Beruflich Dokumente
Kultur Dokumente
To determine if the firmware in associated LSR4300 speakers requires an update, determine the firmware version
currently installed in each speaker using this procedure:
• Remove the power cord from the loudspeaker.
• Reconnect the power cord to the loudspeaker.
• Following a brief (2 second) start-up sequence, the front panel display will freeze for approximately
5 seconds with all buttons illuminated and the firmware version displayed on the level meter.
The firmware version should be read as follows:
• The number of green LEDs to the left of the -15dB mark indicate the 1’s digit of the firmware version.
• The number of yellow LEDs to the right of the -15 dB mark indicate the 1/10ths digit of the firmware version.
• For example. Firmware v1.1 will be displayed as follows:
GREEN YELLOW
GREEN
If your Studio Monitors have firmware version 1.1 installed, use the firmware update application to update each Studio
Monitor to version 2.0 or later. Before proceeding, read the READ-ME file associated with the firmware files. Copy the
contents of the CD to a Macintosh computer with OS10.3 operating system (or later) or a PC with Windows 2000, XP
operating system (or later) . Click on the Flash Update application for Mac or Windows and follow the prompts.
Notes:
• Using LSR4300 speakers with differing firmware versions is not harmful to any of the speakers. However,
when speakers are connected together in a network, features will not work correctly.
• Firmware update is not required unless you plan to introduce a subwoofer or newer LSR4300 speaker into
an existing system.
If you experience any difficulties, go to www.jblpro.com/lsr for the latest information related to the firmware.
Or contact:
Connect the computer to the speaker USB port using a USB cable. For LSR4328P, LSR4326P model speakers,
activate the LEFT Dip (set switch to the UP position) and make sure all other DIP Switches are OFF (or down.)
For LSR4312SP subwoofers, activate the SUB 1 DIP Switch (set switch to RIGHT position) and turn other dip
switches OFF (LEFT).
Macintosh: You will see three icons. Click on the correct icon for the speaker model you intend to update.
Windows: For Windows operating system you will see these folders:
Before installing the actual firmware you must install the DOTNETFX file. Open the dotnetfx folder.
Click on “dotnetfx.exe”. Installation of this file takes several minutes.
When installation of “dotnetfx” is complete, click on the folder and correct file type for the speaker model to be updated.
MAC and Windows – You will see the following images on your screen. Follow the instructions exactly to perform
the firmware update and repeat the procedure for each speaker in the system that requires an update.
If this screen does not appear, you will see the above screen. Check USB connections, follow the
directions on the display for STEP 1 above.
You will see this display as the firmware update procedure progresses.
STEP 2 - When the “progress bar” is completely filled with blue perform the steps above exactly as written.
After completing step 2, you will see this display.
If STEP 2 was not performed correctly this message will appear. Follow the directions on this screen.
When STEP 2 is performed correctly, the process will complete itself and this message will appear.