Beruflich Dokumente
Kultur Dokumente
References
Table 9 - IS 456
Kg
Types Of Mix
2. Design Mix:
70
NUMBER OF SPECIMENS IN 70
60
60
55
52
50
50
INTERVAL
40
35 35
30 30
30
20
15
10 10
10 7
4 5
2 3 3 3 2
0 1 1 1
0
40 41 42 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65
COMPRESSIVE
STRENGTH IN MPa
Standard deviation (S.D.) :
The value of 1.65 is based upon the provision that 5% of the test results can be
accepted having lower than the required strength.
Value of X Table 1 of IS-10262
Grade Of Concrete Value of X
NOTE-
1. In the absence of established value of standard deviation, the values given in
Table 8 may be assumed and attempt should be made to obtain results of 30
samples as early as possible to establish the value of standard deviation.
1-5 1 ≥ fck + 4 34
Acceptance Criteria (As per CBC)
1. Compressive strength-
(For M-20 & above grades only)
39
4. Selection Of Water Content
Table-4 of IS-10262 Water content per cubic meter of concrete for
nominal maximum size of aggregate.
Volume-
a. Volume of entrapped air
b. Cement = Mass x 1
SG 1000
c. Water = Mass x 1
SG 1000
e) Water absorption:
1) Coarse aggregate - 0.5%
2) Fine aggregate – 1.0%
f) Moisture content of aggregate (As per IS 2386 (Part-3)):
1) Coarse aggregate - Nil
2) Fine aggregate - Nil
g) Sieve analysis:
1) Coarse aggregate - Conforming to Table 7 of IS 383
2) Fine aggregate - Conforming to grading Zone II of
Table 9 of IS 383
CALCULATIONS FOR MIX PROPORTIONING
1. TARGET STRENGTH FOR MIX PROPORTIONING
f'ck = fck + 1.65 S OR fck + X whichever is higher
From Fig. 1, free w/c required for the target strength of 48.25
N/mm2 is 0.36 for OPC 43 grade curve.
(For PPC, the strength corresponding to OPC 43 grade curve is assumed for
the trial).
From Table 5 of IS 456, maximum water-cement ratio = 0.45.
prescribed for ‘severe’ exposure for reinforced concrete.
0.36 < 0.45, hence O.K.
4. SELECTION OF WATER CONTENT
7. MIX CALCULATIONS