Beruflich Dokumente
Kultur Dokumente
www.huawei.com
BTS3900 GSM
BTS3900A GSM
DBS3900 GSM
Page1
1) Double radio filter unit 2) Fan box 3) GSM antenna and TMA control module 4) Baseband unit 5) Direct current distribution unit
-48V Cabinet
Copyright 2006 Huawei Technologies Co., Ltd. All rights reserved.
Page2
(1) Double radio filter unit (2) Fan box (3) Baseband unit (4) Direct current distribution unit (5) Cable in/out unit (6) Power supply unit
BBU
Page4
BSBC: The universal BBU subrack backplane type C GTMU: The GSM Transmission, Timing and Management Unit UBFA: The universal BBU fan unit type A UPEU: The universal power and environment interface unit UELP: The universal E1/T1 lightning protection unit
UEIU: The universal environment interface unit
Page5
GTMU
Page6
GTMU Ports
Port CPRI0 CPRI5 Type DLC Corresponding Cable Optical fiber between BBU and DRFU Description Connected to DRFU for the optical signal transmission
ETH FE0
FE1
RJ45 RJ45
DLC
Terminal maintenance and commissioning A reserved port that performs the following
function: Connects the BBU to a routing device in the equipment room through the
Page7
UBFA
The universal BBU fan unit type A (2U) (UBFA) works with the air inlet box of the cabinet to form a ventilation circuit, thus cooling the entire cabinet The UBFA module communicates with the GTMU to regulate the
temperature, adjust the fan speed, and report alarms. The UBFA module is hot swappable
Indicato r Color Green Status Fast flash(0.25s on0.25s off)
Description
STATE
Can not communicate with the board and there is no alarm generated
Red Green
Page8
UPEU
Type
Description Provides the input and output of the externally collected environment monitoring signals to the GTMU according to the RS485 communications protocol Same as MONO0 Transmits the externally collected environment monitoring signals to the GTMU through communications protocol related to the dry contact Same as EXT-ALM0
MON0 RJ45
EXTALM1
RJ45
PWR
3V3
-48V DC input
Page9
UEIU
MON0 RJ45
MON1 RJ45
EXTALM0 RJ45
Same as MONO0.
Transmits the externally collected environment monitoring signals to the GTMU through communications protocol related to the dry contact Same as EXT-ALM0.
EXTALM1
RJ45
Page10
UELP
Port INSIDE
Description Transfers the four E1/T1 signals between the UELP and the GTMU Provides the input and output of the four E1/T1 signals between the BBU and the BSC
Page11
OUTSIDE
DB26 male
BBU Cables
cable, main node alarm signal cable, FE port cable, CPRI port signal cable and transmission cabinet monitoring cable
Page12
DCDU Panel
a: Power switch
ANT_RXB
CPRI0
Used in connection to the lower-level cascaded MRFU Input port for diversity signals in antenna channel 1 Output port of diversity signals in antenna channel 1
Receives power input
PWR
Page14
P9
P10 P11-P12
1
1 2
S1-S6 S7
S8 S9
CPRI Signal Cables Between the BBU and DRFU E1 Transfer Cable of the BBU
Monitoring Signal Cables for the DCDU Monitoring Signal Cable for the Fan Box
6 1
1 1
S10
Page15
The MRFU supports various network topologies: star, chain, and ring
Page16
Thank you
www.huawei.com