Beruflich Dokumente
Kultur Dokumente
Group Members :
Kunal Kshirsagar - 12MSS0034 12MSS0035 12MSS0039 A.Jagadeesh Kumar L.Vinoth -
Guide:
P.Sathya,M.E., SENSE VIT University
PROBLEM DEFINITION
In Fabrication areas,very important and sensitive problem is the external influence produced by
humidity, dust particles, temperature and pressure variations etc. Also,In case of PCB an exposure to humid ambient conditions will cause the absorption of moisture that can greatly affect the proper operation of the equipment. The corrosion on metallic parts of an electronic assembly is another problem generated by the humidity, especially in the fabrication stage.
OBJECTIVE
To Measure and monitor the environmental
Parameters like humidity and temperature using Labview. Developing a Data acqusition system that is capable to measure the Environmental parameters. Since we are getting input from the sensors periodically,it is possible to analyse the conditions at different Time instants.
LITERATURE SURVEY:
S.NO TITLE OF JOURNAL DESIGN TYPE
METHODOLGY
Temperature Sensor(LM35)
REFERNCE VOLTAGE
ANALOG MULTIPLEXER
ADC control
Channel Selection
DESCRIPTION
Temperature sensor (LM35)
Sensitivity - 10.0 mV/C Accuracy - 0.5C Temperature Range -55C to +150C Humidity sensor (HIH3605) Accuracy 2% Linearity 5% ADC0804 Resolution -8 bits Conversion Time - <100u sec Lab view Version 10.0
Work Plan
Area & Topic Identification ,Literature survey, Methodology work , project review
Sept 2012
Hardware Implementation
Oct 2012
CONCLUSION :
Environmental parameters (humidity, pressure, temperature etc.) have a significant impact on
electronic modules and circuits, those been necessary to be continuous monitored and measured, especially in fabrication areas. The performance of the proposed measurement and monitoring systems depends mainly by the sensors that are used. It has a simple structure and still allows an accurate monitoring of the proposed parameters.
REFERENCES:
S. Siddhaye, P. Sheng, C. Ooi, Environmentaleffects in
component packaging selection, IEEE Transactions on Electronics Packaging Manufacturing, Vol. 22, pp. 185 190, 1999. T.H. Huanga, J. C. Choub,T.P. Sunc, S. K. Hsiung, A device for skin moisture and environment humidity detection, Sensors and Actuators, Vol. 134, pp. 206- 212, 2008. Y. Takei, Y. Nakajima, Construction of The Monitoring System of Urban Environment in Shinagawa City, AIJ J. Technol. Des., Vol.13, No.26, pp. 635-640, 2007. N. Kularatna, B. H. Sudantha, An environmental air pollution monitoring system based on the IEEE 1451 standard for low cost requirements, IEEE Sensors Journal, Vol. 4, pp. 415 42, 2008. A. Hassanzadeh, R.G. Lindquist, A. Borghei, Relative humidity measurement using capacitive sensors, Southeastcon, IEEE, pp. 396 398, 2008.