B-63040N03 4. DESCRIPTION OF PARAMETERS
49
n 6 8 mw os 2
PARAMETERS OF wae ai 20
COORDINATES ver aK 2
[Data type] Bit
ZCL Local coordinate system when the manual reference position return is
performed
0: The local coordinate system is not canceled.
1: The local coordinate system is canceled.
AWK When the workpiece zero point offset value is changed
0: The absolute position display changed when the next bufforing block
is performed.
1: The absolute position display is changed immediately.
‘Changed value is valid ofter baffering the next block.
WZR_ Upon reset, the workpiece coordinate system is:
0: Not retuned to that specified with GS4
1: Returned to that specified with G54
ww em wt
RIC] 60] Eve | wo
1202
aE Re
[Data type] Bit
EWD. The shift direction of the workpiece coordinate system is:
0: The direction specified by the external workpiece zero point offset
value
1: In the opposite direction to that specified by the extemal workpiece
zero point offset value
x x x Xx
eEwo-0 ewo=t
z Z (Shite workpiece
‘coordinate system)
EXOFS “EXOFS:
z 7. (Original workpiece
coordinate system)
EXOFS : External workpiace zero point offset value
EWS Shift value of the workpiece coordinate system and external workpiece
zero point offset value are
0: Stored in the separate memory areas.
1: Stored in the same memory area, that is, the shiftand the offset values
are the same.
G50_ Ifthe G50 command for setting a coordinate system (orthe G92 command
in G command system B or C) is specified,
0: G50 is executed and no alarm is issued.
1 G50 is not executed and a P/S alarm (No. 010) is issued.
RLC Local coordinate system is,
0: Not cancelled by reset
1: Cancelled by reset
—xy—4, DESCRIPTION OF PARAMETERS B-s3a40EN03
GS2_ In local coordinate system setting (G52), a cutter compensation vector is:
0: Not considered.
1: Considered,
NOTE
Select a local coordinate system setting operation when
cutter compensation is applied, and when two or more
blocks specifying no movement exist prior to the
specification of G52, or when G52 is specified after cutter
compensation mode is canceled without eliminating the
offset vector.
ww mt
Ta ENC
[Data type] Bit
EMC The extended extemal machine zero point shift function is:
0: Disabled.
1: Enabled,
NOTE
1 To use the extended external machine zero point shift
function, the external machine zero point shift function or the
external data input function is required.
2 When the extended machine zero point shift function is
enabled, the conventional external machine zero point shift
function is disabled,
Ta Exeralworkpacs Zao pant afeatvalas
[Data type] 2-word axis
[Unit of data}
Taputinerement SA] 88 | SC | unt
Tinear axis Gapatla my cor [00 | 0.0007 | am
[Linear axis (inputin inches) | 0.007_| 0.0007_| 0.00007 [inch
Rotation ans aor 0.007 0.0007 | dea
[Valid data range] 99999999 to 99999999
This is one of the parameters that give the position of the origin of
workpiece coordinate system (G54 to G59). It gives an offset of the
workpiece origin common to all workpiece coordinate systems. In
‘general, the offset varies depending on the workpiece coordinate systems.
‘The value can be set from the PMC using the external data input function