Beruflich Dokumente
Kultur Dokumente
Thanks for trying my plans! I hope you have fun with them! Remember you can buy ALL the electronics for this plane at, WWW . MIKEYSRC . COM
Glue a 7 inch BBQ skewer on the bottom here to add support where the battery hole is cut.
Use the V tail angle guide to help you get the correct angles on the tail.
Glue a small BBQ skewer on at an ange like this on either side of the fuselage to help support the fuselage.
w
il, Ta
.M w w
ut c ut o
sR y ke i
of 2 he t e. s
om .c C
COPYR IG HT 201
0 Mike ysRC
eys RC
Center of gravity is right on this line. The plane should balance when held here.
Build Materials
*45 inches X 35 inches sheet of 3/16 inch black Foam core for the fuselage, wing and tail. *About 3 popsicle sticks. *16 guage galvanized steel wire on a roll(from a hardware store) or RC pushrods. About 10 inches are needed. *Hot glue or 5 min epoxy. *Thick packing tape for control surface hinges. *4 12 inch wooden BBQ skewers * Stickey backed velcro to hold down motor speed controler and batteries.
Plane Requirements
*1 11.1V 1300-1600mAh 20C Li-po. battery. *1 40 amp speed controler. *1 4300KV brushless inrunner motor. *1 64mm Ducted Fan. *2 9 gram servos.
Glue this edge to the wing / fuselage.
www.MikeysRC.com
Do
This is just a suggested area to cut out to mount your ducted fan. As ducted fan shrouds differ in size and shape plaese cut out your hole for your specific fan. Also make sure to keep the center of gravity in mind when figuring out a place to mount your ducted fan.
NO TR
ed istr ib
ute
Do NOT Redistribute
Glue a 12 inch BBQ skewer here to help support the wing. Then cover with packing tape.
7 2.
Glue a 12 inch BBQ skewer here to help support the wing. Then cover with packing tape.
AIL V T
AN
th is
G GLE UID E
sid e