Beruflich Dokumente
Kultur Dokumente
he Svetlana 3CX6000A7 / YU148 is a high-performance ceramic/ metal power triode designed for use in zero-bias, RF amplifier service, and modulator service. A modern mesh filament is used, replacing the old-fashioned hairpin construction. The improved mesh filament design ensures better mechanical rigidity and long lasting concentricity of the filament, providing enhanced linearity, less noise, reduced warm-up variation and longer life. The low-inductance, meshfilament basket also forms a natural extension of the cylindrical stem geometry into the active area, giving superior VHF performance. The Svetlana 3CX6000A7 / YU148 is manufactured in the Svetlana Electron Devices complex in St. Petersburg, Russia. Svetlana has achieved the improved performance described above with exact replacement compatibility with the 3CX6000A7 / YU148 manufactured in the United States.
SM
Svetlana
ELECTRON DEVICES
Mechanical
Cooling Base Socketing Operating position Maximum operating temperature Maximum dimensions: Length Diameter Net weight
Typical operation
(Frequencies to 110MHz) Plate voltage Grid voltage Plate current Grid current* Peak RF cathode voltage* Calculated driving power* Plate dissipation Useful output power *Approximate values 4800 0 2.3 0.32 215 500 3200 8000 5700 0 2.5 0.33 224 600 4100 10000 6000 -100 2.56 0.48 340 800 3900 12000 V V A A V W W W
Page 2
Dimensional Data
Dim. Millimeters Min. Max. 152.4 155.58 19.8 21.4 92.1 15.6 16.1 37.6 38.4 75.9 76.4 20.6 23.8 34.9 41.3 9.5 11.1 96.4 107.9 84.5 17.5 20.6 203.2 226.6 65.1 25.4 28.6 Inches Min. Max. 6.00 6.125 0.78 0.843 3.625 0.614 0.635 1.488 1.512 2.988 3.010 0.811 0.937 1.374 1.626 0.374 0.437 3.874 4.250 3.327 0.688 0.812 8.000 9.000 2.563 1.000 1.126
R L
J K H G D E F C
Page 3
* Because the power dissipated by the filament represents about 546 watts and because grid dissipation can, under some conditions, represent another 225 watts, allowance has been made in preparing this tabulation for an additional 771 watts. 1 When air is supplied in the anode-to-base direction, a minimum of 5 cfm must be directed into the filament-stem structure between the inner and outer filament terminals to maintain the base seals below 250 C. A separate air system is not required with base-to-anode airflow.
Page 4
3.0
Plate Current - Amperes Grid Current - Amperes
-250
-200
-150 0.5
-100
-50 0.1
2 1
0 0
50
1000
2000
3000
4000
5000
6000
Page 5