Beruflich Dokumente
Kultur Dokumente
Document No.: Prepared by: Patjun Paul Palo/ Allan M. de Guzman Subject: Page 1 of 3
1.0Objectives
1.1 1.2 To troubleshoot sites which are experiencing weak signal coverage. To provide optimum signal coverage.
2.0Scope of Activity
2.1. Preparations of CDMA BTS Antennas and delivery to corresponding site. 2.2. Pre-drivetest. 2.3. Conducting of RX Level (received signal) measurements using BWL unit on various test points prior to the troubleshooting/change-out/cut-over activity (to be identified and performed on site by Network Operations). 2.4. Recording of results of RX Level (received signal) measurements. 2.5. Installation of new CDMA BTS antennas (3 sectors). 2.6. Blocking of existing site per sector. 2.7. Actual CDMA BTS antenna troubleshooting/change-out/cut-over per sector. 2.8. Conducting of test calls using BWL unit. 2.9. Conducting of RX Level (received signal) measurements using BWL unit on various test points after change-out/cut-over activity (to be identified and performed on site by Network Operations). 2.10. Recording of results of RX Level (received signal) measurements. 2.11. Post-drivetest and site optimization.
3.0Staff Arrangement
Listed below are the contact persons with their corresponding contact numbers for this activity.
Station
Network Operations Mindanao Network Operations Cagayan de Oro Network Operations Cagayan de Oro TAC BTI Engineering BTI Engineering
Contact Person
Leonardo G. Argoncillo
Contact Number/s
(6382) 301 9268
Evaristo V. Bilbao
Alvin R. Tumasis
4.0
4.1
Pre-conditions
All external jumper cables per sector must be properly labeled for easy identification. 4.2 No major alarms are present.
Engineering
TAC Operations
Approved window time Approved window time Approved window time Approved window time Approved window time Approved window time Approved window time Approved window time Approved window time -
Operations Operations TNOC, Operations TNOC, Operations Operations TNOC, Operations TNOC, Operations Operations TNOC, Operations TNOC, Operations Operations Operations
on pre-identified various test points on site (test points to be identified on site by Operations) 16. Record RX level (received signal) measurements results. 17. Conduct post-drivetest and site optimization
Operations TAC