Beruflich Dokumente
Kultur Dokumente
System diagnostic
www.actia.com
Diagnostic
Diagnostic session preparation
Diagnostic options
Powered up bus with Acita multiplex electric system (batteries voltage> 23VDC)
In main Memory stick folder create sub folder with name „MAJ”
from french language„mise à jour” (update)
If S-Diag is run with memory stick in and you don’t want to update it choose „No” at the first incomimg
question on the screen „Are you sure you want to RAZ the tool?”
Configuration window should apear automaticaly after restarting S-Diag. If not follow steps below:
IP „192.168.128.94
Mask: „255.255.255.0”
IP gateway: „192.168.128.249”
Confirm changes
Cancel changes
Confirm changes
Cancel changes
When below screen appear take memory stick out and click on
Diagnostic options
List of main available componets will appear on the screen. Choose one to connect and click on
List of all componets in choosen computer will appear. Choose the one you want to diagnose and click on
Diagnostic options
From the level of remote tool (Computer, tablet, smartphone …), Connect to WiFi network generated by S-
Diag or by Ethernet cable
ex. „SDIAG-0000025”
If not possible to scan QR code click and type web address into browesr
Diagnostic options
Modul name
Signal name (regarding Actia documentation)
Variable name
Signal status
Pin of the signal
Signal description (Solaris decribed it)
Fault presence
Additional informations
List of all inputs and outputs, choose the signal and click on it
Arrow clicking will swipe to nex signals
Modul name
Signal name (regarding Actia documentation)
Variable name
Signal value (on./off./value/etc…)
Pin of the signal
Signal description (Solaris decribed it)
Dynamic mode
On./ off.
Direction (bridge and half bridge)
Connect memory stick to S-Diag where is already created forder „\CONF” and click
Click on„Connect”