substantiated maintenance support equipment major major comonent major lobe
ABBREVIATION
MC MOF MD MECO MF MLG MUFRM MAI NT MbR MES MEAR MGE MCC B4TB MPK MPL MRND MS MSE MAU MC ML NOB MB M/F MKUP MJFD MaF MFLRU MPT MT*O MALF MAOAR MIU MAL MI MOB L7 MGT MGR MANO MORL MANUV MI+ MC MANF MAP M MLLP MRS mPWR mL MAN MANAM MANTUAC Mco MCR Mo mc mdf mace mf mlg mmfm ms~nt mar m4s mar MGE mcc mtb ~k ml mrnd mrs MSE ma j m ml @b * m/f *up -f d maf mf 1r-d Wvt mt hrd malf
TERNI
manual tnput manual input processing manual of operations manual output manual over!oad manual volume control manually operated manufacture manufactured Iaaqwfacturing mawfacturing information manufacturing instruction manufacturing specification manuscript mapper sveep generator mapping mapping ahartlng qnd geodetic
AR13REVIATION
Ml MIP MANOP ?40 MAN OVLD WC MNL OPR MFR UFO WG MFG INFO mi mfp
manop mo
man mvc ml mf r mf d mf 9 mfg mi mfg m msg map ovld Opr
info spec
MI
MFG SPEC Ms MSG MAP McaG MR MR8 MRF MRT MAR MARG MGL MAR MFS MPAu MTAM MK MS MUD MKR M8R MKR MKGS MASK MHPO MSfURY Mo M MHL MA MCR MCRL NOR Mos MIT MITE Ml MLO MLO MLL MMo MORT MO MOPA MOPAR MSMP Msu MSYNC MTC MTL MTVAL MHo MHO LT
mchg
mr mrb mrf mr t Mar marg mgl mar mfs ~am mtam w MS -d
*r *r ukr II& gs
mask msnry m m mhl ma mcr ~r 1 mdr mds mit ml te m~ mld mle m?1 -rt mo -pa mopar msq msw msync mtc mtl mtval tid mhd It
madar
mtu ma 1 mi mob lt mgt mgr mng mand mdr 1 manuv W mc m8nf map m m)lp mrs mnpwr Uwll ---manam mantrac -O mcr md mdi -if lutiu mdf mf c
change
order
change request data data input data input functfon data input untt direction finder frequency control gain control
MOI MDIF
MOIU MOF MFC MGC
masthead
mesthead Ilght
45
ilIS.t-STD-12D 29 Ma]1981
TERM
mastic msstlc flour mesttc joint mmtcm -tert@l materi81 ltst material management code material re+est matmrial test speclficatton matertals hmdli~ ~f~t mthmmaticsl math,mattcs Ratrix q ~llfler matrfx output matt f}ntsh structural factng units mattress Isaxtsum maxlnum authorized qltttude maxtsum qvailable power gain maxlwam capactty maxfnam design meter maxtmm flat envelope delay St8XtIlUm flight maxinum material conditton maxl~ operating time maxtm perm~ssible qxposure maxiwum power output maxlnum torque maxlImJm tracking error max~num usable frequency maxiwm working pressure maxinum uorktng voltage
A13RREV I ATIO!U
TERM
smch8nlc81 bulfar register mechanical recordfng head mechanical tlmm fuza mechanical t~me superqufck -chanical transport -ttantcally cooled mhantcaIly refrigerated mhan f S* mechan f ze machan{zed flame thrower -tan -!C8? btctne cabtnet -1smdium (altm qbbr) mtum qltitude cowmuntcatlons satelltte amdtum qtomic demolition aamttion medium frequency medfum hard drawn medium h(gh frequency medium htgh pressure medtum ~ntenstty med{um pressure medium range medtum range ball istfc missl )e mec!tum range radar -dium scale tnt8gration *turn wave meeting -lamine melting point mwber ~rane ~rane w8terprooflng mmorandum memory memory address memory address cwnter ~ry address rcglster mfnory allocation qnd protection unit memory buffer memory gate generator memo~ i-t rogfster sWJxWy output register memory po~nt memory test corqwter memory unit merchandise merchantab la mercurtal mercury arc mertdian tmeshl~ message q cceptance pulse imssage nwssage qss~ler message construction unit message decoder unit wssage generator }nJectlon untt message message per day message processl~ intermpt count message repeat msssage r,transfnisslon unit message swftching unit indicator message waiting
q
ABBREVIATION
M8R MRH M7F MTSQ MT KXL McnRf MECM MECZ MrT MEO e. MED
WACS
Ustc
MF Md UTCHO MATL ML MMC MR MTS WE MATH MATH MAT MOA MFSPW MTRS MAX MAA MAPG MAX CAP MOM MFEO MAX FLT WC MOT MPE MP9 MT MTE MUF MWP WV
mstc W
mj mtehd matl ml mr mts WE ma ttl math mat
-r
mrh m f ntsq mt
-hc 1 mchrf -h mf t
E ---macs m8@ll
ma
mfsfu mtrs max ma mapg max cap mf qct max flt m mot npe RQo mt mte MJf m May mac M MOT Mf i4Ei F
MADM MF M+F MHP MI MP MR MRBM MRR MSI MU WC MEL UP M9R MEME MwP MEMO MEM MA SEE 8ELOW SEE BELOW MAPU MB MGG MIR MOR MEMPT MTC Mu MOSE MERCH MRCL MA MER MS* MSG MAP MA Mcu MOU MSGG MIU M/D MPXC MR MRU
mf
mhf mhp mt w mr mrbm mrr Ms I Iru mtg -1 v *r
Hay
man q wedynamfc chord mean deviation mean down time mean effective pr=ssure hours between -an fl Ight fatlure mean high tide mean h!gh water mean htgher high water mean low tide mean low water mean lower law water mean point of Imact mean sea level mean solar day mean solar time mean spherfca? candlepower mean te~erature difference -an tide mean time mean t~me between fatlures mean time between maintenance mean ttme between maintenance act tons mean time between removal nx3an time to catastrophic failure mean time to fal}ure mean ttme to first failure mean time to malntaln mean ttme to repa{r mean time to restore mean up ttme mean var~atlon -an width ratfo measure I?Wchantca 1
.00.
HAY
MAC MO MOT MEP MFH8F
MHbi MLT MLW MLLW w! MSL Mso MST MSCP MTD MT MT MTBF MTBM MTBMA MTSR MtcF MTTF MTTFF MTTM MTTR MTR MUT W MUR MEAS MEw
q =** q
Iwlt Inrw
mhbv mlt mlw mllw Ilq2t ms 1
mem ma SEE BELOW SEE BELOW MAPU m 59 m!r mor mew t mtc m mdse merch mrc 1 ma mar mshg msg map ma mcu msgg miu m/d llplc
Mso Ms T
fnsCp mtd
mt
MT MTBF MTBM MT8MA MT9R MTCF MTT F MTTFF MTTM MTTR MTR #WT mv mwr mess -h
*** q q
mr fnru
msu Wui -S s . .
q
Msu WI
MESS
q
messenger
q
.s..
.9=0
*se**
D**
memory memory
address address
counter register
ABBREVIATION
M GM MET MA UA$ MATH WCTB MCW MCP MCEl MCD METC MDM METO METF MGS METG MIS MIA METd MLP METM MMT Mos MOSFET W)ST MET? METP MUD METR Ml-$ MSP METS MT MTUF MNos MTOS MTONS MC SWGR MTLC MTLz MCT METRL METCAL MTR M Mtcs MTR MTRG MNo MTHD MVP MEZZ MAOT MAT MI CAM MI CMP7R MED MELEC MELEM MF Mfc MIC MICROMIM MR m F met me mas ma tw awtb m mob mcd mete
TERM
mlcromodule microphone q lement mtcrophene microprocessor microscope
mtcrouave aerospace terminal control q nplificatton by m~crouave sttnu!ated emiss~on of radiation mtcrowave carrier supply m{erowave detectfon qnd rang I ng mtcrowave early warntng mlcrwave pulse generator mfcrouave relay unit mtddle middle (altn qbbr) middle landtng mlddie marker midget (nKEdtum range) mlerange ballist~c missile
ABBREVIATION
MO Mlc MICELEM MIPRCS MICR MATCON MASER
mtc
m!celem mtprcs
qnchor anchor slots metat q wning type wtndou meta I Base ~tal cas~nt window *tal cast~ng pattern metal corner bead metal covered door amtal curb metal dtelectr~c metal (filter) metal door metal f!asrling metal gravel stop mtal grtl) metal ~nsulated semiconductor metal interface ampltfter metal jalousie -tal lath qnd plaster -tal mold meta! numnt metal oxide semiconductor Oxide Semiconductor metal fteld-effect transistor mtal oxfde semiconductor trans~stor aultal partttien metal portion ~tal rolling door nmtal roof metal slttting mtal splash pan Strtp -tat threshold mtal -tal thru wall flashing
Mcs MIDAR mu MPG MRU MOL MID MLD MM MOGT MRBM MRO MRT Ml MPG MPH MIL MARS MC
mis
mta metj mlp metm rmnt Mos MosreT MOST metp metp
MCE
KM MELVA MILSPEC MXL-STD MS ?4ss MAM MkiL MCM MHB ML MSR MS LT MINTR MXNIAPS MNCMPTR MIN MAFD MINICOM MCA Mm MEA MIP MITO MLD MLI WCA MRA MVS MIN MIN MIR
UISC
mtwf
hums
-tal -aluminum-oxide
Sliicon MAOS
austal-nitride-oxide sil{con wtal-thick-oxide silicon metal -thick-oxide-nl trtde Sllicofl metalclsd swltchgear Metalllc metal lize metallurg~cal meteorology cat meteoro!og$ca} calibration meter I Instrl meter I instr. cob form) wter-ki logram-seconct mQterlng metering faltn abbrl meterfng head CYtfferentla? method methyl-violet paper Rtzzan i ne microalloy dtffused transistor m$croalloy transistor microamme ter mlcroco~utcr mtcroelectrontc devlcc microelectronics mlcroelement microfilm microfunctional cfrcuit micrometer mtcremin{ature microminiature relay
madt mat
mi cam mfcnptr NED melee meIem W mfc
mtc microm$n mr
miscmllmeous
47
MIL-STD-12D 29 ihy1981
TERM
miscellaneous Itve Untt mlscel Ianeous radar Input misc~llaneous stnul at ton genera t ion mtss dfstance fndlcator mlssl18 missils borne guidancs qquipment mlssfle doppler qarly warning system misslls mfssila f{re control system missile flfght cautfon corridor mtsslle fl tght hazard corridor mfsslle guidance qnd control mtsslle hazard report mtsstle lnqmct predtctor missile integration terminal qquipment mfsslle precfston inst~ntatton radar mlsslle tracking radar tiisston mission accomplished m~ssion and traffic control mtssion data re~cttun mi te~ mfter end mixed flow ml xer mixtng fat x ture
AB8WV1ATIOS
Ml-u MUI MSG MDI MSL M8GE M! DOP MEWS MFCS Mfcc MFHC mlu mr +
msg mdl ms 1
TERif molecular
molecular molecule momntary momentary contact moni tor monitoring identification qnd correlation nwwco~e monodetafl drawing monograph -nolfthic monoltthlc ~ntegrated Cil-tuft monophonic monopulse radar mnostable monostable nultlvfbrator month monumn t moon stgnal rejectfon ~tpment moor t ng mop rack morso taper mortar motor carrter -saic most probable number most probable post tion most significant bit mostly motherboard motton motion picture control panel phonographic motion plctur~ Untt mttm p~ctur~ projector rotor motor belt drtve electronics weight
A1311REVIATION
MOLELEX MO1. UT MOL MOM . NC MON MIC MolWc MOOR MONOG ML MIC Mom MPR MNSTB MNSTBMV Mo Motu MSRE MRG WPR MtJRT M(3S MPN MPP MS8 MSLY MTH8D MTN rmlelex Ut ml mm m mon mic
ml
MSGE
mt dop MEWS MFCS nlfCc
fmnoc modr monog In) MIC mono qw mns tb lnfM tbmv w mm MSRE mrg -r mor t m Ifus wpn msb U?Sly
mf bc w rnhr mip mite lq3tr mtr msn ma WC mdr mi t m mxf 1 mxr mxg
mx t
WR MIP MITE MPIR MTR MSN MA MTC MDR MIT ME MXFL MXR MXG MXT MSL METS MPTR MRAP~N MRU Mu MUSE ME WT M MC MXOCR Moo M M8 MoT MOO Mwo MCC Moo MIPE MCW HAVAR MOP Moo MOOEM MOL Moo MGI. MSTRE Ml. MLO MLOG
Inthbd
Intn Ilq3c flupt1
mobile
mobfle depot maintenance q mgfne test stand msbile sub{le positton trackfng radar mobile radar approach contro I radto unit m0bl18 mobtle unit mobile un!t support base mobll{ty equtpment mockup te~late Wde mode chango mode transducer mode 1 model Imilttary nomenclature ) -del block moderate modfficatten modtf~catfon work order -tF\ed ctosm control
ml mts aptr mrapcon Urru m IIUsb ME ImJt m m mxdcr m mb tit mod Uuo -c wd mlpe
WC
MPPH MPP MOT Mso MoclaN MC MCsw Mo MOC MTRON MF MG Mo MTS MT MV6 MWO MS MTRCL MTZ M MT MT O MTG MTGC MVEL MVT Ma I MVG MC MT I MUF MULR MALE MARS
Imt mbd mocan mc mcsw W mdc mt rctn Inf w mts mt mvb m mtrcl altz m mt mtd mtg mtgc ~b i Wlv t *I mvg mc mt i mf wlr male mars
modify ~lar
information processing Wipm9nt -Iated continuous wave ~lattng mplif{e~ us~w vat-fable reactance modulation on th~ pulse moa4iator moc&lator demodulator -IQ -Ius mow 1 mo ts ture -ld Itne molded
mavar mop
ldentlftcat~on
Indtcator
motdtrq
mld mldg
48
MIL-STD-12D
29 by 1981
ARRREVIATION
WItfarray gamm irrad~ator ImJItichannel data recorder Wltlchip nultfdetsfl drawfng wltlemltter transistor mltffrequency pu)slng !m,lItigage WmfIttlatm multilateral force nultilayer circuit board Wltflith mltlmeter fmllttplane nultiple multiple beam klystron mltiple bo~ rack wltiple contact fmJlttple f=~ency shift koy f ng nulttple gun motor carriage mtt{p?e input temntnal ~tpment -ltip)e object phas= tracking qnd ranging wlttple purposa conmunicat tons *lttple sectfon -lttple tape recorder end nultlDle tape recorder start Wulttple target deception sulttple transfer aulttple trigger generator aulttple unft WItfplex WItfpllcatton aulttpl ler Sultlplfcr phototube sulttpole nulttspeed wltisystem test equtpment MAGI MOR MC WOR MET MFP MG NUT MLF MLCB WLTH t4JLTR MLTPL MULT MBK MBR MC MFSK NGMC MITE MOPTAR MPC MS MTRE MTRS MTD MT MTG w MJx WLT WLTR MP MP MLT SP MTE NV MtN MWG H MI MZL w NAC
VIZ NP L
TERM
National National natural natural natural nautical taper Wire pipe Gage (thread
AM3REVIATION
NPT NWG NAT NBS LN NAUT NPT wtG
na
magf mdr mc muctr met Wifp m9 nut ml f mlcb with aultr slltpI mlt
*r mc
nautfcal miles naval ~val bronzo naval electronic warfare sinulator naval oceanographic -teorological qutomatic *Vi cl? navtgate
nsvig8tion navigation and radio homing navigation countermeasures qnd deception navigation satelltte navigational qid navigation? qid inoperative for parts navigational radar Navy Primary Standards Navy Secondary Stam@ards navy standard flange n8vy type near face near side necessary needle mga t i V. negative
mf sk
NAY NAV NAVARHO NAVCM NAVSAT NAVAID NAIOP NAVAR NPS MSS NFL NT NF NS NE C NK NOL NEG
nav nav navarho navcm navsat navaid naiop navar NPS NS S nf 1 nt nf ns nec * ndl neg nic npn npo negpr nr nrd ntc nts np~n Wnp neil nprn net nl It ntwt ntuk nc ndr
mi
te
mnp t q r me ms mtre
mtrs mtd
mt Rltg m WnJx Suit Sultr m w mlt Sp mte mv mum MUG h mi mzl mv nyc viz npl nar nb nbdf x f9 natl NAS NAS Nc NEC NECS NCSC NEF NF N NF NW UP NS
f~ance
converter
NIC
NPN NPO NEGPR NR NRD NTC NT S NPIN NPNP NEIL NP RN NET NL Lt NTUT NTUK NC NOR NEUT NEUT NTN N8 S
WUltivtbrator
mnitions susic wire ~sic Wire Gage mustard gas wtual inductance nuzz 1e nuzzle ve?ocity naceI ?e name 1y nameplate narrow narrow band narrow band Oicke-fix narrow gage matfonal National Aerospace Standards National Aircraft StanctarcYs National coarse (thread) National Electrical Cede National Electrical Code Standards Safety National Electrical Code qxtra fine (thread) National ffne (thread) National form [thread) National formulary Nattonal National gas outlet (threadl Ithread) pipe Nat\onal Nattonal special (thread}
neu t neu t
ntn N8S na nha nk 1 n ~cop nca w ni sil ns nl ntm nr 1
NA WA
NKL NICOP NCA NP
NI SIL
NS NL NT M NRL
locker
---
MIL-STD-12D 29 hy 1981
TERM
nfpplc nltrfde steel nl trostarch no bfss frelay) no change m Cof ) no connection no control circutt contacts no drabftng m good no tndtviduat requirement no later than no Iosd m load frame tim no smintenance required no message no voltage release nolso correlation qqulvalent flux notse densi ty power noise e+qufvaient no~se equivalent power denstty qquivalent t~erature notse nots8 factor [figur8} notsc figure nots~ fr-quoncy notse generator nois8 indmx noiso load rat10 notse meter nols8 power ratio nolso rztio no 1ead namnclature nomtnal non track bmtle scan nonc~stible noncorrosive metal noncoup?ed nondestructive evaluation nondestructive Inspect Ion nondestructive read-out nondestructive testing nondtrectionai beacon nonelectric nonenclosure nonflansnab Ie nonf used n0nhygroscof3 ic nontnteeference basis non] tnear nolmlfagnet ic nomtalltc nonosclllatlng nonpetroieum qrocurabl e nonprope!led nonr=actlve (relay) nonreinforced concrete ptpe nonreplenishable demand nonrwturn nonr=turnto-zero
ABBREVIATION
NIP NITS7L NITROS NO MC MC %CCC No m NIR NLT NLO ?fLFT mR w NVR NC NCFD NEP NEf$O NET Nf Nf Mf NGEN nip nitstl nl tros * NC nc nc noccc nd ng nlr nlt nld nlft nmr m ,I{r nc nef d nep rwpd
TERNI
nonsynchronous ~ntight nonuatertight norms 1 normal charge normal circular pitch normal dlametral pitch normal fuel oi) tank normal lube Otl tank normal overload q ngle normal pressure normal t~rature and pressure normal~ze normally closed normally open north nose fuse nose landing gear not sppltcable not available not earlier than not tn contract not {n stock not otheruise identified not othe-ise specified not to Scalm notched notice of r-vision nottfy novelty [insull Novenlaer nozz 1e nozzle control un{t nuclear nuclear detection ruclsar detection satellite melsar megnatfc resonance fwclear magnetren nuclear reactor nuclear weapon b$ologlca! chemica nucIe8r. nwber -er of bits -er of passes nund3er of rejected initial pickups wer of transfer units ~r of words tier of words per entry ~eing ramera 1 numerical ?n!mleT=lcal control nut plate nylon nylon (tnsul) object object glass objective obligation obl Ique obscure
AIIBREVIATION
NONSYN NT NW MRM NL CHG NCP NDP NF T NLT NOL NP A NTP NORM MC No N NF NLG NA NA NET N!C MIS NOI Nos NTs NCH NOR N7FY N Nov Noz NCU Wc t@lOET NOS ?4MR w NR NW N8C No (N) NaP NRIP nons yn nt nvt norm n] Chg ndp nf t nlt no I npa ntp
norm nc no
net
nf nf nf ngen nl nlr m npr nr nl nomen nom n tus ncowb 1 ncpld MOE No!
ndro NOT
NI
NLR w UP R M NL fI#MEN NTws NCONBL NCPLO ?UIE No! NORO NOT Moe fWLEC NENCL NONF LW NFSO w
N nf nlg na na net nic nis noi ms nts nch nor ntfy n Nov noz m nuc nude t
nds nmr m
nr flu
N6C no
(n) nop nrip ntu nwde~ nog num rum MC ntpl ny 1 n obj 09 objv obln Ob 1 ob Og 1 Oug 1 obsv Obu Obs obs obs t ob~tn
NIB
NLNR WAG w *SC NPET NP
nonreturn-
to-zero-change
nonreturnto-zerolevel nonreturnto-z~ro-mark nonrwversi ble nonsatell~te identification ftons81 f le nonswviceab nonslip tread nonstandard
NP NR NRCP NRO NRETN NRZ NRZC NRZL NnzM NRVSSL NS I NSLF NS MST NONSTO
ne!ec nenc 1 nonf 1nf sd nh n~b nlnr nmag nm nose npet m m nr nrcp
rrd
WU NW
NWOEN NOG NW
WM %
NTPL NVL N OW OG OBdV OBLN OBL 08 OGL OWGL 08SV OP OEM 08s OBS 08S1 OBSTN
50
.-
AFM3REVIATION
*vors@ occuw t 1on Occupy octagon octahedra I octal octal print Ott qne Ott ober 08V obv
TERM
open open end hearth op~n ]otsted open loop circuit open type control contacts open ventilated open window unit opener open 1ng opens 1de overate operattng (operational ) contro) prf3ca@ure operating characteristics
Ai3RFZEvlAT10N
OE cm Qd OL Otccc Ov Ow OPR oPNG OPSO OPR OCP Oc OGE OSP ::N O&c Olm OPM OPNL Oe
Occ
Occ
OCT 0CTAt4DR
Occ Occ
Ott octahcr Oc t
oh
8J 01 0 t ccc
OCT
punch
OPP
OCT OCT OCT ODOM 07$ oFFm OFCE OFCL OFs OAP ODOP oPPR O* Cn 00RNR OCHR Oca OCR OCLNR 0CON7 OCLD OCLR 00IFF ODPSK OFLTR 01 OIWC 01 OIFC OISC QLVL ON(IZ OPN OPLG OPRS OP OR OSCRN OSL OSP 0s OTK OTG OP 01 00 Oao 0s f 06s 0W41 OMNIRANGE ORDIR Oc OVE SP us OSMV 1STG l/w Iw OPXL OPA Oco 00P 00PP
Ov
Ow opr opng opsd opr Ocp Oc OGE Osp 0s opn obc
obm
Ott
Oc f
Ott odom
Otp of fen ofce Ofcl of s Oap Odop Oppr ohm cm ohm obrnr ochr Ocb Ocr oc 1nr ocont Ocld octr Odiff oxsk ofltr Ot Otuc 01 Oifc Otsc
operattng operattng
operatfng operation operstion operatton operatfon
operational
operational tnstructfve operational
OAIDE
OSR OSE OTbE OWS OPCOM OPR OPRT OPPtJR OPP OPP OPP CE oPP FIND OPP PE OPT OPTAR OPT AX OCR OPDAR OFG ORD UPT oWF OPTL OPT OPA URN o
opm opn 1 oatde osr OSE ot8e ows Opcom opr oprt
opposite
cofmrutator
end
Osp 0s otk Otg w Ot Od Oel Obs Omnl cwmirange ord i F Oc ove SP 0s Osmv Istg 1/u lW Opil Opa Oco Octp Odpp
ofnnlaeartng itiicator omibearing selector omntairect$on omnidirectional radio range Omnfrange d!gftal radar
on center on vehicle equipment one pole one shot one shot Wltlvlbrator one stage one way one-wf re opalescent tndlcattng ltght op8Que open close open open dripproof open drfpproof protected
opposfte hand opposite pulley end opttcal automatfc ranging optical opttcal qxis optical character recognition opttcal detection qnd ranging optical frequency generator opt~cal rotary dispersion optimum optlmun bforkfng frequency opt tonal abDrl Optfonal {altn optoelectronic pulse q ~)ifier orange orange (attn qbbrl orange indlcat~ng light orbit determination and attitude reference vehicle orbital Zttltude qnd maneuvering electronics Orbftal determfnatton module ortstttng qstronom~cal
OIL
00VAR OAME 00M OAO OGO Ov ORD ORO QwAVE
AI3I3REVIATION
ORO 00 OR ORG ORG ORIENT ORF ORIG ORIG OEM
0R16 ORN Osc
TERNf
overf 1ou overfrequency ov8rfrequency relay ovwhanglng overheu 1 overhaul and repair overhead over I qp overload overload gross weight overload relay overpower Overpressur tzed override override control bits overrun oversize overspeed overtone overtravel overvoltage owl doppler null {fier oxide Oxtdlzed oxygen oxygen breathing apparatus ozalld print pack p8ck qge pack t ng paCkt~ Crating and handl~ng pad qnd boom (refuel fngl padder (capacitor) pad tock printer pafnt painted patnted base pafnted ~tal patntlng stringer paints qnd otls patr pallet pa-h I et pan head pane I panel point panic bolt panoramfc panoramtc radar pantograph pantry paper papw (coti form) paper (fnsul) paper base papm- tape
page page
ABBREJIATION
OWL of OFR OVNG OVML 06R OVHO 01. OVLD OGW ORLY OVPWR OVPRESS OVRO Oca OVRN Ovs OVSP 01
OVTR
o ord od or org org orient or f Orfg orig Oem orig orn Osc Oscg Osc Oscgrm cro Oscg scope Ofp oda 0s Oz 02 fn Otoo w Ou tbd outer m w Obe of t out ogr Og t Out Og t out oa ob Oms or osr outxl out z Odt of oha Oml o/m or Oslly Ott 0s I ovh Ovp Ov osbd oth oa oat ov rm Ovbd Ovcst Oc ocr
OSCG Osc
OSCGRM CRO OSCG SCOPE OFP 00A 0s Oz OZ IN OTOO OF OUTBD OTR OM %E OFT OGR OGT OUT OGT OUT OA 08 ODU OMS OR OSR OUTXLTR OUT Oc of) 00T % OML O/M OR OS8Y OTT OSL Ow OVP Ov Osao OTH OA OAT OVRM OVBD OVCST Oc OCR
tr
paper
tape
reader
paperboard parabola parabollc paraboloid parachute parachute low qltttude dellvery system parograph parallax paratlel parallel (altn qbbrl paral181-to-ser\al parsmeter
Ovv ODN Oxo Oxo OXY OBA o/P PK PKG PKG PCAH Pie PAO PL P PPTR PNT PTO PB PMET PNT STGR P%o PR PL1. PMFLT PNH PNL PP PANO PAN PANAR PANT PAN PPR P P Pa PT PTQ PBO PRB PROLC PRBO PRCNT PLAOS PARA PRLX IJRL PAR P-s PRMTR
Ovfl of ofr ovhg ovh I 06 r Ovhd 01 ovld Ogu orly ovpur ovpress ov rd ocb ovrn Ovs Ov Sp Ot ovtr Ovv Odn Oxd oxd Oxy oba o/p %9 pk g pcb h p/B pad pl P pptr pr1 t ptd pb pme t pnt stgr p130 ;71 pmf 1 t pnh pn 1 PP panb pan panar pan t pan ppr P P pb pt ptr pbd prb prb I c prbd preht p I ads para prix pr 1 ---p-s prmtr
52
MXL-STD-12D 29 my 1981
TERM
peak to valley pedesta I pee 1er pe 1orus pelorus stand pent i 1 pending pending availability ~lar penetrate pmetration radar pennant pennyueight pehtaerythryte tetranitrate pmtagon pentod8 pentratlon per (between words) percent percent i~edance percussion perfect perforate performance performance qnd cost evaluation performance qvaluation and review technique PerfO171aftC@ Opnl and Maint :~rds for Electronic performed perf~ter q cquisition radar peri-ter period periodic periodtc permanent magnet peripheral peripheral Comand indicator peripheral input tape peripheral unit (cowuuters) per~scope permanent permanent echo ~~~nt magnet (speaker) pe~nent magnet movable cot? permanent manufacturing information permeabfltty permeability invariable permission p@_lSsiv@ action link perpendicular person personnel personnel carrter perspective petroleum petroleum. oils and lubricants pedter phantom phartnactiogfca 1 pharmacy phase q ngle voltmeter phase phase coherent phase conveesfon and step/down phase line I phase locked 100P
q
TER$l
parametric q rrpltffer Oarametr$c qrtlf~ctal talker parametric synthesis paravane paravane and stores crane parcels perchmant parenthesis parity bit parkerized parking parkfng orbit parkway part part failure rate part nwmer part of partial parting line [castfngsl partftion partly parts catalog parts deletion list parts kit parts ltst parts per Ofllfon parts per mil]lon party mssage passenger passing scuttle passing Windw pessfvate ~ssive passive active data stnulation ~SSive atrborne detection qnd ranging passive angle track p8ssive correlation qnd rmglng passive countermeasures passive detection passive deteetlon and location of countermeasures passive cletectlon and rang Jng passiva ranging doppler paste pas tey pa tchboard p8tent patent pending pathological pstrol ~ttern pattern recognition interpretation ane correlat~on p=y load payment peaceat locker peak power peak qnvelop. peak tnverse (reverse) vol tage peak operating voltage peak pulse power -k reverse voltage ~=k tO peak
ABBREVIATION
PARAMP PAT PARSYN PARV SEE BELOW PLS PCHT PAREN PUIT P ARK PRKG Po PKWY PT PFR
PN P/o PART
ABIIREVIATION
P-v PE9 PELR PLRS PLRSTN Pcl. PENO PA PNOLR PEN PENRAD PNNT OUT PETN PNTGN PENT PEN / PCT % IMPO PERC PERF PERF PRFM PACE PERT POMSEE p-v pad pelr plrs plrstn pc 1 penal pa pndlr pen penrad print Wt petri pntgn pent pen / pc t % i-d pert perf perf prfm pace PERT PoMSEE
parawq3 pat parsyn paw SEE BELOW pls pcht paren pbi t park prkg guy pt pt r m pio part pl ptn pt!y w pdl prtkt pi ppb Pm pty pass pass ps P psvt psfv pads paadar pat pacer PACN pci PAOLOC
PL
PTN PTLY Pc
PDL PRTKT PL PPcl PPM PTY PASS PASS Ps Pw Psw PSIV PAOS PAADAR PAT
PACOR PACM
perf per } pacr P pa-d ;ntl ? pc i plt w per is perm pe pm pm pm i perpermtnvar perfn pa 1 perp per pers pc persp petro po 1
Pu
PERIS PERM PE PM PMMC PHI PERM8 PERMINVAR PERU PAL PERP PER PERS Pc PERSP PETRO POL PwTR Pm PHARMACOL PFiAR PH PAV Pc
WCv-so
Po PAOt.OC
PAOAR PAROOP PST PST PCHBO PAT PATPEND PATHOL PTL PATT PATRIC
P?d pm
p?kr pk Pep prv pov PPP prv P-P
putr
phm pharmacol phar ph pav pc phcv - sd pl
PL
..*
**O
a**
paravane
and stores
crane
panrscr
cra
MXL-STD-12D 29 my 1981
TERM
@as@ phas8 Phssc Dhss8 locked oscillator -ter modulation sensitive demodulator *SIS8 Srltft phs=~ st$tft kaylng ph8s8 splltter ptlasm-shtft drlvcr phenul ic phllltps head phonograph phosgene phosphate phosphor brunze phosphorescent photo butt line photo wlttpl~er tube photo optical recorder tracker photo type traveling wave tube photoconducter . photocupy photodiode photoelectric photoelectric cell photoelectric scanner @wztoflash pfw?ugraph photolithograph ic pho~omagnetoelectrlc Photostat phototransistor phrase phystcal on qudit physical configurate on physical configurate ldentif~cat$m phys 1Cs physiological pic$tled qnd oiled pickup ndicator plcXorlal posttlon picture p f ec* pfece mark
p t wee
ABBREVIATION
PLO PHM PM plo phm pm psd psh psk phsp pshd phen phh pnono ;:0s ph brz phos pbl pmt port ptwt pc phoc polio pelec pec pes phof 1 photo Dhetoltth
TERM
ptpet pipette piping ptstol piston p t tch pftch circle pitch dtameter pttcn Ifne pitch mark pttonmter log pfvot p{voted door ptvoted utndow p 1ace plafn plain washer plan pos~tion indicator plan view planar q pitaxtal Basslvated planar (transistor) p ~qne planet planetary planetary orbit plank plann~ng plant In place p I qque plastmr plaster master plaster mockup plastlc plate plate (electron device] plate (tube] plate glass platea platform platlng platinum pliers plotter piottfng plow steel rope plug plug Cuck plug-~n unit plugboard pluggable untt plusE41ng pl~fng and deck drain plunger plus or mfnus p] yuood pneumattc pneumattc test set pneumatic tube magnettc pnpn transistor
logic
A1]13REVIATION
PPE PPE PP PSTL PSTN P Pc Po PL Pw PTMTLG PvT PC) Pw PL PL Pw PPI Pv PLNR PEP PLN PLNT PLNTY Po PLK PLNG PIP PLO PLAS PM PMU PLSTC PL P P PLGL PLO PLATF PLTG PLA7 PLR PLTR PLoT PSR PL Pc PIU PLBO PL U PL.M(! P5ao PLGR PORN PLYUD PNELJ PTS PT PTML PKT PT Po POF PDSO Pa P2B0 PI Pcc ppa ppe PP pstl pstn P F pd pl pm ptmtlg pv t pd pw p] pl w pp{ pv plnr pep pln pint plnty po plk ping pfp plq
PSI
PSH PSK PHSP PSHO PtlEN P+#-l PHONO CG PHOS PH BRZ PHOS P6L PMT PORT PTWT Pc PHOC POIO PELEC PEC PCS PHOFL PHOTO PH070LITH PME STAT
pme
stat pxstr phr phys pca pc f pflys phys { 01 pho pu pp t ptx pc pc * prc ptafd pap
psp
plas Pm
plstc p! P P plgl pld platf pltg plat plr p!tr plot psr pl pc pfu
PXSTR
PHR PFfYs PCA PCI P+fYs PHYSIOL P80 Pu PP!
PIX
pierce
blank
and form
p!ati plank crystal
die
pierced aluminum
pterced steel ptezoelectric ptfpment pfgtaf I pilaster piling pillar pfllou block pilot ptlot house pilot Ilght pilot motor pilot wire pinion pinion end pint ptntle p i oneer pfpe plug pipe rail pipe sleeve ptpe tap pipeline
unit
Cu
PGMT PGT P PLG PLR PLBLK PLT PLTHS PLT I.T PM Pw PIN PE PT PTL PION PPG PR PSL PT PPLN
Cu pgmt pgt P plg plr plBik plt pl ths plt It pm pw pfn pe pt ptl pton
pibd pl u
plm pb dd plgr porm p 1ywd pneu pts pt PTML pk t pt pd pd f
PP9 ;: I
pt ppln
pocket PO f nt potnt detonating po~nt detonat~ng fuze po{nt detonating self destroying point \nftiattng po~nt lnltlatlng base detonating pofnt fnsu)atlng p~lnt of coImound curve
pdsd p{
plbd p! pcc
54
ABBREVIATION
PC
7ER!v
post forming post indicator valve post -ridiera [after-on) post offfce postal posts qnd tf-ers potabie water potent~ai potential dwfce potential difference potential energy potential switch potential transformer Potentiometer potentiometer synchro pound pound per capita per day pound per cubic foot pound-force foot pound-forc8 inch pound-force per brake ho~sepower pound-force per horsepower pound-force per hour
AFIRREV;ATION
P fRM PIV PM Po PSTL P6T PoTW POT Po Po PE Psw PT POT Ps LB
Pco PcF LO FT
Pf PI P! PRc
PST
pc pf pi p{ prc ps t ps pt ptop po I ptb PQGO p/a plrt plzn plz plzd P plcy po I p ~yph po 1yes t polthn ptc ps ptfe peu pvc pon ppt pap pore por port p6s plt ps tt port padre pf t pm posn ---pav pave pavt pcn prl t ptn posn sw ptr psnr pos pdispl ptn pn pnp ptc pntp pnpn poss
p frm
pfv F
po
L8 IN PBHP PHP
Pi-m PM PsF
pstl pat petw pot Pd pd pe psu pt PO t ps lb pcd pc f lb ft lb in wPm phr pm ps f psi psia pslg pwd pwdp pwr P
pa Pad
pound-force
per minute
foot fnch inch inch
PTFE Pm Pvc Pofi PPT POP PORC POR P P8S PLT PS LT PORT PAORE PFT Pw POSN Pos
P AV PAVE PAVT PCN PM!
pound-force per square pound-force per square pound-force per square qbsoiute pound-force per square gage F=-~r passing -r -r (cform) nplffter POWer q ~ltfier driver power q power qnd Itghting power qnd lfgnting Uistr$butjon power cathode follower pwer C~rCUit breaker power control and distribution power control unit power conversion powr dlrect!onal relay power distribution powr driven power factor factor meter power
PSI PSIA
PsIG Pwo
PWOP PWR P PA PAD P%L PBL DISTR PCF PCS Pco
Pcu
dtst
power
power power powr powr
line
carrier
PIN
POSN SW PTR PSNR
Pos
operated oscillator package plant power spectral density power supply power supply [cowb form) power supply control unit power supply untt power switchboard powr takeoff power Untt powrhouse practica praanpltfter prearm preben t
Pscu PsiJ
Pswetl
pcu pc pdr pd pdvn pf pfm p!c popd po ppk g PP Psd pwr sply ps pscu psu pswbd pto
pu
pwrh prac pruanp pa prbnt
prcs t
precast precedence
Qrec
55
AIN?REVIATJON
PRU+ PPT PRCPTN PTTI PRCN PACE PAR P6R PIRT PRELORTR PME PVOR PVR PRED PMG PRcrA8 PREF PFD PREF PRFCS PREF PREFMD PFB P!ft PHR PINSTD PACE PLSS PRELIM PREM PPE PRMLD PEd PREP PREP PAL PRESCR PRES PRESSAR PSVTN PVMTD PSVTV Psv PRE-S PRS PRFT P8D PRSD PRSO MET PRSR PRFT PRESS PA PG PR PRV PSL Pv PvT PP
PRSRZ
TERM
prfce qnd q vallabtlfty primary prtmary qddress code Prfmary Coolant System Prl~ prfdrfver prima mover pr tmr priming princ~pal print pr~nted prtnted Cfrcuit printed Circuit board printed wfring p?lnted w~rfng board q s5ent21y printed-wlrtng printer prlnttng prtntout prlortty prlortty data reductton prt SWI prtvate prtvate automatic branch q xchange q xchange private qutomatic private branch exchange private I\ne proaable probable error probe prob 1em procedure proceare s~gn proc-re word proceed 1ngs process process Specfflcatton (no nuber ) process specification (w/ -er ) process water cooler processing processing un$t processor tape read procurement procurement (altn qbbr) procuresx?nt 18ad time product pro*ct configuration Identification pro*ct posttlon~ng tfme production pr~ction coqresslon capab~l Ity promct{on estimate card pr*ction illustration production order professional profl18 profile angla program program change dec{s{on program change proposal
prev ! -s
ABIIREVIATION
PREV PbA PR 1 PAC Pcs PRM PD PMVR PRMR PRM PRIN PT PTD
Pc prov
prch
pp t
plha
pr 1 :::
pm Pd pmv r
pvor pv r prwd Pw prefab prqf pfct pref prfcs pref pref * pfb pht phr pinstd pace piss prelim prem ppe prm 1d
pe
PA8X PAX PBX PL PROB PE P PROB PRCIC PROSIGN PROWORO Pnoc PRCS PRCS SPEC
Ps
pv t pabx pax
pbx
pl prob
pe
P prob proc pros f gn proword proc ores prcs spee Ps pvc prcsg procu ptr prcmt ---plt Drool Pc I pp t prod pce pe card p/1 po prof pf pa prgm ped P=P pc pdr pe pt pmt
psv pre-s prs prft pbd prsd prse met prsr prft press pa P9 pr pn
ps 1
PPT PROD
Pcc
pressureproof pressurize
p-en t p-entlve prevtw maintenance
PVNT PM Puvw
pv pv t PP prsrz pvnt pm
prvw
MIL-STD-12D
29 TER$4
Pqr~~ -n~torfw qnd diagncsfs ion p~ogram of tnstruct program register prografmnable integrated control equtpment programmable logic qrray pregram9nable logic controller prograwsmble read-on!y me$lmry programmable unijunction transistor programed instruction progranwner progra~tng prograrmning language 1 progress progression project wtndow projected projectile projection projector promote proof (projecti ?e) proof shot proofread propane propellant propelled actuated device propellant propellant and monitor cent ro I propellant transfer system Droool ler propoller horsepower propeller order propel lef= revolution Propeller Revolution Xnd*cator System propelling property property line proportion proportional l{mit proposal proposed proposed change proprietor propulsion prosthetic protect protect protective prOt~tiVe device protosynthex index prototype protractor prov i dm prwfng grouna
proviston provisioning parts breakdovn performance
My
1981
ABBREVIATIO.N
Pm pot Pox PRGM RGTR prgm pice PICE P(.A P LC PROM PWT PI PRGMR PRGMG PL/ 1 PROG PROG PROd
Pw
ABRREVIATION
PB PLB Pa Sw P1.RO Ps PLR PUL PE Pc PLSN PLSR
plb * Sw
PLS
PUAR PA PACN PAM PAMFM PCM PCMO PCMFM PCP Pc PC7M PO Po POM POMFM PF PFM PG PGRF PIB PIE PISAB PIN PMM PM PPH PPMIN PPM PRN Pf? PRI PRM PRF PRP PRR PRT Ps PSD Ps PT
PTM PCF Pw Pwc PM) PWE
PMC PTS PROP PHP PRO PRV PRIS PROP PROP PL PROPN PL PRPSL
PRPSO
prgmr prgmg PL/1 prog prog proj w pjctl pj tn pj tr prom prf ps prf rd prpne prplt prop pad pm P7S prop Pw pro prv PRIS prop Ppl propn pl
prps 1 prpsd pc prop
plrd ps plr pul v F plsn plsr pls puar pa pacm parn pamfm pcm pcmd pcmf m pep pc pctm pd
pd
pfb
pie ptsab pful pm pm P@h ppm t n ppm prn pr pri prm prf prp p~r prt
ps
PROV PG
PROV
provisioning schedu 1e
PPB PPS
prox!mity Ifuze) proxtmity uaening Indicator pseudo-random no~se public address puoltcatton publication (altn abbrl pull qnd push plate
VT
PWI PRN PA PUeN PU8 P6PP
Vt
pw i prn pa Pubn -..--
PWM
PTMUX
papp
57
KIL-STD-12D 29 My 1981
TER.$4
w
ABBREVIATION
PMP PDISU4 PHRHO PMPSCT PQt P-o PPT PT PCHG PURCH Po PR Pos PWTR PRG PM PRFCN PUR PRP PIL PRP P9 PB STA PP PRO PTT PYR PYGN PY ROM PYRO
00W4T
TER.M
~atmrnary quenched quest Ion questfon qnd answer quick qutck q cttng qutck break ~ick cleanlng disconnect quick change qJfck engine qutctc flrtng qick ftx tnterf~~nce reduction capabtllty c&lick look quick look intermediate @Jick make, qutck break ~tck opening device qufck reaction q lert qufck react~on capabtllty qufoscent qutet qutomat{c volume control ~fntuple
AFIBREVIATION
QUAT QUEST ObA OIK QA 08 Oc Qoxsc OEc or OFIRC tape QL QLIT QMQS 000 QRA ORC QUIES QAVC
dlsctwrge h@-u)tC
ram
hand
dr t vm pump suct$on
punch
*rich dte punched pap-r punched tape
tape
ppt
pt
-~~fw
pchg
purch Po pr pds pb+tr prg prng prfcn pur ;7? Pf-P
qf qfirc
ql
purge
purg f ng purtftcatton purl f{er purple wmle Indieattng
ltght
~lre sta $ w prd ptt pyr PYW py rem pyro wad qdrnt ..*qdrtr
w quaur qt :; 1
~otatton
WIN OR
OUOT WOT RAB RK RDR R RAM RAVE RA RADVS RATAN RAPCON RACON R8S R8DE RCM RAOC8f RC I RO RAOCON RAOAT ROF RAOIST
REAO
pyrotechnic
~rang te ~adran t quadrant {altn qbbr) ~adrature ~sdrsture modulation ~adrup Ie ~adruple thermoplastic ( Insul ) ~allftcatlm quallffed products list ~slltattve qaltty qalfty qssurance ~ality characteristics list qalfty conformance inspection cpal~ty control ~altty control reliability ~allty deftcieney report ~allty evaluation ~al!ty verlffcatfon tcsttng qantttat~ve qant 1 ty ~nttzed gate vlueo qmnttzed pulse posltton q ~lfffcat!on by ~antum sttwulated qm?sston of -adiatton quarry qwrry tile base quarry tile floor Warry tile roof
W4D
QORTR ON OUAOR 07 WAL. QPL OUAL OUAL 9A
QCL
Ocz ac OCR QDR QE QVT QIJANT OTY OGv QPP OUASER
Wotient rabbet rack radar radar (cform) q bsorbing material radar q cquisition visual radar trackfng extpment radar q lttmeter radar qlttmeter and doppler vclocfty sensor radar qnd tol-viston qtd to navlgatton control radar qpproach radar beacon radar bowbtng score radar bright display ~tpment radar count-measures radar countermeasures qnd deception radar coverage Indtcator radar data radar data converter radar data transm{sston radar d~~ection finding radar d~stance tndtcator ugmentation radar echo q
device
rsve ra
radvs rstan rapcon raeon rbs rbde RCM R&DCM rc t rd radcon rada t rdf radist rwad rafax rh t rtp rt
wart
quarter ~arter quarter
~arter
cede
generator
QRY 070 QTF QTR OT QTR f/4H 1/4PH l/4Ro QTRS OTZ ORCG
radar radar radar radar radar radar radar radar radar radar radar
facstm$le transmission hetgnt tndtcator point ldenttf~cation fnput Input control input drum tnput mapper Intel 1 ~gence Intermittent laydoun del Ivery ltne of sight
RAFAX RflI RIP RI RIC RID RIM RAOINT RINT RLD RLS RLAOO Rf4M RMGF RMLR ROFT ROT
r{c rtd
rtm
r}s r Iada
rnws rwgf rmlr raf t rot
l/4rd
qtrs qtz qrcg
58
MIL-STD-12D 29 ?hy1981
ABBREVIATION
radar operator radar out Of battle q nalyzer radar performmce radar planning device radar prccipi tat~on integrator radar qual~ty control radar sfmulator ra~ar start radar target tdenttftcatton potnt radar target material radar threshold limtt radar tracking errer -asureman t radar transmitter radar trfgger radar wind radar wind sounding radaroptica 1 radi qc rsdlal radfant intens~ty RO R09 RPA RPO RP I ROC RSIM RST RTIP RTM RTL RTEM ROR XMTR UT R6WIN RAWINOS RAOOP ROC ROL RIM RAO ro rob rpa rpi rqc rsim rs t rtip r tm rt I r tem rdr xmtr rt rsul n rawi nds radop rdc rd I rim rad re rs radn ram rd fad i ac rad rint rtt rdtr rad rar rafar rbn radchm raday rada 1 radar rdf rdi rasar haz radioactive radtograpitfc radiological rad{ologtcal radtologfcal radiological
AJIIIREVJAT?ON
RALW RAD INSP RAOL RAOOEr RAOMON RAOWAR RPF RAD R R RL RLCR RHO
RLG
ralw
rad
lfWp
radl raddef r admon RAOVAR rpf rad ---r ---rlcr rhd rlg rr ry rt rwc rsd rf rfd rfh rmj rndm ra i
-asurenwnt
radt qte
RE RS
RAON RAM RO RAOIAC RAO !4AZ RINT RT1 ROTR RAO RAR RAFAR RBN RAOCHM
RADAV
RR RY RT RWC RSII RF RFD RFH RMd RNOM RAI RAOEM RADAS RAPCOE RASTAC
RANCOM no
rf rf a rfc rf i rin riv rifi ri 1 rm i rn rnf rnv rad opr rtlg rt rte! rtt rtty raact
RAZEL RC RDNU REP RF RHI RI RA LT RM RMAX Rod ROTS RRI RS RS RTD RTOT RT RU RAVEN RAC RAM RF RR R7M
It
rm
rmax roj rots rr i rs rs
rtd rtot rt ru
raven rac ram
r+
R77
RTTY RMC7
rapid
rapid rapid
fire
rectilinear tuning magnetron
rr r tm
59
MIL-STD-12D
29 Slay 1961
TERJ%l retchot
rate
ABBREVIATION
RCHT RT RC rch rt rc rrrv rat rv rtg r rttl rm rtws ru raydtst ryn ra reac rctn RCS remctv reac rfm rva rvm reac rc rco rd ra rom rpr r-w rdr rcc rtc rens rdng rdou t rlr rdy rf { rs rancid rt radot rtcu rtdd r t ddc riot rttv rmr rc rv
TERM
recetve only tape perforator recm t ved rece~ved (altn qbbr) receiver receiver operating character! sties recetver transmitter recetver transmitter ~lator recelvtng receptacle receptacle (altn qbbr)
AIlllREVIATION
ROTR RCVO
RECD RCVR ROC UT RTM RCVG RCPT RECP RCPTN RG REC REC RECHRG RECIP RECIRC RCLMG RCLD
rate of
change rat. of rise of Vol tage r-a t cau rated voltage rattng ratio
recovery
RRRV RAT
rotr rcvd ---rcvr roc rt rtm rcvg rep t ---rcptn rg rec rec rechrg reclp rec 1rc rclmg rcld reel o recog rc 1
rec mecn
f-attai 1 mu meterl
mu tape submoa}e raw water reuh t de ray path distance m yon rayon ( insul j reactance -act ion reaction control system reactivate m8ct i ve reactfve factor mater reacttve volta~ere nwter rnmctfve voltmeter reactor ca~artment re8ctor -actor core read q mlffier mad ~ only memory md prfnter read wrtte (head) read write ctmqute reader contact twader comon reader tape contact i ng -* t -adout qnd relay ready ready for tssue ready service -8) qnd not cerrected data tnput
mal read mad t ness
aI write
recept 1on
reception good recess recessed recharger reciproeattng mctmulate rac)afmfng recltned rectosfng recognltton reco i 1 fnecnanism recotl racoflless recowwnd ion recompress
recondense
RC RCO RD RA ROM RPR R-W RWC RDR RCC RTC ROMS RONG ROOUT R/R ROY
RFI
RS
RANCIO RT RAOOT RTCU RTOO RTODC RIOT RTTV RMR RC RV RSN REASSU4 REASM REASSV Re8T RECALC RCL RCP1
recondition reconnafss qnte recmnatssance (atrcraft) reconnaissance and security line record record qnd report Mcorder record t ng recordtng ansneter recordfng demand meter r~ordlng kilovolt-a~ere inter recording opt$cal tracktng
RECONO RCNOT RECON R RSL RCD RAR RCDR RCOG RANN ROM RKVAM ROT1 RTM RVARM RECY RCVY REBE RCN RECT RECT RECT RR RCUR RED R RFNA RIL REOSG REDWN ROC RCHG RHP ROCR RDCN RG RA RHK RE RED&P REV
rcdr
redg ram rdm rkvam roti rtm rvarm r8cy rcvy rebe rcn rec t rec t rec t rr rcur red ---rf na r{ 1 redsg redun rac r chg rhp rdcr rdcn rg ra rhk re redap rey
-al
digital untt
60
TERM
r*l ~ef relief radf{ relief valve rel teve relocated rematnder remedial maintenance remote remote qutomatic telemetry ~lpment remote control renute controi oscillator Refmte Control System job q ntry remote q nomaly remte magnetic detect ion remote performance monitoring remote performance monitoring and control remote-plan position indicator remoto position control remote power control remoto timing qnd data Uistrtbution remote volume control removab 1e removable cover remove ~ve qnd replace render safe procedure mneuab 1e reneua I data renewal parts renewal parts }eaflet reorganize reps f r repeat repeater repeating coil repel lent repel ler repet~tfon repetitively pulsed plasma accelerator rep 1qce replenishing replentstwnent replenishment at sea report report program generator represen I reproduce reproducer
ABBREVIATION
RLF RR RV RLV RELOC REM RM i?MT RATE RC RCO
RCS RJE REHAO RPM RPMC RPP: RPC RPC RTDD REVOCON REM REM COV RMV R&R RSP RNW8L RNL
RCS rtv rv rfcr ref re f ref des ref 1 rn rp rfnd ref ref 1 ref Id rs i ri refl roe rflx rf rc rfgt refr re f rd ref r rmh rf 1 rfs regen reo regen rgn rgtr ---rgf n] rd rglr ---rob rg \ ---rgl td rgltr -..* rhr rvp reiwb re f nf rc
rccp
rlf rr rv rlv re 1oc rem rm milt rate rc rco RCS rje reread
rppi rpc rpc rtdd revocon rem rem cov rmv rhr rsp rwb 1 rn 1 rpd rpl reorg rpr rpt rptr rptc rplt rplr rptn reppac rep 1 rplng rpnsm ras rpr t RPG rep repro rpdr repro ru repro repb rplsn req ree re { rpq rfp rfw req rl reqd
electrical
regenerat lve reg 1on regi ster register (altn abbr) regfster fn) stages register drive r~lar /altn qbbr) regular re~tar overhaul regulate regulate faltn abbrl re~lated regulator laltn abb~) regulator reheater retd vapor pressure rei~urse rein$orce reinforced concrete reiftfurced concrete culvert
pipe
RPO RPL REORG RPR RPT RPTR RPTC RPLT RPLR RPTN REPPAC RCPt, RPLNG RPNSM RAS RPRT RPG REP REPRO RPOR REPRO RU REPRO REPS RPLSN REO REC
RCCP RCP RTL RST REU RLT RLTN REL R9E RH RIOMETER RLXN ROOT Ri.Y RB RLSE REL RELBL
reinforced concretpipe reinforced tfle Ilnte? reinforcing stee) reject relate relation reiative relatlve biological qffectiveness relative humidity relat~ve tonospher~c opacity meter relaxation relaxation oscillator optically tuned relay B1OCM relay release release (altn abbrl reliability
r!t
r)tn re 1 rbe rh riometer rlxn root rly rb rise ---relbl
RE1
RPQ RFP RFW REQ RI REQO
HXL-STD-12D 29 ?hy1981
TERM
rc~lred for operational capability req I refnent requistt+on nd rest t rescus boat rcscuo rescue q qutpfmnt loctcwr research and development resoarcn research qnd tectwwlogy research Oevelupment test qnd qvaluation res~attng reserve reserve feed water reserve o~l tank reseevoir rsset gate reset inhibtt drum reset-set trigger res i *a 1 q quivalent return restxal 10ss resl-al ?ield restl lent q ncapsulated mfca resin capacitor resistance resistance lcost3 form) reslstanc* capacitance resistance capacitance coup 1qd resistance inductance resistance inductance
ABBREVIATION
ROC R~QT REON RESC RSQ RSQBT REL RES RbO Ra T RDT8E
RESEAT Rsv
Ai3BREV1ATION
retrace retract retractable ratrteve retroactive r~trograde retrogress \ve return return head return to b{as return to zero return to zero level return to zero mark reverberation contrul of gain rwerberatlon q lamination reverberation strength reverse r8verse q cting reverse current reverse current devtce reverse gate reversible r*v t W rev 1se revlsfon rev~sfon block r~vlslon proposal revision record revolution Revolution Ind{eating system revolutions per minute rgvolutlons per second revo 1ve
RETR RETR RETR RTRV
roc reqt reqn rest rsq rse re 1 res R&O RAT rQt6e
RfW ROT RSVR RG RIO RST RESIO RERL RES FLD RE$IL REMC RES R RC RC CPLO RL RLC RTO RES RCTL
reseat rsv rfw rot rsvr rg r+d rst res 1d rer 1 res fld rest 1 remc ros R RC RC c~)d RL RLC rtd res RCTL RTL reso 1n rs 1vr rc ret rag rx resn rg t resn rspv resp rsptr rspd rsp rsps resp rs t restr rstr resup ret rtnr rtng retp rtd rtdc retnn rtcl rg
retr retr retr rtrv ret ro retro retrog rtn rhd rb rz rz 1 rzm rcg reve 1 rs rvs ract rev cur rcd
rg rvsbl rev
rmv
revolving
reutnd
rework
rheostat rhodium rhod~um plate rmtc rhomtwtd ribbed rtbbon ri dge rlggtng rtght q ngle r{ght r{ght bank Ftght circular polarization hand rfght r{gttthand drive right hand stale rtght of way ffght side righting am rlgld rtng rtng counter r t nger rlnglng riser
logic
REV RB RP RR REV RIS RPM RPS RVLV RVLG RuNCt REWK RHEO RHOD RH PL RNO?4S RHOMB
rev
rb rp rr rev RIS rpm rps rvlv rvlg rwnd reuk rheo rhod rh p] rhoti Pm r!b rbn
R18
RBN RUG
RGNG R RT ANG
R8K RCP RM RH OR
beacon Ie
retard retardation
retens 1on Petlclc rettculatetY
eoi 1
grattng
RX RESN RGT RES?b RSPV RESP RSPTR RSPO RSP RSPS RESP RST RESTR RSTR RESUP RET RTNR RT?4G RETP RTD RTC)C RETW RTCL RG
RING RNGG R
RIV RVT RVTD RO RSTG RKR RKRA
river
rtvet riveted road roast{ng rocker rocker ruck e t rock-t rockot
RKT RL RT
. 62
TERM
rocket-assisted takeoff nocit-11 hardness rod control rod drive Ro@bling Wire Gage roentgen equivalent marmnal roentqen equivalent physical roll Foefing rolled rol l~r rofler bearing rolling steel door rollon/rolloff roof erain leader roof
ABIIREVIATIOFJ
RATO RN RCONT RDOR RUG REM REP
RR RL.D
TERM
ABBREVIATION
S1
RLR RLR 6RG RSO RO/RO RO RL RFG RM RO RM$ RSS RTRY RTRSW RVOT ROT RPS ROTR RO ROTOMT RTR RGH Ito
RHR RNO RD
RATO Rh rcont rddr RWG rem rep rr r?d rlr rlr beg rsd
rotro
rd rl rfg rm rd rms rss rtry rtrsw rvdt rot rps rotr rd rotomt rtr
rgh
ro rhr rnd ---rtph rdh rdg rdslm rte rcw t ri rbr ---r rb rce rhJ rfnsul r rtf rs rud rao r6p rnr rnlt rsalt rttl ro rwy rv r russ rpvntv rstpf shi ran spa sbx
ROUT WI RSR RU8 R R8 RCC RHd RINSUL R RTF RS RUD RAO R&P RNR RNLT RSALT RTTL RO RWY RVR RUSS RPVNTV RSTPF SHIQAN SPA S8X SOL
safe locker SL safe operating area SOAR safe practice data sheet SPOS uoricing load safe sbiL safe working pressure SNP safeguard SFGD safety SAF safety destructor so safety valve Sv sail srea SA sallntty SAL Sallnlty indicator S1 saltnometer SAL salt glazed structural SGSFU facing units structural unit salt glazed SGSU8 base salt water Sw SWCP salt water circulating purp SWP salt water pu~ saluttng SAL salvage SALV saom size Ss sanqale data so sanple part SP sanple per second SPS saqal ing SMPLG sand blast SO EL sand loaded SL SAN Sa_ ~ch sanitary SAN SAPON Sapontfy satellite SATL Satellfte qctfve nullifier . SATAN operated satellite CWfpUter SCORE readiness equipment SCF satellfte control facility satelllte ~nformation S I POP procedure operational program satellite interceptor system S1S satelllte launching vehicle SLV SORT: satellite orbital track and intercept satellite paper tape SATPATT transfers satisfactory SATFY saturable core ;: saturable reactor
satan scor~
Sef s i pop
i t
sayeolt seconds universal sca 1c scale model scan coherent doppler qttachment
scanner scanner
satfy Sc sr sat St Sg Ssf Ssu Sc scmod scoda scnr Scu scng Sadie SEM sea 10 scadar sctd scav sop sehed Schen
control
unit
visual
range
russ8t
rust preventive
rwstproof S band high qccuracy ranging and navigation nplifier S band power q S barn transponder -la
sd 1
Scannfng SCatWting analog to digital fftput equipment scanning electron microscope scanning local oscf?lator scatter detection and rang i ng scattered scavenge scavenging 011 Pum Schedu 1q schematic
s CNG SAOIE
SEM
SCHED SC?+EM
63
TERM scfwttt trigger Schuler tuning sc t ence qnd technical scientific information sc~ntillator sc 1qroscope
sc!eroscope
AINIREVIATION
ST St SCI STINFO SC!UT SCLER SH SCTR SRPR SRPG SCRN SCD sat G7 NC SCR Scmff SCRTERN SCRWO SCQR SCROti scl.Y SCUP s SF SL8M SL SLS sl.PL SID SLD SEG SMLS SSTU SRCN SITE SRTC SSo S/T SC3+LT StER SEC SEC s 2RED 2STG STAE SEC se SSR SEC SECT SCTR SS1
SABRE
TERM
selective callfng s81ectfve identification f qa ture selective optical lock-on selectlve rlngtng selecttve tape print select$v{ty selector selenium recttfter S-If calibrating self cleanlng sell Clos{ng self contatned underwater self contatned breathfng apparatus self destroying self generating self tndicatlng s=lf loadtng tape Self locking self propelled self sealing so?f synchronous self tapptng self trapptng ventilated self
AI?BREV1ATION S~LCAL
SIF SOLO SR
STP
St St Sc f stinfo sclnt sc )er sh sctr Srpr s rpg scrn scd scr gt hc scr Scrdn scrterm Sertm scdr scScly Scup s Sf Slbm S1 S?s Slpl Std sld seg Slsls Sstu s rch sfte srtc Ssg
s/t
selcal
sff solo
sr
Stp sel sel ;~lf cal slfc!n
seif cI
hardness
scooter scraper scrap t ng screen screen door screen gate screentng smoke screw screw down screw termina) screw thread
SCNTN SCUBA SD SLFGEN SLFIND SLT SLFLKG SELF PROP SLFSE SELSYN SLFTPG ST Sv Sv SELS SMPHR
SAP
scntn SCUBA sd slfgen slfind Slt Slflkg Self Droo slfse sefsyn Slftpg St Sv Sv se]s sn@wSap
(m~xturc)
screudrtver scrcued bonnet scu 11et-y scupper SCuttlSC8 flwd s8a launched balltsttc miss$le 8=8 level sea level static sea lozdtng pipeline seal in device sea 1ed s@81tng Seamless seamless steel tubfng search qe=reh \nformatlm tape equfpfnent Se==m radar terrain clesrance search sfgnal generator search/tracic searchlight seatar secant second second (cm$3 form} second reduction sectmd stage time qround ecim second secondary battery s@cundarY secondary surveillance radar secret
SACE SAGE sahf semicond S8S SCR Scs Sus sen Sf sfprf Sfxd Sfls Ss stir Svtl Slr sdr Sndg sr sen Sa s qbo spr sens sens Stc sntzd Sllp sntzg snsr Sep
Sp 1 sap
Sus S EN SF SFPRF SFXO SFLS Ss STLR SVTL SIR SDR SNDG SR SEN SA SABO
SPR SENS SENS STC SNTZD SMP SNTZG SNSR SEP SPL SEP SEP
Sectton
sector sector scan tnd~cator secure q irDorne -$ng rsdar equiptmnt s-rfng s-cur t t y w~ndow s-rtty guard utndow screefi 8WUFfty guard sodsn s-t -elect Saloct operate sense select register solecttvc automattc -ltortng
semtenclosed semif{nlshed semffireproof Semt f txed semlflush semfsteel sem{traller semfvttal send qnd recelvs sender sending
senior sense sense
bl~k~ng
SECRG SCTY
SGW
and SMSG SEO SEG SEL SEOPSN SEL RQTR SAn
sensftfve sensltlvlty senstt{vlty ttcontrol sensitl?ed sensitized material print sensitizing sensor separate separate parts Ilst separator septewt3er
sap
64
riIL-sTD-12D 29 thy1981
AFHJREVIATION
TER.M
ship Sh!p shtp class Cmtrol course
ABBREVIATION
SMPCL SCONT
Scou
septupl@
sequence seaueme cneck sequence nu~er tndfcator sequential cod!ng sequential collation of range sementlal conponent qutomattc testing phase s~ent$al
SPT
Sp
SEQ
SEQ CHK SNI SECD SECDR SCAT
Seq Scq Chk sn I seca secor SCAT Sp ser sb sb serno ser srly serr serr svce ---Soc Sb srvclg Sf Sfo Sm sn Sps Ss sesame sfa serg *VO servo svmtF sscr setr set setlg 7/c sew sew Sxl sxtn SXt sh sft Sa se sft ext shf tgr Shp s~rf Shk Shp Sc sh shrp Sp shrng sht~ Shv S?l sh sh 1 sd sh 1 shld
sH
ship dtstance
S?ttp Oraft Indlcatt~ System shtp draft Indtcator transmitter Shtp Inerttal Navigational system ship parts control center ship servfce shfp service turbo oenerator ship speed shfp status ship to surface vessel shfpboard shipboard allowance list shtp5uilaer shipfltter shipment shipptng shlpp~ng container shock shock qbsorber shoemaker q ss-ly qnd shop miss{l~ maintenance shop order shore connection shore terminal box shore) fne short short circuit short ctrcult ratio short leaf y~llou pine short persistence short range short range qttack mfsstle short range bs)llstfc mtsslle range dopp!er short range navigation short side shoPt takeoff qnd land~ng short short taper ttme constant shoFt wave short wave fadeout short wheel base short shortage shot blast shots per minute shCU 1der shower shower and toil~t showr drafn shown shra$me 1 shredder shrtnk mockup tqlate shrwd shroud fin shunt shunt trtp shut down shutoff valve shutter stuttle st* sfd9 Ilgnt side low blanking side Iobe cancellation
SS1S
sdtt SINS Spec 88 Sstg Ssp shsts Ssv shpbd Sa 1 shb 1dr Sftr Shpt shpng shcr shock Sh qbs S* r smsa so sh corm stb snln short short scr
slyp Sp sr sram srbm
::R
sextant
sextuple shack I q Stlaf t shaft q hey shaft center shaft qxtens{on shaft gear shaft horsepower Shakeproof shank shape shaped chmrge share sharpener shear plate shesrtng sheathi ng sheave Sheet sheeting shell shell destroying shellac Shfiald Shield (electron shfs?dtng shi~t shift regtster
SE se SERNO SER SRLY SERR SERR SVCE SERV Soc 58 SRVCLG SF SFO SM SN SPS Ss SESAME SFA SERG Svo SERVO SVMtR SSCR SETR SET SETLG 7/c SEW SEW SXL SXTN SXT SH SFT SA Sc SFT EXT SHfTGR SHP SHPRF Sw SW Sc T*P SP
SHRNG SNTHG
SAL SHBLOR SFTR SHPT SHPt4G SHCR SW SH A8S SH~R SMSA so SH COW s7a SHLN SHT SHORT SCR SLYP SP SR SRAM
SR6M swoop SHQRAN !WT SO STOL STPR
shld shf Sr
SLB SLC
shodop shoran shtsd STOL s tpr stltc Sw Swf sub Stltg sh b] Spfn shier Srl sh&t sd shn shrap shrctr smut shrd snrdf sh sh tr sht an Sov shtr sht 1 side %1 It slb SIG
65
MIL-STD-12D 29 -y 1981
TERM
sflobe suppresstem SfdW 100king 81rbOrn0 radar Stlooking coherent qll range focused sfde Iooking radar Stupset jaw Sia Vtev stale water depth S$-nd s f deut rider s$ut~ si~al stgMl qnd homfng light stgnal conditioner $lgnal conditioning q ~ipment convertw signal data signal information qnd mnitorlng stgnal intelligence slgnal ltght bsre stgnal plus noise and distortion signal processing in evaluated electronic dev 1ces stgnal strength sigwal strength center f ~ency sf~al to interference ratio signal to nofse sfgnsl to nofse ratio Sfgnal underwater sound Slgm)fng signed stl~ silencing q uxil$ary sflent cowpact puuer sfltco-manganese steel sil~eon controlled rectifier (see semiconductor controlled rect ) silicon power rect{ffer qlloy stllcon prectsfon transistor slltcon stud mounted cffoee silicon sywunetrfcal su{tch stltWn unilateral dfffused transistor sf!k (fnsul ) S1 lkscreen Stlver stlvbraze Stlvbrazing s1lv= brazfng union silver plate st?ver solder stmflar Slllq>lex S1WC31CX data distribution Uni t radar slnulated qfrcraft data s(wlat@d data generator stwulated data tape sfmalator
A13RREV1ATIOFJ
SLS SLAR SCARF
SLR
TERM
$~wltaneous
tape
straw
Slr
Su.j Sv Swd sb s i wdr Sdg Stg Sah lt Sc see Sdc siam sigint slb s f nad speed
wr I to Stne s~ne of the amplitude stngie single qcetate (Insul) sfngle acetate single cotton ( tnsul ) Sfnglo base solid propellant sl~le beam klystron sfngle cellophane (insul) stngle channel st~lex single conditioning unit
stn
sn Sg 1 I lC
sbsp
SGL
L LC
SESP SBK
K
sbk
k Scs Scu
Scs
Scu 1/c Scc Sc c Scc cos Cs Cv SCYL
EL EK
EG SE SIF
single conductor
Comctor cable stngle contact sfngle cotton ( insul ) s~ngle cotton covered (fnsul ) Sfngle cotton double stlk (tnsul] sfngle cotton stngle stik (insul) Si~le cotton varnish (fnsul) single cylfnder stngle qnamel single acetate (tnsul) single enamel s~ngle Cellophme (~nsui) single qnamel single glass [insul) sfngle qnd single face sfngle feeder sfngle glass f tnsul) sfngle groove (Insul) single groove single pett~coat {~nsul) singIe paper (insul) single pap~r bonded (insul single paper double cotton (tnsul) single paper stngle cotton (Insul ) phase Stngle s~ngle po)e double throw single pole throw single po)e double Swf tch pole sfngle throw sfngle throw Sfngle polo single Swt tcfl single pole switch sfngle pole tripie throw single propellant Ioadtng sfngle rotating knife sfngle shot single sideband sfngle stdeband fre~ency
mdulatlon
Stngle
SDC
SIAN SIGINT SLB SINAD SPEED
Ss
SSCF
SIR w SNR
Sus SNLG SGO SIL SILG SCAP SMS ----
sFDR G
SG
SGSP P 8P Poc Pc 1PH
9 Sg
Sgsp
P w Pdc
pc tph Sp
SP
SPOT SPOT SPST SW
Sss
spdt
spdt
Sps
SW
SUOT
t
Sw
s SSCRP4 S1l.
S8 S8 S8U SIL PL SILS SIM SPLX
Soou SARO
SPST
SW
Spst
SP Sw
Sp SW
Ss
SSB
Sptt Sp 1 srkn Ss
ssb
ssfm ssm Ssbd Ssig s
Sv
SDG SOT
SIN
S INCOM
SS80
sTT T
sl-later
si-ltaneous correlation
conq3iler
mltiple fmage
SIMICOR
ST
66
ABBREVIATION
ST
Sw ST SK
TERM
sock-t head secket veldtng soda founta$n Sof t soft drawn ptpe soil
ARRREVIATION
SCH SULDG SDFTN s SD SP S SK Sc SE? SMEP SMF SLDR SOL SOLV
St
Sw
St
Sltuat ton
sltuatton display converter Sltuatton display gene~ator sketch Stctl led skinned sk 1nner Stt trt skirted skyltgnt stcyuave synchronized long range navtgatton slate slat. (altn qbbr) shingle roof slate s 1eeve sleeve bearing sleevtng sllce slice Slfdtng sliding door slfding expansion Jo+nt sltnger Sltp fit S?IP jotnt sltp r~ng Silt stop sink slope slotted slow fire slow operate (relay) slow release ~r~laY) slow speed s 1owdown slowed down v~dea sludge slug small smal 1 qrms small arms a~nft~on small cal~ber qmmn~tlon small lightweight altttude q quipmSnt transmission
sk sntr sntr sphn sn Slt Sdo Sdg Sk skd sk sk sk t sk d Slt ss loran Slt ---Ssr Slv sb Slvg Slc SI S1
sld
soil stack
solar co]) solar energy thermion~c solar htgtt qnergy parttcles solar magnetic f~eld solder solenoid solenoid valve
solfd
S01 ld body s01 Id fiberboard sol ta height s01 Id neutral rocket solid s01 id state circuit s01 id state S01Id state det=tor state q lectonic logtc solid electronics sol td state state materials solfd state Suitchtw soltd sotuble solutlon solvent sons r sonar control room sonar countermeasures and deoeptton (sonacelle) sonar nacelle sonoswttch soot blower
Sch Swldg sdf tn s sd Sp Ssk se set snap smf sldr sol Solv sol
sb
sfb S01
hgt
Ss Ssc
SSD SOSTEL SSE SSM Sss SL8L
sn sr Ss Ssc
ssd
SOSTEL
sonac
s-
SONOSU S8
SURGE
SOrting *datfm
generating
sound
report
etc
SNO
Sosus
SOOAR SOFAR
Sosus
soda r sofar Slf stlQ sonar sr s rr Sdr Sndg smach St sndprf sce
Snd
SIF
SR sRR
SMP
SONAR
SOR
SNDG SMACH
s-e. xke generator smobIm stand Smoksless smokelass P-der S-O th smOoth bWe smooth cuntour
smooth face structural tfle smooth neck smooth sur$ace builtup smoothtng snatch snorkel smA3ber Socioty Sucket clay
ST SNDPRF SCE s
SOCD
SOA s .5P
s
socd seen sda s Sp
spacecom
sb Sc
Sfsct Smnk ss8r Sm snh Snk 1 snbr Soc Sk t
SOCN
spsce
spaca
roof
and
scat
sph sot se S!* Spcr spnr
spaco
identif~cation
SOI
Sc
lam q dapter
SLA
SPCR SP?4R
67
AB13REVlATION
SP SF SPK SON SPPL SPKR SPCL SPL
5P SP sADM SPCAT
TERM
Spoo I t ng spot fac8
ABBREVIATION
$PG
Sp Sp
Spg
plug Spaakar special special faltn qbbr) -{al ~com form) Speetal (prejectfle) ~ial atomcc demoltt ton wni tion ~ial category spectaf cleaning spectal crouton (pro]ecttle) qquipment special special launch trajectory special purpose special regulations special screu spectal services Spatial shaped special stgnal ccmdftionfng Untt special test system spectsl test unit ~tal treat-nt steel special weapons ~fai uea~ons overllght *tale specialized repair activity
Sgn Spp1
Sptcr Spc 1 ---Sp Sp saspcat
other
side
sPCLN SPC SE
SLT SP
SR
SPSCR SPS SPSW Sscu STS STU STS SPL WPN SWOG SRA SP SFC SP GR SP HT
spe 1n Spc S8 Slt sp sr spscr Sps Spshp s Scu STS Stu Sts Spl WPfl Swog Sra Sp Sfc SP gr Sp ht SIUQ Sor Sp Vol Spec scn Sect spec se S* $11 Sp Speonv Sp lt Sr spreg Spdom spher Scp Spc t g Spdr spk SD Ss. Spd 1 8P? se w Splc sptn Splft S~ ph s? Spl tr Sp Sp
Spectf+c
specific specit~c
spectfic PffiC
s~tl{ght sprayad qcoustical cell ing spray-r Sprayt{ght spreader Sprfng sprl~ier sprinkling Sprock qt s+adron s+ars s~are centimeter s~arw foot s~ara head s-are tnch square kilometer s-are wsh tracktng sware root square root of mean square squarewave s+emzt grip squtrrel cage stabtllty Stabtlizatton stablllzatlon and control systems StabtliZCd local oscillator Stabilized master oscillator
SF SFo W $LT SAC sPYR SPT SPROR SPR SPR SPRG SPRKT SON so so CM sQ FT sol+ S0 IN sQ KM
sf
sfo Su Stt s qc spyr Sp t sprdr spr spr Sprg Sprk t Sqn Sq Sq cm Sq ft Sqb sq in sq km smt sqrt rms Sqw Sqzgr Sqcg s t qby stbln Scs stale stamo stsh stab s tta s tk Stg stnls Sst s twy sup s tp stan std sba sd Sts sia sid slb snl stdzn stby 81 Wr s tdf Sp sep Ss Stbd Ss It St b Sp solb Som somQ sore-h Sm 1
sMT
sQRT RMS sow SOZGR SOCG sTABY STBLN Scs sTALO sTANO STSH sTA8 S10 STK STG
fuel
gravfty heat
consu~tlon
Stabflfzed
shunt
l~lse
=~~~~atfOnal Spectflc Volum Spectftcattorl Specification change specification cuntro) draw i ng spec t men spectral distrfbuttun spectrum analyzer speech interfereme
not~ce
5P* convertor speed I!gflt speed recorder speed regulator ~ter spherical ~rtcal candlepower sp~~cal cartrfdge spidu spike Spll? bIock spin stsetl~zed (rockets) *itilm spiral splash block Splashproof splice Spl Ine Splft Spltt phase spilt ring Splltter ~llttfng Spoo 1
SIL SP sPCDfW SP LT SR
SPREG SPDOM SPHER SCP SPCTG SPOR SPK Su Ss SPOL sP1. se $P SPLC SPtN SPT $P PM %TR
3P SP
stabilizer stablstack s tags stainless stainless steel statruay stake qnd platform stasQ stanchfon standard pproach standard beam q standard ctevtation standard instruction set instmf=nt qmr-ch standard standard tnst~nt departure standard tron Bar standard nomenclature Itst stmdardizat{on standby stand!instruction Standtng wave ratio (voltage) standoff staxtpe star epitaxial planar star shell (Illuminating projectile) stsrboa~ starboard side light start and stop start of line block start of message stsrt of -sSage prlorfty stsrt of RwSsage-high precedence start of message-low precedenc*
STOZN Slav
SI SWR STDF
SP
SEP Ss sTBO SS LT ST b SP SOLE SOM SOMP soM-t4 SOM-L
MIL-STD-12D 29 My 1981
ABBREVIATION
sow
TERhf
strafgttt thread (pipe
Coupltngs)
ARBREV1ATION
NPsc SLF STR STK STRD sTRP STRAT SM NPSC Slf
stattc pressure
statfc self verfflcatton stat ton stat!on keeping ll~hts stationary stator statuary bronze status steady steady state ferret level stmaey state oscillation steam steam engine direct connected steam generator staam working pressure steaming steel stscl bas~nt wtndow steel cadmtunt plated steel wire rope steering steertng gear dual emergency . steer~ng l~ght stelllte
START STG STMT SR ST PR Ssv ST A SK LT STA STTR St BRZ STAT STDY SSFL Ssa ST SEDC STGEN STWP STMG STL SEW SCOP SUR STRG
SGOE STG LT STLT STEN Sxs sTPm SON 6 STU SRD STPR STPG STEREO STER
Sw sta~t Stg
stint Sr St pe
Ssv sta Sk It sta sttr st brz stat s tcty Ssrl SS9 St Sedc stgen Stup Sting Stl sScalp SUP strg Sgde Stg ft Stlt sten Sxs Stpdn Sdn 8 Su Stu Srd stpr Stpg stereo stmr S tdvg St It Stpl Sttf Spp Stun stir stch S tk Sno snsl so stn so s t png stem stor satSt Slw spe Strm Stw sb srod Stwg str SIwl Ss
stenci
-+-
step by step step down step down qnd step up step up step-recovery diode stepper Stepptmg stereophont c sterilizer stern diving stern Itgmt st=rn plane stfffener still picture projector stt-late stirrup Stlteh stock stock nu-er stock number sequence llsting stock order stone stop order stopping Storable tueular extendible -er storage storage address regtster store stor@ logical word stored program element storeroom storm water Oolt stove stove rod stowage Strafght straight lfne wavelength stratght shank
Su
stratght-ltm frewency strainer stratce stranded strapped strategtc strateg{c mfsstle stratosphere stream Strsaml ine street strength stress anneal Stringer Strtp strtp ttn strf~d strtpper Strfppbng stroboscope stroboscope c stroke strokes per minute strong strongback structural structural carbon steel structural carbon steel medium structural carbon steel structural clay tile Stmtural glass structure Stubs Wire Gage studio transmitter link stuff ing Stuffing box subasseut31y subca I 1ber subcarrle~ authorization
ST
STR SA STGR STP S-T STPD STPR STR STBSCP STROBE STRK SPM STRG STREtK STRL
s-t S tpd
Stpr str S tbscp s trobe strk spm strg s t rbk strl scsh scsm Scss Sc t Sg Struct SWG Stl Stfg
sb
hard
SCSH SCSM
soft
Scss
SCT
SG
STRUCT sMG STL STFG se
SUBASSY SUBCAL
subassy
subcarrler osc~~?ator
subject subntartne suemarlne mtne depot
SCh Sco
SUBJ
subca 1 SCA
Sco Subj sub ssubnq Suexrlg sbm submtn subq ssd Substa subs t st3str substr Ss
sue
SMD
STIR STCH
STK SNO SNSL so
submerged
submergewe submerstb! e subminiature subsequent drafn subsofl substation substitute substrate substructure subsysttm subtraction succeeding suet ion sudden cosmic no~se absorption
sum
STN
so
STPNG
STEM
STOR SAR S7 SLW SP E !j7RM SW SD SROO STWG STR SLWL Ss
SCNA SID
SPA SUF suF F Fs SUY
tonespheric
q nomaly
qcid
enable
SMEK
69
.
TERIM ~ary
of tolorant sumsing suming selector Stank sunny SUP,F high fr~~y q pproach super precision r8u*r supercharge superheater superheteradyne superf~sed current superintendent superqJ t Ck supersede supersensft tve supersonic transport Superstructure suparvise super~iston supplement Supp 1y supply Untt support qquipment support Swres s surf qce surface barrier transistor cmtrol led surface 8v81anche transistor surface controlled oxide untpolar transistor surface to q tr mtss~le surf8ce to surface miss{le surface to underwater missf Ie surface wave transmission ltne surfaced or dressed four sides surfaced or dressed one side surfaced or U-seal one side and one edge surfaced or dressed two Stales surge surgical surveillance radar survmtl lance radar q lement radlatlon .Iectronics
AR$IREVIATION
SORTE SUM Ss
TERM
SWtng swtngtng braekat Swlnglng door SUi tch Swttch Palls Switch stand ttes Swftch wound swltchband swtt~ard swttchgear swttchgear block
ABBREVIATION
SWG
SWG BKT SWGD Sw sWR Sws swl w SWD
sorte sum Ss Smtk sny shf spar spehg suphtr superhet Supcur SUpt Sq sup%d supsens
SST
SUTK SNY SHF SPAR SPCNG SUPNYR SUPERHET SUPCUR SUPT SQ SUPSD
(relay)
SWGR
SGE! Swov WM. SYM Svw SYM $YNP Ssw sYNTI Sft SYN
Swsws SST
SUPV
SPVN SUPPL sPLY Su sPRT
SUPERSTR
IND
SS60 SYNC
SYN LP SYN RECP Ssw SYN SAM
Swg swg bkt Swgd SW sbfr Sws Swt Sw Subd swgr Sgb Svov Sw 1 sym Synsn ---Sylqa s Sw synt f sb syn ind sshd sync syn 1P syn recp Ssw syn sam
synch-tze syncbroniztng
synchrontzfng synchronlz$ng synchronous synchronous
law
receptacle sw}tch
SE
SUPPR SURF
SE suppr surf
sb t scat
q ~l
Itude
converter posttton
recorder
SCOUT sam s Sls sum Swt 1 S4S Sls slsle S2S srg surg sr sre Surv srvl Susp s qpc
sate
Synohroscope synopsis synthetic synthetic thermo-plastic ( fnsul ) syPlnge system system check qnd utiilty
suspended
cetling
SR SRE SURV SRVL SUSP SAPC SA7C SPC SSAC SPNSN STNG SWG SG Sw Swsm SUT SWP ExP $WP INTEQ
sow so SUP
s tcw Stu
S1 t
tfle
TCY
TAESOL T/E T/o T/O&E TAB TAO
solutton
organization qnd
Spc Ssac spnsn Stng Sug Sg Sw Swbhd $Wt sup sd S* qxp s+ tnteg
sd~
qxpand
Suemt
Integrator dou@
of of tables of q ~fpmant tabular tabulate tabulated tawlatton tabulator tachometer tachomter tackle tacttcal tactfcal
tactical
tab I e tlu ta td taosol TIE t/e t/05e tq b tab t adr tb tabs Im tach t vm tk 1 t qc TACAN taso
c!rawlng
block
slImJlator voitmter
qir q tr
navtgatfon
support
q lement
70
TERM
tactical atomic demolition nunltlon tactical attaradar qnd nav$gatlon tacttcal Oata entry tact{cal information processing qnd interpretation iacttcal mtsstle tacttcal mtsslon data tactical range recor-r
tactfcal reconna~ssa~e
ABBREVIATION
T AOM 7ARAN TACOEN TIPI
I-ERM
target target target target tar-t target target target target
tarpaul
AllFIREVIATION
TX TIR TGI
TP I TP
t adn
taran tacden ttpt
tal tmd trr trl tse tfz tgt tg tlg tw tal tlpc tlsft to tl tly tdm t qn te tlt td tkr k tan tcul
tapac tape
Identiflcatfon (lluminatiq radar ~ntensifier posftion ltiicator practice pract~ce With tracer radar ranging system data update track!nq radar
~n
tt
ttr tgi tp t
tp
tp t trr t Sdu ttr tarp tps trsr
Intel 1 igence tactteal support tail fuZe tall gate tail gezr
element
gear
ta!ls?laft takeoff talk liSten tal ly tandem tangent tangent q levation tank tank destroyer tanker tanker (aircraft) tanned tap changing under load tape automatic positionf~ qnd control
synthesizer task para-ter taxi qti ~~ay surveillance radar taxtway teamork techn{cal q~ntt{on technical bullettn techntcal circular technical control teChniCal data package Itst techntcal technl ca 1 d+rect~ve manua 1 techntcal note technfcal order techn{cal order CO-1 iance technical report technical technician teeth
TRSR TWY
TW TECH
twy tw
tech tam TB TC tc tdpl TO TM
TN To t Oc TR tech tee t
q utomattc preparation tape em i mnent unft tape control core tape selector tape data tape dlstrlbuter tape dr~ve identification un{t tape Inverter tape t qpe pack phase {nverter tapa~lffier tape pulse tape recorder conversion t qpe station to card tape to nrtnt tape tape-o~ratsystem taper taper pipe thread taper pipe thread (rafltng fixtures) taper snank t appeal tappet tapping target target cw~sltlon data qtrcraft transmitter target
target
area
tcu
tc tds tdistr tp @tiu tl t apak tp I tpa tr t Sc ttc t tp tos tpr NPT NPTR ts t pd tpt tpg tgt t Dd tat ta tsar tb$ tdt
TC
TDS ToISTR 1P OR
TIU T: ~APAK TPI TPA TR Tsc TTC TTP 10s TPR NPT NPTR TS TPO TPT TPG
TGT TAO
TAT
7A
target area analysts radar target bearing Indfcstor target designation t~ansmitter target deteett~ devfce target detection untt target doppler nulliffer
TAAR 181
TDT TOD
tdd
tdu t dn
TOU TDN
inch teflon (insul) telecoWMUnicatfons telec~nications satelltte telegraph Telegraph SYst~ telegraphic message telemeter telenarter transmitter tel~tric data converter telemetry telemetry code modulation tmlemetry co~utat{on telemetry data digittzer telmtry listlng submodule telemetry processing tel~try processor module tel-try Sfmlatlon SUbwmu 1e telemetry surveillance ions comunicat t~lemotor telephom telephone booth telephOne interference f qctof telamfwne ltne dtgital ermr checkfmg telepwne station telep-terminal equipment telephotograph telepr~nter telescope telesc~~c photograph~c recorder teletype teletype buffer teletype translator teletyp~rtter teletypewriter exchange television
teeth per
TWX TLM TMX TELEOAC TLMY Tcu TMCOMP TDD TLS TMPROC 1PM TSIMS TELSCOM TELMTR TEL TELB TIF TDEC TEL TTE TPHO TPR TLSCP TPR TT TTB TTR TTY TWX TV
tpt tfl te I ecom telesat tlg TS tux tlm tmx te 1edac tlmy tern tmw tdd tls t~roc t pm tsims te ~scorn telmtr tel telb tif t dec tel tte tprlo tpr t I Scp tpr tt t tb ttr tty tvn tv
71
TERM
twlevlslon and radar navigation televtston qutomatic seque-e control televts{on interference tsmqmr t~rature temperature coefftctent t~orature coefficient breakdown volts= t~ature coefficient reststmce t~arature co~nsated Z8ft8r dtoOe t~~rature conpensatlng teqmraturo differential tenperatur~ tndtcating Ier control
temperature Iimited
ABfllLEVIATION
TELERAN TASCON TV! TEM TEMP TC Tcav Tcn Tczo TC to
TER.M
test
test test
AI?IIREVIATION
~-er)
teleran tascon tv t t em tw tc tcbv tcr tczd tc ta ttc tle tm t Sw tu t+ tw t~rg tw I tw toh tndzr tns I ts tnsn tntv term tasc tasr tb tba tea te tg tpd tvdp tvor ternm trpl tehm tc tars tova
speclflcat~on
switch
TS
TSW TtA tSTR TS7G TS8POP 10 TE7 TETFLEYP= TET TXTL IE ID THTR 7HEOR TMO TPF THn 7hlRM THC TDX TE THWS Tc TE
of of
TIC
TLE
emission
t~rature
t~erature t~erature t-red t-red t-ring t-late t~rary t~urary
t-ndertze~ tensf 18 tmnst?e
meter
switch welt water
TM Tsw W TMPD TM
7MPRG
construction
hole
strength
tenston tentattve termtnal area sequencing qnd control q rea survelllanco ta-mtnal radar tWfWlnal bOa~Ct q ssewb!y twminal board q rea terminal control termtnal equtpment terminal gutd$nce termtnal protect~ve device terminal vector display un terminal VHF omnirange tarminatlon terneplate
termtnal
target qrray tester testing testing and poppfng testtng devtce tetrachlorf de tetrafluoroethy Iene tetrode textile that ts the satheatrm theoretical theoretical maxi-m density theoretical point of fog therm therms 1 thermal converter the-al demand transmitter thermal element thermistor therfmcoup 1e thermoe]ectrtc thermo(d thefaometer thermorw clear thermoplastic f nsul ) thermosetti ng thermostat themwstattc thtck t?llck film thtckw~ thfcker th$ckness thiale thin film thin film transistor thtnner third stage circular fwtls thousand
TH
THERM TN T TMOS THERNO THRMSTC THK THKF 7HKNR TMR TWNS TUB TF TFT TNR 3STG MCM THO TBE TC NPSF TF TOE THOFU
tet txtl te id thtr theor tlld tof tlwn t?wm the t du te thins tc te th therm tn t t-s thermo thrmstc thk thkf thknr thkr thkns ttf
TFT tnr 3stg thd t be
q nalog radar terratn s+aulator terra{n and obstacle warning qnd qvotdance
terratn avo!dance radar
thread thread
both
ends
terratn clearance tndtcator terrain contour mapping terratn follow!ng radar terrazzo terrzzzu base t=rrttory tert 1qry test test (altn qbbf-) test and evaluate test qnd handltng
TCI
TERCOM tFR 7ER TCRS 7gaR TER ?s7 T T8E T6M TSTEQ tLK 1P TSPEC
thread cutting thr-ad for press jo~nts thread forming thread one end threaded neck threamiecc threads per ~nch tnree conductor tdi?mnsional phaso three three pole
tight
thr~ three
pole pole
double
throw
single
te~ tst
test tae
tnrw
threshold
throat throttle throttle through tfwowr thpuout
control ltmlt
un(t values
test
test t8st t8st ~~
(no
reset
thrust
THOPC 7P I 31C ?D 3PH 3P 3POT 3PST 3WAY 3W 3STG THR TCU TLV THRT THROT TRST THRU THUR THWT THR
3/c
3d
s~h
3P 3~dt
3ps t
away 3W
--
72
NiIL-sTD-12D 29 ky 1981
TERM
thrust hOFSe~OUCr thrust ltne thrust shell thrust termtnat ton unit thwst vector control thyratron core dr!ver thyratron motor control thyrlstor ticket tfe ltne tle plate ttght joints tight wrapped tfghtefling tilo base tll@ drain tile floor tile shtngle roof tile threshold tile wainscot tiller tflttng tinber tim time qnd motion stufsy time qnd percussion time qnd supercfutck time q ssignment speech
A131IREVIATIOY
THP TL THRSHL TTU Tvc
TERM
timing point timing pulse generator t { nned titanium chlortde titanium tetrachlorid~ title block to be determined tobfn bronze toboggan toggle tot let toilet case tOfl@t paper holder tolerance tone tone qnd alarm tone encoded burst tone modulation tone operatsd net loss adjuster tongue tongue and groove tongueless tool steel tooth toothed r$ng top and bottom tap and bottom bolt
ABBREVIATION
TP TPG TND TM FM 7/8 7S0 TOEi BRZ T08 TGL T TC Tti TOL TN TN&ALM TEB TM 7 DMLAR TNG T&G TGLS tp tpg
thp
tl thrshl ttu t Vc
tnd tnl
fm
T/8 tbd tob
Tccl
THYMOTROL TWR TKT TL TP NPTF TV TTNG 16 To tF TSR 17 TW TLR TLG TMUR 7 TMS
tCd
thymotrol thyr tkt . tl tp npt~ W ttng tb
brz
t ob
tgl t
tc
th
to 1
tn tnAa t eb tm ton) m
td tf
tsr
tt
tu
tlr tlg t@ar t tms tap tsq tas i taccar tbo 7CT0 t Ictac tc td tdc tdo td
7s
T TR The Th13B TC TDC T/FR TOPSEC TOW) TOPG TURP T8ATT TG 1P TRO TDR 70RM TORSIO TRSN TORNL TBC TOT TDH THD TIR TLLD TT T TOTLZ Tl)R TE TEFC TTMF TR TMR TO LT TR TRCR TN TRK 10S TOST TRID TIM TI TIP TN
TAP
TSQ th!!il TACCAR
interpolation
time average clutter coherent airborne radar time between overhaul time co~l(ance technical . order t~eo~ress!on tactical c~nlcat ions time constant tidelay closing time delay ti- delay Opentng time difference tfm divlslon data link t~me division multiplex time index tim length time metee tfnm of fall time of flight time of rise time over target ttnu? pulse ttme pulse distributor ttme r~fnalning until trans~tion t!me signal generator tlsince new time since overhaul ttlm Suftctl t~w tefWYePatUre recordetime to intercept time variation of gain time varlea gain time wore timed timed closing ti~ opening ttmer tt(uing tfmlng
Teo
TCTO
top chord top dead center top of frame tap secret topography
topping torpedo torpedo torpedo torpedo toraue battery
TICTAC TC
TD
group
part of beam
TDC
TOO tD TDDL TDM t: TL TIM T/F TMFL T/R ToT tP TPO TRUT 7SG TSN
tOr@e
tddl tam ti tl
tim t/f tlnf 1 t/r tot :; trut tsg tsn tso ts
differential recefver torquemeter torsiograph torsion torsional toss boc~ter total total dynamic head total harmontc distortion total tndicator reading total load total time total trim totaltze total izing relay enclosed totally
totally enclosed fan touchtone wltifrequency towel rack tower towing light trace tracer tracer w-r track track data stfmJlator track data storage track Identity imitation track track tntt!ate track initiation and prediction track nu~er coo)ed
t ng tbg tgls ts tooth tr thb thbb tc tac t/fr topsec t Opo topg t orp tba t t tg tp t rq tW term torslo trsn tom 1 tbc tot t dtl
thd
tir tlld tt t
totlz tor te
tefc ttmf tr tvr to It tr trcr tn t rk t ds tdst trld tim t! tip tn
7s0 Ts
TTR TT 1 TVG TVG TM TMO
ttr
tti tvg
tvg tw tma tc to tmr tmg tt tdio tmgd
Tc 70
TMR TMG TT
qnd
telemetry
output
timfng
timtng
7010 TN(W
73
MILSTD--12D 29 my 1981
ABBREV1ATION
Tod
TVGL TWS TMSRO TRKG TALT TRAM TilDA TbG TRACOMP TEASE TR TRAM TROTO TREC toj tvel tus twsro trkg ta!t tram tbda tmg tracoup tease tr tram
TERM
transmission qnd dlstrtbutton trsnsmfssfon cuntrol unit transmission tdentlficat+on transmit transmit format generator transmit gain control transmit receive transmft receive 6 guard transmittal transmittance transwtftted transmitter transmitter dfstrtbutor transmitter receiver transmitter turnoff transmtttlng transom transparent
AFlflREVIATION
TbD TCU 71 XNT TFG TGC TR T/R&G XMTL TRAN$ xMTD XMTR TO TR TTO XMTG TR TRANS XPNOR TROO TMC TV TRU tbd
tcu tt xmt
tfg tgc tr t/rbg xmtl trans
ac~ts+t
tracking tra*~ng tracking sfmlation tracktng
ton
qnd guidance c~arison errors qnd evaluation radar radar automatic
data takeoff electronic fnput and
xmtd
xmtr td tr
tto xmtg tr trans xpndr t roo
tracking
monltortng Crackfng radar track~ng radar ~-t tracking radar correlation trackway trade name trade pattern traf?fc traffte control
trdto t Pee
trfc
transponder
transponder on off transport movement control transport vehicle trmsportab]e radio unit transportable sat@llite cowwunications link terminal transportation transpose transposition transverse transverse q lectrlc transverse electromagnetic transverse q lectrostatic transverse qxpansion joint transverse magnetic trapezo~d trapped-plasma q valanche-trtg!?ered trans tt travel correction calculator
TRIC
TRWA TRN TRP TRFC TCP TRLR TLRMTD TRG 7E TE/R TN 7RNR TNG TM TRAd T Jc TRANSA XCVR TRSC8 TRSSR TRS8G
tmc
tv tru
trwa
trn t rp trfc tcp trlr t I rmtd trg te te/r tn trnr tng tm traj tje transa xcv r trscb trsbr trsbg xdcr xfr ---tcr tch TEDL xfmr tr xstr TCL tdcm TT1. tut tvnl tstrz t ac thor trmsm Y xltr tac xmsn
TSCLT
TRANSP TRNPS TPSN TRANSV TE TEM TE TCJ TM TRAP TRAPATT
tscl
post
trafler
tr8tIer tmfltng trafltng tralltng munted
q dge
edge
radtus
trafn
tra f ner trafning tm~ning trajectory trajectory transaction transceiver transcribe transcriber transcrtbfng transducer trans?er transfer transfer manual chart
XOCR
(31tn control abbr) reglst*r XFR TRANS TCR TCH TEDL XFMR TR XSTR TCL TDCM TTL TUT TVM TSTRZ TAC TmR TRNSN Y XtTR TAC XMSN
TCC TRVLMT TRVLR TRVLG TM TWA TUM TWMEK TUT TRAV TRO TRTD TMPrfl TRTMT TR9 TRNGL TRI~ TRKWHL TRIG TRIG TRIG YAF TRMQ TNT TRI TC TPL 3P 3POT
transter fn channel transferred-el~tron-dev ice Iogtc transfom=r transfcwmer rectifier transistor transistor cwPled leg~c transistor driver core melm~ transistor transistor logic tranafstor under test transistor volt~ter transistorized tramsfstortzed automatic Corttro 1 translstortzed high speed operations recorder transition transitional testing (aircraft) trmwlator trmslator asse*ler ~iler trsnsmtssion
fiberboard
treatment treble triangle tributary trfckwheel trtgger
trtb
trkuhl trtg trfg trtg taf t rmr tnt trf tc tp I 3p 3c)dt
form~ng
double
thrOU
TER !M
trtple pole double throw Sut tch ?rlplo pole single throw trfple pole single throw SW f tch trtple pole switch trtpla thermop)asttc (insul) trtple throw triple wall triplex trtpped trtpptng trol ley troptcalized troposphere truck true air tenveraturt true qirspeed true north true position true posltton tolerance true profi?e true watt truncated whftworth coarse thread tmmcated whitworth ftne thread twmated uhitworth special thread trunk t runn t on truss truss head tube axial tube sheet tube sheet .inlet qnd outlet head tube under test tub t ng tum 1e tutiler tune controlled gain tuned plate tuned grid tuned radio frequency tungsten tuning tunne 1 tunnel diode tunnel diode a~lifier tunnel diode charge transformer Ioglc tunnel diode log~c
ABBREV1ATION
3POT 3PST 3PST 3P Sw
TERM
SW
ABBREVIATION
TO TRNTBL TUR TIROS TWSB to trntbl tur t t ros
Sw
3pdt
3pst
SW 3pst 3p Sw tt 3t tplw trx t rp trp trly tpl t rope t rk tat tas TN TP tptol tp Sw
observation
twse
tag tw 2/c 2dtg 2U 2ph * dpdt dpst 2stg ttln 2way 2W tyde tms typl ts typstg tsl tw typ Ult Uoc
q
Tbas TN
1P TPTOL TP TW
WC
TWF Tws TRK TRUN TR TRH TBAX TS TSI-Ott
:C
TWF Tws t rk t run truss t rh tbax ts tsl -oh tut tbg tti tblr tcg tptg trf t ung tun tnl tn)dio tda TDCTU TDL TDTL turb tcc td td tureo
TUT
T8G TMO T8LR TCG TPTG TRF
Ultrasonic
ultrasonic ultraviolet ultraviolet
ltght
wave
mdulator
q ~lif
ication
by
st~-lated
emtssion
f100C1light
of
UVFLT UM8 UMOC UNAUTHD UN8LK UBL Uws UNCLP UNCLAS Uvf I t uUllmc unauthd unOfk ub 1 Ws Unclp unclas Unctd uncond
TUNG
tUN TNL TNLDIO TDA TDCTL TDL TOTL TURS
radtatton ultraviolet
-Ilfcal
unt2tltcal unauthorized unblanktng unbleached unbleached unc 1 qnp imc)asstffed uncoated cord
musl
{n
transistor coupled
tur5ine d~rect turbtne driven turbtne generator (drtverl turbine inlet pressure turb~ne Inlet temperature turbine out\et tenverature turbtne reduction arlve turbo q lternator turbo Jet propulsion turn qnd bank indtcator turn coordination
tcc To TO
TURBO TIP GEN
11-Y warfare
UNCTO UNCUNO Uw
UNOEF UND UNOC UNDF UFR UGNO Uo UH UHT UNDLD Usw
Uw
undef und undc undf Jf r ugnd ud uh uh t undid
tip
tit tot t rd turbo a!t tJp t8bl trn crd trnbk 1 t rnd turn trngr trn It
TIT
TOT TRO TUR80 ALT TUP TU81 TRN CRO TRNOKL TRND TURN TRNGR TRN LT
relay
UndWgrOUW
dtstributlon
Usu
us
us
us
tJNOV
us Undv
75
mL-sm-12D
29 -Y 1.981
TERM UmCferveltage
underwat@F devtce
ABI3REVIATION
Uvo UUTR UB UDT UOL UWTM UAM USM WM U?4REP UNDETM U@17RON tJNf I N UNF unrep uncle tm U5 t t ron unf i n un t ucm t Usfu usub Ufo UN LINE F WF Usb UNs unlf Ud 1 us COEF un~f UUT ups up~ un W* Uj un$fet unit uk Uc uf ae8 Uh Uic UME ue Uf Utc Wt Wt us USG Uss cod
TERM
Umnown unless otherwiss specifted unlfmtted unloading unlocking um.rked unmmmted unregulated unsatisfactory material nottce unsatisfactory report unsenslttzed unscrvicab Ie unsuppressed until further notice untreated untreated hardpressed fiberboard untwist up data ?fnk updated updraft
A13RREVIATION
UUs
Unk Uos unlfm un 1 unlkg
Uvd Uwtr
Ub
underwater
underwater underwater undema t
b8ttery
demolition team object locator team to q tr mtssilc to surface
UNLIN
UNL U?4.KG
undewa
er t qr
Ud t Uo 1 UwWI
uam usm
u-o UNNlo
UNRGLTO
-d
unmtd
unrg Umn UR ustzd us I td
underw ter mtssi 1to underwater ~ater mtsstla undemay replenishment undetermined .u*lating beam interaction q t-tron tube ,
UR USTZD us UNSUPPR UFN UTRTO UHPf8 UNTU UOL UOT O UPOFT UPR U&L UCL UMR USE URT
unsuppr
uf n
utrtd ~fb
untw ud 1
til. LJCMT
USFU USU8
UFO & WE F u?4F USB UNs UNIF UOL us UNIF
udtd
updf t upr U& 1 UCL Usb urt upwd urg ur IJrwc USAS Ub UI uar u/o u/v utn Utll ubd
Wwr
upper upper
limit
range
upper
uppar upright upward urgent urinml urtnal
max~wm
sideband
Untfted
unified Untform ~m~fam LJnt?orm Untformtty untjunctton uninterrupted
S-bsnd
spectal data System thread
UPWO
URG water
link
(lens
closet
Merkingi
Coe?tic+ent transistor power Dower
udT
Wpply
SUPPIY UPS UPS UN
uninterruotibla
union unfon
bonnet
q ffect
t.mtl
W
UNIFET UN UK Uc UFAEO Ui+
::WC USAS Ue UL UAR u/cl u/w UTN UTIL Ueo UCI Uco UCt)N UR UTIL UTEELRAD VAC VAC VIM-VAR VT VRO VTVM VAL VAL VEI VE
Uci
Uco ucon Ur Uttl uteelrad vac vac vim-var Vt Vrd vtvm Val va 1 vei ve Vtp v Vb Vst vstm vd vnx I Vp us vpr vap prf Vt Vrctr
UIC UME UE
UF UTC
unfversal
q synctwonous
rec8$vor-tr9nsmi tter unfvorsal comamicatlons switchf~ d@ViC@ L#niveFYal data transcriber untversal digitat transducer indicator untversal horizontal navfgatton beacon untv~rsal Untvorsal power supply untvwsal product code untvorsal time unlv-rsat time standards
VIP v Va
vST VSTM Vo VNXL VP
UOTI
UHT UN% UNPS UPC UT UTS
Unb Unps
UPC Ut
Vs
VPR VAP PRF VT VRC7R
LiTs
76
MIL-STD-L2D 29 hy 1981
TERM
varhour meter variable varfable cllode generator variable control pressure Varfable crystal
ABBREVIATIO~ VAfh4N
functton ofl VAR VOFG VCOP varhm var vdf g Vcop
TERM
vernter tracktng by q utomstfc correlation versatt Ie versatfle q utomatic equtpment versat~le differential
VATE
verdan vers Vs Vtx ver t v VSTOL vab Vc 1 vce vd t vt~ V1 Vlp V cb
oscillator
beam pOfnt clock
Vxo
VOEL Vos VEB VFL PT Vf VFREO CLK
v Xo
vde I Vds v eb Vfl pt Vf vfreq elk
qna 1 yzer
versed v*rsus vertex vertical verttcal verttcal q nd vertical vertfcal verttcal Verttcal vert~cal stne
variable variabla
variable vartab!e
variable
variable
frtKJU@nCY
freouencv
oscl I later variable gain a~ltfler variable information processing variable length CaVit)f resonance variable low frWQUefIcy standard vsr{able reSIStOr variable speed c0n5tant frequency vartable speed drive variable speed gear variab)e voltage rcctifler variable voltaqe transformer vartable width-pulse variab\e word length variable-threshold logic vari qnte vartation var~ety various varlstor va~ter varni sh varnish ( insul ) varntsh cambric ( insul ) varntsh treated ( \nsul ) (see varn~sh ( insul )) varying vault door vector field vector l~edanc= 10CUS plotter vegetable vehfcle vellum velocity veloclty tndtcating coherent integrator veloclty integration detection qnd ranging velocity modulation veloctty response shape vent hole vent ptpe vent stack ventilate ventilating deadlight vent~latfng equipment ventl later verbatim verification verification unit test set verify vorn t qr vernier engine cutoff
fc~ form) and short takeoff Iand\ng q ss~ly building center line centrifugal dtsplay tnd{cator
v
VSTOL VAB VCL
vertfcal
tffqwtse ladder
Vso
v SG VVR vARITRAN VWP VWL VTL VAR VAR vRTY v AR VRIS VARM V&RN v Vc --VRYG Vo VF VILP VEG VEH VEL
vvr
vari tran
Vup
vu 1 VTL var var vrty var vr{s varm varn
vertical landing potnt ve~tical )ocatlon of the center of buoyancy vertical locat{on of the center of gravity vertfcal plann{ng verttcal polarization vertical raetal vertical reference 1 fne vsrtlcal takeoff and landing verttcal volute spring suspension v8ry high fr~ency very htgh frequency omn+dlrectiona? qnd radio range very large-scale integration very long range very long range tracking very low qltftude very low frequency very low range vQry short rancte very stable oscillator very-high frequency dtrectlon finding very-high frequency omnfrange Iocalfzer vesttbule vestfgtal sfdeband vestigtal sideband modulation VHF omntrange dfstance measuring equtp-nt VHF recovery beacon v fbrate vtbratlng cofl magnetometer vlbratfon vibration per minute vtbrator power unit hardness Vlckers v I 680 vtdeo q ~ilfter video display terminal vfdeo distribution arrplifier video frequency vtdeo integration vfdeo Integrator vtdeo prelauncm c~nd q ~liffer
Vcg
Vp
Vp
vtr vr 1 VTOL Vvss vhf VOR
Vvss
VHF vOR
VLSI VLR VERLORT VLA VLF VLR vSR VSQ VHFDF VORLOC VEST
VLSI vlr verlort vla Vlf vlr vsr Vso vhfdf vor 1oc
VSB
VSM VOROME VRB
vest v sb
vsm Vorm v rb Vtb vem vlb Vpm % vfd v f dau@
vIO
VCM VIB
VPM
VPU
vt4
VID
VIOAMP VOT VOA V1OF VINT
vdt
vda vfdf
V2NT
Vt v~a
VUTS vRfY
VERN
VI
VPCA
VECO
MIL-STD-12D 29 by 1981
3-ERM
vtdeo sweep Integrator recorder vl@eo-tmpe
ABRREvJATION
Vs x VTR Vst vtr Vtl Vto ---v i smr Vise VI vsb 1 vedar Vis vasi varr VFR Vgpi Vgs Vgs i visid voltage controlled crystal oscillator voltage cor?troi)ed oscillator voltage controi led shift regfster voltage detector volta~ drop voltage readout unit volta~ re~lated power Supp t y voltage regulator voltage relay saturated capacitor voltage voltage standing wave voltage standtng wave ratio voltage tunable-magnetron voltage tunab)e oscillator voltage-vartable capacttor voltawaneter voltmeter voltmeter suitch
AJ313RE~lAT10FJ
Vcxo Vco VCSR VDET VD VRU VRPS VR VRLY Vsc Vsw VSWR VTM Vcxo Vco vcsr vdat vd Vru Vrps vr vrly Vsc Vsw vswr Vtm Vto Vvc v am Vm Vs Vo 1 Vt Vc vu vlmtrc Vlt vul~ Wf r wag Wb wa Wtg * It Wlb wh vr w Wls) wan wrb wr whse warhd Wm
village violet
vtolet (altn qbbrl v t sc-ter v I Scos { ty Vlscoslty index vtstble
VIL VIO
v
VI SMR V2SC
VI
VSBL VEDAR VIS VASI VARR VFR VGP 1 VGS VGSI VISIO VIP VLD VLADO VMC VMC vTIP VLC VIT Vc VCT Vo bN7 I VOX VOBANC Vc VOCOM VEV VF VFC VFCTT VFTLG VOflAS VODAT vOGAO VOLCAS Vox Voc VRFI Vi?s)?i VT Vo v VAC Voc V/u V/MIL VOM v V AOd !/CT
vlslble
qnd visual visual
ViSUaI
energy
ranging approach
CSetectton
slope radio rules range
lndtcator
qural
visual
visual visual vfsual vtsual vtsual
flight gltde
glfde glide
path
slope slope
tndicator
Indicator point
tdentiftcation
tdenttf~cation
Vip
vld v I qdd
vVfu Vtip Vlc Vit Vc
volume
volume volume volume indicator of c~artment untt
tvery visual meteor?egical conditions visual meteorogical visual target identification potnt vttal load center vftraous vttrff ied clay vftrlfied clay tile voice vO\CO actuated transmitter k~yer
votco Voice
voice vofcc voice voice
volumetric volute vulcanize water wagon wagon box wainscot waiting wake light wall board
wall hydrant watt receptacle wall vent wa)scal wan t gan
carrier telegraph
dev!ce devtce for
urn wrpg
warr Wb Uf U6M GA ushr Ushg wr w w us
contro
Moen
Gage
voice op-rated transmitter keyer voice order circui t reporttng fault voice indtcator votce reporttng signal asse*ly vo~ce tube void volt qlternattmg current volt volt dtrect current per meter volt
volt per mfl volt-ohm mill tansneter VOI tage voitage q djusttng rheostat voltage control transf*r
V(IX
V* vrf vrsa Vt vd v vac t
water wster
uate-
water water
water water watef wat8r
v de v/m v/mf
R Vom v v adj vet
Ifn@ meter
plane
us
Wturb Utcc
I water 78
coupled
WCC
MIL-STD-12D 29 tby1981
TERM
water turbine dfrect watarcoolor w8toFfog Waterproof waterproof fan cooled Waterproof shroud waterproof Ing uat8rtlght wat8rval I waterwheel watt watt demand meter watt per candle watthour watthour demand meter watthour Uemand ~ter thermal type watthour meter watthour meter with contact dev 1ce watthour rreter with loss compensator
ARflREvlATIO~
WTD WCR WFG
WTRPRF WPFC UPS MPG W7RTT Ww WWHL w MD UPC WH WHOM WHr WHM wtd Wcr whole Wfde depth
TERM
ARBREVIATION
m u Wd w Wb vbdfx WADS WATS Vbc t Wt%tl
Wfg
Utrprf Vpfc Ups -9 wtrtt w Vwfll w
wide utda
band
band
Dlcke data ffx service
m
W8DFX WADS WATS W6CT W60 W8DL WBNL WD w UAF WLC UN MO WDIR WL WNOR WOG w/w WNOLS woo MD WG Mu WSHLD WG WCP WRL WTRZ Uo WPG w w WA woo we WGL ML WM WR Ww Ww Ww WCM us WRG WAF w/ W/so W/EASP w/o u/o w/080 W/o ESSP WI) WATW WB wBF W8L WOBOR Wcu Wo WOF HF s Wd MOP
wd Wpc
wh wilds Wht Wlus Vhc wh 1 m wamoscope
WC
WHL
WM WAMUSCOPE VA w WL WPJ UPN UC Ws WET us WRG WEA WR WSL us WSF WETM WEAT WTHPRF UP W8G WG Wu UT WTG WLD WLOR WLDS WLDMT w WB UP us WE WtlL we Uc w)+ WE USTL WHT w btCF MIL WL UP WR WHs
oscflloscop~
uaveferm analyzer waveguide wavelength weakened plane joint weapon wespon carrier Weapon System weapons effectiveness testing weapons spec,if \catlons wearfng wather weather resfstant weather seal weather stripping weather support farce wsather team weather tight weatherproof weatherproof ( insul ) webb t ng wedge week weight weighting we 1ded we I der ue)dless we)dment west wet bulb wet process
ua Wg WI WJ wpn UC
us w.e t us Urg wa
Ur us 1 Ws us f
wetfn
wea t
wthprf Zg Wg Wk Wt Utg wld Wldr Mlds Wldmt w * w us Vb Vtl I Wb we Wh Wb Wstl vh t ..-. we f wfI W1 w wr whs
ulde-area wide-area telecawnmicatfons service wfdeband wrrent transformer wtdeband data wideband data ltnk widoband notse limit~ng width width (altn qbbr) Wfdth qcross flats Wt}dcat wfnch Wtnd wtnd dlrectten wind load wtnder wtndtng wfnding to winding vindlass w f ndow Wtndow dtmension vlndow guard wtndow unit windshield Ving vtng Cnord plane wing reference line utnterize wipe out Wiptng bftre (conb form) wire armor round ( insul ~ vlr~ q ssetily wIbound wfre gage wtre glass wire I$st wiru mesh wtre rope wire way wfre wound wfre wrap wfred core matrix wireless set wtrfng wiring around frame with (comb form) ufth blowout with equipment and spare parts withdrawn wfthout without blowout without equipment and spare parts wood wood awning type window
*n 1 Vd ---wa f Wlc wn
wd wdtr W1
Wndr
wdg w/w wnd 1s wdo
wd Wg w
wshld Wg
Wcp
wr 1 wtrz Wo -g w w ua Wbd Ug Wg I u} Wm Wr w w w ucm Ws wrg Ua f v/ w/ho u{ ehsp w/d u~o w/obo
floor
Wbf
ml wdbor Wcw
wd Wdf Wf s Wj U*
blockt~ borfng casement window door door and frame furr!ng strips jalousfe panel
t41L-sTD-12D 29 my 1981
ARRREJIATION
w wre i ng
AI3BREVIATION
us r
Wt Wetg Ubx wdf Ud
Wcm
wrench Wr t nger
wrist pln wrftable centrol store urfte printer binary write printer decimal vrtte punch wrf ter wrong direction wrought wrought brass wrought Iron wrought steel yard year yellow yellew (altn q bbr) ye!lou Indicating layellow light yellow varnish cambric ( Insul 1 yle!d point (psi) y~eld strength (psi) zero q djuster zero crossing constant false q larm rate zero set q nplifier zero t~erature coefficient X19289 rivettng 2one zone tfme
Wodc
wooden box-( 811VW) woodruff word word buffer register word co-fner qnd mtttplexer vord per mtnute
W8x UOF m W6R Wtn WPM UPS UP w W8 was Uo Ml. w UKG UC UP WPR ifsP WV UKs VA Wu wffiR wMSFT wMniiL MUD WI(R
Wps
w *
we
has
Ud
WI
w
Ultg
Wc
w
upr
WRK WR URGR WSTPN Ucs UFO WPO MPU WR WRDIR URT W8RS WI us Yo YR YEL Y YIL YLT Y Vc YP
urk Wr urgr Wstprl WCS * -d Wpu wr wrd i r wrt ubrs Wt us yd yr ye 1 ---yll ylt yvc YP ys za
Ys
2A ZXCFAR
w bitts
Ua
w
Umgr Wmsft Ilam#hl Ukr
ZSA
ZTC ZZR z ZT
80
l-ERM
way seven conductor amer8 (cm form) qode (electron devtce) (con@ form) qntf qsbestos t insul 1 q stragal qrmament qnd electronics q sse-ly qnd repair q ir to alr q fr to ground q nalog to digital q ir over hydraul \c qctton time qccordance with qntiaircraft qrmature qccelerator qntialrcratt artillery q cqu{sltion qdvice code q ll q lumfnum conductor anttatrcraft cowuwon qntiaircraft ftre control advanced qerfal fire support system q [r to q fr tdentlflcatfon q ngle of q pproach Indicator qutomatfc q ntiJam ctrcult q ircraft q pproach l19ht ~llffed qutomatfc level control q ir to qfr mlsstle qdvmce q iteration notice
%
(NI -..
IWO
% i+
(n} -----------
---
-------------
-------------
/
l/2DP l/2H l/2RD l/4H l/4PH l/4uo l/c I/w lPW tRCO 1S7G fSTG lW
Z/c
1 l/2dp l/2h f/2rd t/4h l/4pti l/4rd t/c Ilw 1ph 1red lstg lstg lW 2/c 2d 2dig 2ph 2 red 2stg 2stg 2W 2wa y 3/c
p~rcent {~ancw nutier of b$ts qnd so forth (see et c8tera) varntsh treated ( tnsul ) (see varnish [Insul)} qc*tato { \nsul ) (s*. cellulose acetate) cement qsbestos (see qsbestos cement) cement qsbestos board (s80 qsbestos cent board) cyc}t per second (see para 4,7 - Hertz) foctcandle (see para 4.7 cande 1a ) Stlfcon controlled recttflm(see semiconductor Comtrollad r8c t ) per [between words) half dog point half hard half round quarter hard quarter phaS8
four
7/c A A
A A A AhE n&R A-A A-G A/D A/H AIT A/U AA Ml
20 201G
2Ptt 2RE0 2STG 2STG 2W 2WAI 3/c 30 3P 3P 3P w
qsrter round single eommctor one way Stngle phaSe f{rst reduction ftrst stage one stage one-vfr~ two conductor two dinwwional
two digit two phase second Feductton second stage two stage two-wl re two way three conductor three dimensional three POIQ triple pola trtple pole switch threa poie aoublo throw triple pole double throw triple pole double throw Swl tefl three phase three pole sfngle thrw trtple pole slngla throw triple polo sing18 throw swt tch trltrd stage three-stage trtpIo throw three wire three way fwr conductor four dlmansional four pole four pole switch four pole double throw SW f tcrl four polesingle th~ow
qntia(r qntfair
deStrOy~~
qb qb
Al! qb
3d 3p 3p 3p
A88
A81JR ABC ABC A8CA ABCS ABCP AODf4SHP ABL A8M ABMEWS
automatfc q ttack warning system q dapter booster qfterburner q ir base q ir blast qnchor bolt applfcatton block q tr break SWftCh qdvanced battery q cqisftlon raaar qutomatic back bias
3P9T
3POT
3POT SW
3PM
qbbreviate
Srlttsh, Canadtan brlghtnass control Orittsh, Australian ctrcutt br88ker qutosmtfc bias compensation shtp qbanocn ~rtcan, qutomatic American, Can.dlan. q ir blast
sw
3PST
3Pst 3%7 Sw
qbcb qbcp
Sw
q benshp
ab 1 qbm
AOMEMS
AWN
ASN ABNL MO A8RCS A8RSV AOSSV RES A8S ADS CLG AnSC
qm qbn qbn I
aoo A8RES
swttch twr-stage
fuurth stage four wtr8
qarly wsrning qnt~balllstic mfssf I* a t t-borne qbnormal qstable bloctc~ngscillator o qdvanced ball tst{c reentry Sys tam qbrastve abraslva reststant qbsolute qbsolute cetling qutomatic bass convwnsation
missfle system missile
m~ssfle
4W
81
TERM
ABBREVIATION
ACSt ACST ACT ACT control ACTE ACTG ACTL ACTN ACTR ACTT ACTVIUNAL ACTW ACWTR ACV
TERM
qcc8ss time qcoust t c
qbsorb
sbstr
q bsorption
qbstract qbout q fr blast qbovo qutometlc qbax i q I
transformer bandu~dth
ASXL
AC AC Ac ACA ACA ACAQ AC9 ACB ACC ACCEL ACCESS ACCLRM ACCOM ACCOM ACCOMP ACCR ACCT ACCUM ACCUR
q ctivity qlgebraic
qctuate
c~iler
and
translator
q ctg
qct] qetn qctr qctt qctvnanal qetv t qctvtr qcv qm qd qd qd qd qd qd
q ctuating
qctua 1 qction qctuator qcmtate qctivation
q crodynam~c
alternating qsbestos q djacent qutomatic qcaaemic q fr CIF%Utt breaker qsbestos cement board accuwlator qccelerate qccessory
AO
&lo
Ao AD AD AD ADA AOA ADAPT AOAR AOA7
Sccur
qccu qcdt ACE
ACE qcet qcf cg q qcg ACI
AOA qda
q dap
Accu
ACDT ACE ACE ACET AC?T ACG ACG ACI ACIRC ACK ACKTX ACLD ACLE ACLS ACLTR ACM ACM am aCME ACN ACN ACO ACP ACPT ACPTR ACO ACO ACR ACR ACR ACRFLY ACRYL ACS
qltarnattng
current continuous wave qce t dent q cceptance checkout ~tpment qutomatfc checkout q cetylene q trcraft q ng~ocardfogram sngtocardiograph
MC ADcs
q +ipment
AOD ADo AODAR AOOL A9DR AOOt AOF AOF Am AD I AOU AOU AOU SP AOL ADL ADM AOM AONG AOMS Am AOP AOPTR AORAC ADRS AORT ADS AOS AQSOR8 AOT A07 AOU AOV AOVG AOVS
q nalysts activate qctivator q larm check valve q {rcraft centro? and warning qdvertisement q ir duct q~ere demand meter qnode area drafn qs ~rawn air defense arttllery qutomattc data q cqutslt~on q daptation advanced design qrray radar qutomatic data qccumulator and transfer q ir data c+ting q nalog to dfgital converter eefemse Sdvmced Communlcattons satelltte qddendum qddttion qutomatic digital data acquisition and recording
adcl{tional qalder qdditive automattc q uxiliary qdhere qdhes 1ve q ltitude q djacent q djust q djustable quthorized automatic
configuration identlflcatfen atr circulating ack now I eege qutomatfc ct~cutt exCha~ q $reoo}ed
q llocated
qddt
qutomatic qutomatic
clutter
carrfer
q llmtnztor
]andtng
Uirection detonating
ftnder fuze
direction
indfCatOF
4CS ACS
ACS ACSR
qcs qcsr
system qcc-le~ator qctive countermeasures qsbestos covered metal qutomatic clutter mapping qcme screw thread qdvance change notice qutomatic celestlal navtgatlon qction cutout qzimth change pulse qccep t qcceptor q c~i re qcqlsftion qcross qdvanced Capabtl Itles radar qpproach control radar acrwss flats acry) tc qccess qccumulator switch q ircraft control qnd surveillance qlternating current synchronous q luminum conductor steel
q dj q dj
ad
j SP
qd 1 ad 1 qdm qdm
speed data
ltst
q dmg
qdms
qdo
AOP
data synchronizer qudio decads oscillator automatic data Processim q dapter qutomatic d!gltal recordfng qnd control address q nalog data recorder
system
adu
qev
qutomat$c door seal qesoroent qutomatic data translator qverage da~)y traffic qccumulation distrtbutlon
un~t
qdvmce
advantage qdv i se
q dvg
qdv$
reinforced
A13RRE\1
AQVSV
ATION qdvsy
adus
Aovs
AOX AE &bEcP AE E ACG AC 1 AEL ACO AER AERO AERCJDYN AEROHEAT AEROL AEROSP AES AESC AEW AEW&C AEWA AF AFAR AFB AFC AFCE AFCS
adx
ae aecp AEE
qi
ai
qi
ai
aeg
ae 1 ae 1 a eo aer
qi qi
aie aid qil AILAS AILS
COde
integral defense ai leron Automatic Instrument Landing Approach System Automatic Instrumnt Landing System q ir Intercept missile air induction air conc!ttion q tr cleaner air shutter armored infantry vehicle q ntijanantng assetily jlg q ntiJamn)ng/antiinterference air lock alumlnum a~er \ Ight air launcned eoost interCW$t air launched ballistic missile a I coho I automatic leveI control q lurn~num-clad q nalog line driver at a later date q l iUade q utomattc low data input a~rlift qlgebra qlgori thm algorithmic-or~ented 1anguage alignment alkaline alkalinity allocate al Iowance
q ctive
q8ro
qerodyn
aerohea aerol aerosp aes aesc AEW AEWAC aewa af afar afb afc AFCE &bFCS AFCS afm afr AFS AFS qft af t aftclr AFTO qg ag ag aga AGACS agave agc AKA AGCL AGDS AGE aggr ag I agl agm agmt ags q gt qg t agz qh ahdr t
qtm
aindtn alr cond airclnr qirshtr qiv qj aj aj/ai al al al albi qlbm
WCS
AFM AFR AF S ATS AFT AFT AFTCLR AFTO AG AG AG AGA AGACS AGAVE AGC AGCA AGCL AGOS AGE AGGR AGL AGL AGM AGMT AGS AGT ACT AGZ Al+ AHOR
array raaar antlfriction bearing automatic frequency control automatic flight control equ t pmn t Adaptive Fl{ght Control System Automatic Flight Control system qntifrlctton metal qirframe advanced firing systems Arm!ng q nd Fusing System qf ter q utomatic fine tuning qfter cooler Air Force technical order q gitate q ntigas qrmor grattng qir to ground to a!r automatic ground to air conmuntcations system automatic gimbaled antenna vectoring equtpment q utomattc gatn control automatic ground controlled approach q utomatic ground controlled landing Amerfcan Gage Oesign Standard q erospace ground equipment q ggregate qbove ground level qtrborne gunlaying atr to ground missil* q ugmen t automatic gain stabilization agent qviation gas turbine actual ground zero qntihunt q !r header
qlc qlc qlcd qld qld qldd aldrl alft alg algo
ALGOL align alk a)ky qnot allow qlm alo alpha alri alt
rate
alarm
automatic Iocon alphabetical q irborne long range input al ternatiom altitude altltude transmitting equ t pment alt!metef= alternate q l ternator alternative al tered q iteration altitude reservation qrithmetic qnd logic air launched vehicle
radar
qlt
alte altm altn ql tntr q I tnv al trd ql trn ql trv qlu alv
ALTNV
ALTRO ALTRN ALTRV ALU ALV
Unit
83
ABBREVIATION
KY ALY ALZ AM STL
TERM
stl
ABBREVIATION qnc
TERI%f
calling q ll-nu~er Army-Navy Civtl Army-Navy Cormnerc\al qnchored fflament q nnouncing qnecho t c Navy tkst~ Air Force Army-Navy Oeslgn qnodi ze qnerotd angle qnnyorloe qnhydrous qutomatic m~er Identification qnea 1 qutomatic notse limfter q nalog q nalogous q ngle order qgu I qr qnnular qnunclator q]phanumer!c output anodize (altn abbr) q ircraft nuclear power (propulsion) aeronautical nat tonal taper pipe threads qnswer qntenna q ntilogarttim voice qctuated transmitter keyer inhibitor qnti toxin qntiS8pt~C
qly qly
qlloy qlloy
qssault
w
AN AM AM NXt AMA mu
ma qmed
qab
Aua Mu
8* 8* q* 8*
qmc qx 8* ME qmend Amer Amr Std qm t amlg am qwn awwu ausnork arena q tmsup qmohs t qmohstdr ANOS qm 8W qny) allp qhr a~h q mh trk qm 1 q npldn q mlg
MO
ANE MEND AMER AMCR ANI ANLG
S70
zon8 qmatol q ~lltude modulation qnt. meridiem (before noon) q uxiltary memory 8aanonium nltrat= qutomatic message q ccounting q irframe-mounted qccessory dr t Ve qweer -tent qneu I qce qnttmotorboat qsbestos mill board matorlal change qrmament automattc mfxture control q tr movement data sngla measuring equipment qmendmen t Amer t can American Standard qdvanced manned interceptor qm 1gam 8Mter qnttmissfle mtssfle qwmunftton qasmtnftion rack q-n i a qcoustic Infne Swepfng qwnunttion hofst qsmunitton hoist drfve automatic n9teoro)ogtcal
steel Iandtng
qncf
i 1
qncg
qnch
ANO
ANo
Wz ANER AWYD AMiYD MI ANL ANL ANLU
qndz qner
q ngla
qnhyd
q nhyd
qn t
qn 1 qn 1
q nlg
ANms
ANLOR ANLR
AN1.R
ANDu
ANP ANPT ANs AM ANTILOG
qns
snt
qnti qntox
log
APJTIVOX qntspt
8Q 80 qoc qoh AOQ
observing
qdvanced q frcraft
statfon
manned missile penetrate preject
q perage
qpwe
q mpere-hour
q ~hlbious q npllfier
q npl q mhtbious
truck
AmPFt TRX
Am AOQL Am
AOSO AOVC AP AP AP AP AP AP AP AP APA APAR APC APC APC APC APcac APCX APC I T APCT APERS APERT
AOQL
qor aoso
qovc
AMPL
AMPLDN
qm I i dyne
idyno generator q wplfdyne motor generator q wl ftucie qdvance material request qeronautical matertal specification qdvanced manned strategic q trcraft qntimissile surface to q lr missile qbove mean sea level qmount qrm ture qntfmotor torpedo b08t qrea moving target ~ndicator qutomatic mov~ng target tndtcator slr wnlt tons Navy Afr Force alphanumeric Army-Navy qnchor I!gftt Air Force Navy Aeronautical Army-Navy-Afr Force q nalysis qa I yze Army-?+vvy Br\tish Air Force Navy Civil
AMPLG anwwm
AafPTD AK AMA AMSAM AMSL
q lrqslmg amptd
amr ams qmsa qmsam qm% 1 qm t qfat qmtb qmt 1 qmt i
qp qp qp qp qp qp qp qP qpm
spar
qpc
8pc
qrmm
AN ::
qpc qpc
apcbc
qpc
apcit
qn
It
control swatting overhaul qverage outgoing qualfty qverage outgoing ~altty limtt qnchor order qdvanced orbiting solar observatory qutomatic overload circuft access panel qcidproof qfter peak qfter perpendtcuiar qtming point q ir passage q r~nt progranwning qrmor piercing qxfal pressure q ngla qutomatic progrsfmwtng qnd recording qcoustical plaster cefltng qrmor plerclng capped qrmored personne! carrier automatic phase control armor ptercing capped ballistic capped qrmor piercing capped incendiary qrmor plerclng capped tncend[ary With tracer qrmor piercing capped with tracer q nt~personne 1 qperture
84
ARBREVIAT!ON APF
API API APIS APIT APL APL APL APL
TER.54
floor posit ton fndicator armor pfercing Incendiary array processing instruction s*t qrfmor pfercing incendiary with tracer a Programing language qirplane q llowance parts llst qutomatic phase lock appl ted q ppltque q larm panel monitor q pothecary qppearance apparatus qpproach centrol approved (altn abbrl qppl icatton approprtat Ion approximate q ppointment qpprove approva I append t x q pprentice Apr4 1 approach apparent a i rport q uxiliary power Supply surveillance radar qirport apartment qrmor pierctng wtth tracer qutomatic picture transmission automatically programed tool aperture card audio playback unit auxiltary power unit approved qrchitectural projected Wtndow aqu*ous azinutn quant!zed gated Vtdeo qcceptable Wa!tty lavel q cceptable qualtty test aeld resisting C~iSiti~ radar q ir refuellng qs required q irborno rsdar approach q irborne radar qnd doppler arbitrary ~nverse cosine inverse cotangent inverse cosecant qrchitecture qrch$ve tnverse secant inverse sine fnverse tangent src weld qutomatic radar distance measuring equipmxmt arresting (gear or hook) arithmetic arithmetic unit acceptable reliability Iavel
ABBREVIATION
ARM ARM Am ARM CA ARM PL ARMD ARMSHT ARUT ARNG AROM ARP ARP ARR ARR ARR ARR ARS ARS 4RS ARSR ART ART RON ARTCC ARTCLD AR7F ARTY AS AS AS AS AS AS ASAP AS8 ASC ASC ASCII qrm qrm qrm
TERM qntiradiation
armature arming (altn cable missile abbr)
q e
qp 1 qp I
apls
qcl*roof
q ir
q pft
APL ap 1 apt
armored
qp 1
apld aplq qpm apotll app appar alppcon ---app 1 appn approx app t appv appv 1 appx qpr Apr aprch aprnt aprt aps apsr
APLD
APLO APM APOTH APP APPAR APPCQN APPO APPL APPN APPROX APPT
qrp qrr
arr arr qrr
ars
ars qrs qrsr qrt qrt ron artcc
APPV
APPVL APPX APR APR APRCH APRNT APRT APS AP$R APT APT &PT APT
qrtcld qrtf
articulated
qrtificial
arti llery q ir specification qtrscoop airspeed qfmweter switch antisubmarine q utomatic sprfnkler as soon as possible asbestos automatic sensitlvtty control q uxiliary sultch (breaker) normally closed American National Standard Code for Information Znterchangc airport surface detection radar qutomatic stab{ l{zatfon qqu ! pment qtmospheric sound focusing gain aeronautical standards greup assignmmt q ssign air shutoff a-litude shfft keying above s-a level q ir to surface mlsslle assemt31e (auto manufacture ng) average sa~le number astronautical auxiliary switch (breaker) normal ly open qspha 1 t asphalt plank floor asphalt rOOf ShlngleS alloy steel protective plating q spirator q ir sea rescue q lr search radar q irborne survei llance radar qutomat~c send receive
qrty
qs
as qs qs as qs qsap qsb qsc
apt apt qp t
apt
qsc
ASCI !
APTC APu
APU APVD APU AQ AOGV AQL AOT AR AR AR AR AR& ARAO ARo ARC~S ARCCOT ARccsc ARCH aRcH ARCSCC ARC$IN ARCT AN ARcu AROME ARG ARITH ARITW ARL
aptc
Spu ?pu apvd apu
ASOR ASE ASFG ASG ASGMT ASON ASHOF ASK ASL ASM ASM ASN ASNAUT ASO ASPH ASPHPF ASPHRS ASP? ASPRTR ASR ASR ASR hsR
asdr
qq qqgv
4QL AQT ar qr ar qr qra arad a rb arccos qrcco t 8.-CCSC arch aarcs,c arcsin arctan qrar8 rg qrfth qri thu AR L
As E
qsfg
ASG
qsgmt
asgn
qshe+
ask
qs ! qsm
asm ASN asnaut qso
qsph
q sphpf
asphrs
qspp
qsprtr
qsr qsr qsr qsr
85
ABBREVIATION
ASR ASROC asr qsroc asrt qssqssn 8SSOC asst asstn qssy astb q sttg qstn aster ASTREC astrg astro q strophys 8SV ASW qsbl
TERM
automatic spri-ler rtser qnt isubmarine rocket qssort *SS*1O Ossociatfon Sssoct q tc qsststmt 8ssistanc8 q ss-ly sstable q stigmatism astern qntisubmarine torpedo q tomic strtke recording Sys tam q tr starting qstronomic qstrophysics q ng)e stop valve qntlsubmar{ne warfare 8uxf Itary Suftctl Amerfcan Stsel Wire Gage q syRuRtrtc q syaptote qsynchronous Slrttght qmere turn qntfta~ qtomtc (c* form) q tomfc weight qtomic exploston q tomic hydrogen weld
ABBREVIATION
ATS ATS ATS ATT ATTO ATTEN ATTN ATTY ATU ATU
TERM
transportable q lr air turbine starter qstronomical ttme attendant sonar swftch
q ts
ats *ts q tt qttd qtten qttn qtty qtu a tu ATV q tv
hsuT
ASSEM ASSN ASSOC ASST ASSTN ASSY ASTB AST 1 G ASTN ASTOR ASTREC AS7RG AS7R0 ASTROPWYS
q ttttude
attenuate q ttentfon a tt orney antenna tun{ng untt automatic trackfng unft amat=r television automattc thresnoid v*riatlon automattc track while scan astronomical unit qudible sud \ O autodyne detectfon qnd ranging audi tor August q ir to undemater misstle authortze qutomatic qutomobt Ie Ut-WtlC check ValVe qutomattc lean qutomatic overload qutomattc rocloslng qutomattc rtch automatic stop qnd check valve autotransformer qUt0m8t~C digftal network automotive qutomation ptstol st!ffen{ng st=rter automatic starttng automattc votce network qrmored utfltty vehlCle qntfunderwater warfare quxl Ifary q uxtliary register aud~o visual available qutomatic volume control avo\r*pots qerospace vehtcle equipment qutomatic voiume expansion qventJe avtatton fuel average qverage dla~ter avtatton gasoltne qvtztfon q lectron~cs avatlabtltty q irborne very low frequency afrborne vlbratton fWMIttOr avlatton automatic video notse leveling qviation otl qverage picture level q !t~tude vertical velocity Indtcator qbove water qcid waste q ll weather armtng utre automatic
ATV
A7V ATWS AU AUD Auu AUOAR AtJOTR AUG AUN AUTH AUTO AUTO AUTO AUTO AUTO AUTO AUTO AUTO AUTO
qtws
qu aud qud qudar
ksv
ASU ASU ASV4G ASYM ASYMP ASYN AT Al aT At AT UT AT XPL AT/w AtA ATAR A7B ATEM ATC ATC ATC ATCE ATCN A7CN ATCK ATO ATE ATF ATF ATFR
qudtr
Aug
qum qut~
auto quto CV quto LEAN quto OVLO auto RECL quto RICH .auto S6CV quto XWR
cv
lean ovld reel rich S6CV
qsphalt
qutomatic qntitank
terrafn
q ircr8ft
qvo~dance
quto
rocket
ball fstic
AUTODIN
AUTOM AUTOhUU AUTOP AUTOSTIF AUTOSTRT AUTOSTR7G AUTOVON Auv Auw Aux AUXR AV AVAIL AVC AVOP AVE AVC AVC AVFUEL AVG AVG OIA AWAS AVIONICS AVLBL AVLF AVM AVN AVNL AVOIL AVPL AVV I AU AU AU AU
xfmr AUTODIN
q tc
ATC qtc ATCQ q teh
qutomattc 8utomattc
test
q nd c-out
q utostrtg
AUTOVON
qutomatic qutomatte
qtch
a tck qtd ATE atf q tf q tfr
A7H
AT I ATL ATN ATM ATM ATNG ATM ATORP ATOS ATOT ATOT ATP A7R ATR ATR ATRAN ATRC ATUN ATRT
q th
AT
q tl q tm q tm qtm
qtmg
atnm
atorp
ATOS
q trc atrm
atrt
equipment qttach Sttacmt q ttack q lr turbine dr Ve equipment qutomatic test qsphalt ttle # oor in followlng qutomatic terr qutomatic twratn foilout~ radar qthuartshfp qverage total Inspsctfon s~ti?icfal transmission lfne air turbtne motor mfsslle qntitank qtmosphere qtomtztng qntitank nonmetallic anti torpedo Assisted Takeoff System qctual ttover target q ngle track on target authortty to proceed ~r transport radfo qntitransmtt recefvc qttenuated total r-flectanc= qutomatic terrain recognit~on qnd navfgatton q ntitrack~ng control qfter torp~do room antttransmlt receive tube
quv
AUW
qux quxr
qv avat 1 qvc avdp AVE ~vg qve SVfuel qV9
qvg dta qvgas qvlontcs qvlbl qvlf qvm qvn qvn 1 qvot
1
q vpl
avv i
qw
qu
qu qu
86
MIL-STD-12D 29 hy 1981
ABBREVIATION
AUAR AUAT AWG
TERM
weight qverage resolut ~on qrea we fghted qverage T -ntir Anxwican Wire Oage q wning anchor wfndlass American War Standard qx~al flow quxt Ilary drum automatic transformer qxial pitch azlwth qzlwuth qnd elevation qzinuth elevation qzirfuth only qziwth qnd range
ABBREVIATION
BASIC BASIC
TERM
beginners qn-purpose syblic Instruct Ion coda (co~uters) batter battery (electrical) Chg
quar
awa
area
AWN
AWNOLS
AW(3 qwn
awnd Is
AUS ax fl
AUS
AX FL AXD AXFMR AXP AZ AZEL AZEL AZON AZRNG AZ S o 8 n B B B B n B BOFB BT08 08a 08 F B6 I 86 s 88 s B8 s maw B-w s/o B/E 8/L B/n B/M 0/S Sa 8A SA BA SW BAO 8A8S 8ACT @AE BAF BAG aAK BAL BAL OAL CL OAL V SALRHEO 8ALS SALUN BAM81 BANG BAR BAR8 BAR(I BARR 8AS BAS NET . ..*
batt
qxd
candelabra
candelabra
double
si~le
axfmr qxp az
qze I qzel qzun qzrng
8ZS
WE
BELOW
BAYC BAYSK 98
bayonet
b b 0
b
set
%8 06 88 090
%6L BBL ROLL BBM
bb bb bb bb
bbb bb!
bbl rOt~
devfce)
b b
b
BORG
of shtp
bbrg
SUYCY Bc
Sc
bbycy
bc bc bc bc bc bc bc bc bc bc bc bc
bcc
b
bofb btob b8b b8 f bh i bb s b6 s B&s bh W b-w
back
bell bell base beams bell Brown black black btnsry
to back
qnd bell qnd flange and tncrement qnd stringers qnd spigot qnd Sharp Wire qnd white
and to white decfmal prints
SC EC SC SC
6C
candelabra bayonet skirted base band bbulletin board bunching block body bound bolts barrel barrel roller . break before make ball bearing bow buoyancy back connected barge, cargo barium crown
Ec
BC
Gage
bonded
bookcase bottom
single
chord
cotton
(inWJl)
DC UC
BC
b/d b/e
bi ? b/m
b/m b/s
btll
of
exchange
acc Bco
BCFSK ECHO BCI
Ecd
bcf sk bchg bc i bc i bck t bc 1 bc 1 Bc 1
ba
ba ba ba
sw
bab
BABS Dact bae baf bag bak
bill of lading Bill of material buffer multiplexer btll of sale backlash q llowance breathing apparatus buffer q nplifler bell q )arrn switch bam f tt blind q pproach beacon system bacteriological beacon antenna equipment baffle baggage
cubic
decimal
frequency shift
keying
bunch i ng b~nary coded information broadcast interference becket basic contour line
BCI
BCKT 6CL 9CL BCL
BCN BCO BCO SCR 8CRT 8CT 8CT Bcvx
bicycle
breom beacon closet
binary bridge
coded
cutoff
octal
bsk =Fy
balance ballfstfc
ba 1 ba 1 bai cl
bal V ba 1rheo bals balun bai bamg Dar barb bare barr bas bas 4-09,
bc t
balancfng set balance to unbalance network ba}listlc missile boost intercept browning 81rCraft mJJCHlfW3 [gun ) bPOUning automatic rifle barbette barometer
BD 80 00 00 BO ELIM 00 LT Boc BQC BDC 80F BOG am 8_mI 001 00IA .*..
speed
..*.*. .
basic **9.m
network
borocarbon resistor btnary coded range ttme body cmntered tetragonal bushing current transformer biconvex base detonat~ng battle clresstng binary decoder board band Qlimtnatton bow designation light bfnary decimal counter bCtftd8d double cotton IInsull bottom dead center base detonat~ng fuze binding b!ndtng head bearing d!stance heading Indicator bearing deviation fndicator base d{af?wter q .*.*. . . . . . .
BAY
CAN)
DC
BAY CAND SC
XIL-STD-12D 29 :Y=y1981
A13BREl*IAT10N
00L BOLR BON SONG 800
AW3REVJATION BIN
OINOMEXP btn
TER LM
binary blnorwtnal bfology
b t nomew
BIO
8100EF BIOL
BIOL OIONICS OIOR BIPO BIT BITE S! TUM :: BK UK SK BKo BKffl BKDNO 10 BKCO BKLT BK$ BKSLF EKT BL BL BL 9L BL 8L ~: EL BL BL
beqmn
b 1rider bonded
doublo sflk ffnsul) brssS dfvtd-r strip base detonating s81f destroying bob dunm?y un~t binary dlvtde
blo bfodef blol blot bion~cs blor btpd blt btte bi turn
b] b] ---bk bk bkd bk dn bkdnd{o bk gd bklt bks
btologtcal
biological
bdy bdzr be
be Be be
9E 6EC0
BEF BEL CRK Ol!oc SER BERTH SES SESS nEss 9ETU, , 8CV OF OF SF of
btcslf bk t ---bl
bl
q lectronfcs business fnput output blpart{ng doors binary dtg{t built-in test equipment b{tumtnous barrage jafmners break jaw black (altn qbbr) k neck down barge, brake blackboard break down breakdown diode background booklet barracks bzckshelf bucket
biology biological
rerun
qbbr)
bl bl
bl bl bl bl
bl bl
billet blade bleed bone ltne bottom Iayer breech load~ng buflding line but-lfve butt Ilne buttock ?Ine billet steel blind load andrplug bltrtd load and tracer boundary layer control balanced line drtver bllnder
bsekfaee
base fuze beat fr=~ency bofler feed boldface (type) both faces bottom face band filter cutoft boiler fe=d cmpound tank back focal distance bookform ctrawfng b8am forming electrode buffing back focal length beat frequency oscillator boiler fees pu~
Of w w OF aFco OFCT
UFO eFQ OFE BFG 8FL UFO
bf bf
bf bf CO bfct
bfd bfd
bfe bfg bf 1
of P
9fR SFR EfR BFW BG BG 8W OH BH 8MA SHO WIN :!$ 81 s: BICONO BIL OIL
bfo bfp bf r
bf r
-f
bltp
ore
fYams rat!o
bfr bfw bg
bg bgp btl
Bh bha bhd 9 hn bnp
buffer
boiler
feed
gear grease house
water
back
Defg$ barrier bo~ler
proof
mer
bw bl b{ b i COnd
btl btl
horsepower braks horsepower base fgnitton black tron btcond~t~onal basfc inwulse tnsulatton 1qve ! blue indicating Ilght
bl BL OL bl BL bl bl Stl BL STL BLAP bl~p DLhT bl&t SLC blc BLD bld bid BLD BLOG bldg 8LDR bldr ELF blf blk ELK BLK blk BLK blk BLKG blkg BLKG blkg B LKGD blkgd BLKN blkn blkng BLKNG BLKT blkt BLMTH blmth bln BLN DLNG blng BLO blo blr BLR blst BLST BLSTG PWO blstu pwd BLT blt BLT blt OLT 87 blt bt BLTIN blttn BLU blu blu BLU blvd OLVO blw OLW
l!ght
flfng
blank b 1ock
b)anktng blocking
blank{ng
b 1 qck en blackening blankwt
die
powder
bolt
boulevsrd
below
MIL-STD-12D 29 my 19::1
ABf?REvl
9LUDN
ATION
b 1wdn blws
TERM b 1oudown
bellws blw torch blouout ball lstic mtssile beam bench mark breech mechanfsm bombard i er bench maintenance equipment brake =an q ffective pressure Ballistic Mlssfle Early btarntng System browning machine gun DO~lermakeP buoy messenger beamsteertng bimetal!~c barrier moisture vapor proof beanwidth batch mixer battalion btnary ~r bull nosa bench benchboard
ABBREVIATION
BP 8P BP 8P 8P 0P 8P BP BP 8P iiPc 8P0 w m m
TERM
BLWS
SLUT ELWT BM BM EM BM BM9DR BME BMEP SMEWS aMG SMKR BMSS BMST RG
base base
pttch
plate
blwt
blut
bm m bm bm
bmbdr bmeP BME WS
z
w m w m w
bluepr~nt
boilerplate boilfng point
plate
plane paper
bonded
control
(insul
bpc
bpd
bpcl
pressure
BPO
BPG BPH BP I 8PLA BPRF BPS BPS
bpg
b-r bmss
bph bpi
bpla bpr f bps bps bpt bpu ---br br br
br br br Br
barrels per day bush~ng potenttal device breSkpUIS@ generator per hour barrels bits per Inch
bow piane
bullatproaf bearing procur-nt
OPT BPU
OR BR BR BR BR 8R 8R BR STD BRAZ BRC SRCH BRD BRO BROG BRG BR~ BRH BRHG SRI tiRIL ORK BRK BRK80 BRKG BRKR BRKY 8RLP 8RLS BRN 8RNG SRNSHR BRP BRRU BRRG BRS BRSIT ORST STR 8RSTR 9RT 8R1 SRTH ORTkiR BRZ 8RZ BRZG es BS as
specification bits per second bfpost processing basic brown laltn qbbr}
bedroom
un{t
bnch
bnchbd bnc 1
bend book
branch
radius
rack
regfster Standard
binnacle
binocular band bonded
bnc 1r
bnd bnd bnd dfS bndg
bndz
bnf bng bnls bnr
braz brace
British brazier
braC@
broach bra i d bra i ded br t dge
bear I ng
BNS
bnsh on t
system
SOA 808 aoc Euc mi3 BOD Bor Eofs SUG BOLS BOLT BOMST
bo 00 be bo bo bo/bs boa
bob boc boc
brng
brnshr brp
bofling erwakoff
bolster
height
brrd brrg
brs brs i t
beam of ~ardment
light
transistor
(projectile)
Soss
bet botmg bowr w bp m
brst brstr
br t br t
brth brthr
str
indicator brflltance break brick brakebanci breaking breaker brccket bur 1 ap Barrier Ready Ltght System brwn burn Tng burn{ sher beacon ranging pUlS8 barred barring brass boreslght bursting strength burs ter brfght brightness
orbltlng
station
brea t im breather
braze bronze brazing binary SUbtraCt black scale boService
blackout wtndw
boiler water back pressurm bandpass base percussion
KIL-STD-12D 29 my 1981
TERM backward
bwo bwpa bwr bwstrn bxdt bx f bynt byP
ABBREVIATION
8s
ABBREVIATION
bs
8UN
BUO BwP BWPA
wava
magnetron
8s
bs
bs
bsc bsc b,f 1 bs~ bsk t bslr bsmi th bsmt bsp
0s
Ssc Osc
BSFL
backward
wave oscillator
SSUQ
mm 8WS
EWSTRN BUV axDT BXF BYNT BY?
bandufdtn
beveled
ratfO
WO~ sfd~ng
elsut
8SLR 8SMITH 0s?47
basket
bus selector blaCkSIIIlth basement tml?stop blip scan rat\O blua stern light boost FOCk=t
BSP
8SR 8ST LT BST RKT SSTB Ssra ST ST ST BT 8TCR BTO BTDL BTF BTFL BTH BTL BTLL BTLR BTN BTIWO 8T0 DTR 6TR OTR DTRY 8TS OTST OTU BTWLO Ou au Su 9UBMEM BUCK Duxc
c ; c c c c
c
c c c
ValV8 boxcar detector box ftn buoyant bypass capac~tanCe (co~ form) cast (co~ form) cathode (CO* form) clear: reset
bt bt bt btcr
btd BTOL btf
btfl
bth
btl btll
trslnfng bathyt-r-graph bent bus tla butcher bm testfng device back transfent diode loglc btall fuse butterfly bertm bottle bottom lead left bottom lead right button button head b~ing thrwgh overcast barrel tile rwf bus transfer
. .
;
c c c
c c c c Ctoc c8 a
device)
;TOC clkA
chd egd
c6h cbn cb t c/n c/o c/u c/w ca ca Ca cab
center to center qnd qccess ce~artmnt commmtcattons and data qnd dtsplays controls
coat qnd hat hooks commmtcattons and navigation communications acarrter to noise consist of camier wave coqlete wtth cab I q c ~rca clear aperture cab t n
t=~e~try
bush
transfer
bat tery
blue tool steel bootstrap I!Drttish themmal unit buttwld bulk (substrate l(el~tron device) bureau bushe 1 bubble memofy buckrm baCkWp interceptor control Barrier Up Indicator System bulletin bend up bus t ness bushtng (a\tn buoy unde-ater butanw abbr) sound stgmal
cab
cacb cad cad cad cad cad CAO cadi cade Cage CAI Ca ! ca I C81 Ca 1 talc cam cam CAM CANA CANAC
cabinet
co~ress~ breaker Cabltng
q tr
c{rcuit
cartr~d~
BUIS
BULL 8UP Bus BUSH Suss WN euz av 8V 8VC BVGE Ow SW au 9W Bw au a BW LT DUG 8UL
conputer conWJter
access q ided
devtce design
buzzer back
bv
vtew breakVolta= black varnfSh Ca-rlC (insul) beverage Bandwidth below water biological warfare both ways Braldti w(ro qrmr
coqwter qccess devfce tnwt ccmqauter qccess ctevicoutput coded qutomatic gafn control comutur-af~d tnstmct~on caliber calfttrate callbratiom calorie calculate ca~er Chtiout qnd qutomatic
monltor~ng cewwuter-ai~d
centralfzd message
c~ter-autmatti masur~nt
manufacture
q ccountln9
qnd
q utomattc
control
qnd s,alfng
camof
camr can cane canal
camouflage
camera canopy cmce 1 candelabra
bv
BWG
Bw 1
w~r= lfne
Ga=
MIL-STD-12D 29 My 1981
TERM
candelabra screw cantilever cancel led transmission canvas capacitance capacitor capacity capi tal cap scrw communications qutomatic processing equlpnwnt capacitor start capacitor start and run cargo carburetor carburizc carpet comqwted q {r release point carrier carrter current calculated qirspeed cal~brated air speed cascade castle castle nut
Carw
SCr cant( 1 cantran canv cap cap, cap cap cap scr cape caps t capst8r car carb care carp carp earr carr cur eas cas cas cas cas nut case
Cbshp
Cbt Cbx cc cc cc cc cc
Cau
C8X cc cc cc cc cc cc cc cc CCA CC8 ccc ccc cm
CCD
cc
cc cc
cluster boa unft cam box cam chafr cam Chafr close coupled Closfng coil color code commn coilector cross coupie
cca
ccb ccc ccc
ced
ccd
ccd cc f Ccft Ccg Ccg Cchk Ccm ccm
Cco
CCF CCFt CCG CCG cm CCN cm cm CCND
core
CUrrent
drfver
CCM Ccnd
turbulence
computerized tomography
qxial
concrete floor controlled current feedback transfo-r cargo center of gravity constant current generator Cont{nutty check constant current modulation carrier controlled modulation counter countermeasures continuous current monitoring device coinnand control nuber cuntract change nottce crystal controlled
CB Cb cb es Cb C8
cba cba 1 Cbd Cb I rd
couputer aided test equipment cathode cattle htde cable televtsfon cofmmntty antenna television crypto q ncillary unit taut ion cavity Ceflfng and vlslbllity unl imited cof!awnlty qutomatic exchange catch basfn ce!mnt base center of buoyancy circuit breaker citizens band coaswon base comon battery c~arator buffer cmponent boar8 continuous taloudown cqenent beard qss-?y counterbal qnte carbide
oscillator
CCOP CCP CCR Ccs Ccs CCSA CCSL
CCT CCT ccr constant pressure control oil
cryptologic
ccurh cd cd
cd
program control contactor cont~nuous Comerctal service hundred call seconds co-n-control switching arrangement Compatible current-sinking logic circle cutting constant current transformer closed circuit television camera control unit common control unit coronary-care unit Counterclockwise canvas covered wtre rope handratl
cable
act
cable
reed
cd
cd cd cd
C8PMP Cm C8S
cbs
chemical biological nunitions current bft mon{tor unit carbine carbon tetrachlortue counterbore count-rbore other side cold brine pu?v chemical btologfcal radtolog~cal (warfare) call box station
cd
cd cd cd
PL
ROR
CD
Cl)A
cd cd cd
p! rdr
cda
candle capacitor diode card center distance circuit description co{n di~le cold drawn conm?on digft~zer cord crystal driver current density cadmium plate card reader comand data acuuisltton
91
JILL-S
L>lLIJ
29
}ky
1981
ABBREVIATION
Cdb Cdc CDC COtL CDF COG CDI CDL cm coo CDP CDR
TERM
ABBREVIATION
CFAl! crfterla CFAR CFC CFE CF F CF L CF AE CFAR Cfc CFC
TER,M
contractor furnished q trcraft qquipment constant false q larm rats central f)re control contractor furntshed q qu{~nt crttical fltcker frequency calibrated focat length confltct counterflasning cathode follower mixer center frequency modulation cubic foot ($eet) per Intnute contractor furnished preperty carbon film resfstor crossfire carrier frsqmncy shift center frequency stabilization cold finished steel confuse cubic foot i feet) per second confusion clean fuel oil tank cage center of gravtty chain grate clutter gate phosgene cleaning gear locker centfswter gram secorm ceramic glazed structural facing units cl~ar giazed structural factng untts ceramtc glazed structural unit base clear g!azed stmctural unit base caramtc glazed units case tmrden cha i n chief chiffonier choke coat hook conductor head chiffonier locker chiffonier mirror challenge chmmf er chamer (altn abbr) channe I channel qntry channel shifter chsp tw character Cbassts check cofl choke COII chord chemical change (altn abt$r) charge change over charger check check blt checker chilled eha-r
q ***** q ***
cde
Cde cdf cdg cd f
constant c-fried
delivery
COL
Cdm
Cf f Cf 1 .
Cf 1 Cflg cfm cfm
Cdo
Cdp edr cdr cdr cdrfl? cdrillo cdr I
CDR
COR CDRILL CDRYLLO CDRL CDS Cos CDT COTY CDW cow CDWR COWR COWT Cox CE :: %A CEF CEI CEL CEM CEM CEM WRT CENC CEM~
cfm CFP
cf r
Cfr
Cfs Cf s Cf s efs Cfs cfsn Cf t Cg Cg Cg Cg Cg cg lkr c 9s Cgsfu
cds
cds
cd t cdty Cdw Cdw ccfur cdur
CfM)St chilled
Of
dFaWM dri-ing
water
.
edw t
Cdx ee CE Ce Cu cea Cef cc f ee I Celn
transmitter eonaaon emitter comunicatlons electronics cmmmtator end conducted emisston cfreular wrror qverage
caerter q limlnat{on ftlter contract qnd {tern celesttal c-n t c~nicattons electronics meteof-ologlcal cement mortar counter electromotive cell counter q lectromotive force circular error probability ceramic Cofmmnity educational radio ffxed servfce ceramic metal element ceram~c to metal (seal ) cert i fy Cunulattve elapsed time cable fuzing [firing) carrier frequency cathode follower cement floor center of ftotation centr~fuga? force co~l fln~sb
Cgs f u
Cgsub
cgsub Cgu Ch Ctl ch Ch ch Ch ch ch I&r clt mtr Cha 1 chain ---than SEE chap char chas Chc chc Clld
CEM
Cem mort cemc Cemt cep cer CER~S e8ram cerme cert cet Cf Cf Cf ef Cf Cf Cf Cf Cf Cf ef Cf Cf t t
mm
CHAN aWN Em
CF c?
CF CF CF
cold
co-are
ftnished
CF CF CF Cf Cr
CF51 CFAC
cf8{
CFAC
[for re+erenctng) concept fornuiatton confer (conpare) (for referencing I cooltng fan counterftre contractor furnfsh qnd Install contract furntshed q lrcra?t q ~tpment
qnt l!ELOW
:* *8 Cl a 4KR
4LD
: -n
B*****
Chid -r
q *.***
CH&N
SHFTR
than shftr
channel shifter
MIL-STD-12D 29 WY 1981
AB13REIIATION ch~
Chp chr Chr chrom chrs t Chw Cl Ci c{ et Ct
TERiM
change chopper character eeg~ster ctirom ( um chrom i nanC8 charactertsttc chilled water cast tron ctrcutt interrupter c~tmr fndfcator conftguratlon Item counter tntelltgenCe co-at ~nformation cent8r cast iron conduit box coqso-t Identlflcatfon coqonent fdentlffcatien nu**r qnd freight cost , Insurance enciphered facsfmlle cofmamtcat Ions clear indicating lfght carrier input code identification number cinematography ic cast iron pipe c~ressor \nlet pressure c~rcle circular clos=-in s~port coaqressor inlettemperature construction jotnt cork cork base board cork co@pl@tely knocked doun Curk f?oor Cockpi check circuit circuit circuit circuft ctrcuit carload t
ABBREVIATION
CHROM
CHRST c1 c1 CI
CI c! CIC CICND
CIC
BOX cicnd eid box no
cii
CID NO CXF
CIFAX C: L
cid Cff
Cifax Cil Cirl cin eine Ctp eip cir circ Cts Cit Cj ck ckb ck bd
CIN CIN
CINE
CI P
CLP SCR CLPR CLPR CLR CLR CLR CLR CLR CLRG CLRG CLRN CLS CLS CLSC CLSTBfl CLT CLTG CLTH CLTHG CLTR CL7RM
CLTV CLU
elp
CLV
CLWG z CM u CN CN CM
ckd
ck f ckpt Ckt Ckt ckt bkr Ckt c1 Citt Op cktf c1 cl c1 c1 cl cl c1 cl cl CI Cllp Cl@ cla C18C clamti elar
teq81ate
%50
breaker closlng opening finder Ialtn
clpr clpr clr Clr clr clr clr clrg clrg C!rm Cls Cls Clsc clstbb Clt Cltg clth c1 thg cltr c1 trm Cltv Clu Clv Clwg q cm cm cm cm cm cm CM CNbo cma
caltper
c t apper clear collar co I or coo 1 qr current limiting clearing coll~ctor Ffng cool room classify constant level coalesce cluster bocleat eollscting cut length clothing
resistor
speech
clutter
clutter map collective central logtc unit clevts clear wire glass calibrated magniftcattm center matched chemical milling circutt master comnand module cure memory corrective maintenance countermeasures countermeasures qnd deception contact making [or breaking) aavneter com { ne c-$ ned co-s tor contact making clock cam case conmand core me~ry drfver current mode dlgftal to q nalog converter corwnodi ty coated metal coherent memory filter cam fol louor homing countermeasures, circular mll current mode logic chemical defensm Conwen t carbon mlyedenum steel coaqlemantary metal-oxide
qbbr)
CKT OP
Q(TF CL CL CL CL CL CL %
mm mm
CNBSTR
-d
c-d
cmstr Cmc Cmcs C* Cmdac
center llne
class clearance c 10s0 closed loop C)osing clutch contact lost crane load cl Ip
CNcs CNOAC
CMOTY CNET CMF
CL CL
CL CLA CLA CLAC CLAMTI am CLASS CLB .
CLD CLOY CLE CLG CLG CLU
cmldef
Cmnt Cnws
line
bend
CMos z
semiconductor
CNPo CNPKT CNPLM CNPNT CNPR CNP s c-d t CnQtc
cnplm cwqant cltQr Cms cowonent metal parts corrugated metal p~pe co~ound ca~ocket Cufqi 1emen t c~onent coware eenti-ter per second
Rnd
joint
CLK CLKG
CLKJ CLN
joint
93
KIL-srD-12D
ATION Cnps
Cllqmcty cnqxn
TERM
eomQ8ss computer security Cqos t t i Ofi c~os 1 te
A13FIREVIATION
TERM
mm CUSHF7
c~tc
e~tlng c~ter comnon mod= rej-t ion coamuntcations -on r=e18y cam rol Ier current modc switchff% camshaft
Cmt cmv m cn cn en cna cnc 1 cncr Cnc t rc cncv cnd cndc t cndc t cndc t Cnds CN I cns cns 1d crisp entfard cntd cntfgl cntnr
Corwntt
contact makfng volt-ter can ch~n@ notice chloracetop-mne copper ntckel qlloy concealed concurrent concentric concave Condu i t Conoc t Conduettvl ty conductor condensate ccwmmmicatton navigation \denttficatiom ch!oracetop~solution consol idata consplwws IY centert30ard contained centrifugal container eontaetor counter convenience conveyor central office change or-r checkout cl-amt c~any Cute+ f cutout constant output a~liffer coarn 1ng coherent qrray radar coaxtal cobb I cr cobalt chrome coded blphase coamm business-orient~ 1anguag8 Coding carrier operated device antlnolse correlation dfsplay analyzt~ and recording coder decoder
cntor
cntr envc cnvr co co co co co co eo Coa coam coar coax Cobb Cobcrm cob t COBOL cod COOAN coda~ codec cod t t Coe coed coef cot Cof f cofml cog
Cuvc CNVR co co co co co co co COA CDAM COAR COAX C(I8S msmw COBI COBOL cm COOAN
CQOAR COuec CODI T cot COEO COEF cur Corr mm au
computerdfr=t to t*leWa~
cab over ~lne ccwuuter operated electronic display cOefflcfent conical fin
cofferdam
coffee mill cognizant
Contimous Orbttal Gutdanco COGS COGS system coherent oscillator coho CONO counterinsur~wy co~n COIN co I Umn co I COL cold leg Colg COLG coherent ltght detection CO1 tdar COL 1 DAR and ranging collimator coltm COL:M CO1 Iector Coil COLL eO~ lotd Coil COLL collaboration Collab COLLAB cologarlthm co 1Og COLOG collapse co 1ps COLPS communication Ifne colt COLT terminator comon com COM cmeinat~on cCOM8 combining cCOMB eowdwst ion Comb c0n43ustlble comtY 1 :OMBL comnunlcat ions comcm X)MCM counter-asures qnd deception cofnnand weapon carrier Cored UC mMo UC commmicatfons lntell Igence comtnt :UM I NT commmicat~ons janmitng comj am mNdAM cowmerc ia 1 Cowl1 mm comnunhcat~on Comn mm commutator Coman mw conwunicattons wed comneed CONWEO CoImmJnlcattons network Comne t CONNET coherent master oscillator Com cow conpan~on COUQ COUP co~ensator Coq cow conpfler cm co~ressed alr compa c~ressor expander co~i ier ass-ler conq2ass COMPASS co~ensate conpen CONPEN c~os~tion floor Conwf CoMw complete CorrpI COMPL cofmmnications tag pool COrrpoo 1 COMPOOL ---c~ressor (altn abbr~ cONPR eo~ositlon roof cofrpr ~MPR cowpwwating Comsg COMPSG compartment Conp t COMPT cowarator Com)tr COMPTR c~tometer conw t r cOMPTR cwwmmications satellite c(M4SAT CDMSAT conmisston comsn COMSN commercial translator comtran COMTRAN concession con CON construction spectflcatfon con spec CON SPEC ---concmtrlc (altn abbr) concentrate Cone concrete cone CONC conclusion Cone I CONCL ---conditton (altn abbr) CONO ---conductor faltn abbr) CONO condenser Cond CONO cwndittor~ conatn CONOTN cenferonco conf cow confidential conf CONF conf 1ne conf Cmf conformance conf CONF configuration conf Ig CONF I G concf~tioned reflex (machine! conf 1qx CONFLEX congruent congr CON(3R conjunction conj CONd eonf ca ! con 1 COW. connection corm Cow
94
MIL-STD12D 29 my 1981
ABBREVIATION
COWI OIAG COM4RO0 CONSCAN CONSEC CONS XM Cmsl CONSTR CONSTR CONSULT ~NT CONT CON7 CONT CONT CONT eenn corm d{ag cennrod conscan consec cons{m cons t cons t r constr consu 1 t cent cent con t cent con t con t cent cent ckt Cent hp cent ud conta cent am con td contr contr central 1 contrib contro contv contwr conv cvnv
AW?REVIATION
COTAR cotar coth eov Cov Cov covers cow I Coz t CP CP CP Cp CP Cp Cp Cp Cp Cp
TERM
correlated orientation tracking and ranging hyperbolic cotangent cover cutoff valve cutout valve coversed stne cowl I ng commumtcattons zone
CONTRAIL CONTRIE CONTRO CONTW coNTWR CONV CONV coNV CONV CONVG CONVN CoNVR COOL COORD COP COP PL COPO COR cm COR COR 80 CORA
CORAO CORAL CORAL
conv
conv convg conv n comvr coo 1 coord cop cop pl eopd cor cor eor car bd cora corad cora I cora 1 corcn corp corr corr corr fbd corre corres Cos Cos Cos
mRcN
CORP CORR mRR CORR F130 CORRE CORRES Cos Cos Cos
~SAL COSH COST Col
connectl~ rod conical scan consecutive console staulator constant constraint construction consultant contact contents eont i nue continued laltn qbbr) continuous control controller control circutt continental horsepower control word control qss-ly contaminated Coflt t nued contract contractor condensation trail contriwtfon contracting offtcer continuous wtnoow conning tower convention convert converter COnVUrtibl q convergence convection convector cool ant coordinate coppor copper plate coppe~ed carrier operated relay contactor, running corner corner bead condi ttoned response qnalog fmachine) corre}atton radar cO~and radio 1 ~nk correlation rad{o link coercion corporation corree$ corrugate corrugated f{bertsoard correlate correspond cassette-operated system contactor, starting eos t ne
COTH
Cov Cov
Cov
COVERS
COWL
COZ
candlepower
center of pressure center punch centipoise cesspool change point chemically pure c~ecuit package circular pitch ctrcular polarization claw plate clay pipe
Cp CP 7 CP CP w w CP
Cp
Ciock
pu?se
of
performance
Cp CP v
CPACS cpam Cpbl cl= Cpc Cpctl cpd cpe cpe Cpf f Cp 1 Cp 1 Cptn
mass
prop
Cpl
cpl cpld
Cplg
cplr cplr cplry
76S
CPM
CPNTR
t8b
CPO CPPO
CPREF
Cpo
cppd cpref
cosa 1
cosh cost cot cot cot cot cot
coordinated q llouancm
shipboard
?tst cosine oll
web
hypereol~c contaminated t qnk cotangent cotter cotter p{n cotton cotton W@Dblng
cpress cprs
cprsn
cement plaster cet?tng clock pulsed control conputer process control controllable pitch propeller contact potentfal.difference centra? processing element CirCUlar probable error test p)us fixed fee cost plus fncenttve crash posit ton tnd{cator Cramkpfn cement ptaster coup I e cwp 1ed coupl ing center of pillar coup 1qr capil lary capillary tube and bulb card per minute Crttfcal path mthod carpenter commd pulse output capped candelabra prefocused coqound pressure
corfpress
co~resslon co~ressor Clrcutt co-ass counterpoi coherent capsu 1e
settltng
cprsr
Cps CpS ~sg
CPS
Cps CMPSG
CPSE
CPSK CPSL CPSN CPT
cpse
Cpsk Cps I cpsn Cpt
capstan casement
projected
transom
95
?lIL-sTD-12D 29 my 1981
ABRREVIATION
CPT
IERM
power transfo-r path tccftntae crit~cal central process~ng unft counterpunch cofmwrc{al projected wtndow control
AflBREVIATION
CRYPTO CRYST crypto
TER!$l
cryptography crystal 1 {ne carbon steel carrfer supply case cast steel cast stone center section clese support co~l stietch Comercfal Stanaard c~n steel lproject(le)
Cpt
Cp t
Cpu cpunch
WT
CPUNCH
CPU
CQ
Cpw
Cq cr cl= cr cr
c~rcial
cathode Chmge cola eou$sat
~ality
ray
requmst
CR
CR CR
Cs Cs Cs Cs Cs Cs E: Cs Cs Cs Cs Cs Cs Cs Cs Csu Csc Csc Cscn CSCH CSCR CSD Cso CSD Cst CSE CSG CSHAFT CSNG CSK CSKH CSKO
CSL CSM
relled
CR
CR CR
cr
cr Cr cr Cr
complete
CR CR CR
CR CR
cr
cr
ready round co~onent repatr continuous rod control relay cwitrol room controlled rectlffer Cred ~ t
crys t Cs Cs Cs Cs Cs Cs Cs es
Cs
:
CR CR NOLY
SEE BELOW CR VAN CRAN CR8NT cRllso CRC
cr cr
cr cr moly SEE BELOW cr van cram crbnt
crew
crystal
(as
spaces)
crbsd
erc Crcl t ercmf crctd crdf crd 1 ere cres crf t crg crtt crt tf crank crkc crkshv Crm CRM Crmt crn crown crnmtc crnmtr Cro cro CROM Crp crp 1 crs crs Crshd
CRCLT CRCMF
CRCTD CROF
CROL CRE CUES CRFT CRG CRIT CR17F CRK CRKC CRKSHV CRM CRM CRMt CRN CRN WNNTC CRNMTR Cl?o CRQ CROM CRp CRPL CRS CRS CRSNO
CRSNO
CRSN
SIN
CrShd
crsn
stn
mctifter curr8nt relay chrome molybdem chrome tanned leather chrome vanadium card random qccess -mrY carbonate curbs i de c~lete round cnart circulate circumference corrected cathode ray d{rectton finder crad 1e corroston resistant corrosion resistant steel crwfoot carr t qge Crftical critical fr~ency crank crankcase cranksheave chrome counter radar measures chromate crane crwn chronometer {c chronometer catfpde ray oscillograph oscil lograph control read-only memory (H-1* chromium plate coars= cold rolled steel crosshead crushed stone corrosion corrostve
conducted susceptlbtltty control switch core shift current sertes cycle Shift single cotton stngle silk (tnsul) concrete splash block cartrtdge storage case cosecant hyperbel!c constant hyperbolic cosecant cofrplementary semiconductor controlled rectif~er cold side constant spemd drtve core sh~ft ertvee coamuntcations suppof-t q lement core storage element cas { ng crankshaft Cush t ng countersink countersunk head countersink other s~de console
comnand and Servfce mcluie COppWSmlth Cfrcutt switchtng magnetic t qpe contcal scan on Pecetv= only coder se~entlal pulse cowmunicatlons satel}fte re 1 qy control shift register customer signature recfu~red control sttck s.eerlng co~attble single Stdeeand cast~ng castel late cantster ctrcu~t swltcm~ng unit control power suiteh center tap cmramic ttle c~uter$zed tomography count current transformer changeable type plate style count per m!nute count per second continental tropical q l? mass Cmramlc ttle base cam tim!ng contact Centralized Traf@lc Control close type control circuit contact coa ted
CSMITM CSMT CSORO CSP csa CSR CSR Css Csse CSTG CSTL CSTR Csu mu CT CT CT CT CT
CT-PS cT/M CTIS cTbM CTa CTC CTC CTCCC
Css
essb Cstg Cstl cstr Csu Csw Ct et
crossover cathode
ray
twbe
CT Ct Ct
Ct-ps ctlm et/s ctam ctb Ctc
ctrcult
cartr~dge cartographer controllable simlator
requirement
radar
tamle
target
cru fs
crv crv dwg cryg cryog crypts
.*9..
Crufstng
curve curve drawing carry{ng cryogenic cryptoanalys
q
{8
q
cm
****
q
..**
.**e
.**-
CR TAN LTHR
cr tan lthr
96
MIL-STD-L2D 29 my 1981
Af3BREVi/iTION
CTc
TER .M cable
termtn8t ion equipment central timing equipment ceramic tile floor coat i ng crating cuttfng cryptography centra I conplemantary transistor Ioglc core transistor Iogtc cutlary catalyst carton center con tour cut ter center frequency centarlng control (coqmters) contrast close to shoulder counteeshaf t countcrsucard-to-tape tapcentral ttmtng un$t catwa lk counterweight county crystal unit, pfezoe ectrfc
ABFIREVIATION
TERM
continuous wave intermediate frequency cirwlatfng water pu~ control wheel steerfng
Cta
CMIF
CUP Cus cut Cx CY CYCLO CYL CY L CYL CART CYLL cYls CYN o 0 0 0 D ObC DbCU 08 F ohm Obs DIA OA PA DAC OAC OACDN OACT OAO OAGC OAM DAMLG 0OAP DAR OART OAS DASTARO
Cuif
CTE CTF
CTG CTG C7G
CTGH CTL CTL ctL CTLRY CTLST CTN CTR CTR CTR
CTRF CTRG CTRL CTRS
hundredueigh
control transmitter cyc I q cyclotron cyl tnder cylindrical cylindrical cartrtdge cylinder lock cyl Indrfcal surface cyan i de deep depth of Sh\p
d
d L? e8c
double double
era~n dtsplay
(coftnsull
form) devfce)
unit
control control qnd
(electron
and
Cts
CT SktFT CTSK CTT CTU CTWALK CTWT CTY Cu : CU CU
dacu daf
dam
d~splay
and
determination
ftndings
FT
IN CUM cu Cu Yo
CUB
CUJT
d8 S dla da da
dac
dressed display
dlgitat decimal drtft dtgital data direct
q nalog
q nalog
analog convmrter ability code
dac
q vail
cubic
piezwlectric cubic foot cubic Inch crysta unit
dacon dact
dad
controller acting
ffeet)
dagc
dam
cu m Cu m = Yd cub
CUJT Culv cum Cuo cup
cubtc
cubic
mtef
milltmetmr
descriptor
dental
damlg
q malgamator
attribute
matrix
CULV CUM mu CUP CUR CURT Cusn CUST CUST CUTS Cv Cv Cv Cv Cv CVK CVL CV?4TL CVRSN Cvx m m .Cu Cw Cuba WC mfM
daw da~
dar dart
untjunction
ctlstributlon anplifler data automation proposal *+ense acquisition radar data analysts recording tape
das OASTARO
cupboard
current curtain cushion custody customer
cur
curt CUSR Cust
OASTM OAT 0A7ACOM OAVC OAZO 08 0s 08 us 0s 08 0S OBAO 080 008 Oec OBC DUD 06F 06FS OBNP 09 I 08L 08L ACT 09Lf DBLR
dastm da t da tqcorn
davc dazd a * * db do Qb * abao -e -b *C
Cus t cuts
Cv Cv Cv
array transportable detection double q cting steam datum data Communications detayed automat~c volume control double anode zener diode
decibel
distribution box double biased (relay) double bottom double braid (insul) dOUbl@ break dry bulb digttal block ANO-OR gate detector back bias detectorbalanced bias diameter bolt circle digital to binary convert-r diesel belt drfve demodulator band ftlter fintsh slate dull black
varlabie varnish
keel
Cv
Cv Cvk Cv I cvnt I cvrsn Cvx m Cu Cw CM Cwa r Cvc Cufwl
counter
single
voltage cotton
wave
acqulsltfon
condtt~on
continuous modulated
corrugated continuous
uave
wtre wave
freqency
glass
tllumlnator
qct
CUI
CV9 cut
doub 1er
97
!41L-STD-12D 29 my 1981
AI3I?REVIATION
08LU Olw dbsp
TERM
double araubar wall pull
TERM
data terminal equ 1pment digftal dtstrfbut{ng valve deck drain diesel electric digital encoder double enamel (insul) qnd deuble qnd drive deck edge light diethamolamine deaerating Oec~er dec i ma 1 decalcoman ia decareurtzatton decision decoauress ton decentamtnation decrease decrement
dfgltal dedendum d~esel
ddte ddv
de de de
08P 09SP DSU7 Dew DC Oc DC DC Oc OCD Oco DCDR 0C9S OCF EM OCG ocklAN Ocwm DCX8 DCKG DCL
double
dbut *
de ac de de
unit
dcsfgn
oamage
ctepth
charge
current contact cotton
Gimct
dcd
dcd
dcdr
dcds dc?em
dcg dchan dchem dctb
double double (~nsul) decode double channel duplex decooer double cotton doub?a (insul) dynamic crossed field .Iectren mltlpl~catlon diode Capacttor gste
de de de
It dea deartg
sf?k
f~ut
OCLR
OCLU Dc$4Ps DCMPTR
degausslng coqwter cfestgn change notice change not~ce drawing data conversion receiver
digital a~rect Convarsfon receiver current restorer
OECRT DED OEO DEF OEF DEF OEFL OEFT DEtI D:GUSG OEL OEL~ OEMA
q ngine
dtrect
drtve
def !
deft
time
qmissten
a~l ifier
drawing chaqe request double cotton stngle silk ( ~nsul ) dfrect coupled transistor logic duct type eata control unit
decade
counting unft
Ocv 00 00 00 00 00 DO 00 00 DOA DOA Ooc Ooc Ooc DOD 00 I OOL OOM DON OQPC DOR OOR 001
dectmal countfng unit digital counting untt double cutton varntsh I Insul) driver diesel direct dfg~tal data dtscmnectlng device diamond double
drydock retch door differential dfg~tal qna 1yzer
digitally d{gftal directed deep delay drawn
OENOB OEMOO OEN OCNG otNs OEP OEP OEP INST OEPR DEPT OER OER OCRIV OES OES
OESCP
demobilize
demodulator
inst
reduction
q nalog
data converter
ddc
000
dd t
ddl
ddm we
ci~g~tally directed control dual diversity cxaratur direct distance d?aling depth dev~ation tndfcator etlgital data link waxWlatton derived delta dffferenm in depth of
mlatton digital data equipment dlgfta! data
direct doppler drfve data
OESCR OCST OESTN OESTR OESTR FIR OET OE? OET DET OETl+I oE TN
Ow OEV OEV OH ocv
fir
det det de t
de t
processing
receiver translator
DCV
OEV OEVN OEVR
ddr dar dd t
EOL HGT La m
description describe destruct~on destination destructor destructive detatl detector determinant detonator detention
determination develop (altn
firing
qbbr)
Sq,#alfzer
height length wfdth
devr
qlaminating
regulator
98
YUL-STD-12D 29 My 1981
.
ARRREIIAIION
DEW DEwTRG OF or DCU
TERM
distant early deu. tcrlng warntng
TER,M
dig{tal dtrect d t Ode nulttb8am st.ertng notse q ~lfftcation
dw t rg df df
dins
dio
defogging
dense flint Ofci(e fix direct ton finder dissipation factor double feeder douglas flr .drfnklng fountatn drtve fit fOr@ drop
dtopt
OIP dtplxr
Citpx dir atr dlr dtr dir Corm dir COUP
OF OF of OF or OF OF OF DFOEL OF L DFMACH Of R OFR OFSK Df 7 OF1 OFT oFT OF7G OFTR OFT SDG DG DG DG DG OG DGDP OGLO *R DGs DGSFR DGTL DG7ZR DGz WY OHP 01 D! 01 OIA
Df df df df df
df df d~ dfdel df 1
package
OIR
IIR IXR IIR
deferred
deflatlng
dellvery
machine
df df dt df
m~eh
r
r sk
Uraftlng
defrost
d+ t OFT &f t df t
draf
df tg
df tr
df tsm
dg * * * * Cig
dgdp
dgld dgr *S
generator gyro
)IR COtQ4 IIR COUP IIR FLT )ISASSM )!SASSY )Isc JIscn )ISLVD IISM IISP )ISP )ISP )lSPL >1 SPN 11ST 31ST 31s1
d ~SCt1
dislvd dism disp disp disp dis~l dtspn dist dist dist dtst~ng distn distr distr distr dits dlv dfv dtv
coupler f{~ter
disposition
dtsk
dogged double double
gr~nd
giass (tnsul)
21STING
DISTN DISTR
}
DISTR DISTR DITS DIV OIV Dxv w Ott OK CRC HSE
groove
(lnsu?
double
09s f r dg t dgt 1 dgtzr dgz dhd *d ahp ahu al di U( d{a dia diag diag d t agr
PHTH dial phth d i aph 010 010 diel dtfa dlff
groove double petticoat {Insult .. dtaphra~ gland *grease degwssing Systm degasff~er atgft dtgttal digitizer designated ground zero double heat si~ diode Clrap h8-r die dehumicfffy developed horsewer double hung windows delclng demand indicator dev~atiOn lndlcator defjcfency in q llouame dlamet~r diagonal dt qgrars diagrafwsatfc dfallyl phttwlate item
distribution distr~wtor
televfs~ofl digttal spectrometer diverter dtvtde dlvfslon dr~ll jig dark deck house
DKE
DKPG
OL OL OL m DL :: OL OL
OLA OLC OL IL~
dl
dl
dl
dla
kiAa
010
diaphraq
data
OLINDG
OLL DLO OLO DLOCX OLR OLS OLS DLT OLTM OLVY DLX 0s OLY OLY
direct
dielectric dtfferentfal difference dffferent!al dffferent~sl diffr~CtfO~ dtffust~ dfgftal diagnostic dfhydrate dl lute dilUtiOn dfamtsion
d10
dlo d 10Ck
dlr
dls dls dlt dl tm dlvy dlx dlx dly dly m
dtff
dtff tr dlffr dlffus Ctigtcom dfgn dihy dj 1
set
tim
relay
commmications
dt 1
dim
Ijnk Sinulator line translator data link test messagm de 1 i very de I Uxe dle lock delay dot?y demand meter
99
MIL-srD-12D 29 my 1981
ABBREVIATION
Da
TERM
ABBREVIATION DPDT OPOT SU DPfC DPFT DPG QPH OF I DPL DPLR OPLXR OPM OPNL DPO OPO OPP DPR DPR OPRP DPS DPSK DPST DPST DPST SW OPSTK OPT OPTM dpdt
dpdt SW two pole
TERM double throw double pole double throw Sw I ten pole front connected dotm)e desk . double pedestal
daflat-top i ng pyramtd
m
DNA
a *
dma dmd
dtcsclawcbmlcal
dtscard
direct
message
memory qccess mtcrucfrcuft
digttal DME
ONE
*fc
dp?t *g ~h *t *I
OME
~t dmgz dml dmnrlzr
DMGT DMGz DML DNNRLZR OMPG DNPR DNR DNSTt4 OMTZR DMX m ON DNA ~OFT ONT L DN7 RD
d 1 qmend design margtn evaluation dtstancm measurtng qquipment damage data management demagnet f ze drop llt*nho18 demolttlon oemfneral Izer d~ode microwav~ oscillator
diamond
detectea
pulse
hardness interference
dplr
dplxr DPM *I z g: dpr *W
double propellant loading dopu \er dup I qxer data 13rOCeSSfng m8Chine distribution panel double pulse operatton dripproof open dripproof protected dtazoprlnt double pulse ranging drtpproof qnd rat prOOf drlpproof Semt-enclosed d~fferenttaI phase shfft keying
-f% d8nQer
difmner demonstration demsgnetizwr data wltfptex deIt8 q ~lttude
dOWn
doss
down d{n{ng dental Uenatured do not usUtcsel 011 dissolved OXy~n d$tto draw out oat~ of birth data output chmneI document direct outward dialing dynamic octal load ~stic doppler phase lock date of requmst ~ler ran9s qnd navigation disk-operatsystem doppler veloctty and posit~on dozen da-roofing dash pot (r81ayl data processing deck piercfng deflection plate demand met-r printtng depth descrtpttve pattern dew point dtal pulstng dtamtral pttcn differential pressuro double paper (tnsull double pole drtl? plate not draft
dna
q ~ly
SW
end
dng dntl dntrd dnu do
f t
double pole single throw throw two pole single double pole single throw
SWi tch d+pstick drfpproof totally enclosed desk. double pedestal typewriter data processing unit dry pipe valve data qualfty numttor
do ao
do eoe doc dOC 000 do 1 aom dop I @. dor doran dos
OPV OR OR Oa OR DR OR OR OR OR DR6A DRA ORCDG ORCTY DRCTY ORD ORDCN ORDP DROTO ORE DREC DRET DRGR OR1 ORK DRM ORO ORCl DROS OROT ORPR DRR URRL
DRS ORSG 9asR ORT
*V dr dr dr dr dr dr
dead
reckoning
radar
dtscriminatfon
mR WRAN 00s
00VAP Doz OP w OP
dr
dr
dov aP
doz dP * % m * : z m * : * * * 2 m Sw dpbc dpc
@d
dr draa dra
door drafting request dratn dram drill drf)l rod drive data reduction and q naIysis dead reckontng analyzer
drcdg drcty
drcty drd drdcn dr~ drd dre to
OP DP OP
OP 0? DP DP UP DP DP DP OP
drec
dre t
drgr dr i drk am dro dro dros drot drpr drr drr 1 drs drsg drsr dr t
UP DP OP DP OP Su
DPSC OPC DPO
dripproof
dry battery dual purpose two po!e dOUble pole double pole double pa-r (tnsul)
swttch
back
singlo
cunnected cotton
DPDC DPt?T
@dc
~d
dfgftal double
phase
paper
dffferencs
double cetton throw
double
--
100
MIL-STD-12D 29 my 1981
AIMIRE~IATION
TERM
dead reckoning tracr drlptank diode resistor trans~ster logic dead reckonfng trainer d~iv. unit er t ver d~aSCal@r decannlng scuttle diode swttch discard~ng sabot disconnect switch domestic Seevice double sflk (.insul) dovmspou t draft stop clack surface light data switching qnd data handling data storage qnd retrieval dOUble %i-band
TERA1
diode ~al data transistor logic tone wulttfrequency takeoff timing pulse
ORT
ORTA DRTL
OTL
dt!nf
dto dtp dtpb
dtr dtr d t rbd
ds
ds ds ds ds ds ds ds 0s ds
OTU OTV OTVC OTVN DTY CY OUM OUMR DUNC OUP OUT 0V8D
DVC
It
ds$dh dsllr
dsb dsb I dsc dscaprs dscc d~cont dscrm
dsct
dty
-m *Wdune
Cy
DSAR 0s8 OS8L DSC OSCAPRS DSCC OSCONT DSCRM OSCT OSD DSE DSZNGA OSGN OSHR
OSIF
disable data
dental
synchronizer suction
channel
q pparatus
desiccant
discontinue d~scrimtnator double secondary current transformer dual speed drive data StOragQ WulVnt disengaging destgn dish rtnsing deep space instru-ntatlon facii~ty deep scattering layer diesel desal ter
OVL DVL OVM OVPP I DVR OVST OVT L m Ow K DW Owo Dwo DWEL OWG OWL OWL DWL OWLFEO OWN OUR Dus DWt
distributor definite time relay demand total izfng relay daughtarboard distress detent digital telew=try unit television digital d~gftal transmission and verification converter differential thermocouple voltmeter duty cycle dummy dust qnd moisture ~ underwater measuring dev t ce ~llcate device under test dfesel v-be?t drive
dfrect
voice line vol tmeter digi tal daylight view plan $nd\cator
pOSitiOn
ds gn
dshr
0s1: ds 1
ds 1 dsl tr dSntZ
dvst dvtl du w @u * *
.,dlvar direct
@ovetail
view
storaga
tube
Uesensfttze
desensltizi ng design specification
duel
dug *I *I
display disposal discipline double strokes dispensing data scanntng double single
display storage stop
per
minute
dul du)fbd
dun dbtr dus dut at
ds t dst!
astlt dsu
door
DSU
esu dsu~htr dsv asw dt dt dt dt dt dt df dta dtch atd dt8 alter
distill distillate data syncnrontzer dtsk storage unit unit drum storage desup-rheater
untt
silk door sultch decay time deep tank ctfe tmlate dwb)@ thrw tile drain
dual dust tires ttght
double
varnish
linsul)
therms
Wqulpment
% OY DY DYE OYG OYUR OVN DYN 0Ovw OYNMT E E E ETOE Ebl EBSP EA tAc
water line dominant wavolongth dowe 1 dOUbl@ wall fiberboard drawn drawr drop wood siding deadue i ght pennyue i gh t dup I e% data transmitting eeluipment
draw~ng designed
duty
day dynamic dry i ng braking
dehydrator
dynamt c dynanm dynamotor dynamite
dynamometer east
Smltter enamel qnd to (electron ( !nsul )
devfce)
equ$p
8s Qac
parts cloarancc
qxpected
approach
101
MIL-STD-12D
29 ?tily 1981
ABRREIl
CAROM EAS EM ED AS8
ATION
E AROM eas eax eb qsb eec EBCOIC ebdc ebdp ebds eblc
TERIM
TERM qrror
detectfon qnd correction qnamel double cotton qnamel double cotton vamlsh ( tnsul 1
qlectronically
q ?tcrable
qf)p
ebpa ecas qe qc qc ec ec Sw ec wire eca UC Ecc
read-only mawmry ~fvalent. atr speed q lectronic qut=atic qxchange qbony qsbestos COttOn -a#!o1 bonded Sl~le ({nsul) qxpanded binary-coded decfmal interchange code enamel bonded double cotton [ tnsu!) enme) doublpaper ,bonded ( tnsul ) enamel bonded double silk ( insul ) q lectron b~ardment fnduced co~ctivity enamel stngle paper bonded ) ( tnsul .Iactron besm parametric a~li+ter qnamel oonded sfngle stlk 4 irlsul ) edge connector emergency coordinator ena=l single cotton ( tnsul) ~t~t controller 8CQI1 suttch qxtra control wtre q~lpment condftlon q nalysts eccentric qrror correction code q lectronle counter countermeasures
qdc
edcv 8dd EOOCI
(insul)
Enoo
EDOF EOE
qdd f
ode edf q edge Ulgw
EDFA
EDGE EDGW EOI TAR Em Em EOP EDPE EDR EDS EDSV
engineering data depository q x~anded direct dfstarn q dlal(ng error detect~on qnd decfs~on fee-aek emergency dece}eratlng ~relay) different$a el~ctronic analyzer
electronic qquipment qdgeu I se data gather
tracking
of
objecttve
EDP edpe edr eds data processing electronic data processing equ i pmefi t equivalent direct radiation enamel double silk (Insu? enamel double sllk varnish (insuli electrfcal dfscharge tube
q lectronic
qdsv
edt educ educ educ edynmt eeg e*g qf e+ qf efel qfc efc qf f qf f ef 1 ef 1 qf 1 ef t EFT eg =9 egd EGO
qducation
educator eductor q iectrfc dyna~ter electroexplos~ve
ECCSL Eca
ECDC
emitter-coupled current-steered
devfCe Iogram
Ioglc
q lectroencepha
estlmatcd c~letlon date electrochemical diffused co! ?ector c}ectrocard fogram e?ectrocardi ograph ache 1 on eddy current loss emttter coupled logtc electronic countermeasures electronic countermeasures environment q lectronic countermeasures program q ngineering change notice equipage category numer electron coup)ed oscillator electronic checkout eng{neor{ng change order
EEG
EF EF EF EF61 EFC EFC
effective
efftctency !affect!ve focal length eff)uent equivalent focal length effect electronic funds transfer for example single enamel stngle glass ( lnsul ) electrogasdynami cs eccentric orbit geophysical ot3servatory eye ~ard q lectronic gl!de slope exhaust gas tCWQeratUre ex~t gutde vane end half qxtremely hfgh frequ@ncY effectfve horsepower electrfc horsepower
EGO
EGO EGRD ~GS EGT E GV EHF EHF EHP EHP EHV Euu EI El EI EIhT
econani ze economizer
engineering change proposal eng!neerfng change request engineering cnange re~est/ authorization Emergency Coolant System enamel stngle cotton vsrnlsh [ {nsul J edge distance edltfon engine drive envelope drawfng qrror detecting q ngineering department sketch electronic dtg~tal qnalyzer
q grd
egs eg t egv en f eh f ehp ehp qhv ehu qt ql qi efbt
ECV ED
ED ED
ED ED ED SK
CGA
ed ad qd ad ed ad Sk
eda
extra
extre?m
hfgh
high
Voltage water
tnterface {nstallatfon tnstallat~on
102
IUL-STD-L2D 29 My 1981
.4 RRREVIATION TERM e+tpment Code emergency tdenttflcat
Identiflcatfon
ABBREVIATION ion
EM&R EMF EMI EM:NT GNP EMP WPL WPs EMG mar emf
TERiNl emergency
q lectromotive force
fc fnter?ermce intelligence pulse
EIC Exo LT
q ic q td It
emi
qlectromagnet
qlectromagnetic
1 fght electronic Jansning qj Ed sjector qjctr EUCTR qj8ct\on @jn EJN qjection s-at EUN ST qjn st singlo qnamel single ek EK cellophane (~nsul) qach layar el CL elastlc ltmit e] EL e)ectrolumtnescent el EL q levat~on el EL eye lens el EL stngle enamel single el EL acetate (\nsul) elastic elas ELAS 81asticity q Ias ELAS q 1bow EL8 elb electrical contact e)ctc ELCTC electrical contact elctcbr CLCTC8R electrode ELC7D q lctd electrolyte elctlt ELCTLT qlectrolytic elctlt ELCTLT electrical contact qlctrg ELCTRG q lectron elctrn ELCTRN electrtc ELEC elec q lec q lectr~cal ELEC q lectc q lectronic control ELECTC SEE BELOW SEE SELOW electrochemtstrv . electronic ELEK e)ek element elem ELEM q limentary elem ELEM
emtnt eq
qnp
eupl enps emr
EMU
EMS EMT ENTR
ems
emsn emt emtr qw eum ellml en enam -1 encap encd encdr qnc 1 qnc 1
EMJ
E!W EWL EN ENAN ENOL
ElWA?
bwsh ENCD ENCDR HJCL ENCL ENCSD ENG ENG ENG RM ENGA ENGA ENGR ENGRG E-V Em ENGY ENLG ENLGO ENRGZ ENSI EMT ENTC ENTR ENTR ENUN EW EWIR ENVIR EO EO Eo EOA
rfng
qncsd eng
E-
qng rm qnga
enga
qngr qngrg
engr-v engv engy enlg q nlgd Wflrgz ens I ant
.ELEV ELEv
ELEX
elev
elev elex elf elf 81fc e 1hyd e?lig el tm el int elmcfl qlng elong elp elpc elph e 1pneu ELS qs 1ec q lsse elv q lw em em qm em em
elevate q levator
electrentcs explostve
electromagnetic e~ennage amp 1Oyee Supp I y emwgency power qstet qlectromagnetic electromagnetic radfatlon electromagnet lc surve{l lance emtssion electrical wmtalllc tubfng emi tter electrofnagnetfc units e-l ator ewulsion qngtneertng notice enamel enab 1e encapsulate encode encoder enc I ose enclosure qncasmd qng t ne English qngine room engage engag \ ng qngineer q ngineering engrave q ngtne v-belt energy ., enl qrge en] q rged energ t ze ecp~valent noise sideband Iqsut equtvalent noise te~erature qngine negative torque control enter entrance enumeration enve I ope qnvirenmen t qnvtronmen tal qngine ofl englneer?ng order qthylene ox?8e qnd of address electronic order of battle edge of cutter q lements of data qxplosfve ordnance disposal end of line block electro-optical light modlJlator end of mssage qnd of message sequence end of part qng!ne order end of tape end of transm~ssion
ELF ELF ELFC ELHYD ELIG fLIM ELIN7 ELMCH ELNC ELONG ELP ELPC ELPH ELPNEU ELS ELSEC ELSSE ELV ELW EM
EM EM EM EM EMA EM8 ENC EMO . ..*
qctuated
ltght
fflter
extremely low frequency q lectro)uminesccnt ferraelectric cell electrohydraul ic eltgttiie el tm~nate electronic lntefllgence electrofmchanieal elongate elongation q lliptical e!ectrolumtnescent photoconductive qlliptical head electrouneumat~c qarth landing system electronic securfty electronic stty screen qquipment qlectrically operated extreme low wat=r
qntc
entr entr env env t r env t P eo qo eo eoa eoc
qod
eolb eolm
electromagnetic
ang~neertng enlisted epftaxial memorandum men mesa
eom
eoms eop eor eo t eo t
ema
qmb
emc emd . .
q q
expam metal q lectron~c missile q c~isition ehoss qlectromagnetic co~atibflfty electric motor ertven
tape pulse
pane) polarized
.**e*
*m**.
.**.**
ELECTROCHEM
electrochem
electrochemistry
103
MIL-STD-12D
TERM EP EP EP EP EPao
EPSX EPO
ABBREVIATION ESP ESPAR ESPEC ESR ESR ESS ESS ESSU EST EST ESTS ESTD ESTN ESU ESV Esv El El ET ETA
ETAS
TERM
especially qlectronically steerablo phased qrray radar q lectrical specification q lectron sptn resonance equivalent series resistance q lectronic switching system emergency sn~p servtce selective q lectronic suitching unit electrostatic storage tube estimate establ lsh electronic standard endstone electrostatic units earth satellite vehicle enamel single silk varnlsn i insul ) edge thickness qlapsed time q lectrical tfme qsttmated ttme of qrrival q ffectfve true qtrspeed et cetera 81apSed ttHw code generator etching estimated tfma of departure qxtrusion trim qnd drill te~l ate elapsed time indicator qstimated time of r=turn endless tangent screw electrical time superquick qxtrusion trim tenplate qdurational televlsten q lectrostatic transistorized voltmeter emergency unsatisfactory report extreme ultraviolet extra vehicle activ!ty evacuate evacuator evaluate .vsporate evaporator qvaluation q lectronic voltmeter electronic voltotwmmter qver 1ock energy variant sequential detectton qach way q lectronic warfare electromagnetic wave awl by stimulated emission of radiation embedded wtrtng board
qp
* * w 9p& d EPSX epd apt apt epl epo -P epr ep r eprom ups ept
EPI
EPI EPL EPO CPP tPR
EPR EPROM
EPS
EPT
qpu
epw r ---eq ----
eql
eq 1 eq I eql sp eqp t equil equlv er er ar
ERS ERS ES Es Es ES Es EsA EsAR ESC Esc ESCi. EsF ESG ESG ESHP ESK ESNTL ESP
Ors em es es es es es ESA esar esc qsc qscl qsf qsg 8sg qshp qsk esnt I esp
~tneerfng practtce epitaxla) p)anar explosion proof 8xtreme pressure SIoctr)c power qnd d~strlbutton e)ectrontc private branch exchange 81ectric power distr~but~on q lectronic posttion {ndtcator qxpsnded postt{on Indfcator electroplate engtne propeller order emergency power package q lectron paramagnettc rosonmco qxhaust pressure ratio qrasable programabl~ read-only memory electrtc power Supply 8xternal pipe thread e!ectrtc power unit emergency power unft emergency power e~al (altn qbbr) equation equally spaced (altn abbr) equa 1 -a 1 i zofe~ally equally spaced ~ipmnt equflibrfum ~fvalent echo ranging q lectrfcal resistance reconnaissance. q lectronic emerge~y room axtended range ballistic mtsst Ie erect i ng erect or qrect ion engineering release nottce q$fectiv~ radfated power engineering release record errer error correction expendabill ty, recoverabil fty, reparability cost qrased expanded radar service echo Soundtng q iectron?c swftcntng q lectrostatic enameI Sfngle sflk (fnsul)
qsp qspar
espec esr esr 8ss ESS essu es t qst estb estd qstn qsu qsv esv et
qt
et
q ta
etas
ETC ETCG ETCH ETD E70T ET! ETR ETS ETSO ET7 ETV ETVN EUR EUV EVA CVAC EVAC EVAL EVAP EVAP EVLTN EVM EVOM EVRLK
EVSO
etc ETCG
q tch q td
etdt eti q tc ets etsq q tt q tv 8tvm eur guv
evl tn 8vm
ev om evrltc uv sd ew EW ewaser
EU EM EUASER
equal
sectfon
engineering support q ctivity electronically steerable array radar qscaPe escutcheon escalator q lectrostatic focustng qlectrically suspended gyro qxpanded sweep generator =quivalent shaft horsepower engtnecring sketch essential electron stream potenttal
EM@ EMC EWO EWR EX EX EXAM EXC Exc Exc Exc EXCH CXCL EXCL
ewc Wo
c!ectrtc
water
cooler
ewr qx
ex exam qxc qxc qxc qxc exch qxcl exe]
engfneertng qarly uarntng exawle qx tra examination excavate qxcellent qxcep t qxcttat~on qxchange exclude exclusive
104
ABBREVIATION
Excsv
TER,M
qxcwssfve qxciter
execute qxecut i ve qxercfse qxhaus t qxhfbf t exhaust vent qxpansion qxpense qxperiment qx~rtmental qxposed qxpress 8xpulston qxpanston joint qxpedt tc qxpendable cxplanat~on
ABBREVIATION FAC
FACI fACIL F ACT F AC? FAGC FAI FAl FAIR rm FAO FAR FAR FAR FAS FAST FASTAR FAT FATOL
TERM
forward
atr controller first artfcl~ conff~ratfon inspection facility factual co~tler fully qutomatfc c~ller translator fast qutomatfc ga~n contrel frequency qzfwth intensity fresh q tr Inlet fafring
qxcsv qxctr
?qc
FACI facfl fact
8xec
qxec exer exh exh qxllv 8X$ ,Xp qxp qxp exp qxp 8xp qxp jt qxpea expcn exp ) expld exp I n expnd expnt qxpnt expo qxpsr qxst qxt ex t ex t ex t qx t extol qxtg extm extnd ---extr qx tradop extrn eylt eypc f f f f f f f ftof f68 fab fadf faf fta
EXPLD
EXPLN cxPfuo EXPNT EXPNT EXPO EXPSR EXST EXT EXT EXT EXT EXT exTo CXTG EXTM EXTNO ~XTR EXTR EX7RADOP EXTRN EYLT EYPC F F f F r ;
qxp Ioda
exploston qxpenditure qxponent qxponential expert~tal
f~rst forward radar fueling fast qutomatic shuttle transfer fr=quency qngIo scanning, tracktng and ranging f~ee q ir temperature frequency qnd t~dlvtston link
qlarm q larm
order
FATR F AV FAX FE FB F5CK FBoc FBDS F8M FBM f8M FeoE FBR FBR FBR80 FURS FBT F8T FC % FC FC FCA FC8 FCC FCG FCG FCI fco FCR FCR FCRLS fcs FCSG fCSLE FCST FCT FCTN
ftxed
quto
transformer
corrugated
fiberboard
board fleet ?oot
(altn range
abbrl doppler
ratio
f qc f 2C
metalllc qrmor (insul) Flint f orem fr~ency (cob form) intorcoptor (aircraft) face to faca fore qnd qft fire qnd bflge fuel qnd defustllng ffre qnd flushing fuel q ir ratio faco or field of drawing flat pattern ftrlistl one Stfinish two sides fteld qrtillery ftnal qss~ly forced atr fr~e aperturo fabrtcate first q id box fire 818MI bell f)ush qrmor balance uatertlght hatch fire q larm box factor ffold qccelerator
ftre #tat-band
ftre
clay
f Ca
f cb f cc fcg
fire control front connected functional eenfiguratfon qud i t free cutting brass face centered cubic
gauge
fcst
fct
fctn
fcty fd
FCTY FD fD Fe Fo
fd fd
fd
functional configuration identification cleanout flush with f$nished floor fire control radar 4use eur~mnt rating Flight Control Reacly system Fire Control System fomsing forecastle forecast ftlament center taP function factory feed flange focal dtstance floor dratn forced draft
Ltght
105
XIL-STD-12D 29 my 1981
ABBREVIATION
PO
ABBREVIATION
FGN FGR FGY FH FH FH FHC FHP FHP FHR FHT FHY FI FIC fgn f gr f gy ---fh fh fhc fhp fhp f hr fnt f hy f{ ftc
fd *d
Fo
m
FDAI
$d
fd
fdat
fdb fm
flat fire
full
head hose
(altn
abbr)
I\nk
fluid
fractional
flow
doppler gate wultiplex
field
dtscharge
FIFO FIG
fdpl fdr
dr f dr f dr f dr
f
Cabfnet horsepower frlctlon horsepower ffre hose rack fully heat treated fire hydrant fi-ld intensity frequency interference control first-!n-ffrst-out f i gure Federal Item Identfflcatton
fractional Federal Item Identlftcatton Guide Federal Item Identff{catton Nuwber f I lamnt fillet ftlltster fuel injection ltne flllister head filling full tndicator mmmmmnt used fn ANSI Y14.S) ftntsh (altn abbr) ftnanctal fuel injection punp fired fuel tndlcator readfng full tndicator readtng floattng-point instruction set f Ork forked ftlter (cform) flashlng flat flood (vent) floor floor line
fire
hard hose
FIIG FIIN
fil
fll ftl fil fllrl ftll ffm ---fin
f ceder
+tndar
fire
fltght
door
data
FDTT FDW FOWL ~DX FE8 FEB FECP FED FEZ FELR FELR FEM FER FER CON FESE FC7 FEXT
?F F? F* FF FF FF FF
fr~oncy f Oundry
food
full
recorder dfvcrsfty
teletype double
radar
sewlce
FIN
wal? FIN FIN FIP FIR FIR FIR FIS
(as
ftp
electronic
formal
eng{neerfng
block change
flr
flr flr fls ftc fkd f? fl fl fl fl fl t! fl fl
proposa Federal
flrfng
fe81er feeler
I
indicator
error
con
fese
FET fext ff *f ff ff ff ff ff ffar ffe ffd
room
secondary transistor
FK FKD FL FL FL FL FL
FL FL FL FL FL FL FL FL/W FLA FLO FLD FLOG FLDK FLDNG FLDO FLDT FLEA FLEX FLEX FLF FLFT FLG F LG fLGSTF FIGSTN FLU FLH
fire
qxttngufsher
flow
flutd f 1ush flute lead focal length footlawbert flash weldfng full-loact qnperes fatrlead fle?d fold!ng flight deck flooding final limit down floodlight flux logic element array flexible f 1exure ffnal Iimlt forward full load fram ttme
FFAR FFC FFD FFEC FFl FFILH FFL FFI. FFL FFL FfP FFRR FFT PC FG FGD ?G#3
ffec
ffi ffilh ffl ff? ffl ffl ffp ffrr FF7 fg fg f gd
fgd
fa~lure factor ~~ie finish ffre ftghting fltp flop fotlowtng force feed full fteld folding ftn afrcraft rocket fltp flop co~l~ntary field forcing (decreasing] ffeld frms qmission current ffeld forctng (trtcreastng) flat fill tster haad female f18red tteld failure flfp flup latch front focal length firm fixed prfce full fre~ency range recording fast FourlQr transform filament ground frog fine grain data f org8d
fl
fl fl fl/w fla fld fld fldg fla f 1dng
fldo
fldt flea flex flex flf
fIqnge
flooring flagstaff flagstone final Ilmtt flat head
hoist
. .
MIL-STD-12D 29 my 1981
ABBREVIATION
P Lnls FLSDEN FLIR FLKO FLL FLL FLLD FLM FLM RES flhls flieen flir flkd fll fll flld f lm flm res flm rtd f!we f lnywf f 1mprs f lmsd f)mt flmtt fln
TERiM
flashtcss fllght data qntry forwsrd Iodk{ng lnfrafluked final Ilmit Iouer flow line full load flalm flame ruslstant flame retardant flananable flameproof film processing fllnl sound f 1ushmount flametight flatten fuel line fuel tng floating coummtator ffre locat!on radar flotation f 1 qpper
ABBREVIATION FMR
FUR FMS FMS FMT FMT FN FN FNN FNI FNO FNPT FNSH FNSII FO Fo
TERM
frequency modulated radar frequency modulated receiver floating machine shop free machintng steel flush wmtal threshold frequency modulated
fmr
ffms f ms fmt fmt fn fn f nh fnt f no fnpt f nsh fnsh fo
transmitter
f!nd ~er flat nose (project~le) flashless nonhygroscopfc fan ~n fan out fusion point finish finish specification (no numer ) fast operate (relay) flat oval foldout fuel 0{1 forced oil qnd afr free on board front of board focal f Ocus full operational capablltty fog foam follow foam liquid fuel oil pump forging formation fomla forwla translation fog oil smoke generator frequency of optiwm operation fuel 011 tank fuel oil trsnsfer for official use only f)ush o$ltight ventilation hole foyer faceplate feedback positive field protective fireplace flat po~nt fore peak forward perpendicular freezing potmt fungus proof faded pr!or to lnterCept fluorescent penetrant inspection forward propagation Ionospheric scatter ftre plug frequency phase lock foot (feet) per mtnutc feedback potentiometer flshpaper flrepruof focus projection qnd scanning foot (feet] per second foot pound second (System) female pipe thread forward propagation tropospheric scatter failure rat. fast release (relay!
SPEC
spec
fln flng
f 1 Ocom f 1 ora flot flpr flr flr flr flrd flrg flrt flry flsp flsw flt flt flt flt flt pln f)td fltg fltl fltp f)tr flu f 1Uor f lUSOC f IUsoctl flut flu
fo
fo
F13
FO
fo
f oa fob
FOA F08
FOB FOC Foc FOC FOFM
FOL FOLQ FOP
fob foc
f Oc f Oc
revarse
fefwl
fel folq fop forg
fluk flwp
flyuhl flyut fm fm
fm fm
fm fm fm f man
f new
fmfb fmfm fml fml fmop f-
flarlng flow rate f 1urry fltght space flw Swttch f8ult flashlight flight . float flfght plan fluted floating flightltne flush type filtar final llm~t up fluorescent fluted socket fluted sock~t head f lutter flat washer flat work follou up flyuheei flyweight fan markmr fathom fteld manual f~re main frequency modulation frequency aultfplex tltan$um tetrachlortde f oremn frequency modu?atcd continuous wave frequency modulation f eem?ack
FORff FORM FORM FORTRAN FOSGEN F07 FOT FOT FOLIO Fovu FOY FP FP FP FP FP FP FP FP FP FP I f? I FPIS FPL FPL
FPM
form form
FORTRINM fosgen
FPUT fPPR
FPRF
frequency
modulation
Formel
(Inwll
modulation smdulatton on phase
FR
fr fr
107
Plfi-sTD-12D 29 my 1981
TERM
$R FR FR FR PR BEL FR FY FRAC FRAG
ALfBKEViAll(.)IN F SW FSW
fr fr
fr fr
fr be? fr fy f rac f rag FRAUO fraud FREEEO f reebd FREQ f req FREQ CNG freq chg conv FREQ CONV freq freq FREQ INO tnd FREQM f reqm f res FRES f rhgt FRHGT frict FRICT f rm FRM f rmr FRMU FRNG f rng frt FRT frtn FRTN
f~eld revers{ng frame from f ren t from below fr~nch fry fractional fra~tatien
f Sw
f Sw
ft ft ft ft ft ft
word
FT
FT F1 FT FT FT LB FT&TW FTC FTD FTD FTF FTFGS FTG FTG FTHRO FT1 FTK FTM
FTN
flush
threshold
lb
foot (feet) frequency tracker fume tight functional test foot pound force
f t6tw
desk. qnd
cO*inat!on
typewriter time constant
flat-top
chmger
convorter
ftc f te f td ftf
ftfgs f tg ftg f thrd fti f tk f tm f tn
frequency fndicatw frequency meter fire reststant free height frtctlon fire room former fringe fretght front end t r qrework freeze freezer far side Federal Speclffcatton feedback stabtllzed female soldeved
fast fitted frequency translation distortion flared tube fitttng flared tube fftttng gasket sea 1 fitt!ng footing female thread frequency tiindicator
fwl
tank
field
service
fin stabilized ffnish specification ( numr ) fire station ftrtng set fere~gn s~rvfce foresight freight supply (vessel) frequency sh{ft full size functional sehematfc
f tp
ftF ftr ftr
ftr ftt
fu fubx fuhlr
flextble theatre missile fortification fuel transfer puw feather ftxed transom flat tile roof functional test requirement flat trim t-late fuse fuse box
fuj
ful f Und furll fur f Ur furn f urn ---fuslg fut fv fv fv fv f vd fvr fw fw
jaw
(altn
abbr)
fuselage station sulfur trfexide ChlOrSUlfOniC qcid feasible fusible fusible Cutout Federal Supply Class full scale fre~ency space eharaeteristie t~edance Catalog Federal Supply
Identification List Federa) Supp)y Code for Manufacturers f)ying spot digftlzer forecast support date fle]d support qquipment shift keying frequency fleId strength meter ffeld service modification work order Federal stock Wmmer fuel servfca nozzle fremency standard prtmary ffeld strength radfo frequency scan radar fission forged stw} frequency shfft transmission fastener
flux front
full
fire
wall
fresh water full wave forward fresh water drain collecting tank field weakening
FSK FSM F sMWQ ?SN FsN FSP FSR FsR FS$N F$T PST ?STNR
feed
water
puwq
fwr f xd
f Xp fxtr fy fytg ?Z fzsto ----
F%? FXTR fY
fresh water puq faitwater planes full wave recttfier fixed ffxed point f i xture
ftscal year
for fuze frozen green your information
FYIQ Fz FZSTO o
qnd
guldantw
storage Ialtn qbbr)
fst fst
fstnr
108
MIL-STD-lU) 29 my 1981
ABFIRE\l
G G G
ATION
G 9 9 9 : 9 9
grtd ga e gh n
ABBREVIATION
GEF GEN gef gen gefl gen ge~ gee 1 =9
TER,M
fa lure generation generator general contractor gasoltne engtne genera I geolog~cal geomagnetfsm ground effect take off and 1 andt ng gas ftlled govern~nt furntshed q ircraft equipment gap ftller. data government furnished equ t preen t government furnfshed qqutment llst granoltthlc ffnfsh floor gap ftller tnput ground-fault interrupter generator field government furnished materfal gap ffller output government furntshed parts governwwnt furntshee property government furnfshed property qnd servtces gap ffllar radar glazed facing unit ground glass Greenwtcti hour qngle gray fron Governnwtnt-Industry Data Exchange Program garbage in, garbage out green tndfcatfng lam Generalized Information Retr~eval qnd Llsttng
ground
equtpment
GEN
G
G G G G G G4kC GAN G-A G-G GA GA GA GA
GEN CONT
GENG GENL GEOL
cent
GEOMAG GETOL GF GFAE GFO GF E G?EL GFF GF I GF I GFLO GFM GFO GFP GFP GFP$S GFR GFU GGL Cl GIOEP GIGO
GIL GIHLS
gf GF AE
GABD GADL GAG GAI GAL GALL GALV GALV GALVI G4LVN0 GALVNN GALVS GALY GAM GAPL GAR GAR GAR80 GAS GAS /W GAT GAT GAT GATR GetG Gc GCA GCC GCD GCD GCI GCL GCMPS GCN GCR GCRG GCT GO GO GO GO GOE GDE
GDE GOLK GONC GDOP GOR GE GECC
gauge board grwnd to air data It?!& ground to q ~r to ground indicator gate qlarm
ga 11 ons ga 1 I ery gslvantc galvanize galvanized iron galvamnealed galvanometers galvanized steel galley guided q ircraft mlS311e group qss~ly parts ltst garag8 gutded q {reraft rocket garboard gaso I ine avfatton transponder Greenwtch qpparent ti~ ground to air transmitter ground to q tr transmitter race fver
galvs galy
gam gap 1 gal-
gar garbd gas 9as/w ga t GA? ga t gatr *9 ~A Gcc gcd gcd GC: gc 1 gems gcfl :Fg GC7 gd * gci * gde
gde gde gdlk
GIOEP
gtgo gf I GIRLS
weld general
gas
system
GIT GJ GL GL % GLB GLD GLE GLX GLUSS GLPG GLS GLT GLTN GLV GLWB GLYCN GLZ GM GN GN GM GN GMAT GMBL git 9J gl gl gl gl graph isomorphtsm grown junction glass grade ltne green light gun laying glass block gold government loaned tester
garbage guidance
ground ground
approach center
gain centroi drtver greatest comon divisor ground controlled interception landing ground control gyroco~ass gag- code number radar grOUnd controlled
~n carriage Greenuich ctvfl t(me graphic demand meter ground detector grown dtffused guard ground data @Wi~nt guide gut am grid leak gu 1 dance geometr~c dflutfon of prec{slon guard rail gas qjectfon gasoltne engine. close
ewipment
g] fder
glossary gtouplug glide slope gu{de light guillotine globe valve glazed wallboard glycerine glaze
gaseous
geometric
mfxture
m?an
gdnc gdop
gdr
ge gecc gad
coup 1ad
GEO
gasolfne engfne driven
109
A8BREt1 ATIUN
ma GNLOG GM* greet gml gmleg G gmtry 9 P *
TERM
gun metal guided missile
launcher
ABBREVIATION
GRSHfT GRTG GRTN GRTR GRv GRVA GRVO GRVG grshf grtg grtn g~tr grv grva grvd grvg grvr grwt g% gsap gse gsbr t .
7ERM
gearshaft gratfng grid return grater gruove 9raphic var~ter groovca grooving groover gross weight ground speed gun sight qiming pOint gypsum s~athi~ board gravel-surface bu{ld-up ground speed drift angle ground support qqui~nt glazed structural facing
GNr
WTRY
m GNu
Q4LTD GWz
GtJP
garnish mo!dfng ground mamtng radar Greenwich mean time geometry guaranteed mtniaum value general not~ ground granulated grease nozzle gas nonverslstmt gated off controlled Pecttft@r ~vernment owned qquipment ground operation Squlpmnt gas operated
GRVR URWT Gs GSAP GSS GSBR GSDA GSE GSFU GSIL GSKT GSR Gss GST Gsu GSU8 GSV Gsv GSWR Gt GT GT GT GTC GTC GTL GTO GTR GTRS GTV GUAR Gus WT GVA GVL GVU ewe GUT GwTa GY OYM GYP GYRO Gz Gz GZ7 i+ H H H
roof
gsda GSE
gsfu Gsil gsk t gs r GSS G$T gsu gsub gsv gsv gswr gt gt
support
(relay)
q~ltfier qutomatic
Cefllng
equipmnt
requirements
gasproof gallons graphtte ground gallons ga~lons per hour
receiver Ganma Scintillation System Greenwich stdereal time glazed structural units glazed structural unit base globe stop valve ~ided space vehicle galvanized steel wire rope gastight grease trap gross ton ground transmtt gain time control gas tu-tne compressor government test laboratory gate turnoff garter
gas
gate
GPW
GPS GPW GR Ga GR GR GR GR GR GR he GR LP
GR& GR &a mm GRAM GRe GRBX GRc GRD GRDL GRom Cuf GRG GRK GRL = GRP ms
resistor
Ip
gra grad
gran gran grb grbx grc grd grdl grdtn 9P f 9-9 grit gr I grn groin grph grs
graPhic k!lovolt a~ere meter grave ! gross veh~c)e weight gypsum wallboard t!le glazed wall glazed wall t$le base gray (altn qt3Dr)
gymnastum
gypsum gyroscoPe
ground
righting Creenwlch
zero
qrm zone tim
gearcase grind
grtudle graduation group repetition gear ~ng gear rack grflle green gr~t glass reinforced graPh i C grease
H H
frequency
H GALV
Iiloti *C H&o H8G HA HA H&
h h h h h galv
htoh hbc had hbg ha ha ha
hardened
and dtspersed
p~asttc
-110
MIL-STO-12D 29 by 1981
ABBREVIATION
i4A0 had heat
ABBREVIATION HOST How HoWc HDwo Iiox HE HQ HE HEAA HEAF HEAP HEAT rtEec UESDC HEBOP HE80S HEBP MEDS HEC MECV HEOC HEDCV HEDS HEOS HEDSV
HE f HEG HE I HEXT hebs hec hecv hedc hedcv beds beds hebds MS t
7TR M
headset
hardware hardware cloth
HAF HALO
HAP
ha f halo
HAP
HAPOAR
napdar
tu!x
he
barn HARhl HARM LTHR barn Harp HARP harp HARP hasp HASP
t4ATCDS ha teds
he he
heaa heaf heap
high
Halpern qnti-radar point relay point high q ltltude sOUtiing high q ltttude
projectile high-altitude
contour
HATRAC HAV
hatrac
hav haz hb hb hb hb men ~w he he he he he he! hc he hcg *I hcl hen hconn hcp hcp hcs hcsht
HAZ W
H8 HE He HSCN
HSPMP Hc Hc Hc Hc Hc Hc NC u Hc HCG HCI HCL
handover receiver haversine hazardous half breadth heavy barrel (rifle) homtng beacon
heat
hebc
hebdc
h{gh qntiaircraft heavy end avtatfon fuel high qxplosfve armor ptercing high explosfve qntftank heavy enaml banded Sfngle
(Insul)
double
cotton ( insul I heavy ena~l double paper bonded t insul I heavy enamal bonded dOUble silk (instJl ) heavy qnamel single paper bonded ( insul ) heavy qns-l bonded single silk (insul) heavy qnamel stngle cotton {insul ) heavy qnamel single cotton varnish (fnsul ) heavy enamel double COttOn I Insul ) heavy enamel double COttOn varnish [ Insul ) heavy enamel double sflk ( insul) high exploslve d~scard~ng safaot heavy enamel double silk varnish ( insul ) htgh wnwrgy fuel heavy qnamel single glass (insul ) high expiosive incwwilary high exp)oslve Incendiary with tracer heavy qnamel single cellophane ( inSUl ) hybrid electromagnetic wave high qxplostv8 plasttc high qxplosive rocket qssisted high qxplosfve ramjct heavy qns-l stngle silk [ insul ) high qxplosive spotting HEAF emergency servtce tanks heavy enamel single stlk varnish (Insul ) heterodyne high qxploslve utth tracer hexagon hexagonal head hexagonal socket hexagonal socket head htgn frequency holdlng ftxture hand form block high frequency cUrrent hydro form dte high frequency dtrectton
hedsv
hef heg he!
hett hek
hhers herj hes has hes t hesv M?t het hex hex hd hex Soc -X soch hf hf hfb hfcur hfd
Hcu Ho Ho Ho HD Ho Ho
HO HD m CR HO ORN HODK
HEK HEMU HEP HERA MERd MES HEs i+EsT MESV ttt7 HET lux HEX Ho Soc -x
HEx SOCH w w we HFCUR Hfn HfOf
hard harmonfc distortion head head dtametor headed hwvy Cmty hard chromium
hard drawn handbook
HOCP
HOEP HOG WI
hand { cap
densfty packaging headt ng
htgh
electronic
hdg
hd $ bd I hdlg MIs
ttorfzontal
handle handlfng headIess harden hardness hardovcr horizontal header handshake
dtspIay
Indlcstor
HOL HO!-G
HOLS
Mn Mns
How hdov
HDP HOS*
data
processing
hdr hdsilk
hfdf
(cofput8rsl
ftnder
111
ABBREVIATION
HFMF HF9 hfmf hfo hfr flfs hf x hgbn hgc hgps hgr hgsu hg t hh hh hhd ht f{ ht hum hiac t?t~ htnt htpar hipot hlpott hfpri hir hirac hj hj hkp RI hl h.1 hl hl hlbr hlbrd hlcl hlcps hlcptr hldg hldn hldr hlext hlfm hlg HL L hing hlp hlsd hltl hlttl hlxa Iwl hm hmc hmd hmdf hq hmnc hmr hnd hnd hmd hndr hnds hndw hnfbr hng hng hone-finish mono-l ithic f 1oor high frequency oscillator hetgtit finder radar hyperftne structure hfgh fre?sncy transceiver herr \ ngbone hyperbolic clean high grade plow steel hanger horn gap switch hefght handho I d handho 1q
ABRREWATION
WIL
HNTG W4YCNB Hoe Hoe HNIL
hntg hnycb hob hoe hogen boj hol hon ---her t z hosp how w w m w m hp hr hpa :: hpf hpfl hplr hpot hpr hps $: m E hr hr hr hr hrf hr 1 hrlr hr I hrpo hrs
TER ,%4
hfgh-noise-lfrTNnity hunt~ng logic
honeycowb height of
hom!ng height
Hoc
imGtN
HIMP
HINT
HIPAR HIPoT HIPOTT HIPRI HIR MIRAC HbJ tlu mP HL HL HL HL Fit i+LBR HLURO HLCL HLCPs HLCPTR HLOG HLDN HLDR HLEXT HLFM HLG HL L
HLNG HLP HL$O HLTL i4LTTL HLXA NM w *D HMo HMOF HMG Hwc I-MR HNo COW WO GEN Wo R$T W40RL WOST
burst on offset beacon overlap coverage hold off generator home on jawwnlng hol low horn i ng honorary horizon Ialtn qbbr) horizontal hospi tal howitzer htgh paSS high pressure horizontal polarization horsepower hOt press horsepower hour high power a~llfier hinged plottfng board hard po~nt defense hlghe$t Possible fW@enCY h!ghpass filter h~nge ptllar hel {potentiometer hopper high pressure St@afW high po~nt htgh pressure test hea~arters handling room height range hook rail hose rack hot roll~d hOUr height range finder hetght range fndlcator high resolution infrared horizontal reference line hot rolled pickled and oil hot rolled steel high resolution tracker hypersonic research vehtcle hor t zon hardness surveillance high speed hing~d seat horizon sensor horizontal shear h~gh speed bombing radar ha-tlcally swaled container horizon scanner high speed data hotsfae house hous { ng househoid horizontal situation indicator high speed memory high speed printer high speed paper tape reader
heltcal Wltcal
co~ressfon
I+40UL W4F8R
helicopter ho)d{~ ho 1ddown ho? der helical qxtanston hat fmuon hot leg htgh-level language (c~ters 1 headlining helper heel sanding h~gh level transistor htgh 10VOl transistor transistor logic heltx q ng!o hardness maintenance hollow metal motor carriage howitzer Wmid hum{df ty hollow metal door and kavy mach$ne gun harmonic hm!sner hand control hand generator hand reset hand rail handset hand wneel horn fiber hangfng h ?nge
hr t hrv
hrzn hs hs hs hs hs hsbr hsc hsc hsd hsd hs q hsg hshld
logic
frame
i+s I
HSM
HSP HSPTR HSR Hs s H$T HS TM
hs I hsm hsp
hsptr hsr hs S hs t hsth
high high
hoist hose
speed speed
thread
reader steel
MIL-STD-12D 29 by 1981
ABRRE\l
ATION hs zd
TERiM
hermetically sealed diode half tone heat heavy thermoplastic htgh tenston zener
AI3IIREV1ATIOIU
HY9APT ttYoN WOR HYORELC HYDRST
hyaapt
hydm hydr hydre
km NT MT ffT m Ht w W UT
RES
TR
ht ht llt ht ht ht ht ht res ht tr hta htct htd Rtf htg HT L htm htm htns 1 htr htrk hts hts hts
htshld htsk htv hv hv
(insul)
1c
analog
q-
hydrst
hydtd hyp hyperb
hollow
ttlo
horizontal tabulation hot tln heat r-si%t{w heat treat haavfer than q ir htgh tenstle cast iron hea taa height ftndi~ heating high-threstild Iogtc hard tub. modulator
ktYoto HYP
HYPERB HYPH
hydrostatic hydrated
hypotenuse hyperbola hydrophore hypothetical
horizontal
hor{zomtal interlocked ( fnsul
tnpulse
reaction metallic
qrmor
tt{gh
high heater half hefght high h{gh httat heat
tefqserature
tenSile track telllng tensile tensfle $hteld si~
inlet
Ibs
ibt
hv 8P hv qp w qpas
hvar hvc hvch hvdc hvdf
hypersonic test ventcle high veloclty voltage htgh hfgh veloc~ty qrmor p~ercing
hypervel-fty armor plerc~ng hyperveloctty armor pfercf~ d~scardf~ SabOt high velocity q ircraft rocket hardemd voice ctrcuit haraened voice channel high voltage dfrect Curreht high htgh and very frequency dtrectton ftndtng high voltage power supply hfgh vo!tage regulator hover i ng hortzental volute spring
{/f I/m
f/0 i /ob t/oe 1 /or ; :Cs 1 qd taf tq ge {ai f 8s t qs
I/OR
IA 1 acs
head ~nterchangeabil[ty qnd substitution Identification and traceabtllty image to frame ratio Ins!de of metal fnput output fnput-output buffer Input-output element {nPut-output register lntttal qppearance International Annealed Copper Standard fnltfstfon area
discriminator
Inft!al qpproach fix instantaneous automatic gain centrol tnformattonal q cquts~tlon qnd tnterpretatton imwdtate qccess storage Indtcated q ir spead tnd~catect air t~erature instantaneous qutomatic volu~ control tn accordance with incendiary bo~ inner bottom fnStfUCtlOn bOOk
Iat t qvc i qw
target target
IAU 1% IB
sabot
tb
fb ib : bi bcn Ibe ibid ibp
w w w w
hu h hw hw k WC
target dtscaratng
mounted
beacon
(for
IllE
IDID 18P IBRL Ic IC Ic !: IC Ic Ic IC & FCD IC ORUM
hot
water
tnitial
hyd
how I qr hot water eirculat~ng hat water heater high water line hotwel i h I ghuay height by wtdth by length hybr ~d hybr~d microelectronic dev 1 ce hyeria Comuter lfnk hydraulic (ALTN ABf3R) hydrant
tbrl tc tc tc Ic fc tc Ic
lC {c ~c 6 fed
drum
point ~ release line conductor Conditions card \nteurated ctrcuft nte;lm change ntertor conammicatlon nternal cotiust{on on char!ber ntertor coimun{catton and ftre control dtstrfbutton ntercofmunicatton drum tnitial ~~ulse init~al Instruction
boll!ng
113
KIL-STD-121) 29 my 1981
ABBREVIATION
ICAS
ICUM Icas t cbm f cbr t cd i co ice tcf tcm i mcp t Cnps i cr I crm Ics t Cs ict tct 1 c1 ictcd Icu i Cv t Cw
TERM
tntorm{ttent comerclal and qmateur service tnterconttnental ball tstic missf 18 ice cuber interface control draw$ng tncreased co@mt
ABBREVIATION
I FT IG lG fft IG Ig i ge i gen IGFET
TERM
Intermediate frequency
transformer lgnttor Ielectron devfce) tnerttal guidance in ground effect current source ~nsulated gate field effect transistor Isolated gate fteld effect transistor l~tngemsnt ignttjon ignitron ~gni tor inertial *ldance system f ngo t tnlet guide vane inhtblt halt fltp-flop
IC9R Ico ICE ICE ICF IIc?w ICMPS I CR ImM I Cs Xcs ICT I CT ICT ICTctl Xcu Icv % ID SD ID 10 10 LT 10 No I Da I DAC I OCTR 10DD SDW XDENT XOEW 10F IDFO IOfR IOL I UP IDRTY 10S I OSM IDTY 10X IE Zf IF IF IFA 1?s IFC
engtne
{d id id id id {d
It
Ident ident
I@ent
inspection check ftxture intercomwunicat~on (short form) interchannel master pulse induct~on c-ass tron cure r-actor tee cream Intercomumtcatlon System tnterphone control station lnSp*CtiOn check t~?ate insulating core transformer :nternattonal Crit!cal Tables insecticide Intensive-care unit internal correction voltage interrupted continuous wavo indicator dr~ver induced draft inside diameter internal diawRter the s8m identification lfght identification nufmwr {nput data assew@}er interconnecting d{gital q nalog convortor \nductor \nternstional dtrect distant. d$aling Identtcal identtftcatlon
indtcated
Indicated inproved
horsepower
horsepower hour
hfgh
speed
b-lng
IIR
IK IL IL
IL IL
ILA I LAs ILAS ILLUM 1LLUS I LO ILPFL rl.s 11S IM IM IM IM lM IM I MAG IMC IMD
IMEP 2WI
Ilas
fllum f I IUS
----
110
Ilpfl
Identify
that
is
fnstde frosted Instruction folder !ntermed{ate frequency intermediate frequency q ~lifier Invitation for bid instantaneous frequency
IMI IMIR
IUX7
I ML IMNED
xm I UP IMP Ps IMPATT lNPD IMPF INPL IMPLR IMPLS
rFE
IFF XFFS
fndleated nan effective peessure inlet manhole fwroved manned Interceptor interceptor missile tnterrogatlon radar imitation Instde mold line tmediate tndlcateci math nuwtter
luQact {~roved Iwact tfm l~sdance l~erfect i~lement i~eller Iwpulse plow stee! transit
tfru
ffs
tdenttftcatlon frtend or foe switching circutt lnfllght ~nsertion inflatable Inflating-clef latfng lnstrumnt fl{ght rules interference rejection unit Intermediate frecpemy strip
qvalanche
114
ABBREVIATION
lMPR
TER ,M
ABBREV1ATION
INSOL INSP INSP INSR INST INST unit Insol i nsp insp Insr ..-. tnst tnst RLY Insoluble
TERM Inspect
Inspection Insert Instrument
Insert screw
IMPRG IMPRL IMPROV SNPRSN IMPS lNRS IW :: LB lNACTV 1NAO IN80 I NC INCANO
i ~edor
i~regnatQ ~~erlal ~~rovement tuqmession i npose tmmrs t on inertial measurent 1nch ~rich-pound inactivate { nadequa te Inboard incorporated incandescent incubator incident incinerator
(altn
thread
qbbr)
tnst fnst
instar
r!y
tnactv { nad
i nbd tnc i ncand t ncBf incdt incin tnc! tncl
NSTL
NSTL
NSTLR tisTM NSTPN NSTR WTR :NSTR [Nsuf
*nClude
inclustve Incllned fntercoolef tnc]osure incom$ng incendiary incoherent fnco~lete incwrect tncrease 1ncr~t interrupt tndicata Indicating indicator tmctance
incln
~nclr Incls incm t ncnd f ncoh i ncm i ricer i ncr i ncr i ncr i nd fnd tnd ind 1nd i nd 1 nd ind 1P fnd r-g i ndef i ndep ! nde t indl t ndoc indt indtr i ndv { nf tnfo i nf rn 9nhe imit ~nit 1nj fnj in] i nop i norg Inp i nq I nr inrt tnrtflr inrtg ~nrtl ins Ins tns char #nsc
INsut
INSUL lNSUL [NT [NT [NT [NT CON INTCMG t NTCt+GR
INTCON contr~l re9tster
t-ctame
induction i n-s try
s*lf
instl Instl instlr ins tm instpn tnstr instr instr i nsuf I nsu 1 i nsu 1 t nsu 1 i nt i nt int int con i ntchg intchgr \ntcon i ntcp intcyl 1 nteg intel t nten i ntereom Intercom intergovt intfc
installer instru-ntatton instrument panel tnstruct tnstructton instrument insufficient Insulate insulatim insulator integral Interim interrupter (relay) internal connection interchangeable interchanger interconnection intercept intercylinder integrate intelligence intensity interc~nicating intercomntcatton intergovermnta 1 interface intake internal international interlock intermediate intermittent interphtme interphase transformer interpole interpret tnterior tntricate interference interrogate introduction interpolation tnterpupillary interrupt intersect intership interstate instrumentation television interval intervalo~ter inverter invariant investigation Involute inventory inverse invert i nuard \nput translator
INTEKOM
2NTERGOVT INTFC I NTK INTL INTL INTLK INTMO INTMT INTPH INTPHTR INTPO INTPR INTR INTRC I~RF INTRG INTRO
I No IND LP
INO REG INOEF
INOEP INOE?
Indicating lam
inducta=e regulator indefinite independent indeterminate industrial indoctrinate i neen t ~ndicator transmitter individually infin~te information inference tnhibit initial initiation inject injection inlet inoperative Inorganic input inqufry inner inert inert filler inert gas inertial inside nsure nsert character ascription nseparable
It=8 INIT INIT JW lNd I NL IP#P I tU)RG INP INO I NR INRT INRTFLR INRTG INRTL INS INS
INS CHAR INSC
INTnPL
1NTRPM% INTRpT ItWSCT
INSEP
i nsep
..
115
MIL-STD-12D 29 *y 1981
A!3RREVIATIUN
TER.Yl
tnfttal operating (Operational) Capability instantaneous overlosd lncrt opcrattonal mtssfle
ABBREVIATION IRREG
TERM
trregu]ar ftem reductton studies tnfrared tracker interrogator responder transducer infrared target seeker incomplete se~ence (relay) industrial service trisect screen fnventory schem)e island information sort and predict independent sideband tnsignta isolation tsolation ward Isolator isometrtc \solate isosceles insulation spectftcatlon issue lnit~al spares support list Internatton.1 Standard
Ioc
IOL !0?4 10~ I ONO IF 1P 1P
1P 1P 1P 1P 1P
1P
f Oc
{01 i om tom I ono
t rreg
1rs lrt I rt {rts fs is is is fs i sap t sb tsgn tsln isln
IRS IRT
lRT IRTS Is Is Is Is IS I SAP 1s8 I SGN
I SLN ISLN ISLR 1S0 WV
Interoffice ionosphere
memorandum
tlon
Ip tp
ip ip tp ip fp lp ip Ip tpa ipadaa
1P
IPA XPAOAE
tdent{ficatfon of post itmact point initial point instruction plate Instruction pulse tntercept point fnterchangeaole Soltd screen panels fntertiiate pressure interpost Iron ptpe
a-
wd
fP8 1pbm
f pd ipd t pdp tpi ipl i pm 1ps 1ps IPS
q ~lifler intermediate powr integrated fmssive-actton detectton qnd qcquisltton qqu t preent illustrated parts breakdewn
Interplanetary ball tstic mfssile tnsertion phese delsy priority designator tssue tntervals of pulsations dimfnfshlng pertod
I SOL 1S0S
ISPEC I Ss
Islr t so tsol tsos f Spec \ss tssl 1ST istar 1syn ft it ft it i tae, t tas I tde
tttn itl 1 tm
Thread
lSVN
IT IT IT IT IT8E ITAS I TOE ITIN ITI. I TM
lmetric)
tdentif{ud intercept
prior
to
indentured parts ?tst interruptions per minute tncn per second Instrumentation pover supply International Pfpe Standard
Ips t ps
ipt ipt if ir ir ir ir t racqr t rah t ran i raser
tntermptions per second tron pipe sfz. tntwnal pipe thrsad Iron pipe thread retrteval Informatlurt
{nfrared fnsfde radtus insulation resistance ~nte~rogator responder tnfrared acquisition radar tnfrared q !ternate head ~nspection qnd repatr qs nec~ssary tnfrared maser tnte~im remote area termtnal q qut~nt Intermediate range ball lstic mlss{le information retrieval center infrared counter countermeasures Infrared countermeasures tnfrared tnfortuatton qnd q nalysts infrared measurement tnfrared mtss utstance approximator {nfrared monochrornattc radiation intermediate m8d~um range ball tst{c missile increase re11at3tlity of operational system ~nfrared physical measurement intelligence radar reporttng Infrared range qnd detection
IR rR IR IRACOR I RPil IRAN !RASER IRATE x ROM I UC IRCCN I RCN ZRIA I RM I RMa I RMRA IRMREtM IROS I RPM IRR I RRAO
ITR ITS
ITS ITT
ftr t ts t ts ttt tu iv iv { vd tw J 1 J jhp j amg dan JAN @N&F Jap UATO ]b ;: Jet
UFET jk jkscr jkt
lU Iv
image storage translation qnd reproauctton Inductosyn !nstructlon tag insulating transformetinternal translator interrogator transponder integrated time and absolute error indicated true q tr speed interchannel time displacenmmt qrror {tinerary inverse time ltmlt interceptor tactical wtisstle Inverse time relay insulation test speclficatton intermediate tape store {nside trim teqJlate ~denttftcatton unit Inttial velocity
IRATE
irbm
fro I RCCU
intermed~ate
Voltage
tmage velocity detector tndtrect waste joiner joist jute asohalted, nonmtall~c armor ( insul ) jo~sts and planks ja=~ng danuary doint Army-Navy do!nt Army-Navy-Air Force japanned Jet qssisted takeoff junction box janitors closet jotnt co~ound junction
junctton
transistor jack jack screw jacket jurrper join
fteld
effect
dKSCR at dMPR m
J-r
jn
116
MIL-STD-lZD 29 by 1981
ABBREVIATION
jnd drm dmo do JOG
TERM just
notlceabl~ dtffermcm j ourna 1 just not nottccablo df f ference job Or-r joggle jotnt operati~ proccduros jet propelled jotner ptlaster fume ttght jotner p~laster nontight junior jamning radar coveragm Indicator ja-ing to signal joint support Jlg tem)ate jotnt joint bar
ABBREVIATION
TER.M
llalson (atrcraft) Ilne (Conm fore) 1ong 1Ow sfngle qcetate (Insul) llst launch qnd Imact locus of radius lead qngle ?tghtning qrrester load adjuster laboratory low altttude bo-ing ltght aircraft binary ~nformat~on link low q ltitude botiing 1 adder laser detectfon and
Jnl Jnnd jo jog doP JP Jpf t jpnt jr jre{ {; Jt ; :b jtsn du I Am just jw K k k k kal
kald kb k Cp k CpC
k
L L L L
1 1 1
1 list l&l I/r la 18 la 1 qb LA8
dOP UP
bJPF7
LAI
L/R LA LA LA LAB LAB LAB IL LABS LAO LAOAR LAOU LAE LAG LAN LANA LANG LAW LAIUUET LAPT LAO LAR LARF
Iabil
LAOS 1 qd 1qdar 1 add 1 qe
System ranging
1 qg
1am LAMA 1ang 1anh 1 qnnet lapt 1 qq lar 1q r+ 1am las Ias 1 qscr
low q ltttude droguc delivery 81ement left qrithetlc 1 agg i ng Iamlnate local qutomat~c message
tcd
kd kdf ko klne klp
qccounting 1mguage 1 aunctT large artlftcial neuron network local apparent t{me I qcquer local acquisition radar low q ltitud= radar fuzlng line qutomattc reperforator light actfvated Swftefl low q lloy stee) Ilght-acttvated
semteenductor controlled Fectifi@r light a~llflcatton by stiwlated emisston of radiation 10U q ltitude search option line anplffter qnd super sync mixer latitude lateral 1 sundry lavatory letter box lifeboat llne buffer linoleum base local battery pound pound-force foot pwnd-force fnch left bank 1 abe I load buffer memory length between perpendlcul ars 1umber f iberty I t brary
LASER
1qser
KP KPe D KPG KPL KPLS KPSM KRAL KRSN KSR KsT UVM KVAFW KVAM KUHN KUY KVt30 : L L L
key
k ybd I L 1 1 1
klystron q q!llfter klystron oscillator knot kntfe switch knife blaae knffe q dge knurl kfckoff (relay} knockout keypunch klckpipe kick plate and drip k qup i ng kick plate key pulsing klystron power supply modulator Koroseal kerusene keyboard send qnd receive key5ea t kilovolta~ere hour kflovoltawere hOur meter ki lovolta~ere inter kilowatt hour meter keyway keyboard cellulose acetate ( tnsul 1 fnductanc8 lconb furm) lead sheath (insul I left lew?site
1av lb tb
lb
LB L6
LB u FT
LB l?f LBK L8L L8M LSP LBR L8RT LBRY LBYR L8YRPK LC LC LC LC LC LC
capacitance launch coqlex laundry chute lead COver~ learning curve length of chord
pack
117
MIL-STD-12D 29 my 1981
ABBREVIATION Lc Lc
LC LC LC Lc LC LC LC LC Lca Lcc :%L lC lC IC Ic Ie Ic
TERM
I!ght limited
line load Iosd CaSC coordination
ABBREVIATION
LEA LED LEIO LCd LELU LEM LEP LEPT LER
TERM
llne equal tztng awplffler light emitting diode IOU energy \on detector Iongitudtnal expanston joint launch qable Ioglc unft lunar excursion module lowest qffectlvc powr long endqrance patrolling torpedo Ieadlng edge radius launch escape system loep error signal launch escape tower linear energy transfer launch qnabllng unft levelonmter lawn faucet life float l+ne feed linoleum floor load factor (tabular) low frequency low frequency correction low frequency oscillator low-frequency outer marker tot fraction reliability d8ftnition launch facility sirrulator loop feedback signal ?tfttng long (altn qbbr) length light gun )oop gain length-to-diameter ratio light gun a~lifier IOglc 1 qrge light gun pulse generator Ilgnum vitae left hand itter hook eft hand drive ocal hour angle eft hand stale etter of intent w intensity i tense inear integrated circuft eadless inverted device ibrary issue document locked tn deVfC@ light detection qnd ranging linearly frequency modulated pulse l-ast-in-ftrst-out I imer IImit imtt switch !mited distribution ineal i near
1ca
LED !eld 1ej lelu LEM lap lept I er 1qs 1es let let Ieu levmetr lf lf lf If If If
t fc lfo lforn LFRO Ifs ifs, lft ---lg lg Ig
carry~ng
carrter
lC lC lc Ic ) cb LCC
LCD LCDTL 1Ce 1Ce lcf 1Cg 1ch 1Chr lC1 LCL 1cm lcm \ cn Icolnt 1Cp LCR ) crv lCS 1Csw LCT let Ict ;ctn
center load co~ensating low carbon lower case lox clean stngle acetate (tnsul cotton
{relay)
single
LCE LCE LCF LCG LCH LCHR LCL LCL LCM LcM LCN LCOLNT LCP LCR LCRV LCS LCSW LCT LCT LCT
LCTN LO LO LO LD LD LO W LOA LOA LDEI LOO LOC LDC LOET LOG LOG LOG CR LDISCR L= LOP L OR L OR LOR LORI LDRSP LOT Lt LE
) longitudinal positton of C=nter of buoyancy launch control cl?nte~ lfautd-crystal 01sP18Y o~d c~en%atd dto~ transistor logic aunch cowplex *ipment 08d clrcuft efficiency ogttudinal position of center of flotatlon Ongltudtnal positfon of center of gravity q tch launcher I oca 1 lower control limit
lead coated ~tal least cOnmOn nultiple load classtficatton ~er low ceolant left circular polar.izatfon inductance capacitance resistance length of curve
Iifm-cyc)e survivability latcn checking switch local civil time locate tocust location Ieadtng line drautng list of drawings 1oad loglc drtver 1 qndma rk l~ne driving a~l!fier locate drum qc3dress light distribution box low drag boti ?Ine drop c~ensator ltnear Oetonattng cord level detector landfng loading landing ]evel lower
)g/d
1ga
1gc
1ge 1gg Ignmvte Ih Ih It! dr 1ha 1hs
Id ld id Id
ld
Id * 1da 1da ldb Idb tdc I ac )det 1dg 1dg Idg gr Idiscr ldk 1* 1Ur 1dr 1dr Idri I drsp Idt le )e le le 1*
LHA LHS LI 12
Ii Ii
lic LIC lid lla lid 1 idar Iifmop
LIC
LIC LID LIO LID L 10AR
LIFO
lim Iltn
gear
LE
LE LE
discriminator deck language data process~ng leader loader low data rat8 rate fnput low data leadership linear d{fferontlal transformer large end Iaunchtng eqatpment leading edge Ilfting eye low explosive
tm sw Itils
in In \n tnol !q
iquid
~noleum iqutd
nttrogen
iq fI frly fs
LIT
LITHO L2TW
tt 1tho
t tho
tquid fuel aad indicating oop input signal i tter ithograpfl i thographic
relay
118
ABBREVIATION
LOG LOG LOGCON LOGFTC
TERM
logarithm
Iogtsttc Iogtstic logarithmic constant
lunar
qnd
Interplanetary
109 1Og
1ogcom
Iogf 101 lom Iom 1ong 1Ong 1ongn tc
co-nicat{on fast
ti-
lk
Ik
c
O
locked I ockd
closed
open
LKNT LKR
LKROT LKSCR LKT
LOL LOM LOM LONG LONG LONGN LOP LOP LOP LOPAIR LOPAR LOQG LOR LORAO LORAN LOREC LORO LOS LOS LOSS LOX LP LP LP LP LP LP LPC LPCU LPFL LPFM LPG LPG LPHLDR
LPL LPLR LPM LPN LPO LPOX LPR LPRSVR LPS LPSD
length of lead (actual ) light-optic mtcroseopo low order memory I Ong 1 tude Iongitudtnal Iongeron llne of position operatfng procedure local
Iubrtcat!ng 011 ~ long path infrared low power qcquisttfon radar locked oscillator quadrature grtd lunar orbit rendezvous long ranga qctfve detectson
LKUP
LKWR LL LL LL LL LL LL LL LLL LLLTV LLRES LLT LLTT LLYP LM LM
1oro
10s 10s LOSS 1ox lp Ip. Ip
long range navtgat{on long range qarth current conmwn~cat ions lobe on recetve only !tne of Signt 10ss of signal Landtng Observer Signal System ll~ld oxygen programntng ltnear
long persistence long playing lW pass low potnt low pressure loop cuntrol long
1p
Ip lp 1pc 1 pcu
(relay)
)pfl
lpfm 1pg
LNG LNG LNSP LNTL LMYO LO LO LO LOA LOAC LOAMP Los LOS L08AR L(IC LOC Loc LOC CIT LOCO LOEP LOF LOFAR LOFF
l~b;k lmr LMT Imtg lmtr Inu In In ! nod 1rq 1ng 1nsp Intt 1nyd 10 10 LO 1Oa 1oac 1oa~ 10b 1Ob I @bar ---1Oc 1Oc 10C Cit 1Oco 1eep 104 Iofar Ieff
I pg
lphldr lpl Iplr Ipm 1pn 1 po 1pox I pr
puls8 continual wave lowpass filter low-powered fan marker 1qpp I ng ?tqufd petroleum gas
lanqmolcier llghtproof louver lock pillar ltne per minute long part nu~er low power output low pressuroxygen 1ooper Iffe preserver Ilghtpruof shade logically passive self-~al Itne printer Itghtproof vent low-powr vor lumen per watt liquid {n glass ltquidometer 1 ~quor ladder rung Ilqutd rocket load rat~o load resistor (relay) tong range llne rece!ving ~lffter locked-rotor qn@eres control load ratfo long range data llqutd rocket ng~m! left right tndfcator long range interceptor long range radar fnput
ttm{ttng
llmlter llne monitoring unit togartttwn (natural) natural logarithm lens board Iongthening ltntng lens speed I intel 1 qnycrd local oscillator lock on lubrication ordor length overall low qccuracy logarithmic q~tifler lfmfted operating base ltne of balance radar long Base!lnc locate (altn abbr} launch eperatlons center local ~zer fn the place cfted {for
l.PTR LPV
LPVOR LPU LOGLS LONETR LQR LR LR LR :: MA LRA
LRC p8ges
effectlv8
frquency acquisition
LRO LRE
L~I
LRI LRZ
I pw lqg!s Iqmetr 1qr IfIr Ir lr tr 1ra 1rs 1rc 1rd 1re lrl lrl Irl
119
liIL-sTD-12D 29 *y 1981
ABBREVIATION
LRIRR LRR Ls LS Ls LS LS LSA lrft-r Iow-resolution Infrared radlometmr long range rsdar launcher Sfte left qlde I Imstone ltst of spectftcat~ons loudspeaker limited-space-charge qccamulatfon (microwavm diodes) least significant bit lW speed buffer lowr sideband long side LUM LUN LUS
TERM
luminous lunette
1rr 1s
)s IS
UJT
LV LV LV LVCO LVO LVD LVOT LVL LVO LVP LVR LVR LVRE LVRLSE LVS LVS LVTR LWil LWC LUXC LWL LML LWR LUST LYR LYT LZT M M M M M M M M M MeF M8X MhR Mas M/D M/F M/s MA m MA MA MA MA M&A M&c MACH MACH MACS MAO MAOAR MAOO10A MADt4
load
Iv lV
lV 1 vcd
1s
!s LSA
1vd
1vd lvdt lV1 1Vo 1Vp 1vr lvr
lsdt 1shg
LSHI LSI 1 sm lsmlth I Sp Isr 1ss Isst Ist )stm I Svg lSW It It lt It It It It lt It It tk 1 ta
time
large
LSI
LSM
LSMITH
LSP L SR Lss LSST LST LSTM LSVG l.SW LT LT LT LT LT LT LT LT LT LT TK LTA LTBO
scale hybrid integration large scale integration ]agncher status multiplexer ~ocksm?th
resistor launch status summarizer ltst of specifications
lvre lvrlse I Vs
lVS )vtr I* 1UC luic lW1 lw.1 1wr
update Subset launch u-ilica) tower launch vehtcle 1cave low voltage least voltage coincidence detector louvered door low voltage drop linear vartable differential transformer 1eve I louver openfng low voltage protection 1ever louver low voltage release effect 10U voltage release
low
leaves
velocity scanning vhf transmitter recei ver long wheelbase lightweight concrete lightweight insulating
]OW
and
standards local standarcl time low steam ltfesavlng laming signal wand language translation tug large laundry tray lead tim light Itght trap logfc theory low tension
light llghter tank than
light
m m m
m m m m m m m4f tit mkr mss m/d m/ f m/s ma ma ma ma ma ma ma q mac Mach math mats MAO
line low water line 1ouer lowest layer layout local zone ti~ bendtng mment magnaflux manila (rope) mass metacenter meter f instr,
cob
form)
mOde
LTC
LTC LTC LTD LTEMP LTG LTG LTti LTi+R LTID LTL LTM LTPO LTPR L TO LTR LTR LTRN LTRPRS LTSW LW Li.1 LUB
t bn t tc tc ta
t em tg tg t gh
oscillator
model
1thr ltid
ltl ?tm
LTPO
1tpr
Itq
Iu 1ub
I ubo Iutst 1ud
LU80 LU07
LUO LUF L Wf
Iuf 1uhf
longitudinal time constant ? tm~ ted low te~erature lightening ltgtlting lightening hole leather light-intensity detector l!sting t~me lfmlt line type modulation lot tolerance percent defective long taper low torque letter Ietterlng 1 qntern letter press Ifght switch !Ine terminating unit IOgtc Untt lubricate lubricating 011 Iubrfcant llft-up door lowest usable freqUenCy lowest usable high frequency
qnd
day
supply
madar
madd i da
madm
magnetostr?ction master memory address mercury qrc message qsstiler metal qnchor mission accowllshed maxinum authorized altitude mean aerodynamic chord Mach nu~er math i ne medium q ltitude comunicattons sate! l{te magnetic a!rborne detection malfunction qnalysts
nunition
MIL-ST2-UD
29 tiy 1981
TERM
magnetic dmmt race! v$ng equfpment m{croalloy dlffusect trans~stor qequisit!on flux mini-m derisl ty
magaztne magn8t magnettc
AFIBREVIA?1ON NAone
MAOT MAFD MaG MAG MAC MAG-THOR MAGAf4P MAGI MAGNOO MAGN MA(3TO MAH MAI?4T MAd MAL MALE MALF MAM MAN MAN OVLD MANAM MA?JO MANF MANOP HAN7RAC
MAIWV
ABBREVIATION
MOD M8GE
TERAI
motor belt drive!
gutdance missfle borne equ t pment
medrw madt
MBK
MflL M9R MBR M8R MUR NBS !40s NUT MaT MC MC kc z MC MC MC MC MC MC MC MC SWGR MCSG
W&#lttple
SIObiI@ marker
beam klystran
nultiple
magnetron
magnetic
magnetron magn i tude
modulator
mah maint ma J ma I male malf mam ---man ovld manam mand manf manop mantrac manuv MAOS map map map mapg
MAPU Mar mar marg MfJRS
mahogany
maintenance major
malleable fiulttaperture logic malfunction ml 11 iwmneter manual [altn qbbr) manual overload element
tank matn battle tank magnettc core mafn cwlant major c~onent manhole cover medicine cabinet
mil!tary characteristics mode change momentary contact motor chatn moving CO{l
wltichlp
manual
qnundnents
wltiple
mandatory
manifold manual of operations manual q ngle tracking capability maneuweri ng metal-aluminum-oxide silicon pressure manifold qbsolute
mapp f ng -ssage
MAf3S MAP MAP NAP MAPG MAPU MAR MAR MARG MARS
MARS MA!j MASER
MCA Mm xc UC MCE
contact metalclad switchgear mapping charting and geodetic mtninum crossing metal cornq bead
maintenance
-dified
ef
close
contact
qcceptance
qvailable q llocation
maxi-m
memory protection untt March mar~ne margin Mllltary Afffllated Radio system wlttaperture reluctance Sui tch metal anchor slots mtcrowave q ~l{flcation by
equipment ma{l chute mechanically cooled mechanically refrigerated math t nary machtnist magnetic core memory att)ttary characteristics motor vehicles
mtne countermeasures
thousand
MCP ctrcul,ar mfls
stiw~ated radtatitm
MASK MASU MAT MAT MATCON MATH MATH MATL MATW MAVAR MAX mask masking
emtssion
0?
EL Mcs Mcsw xl
masu
ma t mat
machtned
surface
mat con math math matl matw mavar max fnax cap max flt May * m * m m m
matrtx mtcroalloy transistor microwave aerospace terminal control mathematical mathematics material metal q uning type window moauiatlng q~llfler using var~able r8sctance maxiuum maxiaum capmclty maximm flight May mail box main battery (gunsl
unit metal casement window modulated continuous wave matn drum manual data mean devfation motor direct motor dfrect connected fraam! main dlstr~buttng manual dtrectfon finder
make break memory buffer model block motorboat make before break
MO:
NOIF
Mozu MOL
midget magnetfc directlfon indlcater Input manual data mfss distance indfcator input function ma-al data
manual mtddlc module data input unit
121 .
TERM
AFIDREVIAT!ON
MFC MF C MFCC MFC$ MF O MFQ MFEO MFG MFG INFO MFG SPEC MFUOF MF MC MFLRD MFP MFR MFS hfFsrlJ MFSK MFT MG m MG % mfc mfc mf cc manual frequency control mlcrofunctfonal circuit misstle flight caution corrtctor missfle fire control system magnet{c fre~ency detector manufactured maxinum flat envelope delay manufacturing manufacturing tnformatton
maximum c!eslgn meter med{um metal dielectric metal [filterl mobile depot maintenance MOM medi an MOM mdn master mdr data record mdr MOR mission data reduction -lttehannel data recorder mdr MOR mdr I mandrel MORL msster dtmenslon Mos Speciffcatlon mintwm dlscerntble signal mds Mos MOSE merchandise mdse MDT MOt mean dwn ttme MOT moderate mdt message decoder unit MOU ME mftor qd me ME mbfl{ty equtpment ME mtniwm enroute aItitude MEA ma matntenancc englneertng MEAR mar q nalysts record measure MEAS mess mechanical MECH -h mechan f sm mech MECH UCco main q ngtne cutoff -0 mechantze mecz MCCZ ---medium (altn abbr) MED MED medical mad mtcroelectronlc device MED MED melamine MEL met MELEC ts~croelectron~cs me}ec UELEM miero=lement mlem mflttary electronic Ifght Wlva MELVA valve UCu memory address counter SEE BELOW SEE BELOW memory
MFCS
mf d mf d mf ad mf g mfg tnfo nlfg Spec MFH9F
manufacturing
-an
spectf~cat~on
mf hc mf Ird
mfp mf r
fl tght hours between fai lure misstle fl~ght hszard corridor ma)e flared -Ittfrequency pulsing manufacture
mf s Infsfu
mf sk mf t
marine
f~ntsh
slate
m 2 z m&
matt finish 5trUctural facing units Wlttple frequency shfft key+ng mechanized flame thrower machine gun magnettc qrmature
motor manual
generator
gatn
w?ttgage
control mtsstle maintenance
gutdance
ground
qnd control
equtpment
magntfy memory
margtnal mogu 1
wlttple magnet o
MGR
yn
motor
carrtage
qddress
register
mmo
MCMPT
MEP UER
?4ERCH ME Ss MET
MET
met
met
metb
mete metcal metal
MET nETB METC METCAL MCTO METF M6TG UET4 M~TM METP METP MCTR MCTRL METS METS MEW MEUS
met
memkwane mmorandum memory potnt mean q ffectlve -rfdtan mercharttab le mssenge~ fwtal metallurgical wlttemltter
M(?S ml
pressure MGTMTR w NH we #lo
manager metal gravel stop management magnetometer magnettc head manho I e mine hauling bogie
mhd mhd
transistor MHO
cal
metal base
metal
-tal -tal mtal swtal metal curb Ibratfon door flashing grill jalousfe
meteorological
LT
mhd ?t
MriE tif mhhu mhl lwlpd mhr mht
metf
metg metj H tln
MtiE MHF *W WL MD
mold
porttorl
metp
metp
metr metrl mats Wts
metal partltlom
metal metal roof
meteorologtca 1 nultal strtp moetIe engtne test stand m~crouave q arly warntng mtss!?e early warntng system mezzantne matn feed floor mastfe medium frequency m~crofllm motor fteld magaztfloodtng and sprinkling .s90= q **** q **
MI Mt MI MI
MEZZ Mf MF w
Mf M? MF8S . . .
q
MI Ml MI
MIA MIC MIC MIC
MIC
q
ml mi rnt mt mi mt mf
mta
mem adxs
MIL-STD-HD
29 my 1981
ABFIREIIATION
MI CAM
TER,M mt croamnet8r
micrashone q lemnt mtcrocmutt!r character magrte t * c I* recognl t Ion mt croscope micromtntature mfddle ialtn qbbr) detection qnd mtcrowave rang~ng missile cloppler m~ I Itary Military Standard (book} M~l{tary Spectffcatton mfntuun minor minute miniature sccessory power supply mini-m conammtcations miniature manual tnput processing minlwm t~ulse pulse miss~le Inqact predictor modular information
ABBREVIATION
MLTPL MLU M1.w w mltpl mlu mlw Ran
TERM
MICELEM MICNPTR MICR MICR MICROMIN MID MI DAR MIWP NIL MXL-STO
MI LSPEC
mtcafn mtcelem mlc~tr m~cr mtcr mieromtn ---mi dar m{ dop mi 1 MI L-STD
MMF WOO Mm MN MNCMPTR WF Rn MNG MNL MNL OPR MNos MNPUR MNRL
MILSPEC
mtn min mln m{n~aps mtnicom mintr mtp mip mip
mipe
Hmlf nmod ms lmllt m nmcnq tr -f rm ~ mnl Opr mos mr 1 mnstb mnstbmv m m m m m mo z moe wca mocan lt
MINTR MIP
MIP MIP MIPE WIPRCS MfR MIR MIS MI Sc MIT MIT MITE MITE MXYE MZTO MIU MIU Mu m
WSTB
WWSTBNV MO MD IW MO NO NO NOA MOS LT Moc MOCA MDCAN Wo Moo mo mm mD MOOEM MOOR MOL MDL UT ~LELEX NOM WN NON MONO Morwc NO~G MOP
M2PA
processing equtpment
miprcs mir mtr mts
mtsc
mi te mf to fntu
ml Wlicb mld
mld mld mld mlog ml f mlg ml i mI 1 mllp mllw mlo mlp mls mlt mlt sp
microprocessor memory t-t regfster mi rrur metal Insulated semiconductor miscel laneous master instruction tape. mi ter master instrumentation timing equipment missfle Integration termtnal equipment wlttple Input termfnal equipment mfntmum tnterval takeoff malfunction \nsertton unit message Injection unit masttc joint mark mark ed mark~ngs marker marker radio beacon meter-kt Iogram-second makq major lob. material list -Id line monolithic multi layer circuit board master layout duplicat8 middle Iandtng mfntnum line of detect~on mo 1ded
molt?tng
uud -d Wd fmdem modr mol ml Wt molelex mom mon mm mono monoc monog
mops
MOPAR
MOPR
mofmr mopr moptar mor mor t mor t Mos Rws MOSFET NOST mot Wt
MOPTAR NOR MORT MORT Mos MOS NOSFET WST MIT MOT
Nltf lateral force main landing gear fnini~m line of interception master lines layout manned Iumar landing program mean lower low water layout original maste~ metal lath qnd p~aster metal slftting mean low tfde aulttspeed
lmltiplme mtsce)laneous livw untt mean low water mfadle marker material manqpitnent code maximm matertal condftlon mortar motor carrier master makeup qnd display magn9tomotive force mtcromodule magnettc mtne sweeping metal mount main mtnlcquter mainframe managing manua 1 manually operated meta!-ni tride-oxtde sillcon manpower mineral monostable motistable WItlvfbrator machine operation manual output masonry openfng master oscillator month motor operated matrix output qmpltfier man overboard and breakdown 1 lgilt magnet{c optic converter miniwm obstruction clearance qltltude motor can mode 1 modification modtfy modulator moaulus modulator demodulator monodetail drawing molecule molmcular wetght molecular q lectronics momentary moni tor monument monopnon~c monocoque mnograph modulation on the pulse mastee oscillator power asq31{fier master oscillator power ~l ifier radar mop rack Wltlp?e object phase tracking and ranging memory output regtster master operational recording tape mrse taper oxide S@mlCOftdUCtOr metal
&
time
123
MIL-STD-12D 29 hy 1981
ABIIREVIATION
w MP MP MP MPAM MPc WC WPc MPG MPG MPH W 1 MPS MPIC
WPIR MPK MPL MPN MPO MPP UPP
ABBREVIATION
medium pressure melting point nultfplier phototube wu!ttpule maritime polar qlr mass motion pfcturs control panel nultiple purpose coawwnicatl ons maximm permtssfble exposure micrwave pulse generator mfles per gallon miles per hour magnetfc parttcle inspection mean po{nt of f~act message processing tnterrupt count mtssll~ prectsion tnstrumentatfon radar maintenance parts k{t maintenmcc parts list most probable number maxlmm povcr output most prObattI@ position motion picture projecter motion picture phonographic unit monopulse radar male pipe thread mobile positton track~ng radar machine rffle marble material request medium range message repeat mtcromfniaturt relay mtninwm receptton }t~tude mobfle radar qpproach control marble base medium range ball lstlc miss$le midrange [medium rangel ball tsttc fa~ssile mercur f q 1 metal rolltng door marble floor moor tng mechanical record~ng head miscellaneous radar \nput maintenance requ~red not devetoped midrange object{~e medfum range ratlar requirement maintenance Mso MSE MSG MSG MSG mm MSHG MSI MSL MSL MSLY MSMP MSN MSNRY M$P MSR MSRE Mss MST
MST
TERM
mean solar day maintenance support equipment mapper sweep genarator messag8 miscellaneous siwlatlon generation message generator meshing medtum scale Integratim mean sea level missile mostly master senslt!zed mater~al print mtssion masonry metal splash pan mtneral surface roof moon signal rejection equ t preen t Standard Mi?ltary Supply machtne SteeJ ttme mean solar masttc mo i sture message sultching unit master switch master synchronizer magnettc tape mail tray fnaxlmum torque mean tide mean time mechanical transport metal threshold motor transport mount transfer wltiple maritlne trupfcal air mass of true Im9arlng maintenance mean t!me between fat lures mean ttme between maintenance mean time between maintenance act tons mean time between removal master tape control memory test co~uter mission and trafftc control mean ttme to Catastrophic fai lure mat ched mean temperature difference mount ed w)tiple target deceptton maxlnwn tractctng error wltlsystem tqst equ~pment mechanical time fuze meeting mount i ng wultiple trigger generator mounting center magnetic tape handler
V V
w w
fmg fl@l
msl ml
msly msnq3 msn msnry msp msr M$RE Mss
ms t
ml
-l ~tc Up+r llpk -l -n Wo flvP mph wqr Oq3t tfvtr mr mr mr mr mr Inr mra mrapcon mrb
mrbm
mrbm mrc I mrd fnr f
mrg
MSTC MSTRE MSU MSW MSVNC MT MT MT MT MT MT UT MT MT MT MTM MT8 MTBF MTEiM MTBMA #f7eR
M7C
mtb
MTBF MT8M MTBMA MTBR mtc tlttc MTC MTCF mtchd mtd mt d mtd mte mte mt f mtg
mr h mr 4 mrnd mro mrr mrs mrs mr t mr t mru mru mru ms ms MS Ms ms ms !t msb mscp mscr
MTC MTC MTCF MTCHD MTD Mm MTo MTE MTE MT: MTG MTG MTG ?41Gc Mm MTHBO MTHD MTHRD MTl M?L MTLC MTLZ MTMS
MRU
MRU Muu Ms MS MS MS MS WS L? 4s8 MSCP MSCR
mthd
mthrd mt i mt 1 mtlc mtlz mtms
124
.
ABBREVIATIO~
MTN NTONS MTOS MT R MTR MTR MTR MTR MTRCL MTRON MTRE MTRG MTRS MTRs MTS UT s MTsQ MTTE MTTF MTTFF MTTM MTTR MTU MTVAL MTWF MTZ M.J w w M,lt)R WF m.Jf Wfo WLR WLT WLT WILTH MJLTR 9WLTR WN Wsa WT WT M.JT UJx Mv Mv w MVS MVOL W/c MUG MVP MVP MVS MVs MVT MW mtn MTONS MTOS mtr MIR mtr mtr mtr fntrcl mtrdn mtre ---mtrs mtrs mts lnts mtsq mtte MTTF MTTFF MTTM MTTR Intu mtval mtwf mtz IlnJ mu ImJ mdr IIUf Wuf Wfd nwlr IIUlt ImJft wulth multr ImJltr mun wsb ml ImJt Rut Wuw mx mv mv mv mvb mvb 1 mvc mvg
mvp
TERM
Wu)tton metal -thfck-oxfde-nl trtde sflicun metal-thick--oxide stllcon magnetic tape recorder mean t{me to restore wnrter ( fnstrl metering mlsstle tracktng radar motorcycle motor driven nwlttple tape recorder end 8Uter\~ (altn qebr) mattress tape recorder start multiple matertai test specification motor operated transfer swf tch mechanical tl= superquick magnettc tape teminal equ i preen t man time to failure mean time to first failure mean time to maintain mean tlm to repair magnetic tape unit mast-r tape validation metal thru wall flashlng motor{zed memory unit moe~le unit nulttple unit nwltidotail drawing maxifwm usable frequency wffler makeup feed na411er nultiple swltipllcation nultilith wltt~ter -lt~plier wnitions WUbile unit support b8Se mean up time mockup t-late wlti late IMJSfC wtre nu!ttplex mean vartation nultiv{brator nuzzle veloclty motor v-belt movable manual volume control moving magnetic vector potential methyl-violet paper ma~etic voltage Stabilizer mifiiaum visual-signal movement medium wave rmtor whale boat Nuslc WiPe Gage message waltlng fndfcator mill tuatt log{c modification work order maxlf!um working pressurm~rane waterproofing mean width ratio max~wm uorktng voltage mode trans~cer
AB13REV1AT10~
MXPL MXG MXR w T MZL N N N N N MA NA MA MAC mxf mxg
TERIW
mtxed flow
mtxtng
mf xee
mxP tnx t
mz I n N
N n n
NAtoP
NAR NAs NAS NAT NATL NAUT NAV NAV NAV NAV 8RZ NAVAIO NAVAR NAVARW NAVCN NAVSAT NE No Noc NEDFX Mm Nes NC MC u NC Nc % MC NC NCA
na na na nac natop nar NM P4AS na t natl nau t nav nav nav nav brz navaid navar nav~rho navcm navsat nb nb
WC
nc nc nc NC nca nch ncm ncoti ncp ~ld ncu nil MOE NOI ndl ndr ndro nds NOT NEC NIECS NE F
ntiture x muzz 1e electron [n}-type semiconductor material National form (thread) north novelty (tnsul ) nylon I insul I next qssemly not applicable not available nace 1 ) e navigational aid inoperative for parts narrow National Aerospace Standards National A~rcraft Standards natural national nautical naval navfgate navigation naval bronze navigational qtd navigational radar navigation and radio homing navigation counter~asures qnd deception navigation satellite narrow band no bias (relay) mclear. biological chemical narrow band Dicke-fix natural black slate New Sritlsh Standard (l~ertal wire gage) chloropicrin stannic chloride National coarse ( thread) network controller no change no cot! no connection noise correlation
normally closed
mo
lm4r Wv mxdcr
numerical control ntckel copper qlloy not chcd noncorrosive metal noncombust lble normal Circular pitch noncouplea nozzle control unit no drawing nondirectional beacon nondestructive qvaluation nondestructive tnspect~on need 1q normal diametral pttch network data reduction nondestructive read-out satellite nuclear detection nondestructive testing National Electrical Code necessary National Electrical Code Standards (thread) National extra fine
125
TERM
MFU MEG
NEGPR
ABBREVIATION
NOL NOM NOMAD ml nom nomad
TER31
normal overload nomtnal naval oceanographic meteorological automatic dev 1ce nomenclature nonflansnab 18 nonstandard nonsynchronous nutier of passes notice of revision norms I nqrmal ize not othervtse specified nonoscillating Novemer nozzle [thread) National pipe nickel plated nonprocurab Ie nonpropel led q ngle normal pressure nonpetroleum negative-posit iv-- intrinslc(electron aevlce) negative nameplate negattve posltlve negatfve ( transistor) negative-posl tfve-negat lvelelectron device) posttive negative posittve zero no~se power rat~o neoprene Navy Prtmary Standards straight thread (pipe coup] ings) thread for press tfght joints and nipples pipe thread locknut taper pipe (thrsad) taper pfpe thread tight jotnts taper pipe thread (rall)ng f Ixtures) negat$ve resistance notse ratio nonreactive Irelayl nuclear reactor nonreinforccd concrete pipe ~gative resistance d~ode nonreplenishable demand nonreturn nunmer of rejected infttal p i Cicups ntght ratton locker nonrevers ible nonreturnto-zero nonreturnto-zero-change nonreturnto-zerolevel nonreturnto-zero-mark Nat{onal spectal [thread) near side nickel steel nonsew~ceabl e nonsatellfte \denttfication nonse 1f Navy Secondary StandarQs nonsl tp tread navy type
joints National
nefd neg negpr ne{) nelec none 1 nep nepd NESC net net net neu t neut news NF NF nf nf nf nf nf nfl nf se nf t ng ng ngen nh nha nt ni sil nfb nie nic nf cop nip nir nis nitros nitstl nk *1 nl nl n 1 cng nl It nld nlft nlg nlnr nlr nlt nlt run nm nm nm nma g ml nmr nmr no no noccc nog no i
Nan
NEUT NEWS NF NF NF NF NF NF NF NFL RF so NFT NG NG
W4 WA NI NI SIL NIS ?41c NIC NIWP NIP NIR NKS NI T.ROS NITSTL w NUL NL Ml. NL CHG ML LT NLD NLFT NLG NLR NLT NLT m NM NM NM NMAG Ml NNR fwR No No fmca Wz
noise equivalent flux dons t t y negative negative prtnt neon indicating l~ght nonelectric nonenc I osure noise equivalent power nois8 qquivalent power oens ~ ty National Electrical Safety code net explosive wight no~se e~ivalent t~erature not earlier than neutral neutralizing warfare naval .Iectronic sinulator National fine (thread) National fornulary near face noise factor (figure) figure noise frequency notse nose fuse navy standard flange nonf used normal fuel oil tank narrw gage 90noisc generator National gas outlet fthread) nonhygrosCop IC next higher asse-ly noise index ntckel silver noninterference basis negative i~edance converter not in contract nickel copper nipple no indiv~*al requirement not tn stock nitrostarch nttrtde steel neck nickel n(ght letter no 1qad normal charge net lay~ng ltght no load no load fram tinm nosm ?andlng gear nonl Inear nois~ load ratio no later than normal lube o~l tank no mssage noise meter nonmetal 1 Ic nuclear magnetron nonmagnetl c nautical m~les no maintenance required nuc)~ar magnetic resonance normally @pen -er no control ctrcuit contacts -er i ng not othewlse tdentlfied
NOMEN NOW LMS NONSTD NONSYN mR ?mRM F5s Nose Nov Noz
NP NP NP NP NPA
NPE7 NPIN NPL NPN NPNP NPO NPR NPRN NPs NPSc NPSF N*SH NPSL NPSM NPT
NPT
npin npl npn mm npo npr nprn NPS NPSC NPsF npsh
NPSL npsm
NP? NPT nptf NPTR nr nr nr nr nrcp nrd nre nre tn nrtp nr I nrvsb nr z nrzc nrz I nrzm MS
ns
NSS MST NT
ns ns ns 1 nslf NSS ns t
nt
126
AFJFIREVIATIO~
NT NTc N7FY NTM NW NTP NTPt. NTs NTS NW NTUK NTws NTWT WC MJDE7 NW MM NVR Nu Nuo NUDEN NWG NUT
NYL
ABBREV1ATION
OCLO OCLNR
OCLR Oco OCONT OCP
TERM
Oil cooled oil cleaner oil cooler open close open oil control operating leperational) control procedure oil circuit recloser opttcal character recogni tion relay overcurrent
octagon
nt ntc ntfy ntm ntn ntp ntpl nts nts ntu ntuk n tws ntwt fvuc nude t rum num nv r nw nwden NWG nw t ny 1 ---0 Otoo 08 c 08 m 08 r oim
o/p oa Oa oa{de o
qnd OCR OCR OCR OCT 0C7 UCT OCT 00AWR 00 00 00 00A 00XFF :% ODON
ODOP
ocr ocr oc r
Ott
act Ott Oc t Oc t octahdr : Od oda
odiff Odn Odom
Odop
00P
00PP
ODPSK 007 ODU 00VAR OE Ocm or OF OFCE OfCL OFFEN OFG OFLTR
OFP OFR
odpsk
Odt Odu.
odvar Oe
qme
O&lo
Oap oat ob Ob
t Og OGE Og I 000
octal octane October Octuple octahedra I olive drab ordnance data outside dianmter other design acttvity oil differential orbital determi-tion module nu]lif!er own doppleP odometer offset doppler open dripproof protected open drfpproof O{i dipstick outside diameter tube output display unit orbit determination and vehicle qttitude r8fe~e open end origimal equipment manufacturer outside face overfrequency office Offfcial offens~ve (anvnuntt ton) opttcal frequency generator oil filter oscilloscope face 91ane overfrequency relay offset outfit object glass operating ground equipment obscure glass orb~ting geophysical
observatory
01
%fc
OIL
Ozsc OIWC Od OL OL OLVL on OML
ogr Ogt Og t Ogw oh oha ohm ohm cm Oi Oi Otfc 01? o~sc Otwc Oj 01 01 Olvl Om om1
127
q
AB13REv1AT10~
TERM
omnldtrect ton omnld~rectional output nultfp18x s ynchront zer oil nozzle radto rmge
ABBREVIATION
OSCRN OSE 0S1 OSL Osuv
TERM
otl screen operational equ f preen t oil seal
outstanding
oscrn OSE 0s 1 0s1 Oslw Osp Osp Osr osr Ot Ot othe Otccc Otg oth otk Otp outer Ott out out out out outbd outxl tr Ov Ov Ov ovbd Ovcs t ove Owfl ovh Ovhd Ovhg Ovhl ovld Ovp ovpress ovpwr ovrd Ovrm ovrn Ovs Ov Sp ovtr Ov v Ow
ouave
support
leg
OP OP
t)P UP
Op
Op m Opa 09a
opcom
observation
post
oP A OP A OPCOM OPDAR OPI1 oPt-G OPM OPN OPN OPNG OPNL OPP CPP OPP OPP CE OPP W40 OPP PE QPPOR oPPR t?PR OPR
OPR OPRS C)PRT OPSD
opdar Optl Oplg Opm epn Upn Opng opn 1 Opp Opp Opp Opp C* Opp hnd Opp pe oppor oppr opr Opr apr oprs opr t opsd ---opt Opt out ax optar Optl or or or or ord Qrd orcl orcl ore i r Orf org org orient Orlg orig or$g orly orn orn 0% 0s 0s 0s Osad Osay Osc Osc Oscg Oscg oscgrm
Ofl ~ of Iproof out-of-prtnt opeque optoelectronic pu)se q wlifter operations comunicatlons optical detection and rang t ng opalescent indicating light Ofl plug operation per mtnute oil pan uperzt~on open i ng operattona 1 octal print Punch oppose Oppos 1 te opposite co-tator end opposite hand oppostte pulley end opportunity pr~nt~ng press offset
opener operate opera tor
OSP OSP OSR OSR OT OT 0T8E OTCCC 07(3 OTH OTK UTP OTR OTT OUT OUT OUT OUT 0UT80 OUTXLTR Ov Ov Ov Ovao Ovcs? OVE OV?L aw OVHO OVHG ovt4L OVLO
OVP OVPRESS
one shot wulttvibrator ofl suction pu~ operating steam pressure operat~onal scann~ng recogn$t$on output shift register of;tlght overtone operational test and qvaluation open type control clraft contacts gauge oi 1 temperature over the hortzon oil tank of true poslt!on
outer Outstde
OPT
OPT OPT OPT AX OPTAR
DP7L :: z ORO ORD ORO ORO ORUIR ORF ORG ORG ORIENT oR3G
ORIG ORIG
ORLY ORN ORN 0s as 0s 0s 0s49 os&Y Usc Osc OSCG OSCG OSCGRM
oi ) pressure operator table opens i de optional (altn abbr) optical optllm#W optical qxis optical qutomatic rang{ng optional oil ring ordnance requirements outPut register outside radius optical rotary dispersion order ordinary ordnance omn~range cf~gttal radar oefflce organ ~c organtzatfon orientation origin origtnal originator overload relay orange ornament Ofl switch one shot operating systcm otherwfse Speciffed over short qnd damage outs~de screw qnd yoke oscillate oscillator osctllat~ng osctl lograph. strtng oscf ? Iogram
OVPWR
OVRO OVRM OVRN
Ovs OVSP OVTR QW w OWAVE OWF OWGL Ows Ow Oxo Oxo 9XY 02 OZ IN P P
P P P P P P P
Ou f
0W9 I Ows Ow
P P P
trim te~late outgofng outlet output outside outboard output translator open ventilated orbiting veh!cle over overboard overcast on vehicle equipment overf low oval head overhead overhanging overhaul overload oval point overpressur \zed overpower override overarm overrun overstze overspeed overtrave 1 overvol tage outer wing ordfnary wav~ optlwm working frewenc~ obscure u~re glass support operational weather open window unit oxide ox\dtZed oxygen ounce ounce-fncn hole ipJtype sem~conductor matertal page paper [c5* form) paper (insul) period ptlaster p~ tch plate (electron devtca) plate (tube)
128
ML-STD-L2D 29 *Y 1981
ABBREtlATION
P P P P P P FRM PTOP P&&
Pam P&t
TERM
pole (cform] power probe sfngl* paper ( fnsul ) port post forming potnt-to-point vai lability prtce and q plubtng qnd deck drafn power qnd Ilghtlng power qnd Ilghttng distribution paints and 011s ptctclod qnd oiled pull qnd push plate port qnd starboard posts qnd tt-ers punch die paak to peak parallel -to-sertal peak to vall@Y nalog polar to q pad qnd boom (refueling) production (Ilustratton part of pending avaflabflfty q nplif~er p-r prsarm
P P P
P
TER,M
parallel (altn qBbr) q pproach radar prectsfon paragraph q nqltfter parametric passive rangtng doppler parentheses parkerized parametric syntttests
para~
pardop paren park parsyn part
OISTR
SEC
qnd stores
crane
Pbo
PePP p&s pat p-d P-P p-s p-v p/a p/b p/f
p/o pa pa
q ngle
arttftcial track
talker
pavt pax pb pb pb pb
pa
pa pa pa pa paadar pabx
pac pace pace
PA PA PA
Ps PIMOAR
SW
pb sta pa Sw
pbd
Pbd
pbfcl
Pbhp
pace PACM pacm p8cor pacr pad pad pad padar PADLOC
PACN
PACN
passive
pulse
q nplttude
countermeasures COde
PACOR PACR
PAO PAO
PAD PAOAR PAOWC
PANAR PAN9
PANT PnP
modulation passive correlation qnd rang t ng perimeter acquisition radar padder (capacitor) q ~lfflcr driver power propellant qctuated device passtve detectton and ranging passive deteCt tOn and location of countermeasures portable qutomatic data q ~tpment recording passtve qct$vc data si~latlon permtsstve qctton link q ctfon link prescribed q mplftude modulation pulse pulse q ~lttude modufatton frequency modulation panoramic
Pc
Pc Pc
Pc Pc Pc Pc
Pc Pc PC Pc Pc Pc PCMC
PCAt+
PCA
pca
pcb pcc
PC9 PC%
Pcc Pcc PCD PCD
pcc Pcd
Pcd
q
patent pending pattern recognttlon Interpretation and correlation pattern phase angle v01tf!J@3ter posltton and veloclty position and veloctty extraction posttion and velocfty tracking private automattc exchange painted base paper base pull box push button push button statton pull button sultch paperboard pressboard blank and form dic pierce per brake pound-force horsepower partty b{t photo butt line precision ~tng range branch exchange prtvate parts catalog personnel carrier phase coherent photocomctor p t ece pttch ctrcle plug cock of curvo point power conversion prtnted ctrcu{t program counter proposed change pulsattng current pulse compression paper stng!c cotton sfngle (insul) ptece mark packtng crating and handl!ng physical Conflguratlon qudft breaker power clrcuft printed circuft board point of conqmund curve production conqx-ess{on
capability
pantry panOPamfC
radar
pound
per
cap~ta
per
day
panb
pant pap
q
plank
q
Pm
..**.
PART
STR CRA
parv
scr
cra
* paravane
**
.-**.
and
scores
crane
129
ARllREVIATIO~
Pcf Pcr PCF PCH PcnBi3 PC?% PcHT PCI Pc x Pcl
PCL
TERM
POWCI power pulse f)unch par CUbf C foot cathoae follower to cycle fraction
ABBREVIATION
PEP PER PERC PERD PERF PERF PERF PERI PERIS PERM PERM PERMB PERM!NVAR PERP PERS PERSP PERT PES PETN PETRO PEU PF PF PF PF PF9 PFO PFbl PFM PFR PFT PG PG PG PGMT PGRF PGT pH PH PH SRZ PHAR PHARMACOL PHCV-SD PHEN P* PHI PHM
PHM pep per
TERM
plan>r ept taxial [ transistor) person percussion periodic perfect passlvated
pc ? pc f pc f pch pehbd
patchboard
punch f ng parchment pertptteral Cofmand indfcator phys~cal configuration
identification
t PC i
pc i Pc I pc 1 pm pcmd pcmf m pcn pcp pep
Pcs
pchg pch
pc t pctm pcu pd
product configuration tdentfftcation pencfl pulse code modulation PU15~ cOde ~dUlatiOn digital pulse cooe modulation frequency modu18t\on position control nutier program change proposal pulse comparator Primary Coolant System percent pulse count modulation un!t power control
pert perd perf pm f perf per i per 1s perm perm pern@ perminvar perp pers persp PERT pes petri pet ru pf pf pf pf pfb pfd pfm pfm pfr pf t P9 P9 ,. P9 Pmt pgrf
P9t pH
perforate
performed perimeter perfscope permanent permission permeability ifwarfable permeability perpendicular personne 1 perspective performance evaluation and review technf~e photoelectric scanner pentaerythryte tetranftrate petroleum polyurethane potnt of frog power factor prof i le pulse frequency preformed beam preferred power factor meter pulse frequency modulation rate part failure portable flame thrower
pressure gage
PaSSlve
d8teCtiOf7
pd
pd
SCh
pdispl pd 1 pam pdmf m par pt?r par pas pasa pdv n p* pe p, pe pe pe pe card pec pec pe j pelec pelr pen pen penal p~rad pen t pep
pitch diameter pivoted door point detonating potential d-vice potential difference power distribution prtme dr~ver pulse doppler pulse *ration paper double cotton singlo (Insul) detonating fuZ@ point photodiode puw@ d{scharge positive displacmnt parts deletion I{st pulse duration modulation pulse duratton modulation frequency modulation power directional relay priorfty data reduction program drum recording purchasing department specification point detonating self dsstroy{ng power drtven permanent echo p~nion end potential energy probable error program element pulley end production qstfmate card photoelectric cell pedestal premoided expansion jotnt photoelectric peeler penetrate pentrat~on
pwtd t ng
provtng ground pulse generator pigment pulse group repetition frequency pigtail
hydrogen-ion phase concentrattan
ph ph brz phar pharmacol phcv - sd phen phh phi phm phm phoc phof 1 phOnO phos phos photo photolfth php phP phr pnr phr phrhd phsp pht Phys phys physiol pt
and
heaa homtng
tndicator
PE
PE
PHOC PHOFL PHONO PHOS Pws PHOTO PWTOLITH PHP PHP PHR PHR PHR PHRHO
PHSP
PHT
P1-iYs P!fY s
PCNRAC
PENT PCP
penetration
pen t ode
radar power
peak
envelope
PHYSIOL PI
phase meter photocopy photoflash phonograph phosphate phosphoresce t photograph photolithographlc pound-force per horsepower propeller horsepower phrase pound-force per hour preheater pufp hydraul!c ram hand drfven phase splitter preheat physfcal physics physiological point inftfatlng
130
!vIIL-SNL12D 29 My 1981
AF?BREVIATIO~
Px PI PI
PI
ABBREVIATIO~
point tnsulatfng potnt of f-act point of intersection program interrupter programd tnstructtun bmaCOn po I qr ionosphere pulse {nterfermce blanker PLGL PLGR PLK PLKn PLL PLL PMm PLN PLNG PLNR PLNT PLNTY PLO PLOT PLQ PM PLR Pt.R PLRO PLRS PLRSTN PLRT PLS PLS PtSN PLSR PLSS PLS7C PLT PLT PLT PLT LT PLTG
PLWS
TER.M
plate glass p 1unger plank 10CkStr peacoat
pf
pt pi pt PI pib pib plbd ptc plce pie pil pilot plm p!n pin ptn pinstd pton pip pirt ptsab ptt piu piv pix pjctl pj tn pj tr pk pk pk g pk g pk t pk Wy pl
pl
pallet
phase locked 100P plutitng plane planntng p)anar planet planetary phase locked oscfl?ator plotttng p I qcwe pillar plters puller pull rod pelorus pelorus stand polarity parce fs pulse pulsation pulsator prelaunch status si~lator plastic pilot port l~ght procurement lead ttm8 pilot ttght plating ptlot housplotter pulverized polyephase p 1ywood polartze polartzed polarization tpost mertdtem) afternoon permanent magnet (speaker) phase wdulation pilot motor plaster master post merldfem (aftel-noon) pound-force per mtnute preventive maintenance pulse modulation propellant monitor and contre I pumice program mon{tor{ng qnd diagnosis photomagnetoelectric precision measuring equipment painted metal pamphlet marker generator prediction permanent manufacturing information pitch mark
pofnt
tnltiattng
base
detonating pOly8tnyl_ insulated conductor programmable integrated q qutpment control pulse Interference eltminatlon purple ind~cating light automatic pilot pulse interval modulation pinton position fnd{cator positive Intrinsfc negative (transistor) preirwert8d
p i Oneer
PIU
PIV P!x PdCTL PUTN PdTR Pu
PK PKG PUG PKT
PKWY
Pt. PL PL PL PL PL PL
pl pl pI pl pl
p] pl
pl
pl pl pt u PL/ t pla p I ads
PL8LK PLC
PLC PLCY Pm
plas plat platf plb plbd p)blk plc plc plcy pld pld
pig
PLO
PLG
L..
plant in place prectsion infrared tracking pulse interference separation and blank~ng peripheral tnput tape p?ug-in untt post indicator valw picture projectile projection projector pack peak package pack I ng pock et parkuay pad 1ock parting llne fcastfngsl parts Ifst phase line pftch ?lne p I qce platn plate plug private Ifne proparty I{ne proportional limit pluggable un~t programing language 1 programmable logic array parachute Iou qltitude delivery system pl qster platinum platform pull button p)ugboard pl~lOU block carrier power ltne prograssnable logic controller policy psy load plated p?lfng
plnty plo plot plq plr plr plr plrd plrs plrstn plrt pls pls plsn p?sr piss plstc plt plt plt plt .lt pltg p ~ths pltr plvrzd p 1yph plyvd plz plzd pizn pm v pm P pm
pm .
pm pm w pmc
pmc
psul
PMM
PMntc Pm
pulse mode multiplex permanent magnet movable coil Pw pum suction payment photo wlttplfer tube program master taPe
131
TERM
plaster mockup portabie memory unit prime mover part nu~er posttiv8 negativo (transistor) pendu I qr pneumatic pan head post t~ve-negatfvefntrlnsicpostttvc [electron dcvlce) pane 1 pennant posttfve negatfve posft~ve r trmststor) posittve-negat ive-post ttvenegatlve (electron dev~ce) paint pafmting stringer pentagon parking Orbft planetary orbit post offtce power oscillator production order purchase order polar orb~tfng geophyslc~l observatory program of ~nst~ction qnd petroleum, otls Iubrtcants polar poltstl
ABBREVIATION
PPLN PPM PPN
TERIM
p!peltne parts per mlllton perfodtc permanent magnet pulse postt{on modul.tton pulse per minute peak pulse power paper provtslontng performance schedu 1e pulses per second poppet prec~p{tate product posttfontng ttme punched paper tape page pr!nter
patr
PMVR
W PN
PNDLR Pt+Eu PM+
polyethylene
(tnsu)}
pps ppt ppt PPT ppt PPT PPT ppt PPTR pptr pr PR pr PR pr PR pr PR pr PR prac PRAC prb PR8 prbd PROO prblc PR8LC prbn t PRBNT pre PRC prc PRC prch PRCH Prcnt PRCNT prcm t PRCMT prcn PRCN prcptn PRCPTN PRCS Drcs . PRCS SPEC prcs spec
PRCSG
reverse
curve
(no
POMSEE
PON
polyester Performance Opnl qnd Matnt Standards for Electronic Eqpt +n toon WPP t n9 power operated porro
purcelatn
prcsg
PRCST PRO
Pt?E-S
prcs t
prd pre-s preanp prec pred
pref
sw
PP PP
PP
PPKG
plus or m{nus photo optical recorder tracker portable posftfon (altn qbbrl positive post tion position switcn possession potential potentiometer potable water peak operating voltage pane! po~nt piptng power plant pressureproof push PU1l parts per bfll~on provtslontng parts breakdown ptpet p~pette prenu@ulatlon processing q qu~pment ptpe plug pulse per hour pictortal pos!tton fnd!cator plan posltlon Indfcator pow~r package
PREAMP IJREC PRED PREF PREF PREf PREFAB PRGFW PREL2M PRELORTR
PREM
PRF PRFCN PRFCS PRFM PRFRO PRFT PRFT PRG PRGM PRGM RCTR
prf prfen prfcs prfm prf rd prf t prf t prg prgm prgm rgtr
push rod preshavlng prea~llfier precedence pred~ctton preference pref i x prefocused prefabricated preformd prellm?nary prectston long-range tractctng radar prem ~um preparation prepare present prescription pressure presentation equtpment for slow scan radar prev t ous preof repetttton frequewy pulse purtficatton pref ecus
performance
-.
M~L-sTD-12D 29 My 1981
AFIRREV)ATION
PRG?4G Pf?Gf4R prgmg prgmr pr f pr { pr { prin PRIS prkg pr ? prlx prm prm ;%d prmr prmtr prn prn prng prntg pro prot) prob ---proc proc procu prod prod prof prog prog proj prom prom prop prop prop prop prop propn prosfgn pro t pro t prot dev pruto prot r prov prov prouord Pprp Pm prph 1 prp 1n prpl t prprw prpsd prps 1 prr prs prsd prsd met prsr prsrz prstc prt prttc t pw
TERM
progrmmti ~ programmr prfmary priorfty pulse rate indicator prtnctpal Propeller Revolution Indicator System park { ng parallel parallax Prtme prfmfng pulse rate modulation premo 1dad
ABBREVIATION
PRv PRV
PRV PRVU Ps Ps Ps Ps Ps Ps Ps Ps Ps Ps Ps PS LT Pscu Pso Pso PSD Psf PSN PSNO
TERM
peak reverse voltage pressure reducing valve propeller revolution preview chloropicrtn passing scuttle point of switch polystyrene potentiometer syncfiro pover supply (COform) process speciftcatiofl (u/ nutier ) proof shot (projectile) pull suitch pulsa sense pulse str~tcher port stale light power supply control unit phase senstttve demodulator powr spectral densfty pulse shape discriminator pound-$orce per square foot phase shift phase-shift drfver pound-$orce per square inch protosynthex index pound-force per squaro tnctv qbsolute pound-force per square #rich gage passtve phase shfft key{ng pipe s)eevo pressure seal prism positioner pierced steel plank plow steel rope past8 pastry potnt of sptral tangent ptstol postal piston pouer supply unit
prtserve
PRI
PR1
PR I PRIN PRIS
PRKG PRL PRLX PRM PRM PRM PRMLD PRUR PRM7R PRN PRt4 PRNG PRNTG PRO PROB PR08 PROC Puoc PROC PROCU
PROO
ps
Ps
ps
ps ps ps ps lt psa
primer
parameter pseudo-random notse pulse ranging navlgatton purging printing propeller order probab I q prob 1em procur~t faltn qbbr) pr~rc proceedings processing unit procwct production professional progress progression project progrmmmble read-only ~ry pro~te propelled propeller propelling property preprfetor proportion procedure sign protect protective protect~ve devtce prototype protractor provide provision proc~re uord putse repetition period purp Iq purpuse peripheral propulsion propellant
psd
psd psd psf psfl psM
ps f
PSI
Ps I PSXA
psi
psta
PSIG PSIV
PSK
pslg pstv psk ps 1 ps 1 psal psnr psp psr pst pst ps t pstl pstl pstn psu psv psvt psvtn psvtv psu psubd pt pt $ pt pt pt pt pt pt pt ptc
PROD PROF
PROG PROG
PSL PSL PSM qSNR PSP PSR PST Pst PST PstL PSTL
PS7N
PROTO PRoTR PROV PROV PROWORO PRP PRP PRP PRPHL PRPLN PRPLT PRPNE P~PSD
PHPSL
part
pint pipe tap ttc tube P~ point potnt of tangency potentfal transformer print pulse time punched tape positive tenq3erature coefficient pro tec t pa~nted
propane proposed
proposa I pulse repetition rate press prmssed mtal pressed presser pr~ssurfze prosthetic pulse repetition tfme parts t(tt Peak ~nversc (reverse) voltage
PT PT ;:
PTC
PRR PRS
PRSO
PTCT
PTO P7D PTFE
printed
polytetraf pstrol p(ntle partly pulso time luoroethy)ene
PRSTC PRT
-. PRTKT PRV
I Pm
mocWlat{on
133
KXL-STD-12D
29 ?~y 1981
TERM
PTML PTUTLG PTWX PTN PTO PTOUT PTR
PTML ptmtlg
ABBREVIATION
Qnvc 08 Qc qavc * Qc w qc f qcl OCR qdlsc qdr qdrn qdrtr v
TER.M
quiet automatic volucontrol qutck break quality control qufck cleaning qualtty conformance inspection quality characterlst{cs llst quality control reliability quick disconnect quality def~c!ency report quadrant quxlrsture Waltty evaluation q ngine changa ~ictc qtck ftrtng quick fix interference reduction Capabllfty qJ8ntized gate video ~ick quick took quick look tntWmediat8 tap8 quadrature modulation ~tek make, ~ick break quenched quick opentng dev{ce qualtfie procWcts list ~anttzeu pulse position -ire Wick react!on qlert quick reaction capability quasi-ranclom code generator quarry WadfUPIW therwuplastlc ( insul ) qu?rt quarry tit. quarry ttle quarry tile *arter quarters quanttty ~artz quadrant (a
pnpn transistor magnettc logic pf tometer log pulse-time multiplex parti tion power takeoff printout PaP8r tape reader position track radar printer processor tape read pneumattc test set propellant transfer system push to talk preclsc tfme qnd time tntorval wave photo type traveIi~
QC
QCI QCL
QCR
QD:SC
ODR QORNT
qf qf i rc q9f qik ql qltt w qnch qod ml WP qr qra qre qrcg qry qt qt qtb qtf qt r qtr qtrs qty qtz ---quad quadr qua I qua 1 qua I quant q,iaser
tube
Pm w w Pu PUAR
party
pv t pv t
pv t
pertp-ral unit Ico*utors) pickup power unit q c~lsltlon radar pulse qbbr) pUbltCat{On (altn publication programmable untjunction transistor pulley pulverizer purlficr purchase p,lan view pressure vessel polyvlnyl chloride preservation mthod pr~vont preciston vhf omni range pru~sion voltage referencm pivot pressure VOIUWS8 t~erature
QPL
QPP QR QUA QRC QRCG QRY QT Q7 QTB Q7f
bask
floor roe f
private
passing window pflot wire ptvoted Window pla~n washer prtnted wiring projected window pulse width q ssmly printed-wtrlng prtnted w{rtng board process water cooler pulse width coded -Or pulse width discriminator powder passing qncoder PUISQ width proxtm{ty uarn~ng {ndicator pulse width modulation power power supply poverhouso pewter pure water phototranst stor pyrogen untt pyramt d pyrotechnic pyrumeter drone (aircr8ft) qnd qnswer question qssurance quality q cting qutck
pw P pw pw pw pwa pwb
tn
qbbr)
quadrangle quadrup I q
quailftcatlon qualitative quality quantitative ~antum a~liftcation by Sttsmlated emission of radiat{on quaternary quest ion quiescent quintuple quotation quottent quality ver{ficatfon testing qbbr) radtus (altn qbbr) r8d faltn radar [comm form) raft ratio reconnaissance (aircraftl resistance (comb form) r+ght ring r f ser rubber ( insul I rubber sheath
QUAT
QUEST
r r r R r r r r r
134
ABBREVIATION
new nil o R&P R&R R4T R-W R/R R/W R& R& RA RA R& LT RAACT RAB RAC RACON RACY RAO RAD RAD RAO HAZ RAO INSP RAD OPR RADAL RADAR RAOAS RAOAT RAOAY RAOCW RAOCM RADCDN RADOEF RAO(!M RAOIAC RAOINT RAO!ST
RADL ltAOMDN RAON RAOOP
TER iW
recmced
charge research and development rules and proc-ros qnd rep)ace remove research qnd technology urite (head) read qnd relay readout rtght of way radar altlmeter rayon f insul I q npltfter read reductton of qrea range 1 Ight radtoacti Ve rabbet q ct~on change rapid radzr beacon q cttng reverse radiate radio radius radiation hazarQ radiographic ~nSpeCtiOn radio operator rad~o detection and locatlon d8teCtfOn qti ra~l%l rad~o
random qccess
ABBREVIATION
RAR RAs RASER
TE R IV
recor~ qnd replenishment radio freq stlwlated
rad!ation
r chg
R80 rfip r8 r RBT r-w r/r r/w ra ra ra ra Pa It raact rab rac racon rac t rad r aa rad rad haz rad insp rad opr rada 1 radar raaas
rar
ras rasar
report
q ~llftcat~on
emlsston
qt
sma
DY af
RASTAC RAT RATAN RATE RATO RAVE RAVEN RAWIN RAUINDS RAYOIST RAZEL RAZON R8 RS RB RB RBOT RBOE RSE
rastac vat ra tan rate RATO rave raven raw t n raw t nds raydtst razel razon rb rb rb f-b rbb t rtlde rbe rbk rbn rbr rbs f-c rc rc rc rc E rc ac rcc rcc rccp rcd rcd ?cdg
random qccess storage qnd control ra taau radar qnd television q fd to navtgat!on remote automatic telemetry equ I pment rocket-assisted takeoff q cquisition visual radar
tracking equipment
ranging qnd veloclty navigation radar wind radar w~nd sounding ray path distance
range range
qnd
rubber
base
discrete system
radar Oata transmission radio day radfo chemistry countcrmeaswes radar deception
qnd
radar
data
converter
rad i ac radfnt
radfst
radl radmon radn ratfop radot radvs RAOVAR rafar
rafax
radiological defense delta random acc8ss modulation radiation detection qnd coqutatlon indicating radar intelligence radar distance Indicator radiological radiological monitoring radiat+on radaroptica 1 dig~tal real ttme qutomatic optical tracker radar altimeter and doppler velocity sensor radiological warfare qutomatic facsimile radio qnd repr-ctfon radar facsfmtle transmission random access and tnqu~f=y random-access $ndestructive
rebabbit radar brfgftt dlsPlaY equtpment relative biological effectiveness bank right radio beacon r i bbon
rubber
redar
bo!m~ng
score
Cp)d
advanced
nwmory
RCO RCO WDG RCDR RCG RCNT RCI RCL RCL RCLO RCLMG RCLS RCM RCMPRS RCN RCNOT RCNTR RCO RCO RCGNT RCP
rcdr
rcg rch t rc t rc 1 rc I relet rcimg rcls RCM rc~rs rcn
range correction rate of change reactor c~artment rear con~tton reinforced concrete remote control Yesfstance capacitance . -esolver control resistance capacitance coup 1ed reader common contact rubber covered cable eu)vert reinforced concrete p!pe record reverse current device eecordlng recorder reverberation control of
gain ratchet Fadar
RAM RAM
R-
random-access
hemory
...
RAPCON RAR
rapid qrea maintenance qmeter recording qnd not corrected real data Input random coftmunicatlons satal)~te q ngle order rudder programntng random qccess equipment and checkout q pproach control radar qcoustic ranging radio
rend t
rcntr rco rco rcont Pcp
coverage i~dfcator reca I 1 recoi i ?ecl Ined reclaiming recol I less radar countermeasures recowqress ton recreation recondition rfng cwnter reactor core remote contrnl oscillator rod contrel reinforced concrete pipe
135
KIL-STD-12D 29 my 1981
AB$?REVi ATION
rcp
TERM rfght
receipt circular Polar lzatlon
ABBREVIATION
RECALC RECO RECHRG RECXP RECIRC RECL RECM RECOG RECDN RECONO RECP RECT iiECT RECT RECY
RED REDAP REDSG REDWN REF reca
TERM
recalculated
received (altn qbbr) recharger rec$procati ng recirculate reclosing recomwend recogni tton reconnaissance recondense qbbr) receptacle (altn rectangle rectangular rectifier recoverabil ity red reentrant data processing redesignate redr qwn refer fwferenc. refinery reference designation raferenc8 line reflectance reflector reflected refrigerate refr~gerator refrigerated qbbr) register (altn qbbr) r=gular (altn qbbr) regulate (altn qbbr) regulator (altn range and evaluation pproach qnd ~idance for q landing regenerate regenerat ive request for engineering information re i mmurse retnforce reject qbbr) release [altn relative rescue ~ipment locker reliability relocated rema i noer remov qb 1q q ~lvalent mafmnal roentgen
rep t
RCPTM
----
Ic
RCS
Rcs RC$ RCT
rcp t rcptn RCS Rcs RCS rc t RCTL rctn rcur rcv rcvd rcvg rcvr rcvy ---rd rd rd rd rd rd rd rd rd rdc v Cjc rdcn
receptacl@
reception rwact ton control reentry control Rewrote Control
resolver control
system system
System transfornnw
Ro RO RU R9 RO Ro RO RD RD RD RDC RDC RDCN RDCR ROUR RGF RDF RDG ROG RDG RU I ROL ROM RDMI RONG ROMS RmuT ROR RUR ROR XMTR ROS/M
reststor capac~tor transistor logtc reaction recurrent rece t ve received receiving rec. I vor recuvery qbbr) round (altn radar data radfatton detection random drtft read register drtve read roof drain root dlamater rotodollw racliac race tton rwc reducer rod drtve radar dfrection finding radto d{rectton ftndtng resolver differential gewra tor ridge round t ng roundhead radio dopplw Inertial radia) recordtng demand meter range drift measuring unit readfng readfness
REF REf REF DES RCFL REFL R~FL REFLO REFR RCFR REFRD REG REG REG REG
RCGAL
ructwg rectp rec I rc rec I recm recog recon reeond ---rec t rect rec t recy red redap redsg redun re f ref re f ref dms ref 1 ref 1 ref 1 ref 1d refr refr re f rd -------------rega 1
--
REGEN REGEN RE I REIMU REINF REU REL REL REL RGLEL RELOC REM REM REM REM COV RtMAO Rmc RCD REORf3 Rt? RCP REP RCP8 REPL REPPAC REPRO REPRO RSPRO RKQ
regen
regen ret retre i nf re j ----
ROTb~
RDTR @ox ROY RE RE REAC REAC RCAC REACTVT READ RCASM RE~ssEM REASSY RE8E REC
rdou t rdr rdr rdr xmtr rd~lm rdtl%e rdtr rdx rdy rs re reac reac reac rose tv t reaa ---reassem
reassy
readout radar reaar radar transmitter Founds por m~nute research developfmmt
qnd
r. I
re 1 reIbl re 1oc rem rem
test
evaluation
rem
rem cov reread rreo meorg rep rep rep repb rep reppac repro repro repro r qq
mc
Rcc mc Mccli
echo q ugmentation dev ~ce reass~le (altn abbr) reasse-le reassentlly recovery beacon evaluation racess recessed request for engineering change recui I mchanism radar
anomaly fnlca
emfsston
capacitor
regenerated q }ectrlcal output reorganize range error probabil!tv represent q quivalent physical reentgen republic rep I qce repetftivaly pulsed PJas~ q ccelerator reproduce reproduc!bl q reproduction request
136
MIL-STD-12D 29 My 1981
AllRREf1/fllON
Rco REQO REON RCQT RERL RES RES RES @CS fLD RESC RESEAT RESIO RESIL RESN RESN RESOLN RCSP RCSP RESTR RESUP RET RETM RETP RETR RETR RETR RETRO RETRO RETROG REV REV REV REV REV CUR REVEL RWDCON REUK REY RF Rf RF RF WA RFC RfCR RFD RFG RFG RFGT Rfti RF I RF I RF L RFLX RFM itFNA mfNo RfP RfRC RFS RfU RfW RG x RG RG RGINI req reqd
require
TERNI re~ tred requ~ sit ion requ t rement resf dual equivalent return loss r8s~arch res 1stance resistor rest-al fteld rest i nd reseating res i-a I resi 1 {ent resonant resonate resolution respccttvaly respons~bl q restorer resupply retain retenslon retape ret race retract retractable retroactive qetrogradm retrogress Ive rev i ew rev t se r~vfsion revolution reverse current reverberation elimination rewrote volume control rework reentry frequency radio raised face range finder rapid fire radio frequency ~ltfter radio frc~8ncy choke ref qcw rafsed face diameter receive format generator roof tng refrigerant raised face height radio frm~ency interfe~enco ready for issue refuel ref lex reactivo factor mater red fuming nttric qctd ref ined request for proposal refractory
regardless of feature size
ARBREVIATIO~
RGL RGLR RGLTO RGLTR RGN RGNG RGT
TERtV regui qte regular regulated regulator region r~gging resonant gate transistor register relatlve humidtty hand right Rockwell hardness right hand drive rhodtum plate rat Ihead return head rheostat radar height indicator range hd!!i@t Indicator rubber hose jack~t reefing hook rhod f urn
rgn rgng
rg t rgtr rh r-h Rh rh dr rh p! rhd rheo rh i rh 1 rhj rhk rhod rhorhorhp rhr rhr rhs rl rl rl ri rt rib rfc rid
res id
r~si 1
resn
r8sn resoln resp resp restr resup ret ret nn rw tp retr retr retr ret ro
RG7R RH RH RH RHOR RH Pt. RHO RHD RHEO RHI RHI RHU RFOC R~O RHOMt? RHOMO RttP RHR RHR RHS R! RI RI RI RI R18 RIC RIO RIO RIFI RIL RIL RIM RIM RIN
rho-
ic
rld rlfl
rll rll rim rim rtn ring rinsul rint r(nt rtometer riot r$p RIS riv riv rje rack rkr
*ra
r~o td reduced hard pressure reheater roughness he~ght rating right hand side radar tnput range Inst rumentatlon reflective ~nsulatton r8qUlre tdentlflcat~on routing ind{cator ribbed radar fnput control radar input drum reset inhtblt drum radfo ~nterference f!eld intensity radto interference Iewl red tndfcating laradar ~nput mapper radiant Intensity measurement radio inertial ringer rubber insulation radar Intermittent radiation intelligence relative ionospheric opacity meter
RING
R:NSUL RINT RINT RIOMETER RIOT
RIP
real
tlms
tnput
output
rflx
rfls r~na rfnd rfp . rfrc rfs rfw rfw rg rg rg rg rg rgl n I rgd rgh
RIS RIV RIV RdE RK RKR RKRA RK7 RKVAN RL RL RL RL nLAOO RLC RLCR
transducer radar identification point Revolution Indlcattng system radio lnf}uence vo)tage river remote job entry rack
rock ~
rocker qrm rock q t recorcl~ng ktlovolt-a~re meter rail (altn abbr) resistance inductance rOCket launcher roof leader ngle drogue radar low q delivery
resistance lncWctancQ capacitance rai lcar
rlcr
137
..
ABBREVIATION
RLD RLO RLF RLG RLR RLR ERG RLS RLSE RLT RLTN RLV RLXf4 RLY RM RM RN RM RMAX RMGF RW RM1
RMJ RMLR RW RNR RMS RMS RMT nw RN RN RNO RNOM RMF RNG RNGG RNL RNLT RNR RNV RNWBL Ro RO RO RO RQ \ RO Roe ROC ROC
TERM
radar
ABBRJ?Vl,fTION
RPC RPC RPD
TERNI
remote position control remote power control radar planning deVIC@ renewal parts data reproducer radiometer p&2rfOrManCe
rld f-la
rlf rlg
Iaydown
deltvery
rolled
reIfef
ratting brg
roller roller radar baar{ng line of
factor
PPG
RP 1 RPL RPLNG RPLR RPLSN RPLT RPM RPM RPMC RPNSM
report
program
generator
rpi rpl
rplng rplr rp 1sn rplt rpm
rpm rpe
raear preclpttation
integrator renewal parts leaflet replenishing repel ler repulsion repel lent performance remote moni tor!ng Pevo!utions per mtnute remote performance monitoring qnd control replen~stment remote plan position tndtcator request for price quotatton read printer repa I c report revolutions per second rotating passing scuttle rep. a t repeating co~ 1 repetition repeater rust preventive radar quality control rai lroad rapid rectll~near recurrence rate rellef raciti rev{ston record roll roofing range rate indicator rate of rise of recovery vol tage radiated susceptibility range selsctor range surve!l lance ready service reverberation strength side right StOn@ ~bble receipt stowage and Issue running signal and qnchor 1 tgnts
rmas rmgf
rm i rmj rmlr ~ rmr rms rms rmt rmv rn rn rncl rndm rnf rng rngg rn 1 rnlt rnr f-nv rnwb 1
re
range marks raw material remedial maintenance room range maxinum radar mapper, gap ffller refrigerator mechanical househo I d radio magnet{c tndicator ramjet long range radar mapper, radar map matching reamer root mean square square root of mean square remote Wwkve radio navigation reference noise round random radio noise factor (f{gure) range
RPPI RPQ RPR RPR RPRT RPS RPS RPT RPTC RPTN RPTR RPVNTV RQC RR RR RR RR RR RR RR I RRRV RS Rs Rs Rs RS RS Rs RS& I RSALT RSO RSO RSI RSIM
RsL RSLVR RSN RsP RSP RSPU RSPS RSPTR RsPV RSQ RSQEiT
rpnsm rpp i rpq rpr rpr rpr t rps rps rpt . rptc rptn rptr rpvntv rqc rr rr rr rr rr rr rr ! rrrv rs rs rs rs
ringing
renews
ROE ROFT ROH ROU ROM ROOT ROT ROT MY r ROTI ROTOMT ROTR ROTR ROT S ROUT R? RP RPA
rp
rp
rpa
running light runner radio noise voltage renewab I e radar operator recetv~ only rough opening runou t rollon/rolloff radar out of battle rece~ver operating Characterlsttcs required for operational capabi ! ity reflector orbital equipment radar off target regular overhaul range on janan+ng read only nwmory oscillator relaxation opt{cally tuned radar on target reserve otl tank rotate recordfng optical tracking instrument rotometer only tape perforator receive rotator rang. on target s~gna\ rout t ne reference pulse reviston proposal radar performance analyzer
rs
rs rs rs5 1 rsalt rsd rsd rs i
rstm
ra i sed
roll]ng steel door reflected Stgnal Indicator radar Stwulator reconnaissance and security line reselver reason render safe prc7CedUre
respwnder beacon
respond response respirator respective rescue rescue boat root sum square radar start
RSS RSt
138
ARBREVIATION
RST RST RST RSTG RSTPF RS7R RSV RSVR RT RT RT RT RT UT RT RT RTANG RTC RTCL RTCU RTD RTD RTO R70C RTDD RTOD RTOOC RTE RTEL RTEM RTF RTG RTIP RTL RTL RTL RTLG RTM RTM RTM RTM RTN RTNG RTNR RTOT RtPH RTR RTRSW RTRV RTRY RTT R7T RTTL RTTL RTTV RTTY RTV RTWS Rti RU Rus Ruo Russ RV rst rs t rs t
TERM
retnforcfng steel reset-set trtgger restore roast 1 ng rustproof restrict reserve reservo fr r=dar trigger rad$o telephone rainttgnt range tracking rate real tfme racetver transmitter rocket target q gle right reader tape contact rettcle real time control ufllt range time decoder resistance tewerature
ABBREVIATION
RV RV
rv rv
TERM
rear view reentry vehfcle relief valve reactive volta~ere meter recording varmeter rotary variable differential transfornu?r revolvtn~ revolve
react~ve voltmeter
rstg
rstpf rstr
rsv rsvr
RV RVA RVARM RVOT RVLG RVLV RVM RVP RVR RVS RVSBL RVT RVTD RW RWC RWC RWG RWHO RWUO RWY RX RY RYN Rz RZL RZM s s s
s s : s s SMi
m
rv
RUG
rwhd rwnd rx
f-y ryn rz rz 1 rzm ---s s s s ;
s
detector
retard retardation coil real ttme data dtstrlbution remote timing and data utstribution data real tim d{g~tal correction route radio telephony radar tracking error measurement ~r til#loor rattng radar target identification point radar threshold limit ~~inforced tile Ilntel reststor transistor logic Padio telegraph radar target material rapid tuning magnetron receiver transmitter modulator recording tachometer . M turn retaining rota i ner range track on target round trips per hour rotor rotary swttch retrieve rotary rsdtation traciclng transducer ra~io teletype rattail runntng telltale light real time television raaio teletypewriter reentry test vchtcle raw tape write sutmodule range user reproducing unit rubber (altn abbr) rudder
reid vapor pressure runway visual range reverse reversible rivet riveted raw water ratrtuater conductor read write co~ute Roebl\ng Wire Gage rawhide rev i nd runway resolver transmitter rai lway rayon rwturn to zero return to zero level mark return to zero qbbr) slate (altn
scuttle Second
LT
saP ;/:
S/T
It
(come form) silk ( insul ) single silk (insull Sof t ce source (electron *V south Side signal and homing light stake qnd platform strtp tin send qnd receive search/track surfaced or dressed one surfaced
side surfaced
or dressed
side
one tvo
s ides or dressed four surfaced sides sail area sense aaplifier shaft alley small qrms spectrum analyzer stress qnneal arms qmmnft ion small q -lifter blocklng sense oscillator bo~tng secure qirborne radar ~ipment sprayed acoustical ceillng semiautomatic checkout equipnwmt q nalog to digftal scanning input equipment special atomic demolition nunitfon safety semfautematfc ground environment height finder semiautomatic
rtrsw
rtrv rtry rtt rtt rttl rttl rttv rtty rtv r tws ?-U ru ---rud russ rv
sa
SAC
SACE
SADIE SADM SAF SAGE
russet rated
voltage
SAW
--
139
A@SREY 1ATION
SAL
SAL SAL SAL SALV SAM Sa 1 5* I Sa 1 Sa I Salv
sam
TERM
salinfty sal ino~ter saluting shipboard ql loumcs 1 ist salvage selectlve qutomatic monitoring surface to q ir mtsslle q -l itude synchronous modulation sandu I eh sanitary semiarmor pfercfng Suspended qcoustical plaster calling saponify storage qddress register radar Stmlated q ircraft data saturate satellite active null tffer suspended qcoustical tflc ceillng satisfactory satellite tape satelltte paper transfers secondary battery Serfal binary sertal block service bulletfn s i deband silver braze braztng silver sleeve bearing smoeth bore blower spin block splash block Stove bolt stuffing box synchronization bft pproach standard beam q single beam klystron submersible semiconwctor Bilateral Swt tch base sol{d propellant single substrate surface barrier transistor sflver braztng union steel bas~nt window S Band transponder saturable core sca 1e shaft center charge shaped signal conditioner single contact smooth contour solar cell spacecraft small caliber anmunftfon subcarrfer authorization scatter detection qnd rmg t ng scannfng loual oscillator antenna scan q uxllfary sflmt compact povw
ABRREVIATION
SCARF
SCAT SCAT SCAT
TERM
IOokfng coherent q ll range focused sequential eonponent automat~c testtng space communications qnd tracktng surface controlled qvalanche transistor scavenge single conductor cable sfngle cotton covered (insul) door screen specfflcat~on control draw i ng steel cadmium plated screwdriver sfgnal condlttonlng equipment
side
scat
seav Scc Scc scd Scd Scalp Scdr sce sce Sc f
sch sched Schem Scf11 t se i scfnt sc 1er SCly
Sm
sam sam
san San sap s qpc sspon sar sard
SCAV Scc Scc SCD Sco SCDP SCOR SCE SCE SCF :%0 SCHEM
SCHLT
sat
satan sate Satfy satl satpatt sb Sb sb sb sb sb S8 sb sb sb sb Sb sb sb sb sb Sba sbk sbm S8S Sbsp sbstr set sbu Sbu Sox Sc Sc Sc Sc Sc Sc se Sc se sca SCA scadar sca I o scsn scap
source
satellite control socket head sch1e schemattc Searchl tght sc f ence Setntfllator scleroscope scul Iery faciltty
SCI SCINT
SCLER SCLY Scnm SCN
SCNA
Scmod
scn scna Scng scnr scntn Sco scoda scent scope score Scou SCOUT
scale
mode!
solid soot
body
Scp
scr
SCR
scr scr
scrdb scrdn scrn
gt
scrterm
scrthd
Scs
Scs
Scs scsh scsm Scss Sc t sctd sctr sctr Scty
specification change notice sudden cosmic noise q bsorption scmn i ng scanner self contained subcarrfe~ oscillator scan coherent dopple~ attachment ship control osci I loscope satellfte cowputer operated readiness e~ipment shtp course oxfde surface controlled unlpolar transistor sphertcal candlepower screw semiconductor controlled rectifier short circuit ratto screen gate screwed bonnet screw down screen screw terminal screw thread semiconductor controlled Swf tch single channel st~lex stabflfzatlon and control systems structural carbon steel hard structural carbon steel mad i urn carbon steel soft structural structural clay tfle
140
MIL-STD-121) 29 my 1981
AFl13RE\1/fTION
Scu Scu
TERM
scanner control uni t singlo conditioning unft self contatned underwater q pparatUS breath{ng scupper sfngle cyl{nder saf~ty destructor sa~le aata sel~ destroying shell destreylng dra~n shower drawn soft spectral distribution standard deviation sweep driver sand blast source data automation data converter signal dtsplay convsrter situst~on st~lex data dlstrtbutlon unit soda fountain siding siwlated data gene~ator display generator situation swet dough ship distance Shtp Draft Indlcattng System shtp draft fndtcator transmitter saddle down ak step up step sender sounder stnulated data tape slowed down video single end special equtpment support equ~pment system engineering secant second secor~dary secret hyperbolic secant sequential codfng sequential collat~on of range Secur t ng section sedan steam engine d rec t connected
SEOPSN SEP SEP
TERM seopsn sap 58P Sep sap Seq select operate separate separator Sept-er star epltaxial sequence sequence check sense
Scu s Cu SCUBA Scup Scy 1 Sd se Sd sd Sd Sd sd Sd se sd bl sda sdc Sec Sddu sdf tn sdg sdg Sdg sdgh Sd!s
SDIS
SEP
SEP SEQ SEQ CHK SER SER SERG SERNO SERR SERR SERV SERVO SESAME
planar
SDA X SDOU
SDF7N SDG SDG SDG SDGH SDIS
Sf
Sf Sf Sf Sfa sfb Sfc sfdr Sfgd Sfts Sfo Sfo sfprf Sfsct Sft sft qxt sftr sfxd Sg Sg Sg Sg Sgb Sgd Sgde Sg 1 Sgm Sgsfu Sgsp Sgsub Sgw sh Sh Sh sh sh
SDIS
SDIT SOL SON
Su
Su
SOR SDR
SDT SDV SE SE St! SE S&c
Sdv se :: se Sec sec Sec see sech Seco secor secrg sect sed sedc
SF SFA SFB SFC SFOR SFGO SFLS Sfo SFO SFPRF SFSC7 SFT sf7 gx7 SFTR SFXO SG SG SG SG SG8 SGO SGOE SGL :%FU SGSP SGSU8 SGW SH Si-1 SH SH St+ WI SH
clay
tflo shaf t
shaft extension shlpfttter Semtf{xed sawtooth generator single groove (tnsul) structural glass swam glider swi tchgear block signed gear dual q mergency steering sfngle spark gap modulation salt glazed structural facing units single groove single petticoat (insul) salt glazed structural un{t base guard window security sc!eroscope hardness shack I e share sheet sheeting shteld (electron device) shower shunt shower and toilet shock absorber shot blast shore connection shunt tr~p
seg seg se j se I SEL sel SEL se I SEL sel rgtr SEL RGTR selcal SELCAL self cal SELF CAL SELF Ct. self cl SELF PROP self prop sels SELS so I syn SELSYN SEM SEM SEMICONO semi cond sen SEN SEN sen sens SENS SENS sens
sea)tng
segment on joint slidtng qxpans select selectivity selector reg~ster select sol~ctive call{ng Self calibrating self clostng salf propelled solsyn self synchronous scann$ng electron mfcroscove semiconductor sefnlenclosed sense Sensttive
SH SH67
SH Aes SH BL
SH stl sn
sh~t sh abs sh bl sh corm sh tr
sensltivtty
SH COHN WI TR
141
MXL-STS)-12P .-
~? ?My 19&l
AB13REVlAT10~
SN9LDR
SWP SHF mr sHfTGR SHIRAN
TERM
shipbuilder
ABBREVIATION
SIR SIM SXNCON sim slm s i mcom
TERM
s!mt )ar Stwulator conptler sfmulator mage stnultaneous nultlpla corr81atton spectftc ifqulso . Stne stgnal plus nolso qnd distortion hyperbol~c sine Shfp Inertial Navigational System satelltte {nformatton procedure eperattonal program stgnal to interference ratio satelllte interceptor system standard Instruction set sttuation search ~nformatfun tape qqu f preen t stdevtnder slip joint Stnk sketch sk i nned sk ! nner stat$on keeping Itghts sktllea skirted sktrt socket saf8 locker loaded sand sea level slide slidtng spacecraft Iem adapter side looking afrborne radar small lightweight altltude transmission equipment side lobe blanktng s~gnal lfght barU soluble sea launched 13alllstic missile stale lobe cancellation s! tce ssaled Slidtng door s 1Oudowll so 1 der straight-line frequency self cleantng self generating self indtcattng self locking self sealtng selt tapptng s 1udge slug slinger s 1op9 sea loadlng pipelfne side looktng radar sea level static side lobe suppression slow speed self Ioading tape skyl ight slate SItt
Shbldr Sfwr Shep shf snf Shf tgr shlran Shk shock shl shl shld shld
shtppfng
solar partfcles shtft super htgh fre~Y shaft gear accuracy S band hfgh
SIMICOR
SINP SIN SINAD SI?W SINS s! POP
rang$ng
SW
and navigation
SHL
SHL
SHLo SNLD
sFtmR SHLN
S-R Sm
SNOOOP
WORM SWRT
navigation short ctrcutt shaft horsep-=r shape shipboard shfp class sht~$~
shakeproof
dopp)er
SIR SIS S1S SIT SITC S IWOR %J SK SX 9X SK SK LT SKD SKO SK7 SKT SL SL SL St. SL SLA SLAR SLATE SLB SLB SL8L SLEM SLC SLC SLD SLD SLO St,DR SLF SLFCLN SLFGEN SLFINO SLFLKG SLFSE
SLFTPG SLG SLQ SLCR SLP SLPL SLR SLS SLS SLSP SLT ST SLT SL7
s?iPRf SNPT SHRAP SNRD SNRof SHROR ~RNG SNRP SH9TS SW SNTDN SNTC SNTG SNTL SHTR SNTSO SHV SK SI SI SI S1 LT SIA SIAM SIB SIR SID SID SIF SIF SIF SIG SIGINT SIL SXL SIL SZL PL SXLG s:=
shipment shrapm I shroud shroud fin shredder shearing sharpener status ship
d d
short
Stmlt down short time constant shortag* sheatnlng shuttle shutter short Stale sheave International System of Unt ts salfnlty indteator standing lnstruct~on System% International dllnttes side light q pproach standard lnstrumnt fnforw?atton qnd slgnaI monitoring standard tron bar seal tn device standard Instrument departure sudden Ionospheric disturbance selecttve tdentfficat~on feature face Singlo sound {nt@rmedlate frequency signal signal tnte!lfgence silmtcm silver speech interf~renco level sflver plat8 sflencing SilV8r soldor
SIC Slc Sld Sld sld sldr Slf slfcln slfgen slfind slflkg slfse Slftpg Slg Slg slgr Slp Slpl Slr Sls Sls Slsp Slt Slt Slt sIt
142
MIL-STD-12D 29 ?kY1981
q
AIU?REVIATION
=T SLT SLTD SLV SLV SLVG SLVT SLW SLWL $LY P SM SM S?4 SM SM ~ACN SMEK SMF Sm SMK GEN SMKLS SMLS :2 SMP SNPHR SMPLG Sns SMSA SMT SMTK SWT Snv SN SN Srf SN Su SNOR SNO SNDG SIWG SNDPRF SNF Sw SNI StUL SNL SNM SNo
SNR SNR SNSL SNSR SNTR SNTR SNT 20 SNTZG SNY
TERM
spectal launch trajectory Spotl tgnt slotted satelllte launching veh!cle sleeve sleevtng so I vent store logtcal word Stratqht Ilna wavelength short-leaf yellOW ptn~ service module sma 11 smooth
smoothfng
AIIFIREV1ATION
SODAR SOFAR SOI SOL SOL SOL HGT SOLB SOLN SOLO SOLV
SOM SOM-H
TERM
sound detect ton qnd
sound fixtng r8ngtng
Slt Slt sltd Slv Slv Stvg Slvt Slw Slwl Slyp sm sfn sm
sm Sm
sodar sofar so f sol sol sol hgt solb soln solo Solv Sofn sore-h
sore- 1
space obJect solenoid solfd solid hefght start of ltne block solution selecttve optical I=k-on
solenoid
valve
Smplg sms smsa smt Smtk Smut smy sn sn sn sn sn Snbr snd Sndg sndg
sndprf
strategic mfsslle sounding machinm submartne mine depot summary message enable keyboard magnetic ftelcl selar smoke smoke generator smokeless seamless smooth neck sensfttzed materfal pr nt sound motfon picture semaphore sa~l fng sfl~co-manganese steel shop mtssfle ass~ly qnd maintenance square mesh tracking SW tank shrink mockup tewplate surmnary sewlce note signal to nofse sfne of the anplitude
precedence
SOUQ sonac sonar Sonb SONCM80 Soncr Sonosw sop sor sorte sort 1 start of message prlorlty sonar nace!le (sonacelle) sound nav{gatton qnd ranging sonobuoy sonar countermeasures and deceptton sonar control room sonosui tch scavenging 011 PUT specific operational
requirement t sunmry
SOR
SORTE SORT I SOS7EL
of
tolerant
rad~ation electronics
SOsus
SOSTEL
Sosus
Sov sow Sp Sp Sp Sp Sp Sp Sp Sp
Sp
Sov sow SP SP SP SP SP SP SP 5P SP SP SP SP
SP
orbftal track and intercept solid state electon~c logic sound and surveillance system shutoff valve start of word one pole
saqle part Sequential phase shear plate short perslstmce single pole powder smokeless soil pipe space spare spare part spectal (co~ form) special (projectflel special purpose specific speed splashproof splitting Spoo 1 standp~pe specific gravity Spec?f!C heat speed light spl~t phase single pole swttch specfffc volume S faand power anpllfler sudden phase anomaly space co-ntcatfons appruach super prectston
satelllte
SP SP
SP SP 5P SP SP SP GR SP W SP LT SP PH SP Sw $P VOL SPA SPA SPACECOM
so so ;:
SOAR Scc Soc SoCl) SOCN
SPAR
SPAR
radar
~Ynchronms
pOSf tlon qttitude recorder s!licon precision alloy transistor specla? co-n lpro]ectf!e)
stJspended plaster
ceiling
143
s
AHRRE$ IATION
$PCAT SPCC SPCHG SPCL SPCLN SPCONV SPCR SPCTG SPOL SPDOM SPDR SPOS SPOT SPDT Sw
SPE SPEC
TER,M
special category sia~p parts control center supercharge spec f q 1 clean~ng spectal speed converter spacer spherical Cartrfdge spindle speedometer sp { der data sheet safe practice throw s~ngle pole double Oouble throu s{ng)e pole SW! tcrl stored program element Speclffcation spec i men stgnal processing ~n evaluated electronic dev 1Ces single pedestal desk. flat-top spool tng space heater spherical s t phml spark sp$ke speaker special (altn abbr) separate parts ltst single propellant loadlng spfral special weapons splice spline splftter strfplex Supp 1y shots per mfnute strokes per minute spanner suspension st}ll p$cture projector spark plug sense printer silicon power recttffer spring sprinkler
Spreader
AFIBREVIATIO~
Sa SQ CM SQ FT SQ IN SO KM SOCC2 SOH SON SORT sow SQZGR Sn SR SR SR SR SR SR SR ;: SR SR
SR
spca t Spcc spchg Spc I SPC I n spconv Sper Spct g spd 1 Spdofn spdr spds Spelt Spd t SW spe spec Spec speed
SQ sq cm Sq ft sq ~n sq km Sqcg sqh
sqn
sqrt Sqw s qz gr
sr
Sr sr Sr sr
sr
SPCC SPEED
Spft Spg Sp?l spher Spnn spk Spk spkr ---Sp I Sp I Sp I Spl Wp?l Splc Spin spltr Splx Sply spm spm spnr spnsn Spp Spp 1 spr Spr spr spr Sprdr spreg sprg Sprk t sprt Sps Sps Sps spscr sps~p Sps t Sps t Sw Splft Spt Sp t Sptt Sptw gpvn Spyr Sq
sr sr sr sr sr sr sr sr
sr
superqutck square centimeter square foot square inch square kt lometer squirrel cage square head squadron s~are root squarewave squeeze grtp saturable reactor se)ective rtnglng selenium rectifier senior shift register short range slip ring slow release (relay)
rock-t rangtng
regulations
recorder radar
repair attack
q etfvity
miss!le .
bal?fstic
SPL
SPL SPL SPL WPN SPLC SPLN SPLTR SPU SPLY sPt4 SPM SPNR
SPNSN SPP
SRKN SRLY SRNG SROO SRP SRPG SRPR SRR SRTC SRVCLG SRVL :: Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss SS LORAN SS LT
Ssho
srkn
srly s rng srod Srp
mtssfle search step-recovery dtode surveillance radar q lement surge single rotating knife series relay syringe stove rod sonobuoy referenced position scraping scraper sound recorder reproducer search radar terrain clearance service ceiling survival same size semi steel service sink ship servtce signal Strength shot single sink slop smoke stand solid state spin stabilized [rockets) star shell (Illuminating projectile) shank straight subsystem long range navigation starboard side llght synchronization separatur and dtgltizer suspended sprayed qcoustical ceiltng stngle Sieeband single sideboard single swing blocking oscillator
SPPL SPR SPR SPR SPR SPRDR SPREG SPRG sPRKT sPRT SPS SPS SPS SPSCR
SPSHP SPST
speed regulator sprinkling sprocket support smple per second service propulsion spectal serv~ces
special
system
srvclg srvl Ss SS Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss Ss ss
special
scrw shaPed
sinyle single
throw
SW
$Ingle pole single pole Swi tctl split septuple sprayt~ght single pole desk . single typewriter
throw
loran
sum?lng skywave
selector synchronized
supervision
sprayer
square
1 4
AFIHREVIATION
Ssm Ssc
TERM
smooth surface butltup roof Soltd state Ctrcutt s~gnal strength cent-r f Pequeney setscrtw St lkscreen spec~al stgnal conciit~ont~ ul14 t soltd state detector subso~l Clraln solfd state q lectronics system safety engineering saybolt seconds furol steady state fermi level single stdeband frequency modulation search signs? generator sectur scan \ndicator singlo signal sot) stack stngle sfdeband modulation solid state m8t8r181s surface to surface missi18 stlicon stud mounted diode steady state oscillation ship S~single strokes per mtnute s=condary surveillance radar Slate shingle roof silicon synsnetrtcal switch solid state switching stainless steel supersonic transport ship servtce turbo generator seamless steel tubfw saybolt seconds untversal ship to surface vessel static self vcr$ficatton Synctlro switch synchronlztng switch sawtooth schmltt trigger Schu!er tuning self trapping single tire stngle turn Sl~l@-thrUW sounding tube steam store street start and stop statuary bronze stern light stattc pressure station stationary stabi 1 izer stabtlity second time qround echo stabilized local oscillator stabilized master oscillator stanchion starter photostat status shore termfnal box stable starboard stabilization stroboscope standby
ABBREVIATION
STC STCH STCW STO STOF ST9VG STDY STDZN STEM STEM STER STER STEREO STFG S7G STG STG LT STGEN STGR STIF STINFO STIR STK S7K STK STL STL STLR S7LT STNG STML STNT STN Snm STNLS S70L STOR STP
STP STP STPO STPDN STPG STPL
TERM
sensitivity ticontrol stitch system time code word standard standoff stern diving steady Standaraizat ion storable tuoular extendible ~~ stenel 1 seater sterfltzer stereopnon$ c stuff!ng stage starting steering light steam generator strlngcr sttffener sctentif~c qnd techntcal tnformatton st 1rrup stack Stock strake steel studto transmitter ltnk semitral Ier stelllte steaming stisulate statement stone sustaining stainless short takeoff and Iandfng storage selective tape prtnt starq3 strip strfpped step down stepping stern plane stopping short taper stepper stripper straight strainer stream strength stripping strategic stratosphere stuultaneous tape r-ad qnd wr i te strongback stranded steering strong stro~e structural streaml ine storeroom
ssbr Ssc
Sscf
sscr
Stc Stcrl
Stew S td stdf S tdvg Stdy s tdzn stem sten ster
ster stereo
Sscr
SSCR
SSCRN
Sscu
Sso
sscrn Sseu Ssd Ssd Sse SSE SSf Ssfl ssfm Ssg Ssi Sstg SSk s Swl Ssm s sm s Smd Sso Ssp Sspm ssr ssr Sss Sss Sst SST Sstg Sstu Ssu Ssv Ssv Ssu Ssw St St St St St St St St St St St St 8 Sp st brz
Stfg Stg Stg Stg lt s t gen stgr stif stlnfo stir stk stk stk St 1 Stl stir Stlt. Sting stml s tmt stn stng stnls STOL stor s tp s tp s tp Stpd s tpan s tpg stpl s tpng Stpr s tpr stpr str str str str str strat strato straw Strbk strd strg strg strk strl strln Strm s t robe Strp Struct STS Sts
SSM SSND Sso SSP ssPM SSR SSR Sss Sss SST SST SS7G SSTU
St lt st pr
sta Sta stab s t aby stae stale stamo stan start stat stat Stb S tb Stbd stbln s tescp s tby
STPNG STPR STPR STPR s7n STR S7R STR STR STRAT S7RAT0 STRAW STRBK STRD STRG STRG STRK S7RL STRLN $TRM STROSE STRP STRUCT STS STS
stroboscope strapped
structure special special
Ic
test system treatment steel
145
ABBREVIATION
STsf SIT stsh Stt sttr Stu 9 tu s tu Stw s tug s twp !ttuy
Su
TERM
stab fltzed shunt singltarg*t track Stator sPeCfal twst unit step up system tfmfng unft stem Watwr s twage steam wrklng pressure Stalrwy supply unft submarfne Subasse?lt)ly subcaliber subject submerged
ABFIREVIATIO~
SWBHD
TERM
suash bulkhead saIt water Circulating sfde water depth short wave fadeout Standard Wire 8rlttsh Stubs Wire Gage swage swtng swinging bracket
Swbhd
Swcp Swd Swf SWG
SWG
SWCP
Suo SWF SWG
SUG
puap
STTU
SW mu mu SW S7UG STMP STUV Su SUE SU8ASSY SU8~L
Gage
D&t
SWGR
SUCT
SW SUFF sud
SUN
Suw SUM SUPCUR
SWT
sub Sumssy subca 1 sub j Sumag Submg subm t n Subq subs t subs t q Sutlstr suet r sue Suc t sudt Su f Suff Suj sum sum sum supcur SUporhe t supers t r supht r Supp 1 suppr
SW SWLOG
SWOG Suov SUP SUP SWP SW EXP SWP INTEG SUR SUR SUR Sws SUSG SWT SUT SUTL SWVL SXL Sxs
SXT
swgr Sw 1
SW~dg Swog Suov
submergence
subminiature subse~en t Substitute substatlun substructure subtraction succeeding sue t ton stlicun unilateral diffused transistor sufficient suffix stale upset jaw sum t ng surface to unde~ater mtsslle system check qnd utility current superheterodyne superstructure superheater Supple$mmt suppress supersede supersensl tfve superintendent superv 1se surf qce surgical sorting updatfng report generating etc survey semicu~tor unilateral Swf tch Ytgnal underwater sound suspend safety valve self ventilated self ver~fication stale View single s~lk varn!sh ~ tnsul) serv 1ce servomotor servo Semivftal salt water q ave short stngle wetght spot wld swash SWi tch Switchband wound (relay) short wheel base switchboard
sweep
J qxp SWP \nteg swr swr Swr Svs Swsg Swt Swt Swtl Sw 1 Sxl Sxs
qnd
master supertmosed
Sxt
sxtn ---Sym Sywml
sywQ syn syn ind syn 1P syn recp sync sync conv syncom
supsd
supsens sup t Supv surf surg surge
synchronous
converter
Sus
Sus Susp Sv Sv Sv Sv Sv svce
surv
SYNS
SYNSCF=
syns
synscp synth synt i Sys t
Sus
SUSP Sv Sv
SV Sv Sv
t t t t
t t t tee
SVCE
sVMTR Svo
svmtr
Svo
SVTL SW Sw SW Su
SW Sw Sw sue sum
Svtl Sw Sw Sw
test
tooth tab t&bb t8Bf tbd
SW Sw Sw SW Sut) Swbd
synchronous orb~t!ng comsmmtcations satellite synopsis synchroscope synthetic synchro tie system sfngle therwplasttc (Insul) synthetic thermo-plastlc (insul) t-bar ~structural shape) teeth thermoplastic I insul ) time toilet total trim tee test (altn qbbr) tooth top aml bottom top and bottom bolt indicator turn and bank transmission qnd
distribution
146
MIL-SID-12D
29 my 1981
TERM
L
ABFJRE\[ATIO~
T8ATT TBAX Toc TBD TBE TBG TO I
TBL TBLft TBO Tc TC TC TC
TER,$I
torpedo battery tube axtal
7boA
T8E TaG TbG TBH 78P 1/8 T/E T/F T/FR 7/0
tnda t6e
t8g
t/f
t/fr t/o
ta
tsar tab tab
tabsim tabso 1 t ac t ac tac TACAN taccar t acden tach tad t adm tadr taf tal talt tarn tan tan t anh tapac t apak tape TAR taran tarp tars tas tasc t q scon tase tasi tasr tat tat te TB tb te tba
TAB TM TAESIM
TAEiSOL TAC TAC . T Ac
qnd data t-on test qnd evaluate tongue qnd groove tracking qnd gutdance test and handl{ng tfme and pwcuss~on title block tables of equtpment ttm of fail top of frame tables of organtzatton of organization and tables qu i p-n t ttme of rtse transmtt receive $ Ward of allowances table q rea target q rea q alysts radar target tabular tabulate
trackfng
q cqu~sit
ted tbe
tbg
TC TC 7C TC TC TC TC TC TC
TCA TC8V Tcc TCC T CD TCG TCn TCH TCI TCL Km TCP YCR TCE TCTO wu TCU TCU TCUL TCZD 70 TO TD TD TD TO TO TD to
tc
tc tc tc tc tc tc tc tc tca
tcbv tcc tcc tcd teg tch tch tci TCL tcm .
tACAN
TACCAR TACDEN TACH TAO TA~ TaOR TAP TAL TALT TAM TAN TAN TAFU4 TAP AC
cotta thermocoupleq thread cutt~ng time constant timed clostng toilet case top chord trip coil qrea terminal control temperature coefficient of breakdown voltage travel correction calculator turbine close cwpled thyratron core driver gain tune controlled
terra
tcp
tcr tcr TCTO tcu tcu tcu tcul tczd td % td td td ta td td td td tda tdc tde tacm
TDCTi.
t~orary construction hole transfee in channel terrain clearance ~ndfcator transistor coupled logfc telemetry code modulation traffic control post t~erature coefficient of resistance transfer contrul regtster techntcal time comlfance
technical tangent
annmm~tlon
order
tape control untt threshold control unit
transmission control untt tap changing under load co~ensated te~erature Zener diode table of dfstrtbution tank caestroyer technical directtve temperature differential testing dev{ce t~le drain ttme delay difference time
7/lPAK TAPE TAR TARAN TARP TARS TAS TASC TASCON TASE TAS I TASR TAT TAT ;:
TB TB TBA
L
tanned hyperbolic tangent automatic positioning tape qnd control tape pack tape automatic preparation equipment terrain avoidance radar radar and tact+cal q ttack navtgatton tarpaulin q nalog radar terrain sfwlator true airspeed terminal area sequencing qnd control te!evtsion automatic sequence control atr support element tacttcal speech ttme ass~gnment interpolation terminal area surveillance
transmitter dtstrtbutor turbine direct turbfne drfven tunnel diode am~ffier time delay closing top dead center
transistor memory
tunnel diode transformer
driver
core
charge
transmitter
true i9{r tewerature tabulation block technical bulletln termina! board ttle hasq ssewbly terminal board
too TDU
TOOL TOEC TOG
tdd tdd
tddl tdec tdg
logic detecting device target telemetry data digitizer dtvision data link time tel~hone lfne dfgftal error checking twtst drill gage
147
KIL-STD-12D 29 *Y 1981
AB!3REJ1ATION
7010
TDIS7R TDL mu TOM TON Too TDPL Tm TDS 70s
ABBREVIATION total dynamfc head t~m!ng data tn@t output tape distributor
tunnel d~ode log~c multiplex null fficr TFZ Tu TG TQ TGC TGI TGL TGLS TGT TGT tfz tg
TERM tatl
fuze tail gear terminal guidance torpedo group transm~t ga~n control target intensif fer toggla tongueless tail gate target
the?-motd
tg tg tgc
tgl tgl tgls
tds tdst
tdt TDTL tdu tdx te te te te te te te te te/r tease teb tech t qch TEDL tefc tej te I tel telb te 1ecem teledac teleran telesat
TDx n
TE 7E TE TE TE TE
te?mtr telscom tem tqm tew te~ fqwp tml ter ter terb tcrcom term termn terr tet tet tetfleyne tf tf tf tfg tfl tfr TF7
package Ilst torqe differential recefver tape data selector stmlator track data track data storage des~gnation target transmitter tunnel diode transistor Iogt,c target detectton unit thermal demand transmitter tangent elevatfon tmrm{nal ~ipment thermal element thermoelectric totally enclosed tratllng edge transverse electric transverse q lectrostatic q dge radius trail~ng tracking errors qnd slw)ation evaluation tone qncoded burst techni ca 1 technician transferred-electron-device Iogtc totally qnclosed fan cooled transverse expanston joint telephone telephone station telephone booth teiecomnunl cattons telemetric data convarter television qnd radar navigation telecomumlcatfons satellite telefmtor telemetry surveillance Commmications tenper transverse electromagnetic electrical resistance t~rature t~erature tewporary tenplate terrazzo tertiary base terrazzo terrain contour mapping termtnal termination
terr~tory tetrachlortde
opentng
tgt tgt
th th the thd thd thdnk th~ theor therm them thk thkf thknr thkns thkr thm t hlns thor
7H
TM
THO TUB THDNK
tOilet thermal
thread
total harmonic dtstortlon threaded neck threadpiece theoretical ther~ter thermostat thtck thick film thickener thickness thicker therm thermistor transistorized high speed OperatiOnS recorder thrust horsepower treated hard pressed f~berboard -threshold thrust thermal
THOPC THEOR THERM TUERm TW Tt+(F T=NR T!UNS THKR THM tHNs TmR THP THWB THR
THR TnRM THRMSTC THRQT TNRSHL THRT THRU THTR THUR TWT THYNOTROL THYR
t hp thpfta tfw t hr
thrm thrmstc thro t thrsh 1 thrt thru thtr thwr thwt thymotrol thyr tf t! ti ti ti tic tictac tif tim
ttm
thermostatic
throttle
thrust shell
throat through
theatre
TI TX TX TI 71 TIC
TICTAC
TIP
TIP
tfp
tip
tipf
t~r tlr t 1rus
thrOWer throwout thyratron motor control thyristor tape inverter target identification time index track inttiate transmission fdentff{catfon te~erature indicating control Ier time compression tactfcal consrnwticat ions telephone interference factor ttma meter track imttation track inttfation qnd prediction inlet pressure turbine
tact!cal tnformatlon processing qnd
7XPI
TIR TIR TIROS generator
radar
tetrode
tetrafluoroethylene thin film thread formtng tile floor transmit format teflon (insull terrain followtng
thfn ftlm transistor
TETFLEYNE TF Tf TF TFG
TIT
ttt
ttu tjc tjp
TIU T@ TdP
Interpretation target llJuminatlng radar total tndfcator readfng TV tnfrared observation satellite turbfne inlet temperature tape fdentlffcation untt chart trajectory
148
MIL-STD-12D 29 MY 1981
ABBREVIAI-lON
TK
TERM
tank tackle
ABBREVIATION
TO To TO to Lt T08
TO
TERM
technical order timed Opaning turnout towtng Ifght toboggan tobin bronze co-l iance technical order thread one end tero~tev track on jamim tolerance tone operated net 10sS
TKL 7KR TKT TL T& TL TL TLE TLG TLG TLG TLK TLLD T LM TLMY TLPC TLn TLRMTD TLS TLSCP TLSfT TLU TLV TLY TM TM TM TN TN TM TM TM6 TNO TMER TNC 7MCOMP TNO TMO TMO
TMFL TMG ~ TNGO Tms mm) TMPRG TMPROC TMR TNS ??4s TMX TN TN TN m TN TN TN TN8ALM TNO TNOZR TNG TNG
TNL
TNLDIO TNR
tk tk 1 tkr tk t tl t? tl tl tle tlg tlg t)g tlk tlld tlm tlmy tlpe tlr t 1rmtd tls t 1Scp tlsft tlu tlv t?y tm TM tm tm tm tm tm tti tll@ t-r tmc tmcom ttmd tmd tmf 1 tmg tmgd t mos t ~d twrg t~roc tmr t ms tms tmx TN tn tn tn tn tn TN tn~alm t nd tndzr t ng t ng tnl tnldie t nr tnst tnsn tnt tntv to
to
tanker
ticket talk l~%t~ thrust ltn= tie line tfme Imgth tenqmrature l!mi ted emfssim tatl landing gpar te I egraPh ttlttng test li~ total load telemetev telemetry taflplece tfller trailer mounted submodule talemetry Ifsting
to to It
tob tob brz
706 ORZ
Toc TOE TOW Tmi TOL TONLAR TOPG 70?0 ToPSEC TOR TORM TORNL TORP TORSXO 70s Tot TOT TOT tC)TLZ TOUA TP 1P 7P
TP 7P
toc
toe tohm toj tol tonl qr topg topo topsec tor tom tornl torp torsio tos tot tot tot tot)z tows tp tp tp tp tp tp T? tp
q djuster topping topography top secret total izing relay torquemter torsional
torpedo torsiograph tape-operated system time over target tot81 turbine outlet tewerature total ize terrain qnd obstacle warning and qvo~dance target practice test point tie plattime puise tirnin9 point tO~dO part Of beam true position true profile tape drive tape pulse amlifier tapped terminal protective devtce t~m pulse distributor theoretical point of fog tappvng timing pulse generator telei3hotograph tape phase tnverter target pasition indicator teetn per inch threads per inch triple treplcalized trfpie wall telemetry prucessor moduie taper
teleprinter
t91escope
tallshaft table lookup threshold limit values tally tactical m$sstlc technical manual t~erature meter titam~um chloride tone modulation training manual transverse magnetic thimle tum@le ti-r transport movement control telemetry Conputatfon data tacttcal mission
7P 1P 7P
TP OR
theoretical
maxinum densfty
timed
ti~ of flight tfmtng timing devices thermosetti ng tewpered t~er i ng telemetry processing timer tf~ and -tfon study typ8 model sertes telenwter transmitter technicaI note thermonuclear tone trac8r nueer track ~r train true north tone and alarm t i nned tenderizer tongue training tunne I tunnel diode thinner tensi ie t qns i on trtnftrotoluem tentative takeoff
tp dr tpa
tpd
tpd
tpd tpf tpg tpg tpho tp i tp i tp i tpi tp 1 tp 1 tplw tpm tpr tpr tpr tps tpsn tpt tpt tptg tptol tr TR tr tr tr tr tr tr tr
TPt.
TPL TPLW TPN TPR TPR
with
tracer
tuned plate
tme posftton tape recorder technicai report toothed ring rack towel
trace
149
MIL-STD-12D
29
May
1981
ABF?REYl~ill
m TR Tmcow
O~
ABBREVIATION
TRsR 7RST TRTD TRTNT TRU TRUN TRUT TRVLG TRVLUT TRVLR TRWA TRX TS 1S ;; :: TS TS TS8POP TSC
TERM
taxi and runway
TRAJ TRAN TRAU TRANS TRANS TRAMS TRANSA TRANSP TRANSV TRAP TRAPATT
trsr
radar
tru
trun trut trvlg trvlmt trvlr t rwa t rx :: ts TS ts ts ts ts tsapOp tsc tscl t
transp
transv trap TRAPATT
TRAV TR9 TRCR TRO TRO Tmto TREC TRF TRFC TRG TRW TRI TRl TRIO TRKC
trav t rb trcr t rd t rd trdto t rec trf trfc t rg trh tri trt trib
TSCLT
TSOU
TSE TSG TSI-OH
tsdu tse tsg tsi-oh tsints tsl tsn tso t spec tsq tsr tst tsteq tstg tstr tstrz t Sw t Sw tt tt tt tt tt tta ttb ttc t te tti
TTL
throttle reset treated treatment transportable radio unit t runn t on unt{l time remaining transltton travellng travel Iimtt traveler trackway trtplex taper shank Telegraph System tensile strength test spectficatlon (nu~er) tiw swftch tool steel tube shest type spectftcat~on testfng and popping tape station conversion transportable satelltte communications link termfnal tar~t system data update
tactfcal
support element
TSIMS TSL
TSN 7s0
TSPCC TSQ TSR TST TS7EQ TSTG TSTR TSTRZ TSW T SW TT Tt TT TT TT TTA TTB TTC T7E TT I TTL TTM 7TMF
TTNG TTO TTP TTR TTR TTR TTU TTY TUNG
TRK tRKG TRK Wi+L TRLR TRLY TRMR TRN TRN CRO
TRN LT TRNftKL TRNGL TRNGR TRNPS TRNR
TRSOR
TRSC9 TRSN
trig t rk t rk t rk trkg trkwhl trlr trly t rmr t rn Crd trn trn It trnbk I t rnd t rng I t rngr trnps t rnr trnsn trntbl t roo t ropo t rp t rp t rp trpl t rq t rr trr trsbg trsbr trscb trsn
time signal generator tube sheet tnlet and outlet head telemetry simlatton submodu 1e typesetting lead since new time since overhaul time test specification (no nutie r ) tfm qnd super~ick tile shingle roof quipment testing tester transistortzmd t~crature switch test switch teletype tile threshold timing qnd telemetry total tfme trfple thermoplastic (Insul test target qrray teletype buffer tape to card telephone termtnal equipment time to intercept transistor transistor logtc tw tone modulation touchtone -Itlfrequency tigtttentng transmitter turnoff tape to print target tracktng radar teletype translator tifw tewerature recorder thrust termination un~t teletypeurfter tuning tungsten
test test
ttm
ttmf t tng tto t tp
ttr ttr ttr ttu tty tun tung
150
MIL-STD-12D
29 ti~y 1981
AFIRREI1/\?l Tun
TURB
ON
TERh4
turret turb I ne alternator turbo turbine generator turning transistor under tube under test televisfun
transport vehicle
ARRRE$1ATION
Ucso Uo UOL UOL UOT
UOT UOTO
tur
t urb
ucsd ud ud 1
ud 1 ud t ud t udtd Udti Uc Uf Uf uf qed ufn Ufo uf r Ugnd Utl uh uhf uhf /hf Uhfdf uhpfb uhr uh t uh t Uic Uj UdT Uk Ut Ulf ulm
Ult
TUR80
TURBO
ALT
GEN
turbo
turbo turn tut tut tv tv Cvc tvdp tvel tvg tvg tv{ tvm t vm tvor tw tw tw tw tw tu tw tbi tw tw tw twa TWc TWF twm t-k twr tws Tws twsb twsro twt tux twx tuy txtl t yc?e t yp typl typstg uh 1 U:o u/w uam uar uart
TURN
alt gen -
[Ctriv=r) test
TUT
TUT Tv
Tv Tvc TVOP
UDT I
UE UF
TVEL TVG TVG TV I TVM TVM TVOR lW Tw TW Tw TM TN TW TW Tw TM TW TWA TWC TWF TWN
TWMSK
TWR TWS TWS TWSEI TWSRO TWT TWX TWX TWY TXTL TYOE TYP TYPL TYPSTG UA L u/o u/u UAM UAR UART us us UBO U6 I TRON
thrust vector controi terminal vector display unit track velocity time varlstton of gatn time varfed gatn telavlsion interference tac~ter voltmeter transistor veltnwter terminal VHf omn!range tafl wind teamwork t~erature well t~ered water tight wrapped tile wainscot ttme word traveling wave true watt twisted typewriter mltfier traveltng wave q truncated whituorth coarse thread truncated whltworth fine thread traveltng wave maser traveling wave auttiple beam klystron tower track whfle scan truncated whitworth spectal thread twin sideband track while scan on receive only traveling wave tube telegraphic message teletypewriter exchange taxiway textile type designators typtcal type plate typesetting upper and lower used on used with underwater to q ir mfssile
use as
w
UFAED UFN UFO UFR uGNl) UN ml
unit uttra
heater high
ultra
htgh
fre~ency frequencyihigh
frmcfuency ultra-hig~ frequency direction findtng hardpressed untreated fiberboard ultra high resistance
UNT
UNT Uxc Ud
underheat untversal
horizontal
cede
Utic UME
umr IJmJs
UN
reqtred
universal
q synchronous
tter
wow UNCTO
unctd und
Undc
ueL
Uc UCI UCL UCMT Uca
UCON
U8S~ block utility btnary dmp beam Interaction undulating electron tube unbleached unit cooler utilfty card tnput upper control limlt unglazed c8ramic mosaic utfllty co~iler utility control
UNOEF UNOETM
UNOF UNOLD UNOV UNEF UNF
undef Undetnl
L4ndf
ultra low frequency ultrasonic !$ght modulator ultimate Umilical u~il ical cord unit monthly equipment unsatisfactory materfal notice upper maxinum range unbleached wslin unified union unit unauthorized union bonnet universal navigation beacon unblinking unified coarse thread unclassified unc Jam unconditionally uncoated under undercurrent undef Ined undetermined underfrequency under load
undervol tage
unified
q xtra
fine
thread
thread
tf!~
unf In unif
unff caef
IJNIF COW
un i f orfn unlformtty
coefficient
151
~L-sTD-12D
29
May
1981
TERM
un$polar ft-ld transistor un t versa 1 unk nom un i oad t ng
effect
AH13REVIAIION
uN1f
AURREVIATION
Uw
UWT LiWTM UMTR v v v v v v V AOJ VIM V/MIL VM VAC VAC VAC VAC VACT VACW VAL V4L VAN VAP PRF VAR V AR VAR VAR VARW VARISTOR VARITRAN VARM VARN VARR VAS I V#l facing w Vc Vc Vc Vc VC8 VCE VCG E
TERM
unconventional warfare WIft W0t9ht underwater team underwater violet [altn abbr) valve varntsh f !nsul ) vertical (co* form) volt vol tage voltage adjusting rheostat volt per meter per mil volt
verticaI
ET
unitet Untv un 1 unl tm unlkg U-d umntd Unps unrep unrgl td UNS unsuppr untw Uoc
Uo 1 Uos
w
Uw
lJNIv UNL
UNLIM
UNLKG -D Uwwo UNPs UNREP
unltmtted
unlocktng unmarked unmown t qd
untversal
UNRGLTD UNS
UNSUPPR UNT W Uoc UOL Uus
UPC
UPOFT UPR
UPC Updf t
Upr ups
UPS UPS
UPWD
ups
upwd UR Ur ur urg ur t Urwc us ::
us
UR
Uu
power supply underway replentshnumt unregulated special thr=ad unified unsuppressed untwist ultimate operational capabfl{ty underwater object locator unless otherwtse speclfted untversal product code updraft upper uninterrupted powr supply uninterruptible power supply ward unsatisfactory report
urtnal
qlternating
ZSSQ*IY current
bufldlno volts
closet
us
USAS usb usb Usfu
USG
USAS use
Usll
USG UsM
{lens
varistor varltran varm varn varr vast VATE vb Vc UC Vc Vc vcb vce Vcg Vc 1 v cm Vco Vcop
USFU
usm
Uss
ustzd usub Usw Ut UTC Utc
utee; Utfl Utll rad
t{zed
varnish ca~ric (insul ) vttriflecl clay coil voice VOIUme of co~artment vert{cal location of the center of buoyancy
verttcal centrlfuga)
Usw
UT
vertical
center vertical
location
of gravity
of
the
ttme
unit
Utiltty
time
coding
of enemy
ut~llzation
qlectromagnetic
utn utrtd Uts UTS uum Uu t Uv uvaser
radiation
utilization utensi I untreated ultimate tensile strength unive;sal tfnw standards underwater to underwater mlssi!e untt under test ultraviolet a~llffcatlon ultraviolet emlsslon by sttwlated
vCSR
VCT VcT Vcxo Vo Vo Vo w Voa Voc JO%t VOcw
vcsr
Vet
center line vibrating coil magneto-ter cofi-rol led voltage oscillator variable control Otl pressure sh{ft voltage controlled
register vitrified voltage voltage clay control control tile transfer led crysta
vet Vcxo V@ vd Ve Vd
vda
O*
Uvo VFLT Au
uvd Uvflt w
radiation undervoltage
ultraviolet
ultrasonic
devlcm floodlight
wave
oscillator vandyke vault door void voltage drop vidaro distribution ~llf direct current volts VOI t direct eurren* dtrect current test vul~s dfrect current working
er
volts
d
MIL-STD-12D
29 hy ABF3REVIATION
VILP Vl#-VAR VINP VINT VIO VIP VIP VIP VIS VLSC vISIO VI SUR VXT VIZ
1981 TERM
ABBREVIATION
VDCL WET VOfG Vo I VOL Vos VOT Vc VE VEE VECO vale!
TERM
variable deltvwry voitage detector variable diode function generator vertical display indicator ventllattng deadlight varfable depth sonar vtdeo display te-inal wtgtneertng value e~tpment venttlatfng variable elevation beam vernier engine cutoff vfs~ble energy detection and ranging vegetable vebtcle engineered tndlcator value vellum velocity venti late ventt Iator verbatim versattle differential q nalyzer verification very long range tracking vernfer vernier tracking by qutomatfc correlation versed sine versatf Ie vertical vestibule voice qxetted vocoder variable freq4ency vector field voice frequency vartable gafn s~llfier voice freqency carrier voice frequency carrier teletype variable floating point variable frequency osci 1 later visual flight rules variable fr~WtCy CIOCk fremancy telegraph voice
visual vfsual visual glide glide 91 $de path slope sIope Indtcator
Vtlp v t m-var VIVINT Vio Vtp VIP Vip Vis Vlsc vfstd Vismr Vlt Vfz V1 vla v I add Vlc vlcr vld
Vlf Vlfs
Valet
vdfg vdi
vdl
vds
Vd t
Ve ve v eb Veeo
VEDAR VEG ~ VEH VEI VEL VEL VENT VENT VEREl VEROAN VERIF VERLORT VE RN VERNITRAC
VERS VERST VERT VEST VEV Vf w w VFA vFC VFCTT
vedar v eg veh ve ~ V@I ve 1 vent vent verb verdan ver i f verlort vern vernitrac
VL VLA VLAOO VLC VLCR VLD VLf VLFS VLN7RC VLP VLR VLR VLSI VLT VM VM VK VMC VNXL Vo VO!MNC Voc VOCOM VOOAS VOOAT vow
vector tmedance loCuS plotter vacuum tnductlon melt-vacuum arc refmlt vertical Inqulse vtaeo integration violet value in performance varfable tnformatton processing vfsual Identification pOint vtsual Vtscostty vfsual fdentff}cation viscometer Vttreous name I y ver-tlcal ladder very low altitude ngle drogue vtsual low q de 1 I very vital load center cavity vartable length resonance visual Iaydown deiivery
very low variable s tandarcl frequency IOU frequency
vers
VLSI
Vlt tiln vVVW
VFL PT VFO W R VFREQ VFTLG VGP I VGS VGS z VH #t VHF VHFDF VI VI VI V!a VIB VIC1 VIO VIDAMP V$DAR VIDF VIL
Vfl
Vfo
pt
vodas
voda t vogad Vol volcas Vom VOR
CLK
~ndteator
vent hole Vi@ers hardness very htgh fr@qU@nCy v~ry-htgh frequency dlrectfon ftnding video Integrator Vlscostty index volume tndicator vtbrate vibration
volumetric vertical landing po~nt very long range very low range very large-scale Integration volute velocity momlation VOI tmeter vfsual meteoriogtcal condl tlons visual meteoroglcal vaneaxial voice voice band co~ression voice order circuit voice cowmunicatlons voice operated dWiC@ 8ntt-stng voice operated device for automatic transmission voico operated ga{n q djusting aevice Volm voice operated loss control qnd suppressor volt-ohm mi I?iamweter hfgh f=QUenCy very
omnidtrwctional range VHF omnirange and radio
distance
veloctty
indicating
c!oherent integrator V i deo video a~lffter velocity tntegratfon detection and rangfng
measurtng q qutpment very-hfgh frewency omnirange local lzer votce operated transmitter keyer
vapor pressure vent pipe vertical pIanntng vertical polar~zation conanand video prelaunch
Vp Vp
Vp vpca Vpml vpr Vpu
vtdeo
village
f~ency
q ~liffer vibration
vaporize v{brator
per
power
minIJte unit
153
MIL-STD-12D 29 hy 1981 .
AFIRREVIATION
VR VR8
VRCTR VRD VRFI VRFY Vr
TERM
voltage regulator VHF recovery beacon varactor vacuum tube relay drivsr voice report~ng fault tndicator varify varlstor vertical reference 1 ine voltage relay volta9e re~lated power supply veloclty response shape voice r~orting signal
ABRREVIATIO~ w
w w W&M GA w/ U/so u/D W/EbSP w/o W\O
TERM
wide wtre (co~ form) qrmor rwnd ( insul ) wire Nashburn and Moen Gage wtth (CO* form) with blowout wt thdrawn wtth equipmnt and spsre parts Wi thout without equtpment and spare parts wtthout blowout wlndtng to Vi~ing wainscut waveform q nalyzer qsse-ly wtre q sse~ly ( torpedol workshop data servtce wide-area width qcross flats wtring qround frame wagon wave modulated osc~l loscope wani gan warhead warranty wide-area telecowmuntcat tons servtce wood awning type w{ndow wagon box wash bucket wt bulb whale boat wheel base wheelbarrow wide band wood base work bench wideband current transfornx?r wideband data wire bound wtde band Oicke fix wideband data lfnk wood block floor webb i ng wood bloci(tng widebnd noise limiting word buffer register wrought brass work breakdown structure wooden box (ammo) water closet wapon carrier wheel center worktng ctrcle white cathode follower water chtller water cooled core matrfx wired word co~iner and iiultlplexer wing chord plane watercool er wrftable control store woodcuttlmg wood casement window watt demand meter whole depth wtdth
w
w w
W6M GA W/ w/ho u/d w/ei3sp
v rb vrctr
V
rd Vrf i
vrfy vrls
vr I
vrly
vrps VP% vrsa vrty Vru vryg Vs Vs Vs Vs vsb v~bl Vsc Vscf v~d Vsg Vsl 4Sm Vso vsr Vst vstm vstoL v Sw vswr
E&SP
w/o WIO
qhsfs
q ss-ly
variety voltage varytng readout unit
vspor sea) vent stack versus voltmeter switch vesttgial Sideband visible voltage saturated
VAF
WAG WAMOSCOPE WAN WARHO WARR VATS WATU we uO Wo Ws WE us U9 U9 we Wacl WBD WBO WBOFX Moot. WBF MUG MEL W9Nt. UBR U8RS was WBX MC % WC Wc WCF WWR WCLD WCM
wag wamoscope
wan wa rhd warr
VSR VST VSTM V$TOL Vsu VSWR VT VT VT VT VTIP VTL VTM VTO VTOL VTR VTR VTVM VTX vu VULC VUTS Vvc VVR Vvs s VWL VWP Vxo w w u w w
variable speed frequency variable speed drive variable sp~d gear video sweep integrator v~st{gtal sideband modulation very stable oscillator very short range valve seat valve stem
capacitor COnStant
WATS wa tw * Wb Wb Wb Wb Wb Wb Wb Wb Wbc t wbd wbd wbdf X wbd 1 Wbf Wbg Wbl *n 1 wbr wbrs *S Wbx * * Wc WC Wcf wchr weld wcm
v~rttcal qnd short takeoff qnd landfng voltzge standing wave wav9 ratio voltage standing proxtmity (fuze) vacuum tube vaportight voice tube visual target identification po{nt variable-threshold logic voltage tunable magnetron voltage tunable osci Ilator vertical takeoff ati landing vertical radfal video-tape rUCOrdtW vacuum tuba voltmeter vertex
Volum. unit
vulcantze ver{ficatlon unit test set volta~-vartable capacftor varfable voltage rectlfler vertical volute sprfng Suspension varisble word length varfable wtdth pulse oscillator variable crystal white (altn qbbr) wtdth [altn qbbr) waste wa$t
WCP Ma
Ucp wcr
tics
WCTG Wcu bfo Wo Wo
Wcs Wctg
Wcw
wd L/d
West
wd
Wd Wd
I
154
WO
bfD WO
w~nd
ulndow wood dimension
wd
rlLL-sTD-12D Z9 by
1981
TERM
Wo Uo MD u080R Wor WOF Wd
AFJI3REVIATION
WN WNo
WNDLS WNOR Wc) WP WP
Un
TERM
winch wound utndiass wt rider wipe out ptpe waste
water plane water pump weatherproof wet process
we
wd udbor Wcf f ud f Udg uciir Wdo
wood door word work day wood boring wood door and
Wnd Wndls
wndr
fra-
Wo
T T w w * w w w wpb Wpc upd Wpfc *9 W9 wj
upm
WOIR woo
WOP
we a
wea
wet
wetm
Uf bffg Wf r Wf s Wg Wg Wg Wg Wg btg 1 Wh Wh wh Wn Uhc whdm wh 1 wh 1 Wilm Whs uhse Wht Wnt W1 Wi I Wj wj wk Wk * It &g wkr Wks WI Ml w! WI w? Ml Wlb Wlc wld W!dmt uldr Ulds Wlsl Um Um m Wm uwgr Wmsft -n I
WI+ WH w
WH
uoodruff wtnding wind dlrectlon w \ ndow wood panel wa ther weather tight wapons effectiveness testing . weather tesm wash fountatn waterfog UN{ er strips wnod furring wavegu i de Wedge window guard wing wire gage wire glass wal I hydrant water heater
Wa t thour
UP UP UP UP UP UP UP UPS
(Insul)
white phosphorus wood pattern word processing working point binary write printer
watt
per
candie
WPU
UR WR m WR Wn
wheel
house
WI WIL Wd utJ WK WK UK L7 WKG WKR WKs UL ML UL ML WL ML wLa WLC WLD WLDNT WLOR MLDS WLSL WM Mu WM w WMGR WMSFT WMWNL
WRPG waT
WRT Ws Ws Us us us us us us uSF Wsffi bfsHLD WSHR WsL USP \iSR wS7L USTPN WT UT WTCC WTO WTG WTG WTI+URF WTR
upn wpr Wps ups Wpu wr ur wr wr Wr wr wr wr wrb wrdir Urg wrg Urgr urk wr 1 wrn wrpg wr t
wr t Ws us
write printer dectmal waterproof fan cooled waterproof Ing wtping weakened plane joint word per minute weapon working pressure shroud waterproof word per second
wri te punch
wall receptacle wardroom washroom weather resistant white room wire rope wrench wrl ter wardrebe direction wreng
wear t ng wiring ur f nger wreck 1ng
Us
Ws Ws Ws
us Ws Ws
uing reference I tne warn 1ng warp i ng water round torpedo wrought waste stack water surface Weapon System weapons specifications weattir stripping surface wetted
u~reless set
board
wrought steel support force weather washing windshield washer weather seal uorklng steam pressure rQOf wood shingle
uhlstle
wr~st p~n weight wood threshold water turb~ne water turbine waiting weighting weatherproof
water
closed dtrect
coupled
:55
MIL-STD-12D 29 by 1981
AI? HREV14TION
UTRPRF UTRTT UTRZ WTUR8 w WJ w w w w m w w WUHL x x XARM XBAR X8RA X81 IcCUW4 XCVR XCY XOCR XFMR XFR WAIR XMVY XING XLTR XLW% XUSN XMT XMTO XMTG utrprf wtrtt wtrz Wturb w w wu w w w w w w Wbfhl x x x*rm xbar xbra Xbt Xconn xcvr Xcy xdcr Xfmr xfr xha i r Xflvy Xing xltr XI*
xmsn =mt xmtd Xmtg
TERM
uatcrproof Watertight wfnt8rfze wata= turbine Wim Unit work Urltt WOrkShOp unft ( torpedo) wal 1 vent Wcrktng voltage wat8rwa I 1 wir8 way wire wound wfr* wrap waterwheel by (between dimensions) qxperimental testing fafrcraft) qru cross crossbar cross bracing crossbar tandem crmss connection transceiver cross country transducer
transformer
AFIIIREVIATION
XMTL XMTR XPL XPLD
XPNOR xmt
TER.M
transmittal transmitter exp?osfve explosive d transponder crosspoint cross reference cross section q xtra strong transistor crystal crosstalk crystal oscillator extraerd~nary wave double extra- s t rong abbr J yellow (altn te:ting transitional (aircraft) yard y8110w yellow indfcattng lam yellow light yield point lpst) year yield strength Ipsi) yellow varnish cantwic ( insul) zone q djuster z8ro q ~lifler zero set zone tim zero t~srsture coeff}c~ent zero crossing canstant q larm rate false zigzag riveting
XPT XRE F XSECT XSTR XSTR XTAL XTALK XTLO XWAVE XX STR Y Y YD
YEL YIL YLT YP YR* Ys Yvc z ZA ZSA
xmtr Xp 1 xpld xpndr Xp t x ref Usect xstr xstr Xtal xtalk Xtlo xwave xx str ---v yd ye 1 yil ylt YP
yr ys yvc z Za Zsa
transfer eresshair extra heavy cross f ng translator qxtra long wheel transmission transmft transmitted transmitting
base
Zt Ztc
zxcfar Zzr
----
156
provisions of this standard are the Certain standardization agreement QSTAG 229. When of this standard is proposed which will affect revision or cancellation or violate the international agreement concerned~ the Preparing activity will take appropriate reconciliation action through international standardization offices standardization channels, including departmental if required.
International Interest.
subject
of international
Custodians: Army - AR Navy - SH Air Force - 16 Review activities: ArIW - AT, AV, CR, ME, MR, Navy - AS, EC, YD User activities - MC, OS Navy Air Force - 1? DSA - DH
157
k.
dbrt
in md was
Of niditary ~
dunmmnta U@ invitd
q long tha Iinu iodicatod, hpad aAong th 100- edge (DO JV07STW%E),
~cubr
Xn bbek 5, b
q bout
probhm
intarPIwtation,
too rigid, mtncth, -. UBbiguoor wu iocosnpatibis, -d gim prowordiog changu wbicb =uld ailoviata tba If bAock 7 i, tilled out, ao pmbl.ms. Enter in block 6 anY mnsarh not Aatod to q spocifk paragraph of tho documont. acknowhd~mnmt Ooaddord. N07Z: This form may notbe uaadto request copiti of docurnene, nor to mquut wmhom devistiomt, OF ciuificmtion of timizatioo sp-ilktioo mquiromeats on cumnt contrmts. Cornmeata submitted on thk form do mot constiturs or imply q to wmivoany portiom of tho refmwnccd docucrsmt(s) or to amend contractual requimnen~. will ba maihd to you within 30 days to
=r9
~ed
snd m
111111
*
OFFICIALWsme=
qENALTY -On FRIVA7E
USE S200
4
wASl+lNG70N
0 C.
1
and
Development
Command
m ;S.142s
q*E VIOUS
EOITIOM
IS OBSOLETE.