Sie sind auf Seite 1von 5

Induced GGL, Flux Magnet

Magnetic properties of exposure


Most substances very little effect on the magnetic field. Suppose the solenodia or toroida cu rrent flows specific to the sector in a point inside the solenoid or toroid, which was relied upon in a vacuum, there is a magnetic induction of B1: here the index v means the vacuum. If the solenoid or toroid is now filled substance, the field at a pointwill change to B .two terms are defined below: Relative permeability of a substance = km = B / Bc Permeability of the substance = u = km0 Recall that 0 is the permeability of vacuum 4 x 10 T m / A Substances are called diamagnetic, if r its slightly smaller than one (for eg: tin black r=0.9 99 984). Diamagnetic substances causing the solenoid or toroidal field slightly reduced. Paragmetik substance has a price r is slightly greater than one (as egaluminum r = 1, 000 021). Substance paragmetik bit field in the solenoid or reinforce toroid. Ferromagnetic substances like iron and suasa - suasanya air-r about 50 or greater. Substance thus greatly strengthening the B field in the solenoid or a toroid. FLUK LINE MAGNET The magnetic field can be described by the line - a line of field (or lines of magnetic force). Provided that the vector b disuatu points on field lines directed by a tangent to the field lines that dititik. If the line - these lines depicted in such a way as to amount to penetrate the unit area in a perpendicular is equal to the value of the local B, then the field lines are also called line of magnetic fluk.

FLUK MAGNET (), which through the area A is the number of lines that penetrate the wide fluk the kia B1 is a component B of A is perpendicular to the surface. Fluk through a vast magnet = = B1A Fluk (magnet) is expressed in units of weber (Wb)

GGL-INDUCTION If there is a change fluk penetrating a winding, then the coil is affected by an induced emf. -Induced emf occurs during fluk summarized changed. GGL-Faraday law of induction for fluk suppose that through a coil consisting of N winding turns.If the time fluk changes in the coils of the average emf terinduksikan between the two ends of the coil is:

=-N
This induction GGL bersatuan volt (V) changes fluk t expressed as Wb/s minus sign indicates that this induced GGL against changes in the cause arises. This is known as. Lenz's law Induced GGL is always directed in such a way to resist the change fluk magnet which is the cause. For example, if the coil increases fluk flows arising from the emf-induced (this is called the induced current flow) will trying to produce a fluk negate earlier.or if fluk the coil is reduced, thus resulting induced current direction until fluk the accompanying tendency to restore the reduced fluk it. GGL-MOTION FOR INDUCTION every time a conductor moving in a field magnet, to cut the line - a line fluk, will ariseinduced emf in it in accordance Faraday's law. In this case means the number of lines are cut by a conductor fluk moving it, then.

=-N

= The number of lines per second fluk severed.

Symbol means that we only want to know the big ntentang affected emf, its direction will be considered below. Terinduksikan GGL in a conductor whose length L and moving with velocity v perpen dicular to the field B, is:

= BLc
With B, v and wire / conductor must be mutually perpendicular. In this case, Lenz's law still applies, namely-induced GGL is against the process of being progress. Resistance arising in the form of the force carried by the field on current carrying conductor's induction. So the direction of the induced current must besuch that

magnetic force arising against conductor motion. By knowing the direction of the induced current diketahuilah also the direction of induced emf. Problem - problem is solved 1. solenoid, 40 cm long, winding 8 cm2 area, the number of windings 300,containsiron with relative permeability of 600. If the 1.2 A solenoid energized evaluate (a) B at the point inside the solenoid, (b) fluk through the solenoid. a. Of chapter 31 is known that for a long solenoid that applies:
( )

Bc= Then

= 1,13 x 10-3 T

B = kmBv = (600)( 1,13 x 10-3 T) = 0,68 T b. Because the solenoid field lines are perpendicular cross-section, then: = B A = BA = (0,6 T)(8 x 10-4 m2) = 5,4 x 10-4 Wb Fluk through each coil. Because the solenoid consists of 300 turns, then: total = (number of loops) (flauk through one winding) = (300) ( 5,4 x 10-4 Wb) = 1,62 x 10-1 Wb 2. fluk through the toroid changes price 0.65 0.91 MWB MWB be filled when thetoroidal certain magnetic substance. What is the relative permeability and permeability of that material?

p =

= 1,40

Relative permeability of the substance. Ermeabilitasnya = p0 = (1,40) (4 x ) = 5,6 x

REFERENCES Erlangga. Physics. the seventh edition.frederick J.bueche.

FOREWORD Thank God I pray to Almighty God for His grace so that I can complete a paper titled induced GGL ,the magnetic flux. Intent and purpose of the preparation of this paper is to fulfill the task of the eye basic Physics II lecture. This paper will discuss the further from the introduction, the notion of induced GGL , the magnetic flux. The paper is organized on the initiative of lecturers Prof.Dr.R.Palilingan, Msi. is alwaysguiding and providing feedback to the author that this paper can be comple ted and maybe used for the improvement of knowledge in fundamental physics tha t can be applied in the application as a student of Faculty , majoring in Chemistry. In the completion of this paper is also not free thanks to the cooperation of colleagues who helped both morally and materially, for it is through this opportunity I would like to thank all parties involved in the preparation of this paper. Writing this paper is still very much flawed, both in the way of writing , drafting and lack ofreference literature and other limitations. for that constructive criticism it the authors hopeto increase the preparation of the next paper. Finally, Happy reading. Say thank you for your attention.

Tondano, February 2012 The author,

Group 8

Das könnte Ihnen auch gefallen