Beruflich Dokumente
Kultur Dokumente
9.
10.
(1) 80W (2) 140W V1 + (3) 144W (4) None The value of z12 in the circuit shown in figure 3I1 (1) 5 I2 I1 2 4 + (2) 3 + + V1 (3) 1 V2 3 (4) 0
R1
+ V2
S Academy
Page 1
In BCD representation if 12 binary bits are used the maximum switching possible combinations are (1) 1024 (2) 4096 (3) 4097 (4) 1000 The minimum number of 2 4 decoders requires to obtain 4 x 16 decoder is (1) 4 (2) 5 (3) 6 (4) 8 IN and OUT instructions addressing mode is (1) Register (2) Implicit (3) Immediate (4) Direct If f(z) = C0 + C1 Z1 then is given by. (4) 2T i(1 C0 ) (1) 2TC1 (2) 2T(1 C0 ) (3) 2T ic1 Which of the following series indicates sin x x x 2 x3 x3 x5 (1) 1 .... (2) x .... 1! 2! 3! 3! 5! x2 x4 x3 x5 (3) 1 .... (4) x .... 2! 4! 3! 5! 3 1 1 Eigen values of the matrix 1 3 1 are 1 1 3 (1) 1, 1, 1 (2) 1, 4, 4 (3) 1, 1, 2 x 2x e (c1 3x c2 sin 3x) c2e is the general solution of (1) d3 y 4y ! 0 dx3 d3y (3) 3 8y ! 0 dx d 3y 8y ! 0 dx 3 d 3y d 2 y dy (4) 3 2 2 2! 0 dx dx dx (2)
16.
(4) 1, 2, 4
17.
18.
19. 20.
21. 22.
A bag contains 8 white and 6 red balls. The probability of drawing two balls of the same colour is 43 43 43 (1) (2) (3) (4) none of these 88 91 93 A unit step input is applied to a system having 40% damping and n = 7. The peak time is (1)0.48 sec (2)0.23 sec (3)6.42 sec (4)0.7 sec The force voltage analogy is applied to the series RLC circuit. The system given below is x1 (t ) ! 2 x1 (t ) 3 x 2 (t ) , x2 (t ) ! 2 x1 (t ) x2 (t ) u (t ) (1)controllable and unstable (2)controllable and stable (3)uncontrollable and unstable (4)uncontrollable an state 2 . Its gain margin will be A unity feedback control system has G(s) = ( s 3) 3 (1)2 (2)4 (3)6 (4)8 Consider the following statements regarding an electrical machine having a cylindrical stator & salient pole rotor. i. Reluctance torque is produced when rotor winding is excited ii. Reluctance torque is produced when stator winding is excited iii. when both stator & rotor windings are excited electromagnetic torque is produced
S Academy Page 2
23.
iv. When both stator & rotor windings are excited, electromagnetic as well as reluctance torques are produced. Which of these statements are correct (1)2 &4 (2)1 & 4 (3)1 & 3 (4)2 & 3 For the network in given figure, V1(t) is the input and i(t) is the output. The transfer function I(s)/Vi(s) of the network is L R Cs C (1) (2) LCs2 RCs 1 LCs2 RCs 1 V (t)
i
i(t)
The current through and the voltage across a power device is shown in fig. The rms current rating of the device is given by i 10A (1)2.5A t (2)4.1A 1V (3)10/ 3 A (4) 10 3 A
T/2 T t
25.
26.
A single phase AC voltage controller as shown has a resistive load of R=10 and the input voltage is 120V,60Hz. If the delay angle of the thyristor is /2 then the rms value of the output voltage is given by 60 T (1) v 3 + (2)60 3v Vs V D R _o 120 (4)120 2v (3) v 2 Question 26 to 55 Carries 2 Mark Each The severely of line-to-ground and 3 J fault at the terminals of an unloaded synchronous generator is to be same. If the terminal voltage is 1.0 pu & z1 = z2 = j0.1 pu, z0 = j0.05 pu. For the alternator, then the required inductive reactance for neutral grounding is (1) 0.166p.u (2) 0.05 p.u (3) 0.1p.u (4) 0.15p.u For the Op-Amp circuit shown in the figure, V0 is 2k (1) 2V 1k (2) 1 V (3) 0.5 V V0 1V + (4) 0.5 V
1k
27.
28.
If a 3-ph induction motor & 1- J I.r of the same kw rating & same winding voltage are compared, then (1) both will be same size & efficiency (2) the 3-phase induction motor will be bigger in size & less efficient (3) the 3- J I.r. will be smaller in size & more efficient (4) the 3- J I.r will be bigger in size & more efficient
1k
S Academy
Page 3
29.
v0 of the JEET amplifier v1 shown in the figure is IDSS =10 mA Vp = 5V (Assume C1, C2 and C8 to be very large) (1) +16 (2) 16 (3) + 8 (4) 6 The voltage gain A v !
VVD = +10V C2 Vs RD 3k C1 V0 Cs
RG Rs (1M) (25k)
30.
In the circuit of the figure, assume that the region. It has a large and its base-emitter is (1) Indeterminate since Rc is not given (3) 5 mA
(2) 1 mA (4) 10 mA
10k Rc Ic 5k 430k
31.
Driving point Impedance of the network shown below is 1 (1) z(s) ! (2) z(s) ! s 1 1 s 1 (3) s3 2s2 s 1 2s2 1 (4) 2s2 1 s 2s s 1
3 2
1F 1H i2 1H
u(+) +
i1
32.
The ECL logic IC made circuit as shown the MUX output of the circuit (1) (2) (3) (4)
x x 1 0 4x1 A B Y
33.
Q C
J K
Q B
J K
Q A
J K
CL K
S Academy
Page 4
34.
(1) 10 V (3) 4V
(2) 5V (4) 8V
2R
R 2R 1V
R 2R
35.
36. 37.
In the given delay program the DCX D will executed by_______ times LXI D, 0010H (1) 10 (2) 9 (3) 16 (4) Loop DCX D JNZ loop RET If f(x) = 2x315x2 + 36x + 1 is increasing in the interval (1) (2,3) (2) (, 3) (3) (, 2)U(3, ) (4) None Volume of an object expressed in spherical coordinates is given by V!
2T 0
0 0 r
T/3 1 2
sin J dr d J d U.
38.
39.
40.
Value of the integral is T T T 2T (4) (1) (2) (3) 3 6 4 3 A box A contains 2 white and 4 black balls. Another box B contains 5 white and 7 black balls. A ball is transferred from the box a to the box B. then a ball is drawn from the box B. The probability that it is white is 16 14 12 9 (1) (2) (3) (4) 39 39 39 39 An ac servomotor has both windings excited with 150V ac. It has torque of 2 cb ft and coefficient of viscous friction is 0.5 cb ft sec. It is connected to a constant load of 0.8 cb ft and the coefficient of viscous friction of 0.072 cb fts through a gear pass with a ratio of 6. The speed at which the motor will run is, (1) 0.4 rad/sec (2) 0.97 rad/sec (3) 1.1 rad/sec (4) 1.79 rad/sec A servo system with integral control has the closed loop transfer function 7500(s K i ) C ( s) . The range of values of Ki for which ! 3 R( s ) s 34.5s 2 7500s 7500 K i closed loop system is stable. (1) 34.5Ki0 (2) 34.5>Ki>0 (3) 34.5<Ki<0 (4) None ( s 6) . In the root locus for open loop transfer function G(s)H(s) = ( s 3)( s 5) The break away and break in points are located respectively at (1)-2 and 1 (2)-2.47 and -3.77 (3)-4.27 and +7.23 (4)-7.73 and -4.27 In Maxwells capacitance bridge for calculating unknown inductance, the various values at balance are R2=300, R3 = 700, R4=1500, C4 = 0.8F Calculate R1, L1, Q-factor if frequency is 1100Hz
S Academy Page 5
41.
42.
43.
(1) 240, 0.12 H, 3.14 (2) 140, 0.168 H, 8.29 (3) 140, 0.12 H, 5.92 (4) 240, 0.36 H, 8.29 For a lissojous pattern shown, find out the frequency of vertical signal, if the frequency of horizontal signal is 3KHZ (1) 7.5 KHZ (2) 0.5 HZ (3) 3.75 KHZ (4) 7.5 HZ An ac servomotor has both windings excited with 150V ac. It has torque of 2 cb ft and coefficient of viscous friction is 0.5 cb ft sec. It is connected to a constant load of 0.8 cb ft and the coefficient of viscous friction of 0.072 cb fts through a gear pass with a ratio of 6. The speed at which the motor will run is,(a) (a)0.4 rad/sec (b)0.97 rad/sec (c)1.1 rad/sec (d)1.79 rad/sec The causal systems is/are (i) y(n) = x2 (n) u (n) (ii) y(n) = x(|n|) (iii) y(n) = x (n) x(n2n) (iv) y(n) = (1) (i), (ii) and (iii) (2) (i) and (iv) (3) (iii) and (iv) (4) (i) and (iv) A 3-phase squirrel cage induction motor has a starting torque of 150% and a maximum torque of 300% with respect to rated torque at rated voltage and rated frequency. Neglect the stator resistance and rotational losses. The value of slip for maximum torque is (1) 13.48% (2) 16.24% (3) 18.92% (4) 26.79% In a 400 kV network 360 kV is recorded at a 400 kV bus. The reactive power absorbed by a shunt rated for 50 MVAR, 4000 kV connected at the bus is (1) 40.5 (2) 55.56 (3) 45 MVAR (4)6.73 MVAR Common data questions 48 & 49: In the circuit shown in fig Input voltage Vdc = 12V. The required output voltage Vo=5V at R=500. The peak to peak output ripple voltage is 20mV. The switching frequency is 25kHz. The peak to peak ripple current through the inductor is 0.8A. sw
L Vdc D C + _ Vo
44.
45.
46.
47.
48. 49.
The value of inductor to maintain the given p-p ripple current is____ (1)147 H (2)200 H (3)145.83 F (4)none The value of capacitance to satisfy the given ripple in output voltage is ___ (1)200 F (2)145.83 F (3)147 F (4)none Common data questions 50 & 51: An inductor designed with 400turns coil wound on an iron core of 16cm2 cross sectional area and with a cut of an air gap length of 1mm. The coil is connected to a 230V, 50Hz ac supply. Negelect coil resistance, core loss, iron reluctance and leakage inductance (0 = 4p10-7 H/m) The current in the inductor is (1) 18.08A (2) 9.04A (3) 4.56A (4) 2.28A
S Academy Page 6
50.
51.
The average force on the core to the reduce the air gap will be (1) 832.29N (2) 1666.22N (3) 3332.47N (4) 6664.84N Linked answer questions 52 & 53: A 3.5 rVA, slow speed, 3 phase synchronous generator at 6.6kv has 32 poles . Its direct & Quadrature axis synchronous reactance as measured by the slip test are 9.6 & 6 respectively. Neglecting armature resistance, the excitation emf needed to maintain 6.6kv at the terminal when supplying a load of 2.5MW at 0.8pf lagging. The regulation is (1) 40% (2) 50% (3) 30% (4) 55% In the above question using data, the maximum power can the generator supply at the rated terminal voltage if the find becomes open circuited? (1)78MVA (2)95 MVA (3)89 MVA (4) None Linked answer questions 54 & 55: A 3-phase induction motor has a starting torque of 150% and a maximum torque of 250% of the full load torque. Neglect stator resistance and assume constant rotor resistance. Find the full load slip (1) 0.33 (2)0.0695 (3) 3 (4)1.5 Express the rotor current (I2) at starting in terms of full load rotor Current (1) I2, st=4.646 I2f1 (2) I2f1=4.646 I2f1 (3) I2sf, =2.323 I2,f1 (4) I2fL=2.333 I2,st Q.56 to Q.60 carry one mark each Select the lettered pair that best expresses a relationship similar to that expressed in the original pair. DUNGEON : CONFINEMENT (1)church : chapel (2)school : truancy (3)asylum : refuge (4)hospital : mercy SNICKER : DISRESPECT : (1) whimper : impatience (2) chortle : glee (3) frown : indifference (4) glib:fluency Choose the word or set of words for each blank that best fits the meaning of the sentence as a whole. Just as disloyalty is the mark of the renegade, _________is the mark of the _____ , (1) timorousness.hero (2)temerity.coward (3) avarice..philanthropist (4)cowardice.craven The reasoning in this editorial is so _____ that we cannot see how anyone can be deceived by it. (1) coherent (2) astute (3) cogent (4) specious ALACRITY = (1) slowness (2) Plenty (3) filth (4) courtesy Q.61 to Q.65 carry two mark each
52.
53.
54. 55.
56. 57.
58.
59.
60.
S Academy
Page 7
61.
62.
63.
64.
65.
Three different containers contain 496 liters, 403 liters and 713 liters of mixtures of milk and water respectively. What biggest measure can measure all the different quantities exactly? (1) 1 litre (2) 7 litres (3) 31 litres (4) 41 litres X and Y can do a piece of work in 20 days and 12 days respectively. X started the work alone and then after 4 days Y joined him till the completion of the work. How long did the work last? (1) 6 days (2) 10 days (3) 15 days (4) 20 days Excluding stoppages, the speed of a bus is 54 kmph and including stoppages, it is 45 kmph. For how many minutes does the bus stop per hour? (1) 9 (2) 10 (3) 12 (4) 20 A train passes a station platform in 36 seconds and a man standing on the platform in 20 seconds. If the speed of the train is 54 km/hr, what is the length of the platform? (1) 120 m (2) 240 m (3) 300 m (4) None of these In how many different ways can the letters of the word DETAIL be arranged in such a way that the vowels occupy only the odd positions? (1) 32 (2) 48 (3) 36 (4) 60
From
SAIMEDHA TEAM
S Academy
Page 8
S Academy
Page 9