Beruflich Dokumente
Kultur Dokumente
Brief Introduction
Chen Jie
2010-12-4
Director
y 09:00~11:00
1
R8860E ;
RSU60
RSU60E
8900
Schematic
diagram
CC
UBPG
GSM
FS
SA
SE
NIS
STM-1
PM
Power Module
FA
FAN Module
CC Board Introduction
FS Board Introduction
SA Board Introduction
SA Board Jumper
E1 Cable
RSU60
RSU60E
RSU60 Panel and Interfaces Reference BS8800
GU360(V4.00.21)
Indoor GSM&UMTS Macro Node B Hardware Description
RRU Introduction
OLP Power
Cable and Dry
Contact Cable
Director
y 09:00~11:00
1
2 Usage of LMT
Software install and login
2 Usage of LMT
LMT folder
LMT run
2 Usage of LMT
Set Station IP
2 Usage of LMT
login
Director
y 09:00~11:00
1
RU Alarm
RU common Alarm is as follows:
Board communication link interrupted
Outdoor lightning protection box alarm
Remote Antenna Vswr Alarm
Remote antenna over VSWR alarm
Improper DPD running status
RU Alarm
Board communication link interrupted
Advice
Maintenance team meet this alarm. First check
optical fiber, if not ok, check the RU or FS board.
Change order optical interface optical
fiber RU FS board
RU Alarm
Remote Antenna VSWR Alarm
Remote antenna over VSWR alarm
Advise
The same as V3 VSWR alarm If VSWR of antenna is ok,
need to change the RU.
If the alarm is over VSWR alarm, reset the RU after you do
the active, the alarm can disappear.
About RU Alarm
Outdoor lightning protection box alarm
If happening at SWAP time this alarm maybe due
to cable connection of LPB is wrong. If happening at
Maintenance time, this alarm may be due to LPB is
fault. Maybe need to change the LPB
Here is the cable connection Refer to this map
About CC Alarm
Those alarm are due to the transmission. You should
check the transmission.
If you want to re-patch the EI SDR E1
Refer to this map
Fan alarm
If Fan alarm appear on FCE should change the Fan
or subrack 8700 Schematic diagram
SA
SA
Alarm Code
Self-defined dry contact alarm(198084317)
Dry Contact Alarm Content:BC gate safety
signal
Self-defined dry contact alarm(198084317)
Dry Contact Alarm Content:Water Leakage
Alarm
Self-defined dry contact alarm(198084317)
Dry Contact Alarm Content:DG Low Fuel
Remark
From SDR itself
From EASS
Director
y 09:00~11:00
1
Director
y 09:00~11:00
1
5Q&A
Director
y 09:00~11:00
1
6 Demo of 6370