Beruflich Dokumente
Kultur Dokumente
com
INTRODUCTION
This trainer has been designed with a view to provide practical and experimental knowledge of a general circuit of Digital Transmission Receiver fiber optics on a SINGLE P.C.B.
SPECIFICATIONS
1. 2. 3. 4. 5. 1. 7. Power supply requirement Built in IC based power supply. On Digital Data generator. Bits Transmission Source Receiver Source screen printed. Standard Accessories : 1. A Training Manual. 2. Connecting Patch cords. 3. Fiber Optic Cable - 1 mtr : : : 8 bits, NRZ Fiber Optic LED - 660 nm Fiber Optic Avalanche Photo diode (APD). : 230V AC, 50 Hz.
All parts are soldered on single pin TAGS on single PCB of size 12" x 9" with complete circuit diagram
EXPERIMENT-1
Aim:
Procedure: 1. 1. 2. 3. 4. Connect CRO channel-1 at the output of digital data transmitter. Now Apply in digital word using given on/off switch. 00001111 etc. Now connect the output of digital data generator to the input of the digital data transmitter. Now connect the fiber optic link between input and output terminal. Keep the CRO channel 2 at the output of the digital data receiver and check if it is same as input or not If not than vary the 10k 10turn port and check if output is same as input or not.