Beruflich Dokumente
Kultur Dokumente
Bow to
Starboard
Loaded 12 m draft
UKC 3m
Starboard Turn
List 3 degrees
A Build up of
Lateral
resistance
Sinkage
Stern to
Port
1 m draft
increase due to
3 degree list
Pivot point
moves aft
New Pivot
point
Rudder force
less effective
Directional Stability
Vessels ability to hold course against
external influences
Fine lined vessel better than a blunt ended
tanker
Good directional stability rudder amidship
vessel should assume a straight course
Poor directional stability will continue to
turn even though rudder is amidship
In any case steering is less effective when
speed is reduced
Windage Area
Greater the windage area the
following effects are manifested.
Wind Ahead
Easily steered and
stopped.
Pays off easily
Difficult to bring
back
Tries to cross wind
Wind Astern
Easily steered.
Pays off easily
Difficult to bring
back
Tries to cross wind
Difficult to stop
due to leeway
direction.
Wind on Bow
Needs constant
weather helm
Resulting skid adds
to leeway
Greater speed
needed to swing
upwind
Tries to cross wind
Wind on beam
Maximum Leeway
Little effect on
steering
Wind on Quarter
Quarter blows
down wind
Bow luffs up
Vessel tries to
crosswind
Lee helm required
FULL AHEAD
STOP
Sternbore
A vessel tends to
sternbore into the
wind under sternway
FULL ASTERN
Effect of Current
Currents Effect all ships equally with regard
to handling qualities
regardless of trim or loading
downstream drift to be accounted for
Anchored or berthed rudder effective if there
is a flow of water past it
When berthing a vessel should stem the
current
Stemming Current
Stemming current good
control due to braking
effect of current
Tight Swing
Wide
Swing
Stopping Distances
The minimum distance over the ground
that a vessel requires to come to rest.
Speed trials on new tonnages determine:
Stopping distances in the following
From full ahead after ordering stop
From full ahead after ordering Crash stop
Full astern (aqpprox 10 x length of v/l)
Crash Stopping
Crash STOP = Full Ahead- Stop- Full astern
More Effective if =
Slow Ahead
Stop Engines
Slow Astern
Full Astern
Crash Stopping
High Frequency cycling
Using the Drag of the rudder
Hard over each way and reduce engine
revs in stages
Crash Stopping
Low Frequency Cycling
Hard a starboard
until 40 degrees off
course
Hard a port
until back
on course
Hard a
starboard
Full astern
Crash Stopping
A Full turn with gradual engine
reduction
If sufficient sea room
Best to e proceeding at correct speed
then vessel not required to Crash
stop
Turning Circles
Shell International Trading and Shipping Company Limited
5.. cables
TRANSFER
A
D
V
A
N
C
E
Course
# 180 deg
Speed App 7
kts
Time 5.5
mins
Course
# 270 deg
Speed App 6
kts
Time
8
mins
3.2
C
a
b
l
e
s
... cables
TACTICAL DIAMETER
4.5.cables
TRANSFER
A
D
V
A
N
C
E
C
a
b
l
e
s
Course
# 90 deg
Speed App 10 kts
Time
3 mins
... cables
TACTICAL DIAMETER
Course
# 360 deg
Speed App
kts
Time
mins
Turning Circle at
Full Speed
Course
# 90 deg
Speed App 4.3 kts
Time
8
mins
Course
# 180 deg
Speed App 2.4 kts
Time 12.5
mins
Course
# 270 deg
Speed App 1.6 kts
Time 20.5
mins
Course
# 360 deg
Speed App
kts
Time
mins
Turning Circle at
Slow. Speed
Propellers
Transverse thrust (wheeling effect)
Caused by bias of suction behind
propellers and Paddle effect.
Bias Greater
Strong Suction
Strong Suction
Weak Suction
Transverse Thrust
Weak Suction
Transverse Thrust
Propellers
Right handed Propeller
Thrust Ahead
Bow to Port
Transverse Thrust
Ahead Thrust
Right handed Propeller
Thrust Ahead
Bow to Port
Stern to Starboard
Astern Thrust
Right handed Propeller
Thrust Astern
Bow to Starboard
Stern to Port
Transverse Thrust
Astern Thrust
Stern to Port
Twin Screw
Good and Bad handling abilities
dependent on: Rudder configuration
Effect of Torque
Effect of transverse thrust
Pivot Point
Turning ability
Rudder Configuration
Rudder response poor
Effect of Torque
1 prop turning ahead and 1 turning astern
Vessel should turn to the opposite ahead
engine ie Port engine ahead vessel turns
to Starboard
If props are close together the effect of
the torque is disappointing.
Ideal Configuration
2 Props are set wide apart
Bridge Controls
Ahead
Astern
Bridge Controls
Ahead
Astern
CPP
Good speed control
No pitch no thrust no transverse
motion
Cant of vessel is unknown/ or at best
erratic when run astern.
Squat
Bank Effect
Shallow water
Interaction
Venturi Effect
Causes increase in velocity of water on the bank side
drop in water at the bank side
Cushion effect at bow suction effect at stern
Cushion
Effect
Fast
Water
Suction Effect
Squat
The bodily sinkage of a vessel making way
most noticeable in shallow waters
10m
9m
Girding Tugs
Girding a tug occurs: When a towline under stress is allowed to
lead directly abeam from a tug
FULL
ASTERN
Sudden Astern
Motion
Tug Listing
Heavily
Stern
Repelled
Surge Ahead
Surge Astern
Stern attracted
Heavy Weather
Dangers
Synchronism
Pooping
Pounding & Pitching
Broaching
Synchronism
If vessel disabled or stopped will lie
beam on to sea synchronised rolling
Attempt to bring head to wind. use
anchor chain as a drag
If Making way a small adjustment of
course
If Synchronised pitching adjust speed
Pooping
Following waves
Crashing down on poop
structural damage
Broaching
Surfing with following seas
Loosing steerage and stern being pushed beam on to sea
Points to consider:
Stability
Length of swell
Force of wind
Sychronism - Rolling & Pitching
Head to sea - Pounding
Stern to sea pooping and broaching
Heave to
Heavy seas endangering ship
Option to heave to
Vessel head is brought to wind and
speed is adjusted to maintain vessels
head to wind
Beware pitching & pounding
a point off the wind to ride the waves is
more advantageous
Manouvres
Turning Short Round
Manoverboard
Manoeuvre to minimise collision
damage
Manoverboard Manouvre
Determined by Type of Vessel
Proximity of traffic
Time of discovery and circumstances
of Case immediate or delayed turn?
Williamson, Scharnow, single turn,
double turn.
Williamson Turn
Vessel steadied
when course has
altered by 60o
Vessel should
round to the
reciprocal of
Original course
Scharnow Turn
Rudder Hard Over
After deviation
from original
course by 240
degrees rudder
hard over to the
opposite side
Double Turn
Rudder hard over
to side of casualty
30
Manoeuvre to Reduce
Collision Damage
If imminent collision is foresaw
Vessel should be manoeuvred to
minimise damage either
A Glancing blow
Or if no option
Present the bow as engineroom and
sensitive areas are aft.
Test
List factors /components with regard
to turning circles
Describe Bank effect, following
current.
Describe transverse thrust right
handed prop
Describe how to heave to for a vessel
proceeding with the weather