Beruflich Dokumente
Kultur Dokumente
For using the EX-11494-2 you must connect the card with the PC power supply. It must be
connected only one power connector J1 OR J2! Please make sure you connect the plug in the CHECK INSTALLED DRIVER
right direction. Open the >Device manager<. Now you should see at „USB-Controller“ the following new entry's:
Never connect or release the plug while the PC is supplied with power!
CN1-CN4:
4x USB 3.1 (Gen1)
J2: A-Buchse für Endgeräte
For using the EX-11494-2 you must connect the card with
the PC power supply. It must be connected only one power
connector J1 OR J2! Please make sure you connect the plug
in the right direction.
Never connect or release the plug while the PC is BESCHREIBUNG & TECHNISCHE DATEN
supplied with power!
Die EX-11494-2 ist eine USB 3.1 (Gen1) 4 Port Quad Channel PCI-Express Karte. Sie ist mit 4
1 +12V 2 GND 3 GND 4 +5V externen Port‘s ausgestattet, die jeweils 900mA Strom zu Verfügung stellen. Sie unterstützt alle
PCI-Express Slots von x4 bis x16. Der serielle PCI-Express Bus unterstützt optimal die Leistung
des schnellen RENESAS Chipsatz. Zusätzlich besitzt jeder einzelne USB 3.1 (Gen1) Port einen
eigenen Chip und somit auch einen eigenen Channel. Die EX-11494-2 gewährleistet so eine
If you see this or a similar information the device is installed correctly. sichere Datenübertragung und exzellente Performance von bis zu 5Gbit pro Sekunde an jedem
Port! EX-11494-2 benötigt zusätzlichen Strom vom PC Netzteil, um die volle Leistung von
HARDWARE INSTALLATION 900mA an den 4 externen Port‘s zu gewährleisten.
Please note the following installation instructions. Because there are large differences between the Windows 8.x/ 10/ Server 2012R2 Kompatibilität: PCI-Express x4 bis x16, USB 1.1, 2.0, 3.0 & 3.1
PC’s, we can give you only a general installation instructions for the EX-11494-2. Please refer your After the hardware installation, the operating system will recognize the device automatically and Betriebssysteme: Windows XP/ Vista/ 7/ 8.x/ 10/Server 20xx/ Linux
computer’s reference manual whenever in doubt. install the drivers.
Anschlüsse: 4x USB 3.1(Gen1) A-Buchse, 1x 4 Pin Molex, 1x SATA 15 Pin
1. Turn off the power to your computer and any other connected peripherals. Lieferumfang: EX-11494-2, Low Profile Bügel, Treiber CD, Anleitung
CHECK INSTALLED DRIVER
2. Remove the mounting screws located at the rear and/or sides panels of your Computer and Zertifikate:
Open the >Device manager<. Now you should see at „USB-Controller“ the following new entry's:
gently slide the cover off.
3. Locate an available PCI-Express expansion slot and insert the card. Make sure that the card
is plugged in correctly.
4. Now install the power supply via the SATA 15 pin connector or the 4 pol molex connector. ANSCHLÜSSE
(see picture Connectors J1 or J2)
5. Then attach the card with a screw to the rear panel of the computer. USB 3.1 (Gen1) A-Buchse:
5 6 1
ANSCHLÜSSE TREIBER INSTALLATION EX-11494-2
J1: Windows XP/ Vista/ 7/ Server 2003 & 2008R2
Windows erkennt beim Start vier neue “USB (Universal Serial Bus)-Controller“. Legen Sie
nun die Treiber CD in Ihr CD-Rom Laufwerk (z.B. Laufwerk D:) ein und starten Sie das
Manual
Pin Bezeichnung Pin Bezeichnung Pin Bezeichnung Vers. 1.1 / 15.05.2019
„SETUP“ welches sich im Ordner „uPD720201_202“ befindet (siehe Abbildung):
1 3.3 Volt (Orange) 7 5 Volt (pre-charge) 13 12 Volt (pre-charge)
Sind diese oder ähnliche Einträge vorhanden, ist die Karte richtig installiert.
2 3 4
EX-11494-2 USB 3.0
Anwendung / Application
Server
Laserprinter
Scanner
P.O.S
Barcode EX-11494-2
USB 3.0
HUB
Work-
Card station
Reader
Touch-
Screen
USB 3.0 Quad PCIe (x4) Karte USB 3.0 Quad PCIe (x4) card
mit 4 Externen Ports (Renesas Chip-Set) with 4 external ports (Renesas chip-set)
Beschreibung Description
Die EX-11494-2 USB 3.0 Quad PCI-Express (x4 Slot) Karte stellt vier Externe The EX-11494-2 USB 3.0 PCI-Express (x4 slot) board offer you four external Super-
Super-Speed USB 3.0 Ports zur Verfügung. Jeder Port hat einen eigenen Renesas Speed USB 3.0 port. Each port have his one Renesas single chip. Thus, each port
Single Baustein. Somit erreicht jeder Port seine volle Datenübertragung von bis zu reached a full data transfer of up to 5Gigabit per second. The EX-11494 it’s design for
5Gigabit pro Sekunde. Sie ist entwickelt worden um vier weitere USB 1.1, 2.0 oder 3.0 connect four more USB 1.1, 2.0 or 3.0 peripheral device to your Workstation, Desktop
Endgeräte an Ihre Workstation, Desktop oder Server anzuschliessen. Sie unterstützt or Server. He support USB 1.1 Low-Speed (1.5Mbps), Full-Speed (12Mpbs), USB 2.0
USB 1.1 Low-Speed (1.5Mbps), Full-Speed (12Mpbs), USB 2.0 High-Speed (480Mbps) High-Speed (480Mbps) and USB 3.0 Super-Speed (5Gbps). It is an ideal technology for
und USB 3.0 Super-Speed (5Gbps). Sie ist die perfekte Technologie für Externe Speicher external storage devices, digital cameras, webcams, scanners and much more. For
Gehäuse, Digitale Kameras, Webcam, Scanner und mehr. Zur Unterstützung des support the power of 900mA to the external USB 3.0 ports, need the power from the
Stromes von 900mA an den Externen USB 3.0 Ports, benötigt man den Stromanschluss computer case power supply.
vom PC-Netzteil.
Merkmale Feature
· USB 3.0 PCIe Karte für x4 Slot · USB 3.0 PCIe card for x4 slot
· Kompatibel mit USB 3.0 und Intel xHCI Spezifikationen · Compliant with USB 3.0 and Intel xHCI specification
· Unterstützt alle USB kompatible Daten Übertragungs Typen wie zum Beispiel · Supports all USB Compliant Data Transfer Type such as
Control/Bulk/Interrupt/Isochronous Control/Bulk/Interrupt/Isochronous
· Unterstützt bis zu 123 Geräte · Support up to 123 device
· Kompatibel mit PCI-Express Gen2 Spezifikationen · Fully PCI Express Gen2 Specification Compliant
· Unterstützt „Hot Swapping“ und „Plug-and-Play“ · Support “Hot Swapping” and “Plug-and-Play”
Spezifikationen Specification