Beruflich Dokumente
Kultur Dokumente
Final
CCNA 1
- FINAL -
Page 1
1.0.Final
Datagram retransmission occurs when the retransmission timer expires in the source
host.
Datagram retransmission occurs when the retransmission timer expires in the
destination host.
*Datagram retransmission is controlled by the application layer protocol.
Datagram retransmission involves only the data with sequence numbers equal to or
higher than the sequence number of the current datagram.
====================================================================
What is significant about the ping 127.0.0.1 command?
*It verifies the operation of the TCP/IP protocol stack on a host and is called an
internal loopback test.
It verifies connection to the remote host with the IP address 127.0.0.1.
It verifies whether the router that connects the local network to other networks can
be reached.
It verifies the route packets take between the local host and the host with the IP
address 127.0.0.1.
====================================================================
Which LAN switching mode has the highest latency?
fast forward
fragment-free
latency forwarding
*store-and-forward
====================================================================
Which of the following application layer protocols use UDP segments? (Choose two.)
*DNS
FTP
Telnet
*TFTP
SMTP
====================================================================
Which cable specifications are indicated by 100BASE-T?
100-Mbps transmission speed, baseband signal, coaxial cable
100-Mbps transmission speed, broadband signal, twisted-pair cable
*100-Mbps transmission speed, baseband signal, twisted-pair cable
Equal to 10-Gbps transmission speed, baseband signal, twisted-pair cable
====================================================================
When is a crossover cable used in a network?
IP address *
subnet mask *
default gateway *
router name
switch name
NetBIOS name address
====================================================================
Which cable diagram displays the end to end pinout for a crossover cable used with
Cisco devices?
Cable A
Cable B
*Cable C
Page 2
1.0.Final
Cable D
====================================================================
Which type of address is 192.168.17.134/29?
*host address
network address
broadcast address
multicast address
====================================================================
How many collision domains are shown in the diagram?
three
four
five
six
*seven
eight
====================================================================
When is a straight-through cable used in a network?
Page 3
1.0.Final
only PC
only router
PC and router
PC, hub, and router
*PC, printer, and router
====================================================================
What kind of connection is represented in the graphic?
*console connection
Ethernet connection
ISDN connection
leased line connection
====================================================================
Which of the following is the decimal representation of the binary number 11010011?
203
204
*211
212
====================================================================
Which type of cable is required to make a connection between a router console port
and a PC COM port?
straight-through cable
crossover cable
*rollover cable
DB-9 cable
coaxial cable
====================================================================
Determine the number of useable networks and hosts for the IP address
192.168.50.0/27
4 networks / 62 hosts
6 networks / 64 hosts
32 networks / 8 hosts
*6 networks / 30 hosts
8 networks / 32 hosts
2 networks / 8 hosts
====================================================================
A network administrator is placing an older router back in to service. The
administrator discovered that the IOS and configuration files need to be updated to
meet the LAN specifications. Which application layer protocol is used to transfer
the new configuration files into the router memory?
SNMP
SMTP
HTTP
*TFTP
====================================================================
Which of the following best describes Spanning Tree Protocol?
255.0.0.0
*255.255.0.0
255.192.255.0
255.224.0.0
Page 4
1.0.Final
*255.255.252.0
255.255.255.128
====================================================================
How is data encapsulated as it is moved down the OSI model?
data, segments, frames, packets, bits
data, packets, segments, frames, bits
*data, segments, packets, frames, bits
data, packets, frames, segments, bits
====================================================================
Which of the following describes latency?
*01101111
01111101
11110111
11101101
====================================================================
Which LAN switching mode begins switching after reading only the first 64 bytes of
the frame?
fast forward
*fragment-free
latency forwarding
store-and-forward
====================================================================
When using Category 5 UTP cable, which RJ-45 pin pairs are used to exchange data
between hosts on an Ethernet network?
1 and 2; 4 and 5
1 and 2; 3 and 6 *
3 and 6; 7 and 8
4 and 5; 7 and 8
====================================================================
Which of the following commands could be used on a Windows-based computer to view
the current IP configuration of the system? (Choose two.)
configip
ifconfig
*ipconfig
*winipcfg
winipconfig
====================================================================
Which type of address is 192.168.17.111/28?
host address
network address
*broadcast address
multicast address
====================================================================
Which of the following networking devices increase the number of collision domains?
(Choose three.)
*switch
hub
*router
Page 5
1.0.Final
repeater
*bridge
====================================================================
What information can be determined from the MAC addresses of PC1, PC2, and PC3, as
shown in the graphic? (Choose two.)
PC1 and PC2 NICs need to be replaced because they have the same OUI identifier.
PC2 and PC3 NICs need to be replaced because they have different OUI identifiers.
*PC1 and PC2 NICs are from the same vendor.
PC1 and PC3 NICs need to be replaced because they have the same vendor-assigned
address.
*PC2 and PC3 NICs are from different vendors.
PC2 and PC3 NICs are from the same vendor.
====================================================================
Which of the following are considered WAN technologies? (Choose two.)
*DSL
Ethernet
Wireless Ethernet
*T1-Carrier
Token Ring
====================================================================
which one of the router connectors shown in the graphic would be used for a LAN
connection?
Connector A
Connector B
*Connector C
Connector D
====================================================================
How is full-duplex capability typically achieved in fiber-optic cable?
*Two fibers are encased in separate sheaths.
Light is bounced at different rates in opposite directions.
Transmit speeds are so high that half-duplex is acceptable.
Colors of the light spectrum are separated into transmit and receive streams.
====================================================================
Which of the following are characteristics of IP? (Choose three.)
connection-oriented protocol
connectionless protocol*
reliable protocol
unreliable protocol *
routed protocol *
routing protocol
====================================================================
Which of the following describe the token-passing logical topology? (Choose two.)
*FDDI is an example of a token-passing network.
Token-passing logical topologies must also be physical ring topologies.
One of the disadvantages of the token-passing logical topology is the high collision
rate.
Computers transmit data after "listening" to the wire to detect other traffic.
*Computers are allowed to transmit data only when they possess a token.
====================================================================
What is the maximum length of a media segment used for 100BASE-TX?
*100 meters
185 meters
400 meters
500 meters
====================================================================
which of the following networking devices divide a network into separate collision
Page 6
1.0.Final
domains? (Choose two.)
repeater
*bridge
*switch
AUI
hub
====================================================================
Which of the following are characteristics of UTP cable? (Choose three.)
*Each wire is covered by insulating material.
It is not affected by EMI or RFI.
*It is a four-pair wire medium.*
It is difficult to terminate the cable.
*It relies on the cancellation effect produced by the twisted wire pairs.
It is more expensive than any other type of LAN cabling.
====================================================================
Examine the graphic with current configurations. Host A in the Clerical offices
failed and was replaced. Although a ping to 127.0.0.1 was successful, the
replacement computer can not access the company network. What is the likely cause of
the problem?
IP address incorrectly entered
network cables unplugged
*subnet mask incorrectly entered
network card failure
====================================================================
Which of the following describes a physical full-mesh topology?
*three
four
five
six
seven
eight
====================================================================
Which of the following are advantages of UTP cable? (Choose three.)
Page 8