Beruflich Dokumente
Kultur Dokumente
BY
S.Chinmayi
-07f21a0413
R.Manju Bhargavi -07f21a0436 B. Maruthi Prakash-07f21a0441 Mallikarjuna Guide: Mr.IMTHIAZ BASHA Assistant Professor, Gates Institute of Technology. Gooty. -07f21a0434 Head Of the Department: Smt. N.CHITRA Associate Professor, Gates Institute of Technology. Gooty.
AIM:
LEVEL DESIGN:
wireless technology
Components required: Micro controllers RF transmitter and modulator RF receiver and demodulator Relay and its drivers
Receiver section
Relay circuit RF receiver Demodulator
AT89S52
Sound system RF receiver
Micro controller:(AT89s52)
Features 8K Bytes of In-System Programmable (ISP) Flash Memory 4.0V to 5.5V Operating Range Fully Static Operation: 0 Hz to 33 MHz 256 x 8-bit Internal RAM 32 Programmable I/O Lines Three 16-bit Timer/Counters Eight Interrupt Sources Full Duplex UART Serial Channel Watchdog Timer Power-off Flag
AT89s52
RF TRANSMITTER(STT433)
FEATURES: 433.92 MHz Frequency Low Cost 1.5-12V operation 11mA current consumption at 3V Small size 4 dBm output power at 3V
TRANSMITTER(STT433)
OPERATION: When a logical 0 is being sent, the transmitter is off. fully suppressing the carrier. When a logical 1 is being sent, the carrier is fully on.
OOK
Exhibit
ENCODER(HT640)
FEATURES: 433.92 MHz Frequency Low Cost 1.5-12V operation 11mA current consumption at 3V Small size 4 dBm output power at 3V
ENCODER(HT640)
OPERATION:
Three-word
active high).
Repeat
Once
the transmission enable falls low, the encoder output completes its final cycle and then stops
RF RECEIVER(STR 433)
FEATURES:
Low Cost 5V operation 3.5mA current drain No External Parts are required Receiver Frequency: 433.92 MHZ Typical sensitivity: -105dBm IF Frequency: 1MHz
RF RECEIVER(STR 433)
OPERATION
super-regenerative AM detector
GAIN >1- oscillates. the gain will be lowered over time proportional to the RC time constant until the oscillation eventually dies. Ultimately oscillations starts again. Measuring the emitter current of the gain stage.
DECODER(HT648): FEATURES:
Operating voltage: 2.4V~12V Low power and high noise immunity CMOS technology Low standby current Capable of decoding 18 bits of information Pairs with HOLTEKs 318 series of encoders 8~18 address pins 0~8 data pins Trinary address setting Two times of receiving check Built-in oscillator needs only a 5% resistor
DECODER(HT640)
OPERATION: Decoders receives serial address and data from the encoders. It then compares the serial input data twice continuously with its local address. If no errors are encountered, the input data codes are decoded and then transferred to the output pins.
Generally relay coils are designed to operate from a particular voltage often its 5V or 12V.
Relay Switch
6.1 ADVANTAGES:
Its operation is simple and easy. It is less expensive. It is highly efficient. Power required is less. Portable
6.2 APPLICATIONS:
Consumer products including sound system, TV, etc can be automatically muted. Useful for drivers in automobiles to mute the sound systems when the phone is rang. Useful for physically handicapped people.
Future enhancement:
As Further enhancement of our project Caller number display using LCD & Automatic call attend while driving can be implemented
THANK YOU
queries?