Beruflich Dokumente
Kultur Dokumente
Contents
Equipment Overview
Safety Procedures
Installation
Commissioning
EQUIPMENT
OVERVIEW
RADIO IP20C
Power Specifications/Requirements
Power Specifications/Requirements
1. -48V DC Nominal
2. Maximum rating (MCB) of the overcurrent protection shall be 6 Amp.
Type of MW/IP-20C Interface Description
Safety Procedures
INSTALLATION
Antenna(s) are securely mounted to their relevant Pole Mount, with all
elements provided by the manufacturer.
Antenna(s) are installed properly with no physical damage, in accordance
with the manufacturer’s installation procedures.
Antenna(s) Feeder polarization is per link requirements.
Preparing of the Cables and
Connectorization
Preparing and Connecting the DC Power
Cable
COMMISSIONING
Commissioning
Changes to be done in System(Laptop)
1. Select Control Panel > Network and Sharing Center.
2. Change Adapter settings.
3. Select Local Area Connection > Properties > Internet Protocol Version 6.
4. Set the IP address according to requirements.
5. Click OK.
First to set TIME in equipment using CMD Prompt
1.First Login in Google Chrome using LOCAL IP > 192.168.1.1
2. Unit parameter to be changed as per LB (Platform Management>Unit
Parameter’s)
3. Port to be used (Platform Management>INTERFACE MANAGER)
For Vertical link (1+0)
o Radio slot2 Port2 should be UP
o ETH Slot1 Port2 should be UP
o Rest Ports set to Down
For Horizontal link (1+0)
o Radio slot2 Port1 should be UP
o ETH Slot1 Port2 should be UP
o Rest Ports set to Down
For XPIC link (2+0)
o Radio slot2 Port2 / Radio slot2 Port1 should be UP
o ETH Slot1 Port2 should be UP
o Rest Ports set to Down
4. IPV6 Settings (Platform>IP>Local)
4. SNMP Settings (Platform>IP>SNMP>SNMP Parameters)
5. Software Up-Gradation (Platform>Software>Software Version)
File Zilla Settings for Software Up-
gradation
6. License Settings (Platform>License>License Config.)
7. Radio Settings (Tx/Rx/Power Settings) (RADIO>Radio Parameters)
For Vertical link (1+0) > Radio slot2 Port2 should be used
Parameter to be changed in it (as per LB)
1. Tx freq
2. Rx freq
3. TX Level (Power)
4. Tx Mute Should be OFF
5. RSL Connector Source should be PHY2
For Horizontal link (1+0) > Radio slot2 Port1 should be used
Parameter to be changed in it (as per LB)
1. Tx freq
2. Rx freq
3. TX Level (Power)
4. Tx Mute Should be OFF
5. RSL Connector Source should be PHY1
For XPIC Link (2+0) > Radio slot2 Port1 / Radio slot2 Port2 should be used
Parameter to be changed in it (as per LB)
1. Tx freq
2. Rx freq
3. TX Level (Power)
4. Tx Mute Should be OFF
5. RSL Connector Source should be PHY1
8. MRMC Settings (Radio>MRMC>Symmetrical Script>ETSI)