Beruflich Dokumente
Kultur Dokumente
8
CCNA 1
Chapter 8
===========================================================================
Which switching mode describes a switch that transfers a frame as soon as the
destination MAC address is read?
fragment-free
* cut-through
store-and-forward
latency forwarding
===========================================================================
What does a switch broadcast to let other switches know of its existence on the LAN?
STP
STA
BDPU
BPU
* BPDU
===========================================================================
Which of the following network types uses networking devices to extend the distances
that cable can be run?
length/shared media
* extended shared media
point-to-point network
extended point-to-point network
multiple access/point-to-point
===========================================================================
Which of the following is a term associated with replacing hubs with switches to
increase the number of collision domains?
encapsulation
latency
* segmentation
layered model
broadcast domain
extended
===========================================================================
While working on her computer, Mary noticed longer than normal network data
transfers. Mary investigates the problem and notices that her co-worker John has
been hosting an online video conference. What is the network probably experiencing?
collision storm
* broadcast storm
IP storm
data rain storm
===========================================================================
Which of the following does a router use to make a forwarding decision?
* destination IP address
Page 1
1.8
MAC address
source IP address
encapsulation address
default gateway
===========================================================================
A network administrator has a multi-floor LAN to monitor and maintain. Through
careful monitoring, the administrator has noticed a large amount of broadcast
traffic slowing the network. Which device would you use to best solve this problem?
bridge
hub
* router
transceiver
===========================================================================
What is a disadvantage of cut-through switching?
* no error checking
a decrease in error checking
decrease in number of collision domains
decrease in bandwidth
increased latency
===========================================================================
Which of the following would alleviate the problem of excessive collisions in a LAN?
(Choose two.)
* STP
BDPU
UDP
EIGRP
learning
===========================================================================
Which of the following are considered Layer 1 devices? (Choose two.)
router
switch
* repeater
bridge
* hub
===========================================================================
Which of the following are not to be exceeded when implementing the 5-4-3-2-1 Rule?
(Choose three.)
* cut-through
fragment-free
latency forwarding
store-and-forward
===========================================================================
Page 4