Beruflich Dokumente
Kultur Dokumente
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
Inside my laptop Do-It-Yourself laptop and notebook repair tips and tricks RSS Home Laptop Repair Tools Most Popular Guides Recover Files From Broken Laptop
Me gusta
23
In this guide I explain how to disassemble a Dell Studio 1555 laptop. Ill show how to take it apart completely and remove all major parts. With this guide youll be able to: - access laptop hard drive, memory, CMOS battery. - remove and replace keyboard. - remove and replace DVD optical drive. - remove motherboard. - remove and clean the cooling fan assembly. - access and DC jack harness. etc Before you start, make sure the laptop is powered off and battery removed. STEP 1. Start laptop disassemble with removing the memory card and hard drive cover which is secured by three screws.
1 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 2. Under the cover youll get an access to both memory modules/slots, hard drive, wireless card and CMOS battery. Also, some Dell Studio 1555 models can be equipped with WWAN and WPAN cards. Remove four screws securing the hard drive. Slide the hard drive to the right to disconnect it from the motherboard.
STEP 3. Lift up and remove the hard drive. If you replacing the hard drive, youll have to transfer mounting brackets to the new drive. My Dell Studio 1555 laptop has a regular 2.5 SATA hard drive which can be upgraded to a SSD hard drive (expensive but quite and fast).
2 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 4. In order to release the memory module youll have to spread latches on both sides of the memory slot. The memory module will pop up at a 30 degree angle. Pull both memory modules from slots. Dell Studio 1555 laptop uses DDR2 PC2-6400 memory. It can take up to 8GB total (up to 4GB RAM in each slot). If you want to use more than 4GB RAM, youll have to run a 64-bit operating system.
3 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 6. Carefully lift up the upper side of the center control cover and slide it towards the display.
4 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 9. Lift up the keyboard and place it upside down on the palm rest. Be careful. The keyboard still attached to the motherboard. There are two ribbon cables running from the keyboard to the motherboard. Before you can remove the keyboard, its necessary to unlock both connectors and release cables.
5 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 10. You can unlock both connectors using the same method. Lift up the right side of the locking tab. It will open up at a 90 degree angle.
STEP 11. On the following picture the connector shown in the unlocked position. Now you can pull the cable from the connector. Open up another connector using same method.
6 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 12. Remove the keyboard. Now you can replace it with a new keyboard if needed.
STEP 13. Disconnect both antenna cables from the wireless card. If you have WWAN and WPAN cards installed, disconnect antenna cables from them too. I would suggest making notes how those cables are connected.
7 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 14. Unroute all antenna cables. Remove two screws securing display hinges on the bottom of the laptop.
8 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 16. Unroute display cables and pull antenna cables though the opening in the top cover. Remove two screws securing the display hinges.
STEP 17. Lift up and remove the display assembly. In one of the following posts I explain how to take apart the display assembly and remove the LCD screen.
9 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 18. Remove eight screws from the bottom of the laptop.
STEP 19. Remove ten more screws from the top cover. Disconnect shown cables from the motherboard.
10 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 20. Start separating the top cover assembly from the bottom cover.
STEP 21. Continue separating the top cover. Im using a guitar pick as a case cracker.
11 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 23. Remove one screw securing the CD/DVD optical drive.
12 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 24. Lift up the front side of the CD/DVD optical drive and disconnect it from the motherboard.
13 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 27. Remove the ExpressCard board. As you noticed, I disconnected cables from the card itself and left them connected to the motherboard.
STEP 28. Remove six screws securing the motherboard. Disconnect three shown cables from the motherboard.
14 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 29. Lift up the right side of the motherboard and carefully pull it from the bottom case.
15 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 31. On the bottom side of the motherboard youll get an access to the cooling module (cooling fan and heat sink). If the cooling fan and heat sink look dusty, you can blow it off with compressed air. Also, cleaning the cooling module will fix any possible laptop overheating issues. Noisy fan? New Dell Studio 1555 fans available here.
STEP 32. If you would like to replace the cooling module or apply new thermal grease on the CPU, youll have to remove it. Loosen six screws securing the cooling module and disconnect the cooling fan cable from the motherboard. Now you can separate the cooling module from the motherboard and access the CPU.
16 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
STEP 33. The DC jack (power connector) in Dell Studio 1555 laptop is not soldered to the motherboard. The DC jack attached to the power harness which can be unplugged from the motherboard (we did it in the step 28). If your DC jack failed, just replace the entire DC jack harness.
Its possible this guide will work for some other Dell Studio laptops. If it works for you, please mention the model in comments below.
Did I help you $ave some money? Please consider making a donation. Thank you!
17 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
@Jay My Studio 1555 has an overheating issue with the GPU and therefore would like to investigate the cooling system on it. As this appears to be a lengthy process to take apart Ill dedicate a few hours on Saturday and post back how I get on and what parts I didnt have to disassemble. If anyone has some hints or tips before I get to work Id really appreciate them. Thanks for the guide, very detailed apart from mentioning the graphics card (I assume your machine has the integrated one?). 15 Jay Says:
August 30th, 2011 at 12:10 pm
Hi. This is a very thorough guide but is it possible to get an access to the video card without removing LCD or taking out the motherboard? 14 Gecco Says:
August 28th, 2011 at 11:41 am
hiican you help me whether i can change my usb ports from 2.0 to 3.0?.my laptop is acer 5745gdoes acer 5745g has facility to change its USB ports from 2.0 to 3.0??please kindly help methank you:) 11 Ron Says:
August 19th, 2011 at 7:08 pm
Thank you! You saved me having to buy a new laptop 10 Garvil Says:
August 16th, 2011 at 12:00 am
And it works for Dell Studio 1557 & 1558 9 Garvil Says:
August 11th, 2011 at 5:33 am
18 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
I have to replace the power button cable. To what degree of disassembly do I need to do to accomplish this? I think the cable I bought has a wifi connection as well. Great detail by the way. Fantastic help. Pages: [2] 1 Show All
Leave a Reply
Name (required) Mail (will not be published) (required) Website
Categories
1. Acer Laptops 2. Asus Laptops 3. Compaq & HP Laptops 4. Dell Laptops 5. Gateway Laptops 6. IBM & Lenovo Laptops 7. Sony Laptops 8. Toshiba Laptops 9. Other Laptop Brands Backlight BIOS password Bluetooth CD/DVD drive CMOS battery Cooling fan Diagnostic utility Disassembly help Display hinges Ethernet port Fun projects Graphics card Hard drive Keyboard LCD screen Memory Overheating Power jack Processor (CPU) Screen inverter Screen problems Sound problem Startup problems Video problems Wireless card
19 of 20
21/11/2011 12:53 PM
http://www.insidemylaptop.com/how-to-disassemble-dell-studio-1555-...
Recent Posts
How to disassemble Acer Aspire 4810T 4810TZ 4410 series laptop How to replace LED LCD screen on Dell Inspiron 1750 laptop Replacing keyboard on Dell Inspiron 1750 laptop How to replace keyboard on Acer Aspire 5733 laptop Replacing cracked LCD screen on Dell Inspiron 1545 laptop How to replace broken screen on HP 2000 laptop Upgrading memory and hard drive on Lenovo G570 laptop How to disassemble Gateway NV7802u laptop How to replace keyboard on Lenovo ThinkPad T410s laptop Taking apart Dell Inspiron N5010 (Inspiron 15R) laptop
Warning!
Static electricity can kill your laptop. I recommend wearing an anti-static wrist strap while working with internal parts of your laptop.
Popular posts Taking apart Acer Aspire 5100 laptop How to take apart HP Pavilion dv6000 laptop How to repair damaged power jack in Toshiba Satellite L305 and L355 laptops How to remove and replace damaged LCD screen in HP G50/G60/G70 notebooks How to remove LCD screen and inverter from HP Pavilion dv6000 laptop How to disassemble HP Pavilion dv6500, dv6600, dv6700, dv6800 notebooks HP Pavillion dv9000 laptop. How to remove LCD screen and inverter board. How to disassemble Compaq Presario F700 notebook How to disassemble HP Pavilion dv7 series notebook HP Pavilion dv9000 laptop. Removing hard drive, memory, wireless card, keyboard. Copyright 2011 Inside my laptop All Rights Reserved THEME by I SOFTWARE REVIEWS Terms and Conditions | Privacy Policy
20 of 20
21/11/2011 12:53 PM