Beruflich Dokumente
Kultur Dokumente
ME-370
Training Participants:
Md. Jubayer Hossain(0510077) Shuvra Banik(0510094) Aminul Islam Khan(0510117) Sudarshan Chandra Saha(0510119) Md. Shoeb Hasan(0510130)
2
Boiler
Boiler capacity (Superheated steam): 670 t/h Reheat steam flow rate: 580 t/h Superheated steam temperature: 545 C Reheat steam temperature at boiler outlet: 540 C Feed water temperature: 247 C Boiler efficiency: 93%
5
Turbine
Nominal capacity of the turbine: 210 MW Number of cylinder: 03 Total number of stage: 29 Number of extraction: 7 Frequency of rotor rotation: 3000 r.p.m Steam consumption of turbine at full load: 638.1 t/h
6
Generator
Power output: 210 MW Power factor: 0.85 Stator voltage: 15.75 5% KV Excitation voltage: 430V Phase: 3 Frequency: 50 Hz Stator cooling media: Demi-water Rotor cooling media: Hydrogen
7
Description of boiler
It is the steam generation unit of the plant It transfers the heat energy of the combustion of fuel to the water It consists of a boiler drum, mountings and accessories
Boiler mountings
These are the fittings, which are mounted on the boiler for its proper and safe functioning Different mountings: Water level indicator Pressure gauge Safety valve Steam stop valve Feed regulating valve Blow off cock Steam regulating valve
11
Boiler accessories
These are devices which are used as integral parts of a boiler, and help in running efficiently. Different accessories: Feed water pump Superheater Economizer Air preheater Reheater
12
Air preheating
Description of turbine
It consists of 3 cylinders: 1. High pressure cylinder 2. Intermediate pressure cylinder 3. Low pressure cylinder Number of stages are 29
15
Turbine of bearing
16
Turning gear
Used during starting and shut down It rotates the turbine shaft at 2-3 r.p.m It prevent thermal stresses developed due to non-uniform cooling
18
Generator
A generator consists the following parts: Stator winding (conductor) Rotor (magnet) Stator core
19
During closing:
1. Air out 2. CO2 in 3. When percentage of CO2 is reached to 99100%, hydrogen is introduced and CO2 gets out 4. When hydrogen purity reached to 99.9%, generator is closed
22
23
Shut down
Before shut down load is cut down to 70 MW. Then switch off. After shutting off, turning gear runs for about 72 hours at 3rpm.
25
Condenser
It is a shell and tube type condenser Cooling water passes through the tube and steam passes outside the tube The number of tubes are more than 12000 The inside temperature is 45oc It works at a pressure lower than atmosphere. It is 0.1kgf/cm2(-0.9kgf/cm2)
26
Ejector pump is used to vacuum the condenser The working principle of the ejector pump is based on venturi meter (Bernoulli's principle)
Deaerator
It removes the dissolved gas from the feed water The feed water is heated to saturation temperature by the steam extracted from the turbine to remove the dissolved gas
28
Description of pumps
Vacuum pump
Vacuum pump is used to create vacuum to bring the syphon come into action. There are two vacuum pumps One runs and another remains standby
Fig: Vacuum pump
29
31
Other pumps
Drip/Drain pump Technical water pump Gas cooling pump Raw water pump Oil pump Emergency oil pump Sealing oil pump Condensate water pump
32
33
35
An-ion exchanger
Decarbonizer
Cat-ion exchanger
Treated water
36
38
THANK YOU
39