Ss*Ss Ss Ss Ss Ss Sg Sg Sg Sg Sg Sg Sg Sg
Ss
e +o tame
25
SAFETY SUPPLEMENT
és OPERATION MANUAL
Ss USAF SERIES
: HGM-16F
Ss MISSILE
THUS PUBLICATION SUPPLEMENTS 7.0. ZIM-HGMIGF-1 DATED 1 APRIL. 1964
Ss (PREHEAT AND FED HEAT) AND GEPL ACES INTERIM SATETY SUPPLEMENTS
ro. FMHGM Gr i863 DATED 19 JULY 1964 AND TON ML
DATED 39 JULY 1964. Reterence te thie soprlement will be meda-on he til pose
publication by personnel responsible for maintaining the publica
SUPPLEMENT TO THE ATTENTION OF ALL AFFECTED
COMMANDERS ARE RESPONSIBLE FOR BRINGING THIS
® AIR FORCE PERSONNEL.
PUBLISHED UNDER AUTHORITY OF THE SECRETARY OF THE AIR FORCE
Ss ee
¢. in this publicotion Is,
During a PLX or maintenance countdown using LN2 in place of LO2 and the
STORAGE AREA OXYGEN 19 PER CENT indicator on the FRCP illuminates
Ss. red from "START COUNTDOWN" to MISSILE LIFT UP AND LOCKED
s INDICATOR AMBER", and a TV camera is positioned on Level Seven to
scan all LO2 transfer lines and valves on Level Seven outside the MEA, the
countdown may be continued at the discretion of the MCCC, only if it can
é be determined by visual observation and by Logic and pressure indications
that there is no evidence of LNZ leakage or spillage. If leakage or spillage
29 JULY 1964
is evident, MCCC shall initiate abort in accordance with Table 4-2, Item 6C.
Ss If the countdown is continued, the following procedures shall apply:
1, After MISSILE LIFT UP AND LOCKED indicator illuminates green,
and ABORT INDICATOR illuminates red, perform ACTION 1, Step 1 of
Table 4-2, Item 6G
® 2. After ABORT EXTERNAL INDICATOR illuminates amber, perform
s steps 2 through 6, Table 4-2, Item 6C.
$ 1
=Sse Ss Ss Ss SAFETY SUPPLEMENT ‘Ss Ss Ss@s
Ss
Ss
Ss Ss Ss Ss Ss Ss Ss Sg Sg Sg Sg Sg Sg
ee
T, O, 21M-HGM16F-1SS-2
SAFETY SUPPLEMENT
OPERATION MANUAL
USAF SERIES
HGM-16F
MISSILE
THIS PUBLICATION SUPPLEMENTS 1.0. 214-HGHISF-1 DATED 1 APRIL 1964
SHANGEDS APRIL 1964 AND 13 APRIL i364 AND RERL ACES INTERIM SAFETY
IN-HGMI6F.1SS-2 DATED
COMMANDERS ARE RESPONSIBLE FOR BRINGING THIS
SUPPLEMENT TO THE ATTENTION OF ALL AFFECTED
AIR FORCE PERSONNEL.
PUBLISHED UNDER AUTHORITY OF THE SECRETARY OF THE AIR FORCE
NOTICE: Reproduction for non/military use of the information
ed in this publication is not permitted
without specific approval of the issuing service
te
or illustrations contai
15 JULY 1964
1, PURPOSE,
To provide the capability of conducting a PLX and maintenance count-
down with the Diesel Fuel Vapor Detector System removed or nonoperative.
2, GENERAL,
At the present time, the HGM-16F Operation Manual required an
operable Diesel Fuel Vapor Detector System as a pre-requisite to conducting
a PLX. This requirement will preclude a periodic inspection maintenance
countdown or PLX and subsequent return of complexes to an EWO status.
3. INSTRUCTIONS.
At those complexes where the Diesel Fuel Vapor Detector System
has been removed or is non-operative, the following paragraphs in T.O.
21M-HGM16F-1 will be disregarded. 1
Ss Ss Ss SAFETY SUPPLEMENT ‘Ss Ss SsT.O, 21M-HGMI6F-1SS-2
a. Page 3-11, that portion of paragraph 3-59 which refers to Diesel
Fuel Vapor Detector System.
b, Page 3-101, that portion of step 18 which refers to Diesel Fuel
Vapor Detector System.