Sie sind auf Seite 1von 17

FOUNDATION OF AC

CIRCUITS
(LECTURE 2)

EPO460 March 2013 1


A. Basic Principles of AC Circuits
• 2 fundamentals laws in AC circuits
• Ohm’s Law: V = IR
V - potential difference in volts (V)
I - current in amperes (A)
R - resistance in ohms (Ω)

A1- Kirchoff’s Voltage Law:


• “the algebraic sum of all voltages around any closed loop is zero”

Or V1+ V2 +V3= 0

EPO460 March 2013 2


EPO460 March 2013 3
NZA 2009
A2- Kirchoff’s Current Law:
“the algebraic sum of currents at a node is zero”

EPO460 March 2013 4


A3- AC Circuit
:alternating current form (AC) that has positive
& negative portions
Vm- the maximum voltage
V(t) = Vm sin ωt ω - angular frequency in rad/s = 2πf
f - supply frequency in Hz
T- period = 1/f

AC Signal

EPO460 March 2013 5


Two AC Signals with Different Phases

Vm sin (ωt + Φ) is a signal that leads the


original signal by an angle of Φ
EPO460 March 2013 6
When capacitors or inductors are involved in AC circuits, then
current & voltage do not peak at the same time. The period
difference between the peaks expressed in degrees is called
phase difference. This phase relation is often represented
graphically in a phasor diagram

RMS Voltage is the root- mean–square of Voltages

Vm - the maximum voltage

EPO460 March 2013 7


NZA 2009
Example 1
An AC signal is given as V (t) = 141.4 sin 314t.
Determine the following:
a) Maximum voltage
b) RMS voltage
c) Frequency
d) Period to complete 1 cycle
e) Phase shift

EPO460 March 2013 8


NZA 2009
B - Components of AC Circuit:
V - the effective or rms voltage values
I - the effective or rms current values
V=IZ where Z - the impedance

Resistor – R in Ohms (Ω)


Inductor – L in Henry (H)
Capacitor – C in Farad (F)

p.f. = cos θ i. Pure Resistive Circuit


Power factor is 1.0 or Z=R
unity since θ = 0 °

EPO460 March 2013 9


ii. Inductive Load where Z = R + j XL

Where XL = inductive reactance (Ω)


= 2πfL = ωL
L= inductance (H)
f = supply frequency

p.f. = cos θ
Power factor is lagging

EPO460 March 2013 10


iii. Capacitive Load, Z = R – jXC
Where XC= capacitive reactance (Ω)
1 1
= 
2  fC C
C = capacitance (F)

p.f. = cos θ
Power factor is leading

EPO460 March 2013 11


Example 2
A resistance of 7.0Ω is connected in series with a pure
inductance of 31.4mH and the circuit is connected to a 100V,
50Hz, sinusoidal supply. Calculate the circuit current & the
phase angle.

EPO460 March 2013 12


B. Power in AC Circuits
Active, reactive & apparent power apply to
steady-state AC circuits with sinusoidal
waveforms only.

1. Active Power, P (Watts)


 real power @ true power @ actual power
 The effective power that does the work
 P = V I cos θ where θ is the angle between V & I
 P = I2Z cos θ

EPO460 March 2013 13


2. Reactive Power, Q (VAr)
 imaginary power
 Does no real work, circulating power
 Q = V I sin θ
 Q = I2Z sin

3. Apparent Power, S (VA)


 The vectorial sum of real and reactive
power
 S= P+ jQ
EPO460 March 2013 14
C. Sources and Loads:
 Generator - delivers active power

 Resistor- absorbs active power

 Capacitor- delivers reactive power

 Inductor- absorbs reactive power

D. Complex Power, S

 S = V I*
 S = (V∟θv°)(I∟-θi°)* = (V∟θv°)(I∟+ θi )
= P + j Q = VI cosθ + j VI sinθ

EPO460 March 2013 15


E. Power Triangle

P
pf   cos  Where 0 < pf < 1
S

Resistive Load Inductive Load Capacitive Load


I is in phase with V I lags V I leads V
θ = θv° - θi° = 0 θ = θv° - θi° > 0 θ = θv° - θi° < 0
Q is zero Q is +ve Q is -ve
pf is unity pf is lagging pf is leading

EPO460 March 2013 16


Example 3
Figure below shows an AC voltage source supplying power to a load
with impedance Z = 20∠-30 Ω. Calculate the current, I supplied to the
load, the power factor of the load, and the real, reactive, apparent,
and complex power supplied to the load

EPO460 March 2013 17

Das könnte Ihnen auch gefallen