Beruflich Dokumente
Kultur Dokumente
ACE850TP: 59658
www.schneider-electric.com
DANGER
HAZARD OF ELECTRIC SHOCK, ELECTRIC ARC OR BURNS b Only qualified personnel should install this equipment. Such work should be performed only after reading this entire set of instructions and checking the technical characteristics of the device. b NEVER work alone. b Turn off all power supplying this equipment before working on or inside it. Consider all sources of power, including the possibility of backfeeding. b Always use a properly rated voltage sensing device to confirm that all power is off. b Start by connecting the device to the protective earth and to the functional earth. b Screw tight all terminals, even those not in use. Failure to follow these instructions will result in death or serious injury.
50 ACE8
TP
P1 P2 m Sepa F C0 S4 S80
0 10/10 X -T BASE 0 10/10 X -T BASE
BBV35290+01+DP00000000
ACE850FO: 59659
DANGER
RISQUES DELECTROCUTION, DARC ELECTRIQUE OU DE BRULURES b Linstallation de cet quipement doit tre confie exclusivement des personnes qualifies, qui ont pris connaissance de toutes les notices dinstallation et contrl les caractristiques techniques de lquipement. b Ne travaillez JAMAIS seul. b Coupez toute alimentation avant de travailler sur cet quipement. Tenez compte de toutes les sources dalimentation et en particulier aux possibilits dalimentation extrieure la cellule o est install lquipement. b Utilisez toujours un dispositif de dtection de tension adquat pour vrifier que lalimentation est coupe. b Commencez par raccorder lquipement la terre de protection et la terre fonctionnelle. b Vissez fermement toutes les bornes, mme celles qui ne sont pas utilises. Le non-respect de ces instructions provoquera la mort ou des blessures graves.
ACE8
50FO
P1 P2 m Sepa F C0 S4 S80
100 X -F BASE Rx Tx 100 X -F BASE Rx Tx
CCA614
50 ACE8 TP
P1 P2 Sepam F C0 S4 S80
10/100 -TX BASE 10/100 -TX BASE
on
I>51
ext
0 off
I on
trip
UMI
V0232
MET148 V0150
ACE850 + ...
Version OK
Base V6.00 Appli V6.00
OK
< V7.00 < V6.00 < V6.00
...Sepam series 80
BBV35290-01
1/4
A
ACE850TP: 59658
1 2
ACE850TP
ACE850FO
ACE850FO: 59659
3 4
Sepam F C S80 S40 P2
10/100 BASE-TX
P1
10/100 BASE-TX
5 6
P2
P1
1 2 3 4 5 6
ACE850 Interface status Communication status P2: 10Mbit/s or 100Mbit/s P2: Activity link P1: 10Mbit/s or 100Mbit/s P1: Activity link
Etat de linterface ACE850 Etat de la communication P2 : 10Mbit/s ou 100Mbit/s P2 : Activit ligne P1 : 10Mbit/s ou 100Mbit/s P1 : Activit ligne
10
11
7 8 9 10 11 12 13
12
13
Sepam
C F S80 S40
ACE850TP
1
CTION TRU OF DES P1 ISK ernet 00 10/1 TION-R Eth E-TX CAU P2 BAS Sepam
C F S40 S80 00 10/1 E-TX BAS
Sepam
C F S80 S40
ACE850
ACE850TP
ACE850FO
3
Sepam series 40 Sepam series 80
C1
C2
CCA614
CCA614
C D
D1 D2
4
BBV35290-01 2/4
CAUTION
RISK OF DAMAGE TO PORTS P1 AND P2. Never connect the ACE850 Ethernet ports P1 and P2 ports to a Sepam. Failure to follow these instructions can result in equipment damage. Pin number Numero broche 1 2 3 4 5 6 7 8 Signal Signal RX+ RXTX+ Reserved Rserv Reserved Rserv TXReserved Rserv Reserved Rserv 1
ATTENTION
RISQUE DE DESTRUCTION DES PORTS P1 ET P2. Ne raccordez jamais les ports Ethernet P1 et P2 de l'ACE850 au Sepam. Le non-respect de ces instructions peut entraner des dommages matriels.
P1
P2
P1
Connector Type Type de connecteur RJ45 Data Port Donnes 10/100 Mbits/s Media Media Cat 5 STP, FTP, SFTP Maximum distance Distance maximale
P2
100 m / 328 ft
P1
Tx P2
Rx
Tx P1
Rx
CAUTION
HAZARD OF BLINDING Never look directly into the end of the fiber optic. Failure to follow this instruction can cause serious injury.
P2
ATTENTION
RISQUE DAVEUGLEMENT Ne regardez jamais directement lextrmit de la fibre optique. Le non-respect de cette instruction peut entraner des blessures graves. Speed standard Mode / Connector Wavelength Fiber diameter Vitesse standard Connecteur / Mode Longueur Diamtre donde fibre optique (nm) (m) Minimum optical power available Puissance optique minimale TX (dBm) -22.5 -19 Maximum optical power available Puissance optique maximale Tx (dBm) -14 -14 Rx sensitivity Sensibilit Rx (dBm)
P1 P2
100FX
Multimode SC
1300
50/125 62.5/125
-33.9 -33.9
-14 -14
BBV35290-01
3/4
V DC / V AC
x3
2
Click!
3
x3
2
4 5
x2
Terminal Borne 1
L
Description
Voltage Tension -
Reserved (Rserv)
0.5...1.5 mm 0.5...2.5 mm 0.5...2.5 mm 8 mm AWG 20...16 AWG 20...12 AWG 20..12 0.31 in
1
PZ2
mm in
5 0.19
b Earthing braid, to be connected to cubicle grounding. 1 0.03 b Tresse de mise la terre, raccorder la masse de la cellule.
As standards, specifications and designs change from time to time, please ask for confirmation of the information given in this publication. En raison de lvolution des normes et du matriel, les caractristiques indiques par le texte et les images de ce document ne nous engagent quaprs confirmation par nos services. Printed on recycled paper. Ce document a t imprim sur du papier cologique.
BBV35290-01
02-2010