Beruflich Dokumente
Kultur Dokumente
RF PLANNING
TEST MOBILE SYSTEM (TEMS)
TEMS is the drive test tools by Ericsson TEMS consists of Mobile Station with special software, laptop and a GPS receiver Phone with built in features, a serial cable and pc software package
PC is used for presentation, control and storage of measurements GPS will give the position of the measurements The TEMS measurements can be imported to a planning tool with the use of file and information converting system (FICS) The measurements can be displayed on the map so that the measured handovers can be compared with the predicted cell boundaries The information can be displayed in real time or recorded and relayed
SURVEY
GROUND BASE TOWER SITE (GBT)
Sufficient space should be avble for the GBT site Soil should not be back field one Soil condition should be good There should not be any high tension wire There should not be railway line near site it should be twice of the tower height Site should not be in low laying area There should not be any pipe line Access to the site for transportation purpose
SURVEY
ROOF TOP TOWER SITE (RTT)
Columns should be in continuity from the foundation to the top Reinforcement of columns to be checked Size of columns to be checked accurately Structural drawing to be checked if available Life of structure to be checked Slab should be in good condition Enough space to be available for erection of tower Sufficient space to be available for open the door of shelter There should be no high-tension wire in the close area There should be space for earthing pits, routing of power cable and strips Access to the terrace Access to the building
SITE ACQUISITION
Co-ordinate of site Measurement of tower area 1. RTT:- 9mtr -24 mtr 2. GBT:-30-40 mtr 3. 50 mtr 4. 60 mtr 5. 70 mtr Reinforcement 9 mtr 4 no 12 dia column 3.5 mtr 12mtr 4 no 12 dia 3.5 mtr 15 mtr 6 no 12 dia 3.5 mtr 18-21 mtr 6 no 16 dia 3.5 mtr 24 mtr 6 no 16 dia 3.5 mtr Area 850 sq ft 50X50 60X60 66X66 70X70 230X230 mm 230X230 mm 230X230 mm 230X230 mm 230X230 mm distance btn clmn
CIVIL
Site Survey Stability test of Soil for required structure Foundation Design Execution of work as per structural Design and Specification
FOUNDATION DESIGN As per the soil type and its bearing capacity Foundation design can be of following kinds:1. Raft Foundation 2. isolated foundation 3. Pile foundation
TOWER
Basically Two Types
Ground Base Tower Roof Top Tower (GBT) (RTT)
As per Materials
Angular Tower Tubular Tower
EARTHING
Plate earthling Bore earthling Chemical earthling
25x3/25x6/50x6
Shelter
EGB
EGB
arth Pit 1
Earth Pit 2
Lighting Arrester
ELECTRICAL
Electrical wiring DG to PIU DG to Charger Meter box to DG/PIU Types of cables Power cable Alarm cable All wiring &cables as per customer scope/specs
DG lay out
Guard room
SHELTER FDN
TOWER FDN
DG
Meter Board
TOWER
SHELTOR
SECURITY ROOM
GATE
Electric Pole
Cooling pads
PIU
300mm
D D F
PP & BB
750mm 600mm
2500mm
DOOR
BTS EXP
19 Rack
BTS
600mm
100 mm
W F T
SITE ARCHITECTURE
INDOOR OUTDOOR Sharing site Repeater site
Lighting Arrester
MW Mount
TOWER
PIU
Wall Feed Through
A C
Cell Site
DG SHELTER
Lighting Arrester
Radio
M W ANT
TOWER
PIU
Wall Feed Through
Sharing Site
MINILINK ANT Radio
TOWER Sharing
SHELTER Sharing
DG Sharing
OUTDOOR LADDER Sharing
GSM ANT
BTS
PIU Sharing
Feeder Inlet sharing
AC
Sharing
SMPS Battery
Repeater Site
MINILINK ANT
TOWER
Radio
DG SHELTER
OUTDOOR LADDER AND CABLE
TRSM RACK
PIU
Feeder Inlet
A C SMPS Battery
System Architecture
BTS MW MW MW 2 + 2+ 2 1+0 1 + 1 (Freq Diversity) 1 + 1 (Space & Freq Diversity)
TRSM RACK
CDU
TRU 1800 TRU 1800 TRU 1800 TRU 1800 TRU 1800 TRU 1800 GSM ANT GSM ANT GSM ANT
CDU
ECU
DXU 11
CDU
SMPS DG
Battery 200 AH
SITE-B
RADIO
ODU
ANTENNA
IF CABLE
DDU
SMZ 4x2 FAN UNIT
DDU
SMZ 4x2 FAN UNIT
MMU
TRSM RACK
MMU
IDU
AMM 4U
Splitter
SITE-B
RADIO ANTENNA
Wave Guide
ANTENNA
Wave Guide
Mounting Kit
RADIO
Mounting Kit
IF CABLE
RADIO
DDU
SMZ 16x2 FAN UNIT
DDU
SMZ 16x2 FAN UNIT
TRSM RACK
AMM 4U
SITE-A
RADIO
RADIO
IF CABLE
DDU
SMZ 16x2 FAN UNIT
DDU
SMZ 16x2 FAN UNIT
TRSM RACK
AMM 4U