Beruflich Dokumente
Kultur Dokumente
Saad Al Hassan
S84075703
NE Type
NE Type
NE Name Number
OptiX RTN 605 6
OptiX RTN 905 5
OptiX RTN 950 318
Evaluation result:
Total 785 NE Found
Optimization suggestion :
1. Total 6 RTN 605 was found. Suggestion to replace RTN 605 by RTN 905. RTN 600 series has many limitation with IP
service
Summary
Descriptions
Evaluation description:
Evaluation result: It refers to the channel
B1522 3-ISU3 B1530 3-ISU3 Not Pass
Link channel usability except the
availability: A total B1530 6-IFU2 B1522 4-IFU2 Not Pass usability caused by
of362 links are device faults.
evaluated, 119 B1637 4-IFU2 B1805 6-IFU2 Not Pass
Theoretically, it equals to
links Have less
the initial design value.
than 99.997% B2749 3-IFU2 B1689 3-ISU3 Not Pass
Rain Fading
Hardware Issue
Check
Avai. don't reach Bit Error
Start RSL
planning value Value
and TSL
Finish
Frequency
Interference
Average Utilization
160 Average Utilization
140 Ranges Number
120
0-10% 89
100
80
11%-30% 140
60 30%-50% 68
40
50%-70% 20
20
70%-100% 9
0
0-10% 11%-30% 30%-50% 50%-70% 70%-100%
Grand Total 326
Evaluation result:
Link BW Utilization:A total of 326 links are evaluated, 365 links meet requirements(percentage: 97.23 %) and 9 link does not meet
requirements(percentage: 2.76 %)
Optimization suggestion :
1. Check the average utilization, the status is ok
80 11%-30% 134
60 30%-50% 73
40
50%-70% 13
20
70%-100% 15
0
0-10% 11%-30% 30%-50% 50%-70% 70%-100%
Grand Total 326
Evaluation result:
Link Peak capacity saturation: A total of 326 links are evaluated, 311 links meet requirements (percentage: 95.398 %) and 15 link does
not meet requirements(percentage: 4.6 %)
Optimization suggestion :
1. Expand capacity of related links
2. Optimize services. Identify junk services and delete them.
RSL Status
Range Number
RSL Status Graph 15 Links have more than - 3dB difference, Some links are
180 down, we have omitted. Others needs to rectify now. Need to
160 check antenna installation / LoS / connections between
140 Antenna / ODU / IF cable;
120
100
80
Remark: Planning RSL is from RTN Designer, Actual RSL is
60
from performance data
40
20
0
-10dB< RSL Diff < - -5dB< RSL Diff < - RSL Diff < -10dB RSL Diff>0db
5dB 0dB
0
High Actual Highest FAN_AGING FAN_FAIL TEMP_ALARM TEMP_OVER
Shreshold Temprature
Evaluation result:
Temperature Range: Blue bar graph is up threshold of temperature, Brown bar graph is the actual temperature;
Few ISV3 and ISX2 card was found exceeding the threshold, suggested to check the IDU GAPS, Clean the IDU
Optimization suggestion :
Arrange FME to check environment, clean IDU
Software Version
Version Number Software Version
5.76.5.23 1
V100R002C00SPC200 11
V100R002C02SPC100 1
V100R003C00SPC100 2
V100R005C01SPC200 48
V100R006C00SPC200 1
V100R006C10SPC100 38
V100R007C10SPC300 20
V100R007C10SPC500 133
V100R008C00SPC100 1
Grand Total 454
Free Slots
IDU Type Number Free Slots
5000
OptiX RTN 620 3
4500
OptiX RTN 905 20 4000
OptiX RTN 950 4624 3500
3000
2500
OptiX RTN 950A 1296 2000
OptiX RTN 980 478 1500
1000
500
OptiX RTN 980L 1102
0
Grand Total 7523 OptiX RTN OptiX RTN OptiX RTN OptiX RTN OptiX RTN OptiX RTN
620 905 950 950A 980 980L
Evaluation result:
We can take the result as reference to expand direction or service in the future
Status Number
50
NO 110
Yes 232 0
NO Yes
Grand Total 342
Evaluation result:
Out of 342 Links, 232 links were found of High-Low Violation Case. This database is based on Iriver Planning Database. Few cases were
compared with U2000 and found match.
Front Office has to check the violated links, escalate to MW Planning.
Check if the Hub sites have High Low Violation high rate.
4 Long Route B1636/B2752/B1480 Suggested to Install ATN/OSN inbetween the long rout
5 LAG NA
6 VPLS NA 189 VPL Service were found, all of them are in Deployed Status
VLAN Status
Status Number
ok 209
Site Down 1
ok
VLAN not Configured 90 Site Down
Evaluation result:
1- VLAN is important for Ethernet service maintenance, should configure VLAN E2E, if don’t have we need to check MAC,
it will take long time to check route of service;
2- Ethernet Trail can make Ethernet OAM more easier
3- need to delete redundant VLAN for IPRAN sites
TDM Status
Cross Connection Number
Active 11424
Inactive 1682
Grand Total 13106
TDM Status
Active Inactive
Evaluation result:
Out of 13105 TDM Service among South East Region, 1682 TDM Service was found inactive including RTN & OSN. 12.83% of the TDM
service is inactive. The BO/ FO need to analyze these service, if not needed, delete the unwanted service
Top 15 Alarms
3500
3000
2500
2000
1500
1000
500
0
Evaluation result:
1- There are totally 16458 pcs alarms in South East area, the top 15 alarms
2- Configure the parameter requested, for example PASSWORD_NEED_CHANGE / CLK_NO_TRACE / ETH_LOS
Check the hardware, for example BD_STATUS / BD_NOT_INSTALLED
Check the service if exist actually in network, T_ALOS / UP_E1_AIS / DOWN_E1_AIS
For TU_AIS, check the alarm exist time, if more than 3months, we can judge that it’s redundant service, can be deleted
Hardware Alarms
1000
800
Evaluation result: Hardware Alarms
600
400
1- Cold reset the board;
200 2- Remove and reseat the board;
3- If the alarm persists, replace the board
0
Software Alarms
1400 Evaluation result:
1200 1- SWDL_PKG_NOBDSOFT
1000
800 Reload Software
600
400
2- SWDL_AUTOMATCH_INH
200 Need to be handled by support of GTAC
3- SWDL_INPROCESS
COM_EXTECC_F…
0
BFD Session…
MW_CFG_MISMA…
POWER_ABNOR…
TUNNEL_APS_D…
RADIO_RSL_BEY…
GNE_CONNECT_…
IS-IS Adjacency…
MPLS_TUNNEL_…
MPLS_TUNNEL_…
PORT_EXC_TRA…
CPW_ODU_SER_…
NE_COMMU_BR…
The TE tunnel…
ETH_CFM_UNEX…
MPLS Tunnel…
SUM_INPWR_LOW
B1_SD
B3_SD
AM_DOWNSHIFT
IN_PWR_ABN
MW_LIM
BIP_SD
ETH_APS_LOST
LP_REI
SECU_ALM
ETH_LOS
HP_REI
R_LOS
DROPRATIO_OVER
LRDI( MS_RDI )
MAC_EXT_EXC
SWDL_INPROCESS
SYNC_C_LOS
LAG_DOWN
Link Down
DCNLINK_OVER
LCS_LIMITED
NESOFT_MM
CLK_LOCK_FAIL 3 160
CLK_NO_TRACE_MOD 140
E 170 120
Grand Total 173
100
Clearence Status
80
60
Row Labels Count of Clearance Status
Not Cleared 31 40
Cleared 142 20
Evaluation result:
Out of 173 Clock Alarms,31 alarms are not cleared. Also need to check the history alarms whether the alarms are occurring on regular basis.
If yes, need to change the configuration
2.06 8
6000
2.09 2
4000
8 5792
8.06 9873 2000
Grand Total 16471
0
1.04 1.06 1.1 2.06 2.09 8 8.06
Suggestions:
1- RADIO_TSL_LOW etc alarm occurs with low ODU Version.
2- CONFIG_NOSUPPORT, 256Q Modulation makes Bit Error of low ODU Version.
3- Analyze the links and upgrade the ODUs to higher versions
DCN Status
NE Type Number Communication Status
1400
OptiX RTN 605 26 26
1200
Can Not Connect 10 10
1000 Normal 16 16
800 OptiX RTN 620 2 2
600 Normal 2 2
OptiX RTN 905 56 56
400
Can Not Connect 4 4
200
Normal 52 52
0 OptiX RTN 950 739 739
Can Not Connect 19 19
Normal 720 720
OptiX RTN 950A 212 212
Can Not Connect 3 3
Normal 209 209
OptiX RTN 980 26 26
Suggestions: Normal 26 26
1. Check the GNE settings OptiX RTN 980L 99 99
Can Not Connect 2 2
2. If NE is not live for long time, delete the NE Normal 97 97
Grand Total 1160 1160
3. Check if there is any power issue
4. Keep on monitoring