Beruflich Dokumente
Kultur Dokumente
Data Sheet
Description
Features
Specifications
2 GHz, 4.0V, 135 mA (Typ.)
3GX
S
Top View
Applications
! Front-end LNA Q1 and Q2, Driver or Pre-driver Amplifier for Cellular/PCS and WCDMA wireless infrastructure
S
G
Bottom View
Notes:
Package marking provides orientation and identification:
3G = Device Code
x = Month code indicates the month of manufacture.
D = Drain
S = Source
G = Gate
Parameter
[2]
DrainSource Voltage
[2]
Units
Absolute
Maximum
-5 to 1.0
Vgs
GateSource Voltage
Vgd
-5 to 1.0
Ids
Drain Current[2]
mA
300
Igs
Gate Current
mA
20
[3]
Pdiss
1.0
Pin max.
RF Input Power
dBm
+24
Tch
Channel Temperature
150
Tstg
Storage Temperature
-65 to 150
Thermal Resistance[2,4]
#ch-b = 70C/W
Notes:
1. Operation of this device above any one of
these parameters may cause permanent
damage.
2. Assuming DC quiescent conditions.
3. Board (package belly) temperature TB is
25C. Derate 14.30 mW/C for TB > 80C.
4. Channel-to-board thermal resistance
measured using 150C Liquid Crystal Measurement method.
Units
Min.
Typ.
Max.
Vgs
0.65
Vth
Threshold Voltage
0.30
Ids
3.70
Gm
Transconductance
650
Igss
-10.0
-0.34
NF
Noise Figure
f=900 MHz
f=2.0 GHz
f=2.4 GHz
dB
dB
dB
0.80
0.85
1.00
1.3
Gain [1]
f=900 MHz
f=2.0 GHz
f=2.4 GHz
dB
dB
dB
14.0
17.2
15.5
15.0
17.0
OIP3
f=900 MHz
f=2.0 GHz
f=2.4 GHz
dBm
dBm
dBm
36.0
42.0
40.0
38.6
P1dB
f=900 MHz
f=2.0 GHz
f=2.4 GHz
dBm
dBm
dBm
21.7
23.0
23.2
PAE
f=900 MHz
f=2.0 GHz
f=2.4 GHz
%
%
%
33.8
46.0
49.0
ACLR
Offset BW = 5 MHz
Offset BW = 10 MHz
dBc
dBc
-54.0
-64.0
Notes:
1. Measurements at 2 GHz obtained using production test board described in Figure 1.
2. ACLR test spec is based on 3GPP TS 25.141 V5.3.1 (2002-06)
- Test Model 1
- Active Channels: PCCPCH + SCH + CPICH + PICH + SCCPCH + 64 DPCH (SF=128)
- Freq = 2140 MHz
- Pin = -8 dBm
- Channel Integrate Bandwidth = 3.84 MHz
Input
DUT
Output
Figure 1. Block diagram of the 2 GHz production test board used for NF, Gain, OIP3 , P1dB, PAE and
ACLR measurements. This circuit achieves a trade-off between optimal OIP3, P1dB and VSWR. Circuit
losses have been de-embedded from actual measurements.
150
Stdev=0.08
Stdev=0.86
120
FREQUENCY
FREQUENCY
120
90
3 Std
+3 Std
60
90
3 Std
+3 Std
60
30
30
.5
36 37 38 39 40 41 42 43 44 45
.6
.7
.8
1.1
150
150
Stdev=1.14
Stdev=0.22
120
90
3 Std
+3 Std
60
FREQUENCY
120
FREQUENCY
.9
NF (dB)
OIP3 (dBm)
90
3 Std
+3 Std
60
30
30
0
14.5
15
15.5
16
16.5
Gain (dB)
19
20
21
22
23
24
25
26
P1dB (dBm)
Notes:
1. Distribution data sample size is 500 samples taken from 3 different wafers. Future wafers
allocated to this product may have nominal values anywhere between the upper and lower
limits.
2. Measurements are made on production test board, which represents a trade-off between
optimal OIP3, P1dB and VSWR. Circuit losses have been de-embedded from actual measurements.
Gamma Source
Mag
Ang (deg)
Gamma Load
Mag
Ang (deg)
OIP3
(dBm)
Gain
(dB)
P1dB
(dBm)
PAE
(%)
0.9
0.8179
-143.28
0.0721
124.08
42.0
17.2
21.7
33.8
2.0
0.7411
-112.36
0.4080
119.91
41.6
15.6
23.4
44.2
3.9
0.6875
-94.23
0.4478
174.74
41.3
11.2
23.1
41.4
5.8
0.5204
-75.91
0.3525
-120.13
36.9
5.6
22.4
25.7
Note:
1. Typical describes additional product performance information that is not covered by the product warranty.
400
0.9V
350
Ids (mA)
300
0.8V
250
0.7V
200
150
0.6V
100
0.5V
50
0
Vds (V)
45
45
40
40
40
35
35
35
3V
4V
5V
25
20
75
90
105
120
135
150
165
30
3V
4V
5V
25
20
75
180
90
105
Ids (mA)
135
150
165
20
75
180
18
12
17
17
10
16
15
14
120
135
150
165
16
15
14
3V
4V
5V
13
GAIN (dB)
18
GAIN (dB)
14
105
13
12
75
180
90
105
120
135
150
165
3V
4V
5V
90
105
120
135
150
165
3V
4V
5V
180
Ids (mA)
0
75
135
150
165
180
60
Gain_3V
Pout_3V
PAE_3V
90
105
120
135
150
165
180
40
15
30
10
20
10
0
-14
0
-10
-6
Ids (mA)
50
20
-2
10
Pin (dBm)
Note:
Bias current for the above charts are quiescent conditions. Actual level may increase depending on amount of RF drive.
120
30
OIP3 (dBm)
GAIN (dB)
3V
4V
5V
90
105
25
25
180
Ids (mA)
30
165
0
75
180
35
150
40
135
Ids (mA)
120
3V
4V
5V
Ids (mA)
20
75
105
19
90
90
Ids (mA)
19
12
75
3V
4V
5V
25
Ids (mA)
GAIN (dB)
120
30
PAE (%)
30
OIP3 (dBm)
45
OIP3 (dBm)
OIP3 (dBm)
ATF-53189 Typical Performance Curves (at 25C unless specified otherwise), continued
Tuned for Optimal OIP3 at Vd = 4.0V, Ids = 135 mA.
15
30
10
20
10
20
10
0
-14
PAE (%)
30
10
-10
-6
Pin (dBm)
30
30
10
20
10
-2
10
60
Gain_3V
Pout_3V
PAE_3V
25
20
40
15
30
10
20
10
14
20
10
10
0
-10
14
0
-6
-2
30
60
Gain_5V
Pout_5V
PAE_5V
30
10
20
10
0
-10
Pin (dBm)
PAE (%)
15
14
18
10
14
30
Gain_3V
Pout_3V
PAE_3V
25
25
20
20
15
15
10
10
10
18
0
-6
-2
Pin (dBm)
10
14
18
22
Pin (dBm)
Note:
Bias current for the above charts are quiescent conditions. Actual level may increase depending on amount of RF drive.
10
30
50
40
-2
-6
Pin (dBm)
20
18
50
10
0
-10
PAE (%)
30
30
25
14
15
10
40
10
-2
20
20
-6
50
10
0
-6
Pin (dBm)
30
50
0
-10
15
60
0
10
Pin (dBm)
Gain_4V
Pout_4V
PAE_4V
-2
10
40
14
30
-6
20
0
-10
10
60
Pin (dBm)
25
20
Gain_5V
Pout_5V
PAE_5V
25
15
-2
10
30
50
40
-6
30
60
Gain_4V
Pout_4V
PAE_4V
20
0
-10
15
Pin (dBm)
25
-2
40
-2
15
50
20
-6
40
PAE (%)
-10
20
25
PAE (%)
0
-14
50
60
Gain_3V
Pout_3V
PAE_3V
PAE (%)
40
25
30
PAE (%)
20
60
Gain_5V
Pout_5V
PAE_5V
PAE (%)
50
25
30
60
Gain_4V
Pout_4V
PAE_4V
PAE (%)
30
ATF-53189 Typical Performance Curves (at 25C unless specified otherwise), continued
Tuned for Optimal OIP3 at Vd = 4.0V, Ids = 135 mA.
30
Gain_4V
Pout_4V
PAE_4V
25
20
20
15
15
10
10
5
0
-6
-2
10
14
18
30
Gain_5V
Pout_5V
PAE_5V
25
25
20
20
15
15
10
10
PAE (%)
25
30
22
PAE (%)
30
0
-6
-2
Pin (dBm)
10
14
18
22
Pin (dBm)
46
16
44
14
GAIN (dB)
OIP3 (dBm)
42
40
38
-40C
25C
80C
36
34
0.5
1.5
2.5
12
10
10
-40C
25C
80C
8
6
3.5
4.5
5.5
4
0.5
6.5
1.5
2.5
3.5
4.5
5.5
6.5
FREQUENCY (GHz)
FREQUENCY (GHz)
25
45
24
P1dB (dBm)
PAE (%)
40
35
30
-40C
25C
80C
25
20
0.5
1.5
2.5
23
22
-40C
25C
80C
21
3.5
4.5
5.5
FREQUENCY (GHz)
6.5
20
0.5
1.5
2.5
3.5
4.5
5.5
6.5
FREQUENCY (GHz)
Note:
Bias current for the above charts are quiescent conditions. Actual level may increase depending on amount of RF drive.
ATF-53189 Typical Performance Curves (at 25C unless specified otherwie), continued
Tuned for Optimal OIP3 at Vd = 4.0V, Ids = 135 mA
45
18
17
40
35
GAIN (dB)
OIP3 (dBm)
16
30
15
14
13
3V
4V
5V
25
11
90
105
120
135
150
165
180
75
90
105
120
Ids (mA)
30
30
10
20
10
15
30
10
20
10
10
0
-10
14
0
-6
-2
10
14
Pin (dBm)
60
Gain_5V
Pout_5V
PAE_5V
50
20
40
15
30
10
20
10
PAE (%)
25
50
40
Pin (dBm)
0
-10
60
20
PAE (%)
15
-2
180
Gain_4V
Pout_4V
PAE_4V
25
40
-6
165
30
50
20
0
-10
150
Gain_3V
Pout_3V
PAE_3V
25
135
Ids (mA)
PAE (%)
20
75
3V
4V
5V
12
0
-6
-2
10
14
Pin (dBm)
Note:
Bias current for the above charts are quiescent conditions. Actual level may increase depending on amount of RF drive.
ATF-53189 Typical Scattering and Noise Parameters at 25C, VDS = 4.0V, IDS = 180 mA
Freq.
GHz
Mag.
Ang.
dB
S21
Mag.
Ang.
dB
S12
Mag.
Ang.
S22
Mag.
Ang.
MSG/MAG
dB
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.5
2.0
2.5
3.0
3.5
4.0
5.0
6.0
7.0
8.0
9.0
10.0
11.0
12.0
13.0
14.0
15.0
16.0
17.0
18.0
0.544
0.704
0.777
0.813
0.856
0.866
0.872
0.874
0.876
0.880
0.881
0.882
0.879
0.874
0.882
0.889
0.903
0.918
0.948
0.960
0.941
0.946
0.937
0.914
0.951
0.948
0.939
0.948
0.947
0.903
-133.2
-158.7
-169.4
-176.1
178.5
174.5
170.9
167.5
164.1
161.0
150.2
137.1
124.9
112.7
99.5
92.6
78.2
61.3
41.2
24.3
11.8
10.8
0.3
-8.0
-12.1
-20.6
-23.6
-23.1
-24.3
-32.5
31.0
25.6
22.2
19.7
17.7
16.2
14.9
13.9
12.9
12.1
9.3
6.5
4.3
2.3
0.5
-0.7
-3.5
-5.8
-8.2
-10.2
-12.4
-14.6
-16.0
-17.7
-19.2
-21.0
-21.4
-21.1
-18.9
-17.1
35.531
19.023
12.872
9.705
7.687
6.438
5.582
4.939
4.433
4.026
2.910
2.123
1.647
1.304
1.062
0.921
0.669
0.515
0.389
0.308
0.239
0.187
0.158
0.131
0.110
0.089
0.085
0.088
0.114
0.140
110.9
97.1
90.4
85.7
84.4
81.7
79.2
76.5
73.8
70.9
59.6
45.9
33.4
21.1
11.3
1.5
-19.8
-41.5
-59.6
-79.9
-100.5
-109.4
-124.9
-138.0
-153.4
-168.9
177.8
165.9
155.2
133.4
-37.7
-37.1
-36.5
-35.9
-35.4
-34.9
-34.4
-33.6
-33.2
-32.4
-30.5
-28.6
-27.3
-26.6
-26.0
-25.8
-25.2
-25.7
-26.0
-26.7
-28.4
-31.1
-34.4
-46.0
-40.0
-37.1
-39.2
-37.7
-41.9
-35.4
0.013
0.014
0.015
0.016
0.017
0.018
0.019
0.021
0.022
0.024
0.030
0.037
0.043
0.047
0.050
0.051
0.055
0.052
0.050
0.046
0.038
0.028
0.019
0.005
0.010
0.014
0.011
0.013
0.008
0.017
31.7
25.2
24.9
26.3
30.4
32.6
34.5
35.9
36.8
37.1
35.8
31.0
25.0
18.3
12.6
7.1
-5.3
-22.4
-39.5
-55.9
-73.5
-81.6
-108.3
-147.3
71.0
30.2
-4.9
-8.8
-173.5
161.7
0.692
0.738
0.749
0.752
0.756
0.755
0.755
0.753
0.755
0.753
0.753
0.752
0.768
0.766
0.773
0.779
0.793
0.806
0.809
0.844
0.882
0.896
0.872
0.916
0.877
0.882
0.865
0.864
0.856
0.835
-163.7
-173.2
-177.6
179.3
175.7
173.5
171.4
169.4
167.5
165.6
158.4
150.1
142.3
135.5
131.8
123.3
102.9
84.7
69.9
54.6
37.0
27.1
20.3
7.0
-1.1
-7.5
-19.2
-26.2
-33.6
-42.5
34.4
31.3
29.3
27.8
26.6
25.5
24.7
23.7
23.0
22.2
19.2
16.0
13.4
11.5
10.0
9.4
7.0
5.2
3.2
2.1
1.4
0.1
-1.8
-1.3
-4.4
-6.3
-7.2
-6.9
-4.7
-3.2
Freq
GHz
Fmin
dB
Gamma Opt
Mag
Ang
0.5
0.9
1.0
1.5
2.0
2.4
3.0
3.5
5.0
5.8
6.0
7.0
8.0
9.0
10.0
0.65
0.76
0.79
0.86
0.94
1.00
1.10
1.17
1.41
1.53
1.56
1.72
1.87
2.03
2.18
0.394
0.417
0.423
0.465
0.509
0.545
0.600
0.645
0.777
0.840
0.855
0.920
0.970
0.993
0.997
163.6
172.4
175.3
-165.4
-147.7
-134.6
-116.7
-103.3
-70.0
-56.1
-52.9
-39.0
-27.5
-19.1
-7.5
Rn/50
0.11
0.09
0.08
0.08
0.06
0.08
0.16
0.28
0.35
0.41
0.42
0.51
0.97
1.88
2.54
40
Ga
dB
25.82
21.83
21.71
18.70
17.63
16.45
14.90
13.53
11.35
10.31
10.38
9.79
7.91
6.11
4.56
MSG
30
S11
20
MAG
10
S21
0
-10
-20
10
12
14
16 18
FREQUENCY (GHz)
Notes:
1. Fmin values at 2 GHz and higher are based on measurements while the Fmin below 2 GHz have been extrapolated. The Fmin values are based on
a set of 16 noise figure measurements made at 16 different impedances using an ATN NP5 test system. From these measurements a true Fmin
is calculated. Refer to the noise parameter application section for more information.
2. S and noise parameters are measured on a microstrip line made on 0.025 inch thick alumina carrier. The input reference plane is at the end of
the gate lead. The output reference plane is at the end of the drain lead.
ATF-53189 Typical Scattering and Noise Parameters at 25C, VDS = 4.0V, IDS = 135 mA
Freq.
GHz
Mag.
Ang.
dB
S21
Mag.
Ang.
dB
S12
Mag.
Ang.
S22
Mag.
Ang.
MSG/MAG
dB
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.5
2.0
2.5
3.0
3.5
4.0
5.0
6.0
7.0
8.0
9.0
10.0
11.0
12.0
13.0
14.0
15.0
16.0
17.0
18.0
0.544
0.704
0.777
0.813
0.856
0.866
0.872
0.874
0.876
0.880
0.881
0.882
0.879
0.874
0.882
0.889
0.903
0.918
0.948
0.960
0.941
0.946
0.937
0.914
0.951
0.948
0.939
0.948
0.947
0.903
-133.2
-158.7
-169.4
-176.1
178.5
174.5
170.9
167.5
164.1
161.0
150.2
137.1
124.9
112.7
99.5
92.6
78.2
61.3
41.2
24.3
11.8
10.8
0.3
-8.0
-12.1
-20.6
-23.6
-23.1
-24.3
-32.5
31.0
25.6
22.2
19.7
17.7
16.2
14.9
13.9
12.9
12.1
9.3
6.5
4.3
2.3
0.5
-0.7
-3.5
-5.8
-8.2
-10.2
-12.4
-14.6
-16.0
-17.7
-19.2
-21.0
-21.4
-21.1
-18.9
-17.1
35.531
19.023
12.872
9.705
7.687
6.438
5.582
4.939
4.433
4.026
2.910
2.123
1.647
1.304
1.062
0.921
0.669
0.515
0.389
0.308
0.239
0.187
0.158
0.131
0.110
0.089
0.085
0.088
0.114
0.140
110.9
97.1
90.4
85.7
84.4
81.7
79.2
76.5
73.8
70.9
59.6
45.9
33.4
21.1
11.3
1.5
-19.8
-41.5
-59.6
-79.9
-100.5
-109.4
-124.9
-138.0
-153.4
-168.9
177.8
165.9
155.2
133.4
-37.7
-37.1
-36.5
-35.9
-35.4
-34.9
-34.4
-33.6
-33.2
-32.4
-30.5
-28.6
-27.3
-26.6
-26.0
-25.8
-25.2
-25.7
-26.0
-26.7
-28.4
-31.1
-34.4
-46.0
-40.0
-37.1
-39.2
-37.7
-41.9
-35.4
0.013
0.014
0.015
0.016
0.017
0.018
0.019
0.021
0.022
0.024
0.030
0.037
0.043
0.047
0.050
0.051
0.055
0.052
0.050
0.046
0.038
0.028
0.019
0.005
0.010
0.014
0.011
0.013
0.008
0.017
31.7
25.2
24.9
26.3
30.4
32.6
34.5
35.9
36.8
37.1
35.8
31.0
25.0
18.3
12.6
7.1
-5.3
-22.4
-39.5
-55.9
-73.5
-81.6
-108.3
-147.3
71.0
30.2
-4.9
-8.8
-173.5
161.7
0.692
0.738
0.749
0.752
0.756
0.755
0.755
0.753
0.755
0.753
0.753
0.752
0.768
0.766
0.773
0.779
0.793
0.806
0.809
0.844
0.882
0.896
0.872
0.916
0.877
0.882
0.865
0.864
0.856
0.835
-163.7
-173.2
-177.6
179.3
175.7
173.5
171.4
169.4
167.5
165.6
158.4
150.1
142.3
135.5
131.8
123.3
102.9
84.7
69.9
54.6
37.0
27.1
20.3
7.0
-1.1
-7.5
-19.2
-26.2
-33.6
-42.5
34.4
31.3
29.3
27.8
26.6
25.5
24.7
23.7
23.0
22.2
19.2
16.0
13.4
11.5
10.0
9.4
7.0
5.2
3.2
2.1
1.4
0.1
-1.8
-1.3
-4.4
-6.3
-7.2
-6.9
-4.7
-3.2
Freq
GHz
Fmin
dB
Gamma Opt
Mag
Ang
0.5
0.9
1.0
1.5
2.0
2.4
3.0
3.5
5.0
5.8
6.0
7.0
8.0
9.0
10.0
0.30
0.41
0.44
0.53
0.62
0.69
0.80
0.89
1.16
1.31
1.34
1.52
1.71
1.89
2.07
0.162
0.291
0.302
0.369
0.433
0.484
0.556
0.613
0.764
0.832
0.848
0.914
0.963
0.991
0.998
150.8
161.3
164.2
-174.2
-154.6
-140.2
-120.6
-106.1
-71.0
-56.6
-53.4
-39.3
-27.9
-18.2
-9.2
Rn/50
0.05
0.05
0.05
0.04
0.04
0.05
0.10
0.19
0.26
0.30
0.30
0.39
0.77
0.96
1.58
40
Ga
dB
26.27
22.12
22.02
18.95
17.05
15.87
14.63
13.21
11.19
10.26
10.04
9.64
8.68
6.57
4.51
MSG
30
S11
20
MAG
10
S21
0
-10
-20
10
12
14
16 18
FREQUENCY (GHz)
Notes:
1. Fmin values at 2 GHz and higher are based on measurements while the Fmin below 2 GHz have been extrapolated. The Fmin values are based on
a set of 16 noise figure measurements made at 16 different impedances using an ATN NP5 test system. From these measurements a true Fmin
is calculated. Refer to the noise parameter application section for more information.
2. S and noise parameters are measured on a microstrip line made on 0.025 inch thick alumina carrier. The input reference plane is at the end of
the gate lead. The output reference plane is at the end of the drain lead.
10
ATF-53189 Typical Scattering and Noise Parameters at 25C, VDS = 4.0V, IDS = 75 mA
Freq.
GHz
Mag.
Ang.
dB
S21
Mag.
Ang.
dB
S12
Mag.
Ang.
S22
Mag.
Ang.
MSG/MAG
dB
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.5
2.0
2.5
3.0
3.5
4.0
5.0
6.0
7.0
8.0
9.0
10.0
11.0
12.0
13.0
14.0
15.0
16.0
17.0
18.0
0.544
0.704
0.777
0.813
0.856
0.866
0.872
0.874
0.876
0.880
0.881
0.882
0.879
0.874
0.882
0.889
0.903
0.918
0.948
0.960
0.941
0.946
0.937
0.914
0.951
0.948
0.939
0.948
0.947
0.903
-133.2
-158.7
-169.4
-176.1
178.5
174.5
170.9
167.5
164.1
161.0
150.2
137.1
124.9
112.7
99.5
92.6
78.2
61.3
41.2
24.3
11.8
10.8
0.3
-8.0
-12.1
-20.6
-23.6
-23.1
-24.3
-32.5
31.0
25.6
22.2
19.7
17.7
16.2
14.9
13.9
12.9
12.1
9.3
6.5
4.3
2.3
0.5
-0.7
-3.5
-5.8
-8.2
-10.2
-12.4
-14.6
-16.0
-17.7
-19.2
-21.0
-21.4
-21.1
-18.9
-17.1
35.531
19.023
12.872
9.705
7.687
6.438
5.582
4.939
4.433
4.026
2.910
2.123
1.647
1.304
1.062
0.921
0.669
0.515
0.389
0.308
0.239
0.187
0.158
0.131
0.110
0.089
0.085
0.088
0.114
0.140
110.9
97.1
90.4
85.7
84.4
81.7
79.2
76.5
73.8
70.9
59.6
45.9
33.4
21.1
11.3
1.5
-19.8
-41.5
-59.6
-79.9
-100.5
-109.4
-124.9
-138.0
-153.4
-168.9
177.8
165.9
155.2
133.4
-37.7
-37.1
-36.5
-35.9
-35.4
-34.9
-34.4
-33.6
-33.2
-32.4
-30.5
-28.6
-27.3
-26.6
-26.0
-25.8
-25.2
-25.7
-26.0
-26.7
-28.4
-31.1
-34.4
-46.0
-40.0
-37.1
-39.2
-37.7
-41.9
-35.4
0.013
0.014
0.015
0.016
0.017
0.018
0.019
0.021
0.022
0.024
0.030
0.037
0.043
0.047
0.050
0.051
0.055
0.052
0.050
0.046
0.038
0.028
0.019
0.005
0.010
0.014
0.011
0.013
0.008
0.017
31.7
25.2
24.9
26.3
30.4
32.6
34.5
35.9
36.8
37.1
35.8
31.0
25.0
18.3
12.6
7.1
-5.3
-22.4
-39.5
-55.9
-73.5
-81.6
-108.3
-147.3
71.0
30.2
-4.9
-8.8
-173.5
161.7
0.692
0.738
0.749
0.752
0.756
0.755
0.755
0.753
0.755
0.753
0.753
0.752
0.768
0.766
0.773
0.779
0.793
0.806
0.809
0.844
0.882
0.896
0.872
0.916
0.877
0.882
0.865
0.864
0.856
0.835
-163.7
-173.2
-177.6
179.3
175.7
173.5
171.4
169.4
167.5
165.6
158.4
150.1
142.3
135.5
131.8
123.3
102.9
84.7
69.9
54.6
37.0
27.1
20.3
7.0
-1.1
-7.5
-19.2
-26.2
-33.6
-42.5
34.4
31.3
29.3
27.8
26.6
25.5
24.7
23.7
23.0
22.2
19.2
16.0
13.4
11.5
10.0
9.4
7.0
5.2
3.2
2.1
1.4
0.1
-1.8
-1.3
-4.4
-6.3
-7.2
-6.9
-4.7
-3.2
Freq
GHz
Fmin
dB
Gamma Opt
Mag
Ang
0.5
0.9
1.0
1.5
2.0
2.4
3.0
3.5
5.0
5.8
6.0
7.0
8.0
9.0
10.0
0.32
0.41
0.43
0.49
0.56
0.61
0.69
0.75
0.95
1.05
1.08
1.21
1.34
1.47
1.60
0.175
0.224
0.235
0.306
0.375
0.428
0.507
0.569
0.738
0.814
0.831
0.907
0.961
0.992
0.996
127.6
143.8
148.3
173.6
-163.6
-147.2
-125.3
-109.3
-72.0
-57.4
-54.2
-40.5
-29.3
-19.3
-8.9
Rn/50
0.05
0.04
0.03
0.03
0.03
0.04
0.08
0.14
0.20
0.24
0.24
0.30
0.60
0.71
1.01
40
Ga
dB
26.45
21.98
21.50
18.55
16.33
15.18
13.86
12.68
10.81
10.64
9.97
9.25
7.78
6.96
4.46
MSG
30
S11
20
MAG
10
0
S21
-10
-20
-30
0
10
12
14
16 18
FREQUENCY (GHz)
Notes:
1. Fmin values at 2 GHz and higher are based on measurements while the Fmin below 2 GHz have been extrapolated. The Fmin values are based on
a set of 16 noise figure measurements made at 16 different impedances using an ATN NP5 test system. From these measurements a true Fmin
is calculated. Refer to the noise parameter application section for more information.
2. S and noise parameters are measured on a microstrip line made on 0.025 inch thick alumina carrier. The input reference plane is at the end of
the gate lead. The output reference plane is at the end of the drain lead.
11
ATF-53189 Typical Scattering and Noise Parameters at 25C, VDS = 5.0V, IDS = 135 mA
Freq.
GHz
Mag.
Ang.
dB
S21
Mag.
Ang.
dB
S12
Mag.
Ang.
S22
Mag.
Ang.
MSG/MAG
dB
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.5
2.0
2.5
3.0
3.5
4.0
5.0
6.0
7.0
8.0
9.0
10.0
11.0
12.0
13.0
14.0
15.0
16.0
17.0
18.0
0.544
0.704
0.777
0.813
0.856
0.866
0.872
0.874
0.876
0.880
0.881
0.882
0.879
0.874
0.882
0.889
0.903
0.918
0.948
0.960
0.941
0.946
0.937
0.914
0.951
0.948
0.939
0.948
0.947
0.903
-133.2
-158.7
-169.4
-176.1
178.5
174.5
170.9
167.5
164.1
161.0
150.2
137.1
124.9
112.7
99.5
92.6
78.2
61.3
41.2
24.3
11.8
10.8
0.3
-8.0
-12.1
-20.6
-23.6
-23.1
-24.3
-32.5
31.0
25.6
22.2
19.7
17.7
16.2
14.9
13.9
12.9
12.1
9.3
6.5
4.3
2.3
0.5
-0.7
-3.5
-5.8
-8.2
-10.2
-12.4
-14.6
-16.0
-17.7
-19.2
-21.0
-21.4
-21.1
-18.9
-17.1
35.531
19.023
12.872
9.705
7.687
6.438
5.582
4.939
4.433
4.026
2.910
2.123
1.647
1.304
1.062
0.921
0.669
0.515
0.389
0.308
0.239
0.187
0.158
0.131
0.110
0.089
0.085
0.088
0.114
0.140
110.9
97.1
90.4
85.7
84.4
81.7
79.2
76.5
73.8
70.9
59.6
45.9
33.4
21.1
11.3
1.5
-19.8
-41.5
-59.6
-79.9
-100.5
-109.4
-124.9
-138.0
-153.4
-168.9
177.8
165.9
155.2
133.4
-37.7
-37.1
-36.5
-35.9
-35.4
-34.9
-34.4
-33.6
-33.2
-32.4
-30.5
-28.6
-27.3
-26.6
-26.0
-25.8
-25.2
-25.7
-26.0
-26.7
-28.4
-31.1
-34.4
-46.0
-40.0
-37.1
-39.2
-37.7
-41.9
-35.4
0.013
0.014
0.015
0.016
0.017
0.018
0.019
0.021
0.022
0.024
0.030
0.037
0.043
0.047
0.050
0.051
0.055
0.052
0.050
0.046
0.038
0.028
0.019
0.005
0.010
0.014
0.011
0.013
0.008
0.017
31.7
25.2
24.9
26.3
30.4
32.6
34.5
35.9
36.8
37.1
35.8
31.0
25.0
18.3
12.6
7.1
-5.3
-22.4
-39.5
-55.9
-73.5
-81.6
-108.3
-147.3
71.0
30.2
-4.9
-8.8
-173.5
161.7
0.692
0.738
0.749
0.752
0.756
0.755
0.755
0.753
0.755
0.753
0.753
0.752
0.768
0.766
0.773
0.779
0.793
0.806
0.809
0.844
0.882
0.896
0.872
0.916
0.877
0.882
0.865
0.864
0.856
0.835
-163.7
-173.2
-177.6
179.3
175.7
173.5
171.4
169.4
167.5
165.6
158.4
150.1
142.3
135.5
131.8
123.3
102.9
84.7
69.9
54.6
37.0
27.1
20.3
7.0
-1.1
-7.5
-19.2
-26.2
-33.6
-42.5
34.4
31.3
29.3
27.8
26.6
25.5
24.7
23.7
23.0
22.2
19.2
16.0
13.4
11.5
10.0
9.4
7.0
5.2
3.2
2.1
1.4
0.1
-1.8
-1.3
-4.4
-6.3
-7.2
-6.9
-4.7
-3.2
Freq
GHz
Fmin
dB
Gamma Opt
Mag
Ang
0.5
0.9
1.0
1.5
2.0
2.4
3.0
3.5
5.0
5.8
6.0
7.0
8.0
9.0
10.0
0.36
0.46
0.49
0.59
0.69
0.77
0.88
0.98
1.28
1.44
1.48
1.68
1.88
2.08
2.28
0.266
0.315
0.327
0.388
0.448
0.495
0.563
0.617
0.764
0.830
0.845
0.912
0.960
0.988
0.994
149.9
162.4
165.6
-172.7
-153.0
-138.6
-116.3
-104.9
-70.5
-56.5
-53.4
-39.7
-28.3
-18.3
-8.5
Rn/50
0.05
0.04
0.04
0.04
0.04
0.06
0.12
0.21
0.31
0.37
0.38
0.42
0.84
1.24
1.78
40
Ga
dB
26.51
22.79
22.09
18.92
17.04
15.87
14.50
13.11
11.19
10.10
10.08
9.39
8.78
8.05
4.74
MSG
30
S11
20
MAG
10
S21
0
-10
-20
10
12
14
16 18
FREQUENCY (GHz)
Notes:
1. Fmin values at 2 GHz and higher are based on measurements while the Fmin below 2 GHz have been extrapolated. The Fmin values are based on
a set of 16 noise figure measurements made at 16 different impedances using an ATN NP5 test system. From these measurements a true Fmin
is calculated. Refer to the noise parameter application section for more information.
2. S and noise parameters are measured on a microstrip line made on 0.025 inch thick alumina carrier. The input reference plane is at the end of
the gate lead. The output reference plane is at the end of the drain lead.
12
ATF-53189 Typical Scattering and Noise Parameters at 25C, VDS = 3.0V, IDS = 135 mA
Freq.
GHz
Mag.
Ang.
dB
S21
Mag.
Ang.
dB
S12
Mag.
Ang.
S22
Mag.
Ang.
MSG/MAG
dB
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.5
2.0
2.5
3.0
3.5
4.0
5.0
6.0
7.0
8.0
9.0
10.0
11.0
12.0
13.0
14.0
15.0
16.0
17.0
18.0
0.544
0.704
0.777
0.813
0.856
0.866
0.872
0.874
0.876
0.880
0.881
0.882
0.879
0.874
0.882
0.889
0.903
0.918
0.948
0.960
0.941
0.946
0.937
0.914
0.951
0.948
0.939
0.948
0.947
0.903
-133.2
-158.7
-169.4
-176.1
178.5
174.5
170.9
167.5
164.1
161.0
150.2
137.1
124.9
112.7
99.5
92.6
78.2
61.3
41.2
24.3
11.8
10.8
0.3
-8.0
-12.1
-20.6
-23.6
-23.1
-24.3
-32.5
31.0
25.6
22.2
19.7
17.7
16.2
14.9
13.9
12.9
12.1
9.3
6.5
4.3
2.3
0.5
-0.7
-3.5
-5.8
-8.2
-10.2
-12.4
-14.6
-16.0
-17.7
-19.2
-21.0
-21.4
-21.1
-18.9
-17.1
35.531
19.023
12.872
9.705
7.687
6.438
5.582
4.939
4.433
4.026
2.910
2.123
1.647
1.304
1.062
0.921
0.669
0.515
0.389
0.308
0.239
0.187
0.158
0.131
0.110
0.089
0.085
0.088
0.114
0.140
110.9
97.1
90.4
85.7
84.4
81.7
79.2
76.5
73.8
70.9
59.6
45.9
33.4
21.1
11.3
1.5
-19.8
-41.5
-59.6
-79.9
-100.5
-109.4
-124.9
-138.0
-153.4
-168.9
177.8
165.9
155.2
133.4
-37.7
-37.1
-36.5
-35.9
-35.4
-34.9
-34.4
-33.6
-33.2
-32.4
-30.5
-28.6
-27.3
-26.6
-26.0
-25.8
-25.2
-25.7
-26.0
-26.7
-28.4
-31.1
-34.4
-46.0
-40.0
-37.1
-39.2
-37.7
-41.9
-35.4
0.013
0.014
0.015
0.016
0.017
0.018
0.019
0.021
0.022
0.024
0.030
0.037
0.043
0.047
0.050
0.051
0.055
0.052
0.050
0.046
0.038
0.028
0.019
0.005
0.010
0.014
0.011
0.013
0.008
0.017
31.7
25.2
24.9
26.3
30.4
32.6
34.5
35.9
36.8
37.1
35.8
31.0
25.0
18.3
12.6
7.1
-5.3
-22.4
-39.5
-55.9
-73.5
-81.6
-108.3
-147.3
71.0
30.2
-4.9
-8.8
-173.5
161.7
0.692
0.738
0.749
0.752
0.756
0.755
0.755
0.753
0.755
0.753
0.753
0.752
0.768
0.766
0.773
0.779
0.793
0.806
0.809
0.844
0.882
0.896
0.872
0.916
0.877
0.882
0.865
0.864
0.856
0.835
-163.7
-173.2
-177.6
179.3
175.7
173.5
171.4
169.4
167.5
165.6
158.4
150.1
142.3
135.5
131.8
123.3
102.9
84.7
69.9
54.6
37.0
27.1
20.3
7.0
-1.1
-7.5
-19.2
-26.2
-33.6
-42.5
34.4
31.3
29.3
27.8
26.6
25.5
24.7
23.7
23.0
22.2
19.2
16.0
13.4
11.5
10.0
9.4
7.0
5.2
3.2
2.1
1.4
0.1
-1.8
-1.3
-4.4
-6.3
-7.2
-6.9
-4.7
-3.2
Freq
GHz
Fmin
dB
Gamma Opt
Mag
Ang
0.5
0.9
1.0
1.5
2.0
2.4
3.0
3.5
5.0
5.8
6.0
7.0
8.0
9.0
10.0
0.34
0.43
0.45
0.53
0.61
0.68
0.78
0.86
1.10
1.24
1.27
1.43
1.60
1.76
1.93
0.225
0.282
0.296
0.362
0.427
0.478
0.551
0.608
0.763
0.832
0.848
0.915
0.964
0.991
0.995
146.2
157.0
160.2
-177.0
-156.3
-141.3
-121.1
-106.2
-70.8
-56.6
-53.5
-39.7
-28.4
-18.5
-8.6
Rn/50
0.05
0.04
0.04
0.03
0.03
0.05
0.09
0.17
0.24
0.28
0.30
0.38
0.74
0.95
1.55
40
Ga
dB
26.30
22.19
22.07
19.00
17.13
15.89
14.59
13.17
11.22
10.16
9.93
9.57
8.78
7.27
3.39
MSG
30
S11
20
MAG
10
S21
0
-10
-20
10
12
14
16 18
FREQUENCY (GHz)
Notes:
1. Fmin values at 2 GHz and higher are based on measurements while the Fmin below 2 GHz have been extrapolated. The Fmin values are based on
a set of 16 noise figure measurements made at 16 different impedances using an ATN NP5 test system. From these measurements a true Fmin
is calculated. Refer to the noise parameter application section for more information.
2. S and noise parameters are measured on a microstrip line made on 0.025 inch thick alumina carrier. The input reference plane is at the end of
the gate lead. The output reference plane is at the end of the drain lead.
13
Ordering Information
Part Number
No. of Devices
Container
ATF-53189-TR1
3000
13 Reel
ATF-53189-BLK
100
Anti-static bag
H
L
#1
#2
E1
#3
B
B1
#3
#2
#1
e1
BOTTOM
COMMON
DIMENSIONS Millimeters
SYMBOL
A
B
B1
C
D
D1
E
E1
e
e1
H
L
MIN.
1.40
0.44
0.36
0.35
4.40
1.62
2.30
2.13
1.50 BSC
3.00 BSC
3.95
0.90
NOM.
1.50
0.50
0.42
0.40
4.50
1.73
2.50
2.20
1.50 BSC
3.00 BSC
4.10
1.10
MAX.
1.60
0.56
0.48
0.44
4.60
1.83
2.60
2.29
1.50 BSC
3.00 BSC
4.25
1.20
DIMENSIONS Inches
MIN.
0.055
0.017
0.014
0.014
0.173
0.064
0.090
0.084
0.059 BSC
0.118 BSC
0.155
0.035
NOM.
0.059
0.0195
0.0165
0.016
0.177
0.068
0.096
0.087
0.059 BSC
0.188 BSC
0.161
0.038
MAX.
0.063
0.022
0.019
0.017
0.181
0.072
0.102
0.090
0.059 BSC
0.188 BSC
0.167
0.047
Notes:
1. Dimensioning and tolerancing per ANSI.Y14.5M-1982
2. Controlling dimension: Millimeter convertions to inches are not necessarily exact.
3. Dimension B1, 2 places.
14
Device Orientation
REEL
3GX
3GX
3GX
3GX
CARRIER
TAPE
USER
FEED
DIRECTION
COVER TAPE
Tape Dimensions
8.000.10
(0.3150.004)
1.500.10
(0.059+0.004)
2.000.05
(0.0690.004)
4.000.10
(0.1570.004)
1.750.10
(0.0690.004)
5.500.05
(0.2170.002)
12.00.30-0.10
(0.472+0.012-0.004)
+
1.500.25
(0.059+0.010)
0.2920.02
(0.01150.0008)
1.800.10
(0.07090.004)
6 MAX
4.800.10
(0.1890.004)
4.400.10
(0.17320.004)
Dimensions in mm (inches)
For product information and a complete list of distributors, please go to our web site: www.avagotech.com
Avago, Avago Technologies, and the A logo are trademarks of Avago Technologies in the United States and other countries.
Data subject to change. Copyright 2005-2009 Avago Technologies. All rights reserved. Obsoletes 5989-3893EN
AV02-0051EN - November 6, 2009