Beruflich Dokumente
Kultur Dokumente
331101
331102
DIGITAL ELECTRONICS
331103
331103
7 8 9 10 11 12 13 1 2 3 4 5 6 7 8 9 10 11 1
331104
COMUNICATION ENGG.-I
331105
ELECTRONICS WORKSHOP
To obtain frequency response constant K-Lowpass filter. To obtain frequency response of constant K-Highpass filter. To obtain frequency response of M-derived Low pass filter. To verify maximum power transfer theorem. To design and test T-type attenuator. To design and test Pai-type attenuator. To design and test amplitude equalizer. To study the standard signal generator. To measure modulation index for AM wave using CRO, SSG and AFG. To measure modulation index for AM wave for different values of AF voltage [use collector To study tuned plate modulation. To study pre-emphasis and de-emphasis networks. To plot the S curve for the ratio detector circuits. To measure selectivity, sensitivity and fidelity of a super heterodyne AM receiver. To plot the output voltage v/s frequency for a tuned RF amplifier and to find the bandwidth. To study the fault finding procedure on AM receiver trainer kit. To study the varactor diode modulator used for frequency modulation. To take the observations for simple A.G.C. circuit used in the receiver ELECTRONIC COMPONENT SELECTION PRACTICES 1.1 Use of data book for discrete electronic components. 1.2 Use of data book for ICs. 1.3 Use of internet for searching components and datasheets 1.4 Access to websites of leading semiconductor device manufacturing industries 1.5 Use of application notes on electronic components CIRCUIT DRAWING AND PCB LAYOUT PRACTICES 2.1 Symbols of electronic components 2.2 Use of ORCAD 2.3 Use of SmartWork 2.4 Use of AutoCAD 2.5 Use of MultiSim 2.6 Use of Electronic WorkBench TESTING OF ELECTRONIC COMPONENTS 3.1 Use of analog multimeter 3.2 Use of digital multi-meter 3.3 Use of power supply 3.4 Use of signal generator 3.5 Use of oscilloscope PCB MAKING AND COMPONENT MOUNTING 4.1 PCB for transistor based small circuits 4.2 PCB for circuits based on small IC 4.3 PCB etching 4.4 PCB drilling 4.5 PCB testing 4.6 Soldering and desoldering MINI ELECTRONIC PROJECT FABRICATION 5.1 Project selection
5.2 Circuit drawing using softwares 5.3 Component selection and procurement 5.4 Component testing 5.5 PCB making and testing 5.6 Soldering and desoldering 5.7 Testing and fault finding MAINTANANCE AND REPAIRING PRACTICES 6.1 Maintenance and repairing of laboratory equipments 6.2 Repairing of domestic electronic appliances 6.3 Maintenance of computers and peripherals 6.4 Inspection of electronic goods