Beruflich Dokumente
Kultur Dokumente
to the networ
While both ports ca uses only one LAN p
n brackets
AC surge protector for the power connection RJ-45 cables for connecting the switch to the local area network and telco lines Music-on-hold source with a standard mini-headphone Y-adapter (optional) #1 Phillips screwdriver
the switch to a telephone company line ng test equipment nance port (19200 bps, 8 bits, no parity, 1 stop nications ) for connecting to a music-on-hold source eo) for connecting to a corporate paging system
If the LED is not lit, make sure the powe power source. If the LED continues ashing, there is an it off, then power it back on. Refer to th ShoreTel Administration Guide for inf ShoreTel Support Services at http://www The LAN ports auto-sense the network trans established, the network LED indicates a tra whether the switch is receiving and transmitt
N1 ector
T1 LEDs
Telco Port
Optional Connections
After connecting the voice switch to the LAN connections, including input from a music-o to your internal paging system. 1. 2. Connect a music-on-hold source (CD pl source) to the audio input port. Connect your sites paging system to the
Monitor Port
ShoreGear 220E1
N1 ector
E1 LEDs
Telco Port
Network LEDs
Each LAN connector provides two LEDs: Link/Act (Left) and 100 (Right). LAN LEDs indicate the activity and communication speed of the connected network.
LED Link/Act Link/Act Link/Act 100 100 Green Network interface is operating at 100 Mbps. Off Network interface is operating at 10 Mbps. Green-Flashing This switch detects network data trafc. Green-Steady This switch is connected to an Ethernet network. Off This switch cannot detect an Ethernet network. Color/State Description
led and powered on, it must be congured for network conguration by assignment from a an administrator console (see procedure below).
from a Console
emulation program and connect to the voice tion settings: 19200 bps, 8 data bits, no parity,
Quick In
nal self-test (i.e. hardware failure). Refer to Conguring tration Guide for details on other ash patterns.
ivity information.
E1 LEDs (SG-220E1)
E1 LEDs indicate line coding, network framing, and loopback status. The Line Coding LED is on the ports left side. The Framing LED is on the ports right side
LED Line coding Line coding Line coding Line coding Framing Framing Framing Framing Framing Red Off Green Yellow Yellow-Flashing Red Off Yellow Green Color/State Description The HDB3 line coding signal is good. This switch is receiving bipolar violations (BPV) at one-second intervals. A loss of signal (LOS) has occurred. The switch has no power. The E1 signal is in frame (synchronized) The CO has sent a yellow alarm. The frame-bit error rate has exceeded its limits E1 signal is out-of-frame (OOF). The switch has no power.
active calls
-60 Hz