Beruflich Dokumente
Kultur Dokumente
PHYSICAL
40mm (1.6)
ENVIRONMENTAL
Design:
RF Immunity:
Electrostatic Discharge: Fast Transient Immunity: High Energy Transient Immunity: Conducted RF Susceptibility: Conducted Emissions:
60mm (2.4)
INS 231-2
Radiated Emissions:
www.texe.com
Latch/First to Alarm (see Section 5)
QUALITY ASSURANCE
4
Remote LED: 12V 0V/NC 9-16VDC 10mA @ 12VDC <24VDC 50mA, 18 (N/C) <24VDC 50mA (N/C)
JP1
LED OFF
PULSE COUNT
1
Cer tificate Number: FM 35285
JP1
LED ON
WARRANTY
10 year replacement warranty. The Prestige MR is designed to detect the movement of an intruder and activate an alarm control panel. As the Prestige MR is not a complete alarm system, but only a part thereof, Texecom cannot accept responsibility or liability for any damages whatsoever based on a claim that the Prestige MR failed to function correctly. Due to our policy of continuous improvement Texecom reserves the right to change specification without prior notice. All specifications are measured at 20C (68F).
2003 - 2004 Texecom Ltd. Document Ref: PMR/EU/1.0-2 The Prestige MR is protected by UK & International Registered Design. Registered Design No: 3004997
JP2
2 DO NOT TOUCH
6
SIDE VIEW
JP2
PYRO 3 MIRROR 0.3 - 3.0m/s 1 - 10ft/s
JP2
For 15m range adjust mirror positions to allow for chosen mounting height
3.1m/100
Latch connected to Set Positive (SW+, Set+): The LED will be disabled while the system is set. Any detectors triggered while the system is set will indicate this by permanently lighting the LED (upon unsetting the system). Detectors can be reset by taking the latch line high and then low again. Latch connected to Alarm Positive (AL+, A+ve): The first detector activated while the system is set will indicate this with a slowly flashing LED (upon unsetting the system). Detectors which activated subsequently will indicate this by permanently lighting the LED. Detectors can be reset by taking the latch line high and then low again.
!
2.5m/84 FRONT BACK
2m 6'7" 10m 32'9" 2m 6'7" 8m 26'2"
!
2.0m/67
2m 6'7" 15m 50'
1.5m/41
15m 50'
COVERAGE PATTERN
10
11
!
15m 50
Please Note For Long Range Mirror: Always install at 2.0m mounting height and check mirror is set correctly:
12
WIRING
Do not run cable parallel to mains wiring
13 CHOOSING A LOCATION
Avoid common false alarm sources
14
DETECTOR KNOCKOUTS
16
230V 110V
230V 110V
7 8
17
!
Ensure mirror is in correct position for chosen mounting height (see Sections 6 & 7)
INS 231-2