Beruflich Dokumente
Kultur Dokumente
Configuration Guide
-- U2000 Web LCT
www.huawei.com
Configuration Procedure
Configuration Tasks
Setting the
Hybrid/AM
attributes of the
XPIC Hybrid radio
link
password:T2000
Copyright © 2006 Huawei Technologies Co., Ltd. All rights reserved. Page 6
Configuring the
Configuring Configuring the
IF/ODU Information
RF link mode
Creating an NE an NE of a Radio Link
Method 1:
Create an NE by
using the search
method.
②
①
①
②
Equipment Commissioning
Add boards.
③
①
②
④
Copyright © 2006 Huawei Technologies Co., Ltd. All rights reserved. Page 10
Power on Basic Confirm that the AM Align Enable the
equipment configuration function is disabled antennas AM function
Copyright © 2006 Huawei Technologies Co., Ltd. All rights reserved. Page 11
Configuring the
Configuring Configuring the IF/ODU Information
an NE RF link mode of a Radio Link
If an ODU supports only one T/R spacing, set this parameter to the default value 0. The default transmission status of an
ODU is Unmute.
Set ATPC parameters according to the network planning documents. Note that before the antenna alignment, ATPC
Enabled must be set to Disabled.
Copyright © 2006 Huawei Technologies Co., Ltd. All rights reserved.
Configuring the
Configuring Configuring the
Setting the Hybrid/AM an NE RF link mode
IF/ODU Information
of a Radio Link
Set AM Enable Status according to the network planning documents. Note that before the antenna alignment, make sure
that AM Enable Status is set to Disabled.
When AM Enable Status is set to Enabled, set Modulation Mode of the Guaranteed AM Capacity and Modulation
Mode of the Full AM Capacity according to the network planning documents.
E1 Capacity specifies the number of E1 services that can be transmitted in Hybrid microwave frames. Set this parameter
according to the design. Note that the number of E1 services at both ends of a radio link hop must be the same; otherwise,
the services are unavailable.
Copyright © 2006 Huawei Technologies Co., Ltd. All rights reserved.
Configuring the
Creating a 1+1 Protection Configuring
an NE
Configuring the
RF link mode
IF/ODU Information
of a Radio Link
Group
① ④
Use the
default
Select a working IF board and a
value.
protection IF board. In the case of 1+1
FD/SD protection group, the working
board and protection boards must be
configured in two paired slots.
①
④