cx70 Manual

DATA PROJECTOR
VPL-CX70
VPL-CX75
REMOTE COMMANDER
RM-PJP1
RM-PJM17
SERVICE MANUAL
1st Edition
! WARNING
This manual is intended for qualified service personnel only.
To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that
contained in the operating instructions unless you are qualified to do so. Refer all servicing to
qualified service personnel.
! WARNUNG
Die Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.
Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um die
Gefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind bei
Wartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegeben
Wartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigung
dazu besitzen.
! AVERTISSEMENT
Ce manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afin
de réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que les
réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.
Pour toute réparation faire appel à une personne compétente uniquement.
VPL-CX70/CX75
For the customers in the Netherlands
Voor de klanten in Nederland
Hoe u de batterijen moet verwijderen, leest u in de tekst

van deze handleiding.
Gooi de batterij niet weg maar lever deze in als klein

chemisch afval (KCA).
Für Kunden in Deutschland
Entsorgungshinweis: Bitte werfen Sie nur entladene

Batterien in die Sammelboxen beim Handel oder den
Kommunen. Entladen sind Batterien in der Regel dann,
wenn das Gerät abschaltet und signalisiert “Batterie
leer” oder nach längerer Gebrauchsdauer der Batterien
“nicht mehr einwandfrei funktioniert”. Um
sicherzugehen, kleben Sie die Batteriepole z.B. mit
einem Klebestreifen ab oder geben Sie die Batterien
einzeln in einen Plastikbeutel.
VPL-CX70/CX75 1 (P)
Table of Contents
1. Service Overview
1-1. Appearance Figure ...................................................................................... 1-1

1-2. Board Locations .......................................................................................... 1-1
1-3. Disassembly ................................................................................................ 1-2
1-3-1. Top Panel ................................................................................... 1-4
1-3-2. QB Board (VPL-CX75) and NF Board ...................................... 1-4
1-3-3. Adjustor Unit .............................................................................. 1-5
1-3-4. Side Panel Assembly .................................................................. 1-5
1-3-5. Lamp Power Supply ................................................................... 1-6
1-3-6. C Board ...................................................................................... 1-7
1-3-7. Optics Block Assembly .............................................................. 1-8
1-3-8. Main Capacitor Lens Assembly ................................................. 1-9
1-3-9. M Board (VPL-CX75) ............................................................. 1-10
1-3-10. U Board and D.C. Fan .............................................................. 1-10
1-3-11. GB Board ................................................................................. 1-11
1-3-12. V Board and GA Board ............................................................ 1-11
1-3-13. D.C. Fan (Sirocco) ................................................................... 1-12
1-3-14. GC Board ................................................................................. 1-12
1-3-15. Extension Boards and Extension Connectors .......................... 1-13
1-3-16. Extension Boards and Extension Connectors Connection ....... 1-13
1-3-17. 3D GAMMA Quick Access Application Software .................. 1-16
1-4. Writing in the USB Storage Media ........................................................... 1-17
1-5. Warning on Power Connection ................................................................. 1-18
2. Electrical Adjustments
2-1. Preparation .................................................................................................. 2-1

2-1-1. Required Equipment ................................................................... 2-1
2-1-2. How to Enter the Factory Mode ................................................. 2-1
2-2. V COM Adjustment .................................................................................... 2-1
2-3. Initial Values of Adjustment Items ............................................................. 2-2
2-4. Service Know-How ................................................................................... 2-10
2-4-1. When the Prism Block Is Replaced .......................................... 2-10
2-4-2. When the Lens is Replaced ...................................................... 2-10
2-4-3. When the Board is Replaced .................................................... 2-10
2-5. White Balance Adjustment ....................................................................... 2-11
2-5-1. HIGH Mode of INPUT-A ........................................................ 2-11
2-5-2. LOW Mode of INPUT-A ......................................................... 2-11
2-5-3. HIGH Mode of VIDEO ............................................................ 2-11
2-5-4. LOW Mode of VIDEO ............................................................. 2-11
2-6. Automatic Focus (AF) Adjustment ........................................................... 2-12
2-7. Memory Structure ..................................................................................... 2-13
VPL-CX70/CX75 1
3. Semiconductors ................................................................................... 3-1
4. Spare Parts
4-1. Notes on Repair Parts .................................................................................. 4-1

4-2. Exploded Views .......................................................................................... 4-2
4-3. Electrical Parts List ..................................................................................... 4-8
5. Block Diagrams
Overall .................................................................................................................... 5-1

C(1/4), QA (1/2) ..................................................................................................... 5-2
C (2/4) ..................................................................................................................... 5-3
C (3/4), QA (2/2) .................................................................................................... 5-4
C (4/4), HA, HB, L, NF, NR, U, V ........................................................................ 5-5
M, QB ..................................................................................................................... 5-6
GA, GB, GC ........................................................................................................... 5-7
6. Diagrams
6-1. Frame Schematic Diagrams ........................................................................ 6-2

Frame Wiring ............................................................................................ 6-2
6-2. Schematic Diagrams and Board Layouts .................................................... 6-3
Schematic Diagrams
QA ............................................................................................................. 6-3
QB ............................................................................................................. 6-4
C (1/14) ..................................................................................................... 6-8
C (2/14) ..................................................................................................... 6-9
C (3/14) ................................................................................................... 6-10
C (4/14) ................................................................................................... 6-11
C (5/14) ................................................................................................... 6-12
C (6/14) ................................................................................................... 6-13
C (7/14) ................................................................................................... 6-14
C (8/14) ................................................................................................... 6-15
C (9/14) ................................................................................................... 6-16
C (10/14) ................................................................................................. 6-17
C (11/14) ................................................................................................. 6-18
C (12/14) ................................................................................................. 6-19
C (13/14) ................................................................................................. 6-20
C (14/14) ................................................................................................. 6-21
HA ........................................................................................................... 6-24
HB ........................................................................................................... 6-26
L .............................................................................................................. 6-28
2 VPL-CX70/CX75
NF ........................................................................................................... 6-28
NR ........................................................................................................... 6-28
U .............................................................................................................. 6-28
V .............................................................................................................. 6-28
M (1/5) .................................................................................................... 6-31
M (2/5) .................................................................................................... 6-32
M (3/5) .................................................................................................... 6-33
M (4/5) .................................................................................................... 6-34
M (5/5) .................................................................................................... 6-35
GA ........................................................................................................... 6-38
GB ........................................................................................................... 6-40
GC ........................................................................................................... 6-42
Board Layouts
QA ............................................................................................................. 6-3
QB ............................................................................................................. 6-5
C ................................................................................................................ 6-6
HA ........................................................................................................... 6-25
HB ........................................................................................................... 6-27
L .............................................................................................................. 6-29
NF ........................................................................................................... 6-29
NR ........................................................................................................... 6-29
U .............................................................................................................. 6-29
V .............................................................................................................. 6-29
M ............................................................................................................. 6-36
GA ........................................................................................................... 6-39
GB ........................................................................................................... 6-41
GC ........................................................................................................... 6-43
VPL-CX70/CX75 3
Section 1
Service Overview
1-1. Appearance Figure
1-2. Board Locations

HA
C
NR
NF
L
GA QA
GB
GC
V Lamp power supply
HB
M (VPL-CX75)
QB (VPL-CX75)
VPL-CX70/CX75 1-1
1-3. Disassembly
A
1-3-1. Top Cover
1-3-2. QB Board (VPL-CX75) and NF Board
1-3-8. Main Capacitor Lens Assembly
1-3-6. C Board
1-3-7. Optics Block Assembly
1-3-9. M Board (VPL-CX75)
C
1-3-13. Fan D.C. (Sirocco)
1-3-10. U Board and DC Fan
1-2 VPL-CX70/CX75
A
1-3-3. Adjustor Unit 1-3-4. Side Panel Assembly
1-3-5. Lamp Power Supply
1-3-11. GB Board
1-3-14. GC Board
1-3-12. V Board and GA Board
VPL-CX70/CX75 1-3
1-3-1. Top Panel 4 Bracket (H1)
5 HA board
2 Top panel
CN100
3 Six claws
C board
1 Six shafts
1-3-2. QB Board (VPL-CX75) and NF Board
CN51
5 NF board
4 Claw
2 Dowel
CN1800
1 Three screws
(+PSW M3 x 8)
3 QB board
(VPL-CX75)
1-4 VPL-CX70/CX75
1-3-3. Adjustor Unit
3 Two screws
(+PSW M3 x 8)
CN301
4 Adjustor unit
1 Two screws
(+PSW M3 x 8)
CN104
C board
CN302
2 Shutter unit,
NF board
1-3-4. Side Panel Assembly
6 Two claws CN41

5 NR board
3 Remove the side panel assembly
in the direction of the arrow A.
4 Claw
CN61
A 7 L board
CN400
CN502
CN2000
2 Two hexagon
screws
1 Open the connector cover (DS).
C board
VPL-CX70/CX75 1-5
1-3-5. Lamp Power Supply 1 Two screws
(+PWHTP 3 x10)
2 Sheet (HM2)
3 Lamp power supply
6 Two screws
(+PSW M3 x 8)
5 Lamp power supply,

7 D.C. fan Shield (BS), etc.
(Sirocco)
4 Two screws
(+PSW M3 x 8)
CN107
CN109
CN103
C board
8 Shield (BS)
!- Sheet (BS)
0 Holder (BSL)
9 Holder (BSR)
!= Lamp power supply,
Sleeve ferrite clamp
1-6 VPL-CX70/CX75
1-3-6. C Board
CN109 CN103 CN108

CN400 CN107
CN100 CN1400
CN1405
CN1000
CN1403
CN105
CN1100 CN1200
CN106
CN101
CN1401 CN104
CN300
CN102 CN1402 C board
Front Side CN302
CN301 CN1300
of Unit (VPL-CX75)
CN502
3 Four screws
(+PSW M3 x 8)
6 C board
4 Fuse connector assembly
CN1300
5 Board to board
(VPL-CX75)
CN1501
2 Two hexagon
screws
1 Open the connector cover (DS)
VPL-CX70/CX75 1-7
1-3-7. Optics Block Assembly 3 Two screws (+PWHTP 3 x10)
6 Screw (+PW 3 x 5)
7 Six screws (+PSW M3 x 8)

4 Sheet (HM2)
8 Optics block assembly
1 Two screws (+PSW M3 x 8) 5 Lamp power supply
2 Shutter unit, NF board
Position of the S out-pre-polarization assembly,

Polarization S panel assembly
![ Screw (+PTP 2.6 x 5)
S out-pre-polarization (G) assembly, !] Polarization retainer
Polarization S panel (G) assembly !. S out-pre-polarization (G)

Green !, Polarization S panel assembly
(R) assembly
!' S out-pre-polarization
(R) assembly @/ Polarization S panel
(G) assembly
Polarization S panel (B)
(Top view)
assembly !; Polarization S panel (B)
assembly !\ S out-pre-polarization (B)
S out-pre-polarization (B) assembly
Red
assembly,
Blue
9 Two screws (+B 2 x 5) !- Two screws (+B 2 x 5)
Polarization S panel (R) assembly
S out-pre-polarization (R) assembly,
!= S Prism block assembly

0 Prism block holder
1-8 VPL-CX70/CX75
1-3-8. Main Capacitor Lens Assembly
1 Four screws
(+PTP 3 x10)
9 Two screws
(+PSW M3 x 8)
7 Screw
(+PTPWH 3 x10)
2 Unit cover (F), etc.
0 Unit cover (B)
6 Main capacitor
lens assembly
4 2ND relay assembly
5 Two springs
(FE-Z) 8 Lamp house
3 Two springs Marking side

(FE-Z)
!- PS converter
Main capacitor
lens assembly
Marking side
PS converter
2ND relay
assembly
Front Side
of Unit
VPL-CX70/CX75 1-9
1-3-9. M Board (VPL-CX75)
1 Two screws
(+PSW M3 x 8)
CN1500 4 M board
3 Flat connector assembly
2 Remove the sheet (FK).
CN1801
1-3-10. U Board and D.C. Fan 7 Four screws

(+PSW 3 x 20)
9 Two D.C. Fans

8 Fan holder
1 Screw
(+PSW M3 x 8)
2 Holder (U)
CN10
3 U board
5 Connector
6 Two D.C. Fans, Fan holder
4 Connector
1-10 VPL-CX70/CX75
1-3-11. GB Board 6 Bracket
5 Three screws
(+PSW M3 x 8) 4 Two screws
(+PSW M3 x 8) 2 Screw
(+PW 3 x 5)
0 Holder (GB)
1 Screw
(+PTPWH 3 x10)
3 Lamp house
7 Shield (G)
8 Two screws
CN203 (+PSW M3 x 8)
CN205
CN204
9 Holder (GB),
CN201 GB board
!- GB board
1-3-12. V Board and GA Board
1 Two screws
(+PSW M3 x 8)
2 Holder (GA), GA board

QB board (VPL-CX75)
CN21
5 D.C. Fan
CN102
3 V board (Sirocco) CN104
CN103
4 Connector
7 GA board
6 Two washers (LW4)
VPL-CX70/CX75 1-11
1-3-13. D.C. Fan (Sirocco)
4 Two screws
(+BTB 3 x 12)
1 Three screws
(+PSW M3 x 8)
5 Duct (In)
2 D.C. Fan (Sirocco), Duct (In)
6 D.C. Fan
(Sirocco)
3 Filter cover, filter
1-3-14. GC Board
CN302
CN301
1 Two screws
(+PSW M3 x 8)
2 GC board
1-12 VPL-CX70/CX75
1-3-15. Extension Boards and Extension Connectors
X kit assembly (Part No. A-1073-342-A)

XC1 board x1 XC2 board x 1 X70 board x 2 (VPL-CX75) XF32 board x 3 Harness x 18
Flat connector x 6 (VPL-CX75) Flat connector x 3 (VPL-CX70)
1-3-16. Extension Boards and Extension Connectors Connection
1. C board extension with using XC1, XC2, X70 (VPL-CX75) and XF32 extension boards.
HA board
C board
Fuse connector
assembly
(VPL-CX75)
X70 board
Three XF32 boards M board
QB board
XC2 board
(VPL-CX75)
XC1 board
Three flat connectors
X70 board X70 board
CN5005 CN5005
CN5004 CN5004
CN5003 CN5003
CN5002 CN5001
Front Side
of Unit
From C board CN1300 To M board CN1501

(Board to board) (Board to board)
VPL-CX70/CX75 1-13
From speaker (2P)
To C board CN400 (2P)
From fan E (3P)
From GC board CN302 (10P)
From lamp power supply (5P)

From L board CN61 (2P), NR board CN41 (3P)

CN103
CN5103 From U board CN10 (3P), Fan D (3P)
CN107 CN109
CN5107 CN5109 CN6403
CN400 CN1405 CN1400 CN1403
CN5400 CN6405 CN6400
CN5105 From fan C (3P)
CN105
From GB board CN203 (4P)
From GB board CN204 (11P)

CN106
CN5106
CN5300
CN300
To C board CN300 (8P) CN6402
CN5302 CN1402
From auto focus unit (8P) CN302
XC1 board
CN5301
CN301
CN5102 To C board
CN102
CN5502 CN502 (9P)
CN502

From V board CN21 (6P) From QA board
To C board CN301 (5P) CN403 (9P)
From adjuator unit (5P)

From fan B (3P)

From Iens shutter (7P)
XC2 board HA board

CN1900
CN5101
CN101
To C board CN101 (8P) To C board CN100 (7P)
CN6401
From HB board CN2000 (8P) CN1401
FRONT SIDE
CN5104 OF UNIT
CN104
To C board CN1401 (3P) To C board CN104 (7P)

From fan A (3P) From NF board CN51 (7P)
1-14 VPL-CX70/CX75
From XC1 board CN5107 (5P) From XC1 board CN5109 (6P)
From XC1 board CN6400 (10P)
From HA board CN1900 (7P) From XC1 board CN5103 (6P)

CN108 From fuse connector
CN109 CN103
CN400 CN1405 CN107 XF32 board assembly (2P)
CN100 CN1400
From prism block assembly
CN1000
LCD (Blue) (32P)
From prism CN1403 From XC1 board CN6403 (3P)

block assembly CN105 From XC1 board CN5105 (4P)
LCD (Green)
(32P)
XF32 board CN1200 From XC1 board CN5106 (11P)
From XC2 board CN101
CN1100 CN106
CN5101 (8P)
CN1401 CN104

CN300 C board
From XC2 board CN5104 (7P) CN1402
CN302
CN102 CN301
CN1300
XF32 board
CN502
From prism block assembly
LCD (Red) (32P)
From XC1 board

From XC1 board CN5300 (8P) From XC1 board CN5502 (9P)
From XC1 board CN5102 (6P) CN5301 (5P)
From XC1 board
From XC1 board CN5302 (7P) CN6402 (3P)
To X70 board CN5002

(Board to board)
(VPL-CX75)
(VPL-CX75)
Flat connector
assembly (68P)
CN1500
M board
(B side)
CN1801 CN1501 Front Side

of Unit
QB board
(A side)
From X70 board CN5001

(Board to board)
VPL-CX70/CX75 1-15
1-3-17. 3D GAMMA Quick Access Application Software
Feature of 3D Gamma Quick Access :

. It can read 3D gamma data from a set and save it in a file.
. It can write 3D gamma data in a PC into a set.
When the optical unit is replaced, load 3D gamma data recorded on the micro floppy disk, which is
supplied together with the optical unit, into a set using the application software.
File configuration :
Executable : QuickAccess200.exe
Readme File : readme_j.txt (Japanese)
readme_e.txt (English)
Software Acquisition :
Download the application software from the GSP website.
. Since this set has not RS-232C terminal, use the quick access assembly (A-1501-849-A).
Quick Access Assembly
(A-1501-849-A)
CN52
RS-232C CN 5P Set
PC SC Mount
Straight NF Mount
cable
1-16 VPL-CX70/CX75
1-4. Writing in the USB Storage Media
When replacing the USB storage media, copy the following files into the USB storage media 8-869-027-
82 from attached CD-ROM.
. \AS_Inst.exe
. \Help\PS for Air Shot\ENG\PSAirShot.chm
. \Help\PS for Air Shot\JPN\PSAirShot.chm
. \INI\as_inst.ini
. \ReadMe\PS for Air Shot\ENG\ReadMe.txt
. \ReadMe\PS for Air Shot\JPN\ReadMe.txt
. \Setup\PS for Air Shot\0x0409.ini
. \Setup\PS for Air Shot\0x0411.ini
. \Setup\PS for Air Shot\Data1.cab
. \Setup\PS for Air Shot\instmsia.exe
. \Setup\PS for Air Shot\instmsiw.exe
. \Setup\PS for Air Shot\isscript.msi
. \Setup\PS for Air Shot\Projector Station for Air Shot.msi
. \Setup\PS for Air Shot\setup.exe
. \Setup\PS for Air Shot\Setup.ini
. \Setup\PS for Air Shot\AirShot.ini (*Note)
m
. Be sure to copy the files of the newest version into the USB storage media.
. The AirShot.ini is different depending on the serial number of the projector. (Refer to Note : Method
to create the AirShot.ini file.)
Method to create the AirShot.ini file

1. Check the serial number of the target projector.
2. Open a text editor application of a PC, and type the lower five digits of the serial number. If the
serial number is six digits or more, type only the lower five digits of the serial number. If the serial
number is less than five digits, fill the blank digits with 0.
Example : When serial number is 1 → 00001
When serial number is 1234567 → 34567
3. Save the created text file as “AirShot.ini”.
VPL-CX70/CX75 1-17
1-5. Warning on Power Connection
Use the supplied power cord when you use the projector in your country.
Otherwise, use a proper power cord meeting the following specification.
The United States, Continental Europe UK, Ireland, Japan

Canada Australia,
New Zealand
Plug type VM0233 290B YP-12A COX-07 – 1) YP332
Female end VM0089 386A YC-13B COX-02 VM0310B YC-13
Cord type SJT SJT H05VV-F H05VV-F N13237/CO-228 VCTF
Rated Voltage & Current 10A/125V 10A/125V 10A/250V 10A/250V 10A/250V 7A/125V
Safety approval UL/CSA UL/CSA VDE VDE VDE DENAN
Cord length (max.) 4.5 m (177 1/4 inches) –
(1) Use the correct plug for your country.
1-18 VPL-CX70/CX75
Section 2
Electrical Adjustments
2-1. Preparation 2-2. V COM Adjustment
2-1-1. Required Equipment 1. Connect the VG to the INPUT-A connector. Connect

the FLAT FIELD 100 IRE signal to the input connec-
. NTSC, PAL, SECAM component signal generator tor. Leave this unit with POWER ON for 10 minutes
Sony Tektronix TG2000 + AVG1 (option module) + or longer for aging.
AWVG1 (option module) or equivalent 2. Enter the Factory Mode. Enter the Device Adjust
. VG (programmable video signal generator) MENU, and then enter the Panel Drive Adjustment
VG854 or equivalent MENU.
. Illuminance meter 3. Connect the XGA, R-single color, 30 IRE, single-line
. Chromaticity meter ON/OFF signal to the input connector.
4. Enter the P. DRV Adjustment MENU, and then enter
n the VCOM R Adjustment screen.
Allow the warm-up time of 5 minutes after the power is on 5. Adjust the VCOM R value for minimum flicker.
before starting the following adjustments. 6. Change the input signal to the XGA, G-single color,
30 IRE, single-line ON/OFF signal, and connect it to
2-1-2. How to Enter the Factory Mode the input connector.
7. Enter the P. DRV Adjustment MENU, and then enter
1. Confirm that the MENU can be displayed. the VCOM G Adjustment screen.
2. Close the MENU. 8. Adjust the VCOM G value for minimum flicker.
3. Press the keys in the following order : [ENTER] → 9. Change the input signal to the XGA, B-single color, 50
[ENTER] → [&] → [ENTER]. IRE, single-line ON/OFF signal, and connect it to the
The message [Do you want to enter the Factory Mode? input connector.
Yes : ↑ No : ↓] appears. 10. Enter the P. DRV Adjustment MENU, and then enter
Select [Yes : ↑]. the VCOM B Adjustment screen.
11. Adjust the VCOM B value for minimum flicker.
[Supplementary information: How to Exit the 12. Store the adjustment value in the memory.
Factory Mode] 13. Turn over the “Image flip” up side down and repeat
Perform the step 3 KEY operation. the steps from 2 through 12.
The message [Do you want to return to the User Mode?
Yes : ↑ No : ↓] appears.
Select [Yes : ↑].
VPL-CX70/CX75 2-1
2-2
2-3. Initial Values of Adjustment Items
(VPL-CX75)
MemoryName
Picture Memory W/B Memory
Remarks
MenuTitle ItemName Status Video S Video Input-A Input-B Video Computer
Set Memory
Memory
Dynamic Standard Dynamic Standard Dynamic Standard Dynamic Standard High Low High Low
PICTURE
Picture Mode Standard
SETTING
Adjust Picture...
Contrast 95 80 95 80 95 80 95 80
Brightness 50 50 50 50 50 50 50 50
Color 50 50 50 50 50 50
Hue 50 50 50 50 50 50
Sharpness High High High High High High
Gamma Mode - - - - Graphics Graphics Graphics Graphics
Color Temp. Low Low Low Low High High High High
Volume 30
INPUT Adjust Signal...
SETTING Dot Phase 15 ( *)
H Size *
Shift *
Wide Mode Off Off Off Off Off Off
Scan Conv On On
SET Smart APA On
SETTING Auto Input Search Off
Input-A Signal Sel. Computer
Input-C Select Air Shot
Color System Auto
Power Saving Off
IR Receiver Front & Rear
Illumination On
Panel Key Lock Off
MENU Status On
SETTING Languege English
Menu Position Center
Menu Color White
VPL-CX70/CX75
VPL-CX70/CX75
(VPL-CX75)
MemoryName
Remarks
MenuTitle ItemName Status
Set Memory Video S Video Input-A Input-B Video Computer
Memory
Dynamic Standard Dynamic Standard Dynamic Standard Dynamic Standard High Low High Low
INSTALL Tilt...
SETTING V Keystone Auto
Side Shot 0
Auto Forcus On
Image Flip Off
Background Blue
Test Pattern Off
Lamp Mode Standard
Lens Control On
High Altitude Off
Security Lock Off
Default Password Enter x 4
INFORMA- fH Display only
TION fV Display only
(Memory No.) Display only
(Resolution) Display only
Lamp Timer Display only
ROM Version Display only
SC ROM Version Display only
Operation Timer Display only
Prev. Lamp Timer Display only
W/B Gain R 152 152 152 152
SETTING G 152 140 152 140
B 152 140 152 140
Bias R 127 127 127 127
G 127 127 127 127
B 127 127 127 127
* : The “Dot Phase E, H Size, Shift H/V and Picture Mode” items in the “INPUT SETTING” menu have their respective initial values for each input signal (PRESET
MEMORY No.).
n
There are some adjustment items that cannot be adjusted, depending on the input signal.
2-3
(VPL-CX75)
2-4
MemoryName
Image Flip
Remarks
Chroma Memory Channel Memory
Device Memory
Item Name Set Status HDTV(G Up/Down
Name NT358/ Pal/Pal-M/N/ Double Up/Down
Memory Memory 15 Component HDTV BR)inc. S Input- Input- inversion
NT443/ Secam/ speed Double Video inversion
kRGB (15k) (YPbPr) Video A B not
BW60 BW50 Component speed possible
possible
A/D ADC/ Clamp Position *1
Converter Clamp Width *1
R Gain(Other) 15 - 88 88
R Gain(Component) - - 80 -
R Gain(VideoGBR) - - 88 -
G Gain(Other) - 15 88 88
G Gain(Component) - - 120 -
G Gain(VideoGBR) - - 88 -
B Gain(Other) - 15 88 88
B Gain(Component) - - 80 -
B Gain(VideoGBR) - - 88 -
R Offset(Other) 126 - 128 128
R Offset(Component) - - 128 -
R Offset(VideoGBR) - - 128 -
G Offset(Other) - 128 128 128
G Offset(Component) - - 128 -
G Offset(VideoGBR) - - 128 -
B Offset(Other) - 128 128 128
B Offset(Component) - - 128 -
B Offset(VideoGBR) - - 128 -
Bandwidth 3
Chroma/ Chroma/ Dither 2 2 2 2
D.Comb Vd 10BitEn 1 1 1 1
Secam Nbw 1 1 1 1
Line2 A Sync 15 15 15 15
Line2 H Sync 7 7 7 7
Line2 Los 31 31 31 31
End Clamp 64
Status 1 Display only
Panel P.Drv Offset R 122 122
Driver Offset G 122 122
Offset B 122 122
V Common R 92 92
V Common G 92 92
V Common B 92 92
Psig 1 R 12
Psig 1 G 12
Psig 1 B 12
Psig 2 R 83
Psig 2 G 83
Psig 2 B 83
Signal Center R 30
Signal Center G 30
VPL-CX70/CX75
Signal Center B 30
Gain R 160
Gain G 160
Gain B 160
SH/ SH1 31
VPL-CX70/CX75
(VPL-CX75)
MemoryName
Image Flip
Remarks
Device Memory
possible
Panel Other/ V Com Ptn Enb Non Adjustable
Driver Installation Non Adjustable
Other 3D Gamma Through 0
SW 1
Other/ HST Position 1425
HST Phase 52
HST Width 0
Temp/ Thresh Lamp Non Adjustable Non Adjustable
Thresh Panel Non Adjustable Non Adjustable
Thresh Atmos Non Adjustable Non Adjustable
Fan/ Hi Alt Const Non Adjustable Non Adjustable
High Alt Cofe Non Adjustable Non Adjustable
Fan1/ Cont Max Non Adjustable Non Adjustable
Speed Max Non Adjustable Non Adjustable
Speed Min Non Adjustable Non Adjustable
Cont Slope Non Adjustable Non Adjustable
Other/ Synchronous 1
Tilt C0 Factory adj. Value
X Tilt Display only
Y Tilt Display only
TL Display only
TP Display only
TA Display only
Gamma Factory adj. Value
m
*1 : It changes with signals inputted.
2-5
2-6
(VPL-CX70)
MemoryName
Remarks
MenuTitle ItemName Set Status
Video S Video Input-A Video Computer
Memory Memory
Dynamic Standard Dynamic Standard Dynamic Standard High Low High Low
PICTURE
Picture Mode Standard
SETTING
Adjust Picture...
Contrast 95 80 95 80 95 80
Brightness 50 50 50 50 50 50
Color 50 50 50 50 50 50
Hue 50 50 50 50 50 50
Sharpness High High High High High High
Gamma Mode - - - - Graphics Graphics
Color Temp. Low Low Low Low High High
Volume 30
INPUT Adjust Signal...
SETTING Dot Phase 15 ( *)
H Size *
Shift *
Wide Mode Off Off Off Off Off Off
Scan Conv On On
SET Smart APA On
SETTING Auto Input Search Off
Input-A Signal Sel. Computer
Input-C Select Air Shot
Color System Auto
Power Saving Off
IR Receiver Front & Rear
Illumination On
Panel Key Lock Off
MENU Status On
SETTING Languege English
Menu Position Center
Menu Color White
VPL-CX70/CX75
VPL-CX70/CX75
(VPL-CX70)
MemoryName
MenuTitle ItemName Set Status
Video S Video Input-A Video Computer
Memory Memory
Dynamic Standard Dynamic Standard Dynamic Standard High Low High Low
INSTALL Tilt...
SETTING V Keystone Auto
Manual... 0
Side Shot 0
Auto Focus On
Image Flip Off
Background Blue
Test Pattern Off
Lamp Mode Standard
Lens Control On
High Altitude Off
Security Lock Off
Default Password Enter x 4
INFORMA- fH Display only
TION fV Display only
(Memory No.) Display only
(Resolution) Display only
Lamp Timer Display only
ROM Version Display only
SC ROM Version Display only
Operation Timer Display only
Prev. Lamp Timer Display only
W/B Gain R 152 152 152 152
SETTING G 152 140 152 140
B 152 140 152 140
Bias R 127 127 127 127
G 127 127 127 127
B 127 127 127 127
* : The “Dot Phase E, H Size, Shift H/V and Picture Mode” items in the “INPUT SETTING” menu have their respective initial values for each input signal (PRESET
MEMORY No.).
n
2-7
2-8
(VPL-CX70)
MemoryName
Image Flip
Remarks
Device Memory
possible
A/D ADC/ Clamp Position *1
Converter Clamp Width *1
R Gain(Other) 15 - 88 88
R Gain(Component) - - 80 -
R Gain(VideoGBR) - - 88 -
G Gain(Other) - 15 88 88
G Gain(Component) - - 120 -
G Gain(VideoGBR) - - 88 -
B Gain(Other) - 15 88 88
B Gain(Component) - - 80 -
B Gain(VideoGBR) - - 88 -
R Offset(Other) 126 - 128 128
R Offset(Component) - - 128 -
R Offset(VideoGBR) - - 128 -
G Offset(Other) - 128 128 128
G Offset(Component) - - 128 -
G Offset(VideoGBR) - - 128 -
B Offset(Other) - 128 128 128
B Offset(Component) - - 128 -
B Offset(VideoGBR) - - 128 -
Bandwidth 3
Chroma/ Chroma/ Dither 2 2 2 2
D.Comb Vd 10BitEn 1 1 1 1
Secam Nbw 1 1 1 1
Line2 A Sync 15 15 15 15
Line2 H Sync 7 7 7 7
Line2 Los 31 31 31 31
End Clamp 64
Panel P.Drv Offset R 122 122
Driver Offset G 122 122
Offset B 122 122
V Common R 92 92
V Common G 92 92
V Common B 92 92
Psig 1 R 12
Psig 1 G 12
Psig 1 B 12
Psig 2 R 83
Psig 2 G 83
Psig 2 B 83
Signal Center R 30
VPL-CX70/CX75
Signal Center G 30
Signal Center B 30
Gain R 160
Gain G 160
Gain B 160
SH/ SH1 31
VPL-CX70/CX75
(VPL-CX70)
MemoryName
Chroma Memory Channel Memory Image Flip
Memory
Remarks
Device
Memory Memory 15 Component HDTV BR)inc. S Input- inversion
kRGB (15k) (YPbPr) Video A not
possible
Panel Other/ V Com Ptn Enb Non Adjustable
Driver Installation Non Adjustable
Other 3D Gamma Through 0
SW 1
Other/ HST Position 1425
HST Phase 52
HST Width 0
Temp/ Thresh Lamp Non Adjustable Non Adjustable
Thresh Panel Non Adjustable Non Adjustable
Thresh Atmos Non Adjustable Non Adjustable
Fan/ Hi Alt Const Non Adjustable Non Adjustable
High Alt Cofe Non Adjustable Non Adjustable
Other/ Synchronous 1
X Tilt Display only
Y Tilt Display only
TL Display only
TP Display only
TA Display only
Gamma Factory adj. Value
m
*1 : It changes with signals inputted.
2-9
2-4. Service Know-How
2-4-1. When the Prism Block Is Replaced
1. Perform the V COM adjustment. (Refer to Section “2-

2. VCOM Adjustment”.)
2. Write LUT and 3D GAMMA data that are supplied
with the prism block.
3. Perform the white balance adjustment. (Refer to
Section “2-5. White Balance Adjustment”.)
4. Perform the AF adjustment. (Refer to Section “2-6. AF
Adjustment”.)
2-4-2. When the Lens is Replaced
1. Perform the AF adjustment. (Refer to Section “2-6. AF

Adjustment”.)
2-4-3. When the Board is Replaced
n
No item needs to be adjusted when boards other than the C
board are replaced.
When the C board is replaced

1. Install the IC204 and IC903 that are removed from the
old C board, into the new C board.
2. Enter the Factory Mode, and select Other in DEVICE
ADJUST.
3. Shorten the TILT adjuster to its shortest limit on the
flat workbench.
4. At this time, the value of 38 Other/X Tilt is read and
inputted in the 35 Other/Tilt C0.
5. Secure the unit so that it faces upward in the vertical
position.
7. Secure the unit so that it faces downward in the
vertical position.
9. Press the MEMORY key and save the adjustment
value.
n
Perform adjustment under the environment of 25 ±5dC.
2-10 VPL-CX70/CX75
2-5. White Balance Adjustment 2-5-2. LOW Mode of INPUT-A
Preparation before adjustment 1. The target chromaticity of the adjustment is (0.327,

0.362).
2. Input the 80 IRE XGA flat field signal to the INPUT-
1. Input the 100 IRE XGA flat field signal to the INPUT- A connector.
A connector and allow the warm-up of 10 minutes 3. Adjust the GAIN R and GAIN B in the LOW mode of
aging at a minimum. W/B until the chromaticity (x, y) that is measured at
2. Enter the Service Mode. step 1 is obtained.
Press the keys in the following order. 4. Input the 30 IRE XGA flat field signal to the INPUT-
A connector.
[ENTER] → [ENTER] → [(] → [)] → [ENTER].
5. Adjust the GAIN R and GAIN B in the LOW mode of
The message [Do you want to enter the Service Mode? W/B until the chromaticity (x, y) that is measured at
Yes : ↑ No : ↓] appears. step 1 is obtained.
Select [Yes : ↑]. 6. Repeat steps 2 to 5 above until the chromaticity (x
±0.002, y ±0.003) with reference to the chromaticity
[Supplementary information: How to Exit the that is measured at step 1 is obtained.
Service Mode] 7. Press the MEMORY key and save the adjustment value.
Perform the step 2 KEY operation.
2-5-3. HIGH Mode of VIDEO
The message [Do you want to return to the User Mode?]
appears. Set Component for the input A signal type.
Select [Yes : ↑].
1. The target chromaticity of the adjustment is (0.293,
2-5-1. HIGH Mode of INPUT-A 0.295).
2. Input the 80 IRE Component flat field signal to the
INPUT-A connector.
Input the XGA 10 STEP signal to the INPUT-A connector, 3. Adjust the GAIN R and GAIN B in the LOW mode of
and see the chromaticity of each tone. W/B until the chromaticity (x, y) that is measured at
If the chromaticity of each mode deviates, perform the step 1 is obtained.
following adjustment. 4. Input the 30 IRE Component flat field signal to the
Before adjusting each mode, confirm that CONTRAST is INPUT-A connector.
80, BRIGHT is 50, GAIN of R.G.B is 152, and BIAS is 5. Adjust the GAIN R and GAIN B in the HIGH mode of
W/B until the chromaticity (x, y) that is measured at
127.
step 1 is obtained.
Select Computer for the Input-A signal type. 6. Repeat steps 2 to 5 above until the chromaticity (x
± 0.002, y ± 0.003) with reference to the chromaticity
1. Input the 100 IRE XGA flat field signal to the INPUT- that is measured at step 1 is obtained.
A connector. 7. Press the MEMORY key and save the adjustment value.
2. Measure the chromaticity (x, y). Set CONTRAST and
2-5-4. LOW Mode of VIDEO
BRIGHT to MAX only during this measurement. After
the adjustment is completed, set CONTRAST to 80, 1. The target chromaticity of the adjustment is (0.300,
and BRIGHT to 50. 0.310).
3. Input the 80 IRE XGA flat field signal to the INPUT- 2. Input the 80 IRE Component flat field signal to the
A connector. INPUT-A connector.
4. Adjust the chromaticity (x, y) to the one set in step 2 3. Adjust the GAIN R and GAIN B in the LOW mode of
by GAIN R and GAIN B of the HIGH mode of W/B. W/B until the chromaticity (x, y) that is measured at
step 1 is obtained.
5. Input the 30 IRE XGA flat field signal to the INPUT-
4. Input the 30 IRE Component flat field signal to the
A connector. INPUT-A connector.
6. Adjust the chromaticity (x, y) to the one set in step 2 5. Adjust the GAIN R and GAIN B in the HIGH mode of
by GAIN R and GAIN B of the HIGH mode of W/B. W/B until the chromaticity (x, y) that is measured at
7. Repeat steps 3 to 6 above until the chromaticity (x step 1 is obtained.
± 0.002, y ±0.003) with reference to the chromaticity 6. Repeat steps 2 to 5 above until the chromaticity (x
±0.002, y ±0.003) with reference to the chromaticity
that is measured at step 2 is obtained.
that is measured at step 1 is obtained.
8. Press the MEMORY key and save the adjustment value. 7. Press the MEMORY key and save the adjustment value.
VPL-CX70/CX75 2-11
2-6. Automatic Focus (AF) Adjustment
Turn on the cooling fan and the lamp.

Set Tilt to 0, Side shot 0, and Keystone correction MANUAL.
1) Wide end adjustment

Set the zoom position to the wide end, and then set the screen size to 60”. (Bring the unit to the front
projection.)
1. On “MENU”, select “INSTALL SETTING”, and set “Test Pattern” to “ON”.
2. Adjust the focus to the optimum position while observing the test pattern at the center of the project-
ed image. (If “Test Pattern” is set to “ON” in step 1, a cross-shaped test pattern appears when the
Focus key is pressed.)
3. Press the AF adjustment switch (1) in the following figure and hold it for about two seconds. (When
the holding action is recognized, the focus starts functioning automatically.)
n
While holding down the key, ensure that no object that may interrupt the projected image exists in
front of the AF module (2) , or between the VPL-CX75 and the screen.
1 AF adjustment switch
2) Tele end adjustment

After completing the above adjustment, set the zoom position to the tele end at the same position.
Then, repeat the adjustment steps 1 through 3 described above.
3) Check
At both the wide end and the tele end, blur the focus by using the Focus key. Then activate AF, and check
that the focus is correctly adjusted.
2-12 VPL-CX70/CX75
2-7. Memory Structure
Memory Structure
CPU internal ROM : 512 K byte Flash Memory
CPU internal RAM : 32 K byte
External NVM memory : 8 K byte EEPROM
Set Memory Set Memory Set Memory
Status No. 01 Status No. 01 Status Memory

Memory No. 02 Memory No. 02
No. 03 No. 03
No. 04 No. 04
Input-A
Preset
No. 05 No. 05
... ...
No. 99 Input-A No. 99
User No. 101
...
No. 120
No. 53
Input-B
User
...
No. 69
Picture Dynamic Picture Dynamic Picture Memory

Video Video
Memory Standard Memory Standard
S Dynamic S Dynamic
Video Standard Video Standard
Dynamic Dynamic
Input-A Input-A
Standard Standard
Dynamic Dynamic
Input-B Input-B
Standard Standard
Chroma NT358/443/BW60 Chroma NT358/443/BW60 Chroma Memory

Memory PAL/PAL-M/N/ Memory PAL/PAL-M/N/
SECAM/BW50 SECAM/BW50
15k RGB 15k RGB
Component (15k) Component (15k)
Double-speed component Double-speed component
HDTV (YPbPr) HDTV (YPbPr)
HDTV (GBR) HDTV (GBR)
includ.double-speed includ.double-speed
W/B High W/B High W/B

Computer Computer High
Memory Low Memory Low Memory
High High
Others Others Low
Low Low
Channel Video Channel Video Channel Memory

Memory S Video Memory S Video
Input-A Input-A
Input-B Input-B
Image Flip Up/Down inversionis Image Flip Up/Down inversionis Image Flip Memory
Memory impossible Memory impossible
Up/Down inversionis Up/Down inversionis
possible possible
CPU ROM External NVM CPU RAM
Initialize Memory
Active memory copy
VPL-CX70/CX75 2-13
Memory structure consists of the followings.
1 Set memory
2 Status memory
3 Picture memory
4 Chroma memory
5 W/B memory
6 Channel memory
7 Image Flip memory
* The gamma memory is realized by giving offset to Contrast and Brightness output values to the devices in the gamma mode function.
Flow of data is described briefly. When the power plug is connected to the wall outlet for the first time
(Standby state), all data that are stored in the internal ROM are written in the NVM(non-volatile memo-
ry). When the POWER is turned ON, all the status memory data and other memory data that are required
for the present picture are selected from each memory block and expanded in the internal RAM.
When any adjustment is performed at this moment, the adjustment data (user mode items) are written in
the NVM (Service/Special Service item) automatically triggered by the memory operation.
The adjustment items (W/B, Device Adjust) that can be adjusted in the Service Mode or in the Special
Service Mode, are memorized in the NVM at the time when the user performs adjustment and performs
the memory operation. Note that the factory adjustment data will be lost at this moment.
2-14 VPL-CX70/CX75
IC
Section 3
Semiconductors
AIC1117A-18PYJTR BA00ASFP-E2 TK11900MTL 74VHC02MTCX
AIC1117A-33PYJTR MIC2562A-OBMTR
AIC1117A-50PYJTR GND SN74LV00APWR
SN75240PWR
TC74LCX125FT(EL)
1
1
2 6pin CHIP
3
1 1 : IN
2 2 : GND TL431CPK-E2
3 3 : OUT 1
PQ20WZ1UJ00H TOP VIEW
14pin SOP
1
AIC1084-PEJTR TOP VIEW
8pin DIP AK4352VT-E2
2 BA6288FS-E2
MB93403-26PB-GE1 CXA1875AM
MB93493PB-GE1 CXA1875AM-T4
1
CY27027ZCT
2
3 1 CY27027ZZCT
4
5 MC74HC4052ADTR2
3
SN74LV4052APWR
TC74HC4052AFT(EL)
BA09FP-E2
S-80928CNMC-G8YT2G A TC74VHCT138AFT(EL)
1 BOTTOM VIEW
TPA2001D1PWR
5
256pin PGA
4
1 HD64F2378VFQ34V
2
3
1 TOP VIEW
KRM-TR303E-TP
16pin SOP
VCC
GND OUT
OUT 1
TOP VIEW M52347FP-TE
144pin QFP SN-USBRCV1
VCC
MBM29LV800TA-70PFTN-
GND SN74AHCT541PWR
GND
768PW VCC GND CXD3536R SN74LV244APWR
MX29LV320ABTC-90G- TC74VHCT540AFT(EL)
769MS100 TDA7309D013TR
OUT GND
BOTTOM VIEW
1 48
INDEX
1
MXS3125GL TOP VIEW
7 176pin QFP 1 TOP VIEW

8 6
5
24 25 20pin SOP
TOP VIEW
CXA2171AQ
1 CXA2171AQ-T6
2 4 MCZ3001UB
3 CXA7005R-T4
LMC7101BIM5X
S-80942CNMC-G9C-T2 BD9781HFP
S-80942CNMC-G9CT2G
SN74AHCT1G08DCKR
TK11125CSCL-G 1 TOP VIEW
1
TOP VIEW
5 24pin SOP
48pin QFP
4
HY57V281620HCT-H-TR
1 1
2
3
7
1 TOP VIEW
54pin SOP
VPL-CX70/CX75 3-1
IC, Diode, Transistor
PW2200B-20L 2SA1162-G HN1B01FU-TE85R D10XB80

2SA1162-YG-TE85L HN1C01FU-TE85R
2SA1576A-T106-QR
2SC2712-YG
6
2SC2712-YG-TE85L 5
2SC4081-R 4
1
TOP VIEW 2SC4081T106R
208pin QFP
DTA114EUA-T106 1
2
DTC144EUA-T106 3 6
5
TC7SA04FU(TE85R) C 4
1
2
B
3
E RD3.9SB
RD3.9SB-T1
1 DTC114EU 2SK2876-01MR-F122 UF4005PKG23
TOP VIEW
DTC114EUA-T106
5pin SOP CATHODE
OUT
LTC1772CS6
SN74LVC2G04DCKR IN
GND
ANODE
2SJ463A-T1 GATE
DRAIN
1 SOURCE
TOP VIEW D MA3J14700LSO
6pin SOP
G
SI4425DY-T1
S
24LC21AT/SN
D
BA10358FV-E2 D
D
BA6287F-E2 SPW20N60S5
CY25033SZC-1T
D
HN58X24256FPIZ
S
M24C64-WMN6T(B) S CATHODE
S ANODE
MC33262DR2 G
MM1096AFF
SI4403DY-T1 SSM6N15FU(TE85R) SF10L60U
ST24FC21M6TR
TC7WH04FK(TE85R) D1
G2
TC7WH125FK(TE85R) S2
TC7WH34FU(TE12R)
S1
UPC393G2 G G1
D D2
UPC393G2-E2 S 12
3
IRMF-A0T-QTP
1
DAN202U 2
XP4501-TXE DAN202UT106 3
ANODE
4
5 RD18M-B1
1 TOP VIEW 6 CATHODE
RD18M-T1B1
NC
8pin SOP
3
2 3
2SA1213Y-TE12L 1 RM11A
4
5 RM11C(RECTI)
2
6
3 1
CATHODE
2 3
1 2
B
C 1
E
ANODE
3-2 VPL-CX70/CX75
Diode, LED
DAP202U D1FS4A-TA
DAP202UT106 RB501V-40TE-17
RB501V-40TE17
3
ANODE
2
1
3
CATHODE
2
1
RD3.9UM-T1B
D10SC4M
ANODE
D10SC6M
D10SC6M(RECTI)
CATHODE
SEC1801C
SEC1901C
SEC2422C
12 CATHOD E MARK
3
1
2
1SS355TE-17
EC31QS03L-TE12L
MA111-(K8).S0
MA111-TX
RD3.3SB
NSCW215T
RD3.3SB-T1
RD30SB-T1
RD39SB-T1
ANODE
RD5.6SB-T1
RD9.1SB2 CATHODE
RD9.1SB2-T1
SECU4901C-S
CATHODE
ANODE
CATHODE
HN1D03FU-TE85L
HN1D03FU-TE85R
4
5
6
3
2
1
4
5
6
3
2
1
VPL-CX70/CX75 3-3
Section 4
Spare Parts
4-1. Notes on Repair Parts
1. Safety Related Components Warning

w
Components marked ! are critical to safe operation.
Therefore, specified parts should be used in the case of
replacement.
[WARNHINWEIS]
Les composants identifiés par la marque ! sont
critiques pour la sécurité.
Ne les remplacer que par une pièce portant le numéro
spécifié.
2. Standardization of Parts
Some repair parts supplied by Sony differ from those
used for the unit. These are because of parts common-
ality and improvement.
Parts List has the present standardized repair parts.
3. Stock of Parts
Parts marked with “o” at SP (Supply Code) column of
the Spare Parts list may not be stocked. Therefore, the
delivery date will be delayed.
Items with no part number and no description are not
stocked because they are seldom required for routine
service.
4. Units for Capacitors, Inductors and Resistors

The following units are assumed in Schematic Dia-
grams, Electrical Parts List and Exploded Views
unless otherwise specified.
Capacitors : µF
Inductors : µH
Resistors : Ω
VPL-CX70/CX75 4-1
Top Cover
4-2. Exploded Views
19
15
21
22
20
18
4 3
1
10
2
9 14
13
5 11
12
17
18 16
No. Part No. SP Description No. Part No. SP Description

1 A-1054-257-A s MOUNTED CIRCUIT BOARD, HA 10 2-149-306-01 s BUTTON (HB)
2 A-1054-258-A s MOUNTED CIRCUIT BOARD, HB 11 2-149-538-01 s MAGNET (V)
3 A-1054-261-A s MOUNTED CIRCUIT BOARD, NR 12 2-149-539-01 s COVER (V), CONNECTOR
4 A-1054-262-A s MOUNTED CIRCUIT BOARD, L 13 2-149-541-01 s COVER (DS), CONNECTOR
5 A-1054-267-A s MOUNTED CIRCUIT BOARD, QA 14 2-149-542-01 s PLATE (DS)
6 A-1072-146-A s MOUNTED CIRCUIT BOARD, C (VPL-CX70) 15 2-177-129-01 s EMBLEM (VPL-CX70)
A-1054-271-A s MOUNTED CIRCUIT BOARD, C (VPL-CX75) 2-149-543-01 s EMBLEM (VPL-CX75)
7 A-1603-156-B s SPEAKER ASSY 16 4-074-246-02 o SLEEVE, VIDEO
8 1-910-002-99 s CONNECTOR ASSY, FUSE 17 4-090-087-02 s SHAFT
9 2-149-305-01 s HOLDER (HB) 18 4-382-854-01 s SCREW +PSW M3X8 (EP-FE/ZN/CM2)
19 4-103-402-01 s BRACKET (H1)
20 4-103-394-02 s KEY (H1A)
21 4-103-395-01 s KEY (H1B)
22 1-500-082-11 s CLAMP, SLEEVE FERRITE
4-2 VPL-CX70/CX75
Chassis
+PWHTP 3x10
111
110
110
110
109
106 107
+PSW 3x20
(VPL-CX75) 113
102 103 110

101
108
110
112
105
(VPL-CX75)
110
No. Part No. SP Description
101 A-1054-259-A s MOUNTED CIRCUIT BOARD, U
102 A-1054-263-A s MOUNTED CIRCUIT BOARD, NF
103 A-1054-272-A s MOUNTED CIRCUIT BOARD, M (VPL-CX75)
104 A-1054-274-A s MOUNTED CIRCUIT BOARD, QB (VPL-CX75)
104 105 1-478-732-11 s SHUTTER UNIT
106 1-478-806-11 s UNIT ADJUSTOR
107 ! 1-787-093-12 s DC FAN
108 1-910-002-95 s CONNECTOR ASSY, FLAT 68P (VPL-CX75)
109 2-149-299-01 s HOLDER (U)
110 4-382-854-01 s SCREW +PSW M3X8 (EP-FE/ZN/CM2)
111 3-669-145-01 s SCREW +PW 3X5
112 2-178-249-01 s SHEET (FK)
113 2-149-558-01 s CUSHION (FAN)
Screws/Washers
7-682-953-09 s SCREW +PSW 3X20
7-685-903-31 s SCREW +PWHTP 3X10 (EP-FE/ZNBK/C)
VPL-CX70/CX75 4-3
Base-1
205
205
205
205
203
202
201
+BTB 3x12 204
205
205
LW4

201 A-1054-268-A s MOUNTED CIRCUIT BOARD, GA
202 A-1054-269-A s MOUNTED CIRCUIT BOARD, GB
203 A-1054-357-A s MOUNTED CIRCUIT BOARD, V
204 ! 1-787-149-11 s D.C. FAN (SIROCCO)
205 4-382-854-01 s SCREW +PSW M3X8 (EP-FE/ZN/CM2)
Screws/Washers
7-685-548-19 s SCREW +BTB 3X12 (EP-FE/ZNBK/CM)
7-623-310-07 o LW4, TYPE A
4-4 VPL-CX70/CX75
Base-2
307
307
307
308
+BTB 3x12
301 302
303
PUSH NUT2
PUSH NUT2
306
305
304
309

301 A-1054-270-A s MOUNTED CIRCUIT BOARD, GC
302 ! 1-478-738-11 s POWER SUPPLY BLOCK
303 ! 1-787-149-11 s D.C. FAN (SIROCCO)
304 ! 2-149-303-01 s DOOR, LAMP
305 2-149-553-01 s FILTER (CH)
306 4-096-057-01 s FOOT REAR, ADJ
307 4-382-854-01 s SCREW, +PSW M3X8 (EP-FE/ZN/CM2)
308 1-500-082-11 s CLAMP, SLEEVE FERRITE
309 2-149-557-02 s SHEET (FAN)
Screws/Washers
7-624-200-11 s NUT, PUSH 2
7-685-548-19 s SCREW +BTB 3X12 (EP-FE/ZNBK/CM)
VPL-CX70/CX75 4-5
Optics-1
+PTP 2.6x5
402
404
406
+B 2x5
405
408 403
401 407
+PTPWH 3x10
+B 2x5
411
409
410
+PS 3x10
No. Part No. SP Description No. Part No. SP Description

401 A-1076-809-A s S PRISM BLOCK ASSY (VPL-CX70) 406 A-1076-813-A s S OUT-PRE-POLARIZER (B) ASSY (VPL-CX70)
A-1054-755-A s S PRISM BLOCK ASSY (VPL-CX75) A-1054-766-A s S PANEL (B) ASSY, POLARIZATION (VPL-CX75)
402 A-1076-810-A s S OUT-PRE-POLARIZER (G) ASSY (VPL-CX70) 407 A-1076-808-A s OPT UNIT ASSY (VPL-CX70)
A-1054-762-A s S PANEL (G) ASSY, POLARIZATION (VPL-CX75) A-1076-805-A s OPT UNIT ASSY (VPL-CX75)
408 A-1054-764-A s S PANEL (R) ASSY, POLARIZATION
403 A-1076-812-A s S OUT-PRE-POLARIZER(B) ASSY (VPL-CX70)
A-1054-763-A s S PANEL (B) ASSY, POLARIZATION (VPL-CX75) 409 A-1076-806-A s LENS ASSY
404 A-1054-761-A s S PANEL (R) ASSY, POLARIZATION 410 2-149-574-03 s SHIELD, LAMP
405 A-1076-811-A s S OUT-PRE-POLARIZER (G) ASSY (VPL-CX70) 411 4-103-519-01 s HOLDER, PRISM BLOCK
A-1054-765-A s S PANEL (G) ASSY, POLARIZATION (VPL-CX75)
Screws/Washers
7-621-771-06 s SCREW +B 2X5
7-682-649-09 s SCREW +PS 3X10 (EP-FE/ZNBK/CM2)
7-685-132-19 s SCREW +PTP 2.6X5
7-685-903-31 s SCREW +PTPWH 3X10 (EP-FE/ZNBK/C)
4-6 VPL-CX70/CX75
Optics-2
+B 2x5 +B 2x5
+B 2x5
502
503 504
+B 2x5
+PTP 3x10
507
505
507
Marking side
506
501

501 A-1054-757-A s PS ASSY
502 A-1054-758-A s S PANEL (R) ASSY, POLARIZATION
503 A-1054-759-A s S PANEL (G) ASSY, POLARIZATION
504 A-1054-760-A s S PANEL (B) ASSY, POLARIZATION
505 A-1076-121-A s MAIN CON ASSY (SVC)
506 A-1076-122-A s 2ND RELAY ASSY (SVC)
507 4-099-077-01 s CUSHION (S)
Screws/Washers
7-621-771-06 s SCREW +B 2X5
7-685-147-21 s SCREW +PTP 3X10 (EP-FE/ZNBK/CM2)
VPL-CX70/CX75 4-7
4-3. Electrical Parts List
----------------------
C BOARD (FOR VPL-CX70) (C BOARD (FOR VPL-CX70))
----------------------
Ref. No. Ref. No.
or Q’ty Part No. SP Description or Q’ty Part No. SP Description
1pc A-1072-146-A s MOUNTED CIRCUIT BOARD, C C304 1-128-992-11 s CAPACITOR ELECT 47MF 25V
1pc 2-187-695-01 s GASKET (USB) C305 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C306 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C100 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C307 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C101 1-128-992-11 s CAPACITOR ELECT 47MF 25V C308 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C103 1-128-992-11 s CAPACITOR ELECT 47MF 25V C309 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C104 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C310 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C311 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C105 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 C312 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C109 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C110 1-164-874-11 s CAPACITOR,CHIP CERAMIC 100PF C314 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C112 1-164-874-11 s CAPACITOR,CHIP CERAMIC 100PF C317 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C119 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C400 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C120 1-131-998-11 s CAP, SOLID ELECT 82MF 6.3 V
C403 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C205 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C409 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C209 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C412 1-164-882-11 s CAPACITOR,CERAMIC 220PF/16V CH
C413 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608
C210 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF C500 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
C213 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C501 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
C214 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C216 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C503 1-117-720-11 s CAPACITOR, CERAMIC 4.7MF/10V F
C504 1-119-667-11 s CAPACITOR CERAMIC 22MF/10V(F)
C217 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C505 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C229 1-164-850-11 s CAPACITOR,CHIP CERAMIC 10PF/50 C602 1-117-720-11 s CAPACITOR, CERAMIC 4.7MF/10V F
C231 1-164-850-11 s CAPACITOR,CHIP CERAMIC 10PF/50 C605 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C232 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF C606 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C609 1-117-720-11 s CAPACITOR, CERAMIC 4.7MF/10V F
C246 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C610 1-164-937-11 s CAPACITOR,CHIP CERAMIC 1000PF
C302 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C613 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C614 1-137-987-81 s CAPACITOR,C.CERAMIC 0.068MF
4-8 VPL-CX70/CX75
(C BOARD (FOR VPL-CX70)) (C BOARD (FOR VPL-CX70))
Ref. No. Ref. No.
C616 1-117-720-11 s CAPACITOR, CERAMIC 4.7MF/10V F C764 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C617 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C765 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C619 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B C767 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C624 1-164-874-11 s CAPACITOR,CHIP CERAMIC 100PF C772 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C625 1-164-882-11 s CAPACITOR,CERAMIC 220PF/16V CH C775 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C626 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608 C776 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C628 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608 C781 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C714 1-135-995-91 s CAP,CHIP CERAMIC39000PF B 1608 C811 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C716 1-117-446-11 s CAPACITOR CERAMIC 3900PF 16V C813 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C737 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C826 1-164-852-11 s CAPACITOR,CHIP CERAMIC 12PF/50
VPL-CX70/CX75 4-9
Ref. No. Ref. No.
C844 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C1005 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C845 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C1006 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C846 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C1007 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C848 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C1009 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C901 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF C1019 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C920 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 C1203 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C929 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 C1212 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C931 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 C1214 1-164-842-11 s CAPACITOR CERAMIC 2PF/16V 1005
C932 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C1215 1-164-842-11 s CAPACITOR CERAMIC 2PF/16V 1005
C1000 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C1314 1-164-934-11 s CAPACITOR,CERAMIC 330PF/50V B
C1001 1-128-992-11 s CAPACITOR ELECT 47MF 25V C1315 1-164-934-11 s CAPACITOR,CERAMIC 330PF/50V B
4-10 VPL-CX70/CX75
Ref. No. Ref. No.
C1403 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 D504 8-719-024-77 s DIODE HN1D03FU-TE85L
C1404 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D505 8-719-941-86 s DIODE DAN202U
C1405 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D506 8-719-036-94 s DIODE RD5.6SB-T1
C1407 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D514 6-500-331-01 s DIODE RD3.9UM-T1B
C1408 1-128-992-11 s CAPACITOR ELECT 47MF 25V D600 8-719-988-61 s DIODE 1SS355TE-17
C1410 1-128-992-11 s CAPACITOR ELECT 47MF 25V D1303 8-719-036-94 s DIODE RD5.6SB-T1
C1412 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D1305 8-719-058-24 s DIODE RB501V-40TE17
CN100 1-770-624-21 s PIN, CONNECTOR 7P D1400 8-719-988-61 s DIODE 1SS355TE-17
CN103 1-580-789-22 o PIN, CONNECTOR (SMD) 6P D1403 8-719-988-61 s DIODE 1SS355TE-17
CN104 1-770-624-21 s PIN, CONNECTOR 7P D1404 8-719-055-30 s DIODE D1FS4A-TA
CN106 1-764-643-21 o PIN, CONNECTOR (SMD) 11P D1406 8-719-055-30 s DIODE D1FS4A-TA
CN108 1-580-055-21 o PIN, CONNECTOR 2P D1408 8-719-941-86 s DIODE DAN202U
CN109 1-770-623-21 s PIN, CONNECTOR 6P D1409 8-719-941-86 s DIODE DAN202U
CN200 1-778-965-21 s PIN, CONNECTOR (PC BOARD) 12P D1410 8-719-941-86 s DIODE DAN202U
CN302 1-770-624-21 s PIN, CONNECTOR 7P
CN400 1-580-055-21 o PIN, CONNECTOR 2P FB100 1-414-921-11 s INDUCTOR, FERRITE BEAD
FB101 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN500 1-784-828-11 s CONNECTOR, D SUB FB102 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN502 1-770-626-21 s PIN, CONNECTOR (L TYPE) 9P FB103 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN900 1-779-884-11 s PLUG, CONNECTOR 4P FB104 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN1000 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P
CN1100 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P FB105 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN1200 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P FB107 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN1302 1-784-010-11 o CONNECTOR, USB (B) FB108 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN1400 1-695-223-21 o PIN,CONNECTOR (SMD) 10P FB109 1-414-921-11 s INDUCTOR, FERRITE BEAD
CN1401 1-580-056-21 s PIN,CONNECTOR 3P
CN1402 1-580-056-21 s PIN,CONNECTOR 3P FB110 1-414-921-11 s INDUCTOR, FERRITE BEAD
FB111 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
CN1403 1-580-056-21 s PIN,CONNECTOR 3P FB112 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
CN1405 1-580-056-21 s PIN,CONNECTOR 3P FB113 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
D100 8-719-157-94 s DIODE RD3.3SB
D101 8-719-036-94 s DIODE RD5.6SB-T1 FB116 1-414-921-11 s INDUCTOR, FERRITE BEAD
D200 8-719-157-94 s DIODE RD3.3SB FB119 1-414-921-11 s INDUCTOR, FERRITE BEAD
D201 8-719-059-53 s DIODE MA3J14700LSO
D203 8-719-055-30 s DIODE D1FS4A-TA FB122 1-414-921-11 s INDUCTOR, FERRITE BEAD
D204 8-719-055-30 s DIODE D1FS4A-TA FB123 1-414-921-11 s INDUCTOR, FERRITE BEAD
D205 8-719-024-77 s DIODE HN1D03FU-TE85L FB124 1-414-921-11 s INDUCTOR, FERRITE BEAD
D206 8-719-059-53 s DIODE MA3J14700LSO
D304 8-719-036-94 s DIODE RD5.6SB-T1
D501 8-719-059-53 s DIODE MA3J14700LSO FB703 1-414-921-11 s INDUCTOR, FERRITE BEAD
D502 8-719-059-53 s DIODE MA3J14700LSO FB800 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
D503 8-719-059-53 s DIODE MA3J14700LSO
VPL-CX70/CX75 4-11
Ref. No. Ref. No.
FB802 1-414-921-11 s INDUCTOR, FERRITE BEAD IC907 8-759-490-43 s IC TC74VHCT540AFT(EL)
FB803 1-414-921-11 s INDUCTOR, FERRITE BEAD IC908 8-759-831-52 s IC TC7WH125FK(TE85R)
FB804 1-414-921-11 s INDUCTOR, FERRITE BEAD IC1000 6-705-025-01 s IC PQ20WZ1UJ00H
FB900 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC1001 8-759-679-05 s IC TC7WH34FU(TE12R)
FB901 1-414-921-11 s INDUCTOR, FERRITE BEAD IC1002 8-752-110-22 s IC CXA7005R-T4
FB1300 1-469-185-11 s INDUCTOR, FERRITE BEAD IC1003 8-759-252-41 s IC TK11900MTL
FB1307 1-414-921-11 s INDUCTOR, FERRITE BEAD IC1300 8-759-596-39 s IC SN74LV4052APWR
FB1308 1-414-921-11 s INDUCTOR, FERRITE BEAD IC1301 6-700-658-01 s IC SN75240PWR
FB1400 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC1302 8-759-649-33 s IC SN74AHCT1G08DCKR
FB1401 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC1303 6-804-220-01 s IC SN-USBRCV1
IC1305 6-702-912-01 s IC S-80942CNMC-G9C-T2
FL900 1-234-494-21 s FILTER, EMI REMOVAL (SMD) IC1400 6-704-958-01 s IC AIC1117A-18PYJTR
FL901 1-234-494-21 s FILTER, EMI REMOVAL (SMD) IC1401 8-759-643-48 s IC BA00ASFP-E2
FL902 1-234-494-21 s FILTER, EMI REMOVAL (SMD)
IC1402 8-759-643-48 s IC BA00ASFP-E2
IC101 6-704-953-01 s IC AIC1117A-33PYJTR IC1403 8-759-643-48 s IC BA00ASFP-E2
IC102 6-704-954-01 s IC AIC1117A-50PYJTR IC1404 8-759-643-48 s IC BA00ASFP-E2
IC103 8-759-681-47 s IC IRMF-A0T-QTP IC1405 6-702-593-01 s IC BA10358FV-E2
IC104 6-704-954-01 s IC AIC1117A-50PYJTR IC1406 6-702-593-01 s IC BA10358FV-E2
IC200 8-759-471-89 s IC 74VHC02MTCX
L101 1-409-527-41 s COIL, CHOKE 4.7UH
IC201 8-759-475-43 s IC TC74LCX125FT(EL) L400 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC202 6-703-225-01 s IC S-80928CNMC-G8YT2G L401 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC203 6-706-022-01 s IC HD64F2378VFQ34V L600 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC300 8-759-491-48 s IC TC74VHCT138AFT(EL) L601 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC301 8-759-460-79 s IC BA09FP-E2
L700 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC302 8-759-598-43 s IC TC7WH04FK(TE85R) L701 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC303 8-759-460-79 s IC BA09FP-E2 L702 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC304 8-752-072-81 s IC CXA1875AM L703 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC305 8-759-580-33 s IC BA6288FS-E2 L704 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC306 8-759-831-52 s IC TC7WH125FK(TE85R)
IC307 8-759-575-16 s IC LMC7101BIM5X L900 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC308 8-759-537-09 s IC BA6287F-E2 L1000 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC400 8-759-352-94 s IC TDA7309D013TR L1001 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC401 6-702-697-01 s IC TPA2001D1PWR L1002 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC500 8-759-661-55 s IC ST24FC21M6TR
IC501 8-759-833-99 s IC MC74HC4052ADTR2 L1101 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC600 6-704-954-01 s IC AIC1117A-50PYJTR L1102 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC601 8-759-646-02 s IC M52347FP-TE L1200 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC602 8-752-108-35 s IC CXA2171AQ L1201 1-469-522-11 s INDUCTOR 1.0UH (NLFV25)
IC604 8-759-548-95 s IC SN74LV00APWR
IC605 8-759-549-14 s IC SN74LV244APWR
IC700 6-704-958-01 s IC AIC1117A-18PYJTR Q100 8-729-905-35 s TRANSISTOR 2SC4081-R
IC701 6-706-008-01 s IC PW2200B-20L Q101 8-729-427-72 s TRANSISTOR XP4501-TXE
IC702 6-703-225-01 s IC S-80928CNMC-G8YT2G Q102 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR
IC703 6-704-953-01 s IC AIC1117A-33PYJTR Q200 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R)
Q201 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R)
IC801 6-703-225-01 s IC S-80928CNMC-G8YT2G
IC802 6-705-986-01 s IC CY25033SZC-1T Q202 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC803 6-804-145-01 s IC MBM29LV800TA-70PFTN-768PW Q203 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R)
IC805 6-704-030-01 s IC TC7SA04FU(TE85R) Q300 8-729-907-00 s TRANSISTOR DTC114EU
IC806 6-702-301-01 s IC TK11125CSCL-G Q400 8-729-907-00 s TRANSISTOR DTC114EU
Q500 8-729-907-00 s TRANSISTOR DTC114EU
IC807 6-704-952-01 s IC AIC1084-PEJTR
IC900 8-752-424-18 s IC CXD3536R Q501 8-729-907-00 s TRANSISTOR DTC114EU
IC901 6-703-225-01 s IC S-80928CNMC-G8YT2G Q600 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR
IC902 6-703-225-01 s IC S-80928CNMC-G8YT2G Q601 8-729-905-35 s TRANSISTOR 2SC4081-R
IC903 8-759-693-83 s IC HN58X24256FPIZ Q602 8-729-905-35 s TRANSISTOR 2SC4081-R
Q603 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR
IC904 8-759-679-58 s IC SN74AHCT541PWR
IC905 8-759-679-58 s IC SN74AHCT541PWR Q604 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC906 8-759-679-58 s IC SN74AHCT541PWR Q605 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
4-12 VPL-CX70/CX75
Ref. No. Ref. No.
Q606 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R220 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
Q608 8-729-907-00 s TRANSISTOR DTC114EU R222 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
Q900 8-729-905-35 s TRANSISTOR 2SC4081-R R223 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
Q901 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R R224 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
Q1001 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R R226 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
Q1200 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R R231 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
Q1400 8-729-907-00 s TRANSISTOR DTC114EU R235 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
Q1402 8-729-028-73 s TRANSISTOR DTA114EUA-T106 R237 1-218-953-11 s RESISTOR, CHIP 1K 1/16W
Q1403 8-729-907-00 s TRANSISTOR DTC114EU R238 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
Q1404 8-729-907-00 s TRANSISTOR DTC114EU R239 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
Q1405 8-729-907-00 s TRANSISTOR DTC114EU R240 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R241 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R100 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R243 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R101 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R102 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R244 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R103 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R245 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R104 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R246 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R247 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R105 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R248 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R106 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R107 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R249 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R108 1-218-962-11 s RESISTOR,CHIP 5.6K 1/16W(1005) R251 1-218-953-11 s RESISTOR, CHIP 1K 1/16W
R109 1-208-671-11 s RESISTOR CHIP 330 1/16W (1005) R252 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R110 1-208-671-11 s RESISTOR CHIP 330 1/16W (1005) R256 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R117 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R260 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R118 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R262 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R122 1-218-937-11 s RESISTOR, CHIP 47 R270 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R123 1-218-937-11 s RESISTOR, CHIP 47 R280 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R201 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R281 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R205 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005)
R206 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005) R288 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R208 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608) R290 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R216 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R217 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R305 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R219 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R307 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
VPL-CX70/CX75 4-13
Ref. No. Ref. No.
R309 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R544 1-211-973-11 s RESISTOR,CHIP 15 1/10W (1608)
R311 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R602 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R313 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R603 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R314 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R604 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R318 1-216-864-11 s CONDUCTOR, CHIP (1608) R606 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R400 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R607 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R404 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R612 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R406 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R614 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R409 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005) R616 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R410 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R617 1-218-949-11 s RESISTOR,CHIP 470 1/16W
R413 1-218-978-11 s RESISTOR,CHIP 120K 1/16W(1005) R619 1-218-953-11 s RESISTOR, CHIP 1K 1/16W
R504 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R622 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R505 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R623 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R506 1-218-823-11 s RESISTOR,CHIP 100 1/10W (1608) R624 1-218-937-11 s RESISTOR, CHIP 47
R511 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608) R631 1-219-601-11 s RES, METAL FILM CHIP 62K(1005)
R517 1-218-823-11 s RESISTOR,CHIP 100 1/10W (1608) R639 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R518 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608) R640 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R519 1-218-937-11 s RESISTOR, CHIP 47 R641 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005)
R520 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R642 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R522 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608) R646 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005)
R523 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005) R647 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R525 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608) R649 1-218-937-11 s RESISTOR, CHIP 47
R528 1-218-971-11 s RESISTOR,CHIP 33K 1/16W (1005) R652 1-208-707-11 s RESISTOR,CHIP 10K 1/16W (1005)
R532 1-218-937-11 s RESISTOR, CHIP 47 R656 1-218-937-11 s RESISTOR, CHIP 47
R533 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R657 1-218-937-11 s RESISTOR, CHIP 47
R535 1-218-937-11 s RESISTOR, CHIP 47 R660 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
4-14 VPL-CX70/CX75
Ref. No. Ref. No.
R705 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R825 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R706 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R826 1-219-570-11 s RESISTOR,CHIP 10M 1/16W
R707 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R827 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R712 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005) R833 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R716 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R838 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R738 1-218-939-11 s RESISTOR, CHIP 68 1/16W (1005) R907 1-218-937-11 s RESISTOR, CHIP 47
R739 1-218-989-11 s RESISTOR,CHIP 1M 1/16W (1005) R909 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R752 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R918 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R758 1-218-937-11 s RESISTOR, CHIP 47 R924 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R762 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) R928 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R763 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) R929 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R764 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) R931 1-218-937-11 s RESISTOR, CHIP 47
R803 1-218-949-11 s RESISTOR,CHIP 470 1/16W R935 1-218-937-11 s RESISTOR, CHIP 47
R804 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R936 1-218-937-11 s RESISTOR, CHIP 47
R805 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005) R937 1-218-937-11 s RESISTOR, CHIP 47
R807 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R939 1-218-937-11 s RESISTOR, CHIP 47
R809 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R941 1-218-937-11 s RESISTOR, CHIP 47
R815 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) R946 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R821 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R1000 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005)
R823 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R1001 1-208-683-11 s RESISTOR CHIP 1K 1/16W (1005)
VPL-CX70/CX75 4-15
Ref. No. Ref. No.
R1002 1-208-711-11 s RESISTOR CHIP 15K 1/16W (1005) R1324 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R1004 1-218-979-11 s RESISTOR, CHIP 150K R1326 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
R1010 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R1331 1-218-989-11 s RESISTOR,CHIP 1M 1/16W (1005)
R1013 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R1402 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R1018 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R1405 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R1019 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R1406 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R1106 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R1412 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R1107 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R1413 1-208-683-11 s RESISTOR CHIP 1K 1/16W (1005)
R1108 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R1414 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005)
R1109 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R1415 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005)
R1110 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R1416 1-208-687-11 s RESISTOR CHIP 1.5K 1/16W (1005
R1206 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R1423 1-208-707-11 s RESISTOR,CHIP 10K 1/16W (1005)
R1207 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R1424 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R1208 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R1425 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005)
R1210 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R1427 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005)
R1211 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R1428 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005)
R1212 1-218-937-11 s RESISTOR, CHIP 47 R1429 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R1301 1-218-937-11 s RESISTOR, CHIP 47 R1430 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608)
R1308 1-218-937-11 s RESISTOR, CHIP 47
RB200 1-234-372-11 s RES, NETWORK 100X4 (1005)
R1309 1-218-937-11 s RESISTOR, CHIP 47 RB201 1-234-372-11 s RES, NETWORK 100X4 (1005)
R1310 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) RB202 1-234-372-11 s RES, NETWORK 100X4 (1005)
R1313 1-218-955-11 s RESISTOR, CHIP 1.5K
RB701 1-234-372-11 s RES, NETWORK 100X4 (1005)
R1314 1-218-965-11 s RESISTOR, CHIP 10K 1/16W RB702 1-234-372-11 s RES, NETWORK 100X4 (1005)
R1315 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) RB703 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB706 1-234-372-11 s RES, NETWORK 100X4 (1005)
4-16 VPL-CX70/CX75
----------------------
(C BOARD (FOR VPL-CX70)) C BOARD (FOR VPL-CX75)
----------------------
Ref. No. Ref. No.
RB711 1-234-371-11 s RES, NETWORK 47X4 (1005) 1pc A-1054-271-A s MOUNTED CIRCUIT BOARD, C
RB712 1-234-371-11 s RES, NETWORK 47X4 (1005) 1pc 2-187-695-01 s GASKET (USB)
RB713 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB714 1-234-371-11 s RES, NETWORK 47X4 (1005) C100 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
RB715 1-234-371-11 s RES, NETWORK 47X4 (1005) C101 1-128-992-11 s CAPACITOR ELECT 47MF 25V
RB901 1-234-371-11 s RES, NETWORK 47X4 (1005) C104 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
RB902 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB903 1-234-371-11 s RES, NETWORK 47X4 (1005) C105 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
RB905 1-234-371-11 s RES, NETWORK 47X4 (1005) C110 1-164-874-11 s CAPACITOR,CHIP CERAMIC 100PF
RB907 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB908 1-234-371-11 s RES, NETWORK 47X4 (1005) C112 1-164-874-11 s CAPACITOR,CHIP CERAMIC 100PF
RB913 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB915 1-234-371-11 s RES, NETWORK 47X4 (1005) C119 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C120 1-131-998-11 s CAP, SOLID ELECT 82MF 6.3 V
RB1002 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1201 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1304 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1305 1-234-371-11 s RES, NETWORK 47X4 (1005) C210 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
S900 1-771-337-21 s SWITCH, SLIDE C217 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
TH300 1-803-353-21 s THERMISTOR, POSITIVE C221 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
TH301 1-771-845-11 s THERMISTOR, POSITIVE C222 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
TH1000 1-803-382-11 s THERMISTOR (10K) C225 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
TP100 1-535-757-11 s CHIP, CHECKER (CONNECTOR) C226 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
TP1202 1-535-757-11 s CHIP, CHECKER (CONNECTOR) C229 1-164-850-11 s CAPACITOR,CHIP CERAMIC 10PF/50
X200 1-813-326-21 s VIBRATOR, CRYSTAL
X600 1-813-124-21 s VIBRATOR, CERAMIC C231 1-164-850-11 s CAPACITOR,CHIP CERAMIC 10PF/50
X700 1-795-756-11 s VIBRATOR, CRYSTAL C232 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
X800 1-813-326-21 s VIBRATOR, CRYSTAL C233 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
X801 1-813-326-21 s VIBRATOR, CRYSTAL C236 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
X1300 1-795-495-21 s VIBRATOR, CERAMIC
VPL-CX70/CX75 4-17
Ref. No. Ref. No.
C304 1-128-992-11 s CAPACITOR ELECT 47MF 25V C616 1-117-720-11 s CAPACITOR, CERAMIC 4.7MF/10V F
C305 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C617 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C307 1-128-992-11 s CAPACITOR ELECT 47MF 25V C619 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B
C308 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C620 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C313 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C625 1-164-882-11 s CAPACITOR,CERAMIC 220PF/16V CH
C314 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C626 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608
C316 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C628 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608
C317 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C629 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
C400 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C701 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B
C401 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C702 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B
C402 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C704 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B
C403 1-128-992-11 s CAPACITOR ELECT 47MF 25V C705 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C408 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C714 1-135-995-91 s CAP,CHIP CERAMIC39000PF B 1608
C409 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C715 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012)
C410 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C716 1-117-446-11 s CAPACITOR CERAMIC 3900PF 16V
C411 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) C717 1-119-923-11 s CAPACITOR,CHIP CERAMIC 0.047MF
C412 1-164-882-11 s CAPACITOR,CERAMIC 220PF/16V CH C719 1-119-923-11 s CAPACITOR,CHIP CERAMIC 0.047MF
C413 1-165-908-11 s CAP, CERAMIC 1000000PF B 1608 C720 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C504 1-119-667-11 s CAPACITOR CERAMIC 22MF/10V(F) C730 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C614 1-137-987-81 s CAPACITOR,C.CERAMIC 0.068MF C762 1-164-854-11 s CAPACITOR,CHIP CERAMIC 15PF/50
4-18 VPL-CX70/CX75
Ref. No. Ref. No.
C784 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 C901 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
VPL-CX70/CX75 4-19
Ref. No. Ref. No.
C1005 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C1403 1-126-205-11 s CAPACITOR,ELECT 47M/6.3
C1007 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C1405 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C1008 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V C1406 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V
C1012 1-128-992-11 s CAPACITOR ELECT 47MF 25V C1410 1-128-992-11 s CAPACITOR ELECT 47MF 25V
C1015 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN100 1-770-624-21 s PIN, CONNECTOR 7P
C1017 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN102 1-770-623-21 s PIN, CONNECTOR 6P
C1018 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN103 1-580-789-22 o PIN, CONNECTOR (SMD) 6P
C1100 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 CN105 1-770-621-21 s PIN, CONNECTOR 4P
C1101 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V CN106 1-764-643-21 o PIN, CONNECTOR (SMD) 11P
C1103 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN108 1-580-055-21 o PIN, CONNECTOR 2P
C1105 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN200 1-778-965-21 s PIN, CONNECTOR (PC BOARD) 12P
C1108 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN302 1-770-624-21 s PIN, CONNECTOR 7P
C1109 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN400 1-580-055-21 o PIN, CONNECTOR 2P
C1110 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN500 1-784-828-11 s CONNECTOR, D SUB
C1111 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN502 1-770-626-21 s PIN, CONNECTOR (L TYPE) 9P
C1112 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN900 1-779-884-11 s PLUG, CONNECTOR 4P
C1113 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN1000 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P
C1200 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 CN1100 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P
C1201 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V CN1200 1-794-823-11 s CONNECTOR (ZIF), FPC/FFC 32P
C1202 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN1300 1-785-306-21 o CONNECTOR, BOARD TO BOARD
C1203 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN1302 1-784-010-11 o CONNECTOR, USB (B)
C1204 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN1400 1-695-223-21 o PIN,CONNECTOR (SMD) 10P
C1205 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN1401 1-580-056-21 s PIN,CONNECTOR 3P
C1206 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN1402 1-580-056-21 s PIN,CONNECTOR 3P
C1207 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V CN1403 1-580-056-21 s PIN,CONNECTOR 3P
C1208 1-128-992-11 s CAPACITOR ELECT 47MF 25V CN1405 1-580-056-21 s PIN,CONNECTOR 3P
C1210 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D100 8-719-157-94 s DIODE RD3.3SB
D101 8-719-036-94 s DIODE RD5.6SB-T1
C1211 1-128-992-11 s CAPACITOR ELECT 47MF 25V D102 8-719-036-94 s DIODE RD5.6SB-T1
C1213 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V D200 8-719-157-94 s DIODE RD3.3SB
C1214 1-164-842-11 s CAPACITOR CERAMIC 2PF/16V 1005
C1215 1-164-842-11 s CAPACITOR CERAMIC 2PF/16V 1005 D201 8-719-059-53 s DIODE MA3J14700LSO
D202 8-719-157-94 s DIODE RD3.3SB
C1300 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D203 8-719-055-30 s DIODE D1FS4A-TA
C1304 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D204 8-719-055-30 s DIODE D1FS4A-TA
C1306 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D205 8-719-024-77 s DIODE HN1D03FU-TE85L
C1308 1-128-992-11 s CAPACITOR ELECT 47MF 25V D206 8-719-059-53 s DIODE MA3J14700LSO
D300 8-719-036-94 s DIODE RD5.6SB-T1
C1309 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D301 8-719-036-94 s DIODE RD5.6SB-T1
C1310 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D302 8-719-036-94 s DIODE RD5.6SB-T1
C1311 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) D303 8-719-036-94 s DIODE RD5.6SB-T1
C1314 1-164-934-11 s CAPACITOR,CERAMIC 330PF/50V B D304 8-719-036-94 s DIODE RD5.6SB-T1
D305 8-719-036-94 s DIODE RD5.6SB-T1
C1315 1-164-934-11 s CAPACITOR,CERAMIC 330PF/50V B D306 8-719-157-94 s DIODE RD3.3SB
C1400 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D501 8-719-059-53 s DIODE MA3J14700LSO
C1401 1-126-205-11 s CAPACITOR,ELECT 47M/6.3 D502 8-719-059-53 s DIODE MA3J14700LSO
4-20 VPL-CX70/CX75
Ref. No. Ref. No.
D503 8-719-059-53 s DIODE MA3J14700LSO FB802 1-414-921-11 s INDUCTOR, FERRITE BEAD
D504 8-719-024-77 s DIODE HN1D03FU-TE85L FB803 1-414-921-11 s INDUCTOR, FERRITE BEAD
D505 8-719-941-86 s DIODE DAN202U FB804 1-414-921-11 s INDUCTOR, FERRITE BEAD
D506 8-719-036-94 s DIODE RD5.6SB-T1 FB900 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
D514 6-500-331-01 s DIODE RD3.9UM-T1B FB1300 1-469-185-11 s INDUCTOR, FERRITE BEAD
D600 8-719-988-61 s DIODE 1SS355TE-17 FB1301 1-469-185-11 s INDUCTOR, FERRITE BEAD
D1305 8-719-058-24 s DIODE RB501V-40TE17 FB1400 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
D1400 8-719-988-61 s DIODE 1SS355TE-17 FB1401 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
D1401 8-719-988-61 s DIODE 1SS355TE-17
D1402 8-719-988-61 s DIODE 1SS355TE-17 FL900 1-234-494-21 s FILTER, EMI REMOVAL (SMD)
D1403 8-719-988-61 s DIODE 1SS355TE-17 FL901 1-234-494-21 s FILTER, EMI REMOVAL (SMD)
FL902 1-234-494-21 s FILTER, EMI REMOVAL (SMD)
D1404 8-719-055-30 s DIODE D1FS4A-TA
D1405 8-719-055-30 s DIODE D1FS4A-TA IC101 6-704-953-01 s IC AIC1117A-33PYJTR
D1406 8-719-055-30 s DIODE D1FS4A-TA IC102 6-704-954-01 s IC AIC1117A-50PYJTR
D1407 8-719-055-30 s DIODE D1FS4A-TA IC103 8-759-681-47 s IC IRMF-A0T-QTP
D1408 8-719-941-86 s DIODE DAN202U IC104 6-704-954-01 s IC AIC1117A-50PYJTR
IC200 8-759-471-89 s IC 74VHC02MTCX
D1409 8-719-941-86 s DIODE DAN202U
D1410 8-719-941-86 s DIODE DAN202U IC201 8-759-475-43 s IC TC74LCX125FT(EL)
D1411 8-719-055-30 s DIODE D1FS4A-TA IC202 6-703-225-01 s IC S-80928CNMC-G8YT2G
D1412 8-719-055-30 s DIODE D1FS4A-TA IC203 6-706-022-01 s IC HD64F2378VFQ34V
IC300 8-759-491-48 s IC TC74VHCT138AFT(EL)
FB100 1-414-921-11 s INDUCTOR, FERRITE BEAD IC301 8-759-460-79 s IC BA09FP-E2
FB103 1-414-921-11 s INDUCTOR, FERRITE BEAD IC303 8-759-460-79 s IC BA09FP-E2
FB104 1-414-921-11 s INDUCTOR, FERRITE BEAD IC304 8-752-072-81 s IC CXA1875AM
IC305 8-759-580-33 s IC BA6288FS-E2
FB107 1-414-921-11 s INDUCTOR, FERRITE BEAD IC307 8-759-575-16 s IC LMC7101BIM5X
FB108 1-414-921-11 s INDUCTOR, FERRITE BEAD IC308 8-759-537-09 s IC BA6287F-E2
FB109 1-414-921-11 s INDUCTOR, FERRITE BEAD IC400 8-759-352-94 s IC TDA7309D013TR
IC401 6-702-697-01 s IC TPA2001D1PWR
FB110 1-414-921-11 s INDUCTOR, FERRITE BEAD IC500 8-759-661-55 s IC ST24FC21M6TR
FB111 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
FB112 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC501 8-759-833-99 s IC MC74HC4052ADTR2
FB113 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC600 6-704-954-01 s IC AIC1117A-50PYJTR
FB114 1-414-921-11 s INDUCTOR, FERRITE BEAD IC601 8-759-646-02 s IC M52347FP-TE
IC602 8-752-108-35 s IC CXA2171AQ
FB119 1-414-921-11 s INDUCTOR, FERRITE BEAD IC700 6-704-958-01 s IC AIC1117A-18PYJTR
FB120 1-414-921-11 s INDUCTOR, FERRITE BEAD IC701 6-706-008-01 s IC PW2200B-20L
IC702 6-703-225-01 s IC S-80928CNMC-G8YT2G
FB121 1-414-921-11 s INDUCTOR, FERRITE BEAD IC703 6-704-953-01 s IC AIC1117A-33PYJTR
FB123 1-414-921-11 s INDUCTOR, FERRITE BEAD IC801 6-703-225-01 s IC S-80928CNMC-G8YT2G
FB124 1-414-921-11 s INDUCTOR, FERRITE BEAD IC802 6-705-986-01 s IC CY25033SZC-1T
FB125 1-414-921-11 s INDUCTOR, FERRITE BEAD IC803 6-804-145-01 s IC MBM29LV800TA-70PFTN-768PW
IC805 6-704-030-01 s IC TC7SA04FU(TE85R)
FB126 1-414-921-11 s INDUCTOR, FERRITE BEAD IC806 6-702-301-01 s IC TK11125CSCL-G
FB401 1-414-921-11 s INDUCTOR, FERRITE BEAD IC807 6-704-952-01 s IC AIC1084-PEJTR
FB402 1-414-921-11 s INDUCTOR, FERRITE BEAD IC900 8-752-424-18 s IC CXD3536R
FB700 1-414-921-11 s INDUCTOR, FERRITE BEAD IC901 6-703-225-01 s IC S-80928CNMC-G8YT2G
IC902 6-703-225-01 s IC S-80928CNMC-G8YT2G
FB701 1-414-921-11 s INDUCTOR, FERRITE BEAD IC903 8-759-693-83 s IC HN58X24256FPIZ
FB703 1-414-921-11 s INDUCTOR, FERRITE BEAD IC904 8-759-679-58 s IC SN74AHCT541PWR
FB800 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S IC905 8-759-679-58 s IC SN74AHCT541PWR
FB801 1-414-921-11 s INDUCTOR, FERRITE BEAD IC906 8-759-679-58 s IC SN74AHCT541PWR
VPL-CX70/CX75 4-21
Ref. No. Ref. No.
IC907 8-759-490-43 s IC TC74VHCT540AFT(EL) Q606 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR
IC908 8-759-831-52 s IC TC7WH125FK(TE85R) Q607 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR
IC1000 6-705-025-01 s IC PQ20WZ1UJ00H Q608 8-729-907-00 s TRANSISTOR DTC114EU
IC1001 8-759-679-05 s IC TC7WH34FU(TE12R) Q900 8-729-905-35 s TRANSISTOR 2SC4081-R
IC1002 8-752-110-22 s IC CXA7005R-T4 Q901 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1003 8-759-252-41 s IC TK11900MTL Q1000 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1300 8-759-596-39 s IC SN74LV4052APWR Q1101 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1301 6-700-658-01 s IC SN75240PWR Q1200 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1302 8-759-649-33 s IC SN74AHCT1G08DCKR Q1201 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1303 6-804-220-01 s IC SN-USBRCV1 Q1300 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
IC1305 6-702-912-01 s IC S-80942CNMC-G9C-T2 Q1400 8-729-907-00 s TRANSISTOR DTC114EU
IC1400 6-704-958-01 s IC AIC1117A-18PYJTR Q1401 8-729-907-00 s TRANSISTOR DTC114EU
IC1401 8-759-643-48 s IC BA00ASFP-E2 Q1402 8-729-028-73 s TRANSISTOR DTA114EUA-T106
IC1402 8-759-643-48 s IC BA00ASFP-E2 Q1403 8-729-907-00 s TRANSISTOR DTC114EU
IC1405 6-702-593-01 s IC BA10358FV-E2
IC1406 6-702-593-01 s IC BA10358FV-E2 R100 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
L101 1-409-527-41 s COIL, CHOKE 4.7UH R102 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
L400 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R103 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
L601 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R105 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
L700 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R107 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
L701 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R108 1-218-962-11 s RESISTOR,CHIP 5.6K 1/16W(1005)
L702 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R109 1-208-671-11 s RESISTOR CHIP 330 1/16W (1005)
L704 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R110 1-208-671-11 s RESISTOR CHIP 330 1/16W (1005)
L1102 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R122 1-218-937-11 s RESISTOR, CHIP 47
L1201 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R123 1-218-937-11 s RESISTOR, CHIP 47
Q100 8-729-905-35 s TRANSISTOR 2SC4081-R R203 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
Q101 8-729-427-72 s TRANSISTOR XP4501-TXE
Q102 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R204 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005)
Q200 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R) R205 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005)
Q201 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R) R206 1-208-699-11 s RESISTOR,CHIP 4.7K 1/16W(1005)
Q202 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R R208 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608)
Q203 6-550-014-01 s TRANSISTOR SSM6N15FU(TE85R)
Q601 8-729-905-35 s TRANSISTOR 2SC4081-R R215 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
Q602 8-729-905-35 s TRANSISTOR 2SC4081-R R216 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
Q603 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R217 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
Q605 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
4-22 VPL-CX70/CX75
Ref. No. Ref. No.
R226 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R318 1-216-864-11 s CONDUCTOR, CHIP (1608)
R235 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R405 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R238 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R409 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
R240 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R412 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R241 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R413 1-218-978-11 s RESISTOR,CHIP 120K 1/16W(1005)
R245 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R503 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R256 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R511 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608)
R266 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R518 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608)
R271 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R520 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R280 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005) R521 1-218-823-11 s RESISTOR,CHIP 100 1/10W (1608)
R281 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005) R522 1-216-811-11 s RESISTOR, CHIP 150 1/16W(1608)
R283 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R523 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
R307 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005) R542 1-211-973-11 s RESISTOR,CHIP 15 1/10W (1608)
VPL-CX70/CX75 4-23
Ref. No. Ref. No.
R600 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R706 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R602 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R707 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R603 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005) R708 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R604 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) R709 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R606 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) R712 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005)
R617 1-218-949-11 s RESISTOR,CHIP 470 1/16W R731 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R621 1-218-953-11 s RESISTOR, CHIP 1K 1/16W R738 1-218-939-11 s RESISTOR, CHIP 68 1/16W (1005)
R622 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R739 1-218-989-11 s RESISTOR,CHIP 1M 1/16W (1005)
R631 1-219-601-11 s RES, METAL FILM CHIP 62K(1005) R752 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R641 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005) R760 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R642 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R761 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
R646 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005) R763 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R647 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R764 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R648 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R801 1-208-707-11 s RESISTOR,CHIP 10K 1/16W (1005)
R649 1-218-937-11 s RESISTOR, CHIP 47 R802 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R650 1-218-937-11 s RESISTOR, CHIP 47 R803 1-218-949-11 s RESISTOR,CHIP 470 1/16W
R651 1-218-937-11 s RESISTOR, CHIP 47 R804 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
R652 1-208-707-11 s RESISTOR,CHIP 10K 1/16W (1005) R805 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
R658 1-208-683-11 s RESISTOR CHIP 1K 1/16W (1005) R811 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
4-24 VPL-CX70/CX75
Ref. No. Ref. No.
R826 1-219-570-11 s RESISTOR,CHIP 10M 1/16W R1003 1-208-711-11 s RESISTOR CHIP 15K 1/16W (1005)
R827 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R1004 1-218-979-11 s RESISTOR, CHIP 150K
R837 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005) R1010 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
R838 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R1011 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R841 1-218-937-11 s RESISTOR, CHIP 47 R1012 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R842 1-218-937-11 s RESISTOR, CHIP 47 R1013 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R907 1-218-937-11 s RESISTOR, CHIP 47 R1106 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R921 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R1206 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608)
R924 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R1209 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005)
R925 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W R1210 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
R941 1-218-937-11 s RESISTOR, CHIP 47 R1313 1-218-955-11 s RESISTOR, CHIP 1.5K
R1000 1-208-695-11 s RESISTOR CHIP 3.3K 1/16W(1005) R1321 1-218-973-11 s RESISTOR,CHIP 47K 1/16W (1005)
VPL-CX70/CX75 4-25
Ref. No. Ref. No.
R1328 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) RB714 1-234-371-11 s RES, NETWORK 47X4 (1005)
R1331 1-218-989-11 s RESISTOR,CHIP 1M 1/16W (1005) RB901 1-234-371-11 s RES, NETWORK 47X4 (1005)
R1404 1-208-719-11 s RESISTOR CHIP 33K 1/16W (1005) RB906 1-234-371-11 s RES, NETWORK 47X4 (1005)
R1416 1-208-687-11 s RESISTOR CHIP 1.5K 1/16W (1005 RB1100 1-234-370-11 s RES, NETWORK 22X4 (1005)
R1424 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) RB1303 1-234-371-11 s RES, NETWORK 47X4 (1005)
R1425 1-208-947-11 s RESISTOR CHIP 330K 1/16W(1005) RB1304 1-234-371-11 s RES, NETWORK 47X4 (1005)
R1432 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608) S900 1-771-337-21 s SWITCH, SLIDE
TH300 1-803-353-21 s THERMISTOR, POSITIVE
R1434 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608) TH301 1-771-845-11 s THERMISTOR, POSITIVE
R1435 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608) TH1000 1-803-382-11 s THERMISTOR (10K)
TP100 1-535-757-11 s CHIP, CHECKER (CONNECTOR)
RB200 1-234-372-11 s RES, NETWORK 100X4 (1005) TP200 1-535-757-11 s CHIP, CHECKER (CONNECTOR)
RB203 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB700 1-234-372-11 s RES, NETWORK 100X4 (1005) X200 1-813-326-21 s VIBRATOR, CRYSTAL
X600 1-813-124-21 s VIBRATOR, CERAMIC
RB704 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB705 1-234-371-11 s RES, NETWORK 47X4 (1005) X1300 1-795-495-21 s VIBRATOR, CERAMIC
RB706 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB707 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB708 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB709 1-234-372-11 s RES, NETWORK 100X4 (1005)
RB710 1-234-372-11 s RES, NETWORK 100X4 (1005)
4-26 VPL-CX70/CX75
--------
GA BOARD (GA BOARD)
--------
Ref. No. Ref. No.
1pc A-1054-268-A s MOUNTED CIRCUIT BOARD, GA VDR101 ! 1-801-268-11 s VARISTOR (TNR14V471K660)
1pc ! 4-034-094-01 s SHEET, INSULATE (PLA)
3pcs 7-682-649-09 s SCREW +PS 3X10(EP-FE/ZNBK/CM2)
C101 ! 1-165-529-31 s CAP,AC M/P 0.22U 275 M (B8113)
C102 ! 1-113-903-11 s CAPACITOR,CERAMIC 0.001MF/250V
C103 ! 1-113-903-11 s CAPACITOR,CERAMIC 0.001MF/250V
C104 ! 1-165-530-11 s CAPACITOR,FILM(ACROSS)0.47MF
C105 1-100-915-11 s CAPACITOR, PE FILM 0.47MF
C106 1-100-914-11 s CAPACITOR, PE FILM 2.2MF
C107 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B
C108 1-162-964-11 s CAPACITOR,CERAMIC 1000PF/50V B
C109 1-127-715-11 s CAPACITOR,CERAMIC 0.22MF B1608
C110 1-126-400-11 s CAPACITOR ELECT 22MF/35V(CHIP)
C112 ! 1-125-991-11 s CAPACITOR,ELECT 180MF/450V
CN101 ! 1-818-742-11 s INLET,AC
CN102 ! 1-691-960-21 o PIN, CONNECTOR (PC BOARD) 3P
CN103 ! 1-785-946-11 s CONNECTOR 3P
CN104 ! 1-691-960-11 o PIN,CONNECTOR (PC BOARD) 3P
D101 ! 6-500-406-01 s DIODE D10XB80
D102 8-719-304-63 s DIODE RM11C (RECTI)
D103 8-719-078-04 s DIODE EC31QS03L-TE12L
D104 8-719-076-72 s DIODE SF10L60U
D105 8-719-037-54 s DIODE RD30SB-T1
F101 ! 1-576-659-11 s FUSE (5A 250V)
FB101 1-414-581-21 s INDUCTOR, CHIP
IC101 8-759-641-00 s IC MC33262DR2
L101 ! 1-456-768-11 s LINE FILTER COIL
L102 ! 1-456-768-11 s LINE FILTER COIL
L103 ! 1-456-767-11 s CHOKE COIL
L104 ! 1-456-133-31 s COIL, CHOKE 200UH
Q101 8-729-055-36 s TRANSISTOR SPW20N60S5
Q102 8-729-230-27 s TRANSISTOR 2SA1213Y-TE12L
Q103 8-729-052-29 s TRANSISTOR 2SK2876-01MR-F122
R101 ! 1-219-759-11 s RESISTOR (SURGE RESISTANT) 1M
R102 1-218-907-11 s RESISTOR,CHIP 330K 1/10W(1608)
R107 1-216-817-11 s RESISTOR,CHIP 470 1/10W 1608
R108 1-249-393-11 s RES,CARBON 10 1/4W
R109 1-216-837-11 s RESISTOR,CHIP 22K 1/16W 1608
R110 1-214-789-00 s RESISTOR,METAL 0.1/5W
R119 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608
R120 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608
TH101 1-810-509-11 s THERMISTOR,POWER
VPL-CX70/CX75 4-27
--------
GB BOARD (GB BOARD)
--------
Ref. No. Ref. No.
1pc A-1054-269-A s MOUNTED CIRCUIT BOARD, GB L202 1-409-527-41 s COIL, CHOKE 4.7UH
L204 1-409-527-41 s COIL, CHOKE 4.7UH
C201 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B L205 1-409-529-41 s COIL, CHOKE 10UH
C202 1-125-889-11 s CAPACITOR, C.CERAMIC 2.2MF L206 1-409-527-41 s COIL, CHOKE 4.7UH
C203 1-128-403-11 s CAPACITOR,ELECT 47MF/35V(CHIP)
C204 1-162-964-11 s CAPACITOR,CERAMIC 1000PF/50V B PH201 ! 8-749-016-82 s PHOTO COUPLER PC123GY2
C205 1-128-004-11 s CAPACITOR ELECT 10MF/16V(CHIP) PH202 ! 8-749-016-82 s PHOTO COUPLER PC123GY2
C206 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B Q201 8-729-216-22 s TRANSISTOR 2SA1162-G
C207 1-115-566-11 s CAPACITOR,CERAMIC 4.7MF B/6.3V Q202 8-729-230-49 s TRANSISTOR 2SC2712-YG
C208 1-128-403-11 s CAPACITOR,ELECT 47MF/35V(CHIP) Q203 ! 8-729-052-29 s TRANSISTOR 2SK2876-01MR-F122
C209 1-115-339-11 s CAPACITOR,CERAMIC 0.1MF/50V Q204 ! 8-729-052-29 s TRANSISTOR 2SK2876-01MR-F122
C210 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B Q206 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C211 1-137-753-11 s CAPACITOR METALIZED 4700PF Q207 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C212 1-107-911-11 s CAPACITOR,ELECT 220MF/50V Q208 8-729-047-32 s TRANSISTOR SI4425DY-T1
C214 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF Q209 8-729-047-32 s TRANSISTOR SI4425DY-T1
C215 1-128-946-31 s CAP, ELECT 2200MF Q210 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C216 1-131-976-11 s CAP, ELECT 820MF Q211 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C217 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225) Q214 6-550-126-01 s TRANSISTOR SI4403DY-T1
C218 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225) Q215 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C219 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF Q216 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C220 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225) Q217 8-729-029-14 s TRANSISTOR DTC144EUA-T106
C222 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF
R201 1-249-389-11 s RES,CARBON 4.7 1/4W
C224 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225) R202 1-218-859-11 s RESISTOR,CHIP 3.3K 1/10W(1608)
C225 1-135-343-11 s CAPACITOR,SOLID ELECT 120MF R203 1-216-832-11 s RESISTOR,CHIP 8.2K 1/16W 1608
C226 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V R204 1-216-819-11 s RESISTOR,CHIP 680 1/10W 1608
C227 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH R205 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608
C229 1-165-870-21 s CAPACITOR, ELECT 100MF(6.3X6) R207 1-216-864-11 s CONDUCTOR, CHIP (1608)
C230 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF R208 1-218-875-11 s RESISTOR,CHIP 15K 1/10W (1608)
C231 1-126-206-11 s CAPACITOR, ELECT 100MF/6.3V R209 1-218-859-11 s RESISTOR,CHIP 3.3K 1/10W(1608)
CN201 ! 1-785-946-11 s CONNECTOR 3P
CN203 1-779-884-11 s PLUG, CONNECTOR 4P R211 1-218-907-11 s RESISTOR,CHIP 330K 1/10W(1608)
CN204 1-779-268-21 o PIN, CONNECTOR (11P)(SMD)(1.5M R212 1-218-907-11 s RESISTOR,CHIP 330K 1/10W(1608)
CN205 1-784-254-11 s CONNECTOR 10P R213 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608
D201 8-719-107-13 s DIODE RD18M-B1 R215 1-216-797-11 s RESISTOR,CHIP 10 1/10W 1608
D202 8-719-037-54 s DIODE RD30SB-T1
D203 8-719-073-01 s DIODE MA111-(K8).S0 R216 1-216-797-11 s RESISTOR,CHIP 10 1/10W 1608
D204 8-719-979-64 s DIODE UF4005PKG23 R217 1-216-821-11 s RESISTOR,CHIP 1.0K 1/10W(1608)
D205 8-719-055-30 s DIODE D1FS4A-TA R218 1-249-417-11 s RESISTOR,CARBON 1K 1/4W(SMALL)
D206 8-719-037-57 s DIODE RD39SB-T1 R220 1-216-815-11 s RESISTOR,CHIP 330 1/10W 1608
D207 8-719-510-12 s DIODE D10SC4M
D208 8-719-510-09 s DIODE D10SC6M (RECTI) R221 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608)
D210 8-719-073-01 s DIODE MA111-(K8).S0 R222 1-202-933-61 s RESISTOR, FUSE 0.1 1/2W
D211 8-719-073-01 s DIODE MA111-(K8).S0 R223 1-243-803-71 s RES, OXIDE METAL FILM 0.33
D212 8-719-073-01 s DIODE MA111-(K8).S0 R225 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608
D215 8-719-073-01 s DIODE MA111-(K8).S0
D216 8-719-073-01 s DIODE MA111-(K8).S0 R228 1-216-821-11 s RESISTOR,CHIP 1.0K 1/10W(1608)
D217 8-719-073-01 s DIODE MA111-(K8).S0 R229 1-216-827-11 s RESISTOR, CHIP 3.3K 1/10W 1608
D219 8-719-078-04 s DIODE EC31QS03L-TE12L R230 1-216-817-11 s RESISTOR,CHIP 470 1/10W 1608
D220 8-719-073-01 s DIODE MA111-(K8).S0 R233 1-218-873-11 s RESISTOR,CHIP 12K 1/10W (1608)
FB201 1-414-581-21 s INDUCTOR, CHIP R234 1-218-863-11 s RESISTOR,CHIP 4.7K 1/10W(1608)
FB202 1-414-581-21 s INDUCTOR, CHIP R235 1-218-871-11 s RESISTOR,CHIP 10K 1/10W (1608)
R236 1-216-825-11 s RESISTOR,CHIP 2.2K 1/10W 1608
IC201 6-705-768-01 s IC MCZ3001UB R237 1-216-835-11 s RESISTOR,CHIP 15K 1/10W
IC202 8-759-183-53 s IC TL431CPK-E2 R238 1-216-829-11 s RESISTOR,CHIP 4.7K 1/10W(1608)
IC203 8-759-100-93 s IC UPC393G2
IC204 8-759-713-98 s IC LTC1772CS6 R239 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608
L201 1-409-527-41 s COIL, CHOKE 4.7UH R241 1-216-827-11 s RESISTOR, CHIP 3.3K 1/10W 1608
4-28 VPL-CX70/CX75
--------
(GB BOARD) GC BOARD
--------
Ref. No. Ref. No.
R242 1-216-845-11 s RESISTOR,CHIP 100K 1/10W(1608) 1pc A-1054-270-A s MOUNTED CIRCUIT BOARD, GC
R244 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608 C301 1-137-980-91 s CAPACITOR,CHIP CERAMIC 0.47MF
R245 1-216-841-11 s RESISTOR, CHIP 47K 1/10W 1608 C302 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225)
R246 1-216-825-11 s RESISTOR,CHIP 2.2K 1/10W 1608 C303 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF
C304 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225)
R247 1-216-837-11 s RESISTOR,CHIP 22K 1/16W 1608 C305 1-100-165-21 s CAP, ELECT 47MF (8X7)
R249 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) C306 1-126-396-11 s CAPACITOR,ELECT 47MF/16V(CHIP)
R250 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) C307 1-135-343-11 s CAPACITOR,SOLID ELECT 120MF
R251 1-216-845-11 s RESISTOR,CHIP 100K 1/10W(1608) C309 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V
R252 1-216-829-11 s RESISTOR,CHIP 4.7K 1/10W(1608) C311 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH
R253 1-216-835-11 s RESISTOR,CHIP 15K 1/10W
R255 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) C312 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF
R257 1-219-611-21 s RESISTOR, CHIP 0.047 1W C313 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF
R258 1-216-797-11 s RESISTOR,CHIP 10 1/10W 1608 C314 1-100-876-11 s CAPACITOR, DOUBLE LAYERS 10F
C315 1-100-876-11 s CAPACITOR, DOUBLE LAYERS 10F
R259 1-216-835-11 s RESISTOR,CHIP 15K 1/10W C316 1-100-876-11 s CAPACITOR, DOUBLE LAYERS 10F
R261 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) C317 1-100-876-11 s CAPACITOR, DOUBLE LAYERS 10F
R262 1-218-907-11 s RESISTOR,CHIP 330K 1/10W(1608) C318 1-100-876-11 s CAPACITOR, DOUBLE LAYERS 10F
R263 1-218-885-11 s RESISTOR,CHIP 39K 1/10W (1608) C319 1-165-870-21 s CAPACITOR, ELECT 100MF(6.3X6)
R264 1-218-891-11 s RESISTOR,CHIP 68K 1/10W (1608) C321 1-100-165-21 s CAP, ELECT 47MF (8X7)
C322 1-126-206-11 s CAPACITOR, ELECT 100MF/6.3V
T201 ! 1-437-380-31 s TRANSFORMER, CONVERTER C323 1-135-960-91 s CAP, CHIP CERAMIC 10MF B(3225)
C325 1-125-827-11 s CAPACITOR,CERAMIC 1MF/25V
CN301 1-784-254-11 s CONNECTOR 10P
CN302 1-766-382-11 s PIN, CONNECTOR (10P)(SMD)(1.5M
D303 8-719-073-01 s DIODE MA111-(K8).S0
IC301 8-759-643-48 s IC BA00ASFP-E2
IC302 8-759-713-98 s IC LTC1772CS6
IC303 6-600-395-01 s IC BD9781HFP
L301 1-409-529-41 s COIL, CHOKE 10UH
L302 1-409-527-41 s COIL, CHOKE 4.7UH
L303 1-409-529-41 s COIL, CHOKE 10UH
L304 1-416-606-11 s COIL, CHOKE (SMD)
L305 1-409-527-41 s COIL, CHOKE 4.7UH
L306 1-409-529-41 s COIL, CHOKE 10UH
Q301 6-550-126-01 s TRANSISTOR SI4403DY-T1
Q303 8-729-047-32 s TRANSISTOR SI4425DY-T1
R308 1-215-864-00 s RESISTOR,METAL FILM 150 1W
R309 1-215-864-00 s RESISTOR,METAL FILM 150 1W
R310 1-219-611-21 s RESISTOR, CHIP 0.047 1W
R312 1-216-852-11 s RESISTOR,CHIP 390K 1/16W 1608
R314 1-218-847-11 s RESISTOR, CHIP 1K 1/10W (1608)
VPL-CX70/CX75 4-29
--------
(GC BOARD) HB BOARD
--------
Ref. No. Ref. No.
R318 1-218-847-11 s RESISTOR, CHIP 1K 1/10W (1608) 1pc A-1054-258-A s MOUNTED CIRCUIT BOARD, HB
R320 1-218-847-11 s RESISTOR, CHIP 1K 1/10W (1608) C2000 1-164-937-11 s CAPACITOR,CHIP CERAMIC 1000PF
R321 1-218-901-11 s RESISTOR,CHIP 180K 1/10W(1608) C2001 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
CN2000 1-779-806-21 s CONNECTOR, 1.0MM PITCH 8P
R324 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) D2000 8-719-045-61 s DIODE SEC1901C
R325 1-216-829-11 s RESISTOR,CHIP 4.7K 1/10W(1608) D2001 8-719-045-61 s DIODE SEC1901C
R326 1-218-899-11 s RESISTOR,CHIP 150K 1/10W(1608) D2002 8-719-045-53 s DIODE SEC1801C
R327 1-218-879-11 s RESISTOR,CHIP 22K 1/10W (1608) D2003 8-719-941-09 s DIODE DAP202U
D2004 8-719-941-86 s DIODE DAN202U
R329 1-216-813-11 s RESISTOR, CHIP 220 1/10W 1608 D2005 8-719-941-09 s DIODE DAP202U
R330 1-216-813-11 s RESISTOR, CHIP 220 1/10W 1608 D2006 8-719-941-86 s DIODE DAN202U
D2007 8-719-941-09 s DIODE DAP202U
D2008 8-719-941-86 s DIODE DAN202U
Q2000 8-729-028-73 s TRANSISTOR DTA114EUA-T106
-------- Q2001 8-729-028-73 s TRANSISTOR DTA114EUA-T106
HA BOARD Q2002 8-729-028-73 s TRANSISTOR DTA114EUA-T106
--------
Ref. No. R2000 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
or Q’ty Part No. SP Description R2001 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
1pc A-1054-257-A s MOUNTED CIRCUIT BOARD, HA R2003 1-218-963-11 s RESISTOR,CHIP 6.8K 1/16W
C1900 1-164-937-11 s CAPACITOR,CHIP CERAMIC 1000PF
C1901 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V R2005 1-218-958-11 s RESISTOR,CHIP 2.7K 1/16W(1005)
CN1900 1-770-624-21 s PIN, CONNECTOR 7P R2007 1-218-966-11 s RESISTOR, CHIP 12K
D1900 8-719-045-51 s DIODE SEC2422C R2009 1-218-967-11 s RESISTOR,CHIP 15K 1/16W (1608)
D1901 8-719-045-51 s DIODE SEC2422C
D1902 8-719-941-09 s DIODE DAP202U S2000 1-771-105-11 s SWITCH, TACTILE
D1903 8-719-941-86 s DIODE DAN202U S2001 1-771-105-11 s SWITCH, TACTILE
D1904 8-719-941-09 s DIODE DAP202U S2002 1-771-105-11 s SWITCH, TACTILE
S2003 1-771-105-11 s SWITCH, TACTILE
D1905 8-719-941-86 s DIODE DAN202U S2004 1-771-105-11 s SWITCH, TACTILE
Q1900 8-729-040-87 s TRANSISTOR 2SJ463A-T1 S2005 1-771-105-11 s SWITCH, TACTILE
Q1901 8-729-028-73 s TRANSISTOR DTA114EUA-T106
R1900 1-218-970-11 s RESISTOR CHIP 27K 1/16W (1005)
R1901 1-218-966-11 s RESISTOR, CHIP 12K
R1902 1-218-963-11 s RESISTOR,CHIP 6.8K 1/16W -------
R1903 1-218-960-11 s RESISTOR, CHIP 3.9K 1/16W L BOARD
R1904 1-218-958-11 s RESISTOR,CHIP 2.7K 1/16W(1005) -------
Ref. No.
R1905 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) or Q’ty Part No. SP Description
R1907 1-218-957-11 s RESISTOR,CHIP 2.2K 1/16W(1608) 1pc A-1054-262-A s MOUNTED CIRCUIT BOARD, L
R1909 1-218-955-11 s RESISTOR, CHIP 1.5K CN61 1-770-619-11 s PIN, CONNECTOR 2P
R1910 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) D61 8-719-084-01 s DIODE (LED) NSCW215T
S1900 1-786-651-11 s TACTILE SWITCH
4-30 VPL-CX70/CX75
----------------------
M BOARD (FOR VPL-CX75) (M BOARD (FOR VPL-CX75))
----------------------
Ref. No. Ref. No.
1pc A-1054-272-A s MOUNTED CIRCUIT BOARD, M C1710 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
C1502 1-119-667-11 s CAPACITOR CERAMIC 22MF/10V(F) C1714 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF
C1513 1-119-667-11 s CAPACITOR CERAMIC 22MF/10V(F) C1723 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C1524 1-115-467-11 s CAPACITOR CERAMIC 0.22MF/10V B
C1526 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V C1732 1-137-710-91 s CAPACITOR,CERAMIC 10MF B(2012)
C1602 1-137-710-91 s CAPACITOR,CERAMIC 10MF B(2012) C1743 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V
C1606 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V CN1500 1-818-313-11 s FFC/FPC CONNECTOR (ZIF)
C1607 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V CN1501 1-779-202-21 s CONNECTOR, BOARD TO BOARD 70P
C1608 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V CN1700 1-770-627-21 s PIN, CONNECTOR 10P
C1610 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D1504 8-719-045-61 s DIODE SEC1901C
D1505 8-719-059-53 s DIODE MA3J14700LSO
C1611 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V D1600 8-719-941-86 s DIODE DAN202U
C1613 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V FB1500 1-414-921-11 s INDUCTOR, FERRITE BEAD
C1614 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V FB1501 1-500-451-11 s MICRO INDUCTOR (CHIP) 41P750S
C1615 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V FB1502 1-414-921-11 s INDUCTOR, FERRITE BEAD
C1616 1-137-710-91 s CAPACITOR,CERAMIC 10MF B(2012) FB1505 1-414-921-11 s INDUCTOR, FERRITE BEAD
C1700 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF FB1506 1-414-921-11 s INDUCTOR, FERRITE BEAD
C1703 1-137-710-91 s CAPACITOR,CERAMIC 10MF B(2012) FB1600 1-414-921-11 s INDUCTOR, FERRITE BEAD
C1705 1-164-943-11 s CAPACITOR,CHIP CERAMIC 0.01MF FB1601 1-469-670-11 o FERRITE, EMI (SMD)
FB1702 1-469-670-11 o FERRITE, EMI (SMD)
VPL-CX70/CX75 4-31
(M BOARD (FOR VPL-CX75)) (M BOARD (FOR VPL-CX75))
Ref. No. Ref. No.
FB1704 1-469-670-11 o FERRITE, EMI (SMD) R1540 1-218-989-11 s RESISTOR,CHIP 1M 1/16W (1005)
IC1500 6-702-812-11 s IC CY27027ZZCT R1542 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
IC1501 6-700-551-01 s IC MIC2562A-OBMTR R1545 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
IC1502 6-704-952-01 s IC AIC1084-PEJTR R1548 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
IC1503 6-703-108-01 o IC SN74LVC2G04DCKR
IC1504 6-704-958-01 s IC AIC1117A-18PYJTR R1549 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
IC1505 8-759-665-50 s IC AK4352VT-E2 R1551 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
IC1506 8-759-331-27 s IC MM1096AFF R1553 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
IC1600 6-704-521-01 s IC MB93493PB-GE1 R1554 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
IC1601 6-702-688-01 s IC M24C64-WMN6T(B)
IC1700 6-700-628-01 s IC HY57V281620HCT-H-TR R1555 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
IC1701 6-700-628-01 s IC HY57V281620HCT-H-TR R1558 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
IC1702 6-804-396-01 s IC MX29LV320ABTC-90G-769MS100 R1560 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005)
IC1703 6-704-509-01 s IC MB93403-26PB-GE1 R1570 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
L1500 1-469-522-11 s INDUCTOR 1.0UH (NLFV25) R1571 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
L1501 1-414-770-91 s INDUCTOR 4.7UH R1572 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005)
Q1500 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R1574 1-218-969-11 s RESISTOR,CHIP 22K 1/16W (1608)
Q1502 8-729-013-28 s TRANSISTOR HN1B01FU-TE85R
Q1503 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R1600 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
Q1600 8-729-026-53 s TRANSISTOR 2SA1576A-T106-QR R1601 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R1602 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R1503 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) R1606 1-218-955-11 s RESISTOR, CHIP 1.5K
R1509 1-218-977-11 s RESISTOR,CHIP 100K 1/16W(1005) R1616 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005)
R1528 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) R1700 1-218-939-11 s RESISTOR, CHIP 68 1/16W (1005)
R1701 1-218-939-11 s RESISTOR, CHIP 68 1/16W (1005)
R1534 1-218-965-11 s RESISTOR, CHIP 10K 1/16W R1705 1-218-961-11 s RESISTOR, CHIP 4.7K 1/16W
R1535 1-218-945-11 s RESISTOR,CHIP 220 1/16W(1005)
4-32 VPL-CX70/CX75
(M BOARD (FOR VPL-CX75)) (M BOARD (FOR VPL-CX75))
Ref. No. Ref. No.
R1716 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) RB1639 1-242-963-21 s RES, NETWORK 33X4 (1005)
R1723 1-218-937-11 s RESISTOR, CHIP 47 RB1646 1-242-963-21 s RES, NETWORK 33X4 (1005)
R1726 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) RB1701 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1712 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1500 1-234-378-11 s RES, NETWORK 10KX4 (1005) RB1713 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1501 1-234-370-11 s RES, NETWORK 22X4 (1005) RB1714 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1601 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1717 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1606 1-234-378-11 s RES, NETWORK 10KX4 (1005)
RB1722 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1727 1-234-371-11 s RES, NETWORK 47X4 (1005)
RB1614 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1624 1-234-379-11 s RESISTOR,NETWORK 22KX4 (1005) TP1505 1-535-757-11 s CHIP, CHECKER (CONNECTOR)
RB1625 1-234-378-11 s RES, NETWORK 10KX4 (1005) TP1506 1-535-757-11 s CHIP, CHECKER (CONNECTOR)
RB1626 1-234-379-11 s RESISTOR,NETWORK 22KX4 (1005) TP1507 1-535-757-11 s CHIP, CHECKER (CONNECTOR)
RB1627 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1628 1-234-370-11 s RES, NETWORK 22X4 (1005) X1500 1-795-690-22 s OSCILLATOR, CRYSTAL (SMD)
RB1629 1-234-370-11 s RES, NETWORK 22X4 (1005)
RB1630 1-242-963-21 s RES, NETWORK 33X4 (1005)
RB1631 1-242-963-21 s RES, NETWORK 33X4 (1005)
RB1632 1-242-963-21 s RES, NETWORK 33X4 (1005)
RB1633 1-234-370-11 s RES, NETWORK 22X4 (1005)
VPL-CX70/CX75 4-33
-------- -----------------------
NF BOARD QB BOARD (FOR VPL-CX75)
-------- -----------------------
Ref. No. Ref. No.
1pc A-1054-263-A s MOUNTED CIRCUIT BOARD, NF 1pc A-1054-274-A s MOUNTED CIRCUIT BOARD, QB
1pc 2-149-624-01 s FRAME (CF)
CN51 1-784-210-21 s PIN, CONNECTOR 7P
CN52 1-785-900-11 s CONNECTOR CN1800 1-817-653-21 s MEMORY STICK CONNECTOR
CN1801 1-818-313-11 s FFC/FPC CONNECTOR (ZIF)
D51 8-719-036-80 s DIODE RD3.9SB CN1802 1-816-408-11 s PIN, HEADER (CF CARD)
D52 8-719-059-53 s DIODE MA3J14700LSO
D1800 6-500-633-01 s DIODE SECU4901C-S
IC51 6-704-826-01 s IC KRM-TR303E-TP D1802 8-719-059-53 s DIODE MA3J14700LSO
D1803 8-719-059-53 s DIODE MA3J14700LSO
R51 1-218-937-11 s RESISTOR, CHIP 47 D1804 8-719-059-53 s DIODE MA3J14700LSO
R52 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005) D1805 8-719-059-53 s DIODE MA3J14700LSO
Q1800 8-729-907-00 s TRANSISTOR DTC114EU
--------
NR BOARD R1800 1-218-965-11 s RESISTOR, CHIP 10K 1/16W
-------- R1801 1-218-937-11 s RESISTOR, CHIP 47
Ref. No. R1802 1-218-941-81 s RESISTOR,CHIP 100,1/16W (1005)
or Q’ty Part No. SP Description R1803 1-218-937-11 s RESISTOR, CHIP 47
R1804 1-218-937-11 s RESISTOR, CHIP 47
1pc A-1054-261-A s MOUNTED CIRCUIT BOARD, NR
R1805 1-218-937-11 s RESISTOR, CHIP 47
C41 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) R1806 1-218-937-11 s RESISTOR, CHIP 47
R1807 1-218-937-11 s RESISTOR, CHIP 47
CN41 1-770-620-21 s PIN, CONNECTOR 3P R1808 1-218-937-11 s RESISTOR, CHIP 47
R1809 1-218-937-11 s RESISTOR, CHIP 47
IC41 6-704-826-01 s IC KRM-TR303E-TP
R1810 1-218-937-11 s RESISTOR, CHIP 47
R1813 1-218-937-11 s RESISTOR, CHIP 47
-------- R1814 1-218-937-11 s RESISTOR, CHIP 47
QA BOARD
-------- R1815 1-218-937-11 s RESISTOR, CHIP 47
Ref. No. R1816 1-218-937-11 s RESISTOR, CHIP 47
or Q’ty Part No. SP Description R1817 1-218-937-11 s RESISTOR, CHIP 47
R1818 1-218-937-11 s RESISTOR, CHIP 47
1pc A-1054-267-A s MOUNTED CIRCUIT BOARD, QA R1819 1-218-937-11 s RESISTOR, CHIP 47
C400 1-165-875-11 s CAPACITOR, CHIP CERAMIC 10MF B R1820 1-218-937-11 s RESISTOR, CHIP 47
C401 1-165-875-11 s CAPACITOR, CHIP CERAMIC 10MF B R1821 1-218-937-11 s RESISTOR, CHIP 47
R1822 1-218-937-11 s RESISTOR, CHIP 47
CN401 1-770-860-11 s CONNECTOR, S TERMINAL R1823 1-218-937-11 s RESISTOR, CHIP 47
R1824 1-218-937-11 s RESISTOR, CHIP 47
D402 6-500-331-01 s DIODE RD3.9UM-T1B
D403 6-500-331-01 s DIODE RD3.9UM-T1B R1825 1-218-937-11 s RESISTOR, CHIP 47
D407 8-719-158-37 s DIODE RD9.1SB2 R1828 1-218-937-11 s RESISTOR, CHIP 47
R1829 1-218-937-11 s RESISTOR, CHIP 47
D408 8-719-158-37 s DIODE RD9.1SB2
R1830 1-218-937-11 s RESISTOR, CHIP 47
FB400 1-500-282-11 o INDUCTOR, FERRITE BEAD R1831 1-218-937-11 s RESISTOR, CHIP 47
R1834 1-218-937-11 s RESISTOR, CHIP 47
FL401 1-239-996-11 s FILTER, EMI
FL402 1-409-755-11 s FILTER, CHIP EMI (COMON MODE) R1835 1-218-937-11 s RESISTOR, CHIP 47
FL403 1-239-996-11 s FILTER, EMI R1836 1-218-937-11 s RESISTOR, CHIP 47
R1837 1-218-937-11 s RESISTOR, CHIP 47
J400 1-566-822-21 s JACK R1838 1-218-937-11 s RESISTOR, CHIP 47
J401 1-785-549-41 o JACK, PIN YELLOW R1839 1-218-937-11 s RESISTOR, CHIP 47
R412 1-216-864-11 s CONDUCTOR, CHIP (1608) R1842 1-218-937-11 s RESISTOR, CHIP 47
R413 1-216-864-11 s CONDUCTOR, CHIP (1608) R1843 1-218-937-11 s RESISTOR, CHIP 47
R414 1-216-864-11 s CONDUCTOR, CHIP (1608)
4-34 VPL-CX70/CX75
-----------------------------------
(QB BOARD (FOR VPL-CX75)) SUPPLIED ACCESSORIES (FOR VPL-CX70)
-----------------------------------
Ref. No. Ref. No.
R1844 1-218-937-11 s RESISTOR, CHIP 47 1pc 1-478-734-21 s
REMOTE COMMANDER (RM-PJM17)
COVER, BATTERY (FOR RM-PJM17)
FILTER (CH)
R1847 1-218-937-11 s RESISTOR, CHIP 47 1pc ! ------------ s
CORD, POWER (See Warning on
R1848 1-218-937-11 s RESISTOR, CHIP 47 Power Connection)
1pc 1-790-081-31 s CABLE, USB
R1849 1-218-937-11 s RESISTOR, CHIP 47
R1850 1-218-937-11 s RESISTOR, CHIP 47 1pc 1-791-992-31 s CABLE ASSY(15PDSUBCONNECTORX2)
R1851 1-218-937-11 s RESISTOR, CHIP 47 1pc 2-149-997-01 s OPERATING INSTRUCTIONS
R1852 1-218-937-11 s RESISTOR, CHIP 47 (JAPANESE, SIMPLIFIED CHINESE)
1pc 2-149-997-11 s OPERATING INSTRUCTIONS
(ENGLISH, FRENCH, SPANISH)
1pc 2-149-997-21 s OPERATING INSTRUCTIONS
(GERMAN, ITALIAN)
------- 1pc 4-096-087-02 s CASE, CARRYING
U BOARD
-------
Ref. No.
or Q’ty Part No. SP Description -----------------------------------
SUPPLIED ACCESSORIES (FOR VPL-CX75)
1pc A-1054-259-A s MOUNTED CIRCUIT BOARD, U -----------------------------------
Ref. No.
CN10 1-580-056-21 s PIN,CONNECTOR 3P or Q’ty Part No. SP Description
S10 1-762-984-11 s SWITCH, PUSH 1pc A-1059-524-A s WIRELESS LAN CARD (CF) ASSY
1pc * A-1059-525-A s WIRELESS LAN CARD (USB)ASSY
TH10 1-803-382-11 s THERMISTOR (10K) 1pc 8-869-027-82 s USM32DP
1pc 1-478-734-21 s REMOTE COMMANDER (RM-PJM17)
1pc 9-885-010-98 s COVER, BATTERY (FOR RM-PJM17)
1pc ! 1-478-737-11 s REMOTE COMMANDER (RM-PJP1)
------- 1pc 2-024-232-01 s COVER, BATTERY (FOR RM-PJP1)
V BOARD 1pc 2-149-553-01 s FILTER (CH)
-------
Ref. No. 1pc 2-176-397-01 s MANUAL, INSTRUCTION
or Q’ty Part No. SP Description 1pc ! ------------ s CORD, POWER (See Warning on
Power Connection)
1pc A-1054-357-A s MOUNTED CIRCUIT BOARD, V 1pc 1-790-081-31 s CABLE, USB
1pc 1-791-992-31 s CABLE ASSY(15PDSUBCONNECTORX2)
C21 1-165-989-11 s CAPACITOR, CERAMIC 10MF (2012) 1pc 2-023-819-02 s OPERATING INSTRUCTIONS
C22 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V (JAPANESE, ENGLISH, FRENCH,
C23 1-125-777-11 s CAPACITOR CERAMIC 0.1MF/10V GERMAN, SPANISH, ITALIAN,
PORTUGUESE, SIMPLIFIED CHINESE,
CN21 1-770-623-21 s PIN, CONNECTOR 6P TRADITIONAL CHINESE, KOREAN)
IC21 6-705-943-01 s IC MXS3125GL 1pc 2-149-997-01 s OPERATING INSTRUCTIONS
(JAPANESE, SIMPLIFIED CHINESE)
R23 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) 1pc 2-149-997-11 s OPERATING INSTRUCTIONS
R24 1-218-990-11 s RESISTOR,CHIP 0 1/16W (1005) (ENGLISH, FRENCH, SPANISH)
R26 1-208-635-11 s RESISTOR CHIP 10 1/16W (1005) 1pc 2-149-997-21 s OPERATING INSTRUCTIONS
R27 1-216-864-11 s CONDUCTOR, CHIP (1608) (GERMAN, ITALIAN)
R28 1-208-643-11 s RESISTOR CHIP 22 1/16W (1005) 1pc 4-096-087-02 s CASE, CARRYING
1pc 4-103-423-03 s PACK, CD-ROM
S21 1-786-644-21 s SWITCH, PUSH (1 KEY)
* : When you can purchase a product, please purchase USB WIRELESS
TH21 1-803-382-11 s THERMISTOR (10K) LAN MODULE (IFU-WLM1).
VPL-CX70/CX75 4-35
Overall Overall
Section 5
Block Diagrams
(VPL-CX75) (VPL-CX75)
QB M IC1600 IC1702 IC1703 C

D10, BS, IC1700, IC400
CN1800 4 SCLK, INS VIDEO FROM MS L L
MEMORY D0-31 IC1701 IC401
STICK
I/F CPU
32
J400 QA R AUDIO
PROC AUDIO
SPEAKER
D16-31
A0-11 AUDIO L
A2-21
SDRAM AMP
INPUT R R D0-15 16
12
A0-19 20
16 D0-D15 16 20 2 SDA 100K 1 CN801
CN1802 D0-31 D0-31 10
12 SCL 100K 1
COMPACT J401
11 A0-A10 32 32 IC701 IC800
FLASH A2-15 A2-21 IC1506 VIDEO IC803 IC900
Y C DEC RE 8 SCAN D0-15 16 D0-15 16 IC1100
2 RESET INPUT 8M 3D R 10
18 14 20 AD CONV GE 8 CONV A0-19 20 A0-18 19 LCD VSIG1-6 10 CN1100
WDT CN1700 FLASH GAMMA CLK, DIRC,
ICE BE 8 10 2 ROM TG DRIVER PSIG, LCD
FRP, PRG 4
IC1501 18 20 CN401 Y (R) VCOM 2 (R)
VCC POWER 2 TXD S VIDEO C RO 8 R 10 SDAT
SEL RXD SDAT, INPUT IC702 SCLK
GO 8 G 10
BICK,
5 RESET BO 8 B 10 SENB
LRCK,
IC1601 PD, IC1505 IC502 DCLK, DHS, DVS 3 GCFB
L R CLK, HS,
5 CKS AUDIO VS, PEN, 14
EEPROM R VIDEO G IC801 IC902 IC903
DAC BUFF B FBK,
CN500
R 8 COAST RESET RESET EEPROM IC1002
IC1500 G 10
G 8 INPUT A HSS SDA 6 LCD VSIG1-6 10 CN1000
4 CLK, DIRC,
B 8 VSS SCL IC802 DRIVER PSIG, LCD
CLOCK FRP, PRG 4
VCLK, VHS, VVS, VPEN 4 SPEAD IC901 (G) VCOM 2 (G)
GEN
R 8 SPECTRAM SDAT
G 8 RESET
SCLK
B 8 RXD SC SENB
VCLK, VHS, VVS, VPEN 4 TXD SC GCFB
IC203 14
5 AF REQ, AF BUSY 2
RXD MAIN IC300 CN300 IC1200
CPU AF SDA B 10
HA S1904, 1905 TXD DECODER ZOOM+, - 2 CN900 SCL SDA CLK, DIRC,
LCD VSIG1-6 10 CN1200
TILT+ KEY0 FOR LUT DRIVER PSIG, LCD
FOCUS+, - 2 S900 SCL FRP, PRG 4
S1900-1903 TILT- ENC0, ENC1, ENC2,CNT PLS 4 OPT IC602 IC605 SDA 400K (B) VCOM 2 (B)
CONTROL H HSS
MENU IC305 DTV V SYNC SCL 400K SDAT
INPUT D1900, 1901 POWER LED VSS
2 MOTOR 2 CN301 SYNC SEP SCLK
POWER
UP DRIVER TILT SEP SENB
DOWN ADJ SDA 100K 1 GCFB
ENTER ON/STANDBY
RIGHT KEY4 SCL 100K 1 IC904-907 14
LEFT IC601 26
H BUFF
PC V
SYNC
HB SDA 100K 1
IC304 IC308 SEP HSS
IC1300
HS PDRV SDAT
IC1001
SCL 100K 1 SYNC VS BUS
S2000-2003 IC 2 2 MOTOR 2 CN302 VSS PDRV SCLK
DRIVER SEL BUFF
LENS FOCUS+ KEY4 SDA 100K 1 DECODER LENS VHS PDRV SENB
LENS FOCUS- D2000-2002 3 SCL 100K 1 SHUTTER VVS
LENS ZOOM+ FAN +B
LENS ZOOM- IC501 IC500 IC1401 FAN A
SDA SDA
LAMP LAMP ON, HIGH/LOW 2 CN107 DDC SCL DDC IC1405 FAN
S2004, 2005 TEMP SCL REG
FLAG BALLAST SW EEPROM DRIVER
SIDE SHOT+ PSAVE KEY3
LAMP COVER FAN CONT 1 IC1402 FAN B
SIDE SHOT-
SDA 100K 2 FAN
SCL 100K 2 REG
IC1403 FAN C
L D61
LOGO FAN CONT 2
IC1406 FAN
REG
DRIVER
IC1404 FAN E
IC41 PDRV SDAT,
NR IR SIRCS
IC103
2 PDRV SCLK, FAN CONT 3
FAN
REG
SIRCS PDRV SENB 3
RX
I/F FAN D
HS, VS 2
IC51 OFF & GO
NF IR SIRCS SIRCS
FAN CONT 1-3 3
RX
TXD
CN52 SDA 100K 2
RXD SDA 100K 2 CN101
VISCA
IC202
SCL 100K 2
SCL 100K 2 GC GB GA AC INLET 3P
100 – 240 V
CN200 IC301-303 IC201 DC (+) IC101
TXD TXD SC 17 V D101 50/60Hz
CPU & PW ROM RESET TXD SC FAN +B MAIN POWER
RXD RXD SC DC-DC
RXD SC OFF & GO CONV SWITCHING FACTOR RECT
S10 LAMP COVER 6V VCC
REG CONT
U SDA
Q200
LEVEL
SDA 400K
SDA 400K
D3.3 V
TH10 LAMP TEMP SCL SCL 400K
CONV SCL 400K CN108
THRM
IC204 17 V
FUSE IC204
S21 FILT COVER 6V
EEPROM
V SUB 5 V
DC-DC
CONV
IC21 TH21 EXIT TEMP POWER ON
PH201
ACCELERO- 2
IC1303 PCONT P CONT
METER
USB CN1302 COUPLER
SIRCS I/F USB
VPL-CX70/CX75 5-1 5-1

C(1/4), QA (1/2) C(1/4), QA (1/2)
IC800
C(1/4) IC701
SCAN CONV
QA(1/2) CDEC AD CONV

E4 U20
J401 CN403(1/2) CN502(1/2) C3 GRE0 DRE7 V20
VIDEO 4 CVBS 4 33 RED1 DRE0 119 B1 W20
PW DRE(9-2)
F4 R18
PW DRE(9-0) 2/4
CN401 C2 U19
6 SY 6 40 GRN1
S VIDEO DRE7 126 C1 R16
D3 GRE7 DRE0 Y20
D2 V19
8 SC 8 49 BLU1
C11 PW DRE(1)
3.3V-2 IC702 PORTC7 Y17
B12 GGE0
IC700 PW DRE(0)
2 RESET 1 99 RESET DGE0 111 B11 PORTC6 W17 CN801
3.3V-3 1.8V 1.8V-3
REG A8 B32 D0
IC703 B8 P20 A32 D1
6V 3.3V 3.3V-3 DGE7 118 C8 C5 X0 DGE7 P19 B31 D2
REG 178 XOUT X801
X700 A7 GGE7 16.384MHz P18 A31 D3
27MHz A3 X1 PW DGE(9-2)
179 XIN B7 M18 B30 D4
PW DGE(9-0) 2/4
B18 R20 A30 D5
IC502
VIDEO BUFF A20 GBE0 R19 B29 D6
R R DBE0 101 B17 DGE0 T20 A29 D7
1 INA+ OUTA 15 35 RED2
G A19 4/4 PWFMBSY W14 PORTA4 T19 16 B28 D8
G OUTB 13 43 GRN2
5 INB+ 107 B16 4/4 INTERLACE Y15 PORTA5 PW DGE(1) A28 D9
CN500 44 SDG2 PORTC5 U17
B B DBE7 110 A17 4/4 SIGCH FLAG W19 PORTB6 B27 D10
INPUT-A 8 INC+ OUTC 11 51 BLU2 PW DGE(0)
A16 GBE7 PORTC4 V17 A27 D11
A15 B26 D12
A6 4/4 MUTE SC W15 PORTA6 L20 A26 D13
3/4 HSS 81 HS2 GRO0 142 C7 GRO0 DBE7 L19 B25 D14
H SYNC 3/4
3/4 VSS 82 VS2 B6 K17 A25 D15
V SYNC 3/4 3/4 CLAMP 85 CLAMP PW DBE(9-2)
139 A5 M19
3.3V-2 IC801 PW DBE(9-0) 2/4
IC805
136 D7 L17 B12 A0
SOG 3/4 2 4
B5 2 RESET 1 Y11 RESET M20 A12 A1
GRO7 133 C6 GRO7 DBE0 N20 B11 A2
A4 M17 A11 A3
C13 PW DBE(1) B10 A4
IC501 IC500 IC802 PORTC3 Y16
DDC SW DDC EEPROM B15 GGO0 A10 A5
PW DBE(0)
GGO0 152 A14 1 PORTC2 W16 B9 A6
14 1X X 13 5 SDA X800 SPREAD 5 D6 DCKEXT
B14 16.384MHz SPECTRAM A9 A7
4/4 SDA 100K 2 12 0X 8
146 A13 B8 A8
5 1Y Y 3 6 SCL DCLK J17 PW DCLK 2/4
GGO7 143 C12 A8 A9
4/4 SCL 100K 2 1 0Y 20
Q501 B13 GGO7 DHS D18 PW DHS 2/4 B7 A10
LEVEL 7 VCK A12 4/4 RXD SC Y12 RXD A7 A11
4/4 DDC SW0 10 A DVS C20 PW DVS 2/4,4/4
CONV C18 4/4 TXD SC Y12 TXD B6 A12
D505 E17 GBO0 A6 A13
Q500
GBO0 160 C17 IC806 B5 A14
4/4 DDC WE INV IC803
B19 2.5V A5 A15
SW 8M FLASH ROM 3.3V-2 2.5V
E16 REG B4 A16
GBO7 153 C16 V10 29 B3 A17
C15 GBO7 D0 Y10 31 DQ0 IC807 B2 A18
D14 Y9 33 1.55V B1 A19
3.3V-2 1.55V
W9 35 REG
DCLK 127 A10 GCLK
V9 38 B22 FCEN
DHS 129 C10 GHS
Y8 40
DVS 131 A9 GVS D0
W8 42
DPEN 128 B9 GPENSOG D15
V8 44 BHEN W12 B13 BHENN
DFBK 130 A11 GFBK
W7 16 16 30 ROMOE V5 B14,B15 ROMOEN
COAST 84 A18 GCOAST
U8 32 ROMWE W4 B16,B17 ROMWEN
V7 34 CS0 V4 B18 CS0
SDA 166 V13 PORTA0
W5 36 CS1 Y4 B19 CS1
SCL 167 W13 PORTA1
Y6 39 NMI W10 B21 NM1
CN1300(1/3)
V6 41 POARTA2 Y13 B23 BOOTWE
A GDC R0 A17 E2
D15 U7 43 DQ15 POARTA7 V15 B24 VPPEN
GDC R1 A19 F1 VR0
U6 45 B20 RESETN
M BOARD GDC R2 A18 F2
CN1501(2/2)
GDC R3 A20 G3 U4
CN800
GDC R4 A22 G2 A0 T4 25 A0
1 RXD
GDC R5 A24 H3 V3 24
3 TXD
GDC R6 A25 H2 VR7 U3 23
GDC R7 A23 G1 Y1 22
W3 21
J4
GDC G0 A28 T3 20 0E 28
H1 VG0
GDC G1 A27 V2 A1 19 WE 11
J3
GDC G2 A29 U2 A19 18 CE 26
J2
GDC G3 A30 W1 8
J1 20 19
GDC G4 B30 R4 7
K3
GDC G5 B29 V1 6
K2 VG7
GDC G6 B28 P4 5
K1
GDC G7 B27 R3 4
L2 T20 3
GDC B0 B23 L1 VB0 U1 2
GDC B1 B22 L3 T1 1
GDC B2 B24 L4 R2 48
GDC B3 B25 M3 A19 R1 17 A17
GDC B4 B20 M1 P3 16 NC
GDC B5 B18 N1 VB7
GDC B6 B17 M2
GDC B7 B19
VCLK A34 E1 VCLK

VHS B34 F3 VHS
VVS A32 E3 VVS
VPEN B32 N2 VPEN
MS H 3/4
MS V 3/4
5-2 5-2 VPL-CX70/CX75

C (2/4) C (2/4)
IC900 CN1100
IC1000 IC1003 IC1100
3D GAMMA & TG 5 VSIG 1
15.5V 13.5V LCD DRIVER
17V 15.5V 15.5V 13.5V 6 VSIG 2
REG REG
121-123,
PW DRE (2-9) DIN0 SIG OUT1 22-20 7 VSIG 3
1/4 PW DRE (0-9) 3-13 RIN0-7 ROUT0-9 126-128, 46-37
130-133 DIN9 SIG OUT6 17-15 8 VSIG 4
PW DRE (1)
14 GND CLKOUT1 83 34 CLK 9 VSIG 5
PW DRE (0)
15 GND 31 DIRC Q1100,1101 10 VSIG 6
60 ROSD1 33 FRP
PW DRE (9) 5 3
59 ROSD0 32 PRG SID OUT 24 BUFF 3 PSIG
7 2 VCOMR
14 YS VCOM OUT 13 31 VCOML
IC906
2 9 19 HST
14 YM DCK1 R 5 SDAT
1 DCK1 151 2 LEVEL 18 23 ENB
CONV DCK2 R 4 SCLK
DCK2 152 3 17 24 VCK
BUFF DCK1 G 3 SENB
DCK3 153 LCD R
PW DGE (2-9) 4 16 25 VST
1/4 PW DGE (0-9) 18-27 GIN0-7 DCK2 G
DCK4 154 5 15 27 CLR
PW DGE (1) DCK1 B
DCK5 156 6 14 28 PCG
28 GND DCK2 B
PW DGE (0) DCK6 157 7 13
29 GND CLR
CLR 143 8 12 12 DCK2
62 GOSD1
61 GOSD0 13 DCK2X
14 DCK1X
15 DCK1
16 HCK
17 HCKX
18 RGT
26 DWN
SOUT1 173 32 GCFB
CN1000
IC907 5 VSIG 1
LEVEL DCK1X R 6 VSIG 2
2 18
CONV DCK2X R 7 VSIG 3
3 INV 17
DCK1X G 8 VSIG 4
4 BUFF 16
DCK2X G 9 VSIG 5
5 15
DCK1X B 10 VSIG 6
6 14 Q1000,1001
DCK2X B IC1002
7 13
DOWN LCD DRIVER BUFF 3 PSIG
8 12
2 VCOMR
DIN0 SIG OUT1 22-20
PW DBE (2-9) 107-114, 46-37 31 VCOML
35-42 BIN0-7 GOUT0-9 117,118 DIN9 SIG OUT6 17-15
1/4 PW DBE (0-9)
19 HST
PW DBE (1) CLKOUT2 84 34 CLK
23 ENB
43 GND
PW DBE (0) 31 DIRC
1/4 PW OSD EN 44 GND 24 VCK
FRP 158 33 FRP LCD G
65 BOSD1 25 VST
PRG 166 32 PRG SID OUT 24
64 BOSD0 27 CLR
IC905
28 PCG
RGTX VCOM OUT 13
1/4 PW DCLK 73 CLKC X RGT 141 2 18
LEVEL RGT 5 SDAT
1/4 PW DHS 66 HDIN RGT 170 3 17 12 DCK2
CONV HCK1 R
4 16 4 SCLK 13 DCK2X
1/4 PW DVS 67 VDIN BUFF
HCK1 G 3 SENB
5 15 14 DCK1X
HCK1 B
HCK1 149 6 14 15 DCK1
HCK2 R
3.3V-2 7 13 16 HCK
IC901 Q900 HCK2 G
8 12 17 HCKX
2 RESET 1 RESET 48 PLLSTB HCK2 150 HCK2 B
SW 9 11
18 RGT
3.3V-2 26 DWN
3.3V-2 IC902 SOUT2 174
Q901 32 GCFB
IC903 IC904 CN1600
2 RESET 1 HST
EEPROM 5 VSIG 1
HST 164 4 16
LEVEL ENB 6 VSIG 2
SDA 5 44 RSDA ENB 144 5 15
8 VDD CONV VCK
44 RSCL VCK 137 6 BUFF 14 7 VSIG 3
SCL 6
VST 8 VSIG 4
VST 136 7 13 IC1200
PCG 9 VSIG 5
44 XCLR2 PCG 165 8 12 LCD DRIVER
44 XCLR3 DWN 169 9 11 10 VSIG 6
Q1200,1201
90-95, DIN0 SIG OUT1 22-20
BOUT0-9 98-102 46-37
1/4 SDA 400K DIN9 SIG OUT6 17-15 BUFF 3 PSIG
1/4 SCL 400K CLKOUT3 85 34 CLK 2 VCOMR
31 DIRC 31 VCOML
S900 33 FRP 19 HST
32 PRG SID OUT 24 23 ENB
44 HSDA 24 VCK
5 SDAT VCOM OUT 13 LCD B
25 VST
CN900
4 SCLK 27 CLR
LUT
3 SENB 28 PCG
44 HSCL SOUT3 175
W SDA 3
W SCL 2 12 DCK2
IC1001 13 DCK2X
BUS 14 DCK1X
1/4 PDRV SDAT 3 5
BUFF 15 DCK1
1/4 PDRV SCLK 6 2
16 HCK
1/4 PDRV SENB 1 7
17 HCKX
18 RGT
26 DWN
32 GCFB
VPL-CX70/CX75 5-3 5-3

C (3/4), QA (2/2) C (3/4), QA (2/2)
C(3/4) IC1401
FAN REG
CN1400 CN1401 FAN A
B FAN +B 1 2 VCC OUT 4 1 FAN A
FAN +B 2 D1410
GC BOARD 5 C
OFF & GO 9 D1403
CN302 2 FAN A PROT
D 3.3V 5 3.3V-2 Q1405 1 CTL
D 3.3V 6 IC400
1.8V
1.8V
REG
IC602 D1404
DTV SYNC SEP Q1402
Q603 4 4/4 PSAVE FCONT SW
2 18
1/4 H SYNC SLICE 36 IN1 H SELH OUT 22 HSS 1/4
6 1 IC1402
Q601 5 IC1405 FAN REG
CN1402 FAN B
1/4 V SYNC BUFF 37 IN1 V
4/4 FAN CONT1 3 1 2 VCC OUT 4 1 FAN B
DRIVE
4 16
1/4 SOG 35 IN3 SELV OUT 23 VSS 1/4 5 7 5 C
1 2 FAN B PROT
4/4 SDA 100K 1 31 SDA
IC1403
4/4 SCL 100K 1 30 SCL FAN REG
D1404 D1411,1412 CN1403 FAN C
IC1406 2 VCC OUT 4 1 FAN C
20 EXTCLK/XTAL
D1408
X600 4/4 FAN CONT2 3 1 5 C
4MHz DRIVE 2 FAN C PROT
15 YG OUT YG IN 16
4/4 FAN CONT3 5 7
FAN D
CN103(1/2)
4/4 FAN PROT
Q607 4 FAN D
IC604 BUFF SW 5 FAN D PROT
9 IC604 IC1404
2 Q1400 FAN REG
4/4 PC DTV D1405 CN1405
8 1 Q608 Q1401
10 3 2 VCC OUT 4 1 FAN E
IC102 INV
5V REG 5V-2 5 C D1409

IC601 2 FAN E PROT
PC SYNC SEP D1406
IC104 IC605 FAN E
Q602 Q604
5V REG 5V-4 17 3
BUFF SLICE 6 C/H HD 15
19 D1407
CN106
Q605 15 5
C 6V 5 6V
LIM 8 V IN
VD 13
19
6V 6 IC1305
GB BOARD 13 7
CLAMP 17 CLAMP 1/4
CN204 19 1 RESET 2 5V-1
+17V 9 17V 4 GREEN IN
H POL 18 H POL 4/4 Q1300
IC1303
SUB 5V 3 5V-1V V POL 19 V POL 4/4 USB I/F
D1305
SUB 5V 2 12
IC1302 10 RST VCC 8
3.3V V.STATE 2 CN1302
CN1300(2/3) 3.3-1V 11 IC1300 1
REG 13 SYNC SEL USB
D SUB 5V A3
IC400
IC604 4/4 SIRCS
3
3 IR IN USB+ 6
SUB 5V B3 1 0Y 2
M BOARD AUDIO PROCESSOR
SUB 5V A4 5 1Y 11 X1 USB- 5
CN1501(1/2) X1300
SUB 5V B4 1/4 MS H 2 2Y Y 3 HS 4/4 12MHz
4 SDA 12 X2 IC1301
SUB 5V B5 4 3Y
5 SCL 6 8
E AU MS L B15 18 IN2L 12 0X PROTECT

AU MS R A15 13 IN2R 14 1X X 13 VS 4/4
M BOARD 1/4 MS V 15 2X
1501(2/2) IC401
11 3X
AUDIO AMP
Q400
QA(2/2) 4/4 SW 3 9 B 4/4 AU MUTE MUTE 3 ST DWN CN400
J400 OUT L 2
CN403(2/2) CN502(2/2) OUTP 7 1 SP +
AUDIO SPEAKER
1 AU V L 1 17 IN1L 1 INP OUTN 10 2 SP -
INPUT
2 AU V R 2 14 IN1R
OUT R 9
5-4 5-4 VPL-CX70/CX75

C (4/4), HA, HB, L, NF, NR, U, V C (4/4), HA, HB, L, NF, NR, U, V
HB C(4/4) IC203
Q2000 MAIN CPU
D2000 CN2000 CN101 Q203 IC301
LED 13.5V-1 9V REG POWER 9V
LAMP 1 LAMP LED 1 43 P11/P09/TIOCB0 PC5/A5 11 SDA 100K 2 1/4
DRIVE
LEVEL
PA5/A21/IRQ5-A 29 IC303
Q2001 CONV
D2001 PC4/A4 9 SCL 100K 2 1/4 9V REG A9V
LED
TEMP 2 TEMP LED 2 44 P12/PO10/TIOCCO/TCLKA PA4/A20/IRQ4-A 28
DRIVE
PG4/BREQ0 130 DDC SWO 1/4 IC304
Q2002
D2002 P53/AOTRG/IRQ3-A 136 DDC WE 1/4 I2C DECODER IC306 IC308
LED CN302
PSAVE 4 PSAVE LED 4 42 P10/P08/TIOCAO 2 3
DRIVE DAC3 4 4 1 1 COVER+
S2000 P81/TXD3 33 PDRV SDAT 2/4 1
MOTOR
LENS FOCUS - 5 KEY4 5 117 P44/AN4 P85/IRQ5-B/SCK3 61 PDRV SCLK 2/4 IC302 DRIVER
S2004
S2001 F0/WAIT 84 PDRV SENB 2/4
SIDE SHOT - 5 6
LENS FOCUS + 5 7 2 COVER- LENS
6 2 7
S2002 6 KEY3 6 116 P43/AN3 SHUTTER
LENS ZOOM - PH3/IRQ7-B 38 SW3 3/4 SW0 2
S2003 PC6/A6 12 PC DTV 3/4
LENS ZOOM + S2005
3/4 H POL 58 P27/P07/TIOCB5/IRQ15-B 14 SDA SW3 10 3 OPEN SW
SIDE SHOT +
7 KEY4 CON 7 3/4 V POL 60 P84/IRQ4-B 15 SCL SW2 9 4 CLOSE SW
Q201
TH001 3/4 HS 56 P25/P05/TIOCB4/IRQ13-B PB4/A12 19 AU MUTE 3/4
PANEL TEMP 3/4 VS 57 P26/P06/TIOCA5/IRQ14-B PC3/A3 8 SDA 100K 1 3/4
LEVEL
122 P91/AN9 PA3/A19 27 IC302 IC305
CONV CN301
Q1900
HA LED
CN1900 CN100 PC2/A2 7 SCL 100K 1 3/4 1 7
6 3 1 M+
3 D3.3V 3 3.3V-2 PA2/A18 26 MOTOR
D1900,1901 DRIVE
3 5 DRIVER
ON/STANDBY Q1901 11 14 2 M-
PG0/CS0 107 TILT
INTERLACE 1/4
ADJ
LED 2 POWER LED 2 45 P13/PO11/TIOCCO/TCLKB P60/TMR10/DREQ0-B/IRQ8-A IC300
81 PWFMBSY 1/4
DRIVE DECODER FOR OPT CONT IC307
PA6/A22/IRQ6-A 30 SIGCH FLAG 1/4
S1900
P80/IRQ-B 3 PW DVS 1/4,2/4 Y1 14 1 BUFF 3 4 T2
7 KEY0 7 113 P40/AN0
S1901 IC202 4 G2A Y2 13 CN300
MENU 3.3V-1
F5/RD 89 5 G2B Y3 12 1 ZOOM+
UP 6 KEY CONV. 6 2 RESET 1 92 RES
S1904 F4/HWR 88 1 A Y4 11 2 ZOOM-
DOWN S1902 TILT - D205
ENTER F3/LWR 87 2 B Y5 10 3 FOCUS+
INPUT Q202
RIGHT AF
5 KEY4 5 39 WDTDVFN F2/IRQ15-A/LCAS/DQML 86 3 C Y6 9 4 FOCUS-
LEFT
S1903 P95/AN13/DA3 126 6 AF BUSY
POWER 8 VCC SDA 5
S1905 F1/IRQ14-A/UCAS/DQMU 85 SW 5 AF REG
IC204 SCL 6
TILT + P45/AN5 118 Q300
EEPROM CN1300
(3/3)
P32/RXD0/1RRXD/SDA1 140 A11 RXD MS F
CN61 CN109(1/2) P30/TXD0/IRTXD 142 B11 TXD MS
M BOARD
L D61 1 LED VCC 1 5V-1
Q100
P65/TMO1/DACK1-B/IRQ13-A 106 B12 BRD STATUS
CN1501(2/2)
LOGO PE6/D6 69 A12 MENU STATUS
LED
2 LED CONT 2 83 P62/TMCIO-B/IRQ10-A P21/PO1/TIOCB3/IRQ9-B 52 A13 FLAG
DRIVE
P64/TMO0/DACK0-B/IRQ12-A 105 A10 MS RESET
PF7/O 94 B13 MS SW
IC103
IC41 SIRCS I/F PE7/D7 71 B10 WLESS ON
CN41 CN109(2/2)
NR SUB 3.3V
IR
RX 2 SIRCS NR 4 2 IRIN1 IROUT 5 51 P20/P00/TIOCA3/IRQ8-B
P46/AN6/DA0 119 FAN CONT1 3/4 A9 SIRCS
IREN1 7 17 PB3/A11
P47/AN7/DA1 120 FAN CONT2 3/4
IREN2 6 16 PB2/A10
P94/AN12/DA2 125 FAN CONT3 3/4 A7 POWER ON
IC51
CN51 CN104 PD1/D9 74 FAN PROT 3/4 B7 POEWR ON
NF SUB 3.3V
IR
RX 2 SIRCS NR 2 3 IRIN2 X200
96 XTAL PD2/D10 75 PSAVE FCONT 3/4
16.384MHz Q101 CN107
97 EXTAL
PE4/D4 67 4 LAMP ON
INV
CN52 TXD 5 5 TXD 5 141 P31/TXD1 PB1/A9 15 5 HI/LOW
VISCA
RXD 6 6 RXD 6 139 P33/RXD1/SCL1 BALLAST
PB5/A13 20 1 FLAG
D203 LAMP COVER
SW 3 ACOM
S10 CN10 CN103(2/2) Q102
U 2 LAMP COVER 2 79 PD6/D14 CN106

TH10 PE5/D5 68 1 TF OUT THRM
1 LAMP TEMP TH 1 121 P90/AN8 PD4/D12 77 2 TF IN FUSE
IC201 CN105
12 11
P50/TXD2/IRQ0-A 133 RXD SC 1/4 1 TF OUT
S21 CN21 CN102 P51/RXD2/IRQ0-A 134
IC200
3 TF IN
G
V 3 FILT COVER 3 78 PD5/D13
2
8 9
TXD SC 1/4
GB BOARD
TH21 PG1/CS1 108 1 IC200 8
3 MUTE SC 1/4 10 CN203
1 EXIT TEMP TH 1 127 P96/AN14/DA4 5 9
IC21 4
6 IC201
P-RX 2 3
ACCELERO- 5 4 TILT X 4 47 P15/PO13/TIOCB1/TCLKC PG2 109 PW OSD EN 2/4
METER 1
4 5 TILT Y 5 49 P17/PO15/TIOCB2/TCLKD/EDRACK3 PC1/A1 6 Q200
PA1/A17 24 SDA 400K 2/4 P-TX 6 5
LEVEL
CN200 PC0/A0 5
CONV 4
P-EXT SW
MD2 8 1 MD2 PC0/A16 23 SCL 400K 2/4
TXD 2
RXD 3
CPU & PW ROM
P-RX 9
P-TX 10
P-EXTSW 11
SIRCS 3/4
VPL-CX70/CX75 5-5 5-5

M, QB M, QB
IC1600 (1/2) IC1700 IC1703 IC1600 (2/2)
QB M VIDEO I/F SDRAM MS CPU VIDEO I/F CN1501 (2/2) A
A17 GDC R0 C BOARD
CN1801 CN1500 23 2 177 133 128 143 A19 GDC R1 CN1300
BS 2 65 BS 65 35 MBS 24 4 114 64 189 75 A18 GDC R2 (1/3)
195 127 VDR [0] 202
CN1800 SCLK 8 59 SCLK 59 170 MSCKO 25 5 43 134 243 142 A20 GDC R3
MEMORY DIO 4 63 DIO 63 34 MSDIO 26 7 113 196 57 254 A22 GDC R4
STICK 65 188 VDR [7] 74
INS 6 61 INS 61 107 MPIO 29 8 178 A24 GDC R5
A0 D [0] 197 126 D [0] 201
VCC 9 64 VCC 64 12 30 10 234 135 16 56 141 A25 GDC R6
136 187
VCC 3 58 VCC 58 SUB 3.3V 31 11 232 A23 GDC R7
A11 DQ0 DDQ [0] D [15] 66 125 D [15]
Q1500 IC1601 32 13 16 115 137 241
SUB +3.3V Q1800, 1801 EEPROM 33 42 44 67 55 A28 GDC G0
DQ15 DDQ [15] 251 186
LED 34 44 112 68 124 78 A27 GDC G1
DRIVE SDA 5 226 SDA [0] 77
22 45 179 139 54 A29 GDC G2
SCL 6 105 SCL [0] 198 185 VDG [0] 145
D1800 35 47 40 204 A30 GDC G3
ACCESS 37 CKE 48 116 144 B30 GDC G4
VDG [7] 256
D00 A21 48 D00 48 161 20 BA0 50 175 200 123 76 B29 GDC G5
D01 A22 50 D01 50 95 16 WE 51 45 69 53 203 B28 GDC G6
71 122
D02 A23 52 D02 52 94 18 RAS 53 180 138 239 B27 GDC G7
D03 A2 9 D03 9 159 19 CS 140 184
199 52
D04 A3 11 D04 11 93 38 CLK UDQM 39 241 DDQM [2] B23 GDC B0
D [16] 77 121 D [16]
D05 A4 13 D05 13 217 17 CAS LDQM 15 187 DDQM [3] 72 16 16 51 80 B22 GDC B1
76 238 148
CN1802 D06 A5 15 D06 15 19 PC D [0] 21 BA1 B24 GDC B2
D [31] 144 183 D [31] VDB [0] 3
COMPACT D07 A6 17 D07 17 158 141 120 79 B25 GDC B3
FLASH D08 B22 51 D08 51 92 PC D [15] 204 50 147 B20 GDC B4
IC1701 256 49 VDB [7] 2
D09 B23 53 D09 53 18 254 48 206 B18 GDC B5
SDRAM
D10 B24 55 D10 55 157 75 45 146 B17 GDC B6
202 181
D11 B2 10 D11 10 91 23 2 126 B19 GDC B7
D12 B3 12 D12 12 215 24 4 125
D13 B4 14 D13 14 17 25 5 188 147 112 VDCLKOUT 208 A34 VCLK
D14 B5 16 D14 16 156 26 7 55 80 111 VDHSYNC 5 B34 VHS
4 175
D15 B6 18 D15 18 90 29 8 192 5 174 VDVSYNC 81 A32 VVS
A0 79 110
12 30 10 131 ENABLE 4 B32 VPEN
A [2] 148 230 A [2] IC1502
A00 A20 46 A00 46 16 31 11 61 3 20 14
A01 A19 44 A01 44 155 32
A11 DQ0
13 16 62
DDQ [16]
208
38
173
AUDIO DAC IC1507 IC1509 E
A [21] 146 109 A [15]
A02 A18 42 A02 42 89 33 42 130 6 37 SDO 168 4 SDAT OUTL 14 1 2 3 OP 1 B15 AU MS L C BOARD
DQ15 DDQ [31] MUTE CN1300
A03 A17 40 A03 40 15 34 44 193 78 172 BCKO 32 3 BICK 4 AMP 4
A04 A16 38 A04 38 88 PC A [0] 22 45 245 149 108 BCKI 103 (2/3)
2 228
A05 A15 36 A05 36 213 35 47 132 82 36 LRCKO 225 5 LRCK
A06 A14 34 A06 34 154 PC A [10] 37 CKE 48 191 145 LRCKI 104
7
A07 A12 29 A07 29 14 20 BA0 50 63 150 PP [6] 193 2 PD
IC1508 IC1510
A08 A11 27 A08 27 87 16 WE 51 129 83 PP [5] 131 16 CKS
A09 A10 25 A09 25 13 18 RAS 53 194 151 OUTR 13 1 2 3 OP 1 A15 AU MS R
8 MUTE
A10 A8 21 A10 21 212 19 CS 1 MCLK 4 AMP 4
38 CLK UDQM 39 182 DDQM [0]
-CSEL B14 35 -CSEL 35 6 PC A [25] 17 CAS LDQM 15 118 DDQM [1]
BE [0] 143 113 BE [0]
D1600 F
BE [1] 142 177 BE [1]
BVD1 B21 49 BVD1 49 165 PC BVD1 21 BA1 VDCDISABLE 82 A13 FLAG C BOARD
BE [3] 74 232 BE [3] IC1702 CN1300
BVD2 B20 47 BVD2 47 24 PC BVD2 49
BS# 94 178 BS# FROM (3/3)
-CD1 B1 8 -CD1 8 25 PC CD1# 122 Q1504
BSTACK# 92 117 BSTACK#
-CD2 A25 56 -CD2 56 100 PC CD2# 185 MUTE 29 24
BSTREQ# 157 118 BSTREQ# 31 23
-CE1 A7 19 -CE1 19 22 PC CE1# 50
CS# [1] 217 114 CS# [1] 33 22
-CE2 B7 20 -CE2 20 163 PC CE2# 52 D [16] 35 21 A [2]
DA [0] CS# [2] 159 234 CS# [2] 38 20
-INPACK B18 43 -INPACK 43 223 PC INPACK# 12 121
DREQ# [0] 99 44 DREQ# [0] 40 19
-IORD B9 24 -IORD 24 96 PC IORD# 123 D [31] 42 DQ0 A [21]
DA [11] DREQ# [1] 25 116 DREQ# [1] A1 18
-IOWR B10 26 -IOWR 26 162 PC IOWR# 184 16 44 8 20
DREQ# [2] 221 180 DREQ# [2] 30 7
-OE A9 23 -OE 23 21 PC OE# 128 32 DQ15
DREQ# [3] 22 43 DREQ# [3] A20 6
REDY B12 30 REDY 30 99 PC RDY 53 34 5
IRQ# [0] 225 115 IRQ# [0] 36 4
-REG B19 45 -REG 45 164 PC REG# 57
IRQ# [1] 29 42 IRQ# [1] 39 3
RESET B16 39 RESET 39 23 PC RESET 124 41 2
RDY# 154 236 RDY#
-VS1 B8 22 -VS1 22 98 PC VS1# 43 1
186 DBA [0] 45 48
-WAIT B17 41 -WAIT 41 26 PC WAIT# 17
127 DBA [1] BE [2] 203 176 A [1]
-WF B11 28 -WF 28 219 PC WE# BE [2] 16
181 DCAS# 40 DE [2] 25 A0 9
WP A24 54 WP 54 166 PC WP DIR
119 DCS# [0] DIR 89 41 DIR 28 OE 10
RSTOUT#
IC1501 243 DCKE RSTOUT# 170 59 TRST# 12 RESET
VCC A13 33 VCC 33
IC1503 51 DRAS# 179 PRST# CS# [0]
VCC B13 32 VCC 32 8 5 132 PP [1] 26 CE
5 1 117 DWE# WE#
31 VCC 31 POWER 2 221 PC VCC3EN# 11 WE
SEL 4 3 36 DCLK CS# [0] 215
1 97 PC VCC5EN#
PC VCC 109 DCLKFB WE# 87
SUB 3.3V 5 SUB 3.3V 5 9 SUB 3.3V
10 11 5V-1
12 13
SUB 3.3V Q1501
PP [20] 163
SUB 3.3V LED A10 MS RESET
IC1500 DRIVE PP [14] 164 B12 BRD STATUS
X1500 CLK GEN D1504 PP [13] 21 A12 MENU STATUS
X' TAL CLK66CPU IC1506 TXD [1] 160 A11 RXD MS
3 XIN CPUCK 13 182 CLKIN SUB 3.3V RESET, WDT
OSC CLK12M RXD [1] 26 B11 TXD MS
AUDCK 16 31 FSCKI
CLK48M PP [3] 28 A9 SIRCS
USBCK 6 29 USCKI 5 VCC CLK 3 102 TOUT [0] Q1503
CLK54M A7 POWER ON
VDCK 4 150 VDPCLKIN
CLKMS PP [17] 219 POWER DET B7 POWER ON
C BOARD MSCK 9 171 MSCKI 6 RCT RSTN 8 106 TRST#
SR SEL CN1700
CN1300 (2/3) AUSEL 5 62 PP [0] 111 HRST#
CN1501 (1/2) IC502 ECLK 32 10 ECLK
5V-1 171 PRST#
D SUB 5V A3
5V-1
3.3V
SUB 3.3V 23 CLKIN
ECV 38 6 ECV
SUB 5V B3 REG Q1502 ED 105 8 ED
SUB 5V A4 ERST# 34 4 ERST
SUB 5V B4 IC504 ICE
SUB 5V A5 1.8V
SUB 3.3V 1.8V-3
REG Q1700
SW 3 WD KILL
5-6 5-6 VPL-CX70/CX75

GA, GB, GC GA, GB, GC
GA L101, 102 D101

GB
F101
CN101 T201
TH101 D102 CN104 PIT
AC IN LINE 10
FILTER 1 DC (+)
100 - 240V
50/60Hz
L104
2 RECT 6
IC201
MAIN SWITCHING Q203
D208
Q209 CN205 H
PWM 9 1 17V
D104 24 VD VG (H) 23 CONT
1 9 Q215 2 17V
CN102 D207
1 17V DOWN
1 DC (+) TO LAMP 1 VSENSE VS 22 8
POWER SUPPLY Q204 Q208 DETECTOR
IC101 3 DC (-)
PWM Q206
POWER FACTOR CONT Q101 Q103 VG (L) 20 CONT FAN +B DOWN
7 9 FAN +B PROT
5 ZERO DRIVE 7 2 DETECTOR
OCP 16
Q210
I SENSE 4
4 6 3.3V DOWN
VC1 15 10 D3.3V PROT
3 MULTI VCC 8 DETECTOR
F/B 2 IC204
5
DC-DC CONV. 5 6V
Q102 CN103 CN201 Q211
6 6V
1 VCC VCC 1 5 VIN VFB 3 6V DOWN
CN204 C
DETECTOR C BOARD
9 17V
2 POWER ON POWER ON 2 4 SENSE PG 6 CN106
6 6V
5 6V
3 SUB 5V
Q201, 202 Q214 2 SUB 5V
IC203
LATCH
PH201
POWER ON DELAY
CN203 G
1 2 7 5 C BOARD
ISOLATER 1 PCONT
CN105
GC IC303
Q207
Q216 Q217
3 PPROT
DC-DC CONV.
H CN301 CN302 B PH202
INV
17V 1 1 VIN SW 2 1 FAN +B
ISOLATER
17V 2 2 FAN +B
5 EN INV 4 IC101 IC202

12V REG. SHUNT REG.
Q303
IC302 2 VCC OUT 4 9 OFF & GO
DC-DC CONV. C 5
6V 5 5 VIN VFB 3
6V 6
4 SENSE PG 6
5 D3.3V
Q301 6 D3.3V
FAN +B PROT 5
D3.3V PROT 6
VPL-CX70/CX75 5-7 5-7

Section 6
Diagrams
Note: [Measuring conditions, voltage and waveform]

. Parts marked “ * ” differ according to the model/destination. Refer . : Signal path.
to the mount table for each function.
. The parts marked “ # ” or XX on schematic diagrams are not
mounted. The components identified marked ! are
. All capacitors are in µF unless otherwise noted. pF: µµF 50WV or critical for safety.
less are not indicated except for electrolytics. Replace only with the part number specified.
. All electrolytics are in 50 V unless otherwise specified.
. : fusible resistor
. : nonflammable resistor Les composants identifiés par la marque !
sont critiques pour la sécurité.
. ∆ : internal component Ne les remplacer que par une pièce portant
. : panel designation and adjustment for repair le numéro spécifié.
. Caution when replacing chip parts
New parts must be attached after removal of the chip.
Be careful not to heat the minus side of a tantalum capacitor,
because it is easily damaged by the heat.
Reference information
RESISTOR RN : METAL FILM
RC : SOLID
FPRD : NONFLAMMABLE CARBON
FUSE : NONFLAMMABLE FUSIBLE
RS : NONFLAMMABLE METAL OXIDE
RB : NONFLAMMABLE CEMENT
RW : NONFLAMMABLE WIREWOUND
: ADJUSTMENT RESISTOR
COIL LF-8L : MICRO INDUCTOR
CAPACITOR TA : TANTALUM
PS : STYROL
PP : POLYPROPYLENE
PT : MYLAR
MPS : METALIZED POLYESTER
MPP : METALIZED POLYPROPYLENE
ALB : BIPOLAR
ALT : HIGH TEMPERATURE
ALR : HIGH RIPPLE
VPL-CX70/CX75 6-1 6-1

Frame Wiring Frame Wiring
6-1. Frame Schematic Diagrams L4413 L4416
J9595 J9595 J9595 L4413 GND A1 A1 GND GND 1 1 GND

J5359 J5359
SUB_3.3V 1 1 SUB_3.3V 1 N.C. 1 N.C. 1 N.C. A1 GND GND B1 B1 GND GND 2 2 GND
HA POWER_LED 2 2 POWER_LED 2 VCOMR 2 VCOMR 2 VCOMR B1 A19 GND A2 A2 GND GND 3 3 GND
D3.3V 3 3 D3.3V 3 PSIG 3 PSIG 3 PSIG A2 GND GND B2 B2 GND GND 4 4 GND
KEY4 4 4 KEY4 4 VSSGR 4 VSSGR 4 VSSGR B2 A18 SUB_5V A3 A3 SUB5V SUB_3.3V 5 5 SUB_3.3V
KEY4_CON 5 5 KEY4_CON 5 VSIG1 5 VSIG1 5 VSIG1 A3 GND SUB_5V B3 B3 SUB5V GND 6 6 GND
KEY0 6 6 KEY0 6 VSIG2 6 VSIG2 6 VSIG2 B3 A17 SUB_5V A4 A4 SUB5V GND 7 7 GND
GND 7 7 GND 7 VSIG3 7 VSIG3 7 VSIG3 A4 GND SUB_5V B4 B4 SUB5V -CD1 8 8 -CD1
1 CN1900
7P
CN100 8 VSIG4 8 VSIG4 8 VSIG4 B4 A16 GND A5 A5 GND D03 9 9 D03
7P
9 VSIG5 9 VSIG5 9 VSIG5 A5 A15 SUB_5V B5 B5 SUB5V D11 10 10 D11
L5127 J5359 10 VSIG6 10 VSIG6 10 VSIG6 B5 A14 GND A6 A6 GND D04 11 11 D04
SUB_3.3V 1 1 SUB_3.3V
11 HVDD 11 HVDD 11 HVDD A6 A13 GND B6 B6 GND D12 12 12 D12
TEMP_LED 2 2 TEMP_LED
12 DCK2 12 DCK2 12 DCK2 B6 A12 D3.3V A7 A7 D3.3V D05 13 13 D05
LAMP_LED 3 3 LAMP_LED
HB PSAVE_LED 4 4 PSAVE_LED
13 DCK2X 13 DCK2X 13 DCK2X A7 A11 D3.3V B7 B7 D3.3V D13 14 14 D13
14 DCK1X 14 DCK1X 14 DCK1X B7 A10 GND A8 A8 GND D06 15 15 D06
KEY4 5 5 KEY4
15 DCK1 15 DCK1 15 DCK1 A8 A9 GND B8 B8 GND D14 16 16 D14
KEY3 6 6 KEY3
16 HCK 16 HCK 16 HCK B8 A8 SIRCS A9 A9 SIRCS D07 17 17 D07
KEY4_CON 7 7 KEY4_CON
17 HCKX 17 HCKX 17 HCKX A9 A7 GND B9 B9 GND D15 18 18 D15
GND 8 8 GND
18 RGT 18 RGT 18 RGT B9 A6 MS_RESET A10 A10 MS_RESET -CE1 19 19 -CE1
CN2000 CN101
8P 8P 19 HST 19 HST 19 HST A10 A5 WLESS_ON B10 B10 WLESS_ON -CE2 20 20 -CE2
J5359 J5359 20 HVSS 20 HVSS 20 HVSS B10 A4 RXD_MS A11 A11 RXD_MS A10 21 21 A10
EXIT_TEMP_TH 1 1 EXIT_TEMP_TH
21 VSSGL 21 VSSGL 21 VSSGL A11 A3 TXD_MS B11 B11 TXD_MS -VS1 22 22 -VS1
GND 2 2 GND
22 VVSS 22 VVSS 22 VVSS B11 A2 MENU_STATUS A12 A12 MENU_STASTUS -OE 23 23 -OE
FILT_COVER 3 3 FILT_COVER
V 23 ENB 23 ENB 23 ENB A12 A1 BRD_STATUS B12 B12 BRD_STASTUS -IORD 24 24 -IORD
TILT_X 4 4 TILT_X
24 VCK 24 VCK 24 VCK B12 A0 FLAG A13 A13 FLAG A09 25 25 A09
TILT_Y 5 5 TILT_Y
25 VST 25 VST 25 VST A13 GND MS_SW B13 B13 MS_SW -IOWR 26 26 -IOWR
D3.3V 6 6 D3.3V
26 DWN 26 DWN 26 DWN B13 BHENN GND A14 A14 GND A08 27 27 A08
CN102
2 CN21
6P
C0828
6P 27 CLR 27 CLR 27 CLR A14 GND GND B14 B14 GND -WE 28 28 -WE
LAMP_TEMP_TH 1 C0828 1
LAMP_TEMP_TH 28 PCG 28 PCG 28 PCG B14 ROMOEN AU_MS_R A15 A15 AU_MS_R A07 29 29 A07
U LAMP_COVER 2 2 LAMP_COVER 29 SOUT 29 SOUT 29 SOUT A15 GND AU_MS_L B15 B15 AU_MS_L REDY 30 30 REDY
GND 3 3 GND 30 VVDD 30 VVDD 30 VVDD B15 ROMOEN GND A16 A16 GND VCC 31 31 VCC
CN10 4 FAN_D 31 VCOML 31 VCOML 31 VCOML A16 D3.3V GND B16 B16 GND VCC 32 32 VCC
3P
WHT 5 FAN_D_PROT 32 GCFB 32 GCFB 32 GCFB B16 ROMOEN GDC_R0 A17 A17 GDC_R0 VCC 33 33 VCC
6 GND CN1000 CN1100 CN1200 A17 D3.3V GDC_B6 B17 B17 GDC_B6 A06 34 34 A06
J5359 CN103 32P 32P 32P
LED_VCC 1 B17 ROMOEN GDC_R2 A18 A18 GDC_R2 -CSEL 35 35 -CSEL
L 6P
LED_CONT 2 J5359 LAMP POWER A18 D3.3V GDC_B5 B18 B18 GDC_B5 A05 36 36 A05
1 LED_VCC AF
CN61 SUPPLY B18 CS0 GDC_R1 A19 A19 GDC_R1 -VS2 37 37 -VS2
2P 2 LED_CONT
J5359 J5359 J5359 A19 D3.3V GDC_B7 B19 B19 GDC_B7 A04 38 38 A04
SUB_3.3V 1 3 SUB_3.3V FLAG 1
1 ZOOM_+ B19 CS1 GDC_R3 A20 A20 GDC_R3 RESET 39 39 RESET
NR SIRCS-NR 2 4 SIRCS_NR OE 2
2 ZOOM_- A20 GND GDC_B4 B20 B20 GDC_B4 A03 40 40 A03
GND 3 5 GND ACOM 3
3 FOCUS_+ B20 RESETN GND A21 A21 GND -WAIT 41 41 -WAIT
CN41 6 N,C LAMP_ON 4
3P CN109 4 FOCUS_- A21 GND GND B21 B21 GND A02 42 42 A02
HI/LOW 5
6P 5 AFREQ B21 NM1 GDC_R4 A22 A22 GDC_R4 -INPACK 43 43 -INPACK
L5127 J5359 CN107
SUB_5V
7 7
SUB_5V 6 AFBUSY 5P A22 GND GDC_B1 B22 B22 GDC_B1 A01 44 44 A01
RXD
6 6
RXD 7 VCC B22 FCEN GDC_R7 A23 A23 GDC_R7 -REG 45 45 -REG
GA NF TXD
5 5
TXD 8 GND TH FUSE A23 GND GDC_B0 B23 B23 GDC_B0 A00 46 46 A00
3 GND
4 4 GND CN300 B23 BOOTWE GDC_R5 A24 A24 GDC_R5 BVD2 47 47 BVD2
3 3 SUB_3.3V 8P C0828
SUB_3.3V A24 GND GDC_B2 B24 B24 GDC_B2 D00 48 48 D00
2 2 SIRCS_NF TF_OUT 1
SIRCS_NF C0828 B24 VPPEN GDC_R6 A25 A25 GDC_R6 BVD1 49 49 BVD1
TF_IN 2
GND
1 1 GND 1 FAN_A A25 D15 GDC_B3 B25 B25 GDC_B3 D01 50 50 D01
LAMP POWER CN108
CN51 CN104 2 FAN_A_PROT 2P B25 D14 GND A26 A26 GND D08 51 51 D08
SUPPLY 7P 7P 3 GND SP A26 D13 GND B26 B26 GND D02 52 52 D02
CN102
3P CN1401 B26 D12 GDC_G1 A27 A27 GDC_G1 D09 53 53 D09
BLK C2904 3P
WHT C0828 A27 D11 GDC_G7 B27 B27 GDC_G7 WP 54 54 WP
DC+ 1 C0828 SP+ 1
1 FAN_B B27 D10 GDC_G0 A28 A28 GDC_G0 D10 55 55 D10
DC- 3 SP- 2
2 FAN_B_PROT A28 D9 GDC_G6 B28 B28 GDC_G6 -CD2 56 56 -CD2
CN400
3 GND 2P B28 D8 GDC_G2 A29 A29 GDC_G2 GND 57 57 GND
CN1402 A29 D7 GDC_G5 B29 B29 GDC_G5 VCC 58 58 VCC
3P LENS SHUTTER
C0828 WHT B29 D6 GDC_G3 A30 A30 GDC_G3 SCLK 59 59 SCLK
1 FAN_C A30 D5 GDC_G4 B30 B30 GDC_G4 # 60 60 #
J5359
2 FAN_C_PROT COVER_+ 1 B30 D4 GND A31 A31 GND INS 61 61 INS
C2904 GB 3 GND COVER_- 2 A31 D3 GND B31 B31 GND # 62 62 #
L5127 J5359 CN1403
DC+ 1 PCONT 1 1 PCONT OPEN_SW 3 B31 D2 VVS A32 A32 VVS DI0 63 63 DI0
3P
DC- 3 GND 2 2 GND C0828 WHT CLOSE_SW 4 A32 D1 VPEN B32 B32 VPEN VCC 64 64 VCC
CN104 PPROT 3 3 PPROT 1 FAN_E GND 5 B32 D0 GND A33 A33 GND BS 65 65 BS
4 3P
WHT GND 4 4 GND 2 FAN_E_PROT N.C. 6 A33 NC GND B33 B33 GND GND 66 66 GND
L5127 L5127 CN203 CN105 3 GND N.C. 7 B33 NC VCLK A34 A34 VCLK GND 67 67 GND
4P 4P
VCC 1 1 VCC CN1405 CN302 7P A34 6.4V VHS B34 B34 VHS GND 68 68 GND
C7822 C0828 3P
POWER_ON 2 2 POWER ON GND 1 1 GND WHT TILT_ADJ B34 6.4V GND A35 A35 GND CN1500 CN1801
6.4V 68P 68P
DC- 3 3 DC- SUB5V 2 2 SUB5V A35 GND B35 B35 GND WHT
J5359 WHT
CN103 SUB5V 3 3 SUB5V M+ 1 B35 6.4V CN1300 CN1501
3P CN201 70P
3P GND 4 4 GND M- 2 CN801 70P
XX
6V 5 5 6V T1 3
6V 6 6 6V T2 4
GND 7 7 GND T3 5
CN502
CN1400
GND 8 8 GND CN301
9P
5P
10P
OFF&GO
AU_V_R
AU_V_L
FAN+B
FAN+B
D3.3V
D3.3V
17V 9 9 +17V
CVBS
GND
GND
GND
GND
GND
GND
GND
GND
GND
SC
SY
GND 10 10 GND
-6V 11 11 -6V
10
C0828
1
2
3
4
5
6
7
8
9
9
8
7
6
5
4
3
2
1
CN204 CN106
C M QB
J5359
11P 11P
WHT
L5127 L5127
L5127
17V 1 1 17V
5
C7822
17V 2 2 17V
10
1
2
3
4
5
6
7
8
9
GND 3 3 GND
9
8
7
6
5
4
3
2
1
AU_V_R
AU_V_L
OFF&GO
GND 4 4 GND CN403

FAN+B
FAN+B
D3.3V
D3.3V
CVBS
GND
GND
GND
GND
GND
GND
GND
GND
GND
SC
SY
9P
6V 5 5 6V
CN302
10P
WHT
6V 6 6 6V
GND 7 7 GND
GND 8 8 GND
FAN+B_PROT 9 9 FAN+B_PROT
D3.3V_PROT
CN205
10P
10 10 D3.3V_PROT
CN301
10P
GC QA FRAME
6-2 6-2 VPL-CX70/CX75
A B C D E F G H
QA QA
6-2. Schematic Diagrams and Board Layouts

1
D401
RD3.9UM-T1B
CN401 JL401 PROTECT C
J400 EMI FB400 R412
15
0uH 1/10W R401 R406
RN-CP 100 150
FL401 1/10W 1/10W
0uH RN-CP CHIP
J401
D403
S_IN
R408FB401
D402
FL401
FB400
D401
D402
R403
RD3.9UM-T1B
JL402 PROTECT Y
R414FB402 4 3 2
D404
FB401 R413
FL403 D408 CN403 FL402 2 1 0uH 15
1/10W R402 R407
D407 RN-CP 100 150
D405 1/10W 1/10W
RN-CP CHIP JL404
D403 1 AU_V_L
G RD3.9UM-T1B JL405
CN401 JL400 PROTECT
QA -A SIDE- 5P
D404
2 AU_V_R
SUFFIX: -11 RD3.9UM-T1B 3 GND

JL403 VIDEO PROTECT JL406
EMI 4 CVBS
FB402 R414
0uH 15
FL402 1/10W R403 R408 5 GND
0uH RN-CP 100 150
J401 1/10W 1/10W
RN-CP CHIP 6 SY
JL407
D405 7 GND
VIDEO_IN RD3.9UM-T1B
PROTECT
8 SC 3
JL408
9 GND
004C
804LJ
704LJ
604LJ
R404 CN403
404R 104C 404LJ504LJ 470k
1/10W
9P
504R 304LJ JL409 CHIP
104R
604R
204R
704R EMI C400
C
904LJ
214R 314R JL410

FL403
10
10V
J400
B
014LJ
0uH
3216
204LJ
104LJ
004LJ
D407
RD9.1SB2-T1
PROTECT QA
R405
470k
C401
10
10V
S IN,
1/10W B
CHIP 3216 VIDEO IN 4
D408
RD9.1SB2-T1
QA -B SIDE- PROTECT
SUFFIX: -11
VPL-CX70/CX75 6-3 6-3

A B C D E F G H
5
4
3
2
1
SIL
10P
CN1800
MS SLOT
A
1 GND
2 BS
R1853 XX
3 #
4 DIO
PROTECT
D1802
5 #
MA3J14700LSO
6 INS
7 #
PROTECT
D1803
8 SCLK
MA3J14700LSO
9 VCC
PROTECT
D1804
10 GND
MA3J14700LSO
B
D1805
PROTECT
MA3J14700LSO
B
10V
0.1
1005
C1800
10k
CHIP
1/16W
R1800
68
GND
67
GND
66
GND
47 CHIP 1/16W
47
R1803
CHIP
1/16W
R1801
SW
65
SW
BS
Q1800
Q1801
100
64
CHIP
1/16W
R1802
VCC
DTC114EUA-T106
2SA1576A-T106-QR
63 R1804 47 CHIP 1/16W

DI0
SUB3.3V
62
#
61 R1805 47 CHIP 1/16W
INS
C
D1800
ACCESS_LED
60
#
SECU4901C-S
59 R1806 47 CHIP 1/16W

SCLK
58
VCC
57
GND B25 GND
56 R1807 47 CHIP 1/16W
-CD2 A25 -CD2
55 R1808 47 CHIP 1/16W
D10 B24 D10
54 R1809 47 CHIP 1/16W
WP A24 WP
53 R1810 47 CHIP 1/16W
D09 B23 D09
52 R1811 47 CHIP 1/16W
D02 A23 D02
51 R1812 47 CHIP 1/16W
D08 B22 D08
50 R1813 47 CHIP 1/16W
D01 A22 D01
49 R1814 47 CHIP 1/16W
BVD1 B21 BVD1
D
48 R1815 47 CHIP 1/16W
A21
6-4
D00 D00
47 R1816 47 CHIP 1/16W
BVD2 B20 BVD2
46 R1817 47 CHIP 1/16W
A00 A20 A00
R1818 47 CHIP 1/16W
QB (VPL-CX75)
45
-REG B19 -REG
44 R1819 47 CHIP 1/16W
A01 A19 A01
43 R1820 47 CHIP 1/16W
-INPACK B18 -INPACK
42 R1821 47 CHIP 1/16W
A02 A18 A02
41 R1822 47 CHIP 1/16W
-WAIT B17 -WAIT
40 R1823 47 CHIP 1/16W
A03 A17 A03
R1824 47 CHIP 1/16W
6-4
39
RESET B16 RESET
38 R1825 47 CHIP 1/16W
A04 A16 A04
37 R1826 47 CHIP 1/16W
-VS2 B15 -VS2
E
36 R1827 47 CHIP 1/16W
A05 A15 A05
QB (VPL-CX75)
35 R1828 47 CHIP 1/16W

-CSEL B14 -CSEL
34 R1829 47 CHIP 1/16W
A06 A14 A06
33
VCC B13 VCC
32
VCC A13 VCC
31
VCC B12 READY
30 R1830 47 CHIP 1/16W
REDY A12 A07
29 R1831 47 CHIP 1/16W
A07 B11 -WE
28 R1832 47 CHIP 1/16W
-WE A11 A08
27 R1833 47 CHIP 1/16W
A08 B10 -IOWR
26 R1834 47 CHIP 1/16W
-IOWR A10 A09
25 R1835 47 CHIP 1/16W
B9
F A09
24 R1836 47 CHIP 1/16W
-IORD
-IORD A9 -OE
23 R1837 47 CHIP 1/16W
-OE B8 -VS1
22 R1838 47 CHIP 1/16W
-VS1 A8 A10
21 R1839 47 CHIP 1/16W
A10 B7 -CE2
20 R1840 47 CHIP 1/16W
-CE2 A7 -CE1
19 R1841 47 CHIP 1/16W
-CE1 B6 D15
18 R1842 47 CHIP 1/16W
D15 A6 D07
17 R1843 47 CHIP 1/16W
D07 B5 D14
16 R1844 47 CHIP 1/16W
D14 A5 D06
15 R1845 47 CHIP 1/16W
D06 B4 D13
14 R1846 47 CHIP 1/16W
D13 A4 D05
13 R1847 47 CHIP 1/16W
B3
G
D05 D12
12 R1848 47 CHIP 1/16W
D12 A3 D04
11 R1849 47 CHIP 1/16W
D04 B2 D11
10 R1850 47 CHIP 1/16W
D11 A2 D03
9 R1851 47 CHIP 1/16W
D03 B1 -CD1
8 R1852 47 CHIP 1/16W
-CD1 A1 GND
7
GND
6
GND
WHT
50P
CN1802
5
SUB_3.3V
CF connector
SUB3.3V
4
GND
3
GND
2
GND
1
H
QB
GND
CN1801
68P
WHT
VPL-CX70/CX75
H
QB -B SIDE-
SUFFIX: -11
009A
G
2081NC
F
QB (VPL-CX75)
E
6-5
QB (VPL-CX75)
6-5
D
QB -A SIDE-
SUFFIX: -11
CN1801
R1852 D1802D1803D1804D1805
R1853
R1851
R1850
R1849
R1848
R1847
R1846
R1845
R1844
R1843
R1842 CN1800
R1841
R1840
R1839
R1838
R1837
R1836
R1835
R1834
R1833
R1832
R1831
R1830
R1829
R1828
R1827
C
R1826
R1825
R1824
R1823
R1822
R1821
R1820
R1819
R1818
R1817
R1816
R1815
R1814
R1813
R1812
R1811
R1810
R1809
R1808
R1807
R1806
R1805
R1804
R1803
B
Q1801
Q1800
R1801
R1800
C1800 D1800
R1802
VPL-CX70/CX75
A
C C
C700
R544R543R542
IC700
C846 R838
C779
C705
FB700
D508 D509 R511R518R522
FB703
R506R517R521
FB802
IC803
R503
R735
R733
R729
R732
C838 C768
C766C764 R507
C505
R751
C771
R512
C746
C720
R743
CN500
CN1300 R740 C760
FB702
FB701
C751
L703
R513
C506 R508
C775 C772
C781
R712
C736C715 C706C714
R317C321
R313C319
C318
R316C322
C716
Q300
C317 R509
R1421
R1412
IC305
C1405 L701 R514
R315
R314
R310
C507
R1414
R1413
R1401
R1405
C805 C821
D305 D300 D1401 R801C816
IC806
R500
C735
R650R646 L704
R826
X801
C807
D304 D306 C617
R648
R647
C316 C314
C610
D303 C616C624
R645
IC807
FB804
R651R644
C844 FB803
C738
IC304
R306R307 C614 L700 C737
IC601
R505
R538C503 R515
R510
R504
C622
R303R305
R620
C605
D302 IC1402
C621
C615
R631
C604
R618
C739
C301
D507
D506
D601
R630
R714
R629 R643 C609
R636
D600
D301 R628 C504
C309
C740
C845
IC300
C776
C709
R617 Q605 R627
R612 R655
R649 C618
R704
C607 R516 R519
C741
C603
Q604 R621 R654
C625
FB801
IC800 D504
R302
R301
R845R844 C602
C800 C831
R619 R642 L601
C509R541
Q601
IC501
C606
R537
R539
R540
Q800 R609
Q602
R604
R603
C769C765
R744
R742
C759
R800 FB800
C300 R615
R300
Q801
R614 R602
R750
R840 Q501
C636 C767R749
C763C770
IC301
FB805
IC604
R674
R665
X1300
R672
C637
R1331
R810 IC702
C1307C1309
R1314
R640
R639
R638
R637
C620
C619
R811 R641
CN1302
C626
D1303
R1316
R808 R667 C634
R1332C612
IC1303
R663
R661
R662 R1321
R659
IC603
R664 D603 R1322 C1310
R1313
R656
R1308 R1324
D602
C632
C633
R670 R1307 R1325
C1308
IC1305
IC1300
R657
R1301
R666
R660 R1306
R1319
R1326
R1333
R668 R1309 R1327
R1318
R1305 R1329 C1313
R1302R1330
C1304 R1303
C630
C611
R622
C608R625
R626R623
R616
R610
R611R613
R608R607
Q607
R658
R605
Q600R600
R606
R624
FB126
R123R122 Q606 Q603 R601

FB110FB120
R1404 C -A SIDE-
D1400C1404
R1400
SUFFIX: -11
IC1401
C1408
R1408
R1411
R1409
R1410 C BOARD
C1215
Q1100
FB116 L1101 R1106 C1214 *: B SIDE

FB105 R1105
C1201
FB117 IC1405 R1109
R1108Q1101
RB1200
FB104 D100 A-9 D1408 * C-7 IC905 B-8 Q1101 D-10
IC1200
C1103 R1107 R1210 D101 B-9 D1409 * B-9 IC906 A-8 Q1200 C-8
R1211
R1427 C1107 R1200 R1204 C1200 D102 B-10 D1410 C-10 IC907 B-8 Q1201 C-8
R1202 C1202
RB1102
RB1101 R1203 D103 A-10 D1411 C-7 IC908 * C-8 Q1300 * E-2
R1201
C1100 C1106 C1104 L1200 D200 D-12 D1412 C-7 IC1000 * D-7 Q1400 C-10
C1101R1111 C1102
C1204 RB1201C1206 L1201

RB1202 D201 D-12 IC1001 * C-11 Q1401 C-11
D201
R1101 D202 C-12 IC101 * E-7 IC1002 C-9 Q1402 C-10

L1100 R1104 R1103
IC1100
R1110
C202
R201 R1102 D203 C-12 IC102 * E-7 IC1003 * C-9 Q1403 C-10
RB1100
R1100 D204 C-12 IC103 A-8 IC1100 D-11 Q1404 C-10

D200 R1207 C1203
R1208
R1209
D205 B-10 IC104 B-10 IC1200 D-8 Q1405 C-10

Q1200
RB200C204 Q1201
R202 R1206 R1205 D206 B-11 IC200 C-11 IC1300 E-3
R200
R203
C203 C1207 D300 F-7 IC201 C-11 IC1301 * E-2 TP100 * E-6
IC201 IC200 D301 F-7 IC202 B-10 IC1302 * E-2 TP200 * C-11
D202 D302 F-7 IC203 * B-11 IC1303 E-2 TP201 * C-11
R1432
Q1402 Q1403R1433
C201
C200
D1410
R212 C1412 TH1000 D303 F-7 IC204 C-11 IC1305 E-1 TP500 * G-1
R914
R913
R912
D203
D204
R1424
R291R251 Q1401
C239 Q1400
Q1405 Q1404
D304 F-7 IC300 F-7 IC1400 * B-7 TP700 * E-2

R240
R239
RB906
R290 R1426
D305 F-7 IC301 F-7 IC1401 E-11 TP900 * B-8

R1429 R1436 D306 F-7 IC302 * F-7 IC1402 F-6 TP1004 * B-9
D1412
R238
R243
R259
R258
R256 D501 * G-1 IC303 * B-7 IC1403 * E-7 TP1102 * D-11
R1007
R1008
R1005
R1006
C225R235
RB904 RB905
C213R226 RB1000 D502 * G-1 IC304 F-7 IC1404 B-10 TP1202 * D-10
Q1001
C1010
R269 R1012
R221 D503 * G-1 IC305 F-6 IC1405 D-11
R213 R234R220 R261
R1014
R1013
R907
RB1002
C258 R272
C1013
D1411
R211 R218 R279 R906 D504 F-1 IC306 * F-7 IC1406 * B-10
IC900
R228 Q202 IC204 R278 Q1000 D505 * F-2 IC307 * F-6

C1011RB1001
C209 IC1002
D205
R902 R903
RB903
R204 R252 R277 D506 F-1 IC308 * F-7 Q100 * A-8

R276 R1011
R207 R1010
R215 R231
R214
C222
R248R275R280 D507 F-1 IC400 A-7 Q101 A-9

RB902
C236 R254R222C210
R205
D1404
IC202 R270 R281R271 D508 G-2 IC401 A-11 Q102 B-9

R1009
R1019
R206
R225 R230
R1018
RB901
C221 C217 R253 R274 L1001 C1007 C1003

R224 C216 D509 G-2 IC500 * F-2 Q200 * C-11
R282R273
R246 C232
R293 R287
C228 R244
C233 R245
R247R292
R255 R283
R257 R284
R285
R263 R288
R286
RB900
D206 D510 * G-2 IC501 F-1 Q201 * C-11

R219
R223
C215
R229
L1000 D511 * G-1 IC600 * E-4 Q202 C-11
D1406
C1009
C230
R294
R267 C1002 IC601 F-3 Q203 * C-10

D512 * G-1
R941
R942
R943
R939
R935
R936
R937
C939 RB908 R938
R944
R940
RB915 D513 * G-1 IC602 * E-3 Q300 G-7

R413 R210
C211
RB910
Q400 RB201 IC104 D514 * G-1 IC603 E-3 Q400 B-11

C120
C117
L101 D600 F-4 IC604 F-3 Q500 * F-1

IC905
RB909
C413
C412
IC907
R934 RB907
FB400
C411 D601 F-3 IC605 * E-3 Q501 F-2
C402R402
C404R403
C937
R1423D103 D102
L400 D602 E-3 IC700 G-2 Q600 E-2

C123
FB402
D100 D101
C401
R414
R400
R401
C400 R415
R120
IC1404 Q102 D603 E-3 IC701 * F-2 Q601 F-3

C405
RB914
RB913R933
C409 FB401
R1420
IC401 C121
C1411
D1300 * E-2 IC702 F-3 Q602 F-3

R1403
R117
R118
FB124Q101
IC906
R1419
D1405
D1301 * E-2 IC703 * E-4 Q603 E-2
R1407
R1418
FB125
FB123
FB122
C410
R412
R411
C119 D1302 * E-2 IC800 F-4 Q604 F-3

C938
L401 D1407 C1407D1403 C118 FB901 IC400 D1303 F-1 IC801 * G-3 Q605 F-3
IC103
R108
R107
R105
R406
R111 D1304 * E-2 IC802 * E-4 Q606 E-3

R112
R114
R116
C407
C112 R113 D1305 * E-2 IC803 G-4 Q608 * E-4

C113 R115
D1400 E-11 IC805 * G-3 Q800 F-6
D1401 F-6 IC806 F-6 Q801 F-6
D1402 * E-7 IC807 F-5 Q900 * C-8
D1403 A-10 IC900 B-8 Q901 * B-8
D1404 B-7 IC901 * B-8 Q902 * B-8
D1405 A-10 IC902 * B-8 Q1000 C-10
D1406 B-7 IC903 * B-8 Q1001 C-10
D1407 A-10 IC904 * B-8 Q1100 D-11
6-6 6-6 VPL-CX70/CX75

VPL-CX70/CX75
JL1305
1051L1J58L0J50L0J5LJ 2152L0J59C25R015LJ 905LJ
TP500
725R 525R
C501
C500
205LJ 603355RR
51314C131C 0031C 325R
005Q 535R
D501
JL513
JL1302
D503 R532
R528
JL1303
JL1304
805C
R524
R531
R533
R520
435R
D502R526
D513 D512
FB1300
FB1301
505D
D514 JL503
107C
C711
0031D 005CI 1278R176R17R 015D
FB1306D1302
JL504
R710
C704R709
C712
R763
C702R708
R707
C732
C731
C730
C729
C728
C727
R705
R706
C717R762
513711R31R 517R
D511 C724
C719R764
R723
R722
R720
R719
R717
JL505
R1311
FB1307D1301 R1310
0031Q 8074L2J7R
JL507
8231R 527R
JL506
0231R 627R
1031CI
C1311
D1304FB1308
CN502 L702
C744 C748
C1306
R1312
RB700
JL712
3231R2031CI 057C
TP700
357C
RB701
5031D 457C
436R 167R
536R 067R
037R
C613
R633
R632
637R
C761
737R 107CI R734

R739
X700
117R 837R
137R
C762
107LJ 147R
007LJ 787C
547R
647R
IC602
747R
RB702
C623
JL711
RB703
JL713
C627
257R
R748
507BR 0179L0J7LJ
507LJ
R759
R758
R653
R652
006X 517B4R17B3R17B2R17B1R17B7R07LJ 017B9R07B8R07B7R07B6R07B4R07BR

C628
JL601
R756
R755
R757
006L 136C
CN800
C629JL608
JL603
428C 008L
106C 108CI
5285C080R38C
728C
C829
606LJ 506CI 407LJ 708R

JL602
C823 C828
R806
R669 JL604
307LJ208CI
X800
R671 C635
376R
IC805
JL605
R754
R753
706LJ 438C
IC600
806Q
C826
618LJ
R815
R814
R813
006C
JL844
CN801
487C
238C 4082L0J8LJ008LJ
C837
338C 508LJ
0482L4J8R 428LJ
3
148LJ4 8 R
C810
C808
C804
C806
C803
C852
C802
IC703
518LJ 748C 458C 918LJ

JL845
738LJ 108C 848C938R 028LJ

C853
158C 948C
387C 9381L4J8R 518C 908C
558C 718LJ
528R
R821
80317B0R31BR 118C 028C

718C 418C
R819
628LJ 138R
R832
C818
R829 C856
228R
R823
R830
038LJ 128LJ 348C

728LJ2 2 8 L J
248C 938C 538R
828LJ 828R 328LJ
R824 R812
338LJ 818LJ
R820
6031BR
R809
728R
R836
438LJ
R818
C813 C841 R833
C850 R837 C836
6185R38C
C812 C840 R834
1389L2J8LJ238L7J18R 5386L3J8LJ
50314B0R313B0R312B0R311B0R31BR
308R
228C 208R
408R
JL842
JL843
918C
513LJ
513C
803R
CN301
JL316 JL317
6-7
IC307
C312
8041LJ
103HT
7041LJ
TP100
6041LJ
CN1402
C
9041C
003HT
813R
JL313
R304
C313
C311
913R
JL322
C105
JL311C303
203C 503C 203CI

JL319
C
601NC 803LJ
C104
JL138 C111
803CI
IC102
711LJ 911LJ 811LJ 211BF

C310
JL136
JL314
231LJ 603CI
C304
131LJ
C1410
JL318 JL320
CN302
JL312
R309
C320
3041NC 501NC 411C

IC303
801NC 1141LJ
321LJ 0139L0J3LJ 101R701BF
6115L1J1LJ 001R
6-7
0001CI
C103
C101
2241R 2041D 6041C

JL405
JL404
430414R1LJ 221LJ 5141R

JL321JL141
6141R 811BF
104LJ
JL1412
0334114R1LJ 9041LJ 601BF

C306 JL128
7141R
D1408
JL400
FB121
FB109
R312 JL110
FB111 C102
FB113 C100
901C
R1402
R1406
JL129
C408
R121
704R 604LJ 703C 2041LJ 203LJ 603LJ

3001LJ
JL304
CN102
031LJ 1030L0J3LJ
R1000
R1001
R1002
504R
JL303
R311 JL140 JL305
JL111JL307
404R
JL323 C308
3041CI
604C 0041CI 003NC
C929
C931
C1403
C108
JL134
IC101
L900
304C
C1211
C1205
C1208
C1001
129R 719R
FB900 FL901
429R
529R
C921
209C2041C309C 229C409C009Q0396C19R
R915
029R 919C 3 3 9 C 1 0 9 C 0 0 9 R 3021LJ

009PT 3121C 0121C 2021L 0021L9J021C2121C
R1212
829C
R918
FL902 R923
JL904
211LJ 209CI 109CI809CI

819C
JL907
1021LJ0021NC
JL137
311LJ
R901C900
619LJ 629R 1494C390C492C39C

JL908
CN103
229R 919R 4021LJ 2021LJ

109Q
C917
R946
R945
209LJ 539C
R909
R908
R932
R911
R910
901R 309CI 809C

R931
JL906 JL910
JL909C916
Q902
C920
011R
C907 R929
R928
729R 429C
C115
4013R01R 409CI
JL911
039R
729C
C905C923C906 FL900 C909
JL905
001Q
309LJ 6294C19C 319C 219C 1190C19C
C915
219BR 639C 529C

R948
R947
JL143CN109
801BF
519LJ 9190L2J9LJ129LJ
JL925
JL924
JL1018
JL144JL114
JL922
329LJ 8001C
JL926 JL929
JL918
R106
729LJ
R1003
R1004
201R
C1006 JL1004
C110
IC1003
JL928
719LJ 419LJ 7101R 5001C 4001C

FB119 JL135
9101C
219L3J19LJ 4101C
C1015
4001PT
421LJ
JL1000
C122
R119
CN107
521LJ 9041D 2101C

6217L2J1LJ
L1002C1016
R1428
R1435
R1431
5001LJ
7101C
CN1000
0041LJ 6041CI
FB1400
C1018
CN1400
200610L0J1LJ
1041LJ
R1425
TP1202
322LJ 1001LJ
JL215
JL216
1041C
FB1401
JL214
JL217
912LJ
C1400
JL221
JL222
JL220
652C 642C
R295
JL1418
692R
862R
562R
C116
262R
062R
982R
5141LJ 462R
662R 302Q
CN1405
6141LJ
7141LJ 052R
942R 902R 2011LJ
TP1102
242R 4011LJ
IC203
FB100
142R
JL133
0011NC1011LJ
102Q 1001CI
C231
R1112
0014L1J1BF
X200
R236
C229
CN100
732R 3111C9011C 2011L 1111C3011L0J111C

JL101
101BF 0001C
CN104
RB203
JL102
4012L0J1BF 722C 0011LJ

5013L0J1BF 612R
622C
JL142
304LJ 812LJ002Q 5041LJ

C1112
4041LJ
JL402
C1108
C1105
712R
904R 412C 902LJ2123L1J2LJ112LJ 3041LJ
804R
CN1401
CN400
014R 202BR 002PT 102PT

C207
C206
C218
R232
C208
C205
R208
R227
R233
6017L0J1LJ9010L2J1LJ
JL108
409R
509R 0028L0J27L0J2LJ502LJ3022L0J21L0J2LJ 101NC
JL901
JL900
JL206
JL204
009S
009NC 002NC
JL139
SUFFIX: -11
C -B SIDE-
C (1/14) C (1/14)
3.3V-1
(TO P2) (TO P2)
CON_PANE
CPU
JL100 3.3V-2
SUB_3.3V 1
JL101 POWER_LED
POWER_LED 2 FB100
JL102 0uH
D3.3V 3 FB114
JL104 0uH
FB101 KEY4
HA KEY4 4 0uH
FB102 C123
KEY4_CON 5 0.1
JL105 0uH
KEY0 Q102 B 10V
2SA1576A-T106-QR 1005
KEY0 6 FILESAFE_SW
GND 7 FB103 LAMP_COVER
1 CN100
0uH
LAMP_PROT R120
7P 10k
1/16W
CHIP
R119
100
R117 1/16W
10k CHIP
1/16W
LAMP_ON CHIP JL124
1 FLAG
LED_CONT FB122
SUB_3.3V 1 Q101 0uH 2 OE
JL106 TEMP_LED HN1C01FU-TE85R JL125
TEMP_LED 2 INV 0uH 3 ACOM
JL107 LAMP_LED FB123 JL126
LAMP_LED 3 FB104 4 LAMP_ON
JL108 0uH FB124 0uH JL127
FB117 PSAVE_LED
HB PSAVE_LED 4 0uH 5 HI/LOW
KEY4 5 FB105 FB125 CN107
JL109 0uH 0uH 5P
KEY3 R118
KEY3 6 10k
JL139
FB116 LAMP_POWER
1/16W
CHIP
C122
0.1
LAMP POWER
KEY4_CON 7 0uH 10V D100 D103 SUPPLY
B RD3.3SB-T1 RD5.6SB-T1
GND 8 PROTECT PROTECT
CN101 JL120
8P
D101 D102
JL110 EXIT_TEMP_TH RD5.6SB-T1 RD5.6SB-T1 CN108
EXIT_TEMP_TH 1 PROTECT PROTECT 2P
R100 POWER_ON JL128
GND 2 FB106 1 TF_OUT
V 0uH 0
JL111 CHIP FILT_COVER JL129
FILT_COVER 3 2 TF_IN
JL140
2 TILT_X
TILT_Y
4
5
JL141
FB118
0uH TILT_X
TILT_Y
2:11E
2:11E
R121
10k
1/16W THRM FUSE
CHIP
D3.3V 6 R101
CN102 JL134 FB107 0
6P JL112 0uH CHIP
LAMP_TEMP_TH 1
JL113
U LAMP_COVER 2
GND 3
FAN_D 4 FAN_D 14:11E
FAN_D_PROT 5 FAN_D_PROT
FAN_D 14:11E
5V-1
GND 6 FB126
0uH
CN103
6P
C115 IC103 C118 C119
CN104 R106 R107 R108 XX IRMF-A0T-QTP 0.1 10
7P VISCA_RXD 47k 47k 5.6k 10V 6.3V
R122 47 2:4H 1/16W 1/16W 1/16W SIRCS IF B B
1/16WCHIP CHIP CHIP CHIP 2012
7
SUB_5V R123 47 VISCA_TXD 1005
2:4H R102
8
1/16W CHIP VDD VSS R111
RXD
6 100 1/16W CHIP 100 1/16W CHIP NR_ON
7
5 IRIN1 IREN1
TXD R112 100 1/16W CHIP NF_ON
NF
6
IRIN2 IREN2
GND
4
FB110 R105 R115 100 1/16WCHIP
0uH FB120 100 SIRCS
5
0uH RES IROUT
SUB_3.3V
3 1/16W R113 2:11E;13:2C;
JL142 CHIP XX 13:5H
SIRCS_NF
2
C110 C112 C113 R114 R116
3 GND
1 100p
50V
CH
100p
50V
CH
0.1
10V
B
XX XX
1005 1005 1005

5V-2
R109 R110
330 330
1/16W
RN-CP
1/16W Q100
RN-CP 2SC4081T106R
LED_SW
R103
10k
1/16W
CHIP
R104
JL143 10k
LED_VCC 1 1/16W
L JL144 CHIP
LED_CONT 2
SUB_3.3V 3
JL114
NR SIRCS_NR 4 FAN_PROT
7A;2:12A;14:11A FAN_PROT
GND 5 FB108 FB119 FAN_CONT1
0uH 0uH 7A;2:12A;14:11A FAN_CONT1
N,C 6 FAN_CONT2
7A;2:12A;14:11A FAN_CONT2
CN109 FAN_CONT3
6P JL135 7A;2:12A;14:11A FAN_CONT3
4 PCONT 1
JL115
GND 2 FB109
0uH
GB POWER_PROT
PPROT 3
JL116 FB121
GND 4 0uH
CN105
4P 17V
17V
C103
47
JL117 25V
C102 JL130
FB111 0.1
0uH 50V
B SUB5V
2012 IC101
5V-1 AIC1117A-33PYJTR
3.3V_REG 3.3V-1 SUB3.3V
GND 1
JL118
SUB5V 2 JL131 I O
ADJ JL122
SUB5V 3 FB112 C104
0uH 0.1 C105
B 10V 47
GND 4 1005 6.3V
JL119 JL137
6V 5 5V-2 5V-4
GB C108
D5V AU5V
6V 6 6V 0.1 C109
B 10V 47
1005 6.3V
5 GND
GND
7
8
C100 C101 JL132 L101 JL133
+17V 9 FB113 0.1 47 IC104 4.7uH
0uH 50V 25V
JL136 B AIC1117A-50PYJTR
GND 10 2012 IC102 5V_REG
AIC1117A-50PYJTR
CN106
11P
WHT
-6V 11
5V_REG I
ADJ
O JL123 I
ADJ
O C (1/14)
C111 C114 C116 C117 C120 C121 (SIRCS IF)
0.1 47 47 0.1 82 82
10V 6.3V 25V 10V 6.3V 6.3V
B B
TP100
JL138
GND
6-8 6-8 VPL-CX70/CX75
A B C D E F G H
C (2/14) C (2/14)
IC204 C258 (TO P1)
BR24L64F-WE2 0.1
10V CPU
IC202 3.3V-1 EEP_ROM
B
S-80928CNMC-G8Y-T2 1005
RESET
8
A0 VCC R291
D206 R248 Q202 0
47k
3
NC
7
VSS MA3J14700LSO 1/16W A1 WP
SC_CPU R222
10k CHIP
HN1B01FU-TE85R CHIP
(TO P1)
RES_SW
13:2C
2
1/16W SCL_E 7H
6
VDD A2 SCL CON_PANE
CHIP
1
CD SDA_E 7H
5
OUT VSS SDA
8:3B
R252
3.3V-2 47k R290
C210 1/16W R261 0
0.01 CHIP
MS_SW
16V 1k
B 1/16W JL218 CHIP
D205 CHIP R283 R284 R285 R286
10k 10k 10k 10k
HN1D03FU-TE85R 1/16W 1/16W 1/16W 1/16W
MUTE_SC
JL223 OR CHIP CHIP CHIP CHIP
1
AFREQ 3:6F
PDRV_SENB
C200 R294
CNT_PLS
XX PWFMBSY
3:2C
0.1
3:2C
3:2C
10:1D
JL217 3:2C
ENC2
ENC0
ENC1
10V 8:5D LED_CONT
B X200
1005 16.384MHz
C231 C232 LAMP_COVER
10p 0.01
C229 50V 16V
CH B FILT_COVER
JL214
JL215
10p R245 R247
50V 10 10k
CH 1/16W1/16W POWER_PROT KEY0
KEY0
14
JL216
13:2C MS_RESET CHIP CHIP
1 R287
R246
220 FAN_PROT 1:5A;12A;5C
13
BRD_ST
2
13:2C XX 1/16W
CHIP R288 KEY3
12
KEY3
3
100
R254 100
R257 XX
R255 XX
R293 C228 C230 1/16W 1:5A;12A;5D
1/16W
11
CHIP
R292
C233
4
10k 0.1 0.1
XX
1/16W 10V 10V 0.1 PSAVE_FCONT 14:11B KEY4
CHIP B 10V
10
B KEY4
5
RB201 B
100 1:5A;12A;5D
C236 0.1
6
9
INTERLACE R244
8
7
R267 XX
R263 XX
7:3H;8:5D INTERLACE 10k
10V
R200
7
8
1/16W
6
5
10k CHIP
1/16W
CHIP
4
3
IC200 9:2F PW_OSD_EN
74VHC02MTCX 108 107 106 105 104 103 102 101 100 99 98 97 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73
2
1
R210 XX
NOR GATE
RTCVCC
PLLVSS
PLLVCC
PG1/CS1
PG0/CS0
P63/TMCI1/TEND1-B/IRQ11-A
F2/IRQ15-A/LCAS/DQML
F1/IRQ14-A/UCAS/DQMU
62/TMCI0-B/IRQ10-A
61/TMRI1/DREQ1-B/IRQ9-A
P60/TMR10/DREQ0-B/IRQ8-A
F0/WAIT
PD7/D15
P65/TMO1/DACK1-B/IRQ13-A
P64/TMO0/DACK0-B/IRQ12-A
RTCGND
EXTAL
PD6/D14
PD5/D13
PD4/D12
PD3/D11
PD2/D10
PF6/AS
F4/HWR
F3/LWR
XTAL
VSS
PF7/Ø
STBY
PD1/D9
PD0/D8
F5/RD
N.C
N.C
VCC
RES
C256
C211 XX 0.1
10V
B
R206 109 PG2 VCC 72
4.7k
1/16W R214 R215 R219
RN-CP 10k 10k 10k 110 PG3 PE7/D7 71 WLESS_ON 13:2C
1/16W 1/16W 1/16W C214 10
C207
CHIP CHIP CHIP
R223
100 C215
6.3V B
111 AVCC VSS 70 2
0.1 1/16W 0.1 112 VREF PE6/D6 69 MENU_STATUS 13:2C
10V CHIP 10V POWER_ON
B 1:5A;12A;12B KEY0 B
R229 100 113 P40/AN0 PE5/D5 68
1/16W CHIP LAMP_ON
114 P41/AN1 PE4/D4 67
C216 0.1 10V B 1005 R273 XX
1:5A;12A;12B KEY3 R224 100 R230100 1/16WCHIP 115 P42/AN2 PE3/D3 66
1/16WCHIP C217 0.1 10V B
116 P43/AN3 PE2/D2 65 R282 XX
C22110V
0.1 B R253 XX
C201 1:5A;12A;12B KEY4 R225 100 117 P44/AN4 PE1/D1 64
0.1 R274 XX
10V R205 1/16W CHIP
B RXD_SC 4.7k 3:8G POS_DET 118 P45/AN5 PE0/D0 63
1/16W C222 10V
RN-CP FAN_CONT1 0.1 B
119 P46/AN6/DA0 DCTL 62 R270 10k
FAN_CONT2 1/16W CHIP
PANEL_TEMP 10:7E 120 P47/AN7/DA1 P85/IRQ5-B/SCK3 61 PDRV_SCLK 10:1C
R271 100 R280 33k
LAMP_TEMP_TH 1/16W CHIP 1/16W RN-CP
121 P90/AN8 P84/IRQ4-B 60 V_POL 6:12F
JL209 R275 XX
14 13 12 11 10 9
1
A0 VCC PANEL TEMP R231 10k 122 P91/AN9 P83/IRQ3-B/RXD3 59

C206 1/16W CHIP
H_POL
2
B0 A2 0.1 C218 0.1 123 P92/AN10 P27/PO7/TIOCB5/IRQ15-B 58 R281 33k 6:12F

TXD_PW 10V 10V B 1005 1/16W RN-CP
B VS
3
O0 B2 CHIP 124 P93/AN11 P26/PO6/TIOCA5/IRQ14-B 57 13:6D

1/16W FAN_CONT3 R23210k JL221
1k 1/16WCHIP 125 HS 13:4D
4
A1 O2 R207 P94/AN12/DA2 P25/PO5/TIOCB4/IRQ13-B 56

R276 XX JL222
AFBUSY IC203
5
B1 A3 R204 126 P95/AN13/DA3 P24/PO4/TIOCA4/RXD4/IRQ12-B 55

TXD_SC 4.7k 3:5F EXIT_TEMP_TH JL212 HD64F2378VFQ34V
1/16W
6
O1 P3 127 P96/AN14/DA4 MAIN_CPU P23/PO3/TIOCD3/TXD4/IRQ11-B 54

RXD_PW RN-CP R277 XX
7
GND O3 128 P97/AN15/DA5 P22/PO2/TIOCC3/IRQ10-B 53

C208 C209 JL213
0.1 0.1 R208 MS_EN 13:2C
C205 10V 10V 22k 129 AVSS P21/PO1/TIOCB3/IRQ9-B 52 JL220
IC201 1:7D;13:2C;
TC74LCX125FT(EL)
0.1
10V
B
B
1005
B
1005
1/16W
CHIP 5:6H DDC_SW0
R227 XX
130 PG4/BREQO P20/PO0/TIOCA3/IRQ8-B 51 SIRCS 13:5H 3
SELECT_BUFF 131 PG5/BACK VSS 50
5:6G DDC_WE
RB202 TILT_Y
100 132 PG6/BREQ P17/PO15/TIOCB2/TCLKD/EDRAK3 49 1:4C
R233 XX R278 XX
133 P50/TXD2/IRQ0-A P16/PO14/TIOCA2/EDRAK2 48
2
134 P51/RXD2/IRQ0-A P15/PO13/TIOCB1/TCLKC 47 TILT_X 1:4C
4
R279 XX
135 P52/SCK2/IRQ2-A P14/PO12/TIOCA1 46
6
TP200 R228 XX POWER_LED
136 P53/ADTRG/IRQ3-A P13/PO11/TIOCD0/TCLKB 45
8
CLK TEMP_LED
137 P35/SCK1/SCL0 P12/PO10/TIOCC0/TCLKA 44
R218 10k JL211 LAMP_LED
1/16WCHIP 138 P34/SCK0/SCK4/SDA0 P11/P09/TIOCB0 43
R234 10k PSAVE_LED
1/16W CHIP 139 P33/RXD1/SCL1 P10/P08/TIOCA0 42
R272 XX
13:2CRXD_MS 140 P32/RXD0/1RRXD/SDA1 VCC 41
5V-1 141 P31/TXD1 NMI 40
CPU & PW ROM D201
MA3J14700LSO 13:2C TXD_MS 142 P30/TXDO/IRTXD WDTOVFN 39
PA4/A20/IRQ4-A
PA5/A21/IRQ5-A
PA6/A22/IRQ6-A
PA7/A23/IRQ7-A
CN200 PROTECT
12P
143 MD0 PH3/IRQ7-B 38
P80/IRQ0-B
P82/IRQ2-B
C246
D203 0.1
P81/TXD3
GND 1 D1FS4A-TA 144 MD1 PH2/IRQ6-B 37
MON_OUT
PB2/A10
PB3/A11
PB4/A12
PB5/A13
PB6/A14
PB7/A15
PA0/A16
PA1/A17
PA2/A18
PA3/A19
10V
PC0/A0
PC1/A1
PC2/A2
PC3/A3
PC4/A4
PC5/A5
PC6/A6
PB0/A8
PB1/A9
JL201 RECTIFIER B
EMLE
TXD 2 C213 1005
MD2
VSS
VCC
VSS
VSS
VSS
PH0
PH1
JL202 0.1
10V C225 JL219
RXD 3 0.1 R269 R289
JL203 B XX 100
1005 10V 1/16W
RES 4 B 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 CHIP
JL204 R201 MD2 1005
VIN 5 100 R242 SIGCH_FLAG 8:7E
1/16W XX
R265 XX
R268 XX
CHIP R211 R235 R238 C226 4
R250 XX
R213 R221
R249 10k
R220 R296 R262
R243 10k
MD0 6 10k 10k 10k XX R226 47k 0.1 R260 100
1/16W
XX
1/16W
1/16W 47k 47k
CHIP
1/16W 10V
CHIP
CHIP 1/16W 1/16W 1/16W 1/16W B 10k 1/16W
CHIP CHIP CHIP CHIP 1/16W CHIP
MD1 7 CHIP CHIP
JL205 1005 PDRV_SDAT 10:1D
MD2 8
1
2
JL206
P-TX 9 XX
3
4
JL207 TP201
3.3V-2
P-RX 10 C227
5
6
JL208 (TO P3) 0.1

I2C_100K I2C_400K 10V C239 R266
P-EXTSW 11 10k
7
8
R239 R240 B 0.1 R295

2.2k 2.2k 10V 1/16W 100
3:7A;4:7C;6:7A
GND 12 RB200 1/16W 1/16W B CHIP 1/16W

100 CHIP CHIP 1005 CHIP
9:1G
C202
0.1 C203 C204 R216 R256
10V 0.1 0.1 4.7k
B 10V 10V 1/16W 100
JL200 B B 2 4 6 8 1/16W
13:6D
SCL_400K CHIP
SW3
CHIP
D200 D202 R202 R203 RB203
RD3.3SB-T1 RD3.3SB-T1 10k 10k D1 G2 S2 100 R264
1/16W1/16W R236 R237 R259 100
PROTECT PROTECT CHIP CHIP 1k 1k 10k 1/16W
1/16W 1/16W 1/16W CHIP
CHIP CHIP 1 3 5 7 CHIP
R241 SCL_100K_2
Q200 100
R258 5:6G
1/16W R251
SSM6N15FU(TE85R) CHIP 1k 10k
5V-2 POWER_CONV 1/16W 1/16W
CHIP CHIP
D1 G2 S2
S1 G1 D2
PC_DTV
SDA_400K
6:12G
Q203
4:6F AU_MUTE
R217 SSM6N15FU(TE85R)
4.7k LEVEL_CONV
1/16W SCL_E 11A
CHIP
5
LAMP_POWER
SDA_E 11A
LAMP_PROT
R212
10k S1 G1 D2
1/16W
CHIP
NF_ON
NR_ON
SDA_100K_1
SDA_100K_2
5:6H
D204
D1FS4A-TA VISCA_TXD
1:3D
RECTIFIER D1 G2 S2
C(2/14)
8:12B;9:1F; PW_DVS
VISCA_RXD Q201
1:3D SSM6N15FU(TE85R)
LEVEL_CONV
(MAIN CPU)
R209
10k
1/16W
CHIP
9:2G
S1 G1 D2
SCL_100K_1
VPL-CX70/CX75 6-9 6-9

A B C D E F G H
C (3/14) C (3/14)
5V-2
6V POWER_9V
R318 R319
0 XX
(TO P2)
I2C_100K CHIP
2:4G;4:7C;6:7A
R316
0 COVER_+
CHIP
SDA_100K_1
R317
XX
SCL_100K_1
1 13.5V-1
IC308
TH300 BA6287F-E2
16 15 14 13 12 11 10 9 MOTOR DRIVER
R314
VCC
SCL
SDA
SW3
SW2
SDA2
SDA1
SDA0
R311 0
POWER_9V A9V
8
IC304 OUT1 GND 0 CHIP COVER_-
CXA1875AM-T4
IC301 IC303 C309 I2C DECORDER CHIP
BA09FP-E2 BA09FP-E2 0.1 R315
7
10V VM OUT2 XX
DAC4
DAC3
DAC2
DAC1
DAC0
9V_REG 9V_REG
SW1
SW0
GND
B 1005 C311
0.1
10V
6
JL322 JL323 B 1005 VCC V__REF
VCC OUT VCC OUT 1 2 3 4 5 6 7 8
GND GND JL312 C320
R312 0.1
5
F_IN R_IN XX 10V
B 1005
C313
C302 C305 C306 C308 0.1
0.1 C304 0.1 0.1 C307 0.1 10V
47 50V 47 50V B 1005
50V 25V 50V 25V
B B B B R301 R302
2012 2012 XX 10k
1/16W
JL308 CHIP JL314
R304 R309
10k 10k
1/16W 1/16W
CHIP CHIP
IC302
TC7WH04FK(TE85R)
INV
2 IC300
TC74VHCT138AFT(EL)
8
1A VCC
DECODER FOR OPT CONT
C303 C321 C322
0.1 0.1 0.1
7
ENC0 10V 3Y 1Y 10V 10V
16
1
2:8B A VCC B B 1005 B 1005 JL321

1005 JL309
ENC1 R310 R313
15
2
6
2:8B B Y0 2A 3A 10k 10k
R300 JL300
10k ENC2 1/16W 1/16W 1 COVER_+
14
CHIP CHIP JL320

3
1/16W 2:8B C Y1
CHIP
5
JL301 GND 2Y 2 COVER_-
13
4
G2A Y2 JL318
3 OPEN_SW
12
CNT_PLS
5
G2B Y3 JL319
2:8B 4 CLOSE_SW
11
6
G1 Y4
5 GND
10
C300
7
Y7 Y5 C318
XX 0.1
10V C319 6 N.C.
0.1
8
GND Y6 B 1005 10V

IC306 B 1005 7 N.C.
TC7WH125FK(TE85R) CN302
SHUTTER_CNT_SW 7P
C301
0.1 JL310 LENZ SHUTTER
10V
8
G1 VCC
B
7
A1 G2
3 C310
0.1
6
10V Y2 Y1
B 1005
5
GND A2
TH301
IC305
BA6288FS-E2 R306 C316
10k 0.1
MOTOR DRIVE 1/16W 50V
AF CHIP B
2012
16
1
GND RNF
JL302
15
2
ZOOM_+ 1 NC NC
JL303
ZOOM_- 2
14
3
JL304 OUT1 OUT2
FOCUS_+ 3 Q300
JL305 DTC114EUA-T106
13
4
4 FOCUS_-
AFREQ
4
5
JL306
AFREQ_SW VM NC
TILT_ADJ
12
5
JL307 VCC VREF
AFBUSY 6 AFBUSY 2:4D AFREQ 2:8B
JL311 JL313 C314 1 M+
11
6
VCC 7 FIN RIN 0.1 JL317
50V 2 M-
B C317 JL315
GND 8 2012 0.1
10
7
NC NC 50V 3 T1
CN300 B
8P 2012 4 T2
R307 JL316
9
NC NC 100k
1/16W 5 T3
CHIP
CN301
D300 D301 5P
D303 D305
RD5.6SB-T1 RD5.6SB-T1 RD5.6SB-T1 RD5.6SB-T1
R303 R305
D302 D304 D306 10k 10k
RD5.6SB-T1 RD5.6SB-T1 RD3.3SB-T1 1/16W 1/16W
3.3V-2 CHIP CHIP
2:5D POS_DET
R308
1 2 3 10k
1/16W
5 CHIP
VCC
V+
OUT
C312 IC307 C315
0.1 0.1
LMC7101BIM5X 10V
10V BUFFER B
B
GND
C
V-
5 4
(3/14)
TILT MOTOR DRIVE
LENS SHUTTER CONT
6-10 6-10 VPL-CX70/CX75
A B C D E F G H
C (4/14) C (4/14)
I2C_100K 2:4G;3:7A;6:7A
A9V
5V-4 1
FB400
0uH
L401
1uH
L400
1uH
IC400 R410
10k
C401 TDA7309D013TR 1/16W
0.1 AUDIO_PROCESSOR CHIP
IC401
10V
B
C410
TPA2001D1PWR C413
C407 R406 AUDIO_AMP
20
1
REC_OUT_L 0.1 47k 0.1 1
IN3L 10V 1/16W 10V 10V
R402 B CHIP B B
100 C402
19
16
2
0.1
1
LOUDL OUTL C406 INP BYPASS
1/16W 10V
CHIP B 0.1
JL404 10VB R404 Q400 2
18
15
AU_L_MS
3
13:2D
2
IN2L CSM 100 INN AGND
1/16W DTC114EUA-T106
JL400 CHIP C412
SDA_100K_1 INV-SW 220p
17
14
AU_L
4
5:3A 16V
3
IN1L SDA ST DWN COSC
R400 R414 CH
XX R408
100 SCL_100K_1 XX R413
16
13
5
4
1/16W VS SCL 1/16W GAIN0 ROSC 120k
CHIP C400 R405 CHIP 1/16W
0.1 100 RN-CP SP
R401 50V 1/16W R409
15
12
6
5
100 B CREF DGND CHIP 100k GAIN1 VDD
1/16W C403 1/16W FB401
JL401 CHIP 25V 47 CHIP 0uH
14
11
7
JL402
6
5:3A AU_R IN1R GND PVDD PVDD
1 SP+
JL405 R407
13
10
8
7
13:2D AU_R_MS IN2R GND 47k R411 R412 OUTP OUTN 2 SP-
R403 C404 1/16W C409 XX 0 JL403
100 0.1 CHIP 10 FB402 CN400
6.3V CHIP 0uH
12
1/16W R415 CHIP
9
10V 2P
9
XX LOUDR OUTR B GNDP GNDN
CHIP B
C408 2012 C411
0.1 10
11
C405 IN3RREC_OUT_R
10
10V 6.3V
0.1
10V B B 3
2012
B
JL406
2:8G AU_MUTE
C(4/14)
AUDIO_PROCESSOR,
AUDIO AMP
4
VPL-CX70/CX75 6-11 6-11

A B C D E F G H
C (5/14) C (5/14)
JL506 AU_L
AU_V_L 1 4:4D V_IN 7:1E
JL507 AU_R
AU_V_R 2 4:4E
GND 3
VIDEO JL505 VIDEO CVBS
CVBS 4
R542
GND 5 0
QA Y
CHIP Y
JL504 SY
SY 6
R543
GND 7 0
C JL503 CHIP C SC
1 SC 8
D510 D512 R544
GND 9 XX 0
XX CHIP
CN502 PROTECT PROTECT
9P
D513
D511 XX
XX PROTECT
PROTECT
JL513
D508 D509 D514

XX XX RD3.9UM-T1B R506 R511 R517 R518 R521 R522
PROTECT PROTECT PROTECT XX XX XX XX XX XX
3.3V-3
C505 D501
47 MA3J14700LSO
6.3V PROTECT
R507 R512 R525 R534
150 150 22k 47
1/10W 1/10W 1/16W 1/16W
RN-CP RN-CP CHIP CHIP R R
C500 R526
0.01 33k
16V
2 B
1005
1/16W
CHIP
15P
CN500 C506 D502
47
6.3V
MA3J14700LSO
PROTECT
JL509 R
6
R508 R513 R527 R535

22k
1
150 150 1/16W 47

1/16W
11
G
1/10W 1/10W CHIP G
JL510 RN-CP RN-CP CHIP G
7
2
JL501
C501
12
B 0.01 R528
JL512 33k R532
8
16V 1/16W 47
JL511
3
B CHIP 1/16W
1005
13
CHIP
9
SOG
4
JL508
C507 D503
14
47 MA3J14700LSO
10
6.3V PROTECT
JL500
5
R536
15
R509 R514 R529 47

150 150 22k 1/16W
1/10W 1/10W 1/16W CHIP
RN-CP RN-CP CHIP B B
INPUT_A C502
R500 R503 0.01 R530
0 0 16V 33k
CHIP CHIP B 1/16W
1005 CHIP
JL502
3
C503 5V-3
R505 4.7 D504
0 10V
F HN1D03FU-TE85R R537
CHIP 2012 PROTECT XX HSYNC
R515 R538
1k
1/16W 0
CHIP CHIP H_SYNC
R504
0 R539
CHIP XX VSYNC
R510 C504
1k 22
1/16W 10V R540
CHIP F 0
3216 5V-1 CHIP V_SYNC
D505
R520 DAN202UT106 R533
10k
220 OR 1/16W
4 1/16W
CHIP
CHIP
Q500
DTC114EUA-T106
INV_SW DDC_WE
IC500 SYNC_IN
24LC21AT/SN 2:5E
DDC_EEPROM 6:1A
1
NC1 VCC
R524 R531
10k 10k SCL_100K_2
1/16W 1/16W
2
NC2 VCLK
CHIP CHIP
2:10G
3
NC3 SCL
4
GND SDA
IC501
TC74HC4052AFT(EL)
DDC SW
C508
0.1 R523 16 15 14 13 12 11 10 9
10V
1
B 100k 0Y VCC
1/16W
CHIP
2
2Y 2X
5
3
R519 Y 1X
47 R541
1/16W 22k
4
3Y X 1/16W
CHIP CHIP SDA_100K_2
5
1Y 0X
2:10H
6
INH 3X
R516
47
C
7
VEE A
1/16W
D506 D507 CHIP (5/14)
8
RD5.6SB-T1 RD5.6SB-T1 GND B DDC_SW0

XX
PROTECT PROTECT C509
0.1
INPUT A,
TP500 10V 2:5E
B
Q501
DC-DC CONV.
DTC114EUA-T106
LEVEL_CONV
6-12 6-12 VPL-CX70/CX75
A B C D E F G H
C (6/14) C (6/14)
5V-3 5V-3
SYNC_IN R605
5:8G Q600
1k
1/16W
CHIP
1
2SA1576A-T106-QR
BUFFER R607
SOG 0
CHIP
R600 I2C_100K 2:4G;3:7A;4:7C
SDA_100K_1
SCL_100K_1
0
CHIP
IC603
R601
XX
R608
XX
L600 XX
1uH R661 MONO_MULTI R670 3.3V-3
XX
R606 XX
0 R639 R640
16 15 14 13 12 11 10 9
100
1
100 1A VCC D603
CHIP 1/16W 1/16W XX
R622 CHIP CHIP
2
1k 1B 2REXT DISCARGE
1/16W R662 C633
CHIP R625 XX XX
3
XX C623 CLR 2CEXT
R610 R637 R638 R641 0.1 R659 C632
47k XX XX 330k 10V XX XX
4
1/16W 1/16W 1/16W 1/16W 1Q 1Q
CHIP R623 CHIP B
R616 1k CHIP CHIP
C634
5
10 1/16W 2Q 2Q
1/16W CHIP C626 XX
CHIP C619 C620 1
6
H_SYNC 0.22 10 2CEXT 2CLR
10V 6.3V 10V D602
R624 C611 B B B XX R667 XX
7
R613 XX R626 C608 47 1608 DISCHARGE 2REXT 2B
XX XX 6.3V 1608 2012 R668 XX
0 Q603
8
R611 CHIP GND 2A
P36
P35
P34
P33
P32
P31
P30
P29
P28
P27
P26
P25
47k 2SA1576A-T106-QR
1/16W SLICE
CHIP 36 35 34 33 32 31 30 29 28 27 26 25
SELCB_OUT
SELCR_OUT
IN1_H/L1
SELY_OUT
C612
ADDRESS
CLP_CR
IN1_3
IN1_2
IN1_1
VCC2
SDA
SCL
Q606 0.47
10V
XX B
1608 R656 R660
P37 P24 47 0
R632
0 P38
37
38
IN1_V/L2
IN1_L3
GND2 24
SELV_OUT 23
P23
1/16W
CHIP JL604 CHIP 2
CHIP P39 P22 JL605 R666
39 IN1_SW SELH_OUT 22 XX R673
R633 X600 10k
0 P40 P21 R657 1/16W
CHIP 40 VCC1 NC 21 47 4MHz CHIP
1/16W
C613 P41 P20 CHIP Q608
0.1 41 IN2_1 EXTCLK/XTAL 20 R652 DTC114EUA-T106
10V
B P42 IC602 P19 10k INV
42 IN2_2 CXA2171AQ-T6 NC 19 1/16W
RN-CP
P43 DTV_SYNC_SEP P18
43 IN2_3 IREF 18
P44 P17 R653
44 IN2_H/L1 CLP_SW 17 0
CHIP
P45 P16
45 IN2_V/L2 YG_IN 16 R658 C631
R634 1k
0 P46 P15 1/16W 0.01
CHIP 46 IN2_L3 YG_OUT 15 C630 RN-CP 16V
P47 P14 0.1 B
R635 47 IN2_SW V_PH 14 10V R669
0 B 47
CHIP P48 P13 1/16W
48 GND1 H_PH 13 CHIP JL606
C628
1
Q607 VSS 7:5H;13:6D
2SA1576A-T106-QR
IN3_1
IN3_2
IN3_3
IN3_H
IN3_V
IN4_1
IN4_2
IN4_3
IN4_H
IN4_V
C629 10V R671
GND3
VCC3
0.01 B BUFFER 47
16V 1608 1/16W
B CHIP JL607
HSS 7:5H;13:4D
1 2 3 4 5 6 7 8 9 10 11 12 IC605
SN74LV244APWR
P10
P11
P12
P1
P2
P3
P4
P5
P6
P7
P8
P9
SYNC_SELECT
C627
20 19 18 17 16 15 14 13 12 11
1
0.1 DTV VCC
10V
B
2
IN0 PC
3
OUT4 OUT0
3
4
IN1 IN4
5
OUT5 OUT1
6
IN2 IN5
C609
7
4.7 OUT6 OUT2
10V
F
8
IN3 IN6
2012
9
OUT7 OUT3
C635
L601 0.1
10
GND IN7 10V
1uH B
Q601 C618
2SC4081T106R Q602 0.1
BUFFER R614
2SC4081T106R 10V
BUFFER B
R602 10 R617 JL601
47k R604 1/16W 470
1/16W 10 CHIP 1/16W
CHIP 1/16W CHIP
V_SYNC CHIP
R646
C603 3.3k
R615 4.7 1/16W
R603 1k 10V RN-CP
47k 1/16W F C604
0.1
Q604 C625
1/16W CHIP R618 HN1B01FU-TE85R IC601 220p
CHIP 1k 10V 16V CLAMP 7:5H
1/16W B LIMITER R636 M52347FP-TE R642
4.7k CH
C602 R612
CHIP 10k
1/16W
PC_SYNC_SEP 1/16W
4.7 470 CHIP CHIP
R609 10V 1/16W V_POL 2:11D
H.STATE CLAMP
20
F CHIP
1
1k TIMING R654
1/16W 0
CHIP CHIP
D600 H_POL 2:11D
4
19
V.STATE V.POL
2
1SS355 R649
47 R655
LIMITER R628 1/16W 0
0 R631
18
C606 CLAMPSW H.POL CHIP CHIP
3
R619 0.1 62k
1k 10V CHIP 1/16W
1/16W B RN-CP R643
CHIP
17
GREENIN CLAMP XX
4
CHIP R664
R650 XX
16
GND VCC
5
C615 4.7 47
1/16W
10V F 2012 CHIP JL602
15
R620 C605 6 C/H HD
1k 0.1 R644
1/16W 10V XX
CHIP B
14
Q605 C/H_DET HD
7
CHIP
HN1B01FU-TE85R
D601 LIMITER JL603
IC600
13
V_IN VD
8
AIC1117A-50PYJTR 1SS355 R663

LIMITER R651 0
6V 5V_REG 5V-3 A5V C616
4.7 R647 47
1/16W
12
V_DET VS/S_OUT PC_DTV 2:7G
9
10V 2.2k CHIP CHIP

R627 C610 F 1/16W R674
0 1000p R645 CHIP XX
C607 50V 2012 VTIMING 47k
10
11
JL608 R621 CHIP B GATESW 1/16W

1k 0.1 CHIP
1/16W 10V VS/S_IN
CHIP B 1005
C617
IC604
I O C614 SN74LV00APWR
0.068 10 C621 C622 C624 R648
ADJ 10V 6.3V 10 0.01 100p 220 NOR
R629 R630 B B 6.3V 16V 50V 1/16W
C600 C601 XX XX B B CH CHIP
47 2012
14 13 12 11 10 9
0.1
1
6.3V CHIP 2012 1A VCC
10V CHIP
B
2
1B 4B
3
1Y 4A
R665 R672
0 0
5
4
2A 4Y
CHIP
5
2B 3B
6
2Y 3A
8
GND 3Y
C636 C637
0.1 XX
10V
B
C(6/14)
(SYNC SEP)
VPL-CX70/CX75 6-13 6-13

A B C D E F G H
C (7/14) C (7/14)
3.3V-2 1.8V
3.3V-2 FB700
0uH
3.3V-3 1.8V
R/G/B
GBUS
FB702
GBO[0]
GBO[1]
GBO[2]
GBO[3]
C746
47 0uH C761 C762 C779
6.3V 15p 15p R743 47
50V 50V 1k 6.3V
CH CH
FB701
1/16W
0uH
CHIP
RB704
L703
R740 R741 R745 100
1uH
XX XX R746
1 L702
1uH
10k
1/16W 1/16W 1/16W XX
CHIP CHIP CHIP 1/16W
CHIP
R747
XX
C751 1/16W
FB703
10 X700 CHIP
0uH
6.3V R735 27MHz R751
B R732 C787 XX
XX XX C766 C768 C771 CHIP R758
2012 C748 1/16W 1/16W 0.1 0.1 47
10 CHIP CHIP 10V 0.1 0.1
C744 6.3V C753 R733 C760 C764 B 10V 10V 10V
C720 0.1 0.1 R729 R739 1005 B B B C781 JL709
10V B XX XX 0.1 1M 0.1 47 SCL_PW 8:5D
47 2012 10V 1/16W
1/16W CHIP 10V 1/16W 10V 6.3V
6.3V B B CHIP B CHIP B
C750 C754 R738
0.1 0.1 68
10V 10V 1/16W
B B CHIP
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
JL708
JL710
TAVSSPST
SYSHCLKT
RESETPOL
R715
AVDDPLL
AVSSPLL
DVDDPLL
DVSSPLL
SYSCLKT
GPIOSEL
TAVD33
TESTEN
GPIO23
GPIO22
GPIO26
DGND1
DVDD1
DGND1
DVDD1
GCLKT
TAVDD
TAVSS
VDDQ3
VDDQ3
VDDQ3
XOUT
VSSQ
VSSQ
SDA1
SCL1
VSSQ
VDD1
DBO0
DBO1
DBO2
DBO3
SDA_PW
XIN
SCL
SDA
VSS
8:5D
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
NC
10k
1/16W R759
CHIP 47
GBO[4]
156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105
C724
1
0.1 RTERM DBO4
10V GBO[5]
B
2
R716 DVDD DBO5 RB706
10k 100 GBO[6]
1/16W
3
RX2P DBO6
CHIP GBO[7]
R717
IC700
4
10k RX2M DBO7
AIC1117A-18PYJTR JL711
1/16W
CHIP
GGO[0]
1.8V_REG
5
DGND DGO0
R718 GGO[1]
10k
6
1/16W RX1P DGO1 RB707
I O R719CHIP 100 GGO[2]
10k
7
ADJ 1/16W RX1M DGO2
CHIP GGO[3]
8
DGND DGO3
C705 R720 GGO[4]
47 10k
2
9
1/16W RX0P DGO4
6.3V CHIP GGO[5]
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52
R721 RX0M DGO5 RB708
C700 10k 100 GGO[6]
0.1 1/16WR722 DGND DGO6 C772 0.1
10V CHIP 10k 10V B GGO[7]
B 1/16W RXCP VSSQ
R723CHIP
C727 10k RXCM VDDQ3
0.1 1/16W
10V CHIP RB709
B DVDD DGO7 100
1.8V-3
C729 C728 GRO[0]

C706 R712 0.1 0.1 DGND1 DRO0
3.3k
10 1/16W 10V 10V GRO[1]
B B
6.3V RN-CP DVDD1 DRO1
B GRO[2]
2012 PGND DRO2
GRO[3]
PVD DRO3
L701
1uH FILT VDD1
PVD VSS RB710
C714 C716 C730 C775 0.1 100
0.039 3900p 0.1 10V B GRO[4]
16V 16V 10V PGND DRO4
B B GRO[5]
C731 PVD DRO5
L704 0.1 GRO[6]
1uH 10V PGND DRO6
B GRO[7]
ALVDD DRO7
C715 C732
10 6.3V 0.110V
L700 2012 B B
ALVDD IC701 DFIELD
1uH PW2200B-20L JL703 GVS
ALGND CDEC_ADCONVERTER DVS
JL704 R753 0 CHIP GFBK
ALGND DFBK
C709 JL705 R754 0 CHIP
V_IN 47 6.3V AVDD DHS
3 5:9A AVDD DPEN
JL707
R755 0 CHIP
R756 47 CHIP 1/16W GCLK
GPEN
AGND DCLK
C735 0.1 R757 0 GRE[3]
10V B CHIP
AGND DRE3
GRE[7]
R705 220 C736 0.1 AVDD DRE7
CVBS VIDEO 1/16WCHIP RB711 GRE[6]
10V B 47
RED1 DRE6
C701 R762 GRE[5]
0.22 22
1/16W AGND DRE5
R 10V R706 220 CHIP C737 0.1
B 1608 1/16W CHIP R 10V B GRE[4]
RED2 DRE4
GRE[2]
AVDD DRE2
C717 RB712 GRE[1]
0.047 AGND DRE1 47
10V
B GRE[0]
R707220 C738 0.1 AVDD DRE0
1/16WCHIP 10V B GGE[7]
AGND DGE7
SY Y GGE[6]
GRN1 DGE6
R708 220 RB713 GGE[5]
C702 1/16W CHIP 47 IC703
0.22 C711 R763 SOG1 DGE5
10V
B 0.047 22 GGE[4] AIC1117A-33PYJTR
10V 1/16W AGND DGE4 3.3V_REG
G 1608 B G CHIP GGE[3] 6V
C739 0.1 GRN2 DGE3 3.3V-3
10V B GGE[2]
SOG2 DGE2
RB714 GGE[1]
AVDD DGE1 47
C712 C740 0.1 JL712
1000p 10V B GGE[0]
50V AGND DGE0
B
C704 R709 220 AVDD DBE7 C776 0.1 I O
1/16WCHIP 10V B 1005 ADJ
4 SC
0.22
10V
B 1608 C
AGND VSSQ
GBE[7] C783
0.1 C784
BLU1 VDDQ3 10V 47
C719 R710 R764 GBE[6] B
0.047 220 22 6.3V
10V 1/16W 1/16W AGND DBE6 JL713
B B CHIP B CHIP GBE[5]
BLU2 DBE5
GBE[4]
iTEST_EN
AVDD VBIVALID DBE4

EXTINT2
EXTINT1
EXTINT0
C741
TMDSEN
HDCPEN
SRGBEN
GPIO24
GPIO25
GPIO27
GPIO11
GPIO12
GPIO13
EXTINT
GPIO14
GPIO15
GPIO16
GPIO17
GPIO18
GPIO19
GPIO20
GPIO21
GPIO31
GPIO3
GPIO4
GPIO5
VDDQ3
GPIO6
COAST
CLAMP
VDDQ3
RESET
0.1 RB715
ADR2
ADR5
ADR6
SDA2
SCL2
VSSQ
VSSQ
VDD1
DBE0
DBE1
DBE2
DBE3
10V 47
HS1
VS1
HS2
VS2
DOE
VSS
VSS
B
100
101
102
103
104
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
C765 C769 R752
0.1 0.1 0
10V 10V
JL701 B B CHIP
7 5 3 1 7 5 3 1
R714
XX
CHIP R761 R760 C759 R736 R737
10k 10k 0.1 10k 10k R744
1/16W 1/16W 10V 1/16W1/16W 10k
CHIP CHIP B CHIP CHIP 1/16W
R704 RB701 R730 CHIP
XX 8 6 4 2 8 6 4 2 100 XX R748
CHIP 1/16W 10k
HSYNC CHIP R742 1/16W
XX CHIP
VSYNC RB700 1/16W
100 CHIP RB705
R711 7 5 3 1 7 5 3 1 R750 47
XX 0
CHIP CHIP
6:12D;13:4D HSS
GCOAST
R734
0
CHIP
6:12D;13:6D VSS GBE[1]
GBE[2]
GBE[3]
GBE[0]
5 R724 R726
6:12E CLAMP
R731
0
CHIP
RB702 8
100 6 4 2 8 6 4 2 RB703
100
XX XX JL700
CHIP CHIP
2:5C;8:5D INTERLACE
R725
XX
CHIP
4
NC VSS R749
10k
1/16W
2
VDD CHIP
C(7/14)
5
CD OUT
C763
0.1
10V
B IC702
C767
0.1
10V
C770
0.1
10V TP700
A/D CONV,
S-80928CNMC-G8Y-T2 B B
RESET C DEC.
6-14 6-14 VPL-CX70/CX75
A B C D E F G H
C (8/14) C (8/14)
7:9A
GBUS
3.3V-2
GCOAST CN801
GFBK XX
R/G/B
L800
ROMOEN
ROMOEN
ROMOEN
ROMOEN
RESETN
BOOTWE
IC802
BHENN
D3.3V
D3.3V
D3.3V
D3.3V
VPPEN
1uH R805
FCEN
6.4V
6.4V
6.4V
6.4V
100k CY25033SZC-1T
A10
GND
GND
GND
GND
GND
A15
A13
A11
GND
GND
GND
CS0
CS1
GND
GND
NM1
D14
D12
D10
A19
A18
A17
A16
A14
A12
GND
GND
D15
D13
D11
A8
A6
A4
A2
A0
1/16W
A9
A7
A5
A3
A1
D8
D6
D4
D2
D0
NC
D9
D7
D5
D3
D1
NC
GCLK CHIP SPREAD_SPECTRUM
A10 A11 R813
GCLK GFBK C824 C825 1k
A10
B10
A11
B11
A12
B12
A13
B13
A14
B14
A15
B15
A16
B16
A17
B17
A18
B18
A19
B19
A20
B20
A21
B21
A22
B22
A23
B23
A24
B24
A25
B25
A26
B26
A27
B27
A28
B28
A29
B29
A30
B30
A31
B31
A32
B32
A33
B33
A34
B34
A35
B35
A1
B1
A2
B2
A3
B3
A4
B4
A5
B5
A6
B6
A7
B7
A8
B8
A9
B9
GVS A9 D10 JL802 10 0.1 1/16W
6.3V 10V CHIP
8
GVS GREF B B X800 X1/CLK XOUT
GHS C10 C14 JL804 2012 16.384MHz JL844 5V-1
7
GHS GBLKSPL X'TAL VDD SSON
1
12_D[15]
12_D[14]
12_D[13]
12_D[12]
12_D[11]
12_D[10]
GPEN C830
12_D[9]
12_D[8]
12_D[7]
12_D[6]
12_D[5]
12_D[4]
12_D[3]
12_D[2]
12_D[1]
12_D[0]
B9 A18
12_A[19]
12_A[18]
12_A[17]
12_A[16]
12_A[15]
12_A[14]
12_A[13]
12_A[12]
12_A[11]
12_A[10]
C826 0.1
12_A[9]
12_A[8]
12_A[7]
12_A[6]
12_A[5]
12_A[4]
12_A[3]
12_A[2]
12_A[1]
12_A[0]
3
6
GPENSOG GCOAST 12p C829 10V PD#/OE REFCLK
B10 C9 JL805 50V 12p B
CH 50V
5
GSOG GHSFOUT CH VSS SSCK R814
JL800 1005 XX
1005
GRE[0] CHIP
E4
GRE0 SC_CPU 2:3A
GRE[1] C3
ROMOEN
ROMWEN
RESETN
BOOTWE
GRE1
BHENN
VPPEN
FCEN
GRE[2] B1
CS0
CS1
NMI
GRE2 JL816
GRE[3] F4
GRE3
GRE[4] C2
GRE4 9:1F;2:7H;9:2G
GRE[5] C1 PW_OUT3
GRE5 R815
GRE[6] D3 22
GRE6 1/16W
RXD 1 CHIP
GRE[7] D2 IC801 RESETN (TO P13)
GRE7
GND 2 S-80928CNMC-G8Y-T2 R842 PPW_OUT1
RESET IC805 R841 47
GGE[0] TXD 3 47 1/16W
C11 TC7SA04FU(TE85R)
MUTE_SC,RXD_SC,TXD_SC
GGE0 1/16W CHIP
CN800 INVERT CHIP JL839
3
GGE[1] B12 NC VSS R806 J17 PW_DCLK
GGE1 XX 10k DCLK
R/G/B
1/16W
2
JL840
5
GGE[2] B11 VDD CHIP C834 C20 PW_DVS
GGE2 0.1 JL845 12_A[0] DVS
10V Y11 U4 FB802 IC803
1
CD
2
GGE[3] A8 OUT B RESET A0 0uH D18 PW_DHS
GGE3 C823 12_A[1] MBM29LV800TA-70PFTN-768PW DHS
0.1 C827 C828 R807
100 JL824 E5 T4 8M FLASH ROM
N19 R843 JL841
4
GGE[4] B8 10V 0.1 XX MCKEXT A1
GGE4 B 10V 10V 1/16W
CHIP D6 V3 12_A[2] DEN 47
GGE[5] B B X801 DCKEXT A2 JL837 1/16W
C8 CHIP
GGE5 16.384MHz A3 U3 12_A[3] 12_A[16] 12_A[17]
R826
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25
PPW_DRE[2]
1
GGE[6] A7 10M X1 A3 A15 A16 V19
GGE6 1/10W C5 Y1 12_A[4] 12_A[15] DRE0
CHIP PPW_DRE[3]
2
GGE[7] X0 A4 A14 BYTE#
B7
GGE7 W2 12_A[5] 12_A[14] DRE1
Y20
PPW_DRE[4] 2
3
A5 A13 VSS R16
RXD_SC Y12 T3 12_A[6] 12_A[13] 12_D[15] DRE2
PPW_DRE[5]
4
GBE[0] B18 RXD A6 A12 DQ15/A-1 U19
GBE0 13:3D;13:3G; TXD_SC V12 V2 12_A[7] 12_A[12] 12_D[7] DRE3
PPW_DRE[6]
5
GBE[1] A20 13:4D;13:6D TXD A7 A11 DQ7 R18
GBE1 V_PORT R809 R812 U2 12_A[8] 12_A[11] 12_D[14] DRE4
4.7k PPW_DRE[7]
6
GBE[2] B17 4.7k A8 A10 DQ14 W20
GBE2 1/16W 1/16W 12_A[9] 12_A[10] 12_D[6] DRE5
CHIP CHIP JL823 V11 W1
PPW_DRE[8]
7
GBE[3] A19 IRRCVR0 A9 A9 DQ6 V20
GBE3 C835 R827 W11 R4 12_A[10] 12_A[9] 12_D[13] DRE6
R818 0.1 PPW_DRE[9]
8
GBE[4] B16 100 10V 10k IRRCVR1 A10 A8 DQ13 U20
GBE4 1/16W B 1/16W V1 12_A[11] 12_D[5] DRE7
CHIP CHIP
9
GBE[5] A17 MS_VCLK E1 A11 NC DQ5
GBE5 VCLK 1005 V13 P4 12_A[12] 12_D[12]
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
GBE[6] A16 MS_VPEN N2 7:10B SDA_PW PORTA0 A12 NC DQ12 T19 PPW_DGE[2]
GBE6 VPEN W13 R3 12_A[13] ROMWEN 12_D[4] DGE0
GBE[7] A15 MS_V E3 7:10B SCL_PW PORTA1 A13 WE# DQ4 C846 T20 PPW_DGE[3]
GBE7 VVS R816 GND_1 BOOTWE 12_A[14] 0.1 DGE1
XX Y13 T2 10V
MS_H F3 R810 1/16W PORTA2 A14 RP# VCC R19 PPW_DGE[4]
VHS 100 CHIP 12_A[15] C838 12_D[11] B DGE2
Y14 U1 0.1 1005
GRO[0] A6 D1 1/16W PORTA3 A15 NC DQ11 R20 PPW_DGE[5]
2:9B CHIP 10V
GRO0 VFIELD W14 T1 12_A[16] B 12_D[3] DGE3
GRO[1] C7 GND_1 PWFMBSY PORTA4 A16 NC DQ3 M18 PPW_DGE[6]
GRO1 INTERLACE Y15 R2 12_A[17] 12_D[10] DGE4
GRO[2] B6 VR[0] E2 MUTE_SC PORTA5 A17 RY/BY DQ10 P18 PPW_DGE[7]
GRO2 VR0 2:5C;7:3H W15 R1 12_A[18] 12_A[19] 12_D[2] DGE5
BHENN,BOOTWE,CS0,CS1,FCEN,NMI,RESETN,ROMOEN,ROMWEN,VPPEN
GRO[3] A5 VR[1] F1 PORTA6 A18 NC DQ2 P19 PPW_DGE[8]
GRO3 VR1 R808 R811 R817 VPPEN V15 P3 12_A[19] 12_A[18] 12_D[9] DGE6
GRO[4] VR[2] 100 100 10k PPW_OUT2 PORTA7 A19 A17 DQ9 PPW_DGE[9]
D7 F2 1/16W 1/16W 1/16W P20
GRO4 VR2 CHIP CHIP 12_A[8] 12_D[1] DGE7
GRO[5] VR[3] CHIP A7 DQ1
B5 G3
GRO5 VR3 R17 V10 12_D[0] 12_A[7] 12_D[8]
GRO[6] C6 VR[4] G2 JL826 PORTB0 D0 A6 DQ8 M17 PPW_DBE[2]
GRO6 VR4 W18 Y10 12_D[1] 12_A[6] 12_D[0] DBE0
GRO[7] A4 VR[5] H3 JL827 PORTB1 D1 A5 DQ0 N20 PPW_DBE[3]
GRO7 VR5 V18 Y9 12_D[2] 12_A[5] ROMOEN DBE1
VR[6] H2 JL828 PORTB2 D2 A4 OE# M20 PPW_DBE[4]
GGO[0] C13
GGO0
VR[7] G1
VR6
VR7
JL829 Y18
U18
PORTB3 D3
W9
V9
12_D[3]
12_D[4]
12_A[4]
12_A[3]
A3 VSS
FCEN
DBE2
DBE3
L17 PPW_DBE[5] 3
GGO[1] B15 JL830 PORTB4 D4 A2 CE# M19 PPW_DBE[6]
GGO1 Y19 Y8 12_D[5] 12_A[2] 12_A[1] DBE4
GGO[2] VG[0] JL831 PORTB5 D5 A1 AQ PPW_DBE[7]
A14 J4 K17
GGO2 VG/Y/U0 W19 W8 12_D[6] DBE5
GGO[3] VG[1] SIGCH_FLAG JL832 PORTB6 D6 PPW_DBE[8]
B14 H1 2:10F L19
GGO3 VG/Y/U1 T18 V8 12_D[7] DBE6
GGO[4] A13 VG[2] J3 PORTB7 D7 L20 PPW_DBE[9]
GGO4 VG/Y/U2 W7 12_D[8] DBE7
GGO[5] C12 VG[3] J2 D8
GGO5 VG/Y/U3 JL821 T17 U8 12_D[9] R838
GGO[6] VG[4] PORTC0 D9 2.2k
B13 J1 1/16W K19
GGO6 VG/Y/U4 JL822 V16 V7 12_D[10] CHIP DRO0
GGO[7] A12 VG[5] K3 PORTC1 D10 K20
GGO7 VG/Y/U5 PPW_DBE[0] W16 W6 12_D[11] DRO1
VG[6] K2 PORTC2 D11 K18
VG/Y/U6 PPW_DBE[1] Y16 Y6 12_D[12] DRO2
GBO[0] C18 VG[7] K1 PORTC3 D12 J20
GBO0 VG/Y/U7 PPW_DGE[0] V17 V6 12_D[13] DRO3
GBO[1] E17 PORTC4 D13 J18
GBO1 PPW_DGE[1] U17 U7 12_D[14] DRO4
GBO[2] C17 VB[0] L2 PORTC5 D14 J19
GBO2 VB/UV/V0 PPW_DRE[0] W17 U6 12_D[15] DRO5
GBO[3] B19 VB[1] L1 PORTC6 D15 H20
GBO3 VB/UV/V1 PPW_DRE[1] Y17 DRO6
GBO[4] E16 VB[2] L3 PORTC7 H19
GBO4 VB/UV/V2 R819 W3 JL835 DRO7
GBO[5] C16 VB[3] L4 XX RD
GBO5 VB/UV/V3 CHIP JL817 P1 Y3 JL836
GBO[6] C15 VB[4] M3 CPUTMS WR H18
GBO6 VB/UV/V4 JL818 Y2 W12 BHENN DGO0
GBO[7] D14 VB[5] M1 CPUTCK BHEN H17
GBO7 VB/UV/V5 JL819 M4 V5 ROMOEN DGO1
VB[6] N1 CPUDI ROMOE G20
VB/UV/V6 JL820 N3 W4 ROMWEN DGO2
VB[7] M2 CPUDO ROMWE G19
VB/UV/V7 W5 JL833 DGO3
IC800
R820
XX U16
MODE0
RAMOE
RAMWE
Y5 JL834R835
XX DGO4
G18 4
PW463A-10VL CHIP CHIP F20
R821 N4 V4 CS0 DGO5
3.3V-2 SCAN_CONVERTER 10k MODE1 CS0
2.5V 1/16W F19
R822 CHIP T5 Y4 CS1 DGO6
IC800 XX MODE2 CS1 Q801 F18
PW463A-10VL CHIP R836 DGO7
R823 P2 U10 XX FB805 XX
SCAN_CONVERTER 10k MODE3 EXTINT XX
IC807 1.55V 1/16W W10 CHIP NMI
IC806 CHIP
1 2 3 4
8 7 6 5
R801 AIC1084-PEJTR NMI E20
S1 S2 S3 G
D4 D3 D2 D1
10k TK11125CSCL-G 1.55V_REG R824 R834 2.5V DBO0
1/16W XX U15 XX
RN-CP 2.5V_REG CHIP ADR24B R840
XX E19
JL842 B20 CHIP FB804 DBO1
I O R825 DN1 0uH E18
C805
1
0.1 ADJ R803 0 C19 DBO2

B 10V 470 DN2 F17
1005 C821 1/16W CHIP
2
0.1 CHIP V14 R833 DBO3

JL843 C822 DN3 10k
1.55V 10V 47 D20
3
B R828 R830 R832 1/16W DBO4

1005 6.3V 0 0 0 CHIP
R802 R804 CHIP CHIP C836 D19
220 220 CHIP 0.1 FB803 R844 DBO5
C807 C816
0.1 C819 1/16W 1/16W R829 R831
XX 10V 0uH XX
D16
0.1 47 CHIP CHIP XX B
B 10V 10V 6.3V R837 DBO6
1005 B C837 C840 C842 220
0.1 0.1 0.1 D17
IC800 10V 10V 10V 1/16W Q800 DBO7
PW463A-10VL B B B CHIP
SCAN_CONVERTER XX R845
C832 C833 C844 0
FB801 10
0uH 0.1 0.1 6.3V CHIP
10V 10V B
B B 2012
C831
10 IC800
6.3V
JL815
B
C839 C841 C843
PW463A-10VL
2012 SCAN_CONVERTER
0.1 0.1 0.1 C848 C850 C852 C854 C856
10V 10V 10V 0.1 0.1 0.1 0.1 0.1
B B B 10V 10V 10V 10V 10V
B B B B B
C845
10 5
N15
T10
T11
T12
T13
T14
T15
P16
N16
K16
H16
F16
E15
E14
E13
E12
E11
E10
P15
R13
R14
R15
U11
U13
T16
M16
L16
J16
G16
G15
F15
F14
H5
J5
K5
L5
N5
P5
T6
T7
T9
E9
E7
N6
P6
B4
C4
U9
A2
U5
F5
G5
M5
T8
E8
E6
F6
G6
R6
R7
R8
F7
6.3V
B
2012
VCC2.5V
VCC2.5V
VCC2.5V
VCC2.5V
VCC2.5V
VCC2.5V
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD1.5
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VDD3.3
VPP1
VPP2
FB800
0uH
R839 C847 C849 C851 C853 C855
C801 C803 C806 C809 C811 C813 C815 C818 XX 0.1 0.1 0.1 0.1 0.1
0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 10V 10V 10V 10V 10V
10V 10V 10V 10V 10V 10V 10V 10V B B B B B
B B B B B B B B
ALL resistors are in ohms, W
unless otherwise noted.
C
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
ALL capacitors are in uF(p;pF)

(8/14)
C800 R800 C802 C804 C808 C810 C812 C814 C817 C820 IC800 (SCAN CONVERTER)
N18
L18
U12
U14
P17
N17
G17
D15
D13
D11
D12
K11
N10
N11
N12
N13
M13
L13
K13
J13
H13
H12
H11
H10
M10
M11
M12
L12
K12
J12
J11
J10
K10
L10
L11
10 XX unless otherwise noted.

A1
Y7
B2
B3
D4
G4
H4
K4
D9
D8
D5
R5
H8
J8
K8
L8
M8
N8
N9
H9
J9
K9
L9
M9
6.3V 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 (5/5) PW463A-10VL
B 10V 10V 10V 10V 10V 10V 10V 10V
2012 B B B B B B B B SCAN_CONVERTER
VPL-CX70/CX75 6-15 6-15

A B C D E F G H
C (9/14) C (9/14)
R 5V-2
DA_R 11:2B
(TO P13)
PW_OUT1
FB901
PW_OUT2 C938 0uH
0.1
R/G/B
PW_DRE[9] 10V TG_R
G B
1A;2F;13:11A DA_G 10:2B
RB900 R934
47 IC906 0 11:2E
P1 P133 R[9] 3.3V-2
RIN9 ROUT9 SN74AHCT541PWR CHIP TG_G
2
P2 P132 R[8] LEVEL_CONV_BUFF
RIN8 ROUT8
4
PW_DRE[9] R[7] 10:2E TG_B
20 19 18 17 16 15 14 13 12 11
P3 P131
1
RIN7 ROUT7 G1 VCC
6
DCK1
1 PW_DRE[8] P5 P130 R[6] RB913
2
RIN6 ROUT6 A1 G2 47 12:5E
8
DCK2 DCK1_R
7
PW_DRE[7] P6 P128 R[5]
3
RIN5 ROUT5 A2 Y1
2
DCK3 DCK2_R
5
PW_DRE[6] P7 P127 R[4] RB901
4
B A3 Y2
RIN4 ROUT4 47 DA_B
4
12:2B DCK4 JL927 DCK1_G
3
PW_DRE[5] P10 P126 R[3]
5
RIN3 ROUT3 A4 Y3
6
DCK5 JL928 DCK2_G
1
PW_DRE[4] P11 P123 R[2]
6
RIN2 ROUT2 A5 Y4
1.8V
8
R921 R924 R925 DCK6 DCK1_B
7
PW_DRE[3] P12 P122 4.7k 4.7k
7
RIN1 ROUT1 4.7k 1/16W 1/16W A6 Y5
1/16W CHIP LCDCLR DCK2_B
5
PW_DRE[2] P13 P121 CHIP CHIP
8
RIN0 ROUT0 R[1] A7 Y6
RB902 JL929 CLR
3
PW_DRE[1] P14 P120 C920
9
GND NC R[0] 47 FB900 A8 Y7
47 0uH GCFB_B 12:7E R933
1
6.3V XX
10
PW_DRE[0] P15 P119 G[9] GND Y8
GND NC GCFB_G 10:8E
6
P16 P118 G[8] RB914
GIN9 GOUT9 L900 47
1uH GCFB_R 11:7E
8
P17 P117 C931
GIN8 GOUT8 RB903
EMI
PW_DGE[9] G[7] FL900 47
P18 P114 47
G
GIN7 GOUT7 6.3V
2
PW_DGE[8] P19 P113 G[6]
GIN6 GOUT6
4
PW_DGE[7] P22 P112 G[5]
GIN5 GOUT5
EMI
PW_DGE[6] P23 P111 G[4] FL902 P173 P139 JL903
G
GIN4 GOUT4 SOUT1 SHST R944 47
C929
8
PW_DGE[5] G[3] P174 P164 1/16W CHIP LCDHST
P24 P110 47 SOUT2 HST
GIN3 GOUT3 6.3V
2
PW_DGE[4] P25 P109 G[2] P175 P167 JL904
GIN2 GOUT2 SOUT3 PST R935 47 C939
4
PW_DGE[3] G[1] FL901 P176 P149 1/16W CHIP LCDHCK1 0.1
P26 P108 CTRL HCK1 B 10V
GIN1 GOUT1 5 R936 47
EMI
PW_DGE[2] G[0] P150 1/16W CHIP LCDHCK2
P27 P107
G
GIN0 GOUT0 HCK2
R920
7
8
RB904 0 P151 DCK1
2 PW_DGE[1] P28 P104 47 DCK1 IC907
1
2
GND NC R906 R907 CHIP
47 47 C930 0.1 P152 DCK2 TC74VHCT540AFT(EL)
PW_DGE[0] P29 P103 DCK2
1/16W 1/16W B 10V P45 P46 LEVEL_CONV_INV_BUFF
3
4
GND NC VDDA VSSA RB915 DCK3
CHIP CHIP B[9] C921 0.1 P153 47
P31 P102 P4 P9 DCK3
5
6
BIN9 BOUT9 B 10V VDD VSS DCK4
20 19 18 17 16 15 14 13 12 11
P154
1
P32 P101 B[8] C922 0.1 DCK4 G1 VCC
P30 P21
7
8
BIN8 BOUT8 B 10V VDD VSS DCK5 RB907
P156
2
PW_DBE[9] P35 P100 B[7] C923 0.1 A1 G2 47
8
BIN7 BOUT7 P58 P34 DCK5 R938 47 R937 47

B 10V VDD VSS DCK6 DCK1X_R
P157 1/16W CHIP 1/16W CHIP
3
PW_DBE[8] P36 P99 B[6] C924 0.1 A2 Y1
2
6
BIN6 BOUT6 B 10V P78 P57 DCK6 DCK2X_R

RB905 VDD VSS P158 LCDFRP
4
PW_DBE[7] P37 P98 47 B[5] C925 0.1 A3 Y2
4
4
BIN5 BOUT5 P92 P70 FRP JL916

B 10V VDD VSS DCK1X_G
P140
5
PW_DBE[6] P38 P95 B[4] C926 0.1 JL905 A4 Y3
6
2
BIN4 BOUT4 P129 P76 XFRP JL917

B 10V VDD VSS RGT_3.3 DCK2X_G
P170
6
PW_DBE[5] P39 P94 B[3] C927 0.1 A5 Y4
8
8
BIN3 BOUT3 P138 P82 RGT DCK1X_B

B 10V VDD VSS RGTX_3.3
P141
7
PW_DBE[4] P40 P93 B[2] C928 0.1 A6 Y5
2
6
BIN2 BOUT2 P168 P87 XRGT R939 47 DCK2X_B

B 10V VDD VSS LCDENB
P144 1/16W CHIP
8
PW_DBE[3] P41 P91 B[1] A7 Y6
4
4
BIN1 BOUT1 C902 0.1 P8 P97 ENB R940 47 JL918

B 10V VDE VSS P165 1/16W CHIP LCDPCG DWN 10:7D;11:6D;
9
PW_DBE[2] P42 P90 B[0] A8 Y7
6
2
BIN0 BOUT0 C903 0.1 P20 P106 PCG 12:6D

B 10V VDE VSS LCDPRG
10
P43 P89 P166 GND Y8
7
PW_DBE[1]
8
GND NC RB906 C904 0.1 P33 P116 PRG R941 47
47 B 10V VDE VSS P136 1/16W CHIP LCDVST RB908
PW_DBE[0] P44 P88 C905 0.1 P54 P125 VST
GND NC B10V R942 47 47
VDE VSS P137 1/16W CHIP LCDVCK
P60 C906 0.1 P63 P135 VCK
ROSD1 B 10V VDE VSS LCDDWN
P59 P169
ROSD0 C907 0.1 P71 P148 DWN
B 10V VDE VSS P159
P62 C908 XX P75 P160 HD1 JL906
GOSD1 B 10V VDE VSS
P61 P161 JL907
GOSD0 C909 0.1 P81 P172 HD2
B 10V VDE VSS P162
P65 C910 0.1 P86 HD3 JL908
BOSD1 B 10V VDE P146 JL909
3 P64
P56
BOSD0 C911 0.1
B 10V
P96
VDE
PO1
P147 JL910
YS C912 0.1 P105 PO2
B 10V VDE P142
P55 C913 0.1 P115 CLP JL911
YM B 10V VDE LCDCLR
P143
C914 0.1 P124 CLR
B10V VDE R943 47
1/16W CHIP
C915 0.1 P134 RGTX_3.3
B 10V VDE 10:3A
C916 0.1 P145
IC900 B 10V VDE
C917 0.1 P155 R930 RGT_3.3
CXD3536R B 10V VDE IC900 XX
11:3A;12:3A
1/4 3D GAMMA_TG C918 0.1 P163 CXD3536R C937
0.1
B 10V VDE 4/4 3D GAMMA_TG
C919 0.1 B 10V
R900 R901 P171
10k 10k B 10V VDE
1/16W 1/16W
CHIP CHIP
R927
0
Q902 IC905
XX SN74AHCT541PWR
IC908 CHIP LEVEL_CONV_BUFF
TC7WH125FK(TE85R) IC900
OSD_SW CXD3536R
3/4 3D GAMMA_TG
20 19 18 17 16 15 14 13 12 11
1
G1 VCC
RGTX_3.3 RB909
2
A1 G2 47
PW_OSD_EN RGT_3.3 JL912
7
RGTX 10:8D
1
3
2:5C G1 VCC A2 Y1
JL913
5
RGT 11:7D;12:7D
4
PW_DRE[9] A3 Y2
LCDHCK1 JL914
2
A1 G2 C900 HCK1_R
3
1A;2A;13:11A
5
0.1 A4 Y3
B10V HCK1_G
1
3
6
Y2 Y1 A5 Y4
4 HCK1_B
7
7
A6 Y5
JL915
4
GND A2 LCDHCK2 HCK2_R
5
8
A7 Y6
HCK2_G
3
9
A8 Y7
PW_OUT3 HCK2_B
1
10
R918 GND Y8
8:12B;2:7H; Q900 R928
2G R915 2.2k 4.7k
R908 R910 XX 2SC4081T106R 1/16W 1/16W RB910
XX XX
CHIP
CHIP SW CHIP CHIP 47
CHIP
R912 47 1/16WCHIP R917 R926
P72 P83 MCLK_R 11:2B 100 1k R932 LCDFRP
CLKSEL CLKOUT1 1/16W 1/16W 47
P74 P84 R913 47 1/16WCHIP CHIP CHIP 1/16W LCDPRG
CLKPOL CLKOUT2 MCLK_G 10:2B CHIP
PW_DCLK P73 P85 R914 471/16WCHIP R929 C936
CLKC CLKOUT3 MCLK_B 12:2B R919 4.7k 0.1
10k 1/16W R931 B 10V
PW_DHS P66 P47 1/16W CHIP 47
HDIN PLLDIV CHIP 1/16W
PW_DVS P67 P48 CHIP
VDIN PLLSTB
P52 P49
2:7H;8:12B; R911 XCLR2 TRST R916 R922
PW_DVS 1F R909
0 0 P53 P50 0 1k
20 19 18 17 16 15 14 13 12 11
4
1
CHIP CHIP XCLR3 TEST1 CHIP NC VSS 1/16W G1 VCC
4
NC VSS CHIP
P69 P51
2
I2C_400K
2
HSEL TEST2 VDD A1 G2
2
2:5G VDD 8 7 6 5 R945 22 CHIP1/16WJL919 FRP

P68 P80
5
3
HSCL RSCL CD OUT A2 Y1
5
VCC
SCL
SDA
WP
R902 CD OUT LCDHST R946 22 CHIP 1/16WJL920 PRG
47 P77 P79 R923 C935
4
1/16W HSDA RSDA C941 47k A3 Y2
CHIP IC901 C934 0.1 0.1 LCDENB R947 0 CHIP JL922 HST
SDA_400K S-80928CNMC-G8Y-T2
C932 IC902 0.1 10V 1/16W B 10V
5
0.1 S-80928CNMC-G8Y-T2 B10V B CHIP A4 Y3
C901 RESET R948 0 CHIP JL921
VSS
B 10V LCDVCK ENB
RESET
A0
A1
A2
0.01 1005
6
B16V A5 Y4
R903 C933 LCDVST JL924 VCK
7
47 S900 0.1
7
5 1/16W
CHIP JL902
B 10V 1 2 3 4 LCDPCG
A6 Y5
JL923 VST
5
SCL_400K
8
A7 Y6
IC900 C940 LCDDWN JL925 PCG
Q901
3
0.1
9
CXD3536R 10V A8 Y7
2/4 3D GAMMA_TG B HN1B01FU-TE85R JL926
1
10
RES_SW GND Y8 DWNX TG
R904 1005
47 IC903 XX 10:2E;11:2E;
3.3V 1 1/16W HN58X24256FPIZ RB912
IC904 TP900 47 12:2E
JL900 CHIP EER_ROM
W SCL 2 SN74AHCT541PWR
JL901 LEVEL_CONV_BUFF
W SDA 3
GND 4
R905
CN900
4P
LUT
47
1/16W
CHIP C(9/14)
(3D GAMMA)
6-16 6-16 VPL-CX70/CX75
A B C D E F G H
C (10/14) C (10/14)
3.3V-2
JL1000
9:9E RGTX_3.3
L1000 C1002
1uH
47
6.3V C1007 C1009
R1009 0.1 47
10k 50V 25V
C1003 1/16W B
0.1
10V CHIP 2012 1
B
R1018R1019
9:4G MCLK_G 0 0
CHIP CHIP L1002
L1001
1uH 1uH
P33 FRP
P32 PRG
C1012
47
P36
P35
P34
P31
P30
P29
P28
P27
P26
P25
G 25V
DA_G
9:4A 36 35 34 33 32 31 30 29 28 27 26 25 C1011 0.1
50V B 2012 C1018
STATUS
FRINV
DGND
DIRC
AGND
AGND
AGND
0.1
VDD
CLK
FRP
PRG
VCC
50V
B
RB1001 2012
G[9] P37 P24 22
37 D_IN9 SIF_OUT 24
G[8] P38 P23 1 N.C.
38 D_IN8 PVCC 23 VCOM_OUT_G
2
G[7] P39 P22 JL1002 VID_G[1] 2 VCOMR
39 D_IN7 SIG_OUT1 22 JL1005
4
G[6] P40 P21 VID_G[2] 3 PSIG
40 D_IN6 SIG_OUT2 21
6
G[5] P41 P20 VID_G[3]
JL1006
4 VSSGR 2
41 D_IN5 SIG_OUT3 20 VID_G[1]
8
G[4] P42 IC1002 P19 5 VSIG1
42 D_IN4 PGND 19 RB1002 VID_G[2]
G[3]
CXA7005R-T4 22
6 VSIG2
P43 LCD_DRIVER P18
43 D_IN3 PGND 18 Q1001 VID_G[3]
2
G[2] P44
(G) P17 VID_G[4] HN1B01FU-TE85R 7 VSIG3
44 D_IN2 SIG_OUT4 17 BUFFER VID_G[4]
4
G[1] P45 P16 VID_G[5] 8 VSIG4
45 D_IN1 SIG_OUT5 16 VID_G[5] C1016
6
G[0] VID_G[6] R1012 0.1 9 VSIG5
P46 P15 2.2k 50V
46 D_IN0 SIG_OUT6 15 C1013 1/16W VID_G[6] B
8
P47 P14 0.1 CHIP 10 VSIG6
47 DGND PVCC 14 50V
P48 P13 VCOM_OUT_G B 11 HVDD
48 DGND VCOM_OUT 13 2012 DCK1_G
C1010 R1013
10 12 DCK2
ADDR0
ADDR1
REFIN
SIG_C
0.1
DGND
DGND
SENB
SCLK
SDAT
AGND
AGND
50V 1/16W DCK1X_G
VCC
B CHIP 13 DCK2X
2012 R1010 DCK2X_G
100 14 DCK1X
1 2 3 4 5 6 7 8 9 10 11 12 1/16W DCK2_G
CHIP
15 DCK1
P10
P11
P12
2:11D PDRV_SCLK
P1
P2
P3
P4
P5
P6
P7
P8
P9
R1014 HCK2_G
IC1001 10 16 HCK
TC7WH34FU(TE12R) 1/16W HCK1_G
BUS BUFF 7 5 3 1
CHIP 17 HCKX 3
Q1000 9:11F RGTX
HN1B01FU-TE85R 18 RGT
2:8B PDRV_SENB
1
BUFFER HST
RB1000 19 HST
22
2
R1011 20 HVSS
PDRV_SDAT 2.2k
2:10F C1017
3
8 6 4 2 1/16W
CHIP 47 21 VSSGL
25V
4
22 VVSS
R1006 R1008 JL1001 ENB
10k 10k 23 ENB
1/16W 1/16W
CHIP CHIP VCK
R1005 R1007 24 VCK
C1000 XX 10k VST
0.1 1/16W 1/16W 25 VST
B 10V CHIP CHIP
1005 9:11D;11:6D; DWN 26 DWN
12:6D CLR
SCLK
SDAT
SENB
SENB
SCLK
SDAT
27 CLR
PCG
C1019 28 PCG
3LINESBUS 0.1
11:2D;12:2D 50V 29 SOUT
B
2012
30 VVDD 4
31 VCOML
GCFB_G
9:7B 32 GCFB
9:12A TG_G R1017
47 CN1000
9:12H;11:2E; TG 1/16W 32P
12:2E CHIP
15.5V 15.5V
IC1000 C1014 C1015

PQ20WZ1UJ00H JL1003 2:4D PANEL_TEMP TH1000 47 0.1
17V 15.5V REG 25V 50V
B
GND
C1004 2012 XX
0.1 IC1003 13.5V-2 TP1004
50V TK11900MTL
B 13.5V REG 13.5V
2012
1
C1005 JL1004
0.1
50V
B
2
1 2 3 4 5
2012
5
3
R1001
1k
1/16W
RN-CP
R1002
15k
1/16W
RN-CP
C (10/14)
(LCD DRIVER (G))
R1000 R1003 R1004 C1008
3.3k 15k 150k 0.1
1/16W C1001 1/16W 1/16W C1006 50V
RN-CP 47 RN-CP CHIP
25V 47 B
25V 2012
JL1018
VPL-CX70/CX75 6-17 6-17

A B C D E F G H
C (11/14) C (11/14)
3.3V-2 15.5V
1
L1100
1uH
C1100 RGT_3.3
47 9:9E;12:3A JL1100
6.3V C1102 C1103
0.1 47
R1104 50V 25V
10k B
C1101 1/16W 2012
0.1 CHIP
10V
B
9:4G MCLK_R R1110 R1111 L1101 L1102

0 0 1uH 1uH
CHIP CHIP
C1105
47
P33 FRP
P32 PRG
25V
P36
P35
P34
P31
P30
P29
P28
P27
P26
P25
R 13.5V-2
9:4A DA_R
36 35 34 33 32 31 30 29 28 27 26 25
C1110
STATUS
FRINV
DGND
DIRC
AGND
AGND
AGND
VDD
CLK
FRP
PRG
VCC
C1106 0.1
0.1 50V
2 50V
B
B
2012
R[9] P37 P24 2012
37 D_IN9 SID_OUT 24 RB1101
R[8] P38 P23 22 1 N.C.
38 D_IN8 PVCC 23 VCOM_OUT_R
2
R[7] P39 P22 JL1101 VID_R[1] 2 VCOMR
4
R[6] P40 P21 VID_R[2] 3 PSIG
6
R[5] P41 P20 VID_R[3] 4 VSSGR
41 D_IN5 SIG_OUT3 20 VID_R[1] JL1104
8
R[4] P42 IC1100 P19 5 VSIG1
42 D_IN4 PGND 19 RB1102 VID_R[2]
CXA7005R-T4 22
R[3] P43 LCD_DRIVER P18 Q1101 6 VSIG2
43 D_IN3 PGND 18 VID_R[3]
2
R[2] P44
(R) P17
HN1B01FU-TE85R 7 VSIG3
VID_R[4] BUFFER
44 D_IN2 SIG_OUT4 17 VID_R[4]
4
R[1] P45 P16 VID_R[5] 8 VSIG4
45 D_IN1 SIG_OUT5 16 VID_R[5]
6
R1107
R[0] P46 P15 VID_R[6] 2.2k C1111 0.1 9 VSIG5
46 D_IN0 SIG_OUT6 15 1/16W VID_R[6]
8
C1107 CHIP 50V B 2012
P47 P14 0.1 10 VSIG6
47 DGND PVCC 14 50V
P48 P13 VCOM_OUT_R B 11 HVDD
3 48 DGND ADDR0 VCOM_OUT 13
C1104 2012 R1108
10
DCK2_R
12 DCK2
ADDR1
REFIN
SIG_C
0.1
DGND
DGND
SENB
SCLK
SDAT
AGND
AGND
1/16W DCK2X_R
VCC
50V CHIP 13 DCK2X
B R1105 DCK1X_R
2012 100 14 DCK1X
1 2 3 4 5 6 7 8 9 10 11 12 1/16W DCK1_R
CHIP
P10
P11
P12
15 DCK1
P1
P2
P3
P4
P5
P6
P7
P8
P9
HCK1_R
16 HCK
R1109 HCK2_R
10 17 HCKX
1/16W
7 5 3 1 CHIP 9:11F;12:7D RGT 18 RGT
HST
Q1100 19 HST
RB1100
R1106
HN1B01FU-TE85R
22 2.2k BUFFER 20 HVSS
1/16W
8 6 4 2 CHIP 21 VSSGL
C1112
47
JL1102 25V 22 VVSS
R1101R1103 ENB 23 ENB
10k 10k
1/16W1/16W VCK
4 CHIP CHIP 24 VCK
SENB
SCLK
SDAT
R1100R1102 VST
10k XX 25 VST
1/16W1/16W
10:1D;12:2D 3LINESBUS CHIP CHIP 9:11D;10:7D; DWN 26 DWN
12:6D CLR
27 CLR
PCG
C1113 28 PCG
0.1
50V 29 SOUT
B
2012
30 VVDD
31 VCOML
9:12A TG_R 9:7B GCFB_R 32 GCFB
R1112
47
TG 1/16W CN1100
9:12H;10:2E; CHIP 32P
12:2E
C1108 C1109
5 47
25V
0.1
50V XX
B TP1102
2012
C (11/14)
(LCD DRIVER (R))
6-18 6-18 VPL-CX70/CX75
A B C D E F G H
C (12/14) C (12/14)
JL1200 15.5V
3.3V-2
RGT_3.3
9:9E;11:3A 1
L1200 C1200
1uH 47 C1202 C1203
6.3V C1214 C1215 0.1 47
2p 2p 50V 25V
R1211 50V 50V R1204
0 CK CK 10k B
1/16W
C1201 CHIP 1005 1005 CHIP 2012
0.1
10V
B
9:4G MCLK_B L1201 L1202

1uH 1uH
P33 FRP
R1210 C1205
P32 PRG
0 47
B 25V
P36
P35
P34
P31
P30
P29
P28
P27
P26
P25
9:4B DA_B CHIP
36 35 34 33 32 31 30 29 28 27 26 25
C1206 C1212
STATUS
FRINV
DGND
DIRC
AGND
AGND
AGND
VDD
CLK
FRP
PRG
VCC
0.1 0.1
50V 50V
B B
B[9] P37 P24 2012
RB1201
22
2012 2
37 D_IN9 SID_OUT 24
B[8] P38 P23 1 N.C.
38 D_IN8 PVCC 23 VCOM_OUT_B
2
B[7] P39 P22 JL1201 VID_B[1] 2 VCOMR
4
B[6] P40 P21 VID_B[2] 3 PSIG
6
B[5] P41 P20 VID_B[3] 4 VSSGR
41 D_IN5 SIG_OUT3 20 VID_B[1] JL1204
8
B[4] P42 P19 5 VSIG1
42 D_IN4 IC1200 PGND 19 RB1202 VID_B[2]
CXA7005R-T4 22
B[3] P43 P18 6 VSIG2
43 D_IN3 LCD_DRIVER PGND 18 VID_B[3]
2
B[2] P44 (B) P17 VID_B[4] 7 VSIG3
44 D_IN2 SIG_OUT4 17 VID_B[4]
4
B[1] P45 P16 VID_B[5] 8 VSIG4
45 D_IN1 SIG_OUT5 16 Q1201 VID_B[5]
6
R1207
B[0] P46 P15 VID_B[6] 2.2k HN1B01FU-TE85R C1210 0.1 9 VSIG5
46 D_IN0 SIG_OUT6 15 C1207 1/16W BUFFER VID_B[6]
8
0.1 CHIP 50V B 2012
P47 P14 10 VSIG6
47 DGND PVCC 14 50V
B 13.5V-2
P48 P13 VCOM_OUT_B 11 HVDD
48 DGND VCOM_OUT 13 2012 R1208 DCK2_B
C1204 10 12 DCK2 3
ADDR0
ADDR1
REFIN
SIG_C
0.1 1/16W
DGND
DGND
SENB
SCLK
SDAT
AGND
AGND
DCK2X_B
VCC
50V CHIP 13 DCK2X
B DCK1X_B
2012 R1205
100 14 DCK1X
1 2 3 4 5 6 7 8 9 10 11 12 1/16W DCK1_B
CHIP
15 DCK1
P10
P11
P12
P1
P2
P3
P4
P5
P6
P7
P8
P9
HCK1_B
16 HCK
R1209 HCK2_B
10 17 HCKX
1/16W
7 5 3 1 CHIP 9:11F;11:7D RGT 18 RGT
HST
Q1200 19 HST
RB1200
R1206
HN1B01FU-TE85R
22 BUFFER 20 HVSS
2.2k
1/16W
8 6 4 2 CHIP 21 VSSGL
C1211
47
25V 22 VVSS
R1201R1203 ENB
JL1202 23 ENB
10k XX VCK
1/16W1/16W
CHIP CHIP 24 VCK
4
SENB
SCLK
SDAT
R1200R1202 VST
XX 10k 25 VST
1/16W 1/16W
3LINESBUS CHIP CHIP 9:11D;10:7D; DWN
10:1D;11:2D 26 DWN
11:6D CLR
27 CLR
PCG
C1213 28 PCG
0.1
50V 29 SOUT
B
2012
30 VVDD
31 VCOML
9:12B TG_B 9:7B GCFB_B 32 GCFB
R1212
47 CN1200
9:12H;10:2E; TG 1/16W 32P
11:2E CHIP
C1208 C1209 TP1202 5

47 0.1
25V 50V
B
2012
C (12/14)
(LCD DRIVER (B))
VPL-CX70/CX75 6-19 6-19
A B C D E F G H
C (13/14) C (13/14)
PPW_OUT2 PPW_OUT1 (TO P9)
PW_OUT2
PW_OUT1
8:6D 8:12C 9:1A
9:1A;9:2A;9:2F
GND A1
R/G/B
PW_DBE[2-9],PW_DGE[2-9],
R/G/B
GND B1 PW_DRE[2-9]
GND A2 5V-1
PPW_DRE[0] PW_DRE[0]
GND B2
SUB_5V A3
PPW_DRE[2] RB1301
47 PW_DRE[2]
SUB_5V B3
SUB_5V A4
1 SUB_5V B4
GND A5 RB1302
PPW_DRE[6] 47 PW_DRE[6]
SUB_5V B5
GND A6 3.3V-2
GND B6
D3.3V A7 RB1303
PPW_DGE[0] 47 PW_DGE[0]
D3.3V B7
PPW_DGE[1] PW_DGE[1]
GND A8
GND B8
1:7D;2:11E; PPW_DGE[3] PW_DGE[3]
SIRCS A9 SIRCS 5H
RB1304
GND B9
MS_RESET A10 MS_RESET 2:7B
WLESS_ON B10 WLESS_ON 2:10C
RXD_MS A11 RXD_MS 2:5F
RB1305
TXD_MS B11 TXD_MS 2:5F
MENU_STATUSA12 MENU_STATUS 2:10C
PPW_DBE[0] PW_DBE[0]
BRD_STATUS B12 BRD_ST 2:7B
3.3V-2 PPW_DBE[1] PW_DBE[1]
2 FLAG A13 MS_EN
MS_SW
2:11E
PPW_DBE[2] RB1306
47 PW_DBE[2]
MS_SW B13 2:8B
IC1300 PPW_DBE[3] PW_DBE[3]
GND A14 SN74LV4052APWR
SYNC_SEL C1304 PPW_DBE[4] PW_DBE[4]
GND B14 0.1
V_PORT 10V PPW_DBE[5] PW_DBE[5]
16
8:3C;3G;4D; B1005
1
AU_MS_R A15 AU_R_MS 4:4E 0Y VCC RB1307
6D PPW_DBE[6] 47 PW_DBE[6]
AU_MS_L B15 AU_L_MS 4:4D
15
2
2Y 2X PPW_DBE[7] PW_DBE[7]
GND A16 R1301 47
HS 1/16W CHIP VS 2:11D PPW_DBE[8] PW_DBE[8]
14
3
GND B16 2:11D Y 1X
VR[0] R1302 47 R1305 47 R1333 PPW_DBE[9] PW_DBE[9]
GDC_R0 A17 R1332 1/16W CHIP 1/16W CHIP XX
XX
13
4
VB[6] 3Y X RB1308
GDC_B6 B17 R1303 47 47
VR[2] 1/16W CHIP R1309 47 1/16W CHIP
HSS
12
VSS 6:12D;7:5H
5
GDC_R2 A18 6:12D;7:5H 1Y 0X
VB[5]
GDC_B5 B18 R1306 47 1/16W CHIP
11
MS_V 8:3C;3D;3G
6
VR[1] MS_H INH 3X
GDC_R1 A19 8:3C;3D;3G
VB[7] R1307 10k 1/16W CHIP
10
7
GDC_B7 B19 VEE A
VR[3]
GDC_R3 A20 R1308 47 1/16W CHIP
SW3 2:10G
8
9
VB[4] GND B
GDC_B4 B20
GND A21
GND B21
3 GDC_R4 A22
VR[4]
VB[1]
GDC_B1 B22
VR[7]
GDC_R7 A23
VB[0]
GDC_B0 B23
VR[5]
GDC_R5 A24
VB[2]
GDC_B2 B24
VR[6]
GDC_R6 A25
VB[3]
GDC_B3 B25
GND A26 5V-1
GND B26
VG[1]
GDC_G1 A27 FB1308
VG[7] 0uH
GDC_G7 B27
VG[0] IC1305
GDC_G0 A28 R1316 S-80942CNMC-G9C-T2 D1304
VG[6] 10k RESET
GDC_G6 B28 1/16W 1SS355
VG[2]
CHIP DISCHARGE
5
GDC_G2 A29 OUT CD
VG[5] C1313
0.1
2
GDC_G5 B29 VCC 10V
VG[3] B R1320
1k
4
GDC_G3 A30 GND NC
VG[4] 1005 1/16W
C1310 CHIP
4 GDC_G4 B30 0.1
10V
B
GND A31
C1311 R1328
R1315 R1317 10 2.2k
GND B31 47k 6.3V
MS_V 47k B 1/16W
1/16W 1/16W CHIP
VVS A32 CHIP CHIP 2012
MS_VPEN Q1300
VPEN B32 HN1B01FU-TE85R
IC1301 SW
GND A33
FB1300 SN75240PWR R1310
0uH FB1306 100
GND B33 0uH PROTECT 1/16W
MS_VCLK CHIP D1305
VCLK A34 RB501V-40TE-17
MS_H JL1304 PROTECT
VHS B34
JL1302 R1311
GND A35 100
MS_V 8:3C;3D;6D 1/16W IC1303
CHIP
CN1302
GND B35 R1318

47k
SN-USBRCV1
MS_H 8:3C;3D;4D 8 7 6 5 MOUSE_RECEIVER R1323
4P
CN1300 C1300 1/16W XX

70P 0.1 CHIP
GND
GND
10V
A
20 19 18 17 16 15 14 13 12 11
B
1
1
TO M FB1307 A VCC R1312 R1319 SEL1IR ENABLE
1005 0uH 100 47k
1/16W 1/16W
2
2
B CHIP CHIP SEL0 CLK
GND
GND
JL1303
3
3
GND Y IRIN DATA
C
FB1301 C1314 C1315
4
D1300 0uH 330p 330p GND N.C
XX 50V 50V 1 2 3 4 C1306
B B 0.1 5 USB- N.C
10V R1313
1005 1005 B 1.5k
6
1/16W USB+ N.C
5 JL1305 CHIP
7
USBV RTS
IC1302 R1331
1M
8
D1301 D1302 SN74AHCT1G08DCKR VDD SOUT 1/16W X1300

XX XX BUFF CHIP 12MHz
9
D1303 VPP X2
RD5.6SB-T1
C
10
RST X1
PROTECT (13/14)
1:7D;2:11E;
2C SIRCS (INTERFACE TO C & M)
C1307 C1308 C1309 R1321 R1324 R1326 R1329
0.1 47 0.1 47k 47k 47k 47k
10V 25V R1314
10k 10V 1/16W 1/16W 1/16W 1/16W
CHIP CHIP CHIP
B 1/16W B CHIP
R1322 R1325 R1327 R1330
CHIP 47k 47k 47k 10k
1/16W 1/16W 1/16W 1/16W
CHIP CHIP CHIP CHIP
6-20 6-20 VPL-CX70/CX75
A B C D E F G H
C (14/14) C (14/14)
Q1401 3.3V-1
DTC114EUA-T106
INV_SW
R1426 FAN_PROT1:6F;1:7A;2:12A
10k
D1400 1/16W
CHIP R1429 FAN_CONT1
1SS355 100 1:6F;1:7A;2:12A
PROTECTOR 1/16W
CHIP FAN_CONT2
1:6F;1:7A;2:12A
IC1401 FAN_CONT3
BA00ASFP-E2 Q1402 1:6F;1:7A;2:12A
FAN REG DTA114EUA-T106
INV_SW PSAVE_FCONT
2:11B 1
CTL
VCC
GND
OUT
R1432 R1433
C
22k 22k
1/16W 1/16W
1 2 3 4 5 R1424 CHIP CHIP
0 JL1403
CHIP
IC1405 1 FAN_A
R1408 BA10358FV-E2 JL1404
13.5V-1 33k DRIVER R1427 2 FAN_A_PROT
C1404 C1408 1/16W 330k JL1405
FAN_A
0.1 47 RN-CP 1/16W 3 GND
50V 25V CHIP
8
FAN+B 1 B
JL1400 R1411 CN1401
R1409 10k 3P
FAN+B 2 1k 1/16W WHT
R1400 R1404 1/16W
7
FB1400 10k 33k RN-CP
GND 3 0uH 1/16W 1/16W RN-CP
Q1403 D1410
CHIP RN-CP DTC114EUA-T106 DAN202UT106
CLAMP
6
GND 4 R1410 R1436
4.7k INV_SW 10k
D3.3V 5 1/16W 1/16W
RN-CP CHIP
5
D3.3V 6
GND 7
GND 8
OFF&GO 9
GND 10 D1401
CN1400
10P
D3.3 1SS355
PROTECTOR
3.3V-2 1.8V
GC IC1400
AIC1117A-18PYJTR
IC1402
BA00ASFP-E2
FAN REG
Q1404
DTC114EUA-T106
2
1.8V_REG INV_SW
JL1401 JL1402
I O
ADJ
FB1401 C1403
0uH
CTL
VCC
GND
OUT
47
6.3V
C
JL1418
C1400 C1401 C1402 1 2 3 4 5
0.1 47 0.1 JL1406
B 10V 6.3V 10V
1005 B 1 FAN_B
R1412 JL1407
33k 2 FAN_B_PROT FAN_B
C1405 C1409 1/16W JL1408
0.1 RN-CP 3 GND
50V 47
B 25V CN1402
R1421 3P
R1413 10k WHT
1k 1/16W
R1401 R1405 1/16W RN-CP
10k 33k RN-CP
1/16W 1/16W
CHIP RN-CP Q1405
R1414
4.7k
DTC114EUA-T106
1/16W INV_SW
RN-CP
D1411 D1412
D1FS4A-TA D1FS4A-TA
D1402 DROP DROP
1SS355 JL1409
PROTECTOR 1 FAN_C
JL1410
IC1403
D1404
D1FS4A-TA JL1411
2 FAN_C_PROT FAN_C 3
BA00ASFP-E2 RECTIFIER 3 GND
FAN REG CN1403
3P
WHT
JL1412
FAN_D 1:2D
CTL
VCC
GND
OUT
C
1 2 3 4 5
R1415
33k
1/16W
D1408
RN-CP DAN202UT106
C1406 C1410 CLAMP
0.1 47
50V 25V R1416 R1422 Q1400 JL1413
B 1.5k 10k DTC114EUA-T106 FAN_D_PROT 1:2D
1/16W 1/16W
RN-CP RN-CP INV_SW
R1402 R1406
10k 33k
1/16W 1/16W
CHIP RN-CP R1417 C1412 R1430 R1434
4.7k 0.1 22k 22k
1/16W 50V 1/16W 1/16W
RN-CP B CHIP CHIP
IC1404
D1403
1SS355
PROTECTOR
4
BA00ASFP-E2
FAN REG
JL1415
1 FAN_E
CTL
VCC
GND
OUT
JL1416
C
2 FAN_E_PROT FAN_E
JL1417
1 2 3 4 5 3 GND
CN1405
3P
R1418 D1405 WHT
33k
IC1406
1/16W BA10358FV-E2 D1FS4A-TA
RN-CP DRIVER RECTIFIER
C1411
47
25V R1419 R1423
1k 10k
8
C1407 1/16W
0.1 1/16W
50V RN-CP RN-CP
B 2
7
R1403 R1407 R1420
10k 33k 4.7k
1/16W
3
6
1/16W 1/16W RN-CP R1425
CHIP RN-CP 330k
1/16W D1409
4
5
CHIP DAN202UT106
R1428 CLAMP
330k
1/16W R1431 R1435
CHIP XX 22k
1/16W
CHIP 5
D1406
D1FS4A-TA
RECTIFIER
D1407
D1FS4A-TA
C (14/14)
(FAN CONT)
RECTIFIER
VPL-CX70/CX75 6-21 6-21

A B C D E F G H
C C
C (1/14) IRMF-A0T-QTP (IC103) C (3/14) CXA1875AM-T4 (IC304) C (4/14) TDA7309D013TR (IC400)
SAD2
SAD1
SAD0
SW3
SW2
SDA
VCC
SCL
VDD 1
16 15 14 13 12 11 10 9
RECOUTL 1
20 IN3L
IRIN1 2 VOLUME + 19 LOUDL
U1 5 IROUT OUTL 2 LOUDNESS 18 IN2L
MUTE 17 IN1L
IRIN2 3
CSM SOFT
LEVEL LEVEL OPEN COLLECTOR 3 MUTE
LATCH 16 VS
CONVERTER CONVERTER
MODE SELECT SERIAL SUPPLY
RES 4 8 VSS SDA 4 BUS 15 CREF
INPUT SCL 5 DECODER
DGND 6 +
LEVEL LATCH
7 6 CONVERTER GND 7
2
I C DECODER
IREN1
IREN2
ADD 8 14 IN1R
13 IN2R
POWER
ON 12 LOUDR
RESET VOLUME + 11 IN3R
OUTR 9 LOUDNESS
LATCH LATCH LATCH LATCH LATCH
C (2/14) TC74LCX125FT (IC201) RECOUTR 10
MUTE
VCC 4OE 4A 4Y 3OE 3A 3Y

14 13 12 11 10 9 8 – DAC DAC DAC DAC DAC
+
VCC
REG
AMP AMP AMP AMP AMP
C (4/14) TPA2001D1PWR (IC401)
BYPASS
AGND
PGND
ROSC
PVDD
OUTN
COSC
1 2 3 4 5 6 7
VDD
1OE 1A 1Y 2OE 2A 2Y GND
16 15 14 13 12 11 10 9
BIAS
1 2 3 4 5 6 7 8 AND
REF RAMP
C (3/14) BA6287F-E2 (IC308)
SW1
SW0
DAC4
DAC3
DAC2
DAC1
DAC0
GND
GEN
GATE
DRIVE
OUT1 1 8 GND
GAIN
ADJUST DEGLITCH
C (3/14) TC74VHCT138AFT (IC300)
DATA OUTPUTS
VCC Y0 Y1 Y2 Y3 Y4 Y5 Y6
VM 2 7 OUT2 DEGLITCH
16 15 14 13 12 11 10 9
GAIN GATE
DRIVER DRIVER ADJUST DRIVE
TSD VDD OK
VCC 3 6 VREF START-UP OC

CONTROL LOGIC GAIN SD PROTECTION DET
Y0 Y1 Y2 Y3 Y4 Y5 2
THERMAL
POWER
SAVE A Y6 1 2 3 4 5 6 7 8
INP
INN
SHUTDOWN
GAIN0
GAIN1
PVDD
OUTP
PGND
FIN 4 5 RIN
B C G2A G2B G1 Y7
C (3/14) BA6288FS (IC305)

1 2 3 4 5 6 7 8 C (5/14) TC74HC4052AFT(EL) (IC501)
OUT2
VREF
RNF
RIN
NC
NC
NC
NC
A B C G2A G2B G1 Y7 GND

16 15 14 13 12 11 10 9 OUTPUT
SELECT ENABLE 0
C (3/14) TC7WH125FK (IC306) Y0 1 16 VDD
2 2
Y1 2 15 X2
1
DRIVER CONTROL POWER Y 3 14 X1
3
LOGIC SAVE G1 1 8 VDD Y3 4 13 X
C (3/14) TC7WH04FK(TE85R) (IC302) Y1 5
1 0
12 X0
TSD 3
INH 6 11 X3
A1 2 7 G2 SELECT A
1A 1 8 VCC VEE 7 10 A
SELECT B
3Y 2 7 1Y VSS 8 9 B
1 2 3 4 5 6 7 8 Y2 3 6 Y1
GND
NC
OUT1
VM
VCC
FIN
NC
NC
2A 3 6 3A
GND 4 5 2Y GND 4 5 A2
6-22 6-22 VPL-CX70/CX75

C C
CLP_CR
C (6/14) CXA2171AQ-T6 (IC602) C (9/14) TC74VHCT540AFT(EL) (IC907) C (9/14) TC7WH125FK(TE85R) (IC908)
VCC 4OE 4A 4Y 3OE 3A 3Y
20 19 18 17 16 15 14 13 12 11
14 13 12 11 10 9 8
29 VCC
YGAIN (4)
0
IN1_1 33 CBGAIN (4)
CRGAIN (4)
IN1_2 34 YPbPr YCbCr 1
(CCIR) Y Y/Cb/Cr 6dB 0 GAIN_SEL (2)
IN1_3 35 CLAMP AMP. 1
MATRIX 27 SELY_OUT
IN1_H/L1 36 YPbPr YCbCr 2 SELECTOR 2, 3 26 SELCB_OUT GND
(BTA) Cb/Cr 1 2 3 4 5 6 7
IN1_V/L2 37 CLAMP 1 2 3 4 5 6 7 8 9 10
25 SELCR_OUT
IN1_L3 38 3 1OE 1A 1Y 2OE 2A 2Y GND
RGB YCbCr MAT_OUT (2)
IN1_SW 39
17 CLP_SW
IN2_1 41 3STATE CLP C (10/14), (11/14), (12/14) CXA7005R-T4 (IC1002, IC1100, IC1200)
IN2_2 42 SYNC &
STATUS
DET. 3SYNCP CLOCK
FRINV
DGND
AGND
AGND
AGND
IN2_3 43 20 EXTCLK/XTAL
DIRC
PRG
GEN.
FRP
+3-STATE (1)
CLK
VDD
VCC
V V
IN2_H/L1 44 0
CLK_SEL (1)
IN2_V/L2 45 IN1 IN4 36 35 34 33 32 31 30 29 28 27 26 25
SELECTOR PEAK LEVEL POLARITY 1
IN2_L3 46 HOLD DET. DISTINCT.
SYNC
IN2_SW 47 H + EH (1) H COUNTER
+ EV (1) D_IN9 37 24 SID_OUT
IN3_1 1 PRIORITY
SELDUM (1) TG
+ H_NUMBER_H (2) DUMMY SID
IN3_2 2 RANK + H_NUMBER_L (8) SYNC
+ V_NUMBER_H (2) D_IN8 38 23 PVCC
IN3_3 3 HV > CS > Y/G
INPUT_SEL (2)
+ V_NUMBER_L (8) D/A
IN3_H 4
SELSTB_1 (1) 23 SELV_OUT
SYNC V SYNC V V D_IN7 39 22 SIG_OUT1
IN3_V 5 SELSTB_2 (1) SEP.
+ DECL1_1 (2) SEP. D/A Driver
0 1
IN4_1 7 + DECL2_1 (2) HD_TC (1)
+ DECL3_1 (2) HSEP_SEL (1) V_TC (2) D_IN6 40 21 SIG_OUT2
IN4_2 8 H SYNC
+ DECSW_1 (1) HYSW (1) H H
MACRO 22 SELH_OUT
IN4_3 9 + DECL1_2 (2) HS_MASK (1) VISION WIDTH D/A Driver
+ DECL2_2 (2) FIX_SYNC (2) MACRO (1) H_WIDTH (2) D_IN5 41 20 SIG_OUT3
IN4_H 10 6dB I2C bus
+ DECL3_2 (2)
DEC.
IN4_V 11 DECSW_2 (1)
D_IN4 42 D/A Driver 19 PGND
15 16 13 14 30 31 32 6 12 24 28 48 40 18 Digital
YG_OUT
YG_IN
H_PH
V_PH
SCL
SDA
ADDRESS
GND3
Vcc3
GND2
Vcc2
GND1
Vcc1
IREF
D_IN3 43 18 PGND
D/A Driver
D_IN2 44 17 SIG_OUT4
C (6/14) M52347FP-TE (IC601) C (6/14) SN74LV00APWR (IC604)

D/A Driver
D_IN1 45 16 SIG_OUT5
CLAMP+ CLAMP+ HD– HD+ VD+ V S/S V S/S VCC
TIMING V. POL H. POL OUT VCC OUT OUT OUT OUT IN 14 13 12 11 10 9 8 D/A Driver
20 19 18 17 16 15 14 13 12 11 D_IN0 46 15 SIG_OUT6
DGND 47 14 PVCC
CLAMP EDGE V TIME V. SYNC
GEN SW GATE SEP REF
DC_GEN
DGND 48 SIF 13 VCOM_OUT
LOGIC 1 2 3 4 5 6 7 8 9 10 11 12
DGND
DGND
SENB
SCLK
SDAT
ADDR0
ADDR1
AGND
AGND
REF_IN
VCC
REF_OUT
LOGIC
SYNC H H V V
SEP SHAPE DET SHAPE DET
1 2 3 4 5 6 7
GND
1 2 3 4 5 6 7 8 9 10
C (13/14) SN74LV4052APWR (IC1300) C (14/14) BA10358FV-E2 (IC1405, IC1406)
H. STATE V. STATE CLAMP GREEN GND COMP/H COMP/H V IN V DET V TIME GATE C (9/14) SN74AHCT541PWR (IC904, IC905, IC906) 1 8
SW IN IN DET SW
G1 1 20 VDD 0
Y0 1 16 VDD 2 7
C (6/14) SN74LV244APWR (IC605)
2 2
1Y1
2A4
1Y2
2A3
1Y3
2A3
1Y4
2A4
Y1 2 15 X2
Vcc
A1 2 19 G2
2G
1 3 6
Y 3 14 X1
20 19 18 17 16 15 14 13 12 11 3
A2 3 18 Y1
Y3 4 13 X 4 5
1 0
Y1 5 12 X0
A3 4 17 Y2
3
INH 6 11 X3
SELECT A C (14/14) BA00ASFP-E2
A4 5 16 Y3
VEE 7 10 A
SELECT B (IC1401, IC1402, IC1403, IC1404)
A5 6 15 Y4 VSS 8 9 B
A6 7 14 Y5 Vcc 2 Reference
Voltage –
A7 8 13 Y6 +
CTL 1 4 OUT
A8 9 12 Y7
1 2 3 4 5 6 7 8 9 10 5 C
GND 10 11 Y8
1G
1A1
2Y4
1A2
2Y3
1A3
2Y2
1A4
2Y1
GND
GND 3
VPL-CX70/CX75 6-23 6-23

HA HA
1 SUB_3.3V
Q1900 2 POWER_LED
1 2SJ463A-T1
SW 3 D3.3V
S
D1903
DAN202UT106 4 KEY4
PROT
5 KEY4_CON
6 KEY0
C1900 C1901 7 GND
1000p 0.1
50V 10V CN1900
B B 7P
1005
1005
Q1901
DTA114EUA-T106
SW
R1905 R1906
100 100 R1908
1/16W 1/16W 100 R1910
CHIP CHIP 1/16W 100
CHIP 1/16W
CHIP
D1902
DAP202UT106
2 PROT
G
D1900 D1901
SEC2422C SEC2422C
POWER_LED POWER_LED
POWER_LED
D1905
DAN202UT106
PROT
D1904
DAP202UT106
LEFT DOWN PROT
3 2
ENTER KEY0
3 4 1
5 6
S1900
UP RIGHT
MENU
S1901
INPUT
TILT-
4 S1902
S1904
R1912
1.5k TILT+
1/16W
CHIP
S1905
R1913
POWER 1.8k
1/16W
CHIP
GND
S1903
JL1901
5
HA
R1900 R1901 R1902 R1903 R1904 R1907 R1909 R1911
(CONTROL PANEL SW)
27k 12k 6.8k 3.9k 2.7k 2.2k 1.5k 1.8k
1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W
CHIP CHIP CHIP CHIP CHIP CHIP CHIP CHIP
6-24 6-24 VPL-CX70/CX75
A B C D E F G H
H G F E D C B A
6-25 6-25 VPL-CX70/CX75
SUFFIX: -11 SUFFIX: -11
HA -B SIDE- HA -A SIDE-
R1900 Q1900
R1901
R1902 JL1901
R1906
R1905
R1907 D1902 D1901
R1904
S1
90
S1901 S1905 S1904 S1902 S1903
0
R1903
D1904
D1900
R1909
R1911
D1905 R1913
R1912 D1903 R1910
R1908
Q1901
CN1900
C1900
C1901
HA HA
HB HB
1 SUB_3.3V
1 2 TEMP_LED
3 LAMP_LED
Q2000 D2004 D2006
DTA114EUA-T106 DAN202UT106 DAN202UT106 4 PSAVE_LED
SW PROT PROT
5 KEY4
6 KEY3
Q2001
DTA114EUA-T106 7 KEY4_CON
SW
C2000 C2001 8 GND
1000p 0.1
R2000 50V 10V CN2000
100 B B 8P
1/16W 1005
CHIP R2001 Q2002 1005
100 DTA114EUA-T106
1/16W SW
CHIP R2002
100
1/16W
CHIP
2
D2003 D2005
D2000 D2001 D2002 DAP202UT106 DAP202UT106
SEC1901C SEC1901C SEC1801C PROT PROT
LAMP_LED TEMP_LED PSAVE_LED
LAMP_LED TEMP_LED PSAVE_LED
D2008
DAN202UT106
PROT
3
D2007
DAP202UT106
PROT
LENS_FOCUS-
KEY4
S2000
R2003
6.8k
1/16W LENS_FOCUS+
CHIP
S2001 SIDE_SHOT-
4 KEY3
R2004
3.9k
LENS_ZOOM-
1/16W S2004
CHIP
S2002 R2007
12k
R2005 1/16W
2.7k LENS_ZOOM+ CHIP
1/16W SIDE_SHOT+
CHIP
S2003
S2005
R2006
2.2k
1/16W R2008
CHIP 3.9k
1/16W
CHIP
R2009
15k
1/16W
CHIP
5
JL2000
GND
HB
(CONTROL PANEL SW)
6-26 6-26 VPL-CX70/CX75
A B C D E F G H
HB HB
R2003
S2000 S2001
4002R
R2005
JL2000 R2006
C2000
S2002 S2003 D2008
D2007
0002NC
1002C
900820R02R
7002R
S2004 S2005 D2005 D2003
D2006 D2004
D2002 Q2002
Q2001
2002R
D2001
1002R
Q2000
R2000
D2000
HB -A SIDE- HB -B SIDE-
VPL-CX70/CX75 6-27 6-27

A B C D E F G H
L, NF, NR, U, V L, NF, NR, U, V
D61 R41
(LED) NSCW215T 47
LOGO_LED 1/16W
CHIP
1 1 SUB_3.3V
TH10
LED_VCC 1 IC41 R42 100
2 SIRCS-NR
C
C LED_CONT 2
KRM-TR303E-TP
SIRCS RECEIVER
1/16W CHIP
3 GND
CN41
CN61 3P
2P 1 LAMP_TEMP_TH
S10
VCC OUT
GND 2 LAMP_COVER C
L
(LOGO LED)
C41
10
6.3V
B
3 GND
CN10
3P
2012 WHT
U
(LAMP COVER SW)
2
NR
(SIRCS RECEIVER)
D52
MA3J14700LSO
PROTECT
3
TH21 JL22
SUB_5V 1
1 EXIT_TEMP_TH
RXD 2
2 GND
JL23
3 FILT_COVER
TXD 3
S21
4 TILT_X
C
GND 4
R53
EXT_SW 5
47 5 TILT_Y
1/10W
CN52 CHIP
5P
6 D3.3V
VISCA CN21
6P
D51
RD3.9SB-T1 R24
PROTECT IC21 R26
CN51
10 0
4 7P MXS3125GL CHIP CHIP
ANGLE DETECT 1/16W
7 SUB_5V
6 RXD
C21 C22
10 0.1
6.3V 10V
5 TXD B B R21 R27
R51 2012 8 0
47 XX
1/16W
CHIP
4 GND C JL21
1 7 R28
3 SUB_3.3V R22 22
XX CHIP
2 6 1/16W
IC51 2 SIRCS_NF
KRM-TR303E-TP R52 3 5
SIRCS RECEIVER 100 1 GND C24
CHIP 4 XX
1/16W
C23
VCC OUT R23 0.1
22 10V R25
GND CHIP XX
C51 1/16W B
5 10
6.3V
1005
B
2012
NF V
(SIRCS RECEIVER) (ANGLE DETECT)
6-28 6-28 VPL-CX70/CX75
A B C D E F G H
L, NF, NR, U, V L, NF, NR, U, V
CN61
D61
L -A SIDE- L -B SIDE-
D52
35R
15D
IC51
CN52
15NC
15R
C51
25R
NF -A SIDE- NF -B SIDE-
R42
IC41
14NC
R41 C41
NR -A SIDE- NR -B SIDE-
01HT
CN10
U -A SIDE- U -B SIDE-
S10
JL23 22C
JL21R21 12C
12HT
72R
IC21
42R
62R
S21
42C 22R
CN21
JL22
82R 32R
32C 52R
V -A SIDE- V -B SIDE-
VPL-CX70/CX75 6-29 6-29

A B C D E F G H
M (VPL-CX75) M (VPL-CX75)
M (1/5) AK4352VT-E2 (IC1505)

DIF0 DIF1
6 7
LRCK 5
BICK 3 SERIAL INPUT
INTERFACE
SDATA 4 15 VCML
8X T∑ LPF 14 AOUTL
INTERPOLATOR MODULATOR
VDD 10
8X T∑ LPF 13 AOUTR
VSS 9 INTERPOLATOR MODULATOR
PD 2 DE-EMPHASIS 12 VCMR
CLOCK DIVIDER
CONTROL
8 1 16 11
DEM MCLK CKS VREF
M (1/5) MIC2562A-OBMTR (IC1501)
M (1/5) CY27027ZCT (IC1500)

VDD VDD VDD
2 8 12
4 VIDCLK
PLL1 14 ASICCLK
XIN 3
SSCG DELAY 13 CPUCLK
SSSEL 10
PLL2 16 AUDCLK
AUSEL 5
6 USBCLK
PLL3
9 MSCLK
MSSEL 15
1 7 11
GND GND GND
6-30 6-30 VPL-CX70/CX75

M (1/5) (VPL-CX75) M (1/5) (VPL-CX75)
A1 GND
SUB3.3V
B1 GND
Q1500 5V-1 A2 GND

2SA1576A-T106-QR
SW FB1501 0uH B2 GND
JL1517
SUB3.3V A3 SUB5V
B3 SUB5V
A4 SUB5V
Q1503
C1500 C1502 C1506 R1509 2SA1576A-T106-QR B4 SUB5V
0.1 22 R1506 0.1 R1508 100k SW
10V 10V 2.2k 10V 1k
1/16W
GND
68
B
1005
F
3216
1/16W
CHIP
B
1005
1/16W
CHIP CHIP A5
B5
GND
SUB5V
1
R1549
GND
67 100 A6 GND
1/16W
CHIP
GND
66 2:7E 2:8J;3:16D POWER_DET B6 GND
R1574
R1550 22k
BS
65
C2_BS 1k 1/16W FB15020uH A7 D3.3V
R1570 1/16W CHIP
64 0 CHIP
VCC B7 D3.3V
63 CHIP 2:7E JL1520
DI0 C2_DIO A8 GND
R1571
#
62 0 2:10J R1553 B8 GND
61 CHIP 3:8D 22 1/16W CHIP
INS C2_PIO SIRCS_CPU A9 SIRCS
R1572 FB1503 XX
#
60 0 2:15H R1554 B9 GND
CHIP SUB3.3V 10F 22 1/16W CHIP
SCLK
59
C2_CKO AU_MUTE RESET A10 MS_RESET
R1573 3:17H FB1504 0uH
VCC
58 0 B10 WLESS_ON
57 CHIP 3:15J
GND L1501 RXD A11 RXD_MS
56 4.7uH 3:8D FB1505 0uH
-CD2 PC_CD2_OUT2:2K TXD B11 TXD_MS
1
2
55 3:8D FB1506 0uH
D10 PC_D10_OUT2:5I M_STATUS A12 MENU_STASTUS
3
4
IC1507 IC1509 3:17H FB15070uH
54 R1565 B_STATUS
WP PC_WP_OUT 2:2J XX XX XX B12 BRD_STASTUS
5
6
53 IC1505 R1539 SW OP_AMP 2:8J FB1508 0uH
D09 PC_D9_OUT 2:5K AK4352VT-E2 22 MS_SEL A13 FLAG
7
8
AUDIO_DAC 1/16W FB15090uH
52
PC_D2_OUT 2:2I CHIP RB1501
5
D02 R1555 IN VCC GND OUT B13 MS_SW
1
R1561 22
0 R1557 R1559 C1534
XX XX
2
16
51
PC_D8_OUT2:2J CLK_SEL 2:12J XX
2
D08 MCLK CKS OUT VCC A14 GND
2
5G;2:6E CLK12M CHIP XX
50
PC_D1_OUT2:2I C1532 C1536
4
D01 GND CONT V- V+ B14 GND
3
4.7 R1563 R1566 XX R1569
15
2:16F PD
2
49 PD VCML 10V XX XX XX
BVD1 PC_BVD1_OUT2:2I R1527 F A15 AU_MS_R
22 1/16W CHIP 2012 Q1504 JL1518
XX
14
2:10J;2:6E SCLK
48
PC_D0_OUT 2:5I
3
D00 BICK OURL INV_SW B15 AU_MS_L
R1528
BVD2
47 22 1/16W CHIP JL1519 A16 GND
PC_BVD2_OUT2:5I
13
2:16H SDO
4
SDAT OUTR
IC1508
46
A00 PC_ADR0_OUT2:4I R1529 C1533 R1564 R1567 R1568 B16 GND
CHIP 1/16W 22 4.7 XX XX XX XX
10V SW
12
45
2:10J;2:15D LRCK
5
-REG PC_REG_OUT 2:3F LRCK VCMR F 2:4F VD_R0_OUT A17 GDC_R0
R1530 2012 8 6 4 2
44 R1558 R1560
1
22 1/16W CHIP VD_B[6]
5
A01 PC_ADR1_OUT2:4I 100k 100k IN VCC GND OUT 2:13K B17 GDC_B6
C1535
11
1/16W R1562
6
DIF0 VREF 1/16W XX XX
43 CHIP CHIP
2
PC_INPACK_OUT2:5K
2
-INPACK R1556 OUT VCC 2:4F VD_R2_OUT A18 GDC_R2
0
10
C1531
42
PC_ADR2_OUT 2:4I
3
7
4
A02 DIF1 VDD C1527 C1530 10 GND CONT V- V+ 2:11K VD_B[5] B18 GDC_B5
R1533 10 CHIP
41 XX 10 6.3V 6.3V C1537 7 5 3 1
-WAIT PC_WAIT_OUT 2:5K 1/16W 6.3V
B B B
2012
C1538
XX IC1510 XX 2:4F VD_R1_OUT A19 GDC_R1
9
CHIP DEM VSS 2012 2012 C1539
A03
40
XX XX TP1504 2:8K VD_B[7] B19 GDC_B7
PC_ADR3_OUT2:4I OP_AMP
39 R1534 2:4F VD_R3_OUT
RESET PC_RESET_OUT2:3F 10k A20 GDC_R3
1/16W
A04
38
PC_ADR4_OUT2:4I CHIP 2:7J VD_B[4] B20 GDC_B4
R1551R1552R1575 RB1500
37 JL1500 JL1515 10k XX 10k 10k
-VS2 C1526 R1537 1/16W 1/16W A21 GND
36 0.1 10k CHIP CHIP
A05 PC_ADR5_OUT2:4I 10V 1/16W B21 GND
B CHIP
35
PC_ADR25_OUT 2:4J 1005 2:4G
-CSEL VD_R4_OUT A22 GDC_R4
A06
34
PC_ADR6_OUT2:4I 2:7J VD_B[1] B22 GDC_B1
VCC
33
R1500 R1501
XX SUB3.3V
2:4G VD_R7_OUT A23 GDC_R7 3
VCC
32 0 MA3J14700LSO 2:8K VD_B[0] B23 GDC_B0
31 CHIP D1505
VCC SUB3.3V 2:4G VD_R5_OUT A24 GDC_R5
C1514
REDY
30 0.1 R1535 2:8K VD_B[2] B24 GDC_B2
PC_RDY_OUT 2:5K 10V 220
29 B 1/16W
A07 PC_ADR7_OUT 2:4I CHIP 2:4G VD_R6_OUT A25 GDC_R6
28
-WE PC_WE_OUT 2:3E 2:8K VD_B[3] B25 GDC_B3
27 IC1503 D1504
A08 PC_ADR8_OUT 2:4J IC1501 SN74LVC2G04DCKR CHIP A26 GND
R1518 INV SEC1901C R1542
26 5V-1 PC_VCC MIC2562A-OBMTR 1/16W TIMER_LED SUB3.3V 22
-IOWR PC_IOWR_OUT 2:3F POWER_SEL 22 10k 1/16W B26 GND
1/16W R1531 CHIP
25 FB1500 CHIP WDT_ENB 3:5B 2:11K VD_G[1]
3
A09 PC_ADR9_OUT 2:4J 0uH PC_VCC5EN_OUT 2:4H A27 GDC_G1
Q1501
1
R1532
14
GND VCC5_EN 100 2SA1576A-T106-QR R1536

24 2:13K VD_G[7]
2
-IORD PC_IORD_OUT 2:3F 1/16W SW 10k B27 GDC_G7
CHIP 1/16W
CHIP
2
23
PC_VCC3EN_OUT 2:4H JL1511 2:8K
13
VD_G[0]
1
-OE PC_OE_OUT 2:3E VCC5_IN
VCC3_EN A28 GDC_G0
SUB3.3V R1519 CPU-PRST IC1506
-VS1
22 22 1/16W CHIP 3:12J;3:17H R1526 2:11K VD_G[6] B28 GDC_G6
PC_VS1_OUT 2:5L 0 MM1096AFF
3
12
VCC_OUT EN0 RESET R1540 R1545

A10
21
R1502 R1520 CHIP 1M 4.7k 2:8K VD_G[2] A29 GDC_G2
PC_ADR10_OUT2:4J 10k XX 1/16W
1/16W 1/16W
CHIP CHIP
4
20 2:13A
11
VD_G[5]
8
-CE2 PC_CE2_OUT 2:3E CHIP VCC5_IN EN1 TC RSTN B29 GDC_G5
R1521
-CE1
19 XX 2:13K VD_G[3] A30 GDC_G3
PC_CE1_OUT 2:3E
5
FLAG_MIC 2:12J
10
JL1516
7
VCC_OUT FLAG NC VS
2:11J
18
D15 PC_D15_OUT 2:2L RESET 10B VD_G[4] B30 GDC_G4
JL1505 R1541 R1548
4.7k
9
17
PC_D7_OUT 2:2J 3:11J TIMER
6
D07 VCC3_IN
VPP_IN CLK RCT 10k 1/16W A31 GND
1/16W CHIP
D14
16
PC_D14_OUT 2:2K C1524 CHIP Q1502 B31 GND
C1521 0.22
8
HN1B01FU-TE85R
4
5
VCC_OUT
VPP_OUT 470p 10V GND VCC SW C1540 2:7J TP1506
2:2J
15
D06 PC_D6_OUT 50V B C1529 0.1 VD_VSYNC A32 VVS
B 1608 C1528 R1538 10V
1005 0.1 10k 0.1 B 2:8K TP1507
PC_D13_OUT 2:2K
14
D13 10V 1/16W 10V VD_PEN B32 VPEN
B CHIP B
1005 JL1514 1005
13
PC_D5_OUT 2:2J 1005
D05 A33 GND
C1501 C1503C1504 C1505 C1510C1511 R1516 R1517
12
PC_D12_OUT 2:2K 0.1 0.1 0.1 47 XX XX 10k 10k
D12 10V 10V 10V 25V 1/16W 1/16W B33 GND
B B B CHIP CHIP 2:13J TP1508
2:2J
11
D04 PC_D4_OUT SUB3.3V VD_CLK A34 VCLK
1005 1005 1005
10
PC_D11_OUT 2:2K 2:8K VD_HSYNC TP1505
D11 B34 VHS
D03
9
PC_D3_OUT 2:2I IC1500 A35 GND
CY27027ZCT
8 CLK_GEN
-CD1 PC_CD1_OUT 2:5I R1512 B35 GND
L1500 C1507 22
GND
7
1uH C1512 0.1 1/16W CN1501
SUB3.3V 0.1 10V CHIP 70P
C1513 10V B JL1507 3.3V
16
6 22 B CLK12M
1
GND 10V GND AUDCK 4C;2:6E

5 F 1005 1005
SUB_3.3V 5V-1 SUB3.3V 1.8V-3
IC1502 R1522
R1524 IC1504 1.8V TO B
15
3216
2
VDD MSSEL R1513 AIC1084-PEJTR XX 100 AIC1117A-18PYJTR

GND
4 R1510 22 3.3_REG 1/16WTP1501 1.8V_REG TP1502
JL1504 0 1/16W RN-CP
R1503 CHIP CHIP JL1508
14
3
3
GND 22 XIN ASICCK

1/16W I O I O
JL1501 CHIP
2
GND JL1509 ADJ ADJ JL1512
13
2:13J CLK54M CLK66CPU

4
R1504 VDCK CPUCK

R1514
1
GND 22 22 2:16G;3:8D
1/16W 1/16W
CHIP
12
CN1500 2:7G SR_SEL

5
AUSEL VDD CHIP

68P
WHT
JL1502
2:6E CLK48M JL1503
C1517
47
C1520
C1522
XX
C1523
XX C1525
47 M(1/5)
11
XX
6
USBCK GND 6.3V 6.3V TP1503 GND

R1505
TO QB
22
1/16W R1515
22
AUDIO DAC, 5
10
7
CHIP GND SSSEL 1/16W

R1511
C1508
0.1
0
CHIP
CHIP
JL1510
C1515
47
6.3V
C1516
0.1
10V
R1523 R1525
330 330
1/16W 1/16W
C1518 C1519
47
6.3V
XX
JL1513 CLOCK GEN
CLKMS
8
10V VDD MSCK 2:15H B RN-CP RN-CP

B
1005
1005
R1507
22
1/16W VDD CONT
CHIP
OUT
C1509 TP1500
0.1 X1500
10V 54MHz JL1506
B
1005
VPL-CX70/CX75 6-31 6-31

A B C D E F G H
M (2/5) (VPL-CX75) M (2/5) (VPL-CX75)
MB93943[243]
MB93943[241]
VD_R4_943
VD_G[5]
SUB3.3V
11L
13K
1:11F
4G
JL1643
FB1601
R1625 C1603 C1616 0uH
22 0.110V 10
1/16W B 6.3V
B
CHIP 2012
C1604 C1605 C1607

0.1 0.1 0.1
10V 10V 10V
B B B
1005
257
264
263
262
261
260
259
258
256
255
254
253
252
251
250
249
248
247
246
245
244
243
242
241
320
319
318
317
316
315
314
313
312
311
310
309
308
307
306
305
304
303
302
301
300
299
298
297
296
295
294
293
292
291
290
289
288
287
286
285
284
283
282
281
280
279
278
277
276
275
274
273
272
271
270
269
268
267
266
265
VCB[5]/VCCX[5]/VCCB[5]/PP[29]
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
VDG[5]/VDY[5]/VDX[5]
VDD
VDR[4]/VDCR[4]/PP[20]
VSS
VCR[5]/VCCR[5]/PP[13]
VCG[0]/VCY[0]/VCX[0]
VDD
VSS
PP[4]
VDD
TMS
VSS
D[3]
VDD
D[10]
240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161
1
VSS VSS
MB93943[1] MB93943[77]
2
11K VDB[5]/VDCX[5]/VDCB[5]/PP[37] D[19]
10K
MB93943[2] MB93943[76]
3
9K VDB[2]/VDCX[2]/VDCB[2]/PP[34] D[24] C1608 0.1 7L
MB93943[3] 10V B 1005
4
9K ENABLE/ENABLE# VDD
MB93943[4] MB93943[75]
5
VDHSYNC/VDHSYNC# RDY#
9K 13L
PC_ADR25_943
6
4J PC_A[25] VSS
MB93943[74]
7
PC_A[21] CSR# C1609 0.1 11K
10V B 1005
8
PC_A[19] VDD
MB93943[73]
9
PC_A[16] BE[3]
10K
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
PC_A[15] VSS
IC1601
PC_A[14] A[7] MB93943[72] M24C64-WMN6T(B)
C1610 0.1 11K
10V B 1005 EEPROM
PC_A[13] VDD
C1617
PC_ADR9_943 MB93943[71] 0.1
PC_A[9] A[14] 10V
4J 13K B
PC_ADR7_943 PC_A[7] VSS 1005
4I
1
VCC E0
PC_ADR3_943 PC_A[3] SDA[0]
4I R1629
PC_ADR0_943 LRCK 4.7k
2
PC_A[0] LRCKO/FS0 C1611 0.1 WC E1
4I R1626 1:4D;10J 1/16W
PC_D13_943 10V B 1005 22 CHIP
PC_D[13] VDD 1/16W
2K
3
CHIP SCL E2
PC_D9_943 PC_D[9] PC_INPACK# PC_INPACK_943
2J 6K
2 PC_D6_943
4
PC_D[6] VSS SDA VSS
2J R1632
VSS PC_VCC3EN# PC_VCC3EN_943 10k
4H 1/16W
PC_OE_943 CHIP
PC_OE# VDD
4E
PC_CE1_943 PC_CE1# PC_WE# PC_WE_943
4E 4E
PC_RESET_943 PC_RESET VSS
4F
PC_BVD2_943 PC_BVD2/PC_SPKR# PC_D[5] PC_D5_943
6I C1612 0.1 2J
PC_CD1_943 10V B 1005
R1606 R1610 PC_CD1# VDD
1.5k 27 6I
1/16W 1/16W PC_WAIT_943 PC_WAIT# PC_D[12] PC_D12_943
CHIP JL1615 CHIP 6K 2K
UDP VSS
R1608
XX N.C. PC_A[5] PC_ADR5_943
R1609 0 CHIP 4I
CLK48M USCKI PC_A[10] C1613 0.1 PC_ADR10_943
JL1616 1:3H R1613 0 CHIP 4J
SDI 10V B 1005
SDI/DR VDD
R161522 1/16WCHIP
CLK12M FSCKI PC_A[23]
1:4C;1:5G R161622 1/16WCHIP
SCLK BCKO/MCLK VSS
JL1617 1:4C;10J R161210 1/16WCHIP
C2_SDA[1] SDA[1] VDCLKOUT MB93943[208]
C1614 0.1 14J
C2_DIO 10V B 1005
MSDIO VDD
R1611 1:5B
XX C2_BS MBS VDB[6]/VDCX[6]/VDCB[6]/PP[38] MB93943[206]
1/16W 1:5B 14K
CHIP MB93943[5] A[15] VSS
11K
MB93943[6] A[11] VDG[3]/VDY[3]/VDX[3] MB93943[204]
9L 14K
MB93943[7] A[8] VDG[7]/VDY[7]/VDX[7] MB93943[203]
7K 14K
VSS VDR[2]/VDCR[2]/PP[18] VD_R2_943
4F
3 MB93943[8]
7K
MB93943[9]
BE[2]
DIR
IC1600
MB93493PB-GE1
CONPANION_CHIP
VD_R6_943
4G
7K
MB93943[10] IRQ[1]# VCR[6]/VCC[R]/PP[14]
7K
MB93943[11] DRQ[3]# VCG[1]/VCY[1]/VCX[1]
10J
MB93943[12] DRQ[0]# VCB[0]/VCCX[0]/VCCB[0]/PP[24]
10K
MB93943[13] D[30] VCB[4]/VCCX[4]/VCCB[4]/PP[28]
7K
VSS VCVSYNC/VCVSYNC#
COMP-PP[3] JL1650
TMODE PP[3] 1:4C
Q1600 MB93943[14] D[29] PP[6] PD
2SA1576A-T106-QR 7L
SW MB93943[15] D[28] TDO C1615 0.1
7L
10V B 1005
MB93943[16] D[27] TCK
7L
MB93943[17] D[23] VDD
9J
MB93943[18] D[21] D[1] MB93943[70]
9K 13L
MB93943[19] D[17] D[5] MB93943[69]
10K 13K
MB93943[20] D[14] D[8] MB93943[68]
10L 11L
MB93943[21] D[11] D[12] MB93943[67]
11L 10L
MB93943[22] D[7] D[15] MB93943[66]
13J 10L
MB93943[23] D[4] D[20] MB93943[65]
13K 9K
VSS D[25] MB93943[64]
7L
TRST# CLKIN CLK66CPU
R1633 1:5G;3:8D
PP[7] D[31] MB93943[63] 22
7K 1/16W
R1605 JL1618 CHIP
4 10k
1/16W
CHIP SR_SEL
PP[2]
PP[0]
DRQ[2]#
PRST#
MB93943[62]
11K
MB93943[61]
1:3G 11K
VCB[7]/VCCX[7]/VCCB[7]/PP[31] BS# MB93943[60] R1631
10K 22
VCB[3]/VCCX[3]/VCCB[3]/PP[27] BE[1] MB93943[59] 1/16W
10K CHIP
VCB[1]/VCCX[1]/VCCB[1]/PP[25] A[1] CPU-BE[2]
7K;3:10L;3:7K
VCG[6]/VCY[6]/VCX[6] A[4] MB93943[58]
7K
VCG[5]/VCY[5]/VCX[5] A[5] MB93943[57]
9L
VCG[4]/VCY[4]/VCX[4] A[9] MB93943[56]
11K
VCG[3]/VCY[3]/VCX[3] A[12] MB93943[55]
C1600 0.1 10V B1005 13K
VDD MSCKI CLKMS
1:5H
VCR[7]/VCCR[7]/PP[15] MSCK0 C2_CKO
1:5B JL1651
VCR[3]/VCCR[3]/PP[11] SCL[1]
R1630
XX SDO
VCR[]/VCCR[0]/PP[8] SDO/DX R1628
10 R1627 1:4C
VDB[7]/VDCX[7]/VDCB[7]/PP[39]
VD_R5_943 VDR[5]/VDCR[5]/PP[21] N.C. 1/16W 22
4G CHIP 1/16W
CHIP
VD_R1_943 VDR[1]/VDCR[1]/PP[17] PC_WP/PC_IOIS16# PC_WP_943
4F 6K
VCR[2]/VCCR[2]/PPP[10]
MB93943[24] VDG[6]/VDY[6]/VDX[6] PC_BVD1/PC_STSCHG#/PC_RI# PC_BVD1_943
11K
6I
TOPFIELD/TOPFIELD#
MB93943[25] VDG[1]/VDY[6]/VDX[1] PC_REG# PC_REG_943
11K 4F
VDVSYNC/VDVSYNC#
VCHSYNC/VCHSYNC#
PC_RDY/PC_IREQ#
MB93943[26] DG[0]/VDY[0]/VDX[0] PC_CE2# PC_CE2_943

9K 4E
MB93943[27] DB[3]/VDCX[3]/VDCB[3]/PP[35] PC_IOWR# PC_IOWR_943
VDCDISABLE
PC_VCC5EN#
9K 4F
LRCKI/FS1
VDPCLKIN
PC_A[22]
PC_A[18]
PC_A[11]
PC_D[14]
PC_D[10]
PC_A[24]
PC_A[20]
PC_A[17]
PC_A[12]
PC_D[15]
PC_D[11]
PC_IORD#
VCDCLKIN
MB93943[28] DB[0]/VDCX[0]/VDCB[0]/PP[32] PC_D[0] PC_D0_943
PC_A[6]
PC_A[1]
PC_D[7]
PC_D[3]
PC_A[8]
PC_A[4]
PC_A[2]
PC_D[8]
PC_D[4]
PC_D[2]
PC_D[1]
PC_VS1#
PC_CD2#
IRQ[0]#
DRQ[1]#
BSTACK#
BSTREQ#
9K
SCL[0]
C1606 2I
MSDIR
A[13]
A[10]
BE[0]
D[26]
D[22]
D[18]
D[16]
D[13]
PP[5]
PP[1]
N.C.
BCKI
MPIO
A[6]
A[3]
A[2]
CSC#
VDDP
D[9]
D[6]
D[2]
D[0]
0.1
VDD
UDM
TDI
TDC
10V
5 D1600
B
SUB3.3V
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
DAN202UT106
OR
1:9B;3:16D POWER_DET
R1618 XX 1/16W CHIP
R1621 22 1/16W CHIP

R1620 22 1/16W CHIP
R1617
0 JL1631 FB1600
CHIP
C2_PIO
0uH
C1601 C1602
1:10C 0.1 10
PC_ADR6_943
PC_ADR1_943
MS_SEL 10V
PC_D14_943
PC_D10_943
MB93943[29]
MB93943[52]
MB93943[53]
MB93943[54]
MB93943[40]
MB93943[144]
MB93943[51]
MB93943[39]
MB93943[43]
MB93943[44]
MB93943[45]
MB93943[46]
MB93943[47]
MB93943[48]
MB93943[49]
MB93943[50]
PC_D7_943
PC_D3_943
PC_VCC5EN_943
6.3V
MB93943[31]
MB93943[32]
MB93943[33]
MB93943[34]
MB93943[35]
MB93943[41]
MB93943[37]
MB93943[38]
PC_VS1_943
PC_RDY_943
PC_CD2_943
PC_ADR8_943
PC_ADR4_943
PC_ADR2_943
PC_IORD_943
MB93943[42]
MB93943[36]
FLAG_MIC
JL1630
CLK54M
C2_PIO
PC_D15_943
PC_D11_943
B
CLK_SEL
PC_D8_943
PC_D4_943
PC_D2_943
PC_D1_943
VD_R7_943
VD_R3_943
VD_R0_943
1005
1:3G
1:5B
2012
1:5F
1:6C
7J
10K
10K
11K
13L
11K
11J
10K
10K
10K
10L
11L
13K
13K
13L
6L
6K
6I
4I
4I
2K
2K
2J
2I
9L
9L
7K
7K
4G
4F
4F
9K
9K
7J
7J
7K
7L
9K
4J
4I
4I
2L
2K
2J
2J
2I
2I
4F
4H
1:4D;15D
LRCK
1:4C;6E
SCLK
M(2/5)
JL1629
R1619 COMPANION
4.7k
1/16W
CHIP CHIP
6-32 6-32 VPL-CX70/CX75
A B C D E F G H
M (3/5) (VPL-CX75) M (3/5) (VPL-CX75)
PC_VCC
RB1627
22 RB1638 1
R1623 33
22
1/16W L-BUS-DATA[19] MB93943[77]
CHIP 3:7J;3:9L 15B
CPU-BSTREQ MB93943[41] VD_B[1] MB93943[54] L-BUS-DATA[18] MB93943[44]
3:15J R1624 11I 1:11D 13I 3:7J;3:9L 11I
22
1/16W VD_VSYNC MB93943[29] L-BUS-DATA[17] MB93943[19]
CHIP 1:11F 8I 3:7J;3:9L 7G
CPU-RDY MB93943[75] VD_B[4] MB93943[53] L-BUS-DATA[16] MB93943[45]
1:11D 13I 3:7K;3:9L 11I
3:12L 15C
RB1628 RB1639
22 33
L-ADR[4] MB93943[58] L-BUS-DATA[15] MB93943[66]
3:5K;3:9K 15H 3:10K 15G
RB1610
10k L-ADR[8] MB93943[7] L-BUS-DATA[14] MB93943[20]
3:10K;3:5J 7E 3:10K 7G
5V-1 L-ADR[3] MB93943[34] L-BUS-DATA[13] MB93943[46]
RB1608 3:5K;3:9K 10I 3:10K 11I
22 L-ADR[2] MB93943[35] L-BUS-DATA[12] MB93943[67]
3:5K;3:9K 10I 3:10K 15G
PC_OE_OUT PC_OE_943 R1602 RB1629 RB1640
1:2E 7D 22 R1603 22 22
PC_WE_OUT 1:2E 1/16W 10k
PC_WE_943 CHIP CPU-BE[2] MB93943[8] VD_G[4] MB93943[144]
1:2E 15D 1/16W 13I
CHIP 9I 16H;3:10L;3:7K 7F 1:11F
PC_CE1_OUT PC_CE1_943 PC_VS1_OUT CPU-DIR MB93943[9] VD_G[1] MB93943[25]
1:2F 7D PC_VS1_943
3:12L;3:7K 7F 1:11E 7H
PC_CE2_OUT PC_CE2_943 CHIP CPU-IRQ[1] MB93943[10] MB93943[1]
1:2F 1/16W VD_B[5]
3:8E 7F 7B
15I
RB1600
22k
R1604 CPU-BE[0] MB93943[36]
10I
1:11D
VD_G[6]
1:11E
MB93943[24] 2
3:10L 7H
22 RB1630 RB1641
1:2C 15I 33 22
PC_D0_OUT PC_D0_943
1:2C 9I L-BUS-DATA[31] MB93943[63] L-ADR[13] MB93943[31]
PC_D1_OUT 3:7I;3:8K 15G 3:5I;3:8K 10I
PC_D1_943
1:2C L-BUS-DATA[30] MB93943[13] L-ADR[9] MB93943[56]
9I 3:7I;3:8K 7F 15H
PC_D2_OUT PC_D2_943 3:5I;3:9K
1:2F 14I R1600 L-BUS-DATA[29] MB93943[14] L-ADR[7] MB93943[72]
PC_D3_OUT 22 3:7I;3:8L 7F 3:5J;3:9K 15C
PC_D3_943 1/16W
CHIP L-BUS-DATA[28] MB93943[15] L-ADR[15] MB93943[5]
3:7I;3:8L 7F 3:5H;3:8K 7E
PC_VCC5EN_OUT PC_VCC5EN_943 RB1631 RB1642
1:7E 9I 33 22
RB1604
PC_VCC3EN_OUT PC_VCC3EN_943 L-BUS-DATA[27] MB93943[16] CPU-RESETOUT
10k
1:7E R1601 15D MB93943[61]
22 3:7J;3:8L 7F 3:17H;3:5J 15G
1/16W L-BUS-DATA[26] MB93943[42] CPU-CS[2] MB93943[74]
RB1611 CHIP 3:7J;3:8L 11I 3:15J 15C
10k MB93943[40]
L-BUS-DATA[25] MB93943[64] CPU-BSTACK
3:7J;3:8L 15G 3:10J 11I
RB1609 L-BUS-DATA[24] MB93943[76] MB93943[62]
CPU-DREQ[2]
22 3:7J;3:8L 15C 3:16D 15G
RB1601 RB1632 RB1643
PC_IOWR_OUT 22 33 33
PC_IOWR_943 1:2F 9I 5V-1
1:2E 15I PC_D4_OUT PC_D4_943 L-BUS-DATA[23] MB93943[17] L-BUS-DATA[11] MB93943[21]
PC_IORD_OUT PC_IORD_943 3:7I;3:9J 7F 3:10K 7G
1:2E 1:2F 15D
9I PC_D5_OUT L-BUS-DATA[22] MB93943[43] L-BUS-DATA[10] MB93943[241]
PC_RESET_OUT PC_D5_943
PC_RESET_943 1:2F 3:7I;3:9K 11I 3:10K 14A
1:2D
PC_REG_OUT
7D
PC_REG_943
PC_D6_OUT
7D
PC_D6_943 L-BUS-DATA[21]
3:7I;3:9K
MB93943[18]
7F
L-BUS-DATA[9]
3:10K
MB93943[47]
11I
3
1:2D 1:2F 14I
15H PC_D7_OUT L-BUS-DATA[20] L-BUS-DATA[8] MB93943[68]
PC_D7_943 MB93943[65]
RB1612 3:7J;3:9K 15G 3:10K 15G
22 RB1633
22 R1622
VD_R0_OUT VD_R0_943 10k VD_B[0] MB93943[28] 10k
RB1623
RB1605
1:11D 13I 7I 1/16W

1:11E
10k
VD_R1_OUT VD_R1_943 CHIP

1:11D 7H VD_HSYNC MB93943[4]
RB1621 1:11F 7C RB1644
VD_R2_OUT VD_R2_943 22 MB93943[52] 33
1:11D 15E VD_B[7]
1:2G 7D 1:11D 13I L-BUS-DATA[7] MB93943[22]
VD_R3_OUT VD_R3_943 PC_CD1_OUT PC_CD1_943 VD_B[3] MB93943[27] 3:12K 7G
1:11D 13I
1:2C 9I 1:11E 7I L-BUS-DATA[6] MB93943[48]
RB1613 PC_CD2_OUT PC_CD2_943 RB1634 3:12K 11I
22 1:2C 22
15H L-BUS-DATA[5] MB93943[69]
RB1602 PC_BVD1_OUT PC_BVD1_943 MB93943[3] 3:12K 15G
22 VD_PEN
VD_R4_OUT VD_R4_943 1:2C 1:2C 1:11F 7C
1:11D 13A 9I 7D L-BUS-DATA[4] MB93943[23]
PC_D8_OUT PC_BVD2_OUT PC_BVD2_943 VD_G[2] MB93943[51] 3:12K
PC_D8_943 7G
VD_R5_OUT VD_R5_943 1:2C 1:11F 13I
1:11E 7H 7D
PC_D9_OUT PC_D9_943 VD_G[0] MB93943[26] RB1645
VD_R6_OUT VD_R6_943 1:2C 1:11E 7I 22
1:11E 15F 14I
PC_D10_OUT VD_B[2] MB93943[2]
RB1624
VD_R7_OUT VD_R7_943 PC_D10_943
7C
22k
1:2F 9I 1:11E
1:11E 13I PC_D11_OUT PC_D11_943
RB1635
RB1614 22
L-ADR[14] MB93943[71]
22 MB93943[32] 3:13K;3:5I
L-ADR[10]
PC_ADR0_OUT 3:10K;3:5I 10I 15C
4
RB1606
PC_ADR0_943 L-ADR[12] MB93943[55]

1:2D MB93943[57]
10k
7D L-ADR[5] 15H
3:5K;3:9K 15H 3:10K;3:5I
PC_ADR1_OUT PC_ADR1_943
1:2D 14I L-ADR[11] MB93943[6] RB1646
3:5I;3:9K 7E 33
1:2D 8I L-ADR[6] MB93943[33] L-BUS-DATA[3] MB93943[243]
PC_ADR3_OUT 3:5K;3:9L 10I 3:12K 14A
PC_ADR3_943
1:2D 7D 5V-1 RB1636 L-BUS-DATA[2] MB93943[49]
22 3:12K 12I
RB1615 L-BUS-DATA[1] MB93943[70]
22 CPU-DREQ[3] MB93943[11] 3:12K 15F
RB1603 3:8D 7F
PC_ADR4_OUT PC_ADR4_943 22 L-BUS-DATA[0] MB93943[50]
1:2D CPU-CS[1] MB93943[37] 3:12L
8I 1:2F 15D 10I 12I
PC_D12_OUT 3:16D
PC_ADR5_OUT PC_ADR5_943 PC_D12_943
1:2D CPU-BE[1] MB93943[59] RB1647
15E 1:2F 7D 15G
PC_D13_OUT 3:10L 22
PC_ADR6_OUT PC_ADR6_943 PC_D13_943
1:2D CPU-BE[3] MB93943[73]
14I 1:2F 14I 3:10L VD_CLK MB93943[208]
PC_D14_OUT 15C 15E
PC_ADR7_OUT PC_ADR7_943 PC_D14_943 RB1637 1:11F
1:2E 1:2F RB1625 22 MB93943[206]
7C 9I VD_B[6] 15E
PC_D15_OUT PC_D15_943 10k 1:11D
RB1616 CPU-DREQ[0] MB93943[12]
22 3:11J 7F VD_G[3] MB93943[204]
RB1622 1:11F 15E
PC_ADR8_OUT 22 CPU-IRQ[0] MB93943[38]
PC_ADR8_943 3:17D 11I VD_G[7] MB93943[203]
1:2E 8I 15E
1:11E
RB1607
PC_RDY_OUT PC_RDY_943 CPU-BS MB93943[60]

10k
PC_ADR9_OUT PC_ADR9_943 3:10J 15G

1:2E 1:2E 9I
7C CPU-DREQ[1] MB93943[39]
PC_ADR10_OUT PC_WAIT_OUT PC_WAIT_943
PC_ADR10_943 1:2D 3:8D
1:2F 15E 7D 11I
JL1614
PC_WP_OUT
1:2C
PC_WP_943
15H
5
1:2D 7C PC_INPACK_OUT PC_INPACK_943
1:2D 15D
RB1626
22k
M(3/5)
VPL-CX70/CX75 6-33 6-33

A B C D E F G H
SDRAM-DATA[26]
M (4/5) (VPL-CX75) M (4/5) (VPL-CX75)
SDRAM-DDQM[2]
MB93403[58]
MB93403[56]
MB93403[57]
SDRAM-DCKE
SUB3.3V
11K
5D
5J
5I
8L
8L
C1744 FB1703
C1745 10 0uH
C1724 C1725 C1726 C1727C1728 C1729 C1730 6.3V D1700
0.1 0.1 0.1 0.1 0.1 0.1 0.1 XX B XX
10V 10V 10V 10V 10V 10V 10V 2012
B B B B B B B
1.8V-3
FB1704
0uH
C1746
10
257
264
263
262
261
260
259
258
D1702
256
255
254
253
252
251
250
249
248
247
246
245
244
243
242
241
320
319
318
317
316
315
314
313
312
311
310
309
308
307
306
305
304
303
302
301
300
299
298
297
296
295
294
293
292
291
290
289
288
287
286
285
284
283
282
281
280
279
278
277
276
275
274
273
272
271
270
269
268
267
266
265
6.3V
B XX
1 2012
DDQM[2]
DDQ[26]
D[28]
D[29]
D[12]
VDDE
VDDI
VDDE
VDDI
VDDE
VDDI
DCKE
VDDE
GND
GND
GND
VSS
VSS
VSS
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161
1
VSS VSS
13K C1733
MB93403[1] 0.1
2
A[14] VDDE 10V
11K B
MB93403[2]
3
A[8] VDDE
9K C1734
MB93403[3]
4
A[4] VDDI 0.1 10V
9K B
MB93403[4]
5
A[5] VDDE
9K
MB93403[5]
6
A[11] VSS
8K
MB93403[6] SDRAM-DATA[5]
7
A[17] DDQ[5]
8K C1735 1C
MB93403[7] 0.1 10V
8
R1717 A[21] VDDI
B
10k
SDRAM-DATA[6]
9
1/16W A[24] DDQ[6]
CHIP C1718 0.110V B 1D
10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
VDDE VSS
C1736
0.1
A[28] CMODE[0] 10V B
R1713 10k 1/16W CHIP
A[31] VDDE
R1714 10k 1/16W CHIP R1732
A[27] TESTMODE 10k
1/16W
R1715 10k 1/16W CHIP CHIP
JL1700 RD# VSS
JL1701 CS#[7]/IRQ[7] VDDI
R1708
10k VSS IRQ#[0]/PP[0] CPU-IRQ[0]
1/16W 2:10K
CHIP
ERR# VDDE
R1709 JL1702 BGNT# VDDI

10k
1/16W CS#[6]/IRQ[6] VSS
CHIP
VSS DREQ#[2]/PP[18] CPU-DREQ[2]
2 M_STATUS
1:10C DACK#[0]/PP[13] VDDI
C1731
0.1 10V
B
2:11K
CPU-DREQ[3] DREQ#[3]/PP[19] DONE#[1]/PP[17] POWER_DET

2:10J 1:9B;2:8J
CLK66CPU CLKIN VSS
1:5G;2:16G R1716 22 1/16W CHIP
VSS CS#[1] CPU-CS[1]
C1737 2:10K
0.1
CPU-DREQ[1] DREQ#[1]/PP[15] VDDE 10V
2:10K B
TXD 1005
1:10C C1719 RXD[1]/PP[10] CS#[0] CS-FLASH
0.1 10V B 7K
VDDE VSS C1738
SIRCS_CPU IRQ#[3]/PP[3] VDDE 0.1
1:10B 10V
B
CPU-IRQ[1] IRQ#[1]/PP[1] A[26] 1005
2:7K R1733
VSS VDDI 10k 1/16W
CHIP
JL1703 C1739
TDO VDDE 0.1
10V B
ECLK ECLK VSS 1005
6C JL1704
TCK A[9] MB93403[208]
C1740 9K
ERST ERST# VDDI 0.1
6B 10V
B
CMODE[1] VSS
R1710 0 CHIP
SDRAM-DCLK DCLK VSS
5D;5J R1719 10k 1/16W
TDC D[27] MB93403[204]
CHIP 8L
ECV ECV BE[2] MB93403[55]
6C 11L
IC1703 MB93403[54]
VSS MB93403-26PB-GE1 D[31] 8K
MS_CPU C1743
SDRAM-DATA[11] DDQ[11] VDDE 0.1
5C 10V
B MB93403[53]
VSS D[16] 10L
C1720
0.1 10V MB93403[52]
3 SDRAM-DATA[2]
1C
B VDDE
DDQ[2]
D[21]
D[15]
9K
MB93403[51]
11K
SDRAM-DATA[8] DDQ[8] D[6] MB93403[50]
5D 12K
SDRAM-DATA[14] DDQ[14] D[4] MB93403[49]
5C R1711 12K
10k MB93403[48]
1/16W VSS D[2]
CHIP 12K
R1712 DCS#[1] DDQ[31] SDRAM-DATA[31]
10k 5H
1/16W DCS#[3] DDQ[25] SDRAM-DATA[25]
CHIP 5I
SDRAM-ADR[0] DA[0] DDQ[20] SDRAM-DATA[20]
1K 1I
1K C1741 5I
SDRAM-RAS DRAS# VDDE 0.1
1J 10V
B
SDRAM-ADR[4] DA[4] VDDE 1005
5K
5K R1718 10k 1/16W CHIP 1H
DA[12] DDQM[3] SDRAM-DDQM[3]
2D
SDRAM-DATA[19] DDQ[19] DBA[0] SDRAM-BA[0]
1I 1J
VSS DA[2] SDRAM-ADR[2]
1K
SDRAM-ADR[10] DA[10] DA[7] SDRAM-ADR[7]
1K 5K
VSS VSS
VSS DDQM[0] SDRAM-DDQM[0]
5J
VSS DCAS# SDRAM-CAS
1I 1J
SDRAM-DATA[22] DDQ[22] DDQ[15] SDRAM-DATA[15]
1I 5C
5H 5C
12K 1C
4 MB93403[8]
12K
MB93403[9]
D[1] DDQ[0]
C1742
0.1
SDRAM-DATA[0]
1C
D[5] VDDE 10V
11K B
MB93403[10] D[9] DDQ[13] SDRAM-DATA[13]
11K 5C
MB93403[11] D[11] CMODE[2]
11K
MB93403[12] D[13] VSS
10L
MB93403[13] D[17] VDDP2
VSS PRST# CPU-PRST
1:7E;12J
MB93403[14] D[18] RSTOUT# CPU-RESETOUT
10L JL1713 2:11K;5J
MB93403[15] D[23] TDI
9J JL1714
VSS CPUHOLD
JL1715
MB93403[16] BE[3] RXD[0]/PP[6]
11L JL1716
MB93403[17] D[30] TXD[0]/PP[7]
8K JL1717
MB93403[18] D[24] RTS#[0]/PP[9]
TOUT[1]/GATE[1]/PP[5]
TOUT[0]/GATE[0]/PP[4]
8L
MB93403[19] D[22] DONE#[0]/PP[14] B_STATUS 1:10C
9K JL1718
DACK#[3]/PP[21]
DREQ#[0]/PP[12]
MB93403[20] A[12] DACK#[2]/PP[20] AU_MUTE
CS#[5]/IRQ#[5]
CS#[4]/IRQ#[4]
11K R1734 1:8B
TXD[1]/PP[11]
CTS#[0]/PP[8]
IRQ#[2]/PP[2]
R1736
MB93403[21] 10k 100
9L A[6] IBW 1/16W 1/16W
JL1719 CHIP CHIP
CMODE[3]
RAMBOOT#
MB93403[22] A[3] DACK#[1]/PP[16]
BSTREQ#
BSTACK#
DDQ[12]
DDQM[1]
DCS#[0]
DCS#[2]
DDQ[17]
DDQ[16]
DDQ[30]
DDQ[24]
DDQ[21]
DDQ[27]
9K
CS#[2]
CS#[3]
DCLKFB
DDQ[9]
DDQ[3]
DDQ[1]
DDQ[7]
DA[11]
DBA[1]
R1735
BE[1]
BE[0]
D[25]
A[16]
A[10]
A[13]
A[18]
A[20]
A[30]
BREQ#
A[15]
A[19]
A[22]
A[23]
A[25]
A[29]
VDDP1
TRST#
HRST#
DA[5]
DA[1]
DA[6]
DA[8]
D[10]
D[19]
D[14]
D[20]
D[26]
10k
A[2]
A[7]
RDY#
VDDE
VDDI
VDDE
DWE#
D[0]
D[3]
D[7]
D[8]
VSS
VSS
WE#
DIR
BS#
VSS
TMS
VSS
1/16W
ED
CHIP
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
C1721 C1722 R1731

0.1 0.1 10k
1/16W
5 10V
B
1005
10V
B
1005 JL1712
CHIP
1/16W CHIP
R1727 10k
R1724 10k
1/16W CHIP
R1720 R1721 R1722 C1723 R1723 R1729
10k 10k 10k 0.1 47 10k
1/16W 1/16W 1/16W 1/16W R1728 1/16W R1730
CHIP CHIP CHIP 10V CHIP 10k 1.8V-3
JL1705 JL1706 B
JL1707 1005 CHIP 10k
JL1709 JL1710 1/16W 1/16W
CHIP CHIP
JL1708 JL1711 FB1702
0uH
VDDE
R1725 C1732
10k 10 D1701
1/16W 6.3V XX
MB93403[46]
SDRAM-DATA[12]
MB93403[28]
MB93403[29]
MB93403[30]
MB93403[31]
MB93403[32]
MB93403[33]
MB93403[34]
MB93403[35]
MB93403[36]
MB93403[37]
MB93403[38]
MB93403[39]
MB93403[40]
MB93403[41]
MB93403[42]
MB93403[43]
MB93403[44]
MB93403[45]
CPU-CS[2]
SDRAM-DATA[9]
SDRAM-DATA[3]
SDRAM-DATA[1]
SDRAM-DATA[7]
SDRAM-DDQM[1]
MB93403[47]
CPU-BSTREQ
B
MB93403[23]
MB93403[24]
MB93403[25]
MB93403[26]
SDRAM-DATA[17]
SDRAM-DATA[16]
SDRAM-DATA[30]
SDRAM-DATA[24]
SDRAM-DATA[21]
SDRAM-DATA[27]
2:12L
MB93403[27]
CPU-DREQ[0]
2:11K
CHIP
ED
SDRAM-ADR[11]
1:10C
RXD
SDRAM-ADR[5]
SDRAM-ADR[1]
SDRAM-ADR[6]
SDRAM-ADR[8]
1:7F
CPU-BSTACK
TIMER
2:10K
SDRAM-BA[1]
CPU-BS
2012
CPU-PRST
SDRAM-WE
SDRAM-CS
1:7E;17H
2:10K
12L
12L
12K
12K
11K
11K
10L
11K
11L
11L
11L
11K
12L
2:11K
8K
12L
9K
8L
8L
9K
9K
8K
8K
8K
8J
8K
6C
5C
1C
5D
1C
1D
1J
1J
1J
1I
5I
5K
5I
5K
5J
1K
5K
5H
1K
1H
1H
M(4/5)
(MS CPU)
6-34 6-34 VPL-CX70/CX75
A B C D E F G H
M (5/5) (VPL-CX75) M (5/5) (VPL-CX75)
SUB3.3V
C1700
0.01
16V
B
C1703
10 FB1700
6.3V 0uH
B
2012 SUB3.3V
1:10E WDT_ENB
IC1700 R1707
C1706 HY57V281620HCT-H-TR 10k
0.01 SD_RAM 1/16W
16V CHIP
B
R1704 R1706
1
54
100
1
VCC VSS 100
1/16W 1/16W
CHIP CHIP
R1705 1 NC
53
SDRAM-DATA[15]
2
SDRAM-DATA[0] DQ0 DQ15 R1703 4.7k Q1700
17G 17G 10k 1/16W HN1B01FU-TE85R
C1708 SDRAM-DATA[14] 1/16W CHIP 2 VCC
SDRAM-DATA[1] 0.01 8F CHIP SW
52
12J
3
16V VCCQ VSSQ 3 WDTKILL
SDRAM-DATA[2] B SDRAM-DATA[13]
8F 17H ERST 4 ERST
51
SDRAM-DATA[12]
4
SDRAM-DATA[3] DQ1 DQ14 8E ERST
12J 12J
RB1705 RB1707 5 GND
47 47
50
ECV
5
DQ2 DQ13 ECV 6 ECV
8E
C1701 7 GND
0.01
49
6
VSSQ VCCQ 16V
B ED
ED 8 ED
11J
48
7
DQ3 DQ12 9 GND
ECLK ECLK
SDRAM-DATA[4] 10 ECLK
47
SDRAM-DATA[11]
8
17G DQ4 DQ11 8E
8E
SDRAM-DATA[5] CN1700
C1710 SDRAM-DATA[10] 10P
17C 0.01 17G
46
9
16V VCCQ VSS
SDRAM-DATA[6] SDRAM-DATA[9]
17C B 12J
SDRAM-DATA[7]
10
45
DQ5 DQ10 SDRAM-DATA[8]
12J 8F
RB1706 RB1708
47 47
11
44
DQ6 DQ9
C1704
0.01
12
43
VSSQ VCCQ RB1714 RB1718 RB1722
16V 22 2:8J;7I 47 47
B 9J 8H 2:10L 16F
VDDE MB93403[25] L-BUS-DATA[23] MB93403[15] L-BUS-DATA[15] MB93403[51]
13
42
DQ7 DQ8 5I 15J 2:8K;7I 8H 2:10L 14J
L-ADR[20] MB93403[46] L-BUS-DATA[22] MB93403[19] L-BUS-DATA[14] MB93403[34]
R1700 C1712 5I 8C 2:8K;7I 16F 2:10L 8H
2
14
41
68 0.01 VCC VSS L-ADR[21] MB93403[7] L-BUS-DATA[21] MB93403[52] L-BUS-DATA[13] MB93403[12]
1/16W 16V 9J 2:8K;7J 14J 15A
CHIP B 5J 2:10L
L-ADR[19] MB93403[24] L-BUS-DATA[20] MB93403[35] L-BUS-DATA[12] MB93403[56]
R1701
15
40
SDRAM-DDQM[3] LDQM N.C.
17G 68 RB1719
1/16W RB1715 22 RB1723
CHIP 2:11K;5I 16E 2:11L 47
SDRAM-DDQM[2] 22 8H
16
39
/WE UDQM 5J 15J L-ADR[9] MB93403[208] L-BUS-DATA[11] MB93403[11]
15A L-ADR[18] MB93403[45] 2:8L;5I 8C 2:11L 14J
7H 8C L-ADR[11] MB93403[5] L-BUS-DATA[10] MB93403[32]
17
38
/CAS CLK SDRAM-DCLK L-ADR[17] MB93403[6] 2:11K;5J 14J 2:11L 8H
5J;8E 2:11K;5H 9J L-ADR[7] MB93403[43] L-BUS-DATA[9] MB93403[10]
L-ADR[15] MB93403[23] 2:8L;5K 8C 2:11L 14J
18
37
/RAS CKE 2:11K;5I 15J L-ADR[5] MB93403[4] L-BUS-DATA[8] MB93403[31]
L-ADR[13] MB93403[44]
RB1724
19
36
/CS N.C. 2:8L;5I 22 14J
RB1720 L-ADR[10] MB93403[41]
RB1716 2:7K;5K 22
47 2:7K;5J 8B
20
35
BA0 A11 2:7K;7I 16E L-ADR[3] MB93403[22] L-ADR[8] MB93403[2]
L-BUS-DATA[31] MB93403[54] 2:7K;5K 8I
2:12K;5I 8H
2:7K;7I 8H L-ADR[2] MB93403[42] L-ADR[12] MB93403[20]
21
34
BA1 A9 L-BUS-DATA[30] MB93403[17] 2:7K;5K 14J 5H 14J
2:7L;7I 14A L-ADR[4] MB93403[3] L-ADR[16] MB93403[40]
L-BUS-DATA[29] MB93403[57] 2:8L;5K 8C
22
33
A10 A8 2:7L;7I 14A L-ADR[6] MB93403[21]
L-BUS-DATA[28] MB93403[58] 8I RB1725
2:10K 22 8H
23
32
A0 A7 CPU-BE[3] MB93403[16]
RB1717 RB1721
47 47 2:7K 14J
2:7L;7J 16E 2:10K;7J 14J CPU-BE[0] MB93403[38]
24
31
A1 A6 L-BUS-DATA[27] MB93403[204] L-BUS-DATA[19] MB93403[33] 2:10K 14J
2:7L;7J 14J 2:10K;7J 8H CPU-BE[1] MB93403[37]
L-BUS-DATA[26] MB93403[36] L-BUS-DATA[18] MB93403[14] 16E
25
30
A2 A5 2:7L;7J 14J 2:10K;7J 8H CPU-BE[2] MB93403[55]
L-BUS-DATA[25] MB93403[39] L-BUS-DATA[17] MB93403[13] 2:16H;2:7K;
2:7L;7J 8H 2:10K;7K 16F 7K
26
29
A3 A4 L-BUS-DATA[24] MB93403[18] L-BUS-DATA[16] MB93403[53]
RB1726
47
3
27
28
VCC VSS 2:12J 13J
L-BUS-DATA[7] MB93403[30]
C1714 2:12K 16F
0.01
16V L-BUS-DATA[6] MB93403[50]
B 2:12K 8G
SUB3.3V L-BUS-DATA[5] MB93403[9]
2:12K 16F
FB1701 RB1727
IC1701 0uH
HY57V281620HCT-H-TR 47
SD_RAM C1716 2:12K 13J
0.1 L-BUS-DATA[3] MB93403[29]
IC1702 10V 16F
C1711 MX29LV320ABTC-90G-769MS100 B 2:12K
54
0.01 FROM
1
VCC VSS
16V L-BUS-DATA[1] 8G
B 17F 10L MB93403[8]
SDRAM-DATA[31] L-ADR[17] 13J
53
48
SDRAM-DATA[16] L-ADR[16] 2:12L
2
1
13J DQ0 DQ15 A15 A16 MB93403[28]
13J 8K L-BUS-DATA[0]
SDRAM-DATA[17] SDRAM-DATA[30] 2:11K;8K 2:12L
13J C1709 8G
52
47
0.01 L-ADR[15]
3
2
VCCQ VSSQ A14 /BYTE RB1728
SDRAM-DATA[18] 16V SDRAM-DATA[29]
17F B 17F 2:7K;7K 22 10J
2:12K;13K CPU-DIR MB93403[27]
SDRAM-DATA[28]
51
46
SDRAM-DATA[19] L-ADR[14]
4
3
DQ1 DQ14 A13 VSS 15J
8G 2:12L
RB1700 RB1709 CPU-RDY MB93403[47]
47 47 2:11K;8K
L-BUS-DATA[31]
50
45
L-ADR[13]
5
4
DQ2 DQ13 A12 DQ15 2:7K;8K
5J 10J
C1713 2:12K;10K L-WE
0.01 L-BUS-DATA[23] MB93403[26]
49
44
L-ADR[12]
6
5
VSSQ VCCQ 16V A11 DQ7 2:8J;9J
B
2:8L;9K 2:12K;5I
L-BUS-DATA[30] L-ADR[14] MB93403[1]
48
43
L-ADR[11]
7
6
DQ3 DQ12 A10 DQ14 2:7K;8K 8B
R1726
13J 22
SDRAM-DATA[27] 2:8L;10K 1/16W
L-BUS-DATA[22]
47
42
SDRAM-DATA[20] L-ADR[10] CHIP
8
7
DQ4 DQ11 A9 DQ6 2:8K;9K
17F 15A
SDRAM-DATA[26]
SDRAM-DATA[21]
13J C1707 17F
2:11K;9K
L-BUS-DATA[29] 4
46
41
0.01 L-ADR[9]
9
8
VCCQ VSS SDRAM-DATA[25] A8 DQ13 2:7L;8L
SDRAM-DATA[22] 16V
8G B 13J
SDRAM-DATA[24] 8K
L-BUS-DATA[21]
10
45
40
SDRAM-DATA[23] L-ADR[20]
9
DQ5 DQ10 A19 DQ5 2:8K;9K
8G
RB1701 RB1710 8K
47 47 L-BUS-DATA[28]
11
44
10
39
DQ6 DQ9 L-ADR[21] A20 DQ12 2:7L;8L
C1715 12L
0.01 L-BUS-DATA[20]
12
43
11
38
VSSQ VCCQ 16V L-WE /WE DQ4 2:8K;9K
B C1717
2:11K;17H 0.1
10V
13
42
12
37
DQ7 DQ8 CPU-RESETOUT /RESET VCC B
C1705 1005
0.01 SUB3.3V L-BUS-DATA[27]
14
41
13
36
16V VCC VSS 5D;8E N.C. DQ11
47 B SDRAM-DCLK 2:7L;8L
RB1702
L-BUS-DATA[19]
15
40
14
35
SDRAM-DDQM[1] LDQM N.C. /WP/ACC DQ3
12J 47 R1702 2:10K;9L
SDRAM-WE RB1711 17G 10k
12J SDRAM-DDQM[0] 1/16W L-BUS-DATA[26]
16
39
15
34
/WE UDQM CHIP RY/BY DQ10 2:7L;8L
SDRAM-CAS
17G 8K
15A L-BUS-DATA[18]
17
38
16
33
SDRAM-RAS /CAS CLK L-ADR[19] A18 DQ2
8F SDRAM-DCKE 2:10K;9L
13J 8K
SDRAM-ADR[11] L-BUS-DATA[25]
18
37
17
32
/RAS CKE L-ADR[18] A17 DQ9
47 2:7L;8L
RB1703
2:7K;10K
SDRAM-CS L-BUS-DATA[17]
19
36
18
31
/CS N.C. L-ADR[8] A7 DQ1
12J 2:10K;9L
SDRAM-BA[0] 2:11K;9K
17G L-BUS-DATA[24]
20
35
19
30
BA0 A11 L-ADR[7] A6 DQ8
SDRAM-BA[1] 47 2:7L;8L
13J RB1712 8F 2:8L;9L
SDRAM-ADR[10] L-BUS-DATA[16]
21
34
20
29
BA1 A9 SDRAM-ADR[9] L-ADR[6] A5 DQ0
8G 13J 2:10K;9L
SDRAM-ADR[8] 2:8L;9K
5
22
33
21
28
A10 A8 17G L-ADR[5] A4 /OE CPU-DIR
47 SDRAM-ADR[7] 2:7K;12L
RB1704 12J 2:7K;9K
M
23
32
22
27
SDRAM-ADR[0] A0 A7 SDRAM-ADR[6] L-ADR[4] A3 VSS
8F
SDRAM-ADR[1] 2:7K;9K
(5/5)
12J
(SD RAM)
24
31
23
26
A1 A6 L-ADR[3] A2 /CE CS-FLASH

SDRAM-ADR[2] 47 16D
17G RB1713 12J 2:7K;9K
25
30
24
25
SDRAM-ADR[3] A2 A5 SDRAM-ADR[5] L-ADR[2] A1 A0 CPU-BE[2]

8F 8F 2:16H;2:7K;
SDRAM-ADR[4] 10L
26
29
A3 A4
27
28
VCC VSS
C1702
0.01
16V
B
VPL-CX70/CX75 6-35 6-35

A B C D E F G H
M (VPL-CX75) M (VPL-CX75)
C1703FB1700
C1700
C1702 C1701
RB1710 RB1709
RB1701 RB1700
RB1708 RB1707
RB1706 RB1705
C1528 C1705 C1704
IC1506
R1538 Q1501 CN1700
R1542 C1715 C1714
C1529 R1707
R1540 D1504R1535
R1541
C1707 C1706
FB1501
R1706
Q1502
C1540
R1548
R1545
R1526C1524 C1713 C1712 Q1700
FB1508
JL1520 FB1506
FB1502 FB1505
C1709 C1708
JL1517
R1705
R1704
R1703
JL1511
JL1516 JL1643 JL1719
JL1715
JL1713
JL1716
JL1711
JL1704
C1607 FB1601 JL1709
JL1703
JL1714
R1511
C1516 TP1503
R1510
TP1500
R1574
Q1503
R1550
R1549
R1605
IC1502
RB1612
RB1640
RB1634 RB1613 RB1711RB1712RB1713RB1704RB1703RB1702
JL1650
RB1646
RB1644
RB1633 JL1718
R1570
R1571 C1502R1524R1525 JL1708
R1723
R1710
RB1627
RB1643
R1572 R
R1522 1523 JL1717
RB1727
R1573 R1506 TP1507TP1505TP1506TP1508
RB1639
C1500
RB1726
RB1638
R1736
RB1723
C1745
RB1632
IC1600
RB1722
RB1601 RB1603RB1615JL1614
IC1703
RB1600 RB1602 RB1614 RB1616
RB1721
C1506 JL1500R1502 R1735
Q1500
R1508 R1501 TP1501
TP1504 D1700
RB1631
R1500 FB1703
JL1505
RB1718
R1509
C1504
C1510 D1702
RB1630
RB1717
C1503 C1501
JL1631
R1516 C1746
IC1501
RB1716
R1521 FB1704
C1514
R1517
RB1725
R1520 TP1502
IC1503
R1519
RB1608
RB1610
R1518
R1726
R1727
JL1615
JL1629
RB1609
RB1611
FB1500 RB1719
RB1720
RB1724 RB1714RB1728
RB1715
R1569 R1568
IC1509
IC1510
RB1641
RB1645 RB1628
RB1635
RB1621
RB1623
C1536
R1566 R1567 JL1702
JL1706
JL1705 JL1513
C1537
C1526 R1534 JL1630 JL1700 JL1707
JL1701
RB1622
RB1625
L1501
C1527
IC1505
R1533 JL1712
C1530 R1530
R1529
C1531 R1528
R1527
M -A SIDE-
SUFFIX: -11
6-36 6-36 VPL-CX70/CX75

8151C
C1519
C1520
VPL-CX70/CX75
5251C
IC1504
JL1710
2251C
3251C
JL1512
C1710
R1700
2071BF
C1719
1071D 9171R
4271R
3271C
C1721
C1732
9071R 4371R 6371C 2471C 0071CI
8071R 9371C C1720
R1622
1371R 2271C 1371C
R1732
3261R 0371R 5371C
C1737
RB1629
5171R 22719R271R
8271R
4171R 4371C
3171R 33718R371C
RB1636
1171R
R1701
2171R
C1711
8171C 01227711RR 5271R
RB1637
7171R 3471C 3371C
4471C
RB1642
4261R 0471C
C1730
8171R 1071CI
C1725
C1727
C1728
C1729
C1724
1471C
C1726
617313R61R
JL1507
JL1508
JL1509
0051L
JL1510
1071BF
R1512
R1513
R1514
C1512
R1515
C1509 X1500
0051CI
C1513
C1716 C1717
7051R
IC1702
JL1506
R1532
R1503
R1504
R1505
C1508
R1531
2071R
JL1503
JL1501
716213C61R
FB1600
C1601
C1602
C1507 JL1504
D1505R1536
C1521
1361R
JL1502
JL1618
C1600
1061CI 0161C 5751R

Q1600
C1603
C1604
RB1501
6161C
RB1500
6161R
51610R261R 926510R61C
1261R 1161C
JL1617
JL1651
JL1616
8261R 62619R06810R61R 9161R 15513R55310R51BF

0361R 3161R 25514R55410R51BF
2161R 8161R6061R 6061C
1161R 0161R 4161C
7261R 7051BF
2061R
C1608
4061R 51613C161C 9051BF

C1612
3061R 9061C
6-37
1061R
CN1501
0061R
5261R
M (VPL-CX75)
RB1647
4061BR 6061BR 0061D

R1617
5061BR 7061BR
JL1515
62614B2R61BR
4051Q
6-37
R1565
7051CI 8051CI
R1557
C1534
R1559
C1535
8551R 0651R
C1511
C1505
1 6 5
M (VPL-CX75)
5151C
C1517
81515L5J5381163RR551126RC655541916R3R5511RC
2351C91513L3J51C
7351R
R1539
0051NC
JL1514
SUFFIX: -11
M -B SIDE-
GA GA
CN102
3P
BLK
1 JL103
1 DC+
D102 JL104
RM11A 3 DC-
RECTIFIER
LAMP POWER
SUPPLY
L104
F101 200uH
5A D101
10
L103
9
6
250V D10XB80 550uH
BRIDGE RECTIFIER
D104
C102 L101 L102 SF10L60U
5
4
3
2
1
1000p 6.5mH 6.5mH D103
JL101
250V
E EC31QS03L-TE12L RECTIFIER
4
RECTIFIER
2
FB101
VDR101 0uH Q103
R101 C101 C104 R111 2SK2876-01MR-F122
1M 0.22 0.47 150k
1/2W 275V 250V R108 1/10W 2SK2876-01
TH101 10 RN-CP BALLAST ON/OFF SWITCH
2
PP PT
4
JL102 1/4W
C106 FPRD
C103 2.2
1000p
2 CN101 250V
E
450V
PT R112
R119
47k
1/10W
2P

cx70 Manual

Hochgeladen von

Dokumentinformationen

Originaltitel

Copyright

Verfügbare Formate

Dieses Dokument teilen

Dokument teilen oder einbetten

Freigabeoptionen

Stufen Sie dieses Dokument als nützlich ein?

Sind diese Inhalte unangemessen?

Copyright:

Verfügbare Formate

cx70 Manual

Hochgeladen von

Copyright:

Verfügbare Formate

DATA PROJECTOR

Hoe u de batterijen moet verwijderen, leest u in de tekst

Gooi de batterij niet weg maar lever deze in als klein

Für Kunden in Deutschland

Entsorgungshinweis: Bitte werfen Sie nur entladene

1-1. Appearance Figure ...................................................................................... 1-1

2-1. Preparation .................................................................................................. 2-1

4-1. Notes on Repair Parts .................................................................................. 4-1

Overall .................................................................................................................... 5-1

6-1. Frame Schematic Diagrams ........................................................................ 6-2

1-1. Appearance Figure

1-2. Board Locations

1-3-2. QB Board (VPL-CX75) and NF Board

1-3-8. Main Capacitor Lens Assembly

1-3-7. Optics Block Assembly

1-3-9. M Board (VPL-CX75)

1-3-10. U Board and DC Fan

1-3-3. Adjustor Unit 1-3-4. Side Panel Assembly

1-3-5. Lamp Power Supply

1-3-12. V Board and GA Board

1-3-2. QB Board (VPL-CX75) and NF Board

1-3-4. Side Panel Assembly

6 Two claws CN41

3 Lamp power supply

5 Lamp power supply,

CN109 CN103 CN108

4 Fuse connector assembly

7 Six screws (+PSW M3 x 8)

8 Optics block assembly

1 Two screws (+PSW M3 x 8) 5 Lamp power supply

2 Shutter unit, NF board

Position of the S out-pre-polarization assembly,

S out-pre-polarization (G) assembly, !] Polarization retainer

Polarization S panel (G) assembly !. S out-pre-polarization (G)

!= S Prism block assembly

0 Unit cover (B)

3 Two springs Marking side

1-3-10. U Board and D.C. Fan 7 Four screws

9 Two D.C. Fans

6 Two D.C. Fans, Fan holder

1-3-12. V Board and GA Board

2 Holder (GA), GA board

6 Two washers (LW4)

2 D.C. Fan (Sirocco), Duct (In)

3 Filter cover, filter

X kit assembly (Part No. A-1073-342-A)

1-3-16. Extension Boards and Extension Connectors Connection

Three XF32 boards M board

X70 board X70 board

From C board CN1300 To M board CN1501

From lamp power supply (5P)

From L board CN61 (2P), NR board CN41 (3P)

From GB board CN204 (11P)

To C board CN106 (11P)

To C board CN102 (6P)

To C board CN1402 (3P)

To C board CN302 (7P)

XC2 board HA board

To C board CN1401 (3P) To C board CN104 (7P)

From HA board CN1900 (7P) From XC1 board CN5103 (6P)

From XC1 board CN5400 (2P)

From prism CN1403 From XC1 board CN6403 (3P)

From XC2 board CN6401 (3P)