Beruflich Dokumente
Kultur Dokumente
GALION
150FA
SPECIFICATIONS SPECIFICATIONS
ENGINE Komatsu . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . S6D102E-1 Type . . . . . . . . . . . . . . direct injection, 4-cycle diesel, turbocharged Gross horsepower @2500 rpm . . . . . . . . . . . . . . . . . 97kW 130 HP Net flywheel horsepower @ 2500 rpm . . . . . . . . . . 90.3 kW 121 HP Maximum torque @ 1200 rpm . . . . . . . . . . . . . . . 499 N-m 368 lb ft Bore and stroke. . . . . . . . . . . . . . . . . . 102 x 120 mm 4.02" x 4.72" No. of cylinders . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Piston displacement . . . . . . . . . . . . . . . . . . . . . . . . . 5.88 ltr 359 in3 Electrical system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 V AMA HP U.S. tax purposes . . . . . . . . . . . . . . . . . . . . . . . . . . . 38.8 Net flywheel power output of standard engine as installed in this vehicle (per SAE J1349) complete with fan, air cleaner, alternator, water pump, lubricating oil pump and fuel pump. Engine will maintain specified flywheel power up to 3048 m 10,000' altitude.
Meets EPA Tier I emissions regulation.
BRAKES Service: . . . .Hydraulic power, 4 wheel432 mm x 102 mm 17'' x 4'' Parking: .Mechanical on front axle drive305 mm x 76 mm 12'' x 3''
HYDRAULICS Controls: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Hydraulic Tandem Hydraulic Pumps: . . . . . . . . . . . . . . . . . .189 lit/min 50 GPM and 114 lit/min 30 GPM
BOOM Reach, horizontal, minimum . . . . . . . . . . . . . . . . . . . .6096 mm 20' Reach, horizontal maximum . . . . . . . . . . . . . . . . . . .18288 mm 60' Swing, rotation continuous . . . . . . . . . . . . . . . . . . . . . . . . . . . .360 Elevation, maximum . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 Tail swing, maximum . . . . . . . . . . . . . . . . . . . . . . . . .2642 mm 8'8'' Hook height, boom horizontal . . . . . . . . . . . . . . . . . .2000 mm 6'6''
TRANSMISSION Six speed dual range power shift Torque Converter with full forward and reverse speeds.
CRANE PERFORMANCE GENERAL DIMENSIONS Weight with outriggers (approx.): . Length, overall (4 Section boom): . Width, overall: . . . . . . . . . . . . . . . Turning radius: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
(four section boom)
CHASSIS Frame Length, overall: . . . . . . . . . . . . . . . . . . . . . . .4737 mm 15' 6.5" Box section, center: . . . . . . . . . .572 mm x 127 mm 22.5'' x 5'' Box section, overaxles: . . . . . . . . .381 mm x 127 mm 15'' x 5'' Ground Clearance Axle: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .406 mm 16" Outriggers: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .381 mm 15"
Boom topping speed: . . . . . . . . . . . . . . . . . . . . . . . . . . . .18.9 sec. Boom lowering speec: . . . . . . . . . . . . . . . . . . . . . . . . . . . .17.8 sec. Swing speed: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4.4 rpm Outrigger speed: Down: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3.9 sec. Up: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3.3 sec. Crowd speed (approx.) Extending: . . . . . . . . . . . . . . . . . . . . . . . . . .15.2 m/min 50 fpm Retracting: . . . . . . . . . . . . . . . . . . . . . . . . .18.3 m/min 60 fpm Average line speed: Low: . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38.1 m/min 125 fpm Intermediate: . . . . . . . . . . . . . . . . . . . . . . .68.6 m/min 225 fpm High: . . . . . . . . . . . . . . . . . . . . . . . . . . . .106.7 m/min 350 fpm Standard rigging: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-part line Maximum hook speed with 5-part line . . . . . . . .21.3 m/min 70 fpm Capacity: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .See load charts
HOIST PERFORMANCE AXLES Front: NoSPIN Rear axle disconnect Front and rearSteering Type, planetary Mounting Front: Rigid to frame Rear (no locks needed): Elastomeric suspension Wheels: Integral disc and rim Single part line pull, maximum, bare drum:. . . . . . 3402 kg 7500 lb Single part line pull, rated:. . . . . . . . . . . . . . . . . . . 2812 kg 6200 lb Hoist Drum Capacity: . . . . . . . . . . . 137.2 m 14.3 mm 450.1' cable Wire rope: . . . . . . . . 8 x 19 Seale, rotation resistant 9/16'' diameter IWRC. Minimum breaking strength: . . . . . . . . . 15 tons (30,000 lbs)
STEERING
WORKING RANGES
C E
D X AB
BB W J K R V Q S T U P N L M
F H Y Z AH AJ
AC AD AE
AG
Dimensions
mm / ft. inches A B BB C D E F G H J K L M N P Q R 8992 2642 1168 6248 178 699 749 1930 3378 2000 165 89 4153 1143 1295 1448 1181 29' 6'' 8' 8'' 3' 10'' 20 6'' 7'' 2' 3.5'' 2' 5.5'' 6' 4'' 11' 1'' 6' 6.75'' 6.5'' 3.5'' 13'7.5'' 3' 9'' 4' 3'' 4' 9'' 3' 10.5'' S T U V W X Y Z AB AC AD AE AF AG AH AJ
mm / ft. inches 2743 2426 5144 89 3416 920 2438 1511 2642 4089 2514 2223 406 508 2057 4331 9' 0'' 16' 3.5'' 16' 10.5'' 3.5'' 11' 2.5'' 3' .25'' 8' 0'' 4' 11.5'' 8' 8'' 13' 5'' 8' 3'' 7' 3.5'' 16'' 20'' 6' 9'' 14' 2.5''
Off front of crane Without outriggers 30000 21750 16250 14600 13300 11250 9500 8000 6800 6300 4100 3200 2450 1950 1500 1200 900
Boom Angle Jib Angle 70 0 15 30 6000 4500 3000 60 5300 3400 2500 50 3900 2700 2150 40 3000 2350 1850 30 2500 2000 1500
Parts of Line 1 2 3 4 5
The loads given on the jib capacity chart are the maximum allowable loads due to structural limitations of the jib and boom. The loads on the rated load chart are to be reduced when lifting with the main boom hook block as follows: 1200 lbs with the jib in a working position, 800 lbs with the jib stowed.
Note: Avoid serious bodily injury or death. Refer to Operator Manual and CIMA Crane Safety Manual. The user shall operate at reduced rated loads to allow for adverse job conditions, such as soft uneven ground, out of level conditions, high winds, side loads, pendulum action, jerking or stopping of loads, hazardous conditions, experience of personnel, traveling with loads, electric wires, etc. Side pull on boom or jib is hazardous. Before lifting a load, be sure that: the weight of the load is known, the proper parts of line are used, the load is secured and rigged properly, the hook has a functioning safety latch, the wire rope is in both good condition and has sufficient number of wraps on the winch drum, and all personnel are clear. Rated loads, without outriggers, depends on tire capacity and condition of tires. Ratings are based on 14:00 x 2416 ply tires at 80 psi static and creep, and 17.5 x 2514 ply tires at 65 psi static and creep. For four section power booms, rated loads are based on extending the smallest boom extensions first. The first and second extensions are hydraulically sequenced to extend and retract equally. Boom length should be as short as possible to make a lift. If positioning a load by crowding, repositioning with the lower crowd is recommended. Rated loads shall include the weight of hook block, slings and auxiliary lifting devices. Their weights shall be subtracted from the listed rated load to obtain the net load to be lifted. Single line weighted hook block weighs 125 lbs. Do not two-block. Multiple line hook block weighs 375 lbs. Do not two-block. Working radius is the horizontal distance from a projection of the axis of rotation with respect to the supporting surface, before loading, to the center of the vertical hoist line or tackle with load applied. Do not operate at radii or boom angles where capacities are not listed. For tipping limitations, do not exceed the crane load rating chart. **Rated loads above the heavy line are based on the machines hydraulic or structural competence and not on the machines stability. Rated loads are based on freely suspended loads. Do not two-block. Jib movement and pinning must be controlled during erection and stowage.
STANDARD EQUIPMENT Alternator, 62 MP Antifreeze to -34 C -30 F Two block damage protection 13600 kg 30,000 lb capacity Audible backup alarm Automatic hoist and swing brake Battery, dual heavy duty Boom, 4 section, self-proportioning full power hydraulic with 60 ft. reach Boom angle indicator Boom elevation, 70 maximum Boom point with 3 sheaves Bubble level indicator Cross line relief protection for hoist and swing circuits Drum, grooved Dual swing control Electric gauges, fuel, converter temperature, voltage, water temperature & transmission pressure Electrical system, 12V Engine aire cleaner, dual stage dry with service indicator & safety element Engine hood sides Four wheel drive with axle disconnect Four wheel power brakes Four wheel steering Hoist, 3 speeds Hook block, 5 part line Hook latch Horn Hourmeter Hydraulic outriggers with pilot check valves Master electrical disconnect Muffler NoSPIN front axle Over center check valves for crowd and boom lift cylinders Powershift transmission Rear steer indicator Rotation, 360 continuous Seat, adjustable bucket type Tandem hydraulic pumps 114 and 189 lit/min 30 and 50 GPM Tires, directional, 14:00 x 24-16 P.R. Torque converter
OPTIONAL EQUIPMENT Alarm, engine (high water temperature, low oil pressure) Auxillary sheave (boom point) Auxillary hoist with cable Cab, deluxe enclosed with front wiper, 12000 BTU heater, defroster fan, two outside mirrors and seat belt Electric tire pump with hose and gauge Hook and weight for single part line Jib and gantry, 6096 mm 20' Lights, directional signals Lights, flood, chassis mounted Lights, flood, pedestal mounted Lights, front headlights with combination stop/tail on rear Open cab Paint, special (one color) Pintle hook Rear view mirrors, outside mounted Starting aid, ether injection Sound suppression kit Tires, 14:00 x 24, 20 P.R. non directional, type Tires 17.5 x 25, 14 P.R. directional, tubeless Winch, mounted on front outrigger frame
AESS611-00
DK07(3M)BM DataKom
07/02 (EV-1)
www.KomatsuAmerica.com
Materials and specifications are subject to change without notice is a trademark of Komatsu Ltd. Japan