Beruflich Dokumente
Kultur Dokumente
Vinay V. Ankolekar
vinay.ankolekar@gmail.com 9762310273
Department of Mechanical Engineering Sinhgad Academy of Engineering, Kondhwa, Pune, Maharastra
Mobile Fire Tube (b) Stationary Fire Tube (c) Stationary Water Tube (d) None of the above
(a) Forced circulation takes place (b) Tubes are laid vertically (c) Water passes through the tubes & flue gases surround them (d) Flue gases pass through tubes & water surrounds them
(d) Flue gases pass through tubes & water surrounds them
Stirling boiler (b) Locomotive (c) Bacbcock & wilcox boiler (d) None of the above
(b) Locomotive
b
Cornish boiler (b) Lancashire boiler (c) Locomotive boiler (d) Babcock & Wilcox boiler
more than 10 bar (b) more than 30 bar (c) more than 50 bar (d) 75-80 bar
To withstand pressure in boiler (b) To give maximum space (c) To resist intense heat in fire box (d) To give max. strength
(c) To resist intense heat in fire box
c
(a)
To separate steam from water (b) To remove salts from water (c) To serve as storage of steam (d) All of the above (a) To separate steam from water
3.9 Compared to controlled circulation boilers the dia. of tubes for natural circulation boiler is
(a)
(b) more
b
Cornish boiler (b) Locomotive boiler (c) Cochran boiler (d) Lancashire boiler
(d) No drum
d
To extinguish fire if water level in the boiler falls below alarming limit
the steam dome (b) At the inlet chimney (c) Over the combustion chamber (d) In the drum
(c) Over the combustion chamber
c
tin, lead and iron (b) tin, lead and bismuth (c) tin, lead and nickel (d) tin, lead and copper
(a) Bituminous
a
(d) 65-80%
(c) Three
(c) 18 bar
3.19 For a fire tube locomotive boiler which aspect is not valid ?
(a)
Multi-tubular (b) Externally fired (c) Mobile unit (d) None of the above
Benson boiler (b) Babcock & Wilcox boiler (c) Lancshire boiler (d) Velox boiler
Steam trap (b) Blow down cock (c) Safety valve (d) Economiser
(d) Economiser
Water level indicator (b) Safety valve (c) Superheater (d) Stop valve
(c) Superheater
30-70 bar (b) 80-120 bar (c) 130-200 bar (d) 225-250 bar
3.24 In a Babcock & Wilcox boiler baffles are provided in betw. Water tubes to
(a)
have better contact of flue gases with water tubes (b) prevent buckling of water tubes (c) regulate steam flow a (d) regulate water flow
(a)
3.25 Which of the following boiler can generate superheated steam without additional accessories
(a)
Cochran boiler (b) Cornish boiler (c) Lancashire boiler (d) Locomotive boiler
(d)
Locomotive boiler
(a)
remove sludge from boiler (b) drain off water resulting from partial condensation of steam (c) blow air into the furnace (d) allow flue gases to escape to the chimney
(a)
90%
30%
Vertical water tube (b) Horizontal water tube (c) Horizontal fire tube (d) Forced circulation
(d)
Forced circulation
3.30 Which of the following medium will leak if a safety valve in a locomotive boiler starts leaking?
(a)
Wet steam (b) Dry steam (c) Superheated steam (d) Supersaturated steam
(c)
Superheated steam
3.31 By which of the following is the size of the boiler tube specified ?
(a)
OD and ID (b) OD and thickness (c) Mean dia. and thickness (d) ID and thickness
(b)
OD and thickness
Induced draft fan (b) Chimney (c) Steam jet (d) None of the above
(c)
Steam jet
To provide support for boiler (b) To check failure in compression (c) To prevent flat surfaces under pressure from leaning apart (d) All of the above
c
(c)
(c)
Flue gases (b) Radial losses (c) Incomplete combustion (d) Unburnt carbon in ash
(a) To reduce weight of water to be handled (b) To reduce cavitations of boiler feed pumps (c) To reduce corrosion caused by oxygen (d) To reduce heat transfer coefficient (c) To reduce corrosion caused by oxygen
3.37 Why is the blow down from the boiler drum carried out ?
c
(a) To lower steam pressure (b) To increase steam temperature (c) To control solids concentrations in the boiler water (d) All of the above