Beruflich Dokumente
Kultur Dokumente
20
Ver. 2.1E
2009. 07. 10
Ver. 2.1E
2. Select Bluetooth ON and OK. Then, BTPA N If so, it is that Bluetooth turns on properly. [FIG. 2]
[FIG. 2]
4. Start Settings Control Panel Bluetooth Device Properties. Then, Click Scan Device button. 5. If Bluetooth Device Properties program find Woosim Printer, you can see like [FIG. 3]. Then, Press PIN code and wait until equipment search is
completed.(when Stop button change into Scan Device). 6. If searching is completed, double click below figure. You can see the woosim name.. 7. If you click Trusted like [FIG. 4], you can see a screen whether or not to certify again. Then, you click Yes and input PIN code like [FIG. 5] and click OK.
Ver. 2.1E
[FIG. 3]
[FIG. 4]
[FIG. 5]
[FIG. 6]
8. Double click WOOSIM name like [FIG. 6] and check Active . 9. Execute Card123_DSIC.exe 10. Select BSP2, 57600 BPS, Protocol in Combo Box like [FIG.7] and click Open. If STATUS_ANSWER come out in Printer Msg, it is that PDA and Woosim printer are connected properly.. 11. Click the bottom button(Print[Eng]) in Card123_DSIC.
Ver. 2.1E
12. If Woosim Printer make a output properly, it is that the linkage of Woosim printer and PDA Bluetooth is completed properly..
[FIG. 7]
[FIG. 8]
4. Click Function Printing. If Printing display comes out [FIG. 10], click Print button to test Printing and then check if it is working properly.
Ver. 2.1E
[FIG. 9]
[FIG. 10]
[FIG. 11]
Ver. 2.1E
2. If there is no printer icon of Woosim like No.6 after executing No.5 , -> Wait for the completion of Searching Equipment, and then re-run it with pressing the button of Searching equipment again. -> If there is no usual printer icon of Woosim properly and you find the question mark icon, execute Searching equipments in five times until you can see the printer icon. -> However, if you cannot find the printer icon after executing Searching equipment in five times, register this problem to A/S center.
3. <Woosim> If there is no message of Status_Answer after executing No.10 of 1.1, <Bixolon> If the buttons in Function are not generated properly after executing No.3 of 1.2, If the other existing Bluetooth was connected before, the actual port can be BSP3,4 .9, not BSP Port. After selecting the BSP3(BSP4~9), click the open button again and check the normal Print Meg.can be printed out..
<Caution> If Bluetooth of MB Series model was connected with other Bluetooth equipments, PDA Bluetooth port fix is used by BSP, not COM.
Ver. 2.1E
2.2. The way to apply a connected BT item when PDA hardware reset.
1. Execute BTCSTool.exe. 2. In the connected Bluetooth list, select one to be saved, input Pin code then, Click Saver button. [FIG. 12]
[FIG. 12]