Beruflich Dokumente
Kultur Dokumente
ESD guidelines were followed during the creation of the Authorized Service Provider Repair Guide. To learn more about ESD please refer to the Fujitsu Americas Authorized Service Provider website.
Authorized Service Provider Repair Guides are created by Robert Lark Tony Fink
Page 1
LIFEBOOK T580
Disassembly
ESD Precautions are required when working on this LIFEBOOK computer. Make sure the LIFEBOOK is turned off before beginning this procedure.
2.
4.
Page 2
6.
8.
Page 3
15. Remove both antennas from the Sierra WWAN card as shown.
Page 4
22. Remove Hinge Cover. (Note: Theres a clip on the bottom that holds the hinge cover).
Page 5
Page 6
Page 7
Page 8
41. Disconnect the white USB cable from the system board and the USB board.
Page 9
52. Disconnect the Audio cable from the Audio board as shown.
Page 10
Page 11
Page 12
63. Disconnect the cable from the ambrient light sensor board.
66. Lift up the LCD, then remove the LCD cable secure by tape.
68. Remove the screw cover for the front hinge cover as shown.
Page 13
Page 14
76. Lift lever then remove 1 screw that secures the Main WWAN antenna. (Note: Depends on configuration of unit).
LIFEBOOK T580
Assembly
ESD Precautions are required when working on this LIFEBOOK computer. Make sure the LIFEBOOK is turned off before beginning this procedure.
4. Secure the main WWAN antenna with 1 screw. Position the lever as shown. (Note: Depends on configuration of unit)
Page 16
8. Re-route the cables and replace the hinge on the LCD back cover.
14. Secure the LCD cable with tape. Replace the LCD.
Page 18
Page 19
Page 20
Page 21
39. Connect the white USB cable to the system board and the USB board.
Page 22
45. Connect the LCD cable. (Note: Secure cable with tape)
Page 23
58. Replace the Hinge cover. (Note: Theres a clip on the bottom that holds the hinge cover).
Page 25
Page 26
74. Secure the bracket to the Hard Drive with 2 screws as shown.
Page 28
Page 29