Beruflich Dokumente
Kultur Dokumente
Compression Fitting
Heating PEX-AL-PEX Connection Sizes: 1/2" (12.7 mm) 3/4" (19.1 mm) 1" (25.4 mm)
Compression fittings are designed to be used in radiant heating and snow melting applications, with water or water/glycol solutions. Compression fittings are designed to be used solely with Heating PEX-AL-PEX tubing. No other tubing type may be used. Fittings are available in a variety of Compression x Sweat, Compression x NPT or Compression x BSP connections.
Brass Compression Ring EPDM O-Rings
Specifications
System shall be installed using Watts Heating PEX-AL-PEX tubing. All connections shall be made in accordance with corresponding installation guidelines. Connections shall use Watts Compression fittings and Heating PEX-AL-PEX composite cross-linked polyethylene tubing.
Insulator Insert Male NPT Adapter* Compression Nut Heating PEX-AL-PEX Compression Fitting *1/2" (12.7 mm) fittings will be indicated by a blue mark
Material
Insert Barb/Compression Nut Compression Ring O-Rings Insulator Nominal Barb Size Connection Type Max. Operating Temperature Max. Operating Pressure
Properties
37700 Brass 37700 Brass EPDM Polyethylene 1/2" (12.7 mm), 3/4" (19.1 mm), 1" (25.4 mm) od Sweat or NPT 180.0F (82.0C) 100 psi (6.9 bar)
Installation Parameters
Heating PEX-AL-PEX must be installed in accordance with all installation procedures, including information provided in the Heating PEX & Heating PEX-AL-PEX Installation Manual. 1. C ut a clean, square end to the tubing. 2. U se the Reamer tool to shape and prep the tubing. 3. S lide the compression nut over the tubing. 4. S lide the compression ring over the tubing. 5. M ake sure the insulator insert is in place at the base of the fitting. 6. S lide the tubing over the fitting. Make sure the tubing is seated against the insulator insert. 7. S lide the compression nut up and begin threading it onto the base. The compression ring will automatically be positioned over the fitting. 8. U se an open-end wrench to complete the connection (do not use a crescent wrench). Tighten the connection until snug and then an additional 1/4 turn.
!
Carries the UPC certification mark, as approved by the International Association of Plumbing and Mechanical Officials (IAPMO).
CAUTION
OT FOR
This Engineering Sheet is not intended to provide full installation instructions and safety information. In order to avoid property damage or injury, please refer to the complete installation manual and product safety information provided with the product.
TA
BLE
Watts product specifications in U.S. customary units and metric are approximate and are provided for reference only. For precise measurements, please contact Watts Technical Service. Watts reserves the right to change or modify product design, construction, specifications, or materials without prior notice and without incurring any obligation to make such changes and modifications on Watts products previously or subsequently sold.
PO
Order #
0955234 0955238 0955240
Order #
0955236 0955237
Order #
0955249 0955250 0955251
USA: No. Andover, MA Tel. (855) 699-2887 Fax: (978) 794-1848 radiant.watts.com Canada: Burlington, ONT. Tel. (905) 332-4090 Fax: (905) 332-7068 radiant.watts.com