0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
30 Ansichten1 Seite
The document describes the brake cooling system on a vehicle. It has an OCDB relief unloader valve that closes at engine start and opens when brake cooling oil reaches 50°C. A motor drives three pumps to pump oil through a strainer and filters before it reaches the front, center, and rear disc brakes. A cooler returns warm oil to the tank when it reaches over 50°C. Sensors monitor oil pressure and temperature and trigger warnings.
The document describes the brake cooling system on a vehicle. It has an OCDB relief unloader valve that closes at engine start and opens when brake cooling oil reaches 50°C. A motor drives three pumps to pump oil through a strainer and filters before it reaches the front, center, and rear disc brakes. A cooler returns warm oil to the tank when it reaches over 50°C. Sensors monitor oil pressure and temperature and trigger warnings.
The document describes the brake cooling system on a vehicle. It has an OCDB relief unloader valve that closes at engine start and opens when brake cooling oil reaches 50°C. A motor drives three pumps to pump oil through a strainer and filters before it reaches the front, center, and rear disc brakes. A cooler returns warm oil to the tank when it reaches over 50°C. Sensors monitor oil pressure and temperature and trigger warnings.
At engine cold start - solenoid valve closes from IFM signal. Brake Cooling Circuit When Brake Cooling oil > 50°C (122°F) valve opens. Front Disc Center Disc Rear Disc Brake Packs Brake Packs Brake Packs 2.) Motor / Triple Pump - Motor drives 3 gear pumps and motor relief opens at 100 b (1450 psi) Cooling oil is pumped from the Pressure Cooling tank thru a strainer. Switch Relief @ 1 bar / 15 3.) 6 - Filter & 7 - Relief Valves - Relief @ Relief @ Oil to the front axle is filtered. psi Temperature 1 bar / 15 1 bar / 15 Each axle relieves cooling pressure to 1 bar / 15 psi. Switch / psi psi Sender 4.) Disc Brake Oil Cooler - Warm oil returns to the brake cooling tank thru the cooler when > 50°C (122°F). Cooler protected by check valve. Manifold 5.) 8 - High Pressure Switch - The N.O. pressure switch closes when brake cooling oil reaches 1.5 bar (22psi) 1 bar / 15 psi It signals the VDU for warning. Brake Cooling Disc Brake Filter Oil Cooler 6.) 9 - Temperature Switch / Sender - Motor / The N.C. switch opens when temp Triple 50 °C (122 °F) and signals the IFM to de-energize the solenoid on the Pump OCDB OCDB relief unloader valve. Relief If oil temperature > 60 °C (140 °F). Unloader The sender signals the VDU for System Pressure Valve warning. Drain to Tank Strainer Cooled Brake Oil Hot Brake Oil