Beruflich Dokumente
Kultur Dokumente
Product Positioning
The MiX 4000 series is targeted at the mid-level Fleet Management market sector
Fleet
Asset Security Track & trace
Management
MiX2000
Beam-e
MiX2000
Remora
MiX Tabs MiX6000
www.mixtelematics.com
3
MiX 2000, MiX 4000 and MiX 6000 shares the same commissioning server
Supports FM3xxx scripting engine – current CAN and Serial scripts are compatible
www.mixtelematics.com
4
2 CAN Bluetooth
Ports
Worldwide
K-Line
Magix
MiX 2000
MiX 4000
2 x CAN Ports (Vehicle + DTCO) GPS and GLONASS
2 x Serial Ports Tamper Detect Switches
Worldwide Magix (RF) GSM and GPS disconnect detection
Bluetooth Input Open Load and Floating detection
3-Axis Accelerometer Internal Antennas (Optional External)
www.mixtelematics.com
5
www.mixtelematics.com
6
www.mixtelematics.com
7
SIM and PIN
• The format of the SIM must be “Nano” or (4FF)
• Disable PIN on SIM – then MiX 4000 will never attempt to PIN the SIM
• If the SIM must be Pinned, MiX4000 expects a SIM with default PIN of:
– 0000 (4 zeros) or 00000 (5 zeros)
• The SIM PIN will then be changed with first boot to a secret PIN that is calculated based on a Hash
function of the IMEI number of the modem
• This means the SIM can not be moved to another unit (with a different IMEI) unless you reset the
SIM PIN to 0000 or 00000
www.mixtelematics.com www.mixtelematics.com
8
MiX 4000 - Driver ID
• MiX 4000 uses the same blue code plug interface as FM 3xxx for driver identification
• Extended driver ID is supported
• The list of authorized drivers is stored in the MiX 4000 and not on the plug
• Any valid driver plug will be read and the ID assigned as driver for the trip
• The buzzer will beep for a configured duration or until a valid driver plug is inserted (zero seconds /
don’t beep is default)
• Successful reading of a valid driver plug is acknowledged by two short beeps
• No beep will sound if an invalid/incorrectly programmed driver plug is inserted
• The red LED on the code plug socket will flash until a valid driver plug is inserted
• The red LED turns off once a valid driver is associated with the current trip
In future releases Driver ID will also be supported via RF ID reader (serial port) and Bluetooth
www.mixtelematics.com www.mixtelematics.com
9
MiX 4000 – Starter Interrupt
• Starter interrupt (immobilizer) can only be used with Driver ID and a wired ignition
• The MiX 4000 main harness includes a starter interrupt relay socket (relay not included)
• Refer to the Installation manual for wiring instructions
• The immobilizer will be activated at the start of a trip and starting the vehicle will not be possible
without a valid Driver ID (blue plug)
• Presenting a valid Driver ID (blue plug) will deactivate the immobilizer and allow starting of the
vehicle
• The immobilizer will automatically activate after a configured period at the end of a trip
• After the immobilizer is activated, the blue plug will have to be reinserted to allow starting
• Restarting before the immobilizer is activated (after the end of the trip) will not require the blue plug
(valid Driver ID)
Note: If immobilization is not required, the relay need not be added and no additional configuration is
necessary
www.mixtelematics.com www.mixtelematics.com
10
DTCO (Tachograph)
MiX 4000
and Driver ID card
www.mixtelematics.com
11
www.mixtelematics.com
12
www.mixtelematics.com
13
440FT0931 Serial Harness SR1 Serial Harness (RX, TX, CTS, RTS, GND, DSR-
DTR looped, RS232 with DB9 Male Connector)
440FT0623 Code Plug Socket Code Plug Socket Harness (Code Plug Socket
Harness with circlip with circlip and 4-Way connector)
440FT0930 Code Plug Harness CP2 Code Plug Extension Harness (1m)
440FT0426 MiX 41MC-3G 3G (Global) - MiX 4000 with Type9 and Type4
Magix (433MHz and 915MHz)
www.mixtelematics.com
14
www.mixtelematics.com
15
Documentation
The following documentation and resources are available on Confluence
MiX 4000 Home Page
Product Fact Sheet (PFS)
Installation Manual
Cables and Connectors
Certification and Environmental Test Results
www.mixtelematics.com
16
Support
General Product Support
• Technical support issues can be raised via MiX Assist with the International Support team
mailto:mixassist@mixtelematics.com
www.mixtelematics.com