Beruflich Dokumente
Kultur Dokumente
In an effort to develop a device to emulate the function of a Joe cell without its inherent stability issues, Dave Lowrance came up with this set of 3 concentrically wound coils. In early testing it has become apparent that a field IS being generated, based on the affect that the coils have on my Accord and my Pinto test engine with no power applied to the coils. At this point we want to release this initial design with the hope that others will wind and test similar coils and report their results to the appropriate groups, so that we can learn more about them through further experimenting on a variety of different engines.
The first layer wound and secured. The second layer is cut to a length of 396 cm. This second layer will be longer than the layer its going to be wound on, so before winding it, its necessary to build up the area at both ends of the first layer with tape, so that the second layer will remain concentric along its entire length. Its probably good to completely cover the first layer with tape to ensure electrical insulation. This layer is also wound on in the clockwise direction.
The second layer wound and secured. The third layer is cut to a length of 313 cm. Since it will be covering less length along the form, theres no need to build up the ends of the earlier layers. Simply cover the second layer with tape, than wind on the third layer, but this time in a counter-clockwise direction. Cover the entire coil in tape to protect it.
The third layer wound and secured To be sure that the second and third layers are centered over the earlier layers its a good idea to locate the center of the wire and start winding from the middle outwards in both directions.
Daves original concept was to use a set of these coils to replace each tube of a Joe cell. So I plan to wire another set soon on a 1.5 core, which will just slide over the first set. Happy experimenting! http://magnetism.50webs.com/index.htm