Beruflich Dokumente
Kultur Dokumente
Manual
BRIDGED
BRIDGEABLE
2-CH POWER AMPLIFIER
30A
30A
GM-X972/XR/UC
ORDER NO.
CRT3008
GM-X972
XR/UC,XR/EW,XR/ES
PIONEER CORPORATION
SAFETY INFORMATION
A
- GM-X972/XR/UC
CAUTION
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer.
Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair
complex products such as those covered by this manual.
Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty.
If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so
and refer the repair to a qualified service technician.
WARNING
This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of
California to cause cancer, birth defects or other reproductive harm.
Health & Safety Code Section 25249.6 - Proposition 65
1. Product safety
You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and
should keep the safety during servicing by following the safety instructions described in this manual.
2. Adjustments
To keep the original performances of the product, optimum adjustments or specification confirmation is indispensable.
In accordance with the procedures or instructions described in this manual, adjustments should be performed.
3. Cleaning
D
For optical pickups, tape-deck heads, lenses and mirrors used in projection monitors, and other parts requiring cleaning,
proper cleaning should be performed to restore their performances.
GM-X972/XR/UC
CONTENTS
SAFETY INFORMATION ............................................2
1. SPECIFICATIONS........................................................3
2. EXPLODED VIEWS AND PARTS LIST .......................4
2.1 PACKING...............................................................4
2.2 EXTERIOR .............................................................6
3. SCHEMATIC DIAGRAM .............................................8
3.1 OVERALL CONNECTION DIAGRAM(GUIDE PAGE) ....8
4. PCB CONNECTION DIAGRAM ................................14
4.1 AMP UNIT...........................................................14
5. ELECTRICAL PARTS LIST ........................................18
6. ADJUSTMENT..........................................................20
7. GENERAL INFORMATION .......................................21
7.1 DIAGNOSIS ........................................................21
7.1.1 DISASSEMBLY .........................................21
7.1.2 CONNECTOR FUNCTION DESCRIPTION .......22
7.2 IC ........................................................................23
8. OPERATIONS............................................................24
1. SPECIFICATIONS
Power source .............................................................................................................. 14.4 V DC (10.8 15.1 V allowable)
Grounding system ............................................................................................................................................ Negative type
Current consumption ........................................................................................................ 37.5 A (at continuous power, 4 )
Backup current ................................................................................................................................................. 3.0 mA or less
Average current drawn* .......................................................................................................... 12.0 A (4 for two channels)
18.5 A (4 for one channel)
Fuse ............................................................................................................................................................................ 30 A 2
Dimensions .......................................................................................................................... 269 (W) 50 (H) 309 (D) mm
[10-5/8 (W) 2 (H) 12-1/8 (D) in]
Weight ......................................................................................................... 3.7 kg (8.2 lbs) (Leads for wiring not included)
Maximum power output ...................... .............................................................................................. 300 W 2 / 800 W 1
Continuous power output ..................... .................................... 150 W 2 (at 14.4 V, 4 , 20 20,000 Hz, 0.08% THD)
400 W 1 (at 14.4 V, 4 , 20 20,000 Hz, 0.8% THD)
200 W 2 (at 14.4 V, 2 , 20 20,000 Hz, 0.8% THD)
Load impedance ............................................................................................................................ 4 (2 8 allowable)
(Bridge connection: 4 8 allowable)
Frequency response ............................................................................................................ 10 50,000 Hz (+0 dB, 1 dB)
Signal-to-noise ratio ..................... .................................................................................................. 100 dB (IHFA network)
Distortion .............................................................................................................................................. 0.008% (10 W, 1 kHz)
Separation ......................................................................................................................................................... 65 dB (1 kHz)
E
Note:
Specifications and the design are subject to possible modification without notice
due to improvements.
GM-X972/XR/UC
GM-X972/XR/UC
NOTE:
- Parts marked by * are generally unavailable because they are not in our Master Spare Parts List.
- Screws adjacent to mark on the product are used for disassembly.
- For the applying amount of lubricants or glue, follow the instructions in this manual.
( In the case of no amount instructions, apply as you think it appropriate.)
Part No.
1
2
3
4
5
Screw Assy
Screw
Polyethylene Bag
Cover
Polyethylene Bag
HEA0058
BYC40P180FZK
HEG0011
HNS0101
HEG0022
6
7
8
9
Carton
Contain Box
Protector
Owners Manual(UC)
Owners Manual(EW)
HHG0339
HHL0339
HHP0168
HRD0218
HRD0220
Owners Manual(ES)
10 Owners Manual(ES)
11 Warranty Card
12 Cord Assy
HRD0222
HRD0223
HRY1157
HDE0036
C
- Owner's Manual
Part No.
Language
HRD0218
English, French
HRD0220
English, French, Spanish, German, Italian, Dutch
HRD0222
English, Spanish
HRD0223
Portuguese(B), Arabic
GM-X972/XR/UC
2.2 EXTERIOR
GM-X972/XR/UC
Part No.
Screw
Screw
Chassis
Panel
Panel
BBZ30P060FZK
BBZ30P160FZK
HNA0013
HNB0187
HNB0190
Case
Spacer
Spacer
Heat Sink
Amp Unit(UC)
HNB0194
HNM0006
HNM0124
HNR0228
HWH0194
Amp Unit(EW)
Amp Unit(ES)
11 Screw
12 Screw
13 Terminal(CN604)
HWH0195
HWH0196
BBZ30P050FZK
BBZ30P080FMC
CKF1059
14
15
16
17
18
HEK0030
HKB0020
HKE0048
HKE0049
19
20
21
22
23,24
Fuse(30A)
Pin Jack(CN801)
Terminal(CN601)
Terminal(CN851)
Terminal(CN852)
Connector(CN803)
Holder
Clip
HKE0049
HKM1077
HNC0082
HNC0145
25
26
27
28
29
Heat Sink
Screw
Light Pipe Unit
Screw
Screw
HNR0229
PPZ30P100FZK
HXA0391
ISS30P055FUC
PPZ30P100FZK
30
31
32
33
34
Screw
HBA0029
FET(Q612,613,614,615,616,617) STP80NF55-06FP
Diode(D611)
Diode(D612)
Cushion
35 Screw
36 Screw
FML22R
FML22S
HNM6623
HBA0030
BBZ30P060FZK
E
GM-X972/XR/UC
3. SCHEMATIC DIAGRAM
3.1 OVERALL CONNECTION DIAGRAM(GUIDE PAGE)
A-a
Large size
SCH diagram
A-b
A-a
A-a
A-b
Guide page
A-a
A AMP UNIT
Detailed page
A-b
GAIN = 1
LPF SELECT
HCS0003
10k(A)
HCS0003
10k(A)
GAIN = -12dB
LPF SELECT
EW, ES ONLY
75H
BFC
75H
A
1
GM-X972/XR/UC
A-b
AMPLIFIER GAIN = 11.5 - 41.8dB
***
UC
EW, ES
R608
1R8K
5R1K
R609
1R8K
5R1K
FU603
HEK0030
***
>
EW, ES ONLY
***
FU602
HEK0030
34H
RM4Z-LFJ4
>
UC ONLY
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
GM-X972/XR/UC
A
8
GAIN = -12dB
A AMP UNIT
GAIN = 1
10
A-a
2
LPF SELECT
LPF SELECT
A-a A-b
HCS0003
10k(A)
HCS0003
10k(A)
1
2
3
2
3
GM-X972/XR/UC
BFC
A-a A-b
EW, ES ONLY
75H
75H
A-a
GM-X972/XR/UC
11
12
AMPLIFIER GAIN = 11.5 - 41.8dB
A-a A-b
A-b
GM-X972/XR/UC
***
R608
1R8K
5R1K
R609
1R8K
5R1K
UC ONLY
34H
EW, ES ONLY
>
FU602
HEK0030
>
FU603
HEK0030
A-a A-b
GM-X972/XR/UC
7
The > mark found on some component parts indicates
the importance of the safety factor of the part.
Therefore, when replacing, be sure to use parts of
identical designation.
NOTE :
Symbol indicates a resistor.
No differentiation is made between chip resistors and
discrete resistors.
Symbol indicates a capacitor.
No differentiation is made between chip capacitors and
discrete capacitors.
***
UC
EW, ES
***
5
7
8
A-b
13
RM4Z-LFJ4
SIDE A
Chip Part
P.C.Board
AMP UNIT
SIDE B
2
L+
1
R- R+
SPEAKER
INPUT
L-
R+
L+
RLINPUT
GAIN
LPF SELECT
A
14
A1
GM-X972/XR/UC
SIDE A
A
FU603
FU602
C
POWER
SUPPLY
1
SPEAKER
OUTPUT
E
2
BFC
A
A
GM-X972/XR/UC
15
AMP UNIT
C
1
A
16
A
1
GM-X972/XR/UC
SIDE B
A
L-
A
GM-X972/XR/UC
A
8
17
NOTES:
- Parts whose parts numbers are omitted are subject to being not supplied.
- The part numbers shown below indicate chip components.
Chip Resistor
RS1/_S___J,RS1/__S___J
Chip Capacitor (except for CQS.....)
CKS....., CCS....., CSZS.....
=====Circuit Symbol and No.===Part Name
--- -----------------------------------------------
A Unit Number
Unit Name
:
:
:
:
Part No.
-------------------------
HWH0194 (UC)
HWH0195 (EW)
HWH0196 (ES)
Amp Unit
MISCELLANEOUS
IC
IC
IC
IC
IC
101
301
501
502
503
IC
IC
IC
IC
IC
NJM2068D
NJM2068D
TDA7293V
TDA7293V
TDA7293V
IC
IC
IC
IC
IC
504
505
506
601
602
IC
IC
IC
IC
IC
TDA7293V
TDA7293V
TDA7293V
PA2027A
UPC494C
IC
IC
Q
Q
Q
801
802
201
202
601
IC
IC
Transistor
Transistor
Transistor
NJM2068D
NJM2068D
KSR2202
KSC1623
KSC1623
Q
Q
Q
Q
Q
602
603
604
606
607
Transistor
Transistor
Transistor
Transistor
Transistor
KSA812
2SB1243
KSR2202
2SD1919
2SD1919
Q
Q
Q
Q
Q
608
609
612
613
614
Transistor
Transistor
FET
FET
FET
2SB1277
2SB1277
STP80NF55-06FP
STP80NF55-06FP
STP80NF55-06FP
Q
Q
Q
Q
Q
615
616
617
660
661
FET
FET
FET
Transistor
Transistor
STP80NF55-06FP
STP80NF55-06FP
STP80NF55-06FP
2SD1864
2SB1243
Q
Q
Q
Q
Q
901
902
905
906
907
Transistor
Transistor
Transistor
Transistor
Transistor
KSA812
KSA812
KSA812
KSC1623
KSC1623
D
D
D
D
201
601
603
604
Diode
Diode
Diode
Diode
1SS133
RM4Z-LFJ4
HZS7L(B2)
1SS133
D
D
D
D
D
611
612
613
614
615
Diode
Diode
Diode
Diode
Diode
FML22R
FML22S
HZS16L(1)
HZS16L(1)
ERA15-02VH
18
Part No.
-------------------------
D
D
D
L
L
616
909
911
501
502
Diode
Diode
LED
Coil
Coil
ERA15-02VH
1SS133
L934BR235SRCF
HTH0011
HTH0011
L
L
L
L
L
601
602
603
801
802
HTH0006
HTH0010
HTH0010
CTF1007
CTF1007
T
TH
S
S
VR
601
603
101
601
301
Transformer
Thermistor
Switch(LPF SELECT)
Switch(BFC) (EW, ES)
Volume 10k(A)
HTT0024
HCX0001
HSH0004
HSH-156
HCS0003
FU
FU
602
603
Fuse 30A
Fuse 30A
HEK0030
HEK0030
RESISTORS
R
R
R
R
R
101
102
103
104
201
RS1/16S103J
RS1/16S103J
RS1/16S103J
RS1/16S103J
RS1/16S472J
R
R
R
R
R
202
203
204
205
206
RD1/4PU102J
RD1/4PU202J
RD1/4PU223J
RD1/4PU103J
RD1/4PU333J
R
R
R
R
R
301
302
303
304
305
RS1/16S222J
RS1/16S222J
RS1/16S510J
RS1/16S510J
RS1/16S103J
R
R
R
R
R
306
307
308
501
502
RS1/16S103J
RS1/16S222J
RS1/16S222J
RS1/16S223J
RS1/16S223J
R
R
R
R
R
503
504
505
506
507
RS1/16S911J
RS1/16S911J
RD1/4PU243J
RD1/4PU243J
HCN0005
R
R
R
R
R
508
509
510
511
512
2.20
HCN0005
RD1/4PU473J
RD1/4PU473J
RS1/16S102J
RS1/16S102J
R
R
R
R
R
513
514
515
516
601
2.20
2.20
2.20
2.20
HCN0005
HCN0005
HCN0005
HCN0005
RD1/4PU102J
2.20
GM-X972/XR/UC
Part No.
-------------------------
Part No.
-------------------------
R
R
R
R
R
602
603
604
605
606
RD1/4PU473J
RD1/4PU103J
RD1/4PU103J
RD1/4PU222J
RD1/4PU472J
R
R
R
R
R
901
902
903
904
905
HCN0001
HCN0001
HCN0001
HCN0001
RD1/4PU563J
R
R
R
R
R
607
608
608
609
609
RD1/4PU472J
RD1/4PU182J
RD1/4PU512J
RD1/4PU182J
RD1/4PU512J
R
R
R
R
R
906
907
908
917
918
RD1/4PU563J
RD1/4PU203J
RD1/4PU203J
RD1/4PU273J
RD1/4PU472J
R
R
R
R
R
610
611
612
613
614
RD1/4PU103J
RD1/4PU472J
RD1/4PU101J
RD1/4PU221J
RD1/4PU152J
R
R
R
R
R
919
920
924
930
931
RD1/4PU103J
RD1/4PU392J
RD1/4PU473J
RD1/4PU331J
RD1/4PU331J
R
R
R
R
R
616
619
620
621
622
RS1/16S101J
RS1/16S102J
RS1/16S473J
RS1/16S102J
RS1/16S153J
CAPACITORS
R
R
R
R
R
623
625
626
627
628
R
R
R
R
R
631
632
635
636
637
RD1/4PU272J
RS1/16S472J
RS1/2PMF360J
RS1/2PMF360J
RS1/2PMF360J
R
R
R
R
R
638
639
640
641
642
RS1/2PMF360J
RS1/2PMF360J
RS1/2PMF360J
RD1/4PU472J
RD1/4PU472J
R
R
R
R
R
643
645
646
647
648
RS1/2PMF220J
RD1/4PU472J
RD1/4PU472J
RS1/2PMF561J
RS1/2PMF561J
R
R
R
R
R
649
650
651
652
654
RS1/2PMF220J
RD1/4PU104J
RD1/4PU103J
RD1/4PU393J
RD1/4PU223J
R
R
R
R
R
655
656
657
658
665
RD1/4PU223J
RD1/4PU223J
RS1/2PMF561J
RS1/2PMF561J
RS1/2PMF220J
R
R
R
R
R
666
801
802
803
804
RS1/2PMF220J
RS1/16S471J
RS1/16S471J
RS1/16S223J
RS1/16S223J
R
R
R
R
R
805
806
807
808
811
RN1/10SE1002D
RN1/10SE1002D
RN1/10SE1002D
RN1/10SE1002D
RN1/10SE1002D
R
R
R
R
R
812
813
814
831
832
RN1/10SE1002D
RN1/10SE1002D
RN1/10SE1002D
RS1/16S683J
RS1/16S683J
(UC)
(EW, ES)
(UC)
(EW, ES)
(EW, ES)
RD1/4PU105J
RD1/4PU621J
RD1/4PU621J
RS1/16S472J
RS1/16S472J
0.22
0.22
0.22
0.22
C
C
C
C
C
101
102
103
104
201
CFTNA274J50
CFTNA274J50
CFTNA154J50
CFTNA154J50
CEAT1R0M50
C
C
C
C
C
202
301
302
303
304
CEAT1R0M50
CCSRCH101J50
CCSRCH101J50
CFTNA103J50
CFTNA103J50
C
C
C
C
C
501
502
503
504
505
CEAT220M50
CEAT220M50
CEAT101M50
CEAT101M50
CEAT220M50
C
C
C
C
C
506
507
508
509
510
CEAT220M50
CFTNA104J50
CFTNA104J50
CFTNA104J50
CFTNA104J50
C
C
C
C
C
511
512
517
518
519
CCSRCH471J50
CCSRCH471J50
CEAT220M50
CEAT220M50
CFTNA104J50
C
C
C
C
C
520
521
522
529
530
CFTNA104J50
CFTNA104J50
CFTNA104J50
CFTNA104J50
CFTNA104J50
C
C
C
C
C
531
532
537
538
539
CFTNA104J50
CFTNA104J50
CFTNA564J50
CFTNA564J50
CQMA102J50
C
C
C
C
C
540
601
602
603
606
CQMA102J50
CFTNA103J50
CFTNA224J50
CFTNA103J50
CFTNA103J50
C
C
C
C
C
607
608
609
611
612
CEAT100M16
CEAT100M16
CEAT470M16
CEAT220M50
HCH0013
C
C
C
C
C
613
614
615
616
617
470F/16V
CFTNA103J50
CFTNA103J50
CEAT100M16
CEAT221M10
CQMA102J50
19
GM-X972/XR/UC
Part No.
-------------------------
C
C
C
C
C
618
619
620
621
622
CEAT2R2M50
CEAT101M16
CQMA472J50
CQMA472J50
CQMA102J50
C
C
C
C
C
623
624
628
631
632
C
C
C
C
C
633
634
635
636
637
CEAT221M50
CEAT221M50
CEAT470M16
CEAT470M16
CFTNA473J50
C
C
C
C
C
638
644
651
652
653
CFTNA473J50
CQMA102J50
HCH0007
HCH0007
HCH0007
C
C
C
C
C
654
670
801
802
803
C
C
C
C
C
804
805
806
807
808
CEAT100M16
CQMA472J50
CQMA472J50
CCSRCH470J50
CCSRCH470J50
C
C
C
C
C
809
810
811
812
831
CCSRCH470J50
CCSRCH470J50
CFTNA104J50
CFTNA104J50
CEAT100M16
C
C
832
901
3900F/16V
3900F/16V
2200F/50V
2200F/50V
2200F/50V
2200F/50V
220F/10V
HCH0018
HCH0018
CFTNA564J50
CEAT470M16
CEAT470M16
HCH0007
CQMA103J50
CCSRCH471J50
CCSRCH471J50
CEAT100M16
CEAT100M16
HCH0012
6. ADJUSTMENT
There is no information to be shown in this chapter.
20
GM-X972/XR/UC
7. GENERAL INFORMATION
7.1 DIAGNOSIS
7.1.1 DISASSEMBLY
Panel
B
3
4
1
2
Heat Sink
Amp Unit
Panel
Heat Sink
Fig.1
21
GM-X972/XR/UC
- GM-X972/XR/UC
6.5V
0.2V
BRIDGED
BRIDGEABLE
2-CH POWER AMPLIFIER
30A
30A
22
GM-X972/XR/UC
7.2 IC
*TDA7293V
11
13
2
14
3
12
4
10
MUTE
THERMAL
SHUTDOWN
STBY
1
S/C
PROTECTION
15
10
11
12
13
14
15
-Vs (POWER)
OUT
+Vs (POWER)
BOOTSTRAP LOADER
BUFFER DRIVER
MUTE
STAND-BY
-Vs (SIGNAL)
+Vs (SIGNAL)
BOOTSTRAP
SIGNAL GND
INVERTING INPUT
STAND-BY GND
23
GM-X972/XR/UC
24
GM-X972/XR/EW
GM-X972/XR/ES
3
Audio frequency range
to be output
Very Low Frequency range
Full range
LPF Select
Switch
LPF (left)
OFF (right)
GM-X972/XR/UC
Full range
Connect a subwoofer.
Remarks
Subwoofer
Speaker
Type
Set the LPF select switch as follows according to the type of speaker that is connected to the
speaker output connector and the car stereo system:
Power Indicator
Gain Control
1
4
8. OPERATIONS
Connection Diagram
A
Fuse (30 A)
Grommet
Connecting wires with RCA
pin plugs (sold separately).
External Output
RCA input jack
Front side
Fuse (30 A) 2
Back side
25
GM-X972/XR/UC